MQ Power DCA-15SPX4 User manual

PARTS AND OPERATION MANUAL

OPERATION AND PARTS MANUAL

Revision #0(02/17/09)

THIS MANUAL MUST ACCOMPANY

THE EQUIPMENT AT ALL TIMES.

WHISPERWATT

TM

SERIES

MODEL DCA-15SPX4

60 Hz GENERATOR

PAGE 2 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

Diesel engine exhaust and some of

PROPOSITION 65 WARNING

DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09) — PAGE 3

1

NOTE PAGE

PAGE 4 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

TABLE OF CONTENTS

NOTE

MQ POWER DCA-15SPX4MQ POWER DCA-15SPX4

MQ POWER DCA-15SPX4

WHISPERWHISPER

WHISPER

WW

W

AA

A

TTTT

TT

TMTM

TM

GENERATORGENERATOR

GENERATOR

California Proposition 65 Warning ..................................... 2

Table Of Contents ............................................................. 4

Parts Ordering Procedures ............................................... 5

Specifications ................................................................... 6

Dimensions (Top, Side, Front) .......................................... 7

Safety Message Alert Symbols .................................... 8-9

Rules for Safe Operation ........................................... 10-14

Installation ................................................................. 16-17

General Information ........................................................ 18

Major Components ......................................................... 19

Generator Control Panel ............................................ 20-21

Output Terminal Panel Familiarization ........................ 22-24

Load Application/Max Amperage .................................... 25

Gauge Reading/Terminal Panel Connections .................. 26

Setup ......................................................................... 27-30

Generator Start-up Procedure ................................... 31-32

Generator Shut-Down Procedure .................................... 33

Maintenance (Engine) ................................................ 34-36

Maintenance (Trailer) ................................................. 37-39

Generator Wiring Diagram ............................................... 40

Engine Wiring Diagram ................................................... 41

Troubleshooting (Engine) ........................................... 42-43

Troubleshooting (Generator) ............................................ 44

Troubleshooting (Pre-Heat Lamp Codes) ........................ 45

Explanation of Code in Remarks Column ....................... 46

Suggested Spare Parts .................................................. 47

COMPONENT DRACOMPONENT DRA

COMPONENT DRA

WINGSWINGS

WINGS

Generator Assembly .................................................. 48-49

Control Panel Assembly ............................................ 50-53

Output Terminal Assembly ......................................... 54-55

Engine and Radiator Assembly ................................. 56-59

Battery Assembly ...................................................... 60-61

Muffler Assembly ...................................................... 62-63

Fuel Tank Assembly .................................................. 64-65

Enclosure Assembly ................................................. 66-69

Rubber Seals Assembly ............................................ 70-71

Nameplate and Decals .............................................. 72-73

Terms and Condition of Sale — Parts ............................ 74

Specification and part

number are subject to

change without notice.

DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09) — PAGE 5

1

PARTS ORDERING PROCEDURES

www.mqpower.com

Ordering parts has never been easier!

Choose from three easy options:

WE ACCEPT ALL MAJOR CREDIT CARDS!

When ordering parts, please supply:

❒❒

❒

Dealer Account Number

❒❒

❒

Dealer Name and Address

❒❒

❒

Shipping Address (if different than billing address)

❒❒

❒

Return Fax Number

❒❒

❒

Applicable Model Number

❒❒

❒

Specify Preferred Method of Shipment:

✓

UPS/Fed Ex

✓ DHL

■

Priority One

✓

Truc k

■

Ground

■ Next Day

All orders are treated as

Standard Orders

and will ship the same day if received prior

If you have an MQ Account, to obtain a

Username and Password, E-mail us at:

[email protected].

To obtain an MQ Account, contact your

Order via Internet (Dealers Only):

Order parts on-line using Multiquip’s SmartEquip website!

■

View Parts Diagrams

■

Order Parts

Note: Discounts Are Subject To Change

Goto www.multiquip.com and click on

Order Parts

to log in and save!

