White Mountain Hearth Renegade 50 Conversion Kit Propane to Natural Gas (38227) Owner's manual

Brand: White Mountain Hearth

Model: Renegade 50 Conversion Kit Propane to Natural Gas (38227)

Type: Owner's manual

This manual is also suitable for

40024-0-1118 Page 1

WARNING

This conversion kit must be installed by an Empire Comfort Systems distributor (or other

qualied agency¹)*in accordance with the manufacturer’s instructions and all codes and

requirements of the authority having jurisdiction. Failure to follow instructions could result

in serious injury or property damage. The qualied agency performing this work assumes

responsibility for this conversion.

1National Fuel Gas Code Z223.1 (Latest Edition)

*The term “qualied individual, rm, corporation or company which either in person or through

a representative is engaged in and is responsible for (a) the installation of gas piping or (b)

the connection, installation repair, or servicing of equipment, who is experienced in such

work, familiar with all precautions required, and has complied with all the requirements of the

authority having jurisdiction.

CHECK SAFETY SHUTDOWN PERFORMANCE

WARNING

Perform the safety shutdown test anytime work is done on a gas system to avoid the possibility

of re or explosion with property damage, personal injury or loss of life.

SAFETY SHUTDOWN SYSTEM

Intermittent Pilot System

1. Turn "OFF" using remote control. Main burner and pilot should go off.

2. Pilotgasowshouldstopwithin30seconds.

PARTS LIST

Part Description Conversion Kit Quantity Supplied

MainBurnerOrice,Front P256 1

MainBurnerOrice,Rear P211 1

SIT Gas Valve Conversion Kit R11381 1

Gas Conversion Label 1224 1

Target,Front 40277 1

Target,Rear 40278 1

TOOLS NEEDED:

• StandardScrewdriver

• 1/4 Inch Hex Driver

• 5/16 Inch Hex Driver

• 7/16InchWrench

• 7/16InchDeep

Socket Set

Gas input for direct-vent replace converted to Natural Gas: DVCT50CFP95N

Thedirect-ventgasreplacewhenconvertedtoNaturalGaswillhaveamanifoldpressureofapproximately

3.5inchesw.c.(.871kPa)atthevalveoutletwiththeinletpressuretothevalvefromaminimumof4.5inchesw.c.

(1.120kPa)forthepurposeofinputadjustmenttoamaximumof14.0inchesw.c.(3.484kPa).

INSTALLATION INSTRUCTIONS

DIRECT VENT GAS FIREPLACE

FOR USE ON: DVCT50CFP95P CONVERSION KIT PART NUMBER 38227

FOR CONVERSION TO NATURAL GAS

40024-0-1118Page 2

INSTRUCTIONS FOR CONVERSION

1. Ifthereplaceisinstalled,turnOFFgasandelectricsupply

toreplacebeforemakinggasconversion.AllowFireplaceto

cool completely.

2. Removebarrierscreen,glassdoor,logsandembers,and

liners. See Homeowner's Manual.

Figure 1

3. Removefrontandrearburnersbyremovingscrewsonleft

andpullingouttowardsleftside.See Figure 2.

Figure 2

4. Remove(2)screwsholdingpilotassemblytoburnerpan.

Thiswillallowpilotassemblytodrop.

5. Remove(2)screwsholdingburnerbaseinplace.

 Liftburnerbaseoutofrebox.See Figure 4.

Figure 4

6. Usea7/16inchdeepsocketsettoremoveorices.

See Figure 5.

REAR

FRONT

Figure 5

7. Locatetheoricemarked"32."Usea7/16inchdeepsocket

settoinstalloricemarked"32"ontorearoriceholder.Use

needle-nosepliers,screwreartargetontorearoriceholder.

See Figure 6.

8. Locatetheoricemarked"41."Usea7/16inchdeepsocket

settoinstalloricemarked"41"ontofrontoriceholder.Use

needle-noseplierstoscrewfronttargetontooriceholder.

See Figure 6.

REAR

FRONT

Figure 6

40024-0-1118 Page3

9. Loosenrearairshutterscrewandrotatehandletotheleft

untilfullyclosedisachievedandtightendownscrew.

See Figure 7.

10.Repeatwithfrontuntilfullyclosed.

REAR AIR

SHUTTER

SCREW

FRONT AIR

SHUTTER

SCREW

CLOSED

OPEN

REAR

FRONT

Figure 7

11. Usea7/16inchopenwrenchtoloosenpilotbodybyslightly

turningcounterclockwise.Slideoricebrackettootherside

andtightenpilotbodyclockwise.See Figure 8.

“NAT” MARKING

Figure 8

12. Replaceitemsremovedinsteps2-5inreverseorder.

13. Turngasandelectricon.

14. Gas conversion is completed.

Checkthemainburnerameandpilotburneramemustbe

checkedforproperamecharacteristics,asoutlinedinthe

InstallationInstructionsandOwner'sManual.

Ifreplaceisnotinstalledorprojectregistrationcardhasnot

beenreturnedtoEmpireComfortSystem’s,checkofftypeof

gasconvertedtoonthecard.Alsoindicateconversionbyadding

“Conv.” behind type of gas.

40024-0-1118Page 4

www.empirecomfort.com

Empire Comfort Systems Inc.

Belleville, IL

If you have a general question

aboutourproducts,pleasee-mail

us at [email protected].

If you have a service or repair

question,pleasecontactyourdealer.

White Mountain Hearth Renegade 50 Conversion Kit Propane to Natural Gas (38227) Owner's manual

Brand: White Mountain Hearth

Model: Renegade 50 Conversion Kit Propane to Natural Gas (38227)

Type: Owner's manual

This manual is also suitable for

Download PDF

report

White Mountain Hearth Renegade 50 Conversion Kit Propane to Natural Gas (38227) Owner's manual

This manual is also suitable for

White Mountain Hearth Renegade 50 Conversion Kit Propane to Natural Gas (38227) Owner's manual

Related papers

Other documents