Everpure EV9606-01 User manual

Brand: Everpure

Model: EV9606-01

Category: Sanitary ware

Type: User manual

SELECTING A MOUNTING LOCATION

1. Give consideration to the weight of the unit when operating (ﬁlled with water). Operating weights

of the Insurice Systems are:

 • SingleSystem-9lbs.(4.0kg.)

 • TwinSystem-19lbs.(8.5kg)

 • TripleSystem-27lbs.(12kg)

 • QuadSystem-36lbs.(20kg)

2. Thelocationshouldallowfor:

 • Minimumclearanceof2-1/2”underthecartridge(s)soitcanbeloweredforremovalandre-

placement.

 • Adequatespacefor“in”and“out”waterlineconnections.

 • Benearadrainforushingandneara110Voutletiftheaccessory(soldseparately)Everguard

LowPressureAlarmisused.SeeFigures1-4.

3. Ifpossible,keepatleast6”availabletotheleftandtherightoftheInsuriceSystemintheevent

poorqualitywaterconditionsrequiretheinstallationoftheoptionalEverpureK-SeriesPrelter.

OPERATING SPECIFICATIONS*

Combined Model Name

Replacement

Cartridge

Flow Rate Capacity

InsuriceSingle-i2000 i2000 1.67gpm(6.3lpm) 9,000gal(34,000L)

InsuriceSingle-i2000

i2000

1.67gpm(6.3lpm) 9,000gal(34,000L)

InsuriceSingle-i4000 i4000 1.67gpm(6.3lpm) 12,000gal(45,420L)

InsuriceSingle-i4000

i4000

1.67gpm(6.3lpm) 12,000gal(45,420L)

InsuriceTwin-i2000 i2000 3.3gpm(12.6lpm) 18,000gal(68,000L)

InsuriceTwin-i2000

i2000

3.3gpm(12.6lpm) 18,000gal(68,000L)

InsuriceTwin-i4000 i4000 3.3gpm(12.6lpm) 24,000gal(90,840L)

InsuriceTwin-i4000

i4000

3.3gpm(12.6lpm) 24,000gal(90,840L)

InsuriceTriple-i2000 i2000 5.0gpm(18.9lpm) 27,000gal(102,000L)

InsuriceTriple-i2000

i2000

5.0gpm(18.9lpm) 27,000gal(102,000L)

InsuriceTriple-i4000 i4000 5.0gpm(18.9lpm) 36,000gal(136,260L)

InsuriceTriple-i4000

i4000

5.0gpm(18.9lpm) 36,000gal(136,260L)

InsuriceQuad-i2000 i2000 6.6gpm(25lpm) 36,000gal(136,260L)

InsuriceQuad-i2000

i2000

6.6gpm(25lpm) 36,000gal(136,260L)

InsuriceQuad-i4000 i4000 6.6gpm(25lpm) 48,000gal(181,680L)

InsuriceQuad-i4000

i4000

6.6gpm(25lpm) 48,000gal(181,680L)

*Forindividualcartridgespecications,refertocartridgeliterature.

Temperature: 35-100°F(2-38°C)

Pressure: 10-125psi(0.7-8.6bar),non-shock

Forcoldwateruseonly.

Figure1–InsuriceSingleSystem

 EV3112-81RevEAP08

Installation and Operation Guide

Insurice Filter Systems

ManufacturedbyEverpure

Figure2–InsuriceTwinSystem

Figure4–InsuriceQuadSystem

Figure3–InsuriceTripleSystem

INSTALLATION

1. Usethepredrilledmountingholesinthemanifoldbracketasguides.Markanddrillanchorholes.

Mountsecurely.SeeFigures1-4.

2. Shutoffpowertomachine.

3. ConnectoutletportofInsuricesystemtoequipmentserved.AlwaysuseaNSFapprovedpipedope

orTeontapeatallconnections.Useabackupwrenchonallttingswhileconnectingtoavoid

excessive stress on the system components.

Note: If the optional E-Series Filter is used, install a manual shut-off valve leading to the system

for servicing.

4. Connectminimum3/8”waterlinetoinletsideofInsuricesystem.

5 Connecttubingtoushingvalveandruntodrain.

Note: Some municipal plumbing codes and good sanitary practices require an air gap at the drain

termination point.

6. Installthecartridge(s)intotheInsuricesystemhead(s)followingdirectionsonthecartridgelabelor

asshownintheCartridgeChangeillustrations.

7. Turnonwatertolterandcheckforleaks.

8. Flushthecartridgebyrunningwaterthroughatfullforceforveminutes.Thiswillsettheltering

mediaandpurgeairandnes,insuringmaximumlterlife.

9. Afterushing,closetheushingvalve,turnonpowertoequipmentandplugtheLPA(ifso

equipped)intotheelectricaloutlet.Seeillustrations.