Use the

internet

and qualify for a 5% Discount

on

Standard orders

for all orders which include

Order via Fax (Dealers Only):

All customers are welcome to order parts via Fax.

Domestic (US) Customers dial:

Fax

your order in and qualify for a 2% Discount

on

Standard orders

for all orders which include

Order via Phone:

Domestic (US) Dealers Call:

International Customers

should contact

their local Multiquip Representatives for

Non-Dealer Customers:

Contact your local Multiquip Dealer for

parts or call 800-427-1244 for help in

Note: Discounts Are Subject To Change

Effective:

PAGE 6 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

DCA-15SPX4 — SPECIFICATIONS

snoitacificepSrotareneG.1elbaT

ledoM4XPS51-ACD

epyT

suonorhcnysepytdetcetorpnepo,detalitnevfles,dleifgnivloveR

rotareneg

esahP

eriW-3esahP

elgniS

tuptuOybdnatS

WK5.61

tuptuOemirP

WK51

egatloV

021/V042

ycneuqerF

zH06

deepS

mpr0081

rotcaFrewoP

0.1

rewoPCA

.xuA

)ICFG(

zH06,esahPelgniSCAV021@WK4.2

rewoPCA.xuA

)R03-5L(

zH06,esahPelgniSCAV021@WK6.3

rewoPCA.xuA

)R03-

6L(

zH06,esahPelgniSCAV042@WK2.7

rewoPCA.xuA

)9636SC(

zH06,esahPelgniSCAV042@WK21

zH06,esahPelgniSCAV021@W

K6

snoitacificepSenignE.2elbaT

ledoM

M-3022VATOBUK

epyT

epytrebmahcnoitsubmoclriws,delooc-retaw,elcyC4

srednilyCfo.oN

srednilyc4

ekortSxer

oB

)mm4.29xmm78(.ni46.3x.ni34.3

tuptuOdetaR

mpr0081/PH1.72

tnemecalpsiD

)cc791,2(.ni.uc1.431

gnitratS

cirtce

lE

yticapaCtnalooC

)sretil9.7(.lag90.2

yticapaCliOebuL

)sretil6.7(.lag00.2

yticapaCknaTleuF

)sretil26(.lag4

.61

noitpmusnoCleuF

tarh/)L2.5(.lag73.1 daollluf tarh/)L80.4(.lag80.1 daol4/3

tarh/)L41.3(.lag38.0 daol2/1 ta

rh/)L43.2(.lag26.0 daol4/1

yrettaB

)A525:72(HA56-V21

leuF

leuFleseiD2#

thgieWyrD

gk775

thgieWlatoT

gk946

DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09) — PAGE 7

1

DCA-15SPX4 — DIMENSIONS (TOP, SIDE AND FRONT)

Figure 1. Dimensions

SNOISNEMID.3ELBAT

retteLecnerefeR).mm(.tfnoisnemiD

A).mm055(.ni56.12

B).mm094(.ni92.91

C).mm516(.ni12.42

D).mm514,1(.ni07.55

E).mm

209.ni15.53

F).mm056(.ni06.52

WHISPERWATT

15

MQPOWER

FRONT VIEW

F

E

D

TOP VIEW

SIDE VIEW

Denyo

B

C

A

U

N

V

PAGE 8 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

This Owner's Manual has been

developed to provide complete

instructions for the safe and

efficient operation of the

MQ Power

Model DCA-15SPX4

Whisperwatt™ Generator.

Before using this generator, ensure that the operating

individual has read and understands all instructions in

this manual.

Safety precautions should be followed at all times when

operating this equipment. Failure to read and understand the

Safety Messages and Operating Instructions could result in

injury to yourself and others.

FOR YOUR SAFETY AND THE SAFETY OF OTHERS!

HAZARD SYMBOLS

Potential hazards associated with the operation of this

equipment will be referenced with "

Hazard Symbols

" which

appear throughout this manual, and will be referenced in

conjunction with Safety "

Message Alert Symbols

".

NOTE

DCA-15SPX4 — SAFETY MESSAGE ALERT SYMBOLS

SAFETY MESSAGE ALERT SYMBOLS

The three (3) Safety Messages shown below will inform you

about potential hazards that could injure you or others. The

Safety Messages specifically address the level of exposure

to the operator, and are preceded by one of three words:

DANGER, WARNING, or CAUTION.

You WILL be KILLED or SERIOUSLY injured if you

do not follow directions.

You COULD be KILLED or SERIOUSLY injured if

you do not follow directions.

You CAN be injured if you do not follow directions

Gasoline engine exhaust gases contain

poisonous carbon monoxide. This gas is

colorless and odorless, and can cause

DEATH

if inhaled. NEVER operate this

equipment in a confined area or enclosed structure that

does not provide ample free flow air.

Diesel fuel

is extremely flammable, and

its vapors can cause an explosion if

ignited. DO NOT start the engine near

spilled fuel or combustible fluids.

DO NOT fill the fuel tank while the engine

is running or hot.

DO NOT overfill tank, since spilled fuel could ignite if it

comes into contact with hot engine parts or sparks from

the ignition system. Store fuel in approved containers, in

well-ventilated areas and away from sparks and flames.

NEVER use fuel as a cleaning agent.

Engine components can generate extreme

heat. To prevent burns, DO NOT touch these

areas while the engine is running or

immediately after operations. NEVER

operate the engine with heat shields or heat

guards removed.

WARNING

DANGER

CAUTION

WARNING - LETHAL EXHAUST GASES

WARNING - BURN HAZARDS

WARNING - EXPLOSIVE FUEL

During operation of this generator, there

exists the possibility of

electrocution,

electrical shock or burn,

which can cause

severe bodily harm

or even

DEATH!

DANGER - ELECTROCUTION HAZARDS

DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09) — PAGE 9

1

DCA-15SPX4 — SAFETY MESSAGE ALERT SYMBOLS

ALWAYS place the engine ON/OFF

switch (MPEC) in the OFF/RESET

position when the generator is not in use.

ALWAYS wear approved

respiratory

protection.

ALWAYS wear approved

eye

and

hearing

protection.

Other important messages are provided throughout this

manual to help prevent damage to your generator, other

property, or the surrounding environment.

This generator, other property, or

the surrounding environment

could be damaged if you do not

follow instructions.

NOTE

NEVER tamper with the factory settings

of the engine governor or settings.

Personal injury and damage to the engine

or equipment can result if operating in

speed ranges above maximum allowable.

CAUTION - OVER-SPEED CONDITIONS

CAUTION - ACCIDENTAL STARTING

CAUTION - RESPIRATORY HAZARDS

CAUTION - SIGHT AND HEARING HAZARDS

CAUTION - EQUIPMENT DAMAGE MESSAGES

NEVER operate equipment with covers,

or guards removed. Keep

fingers

,

hands

,

hair

and clothing away from all moving

parts to prevent injury.

WARNING - ROTATING PARTS

Wet-Stacking is a common problem with diesel engines

which are operated for extended periods with light or no

load applied. When a diesel engine operates without

sufficient load (less than 40% of the rated output) it will

not operate at its optimum temperature. This will allow

unburned fuel to accumulate in the exhaust system, which

can foul the fuel injectors, engine valves and exhaust

system, including turbocharges, and reduce the operating

performance.

In order for a diesel engine to operate at peak efficiency it

must be able to provide fuel and air in the proper ratio and

at a high enough engine temperature for the engine to

completely burn all of the fuel.

Wet stacking does usually cause any permanent damage

and can be alleviated if additional load is applied to relieve

the condition. It can reduce the system performance and

increase maintenance. Applying an increasing load over a

period of time until the excess fuel is burned off and the

system capacity is reached usually can repair the condition.