CARTRIDGE CHANGE DETERMINATION

Replacecartridgeswhencapacityisreached,orwhenowbecomesinadequate,butatleastannually.

Allcartridgesonmultiplecartridgesystemsshouldbechangedatthesametime.TheEverpure

PressureGaugeorEverguardLowPressureAlarmprovidesaquickandsimplemeansofdetermining

whentheltercartridge(s)shouldbechanged.Installedontheoutletportofthelter,thegauge

orEverguardLPAcanbeusedtomeasurebothdynamic(owing)andstatic(line)pressure.The

cartridge(s)shouldbechangedwhenthepressuregaugeneedleisintheredareawhileequipment

isinoperation,andyettheneedleshowsadequatelinepressurebetweencycles.Observetheneedle

duringthenextequipmentoncycle.Iftheneedleregistersadequatepressure,itcanbeassumedthat

thetemporarylow-pressureconditionwascausedbyabriefpowerfailureorotherincomingpressure

disruption.

FLUSHING

For maximum life, all carbon ﬁlter cartridges must be ﬂushed for ﬁve minutes at full ﬂow before use. ALL

NEW CARTRIDGES MUST BE FLUSHED AFTER EACH CARTRIDGE CHANGE BEFORE BEING PUT INTO SERVICE!

Ifthecartridgesarenew,havebeenproperlyushedandbothneedleandfollowerregisterinadequatepressure,or

theLPAissounding,youmaybeexperiencinginadequatewaterpressureorsomerestrictionmayexistintheinlet

waterline.Ineithercase,theincomingwaterpressuremustbeimprovedtoreceiveoptimumlterlife.

COMPLETECARTRIDGECHANGEINSTRUCTIONSCANBEFOUNDONTHEFILTERCARTRIDGELABEL.

Not for residential use. For food service applications only.

Figure5–InsuriceSingleSystem

OUTLET

3/8" FNPT

INLET

3/8" FNPT

27.50"

5.60"

Figure6–InsuriceTwinSystem

16.60"

OUTLET

3/4" FNPT

INLET

3/4" MNPT

25.26"

Figure8–InsuriceQuadSystem

24.60"

OUTLET

3/4" FNPT

INLET

3/4" MNPT

29.69"

Figure7–InsuriceTripleSystem

21"

OUTLET

3/4" FNPT

INLET

3/4" MNPT

29.26"

Checkforcompliancewithstateandlocallaws

andregulations.Donotusewithwaterthatis

microbiologicallyunsafeorofunknownqualitywithout

adequatedisinfectionbeforeorafterthesystem.Systems

certiedforcystreductionmaybeusedondisinfected

watersthatmaycontainlterablecysts.

CARTRIDGE CHANGE PROCEDURE

Everpure Carbon Filter Cartridge

Change

1. Shutoffpowertoequipment.Shut

off inlet water ahead of system.

2. Openushingvalvetorelieve

pressure.

3. Holdheadrmlyandpushupward.

Turncartridgetoleftuntilitstops.

4. Pullcartridgedownwardandoutof

head.

5. Holdheadrmly.Aligncartridge

lugwithlabel.Insertnewcartridge

ﬁrmly into head.

6. Turncartridgeright90˚until

rotation stops.

7. Repeatsteps3-6forremaining

cartridges.

Flushing

8. Withushingvalvefullyopen,open

inlet water at full force for ﬁve

minutes.Closeushingvalve.

9. Turnonpowertoequipment

PRESSURE GAUGES

Low Inlet

Pressure

Adequate Inlet

Pressure

Low Outlet

Pressure

Adequate Outlet

Pressure

For installations in Massachusetts, the Commonwealth of Massachusetts Plumbing Code 248 CMR shall be adhered to. Consult your licensed

plumber for installation of the system. This system and its installation must comply with state and local regulations.

REPLACEMENT PARTS

ContactyourlocalEverpuredealerforltercartridgesorsystem

replacement parts.

Description Part Number

Outlet pressure gauge EV3114-09

Inletpressuregauge(quadonly) EV3114-09

Inletvalve(twin,triple&quad) EV3114-07

Flushingvalve EV3114-07

System Tested and Certied by NSF International against

NSF/ANSI Standards 42 and 53 for the reduction of:

Standard No. 42 —

Aesthetic Effects

Chemical Reduction

Taste and Odor

Chlorine

Mechanical Filtration

Particulate Class I: 99.2% reduction of particles

one-half micron and larger in size

Standard No. 53 —

Health Effects

Mechanical Filtration

Turbidity (i2000, i2000

Only)

Cyst

Asbestos (i2000, i2000

Only)

For sales, replacement components, and service, contact your Everpure dealer or:

Everpure, LLC: 1040MuireldDrive•HanoverPark,Illinois60133•800.323.7873

In Europe: Toekomstlaan30•B-2200Herentals,Belguim

In Japan: HashimotoMNBldg.7F•3-25-1HashimotoSagamihara-Shi•Kanagawa229-1103,Japan

PrintedinU.S.A. EV3112-81RevEAP08

Technical Service

800.942.1153

www.everpure.com

LIMITED WARRANTY

COMMERCIAL WATER TREATMENT EQUIPMENT

Youhavejustpurchasedoneofthenestwatertreatmentunitsmade.AsanexpressionofourcondenceinEverpureproducts,thisproductiswarrantedagainstdefectsin

materialandworkmanshiptotheoriginalend-userwheninstalledinaccordancewithEverpurespecications.Thewarrantyperiodcommencesfromthedateofpurchase

and is administered as follows:

For a period of ONE YEAR Replaceable elements (i.e., ﬁlter & water treatment cartridges)*

For a period of FIVE YEARS The entire system (excluding replaceable elements)

*This is for material & workmanship, not ﬁlter or water treatment cartridge life.

TheunitmustbeusedinoperatingconditionsthatconformtoEverpure’srecommendeddesignguidelines.Thiswarrantywillnotapplyiftheunithasbeenmodied,repaired

oralteredbysomeonenotauthorizedbyEverpure.

If a part described above is found defective within the speciﬁed period, you should notify Everpure technical service at the phone number listed below. Any part

found defective within the terms of this warranty will be repaired or replaced (at Everpure’s discretion) by your local dealer or Everpure technical service. You

pay only freight from our factory and local dealer charges. Any repaired or replaced warranty item will be incorporated under the original warranty terms of the

existing system.

Wearenotresponsiblefordamagecausedbyaccident,re,ood,freezing,ActofGod,misuse,misapplication,neglect,oxidizingagents(suchaschlorine,ozone,

chloraminesandotherrelatedcomponents),alteration,installationoroperationcontrarytoourprintedinstructions,orbytheuseofaccessoriesorcomponentswhichdonot

meetEverpure’sspecications.RefertothespecicationssectionintheInstallationandOperatingmanualforapprovedapplicationparameters.

Ourproductperformancespecicationsarefurnishedwitheachwatertreatmentunit.TOTHEEXTENTPERMITTEDBYLAW,EVERPUREDISCLAIMSALLIMPLIEDWARRANTIES,

INCLUDINGWITHOUTLIMITATIONWARRANTIESOFMERCHANTABILITYANDFITNESSFORPARTICULARPURPOSE;TOTHEEXTENTREQUIREDBYLAW,ANYSUCHIMPLIED

WARRANTIESARELIMITEDINDURATIONTOTHEPERIODSPECIFIEDABOVEFORTHEENTIREWATERTREATMENTUNIT.Asamanufacturer,wedonotknowthecharacteristics

ofyourwatersupplyorthepurposeforwhichyouarepurchasingthisproduct.Thequalityofwatersuppliesmayvaryseasonallyoroveraperiodoftime,andyourwater

usageratemayvaryaswell.Watercharacteristicscanalsodifferconsiderablyifthisproductismovedtoanewlocation.Forthesereasons,weassumenoliabilityforthe

determinationoftheproperequipmentnecessarytomeetyourrequirements,andwedonotauthorizeotherstoassumesuchobligationsforus.Further,weassumeno

liabilityandextendnowarranties,expressorimplied,fortheuseofthisproductwithanon-potablewatersourceorawatersourcewhichdoesnotmeettheconditionsfor

usedescribedintheowner’sguideorperformancedatasheetforthisproduct.OUROBLIGATIONSUNDERTHISWARRANTYARELIMITEDTOTHEREPAIRORREPLACEMENT

(ATEVERPURE’SDISCRETION)OFTHEFAILEDPARTSOFTHEWATERTREATMENTUNIT,ANDWEASSUMENOLIABILITYWHATSOEVERFORDIRECT,INDIRECT,INCIDENTAL,

CONSEQUENTIAL,SPECIAL,GENERALOROTHERDAMAGES.

Somestatesdonotallowtheexclusionofimpliedwarrantiesorlimitationsonhowlonganimpliedwarrantylasts,sotheabovelimitationmaynotapplytoyou.Similarly,

somestatesdonotallowtheexclusionofincidentalorconsequentialdamages,sotheabovelimitationorexclusionmaynotapplytoyou.Thiswarrantygivesyouspecic

legalrights,andyoumayalsohaveotherrightswhichvaryfromstatetostate.ConsultyourtelephonedirectoryforyourlocalindependentlyoperatedEverpuredealer,or

writeEverpureforwarrantyandserviceinformation.