This can take several hours to burn off the accumulated

unburned fuel.

CAUTION - ENGINE LOAD (WET-STACKING)

PAGE 10 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

DCA-15SPX4 — RULES FOR SAFE OPERATION

The following safety guidelines should always be used when

operating the

DCA-15SPX4 Whisperwatt™ AC Generator.

General Safety:

■

DO NOT operate or service this

equipment before reading this entire

manual.

The operator MUST BE familiar with proper safety

precautions and operations techniques before using

generator.

■

This equipment should not be operated by persons under

18 years of age.

■

NEVER operate this equipment without proper protective

clothing, shatterproof glasses, steel-toed boots and other

protective devices required by the job.

■

NEVER operate this equipment when not

feeling well due to fatigue, illness or taking

medicine.

■

NEVER operate this equipment under the influence or

drugs or alcohol.

Failure to follow instructions in this manual may lead to

serious injury

or even

DEATH

! This equipment is to be

operated by trained and qualified personnel only! This

equipment is for industrial use only.

DANGER - READ THIS MANUAL!

■

ALWAYS wear proper respiratory (mask),

hearing and eye protection equipment when

operating the generator.

■

Whenever necessary, replace nameplate, operation and

safety decals when they become difficult read.

■

Manufacturer does not assume responsibility for any

accident due to equipment modifications. Unauthorized

equipment modification will void all warranties.

■

NEVER use accessories or attachments, which are not

recommended by Multiquip for this equipment. Damage

to the equipment and/or injury to user may result.

■

The engine section of this generators requires an adequate

free flow of cooling air.

NEVER

operate the generator in

any enclosed or narrow area where free flow of the air is

restricted. If the air flow is restricted it will cause serious

damage to the generators

or engine and may cause

injury to people.

Remember the generator's

engine gives off

DEADLY

carbon monoxide gas.

■

NEVER touch the hot exhaust

manifold, muffler or cylinder.

Allow these parts to cool before

servicing engine or generators.

■

ALWAYS refuel in a well-ventilated area, away from sparks

and open flames.

■

ALWAYS use extreme caution when

working with flammable liquids. When

refueling, stop the engine and allow it to

cool. DO NOT

smoke

around or near the

machine. Fire or explosion could result

from fuel vapors, or if fuel is spilled on a

hot engine.

■

NEVER operate the generator in an

explosive atmosphere or near

combustible materials. An explosion or

fire could result causing severe

bodily

harm or even death.

■

NEVER disconnect any

"emergency or safety devices"

.

These devices are intended for operator safety. Disconnection

of these devices can cause severe injury, bodily harm or even

death! Disconnection of any of these devices will void all

warranties.

DANGEROUS

GAS FUMES

Denyo

DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09) — PAGE 11

1

DCA-15SPX4 — RULES FOR SAFE OPERATION

■

ALWAYS be sure the operator is familiar with proper safety

precautions and operation techniques before using

generators.

■

NEVER leave the generator unattended, turn off engine when

unattended.

■

Unauthorized equipment modifications will void all warranties.

■

ALWAYS ensure generator is on level ground before use.

■

DO NOT place hands or fingers inside generators engine

compartment when engine is running.

■

NEVER run engine without air cleaner. Severe engine damage

may occur.

■

NEVER change or adjust the engine speed which has been

set at the factory prior to shipping.

Power Cord Safety

■

NEVER let power cables or cords

lay in wate

r.

■

NEVER

stand in water

while AC power from the generators

is being transfer to a load.

■

NEVER use a defective or frayed power cable. Check the

cable for cuts in the insulation.

■

NEVER use a extension cord that is frayed or damaged where

the insulation has been cut.

■

ALWAYS make certain that proper power or extension cord

has been selected for the job See Table 6.

Grounding Safety

■

ALWAYS make sure that electrical circuits are properly

grounded

per the

National Electrical Code

(NEC) and

local codes before operating generator. Severe

injury

or

death!

by electrocution can result from operating an

ungrounded generator.

■

ALWAYS make sure the generators are properly grounded to

a suitable earth ground (GROUND ROD). See installation in

this manual.

■

NEVER use

gas piping

as an electrical ground.

Maintenance Safety

■

NEVER lubricate components or attempt service on a running

machine.

■

High Temperatures – Always stop engine and

allow the engine to cool before adding fuel, oil

or performing service and maintenance

functions. Contact with

hot!

components can

cause serious burns.

■

Keep the machinery in proper running condition.

■

Fix damage to the machine immediately and replace any

broken parts immediately.

■

ALWAYS replace any worn or damaged warning decals.

■

ALWAYS store equipment properly when it is not being used.

Equipment should be stored in a clean, dry location out of the

reach of children and un-authorized personnel.

■

The electrical voltage required to operate the generator can

cause severe injury or even death through physical contact

with live circuits.

Turn all circuit breakers OFF before

performing maintenance on the generator.

■

Dispose of hazardous waste properly. Examples of potentially

hazardous waste are used motor oil, fuel and fuel filters.

■

DO NOT use food or plastic containers to dispose of

hazardous waste.

■

DO NOT pour waste, oil or fuel directly onto the ground,

down a drain or into any water source.

■

ALWAYS allow the machine a proper amount of time to

cool before servicing.

■

ALWAYS service air cleaner frequently to prevent engine

malfunction.

■

ALWAYS disconnect the

NEGATIVE battery terminal

before performing service on the generator.

■

Follow all battery safety guidelines listed in this manual

when handleing or servicing the generator.

PAGE 12 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

DCA-15SPX4 — RULES FOR SAFE OPERATION

Battery Safety

Use the following guidelines when handling the battery:

■

The battery contains acids that can

cause injury to the eyes and skin. To

avoid eye irritation,

always

wear safety

glasses.

■

Use well insulated gloves when picking up the battery.

■■

■

ALWAYS keep the battery charged. If the battery is not

charged a buildup of combustible gas will occur.

■■

■

ALWAYS keep battery charging and cables in good

working condition. Repair or replace all worn cables.

■■

■

ALWAYS recharge the battery in an vented air

environment, to avoid risk of a dangerous concentration

of combustible gases.

■■

■

In case the battery liquid (dilute sulfuric acid) comes in

contact with

clothing or skin

, rinse skin or clothing

immediately with plenty of water.

■■

■

In case the battery liquid (dilute sulfuric acid) comes in

contact with your

EYES

, rinse eyes immediately with

plenty of water and contact the nearest doctor or hospital

to seek medical attention.

The risk of an explosion exists when performing service

on the battery. To avoid

severe injury

or

DEATH:

■■

■

DO NOT drop the battery. There

is the possibility of risk that the

battery may explode.

■■

■

DO NOT expose the battery to

open flames, sparks, cigarettes

etc. The battery contains combustible gases and liquids.

If these gases and liquids come in contact with a flame

or spark, an explosion could occur.

DANGER - EXPLOSION HAZARDS

To prevent burns, DO NOT touch or open any of the below

mentioned components while the engine is

running or immediately after operations.

Always allow sufficient time for the engine

and generator to cool before performing

maintenance.

■

Radiator Cap - Removing the radiator cap while the

engine is hot will result in high pressurized, boiling water

to gush out of the radiator, causing severe scalding to

any persons in the general area of the generator.

■

Coolant Drain Plug - Removing the

coolant drain plug while the engine is

hot will result in hot coolant gushing

out of the coolant drain plug, therefore

causing severe scalding to any persons

in the general area of the generator.

■

Engine Oil Drain Plug - Removing the engine oil drain

plug while the engine is hot will result in hot oil gushing

out of the oil drain plug, therefore causing severe

scalding to any persons in the general area of the

generator.

WARNING - BURN HAZARDS

DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09) — PAGE 13

1

DCA-15SPX4 — RULES FOR SAFE OPERATION

Backfeed to a utility system can cause

electrocution

and or property damage.

NEVER connect the generators to a

building's electrical system without a

transfer switch or other approved device.

All installations should be performed by

a

licensed electrician

in accordance

with all applicable laws and electrical

codes. Failure to do so could result in

electrical shock or burn causing serious

injury or even death!

Emergencies

■

ALWAYS know the location of the

nearest

fire extinguisher

.

■

ALWAYS know the location of the nearest

first aid kit

.

■

In emergencies

always

know the location of the

nearest phone or

keep a phone on the job site

.

Also know the phone numbers of the nearest

ambulance

,

doctor

and

fire department

. This

information will be invaluable in the case of an

emergency.

DANGERDANGER

DANGER

-

Electrocution HazardsElectrocution Hazards

Electrocution Hazards

During operation of this generation, there

exists the possibility of

electrocution

,

electrical shock or burn

, which can

cause

severe bodily harm

or even

DEATH!

To avoid these hazards:

NEVER use

damaged

or

worn

cables when connecting

equipment to the generator. Make sure power connecting

cables are securely connected to the generator’s output

receptacles, incorrect connections may cause damage

to the generators and electrical shock.

NEVER insert any objects into

the output receptacles during

operation. This is extremely

dangerous. ALWAYS turn-off

the generators and place all circuit breakers in the “OFF”

position when contact with the output receptacles is

required. There exist the possibility of

electrocution,

electrical shock or burn, which can cause severe

bodily harm or even death

!

NEVER grab or touch a live

power cord with wet hands, the

possibility exist of electrical

shock, electrocution, and even

death!

ACCIRCUIT

BREAKER

ACCIRCUIT

B

REAKER

O

F

OFF

2

A

22

A

120

V

20A

120V

OFF

ON

GA-2.9R

2900

DANGER

Using a generator indoors .CAN KILL YOU IN MINUTES

Generator exhaust contains carbon monoxide. This is

a posion you cannot see or smell

NEVER use inside a home

or garage, even if doors

and windows are open

ACCIRCUIT

BREAKER

ACCIRCUIT

BREAKER

O

F

OFF

2

A

22A

120

V

20A

120V

OFF

ON

GA-2.9R

2900

ACCIRCUIT

BREAKER

ACCIRCUIT

BREAKER

O

F

OF

F

2

A

2

A

120

V

20A

120V

OFF

ON

GA-2.9R

2900

Only use OUTSIDE and

far away from windows,

doors, and vents.

Avoid other generator hazards.

.READ MANUAL BEFORE USE

Engine exhaust gases contain

poisonous carbon monoxide. This gas

is colorless and odorless, and can

cause death if inhaled. NEVER operate

this equipment in a confined area or

enclosed structure that does not provide

ample free flow air.

DANGERDANGER

DANGER

-

Lethal Exhaust Gas HazardsLethal Exhaust Gas Hazards

Lethal Exhaust Gas Hazards

PAGE 14 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

Check with your local county or state safety towing

regulations, in addition to meeting

Department of

Transportation

(DOT)

Safety Towing Regulations

, before

towing your generator.

CAUTION - FOLLOW TOWING REGULATIONS

■

The maximum speed for highway towing is 55 MPH

unless posted otherwise. Recommended off-road towing

is not to exceed 15 MPH or less depending on type of

terrain.

■

Place

chock blocks

underneath wheel to prevent rolling,

while parked.

■

Use the trailer’s swivel jack to adjust the trailer height to

a level position while parked.

■

Avoid sudden stops and starts. This can cause skidding,

or jack-knifing. Smooth, gradual starts and stops will

improve towing.

■

Avoid sharp turns.

■

Trailer should be adjusted to a level position at all times

when towing.

■

Raise and lock trailer wheel stand in up position when

transporting.

■

The maximum speed for highway towing is 55 MPH

unless posted otherwise. Recommended off-road towing

is not to exceed 15 MPH or less depending on type of

terrain.

■

Place

support blocks

underneath the trailer’s bumper to

prevent tipping, while parked.

■

Avoid sharp turns to prevent rolling.

■

DO NOT transport generator with fuel in tank.

Towing and Transporting Safety

To reduce the possibility of an accident while transporting

the generator on public roads, always make sure the trailer

that supports the generator and the towing vehicle are in

good operating condition and both units are mechanically

sound.

The following list of safety precautions should be followed

when towing your generator:

■

ALWAYS shutdown engine before transporting.

■

Drain fuel from generator fuel tank before towing.

■

If generator is mounted on a trailer, make sure trailer

complies with all local and state safety transportation

laws. Follow the listed

Towing & Transporting Safety

guidelines for basic towing techniques.

■

Make sure the hitch and coupling of the towing vehicle

are rated equal to, or greater than the trailer "gross vehicle

weight rating.”

■

ALWAYS inspect the hitch and coupling for wear. NEVER

tow a trailer with defective hitches, couplings, chains etc.

■

Check the tire air pressure on both towing vehicle and

trailer.

Trailer tires should be inflated to 50 psi cold.

Also check the tire tread wear on both vehicles.

■

ALWAYS make sure the trailer is equipped with a "Safety

Chain".

■

ALWAYS attach trailer’s safety chains to towing vehicle

properly.

■

ALWAYS make sure the vehicle and trailer directional,

backup, brake, and trailer lights are connected and

working properly.

■

DOT Requirements include the following:



Connect and test electric brake operation.



Secure portable power cables in cable tray with tie

wraps.

If your generator is trailer mounted, please

read the towing and safety requirements

listed below.

For more saftey tips, see the trailer saftey

guidelines section in this manual.

NOTE

DCA-15SPX4 — RULES FOR SAFE OPERATION

DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09) — PAGE 15

1

NOTE PAGE

PAGE 16 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

Figure 2. Typical Generator Grounding Application

DCA-15SPX4 — INSTALLATION

DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09) — PAGE 17

1

Outdoor Installation

Install the generator in a area that is free of debris,

bystanders, and overhead obstructions. Make sure the

generator is on secure level ground so that it cannot slide or

shift around. Also install the generator in a manner so that

the exhaust will not be discharged in the direction of nearby

homes.

The installation site must be relatively free from moisture

and dust. All electrical equipment should be protected from

excessive moisture. Failure to do will result in deterioration

of the insulation and will result in short circuits and grounding.

Foreign materials such as dust, sand, lint and abrasive

materials have a tendency to cause excessive wear to

engine and alternator parts.

Generator Grounding

To guard against electrical shock and possible damage to

the equipment, it is important to provide a good EARTH

ground.

Article 250 (Grounding) of the National Electrical Code (NEC)

provides guide lines for proper grounding and specifies that

the cable ground shall be connected to the grounding system

of the building as close to the point of cable entry as

practical.

NEC articles 250-64(b) and 250-66 set the following

grounding requirements:

1. Use one of the following wire types to connect the

generator to earth ground.

a. Copper - 10 AWG (5.3 mm

2

) or larger.

b. Aluminum - 8 AWG (8.4 mm

2

) or larger.

2. When grounding the generator (Figure 2) connect the

ground cable between the lock washer and the nut on

the generator and tighten the nut fully. Connect the other

end of the ground cable to earth ground.

3. NEC article 250-52(c) specifies that the earth ground

rod should be buried aminimum of 8 ft. into the ground.

When connecting the generator

to any buildings electrical

system ALWAYS consult with

a licensed electrician.

DCA-15SPX4 — INSTALLATION

NOTE

Indoor Installation

Exhaust gases from diesel engines are extremely poisonous.

Whenever an engine is installed indoors the exhaust fumes

must be vented to the outside. The engine should be installed

at least two feet from any outside wall. Using an exhaust

pipe which is too long or too small can cause excessive

back pressure which will cause the engine to heat excessively

and possibly burn the valves.

Mounting

The generator must be mounted on a solid foundation (such

as concrete) and set firmly on the foundation to isolate

vibration of the generator when it is running. The generator

must set at least 6 inches above the floor or grade level (in

accordance to NFPA 110, Chapter 5-4.1). DO NOT remove

the metal skids on the bottom of the generator. They are to

resist damage to the bottom of the generator and to maintain

alignment.

Pay close attention to ventilation when operating the

generator inside tunnels and caves. The engine exhaust

contains noxious elements. Engine exhaust must be routed

to a ventilated area.

CAUTION - EXHAUST HAZARD

PAGE 18 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

DCA-15SPX4 — GENERAL INFORMATION

DCA-15SPX4 Whisperwatt™ Series Familiarization

Generator

The MQ Power Model DCA-15SPX4 is a 15 kW

generator

(Figure 3) that is designed as a high quality portable (requires

a trailer for transport) power source for telecom sites, lighting

facilities, power tools, submersible pumps and other industrial

and construction machinery.

Generator Control Panel

The “Engine Operating Panel” is provided with the following:

■■

■

Warning Lamp Unit

■■

■

Preheat Lamp

■■

■

Oil Pressure Alarm Lamp

■■

■

Water Temperature Alarm Lamp

■■

■

Battery Charging Alarm Lamp

■■

■

Speed Control Switch

■■

■

Frequency Meter (Hz)

■■

■

AC Ammeter (Amps)

■■

■

AC Voltmeter (Volts)

■■

■

Voltage Regulator

■■

■

Starter Switch

■■

■

Hour Meter

■■

■

3-Pole, 70 amp Main Circuit Breaker

■■

■

1-Pole, 20 amp Circuit Breaker (for GFCI)

■■

■

1-Pole, 30 amp Circuit Breaker (for L5-30R)

■■

■

2-Pole, 30 amp Circuit Breaker (for L6-30R)

■■

■

2-Pole, 50 amp Circuit Breaker (for CS6369)

■■

■

“Control Box” (located behind the Gen. Control Panel)

■■

■

Automatic Voltage Regulator

■■

■

Current Transformer

■■

■

Over-Current Relay

■■

■

Voltage Rectifer

■■

■

Starter Relay

Output Terminal Panel

The “Output Terminal Panel” is provided with the following:

■■

■

Three output terminal lugs (1Ø power)

■■

■

1-Phase Output Terminal

■■

■

120/240V output receptacle (CS-6369), 50A

■■

■

120 output receptacle (5-20R)GFCI, 20A

■■

■

120V output receptacle (L5-30R), 30A

■■

■

240V output receptacle,(L6- 30R) 30A

■■

■

Ground Terminal (for G.F.C.U)

■■

■

Battery Charger (Optional)

■■

■

Water Heater (Optional)

Open Delta Excitation System

The generator is equipped with the state of the art "

Open-

Delta

" excitation system. The open delta system consist of

an electrically independent winding wound among stationary

windings of the AC output section.

There are four connections of the open delta A, B, C and D.

During steady state loads, the power from the voltage regulator

is supplied from the parallel connections of A to B, A to D,

and C to D. These three phases of the voltage input to the

voltage regulator are then rectified and are the excitation

current for the exciter section.

When a heavy load, such as a motor starting or a short

circuit occurs, the automatic voltage regulator (AVR)

switches the configuration of the open delta to the series

connection of B to C. This has the effect of adding the voltages

of each phase to provide higher excitation to the exciter

section and thus better voltage response during the

application of heavy loads.

The connections of the AVR to the AC output windings are

for sensing only. No power is required from these windings.

The open-delta design provides virtually unlimited excitation

current, offering maximum motor starting capabilities. The

excitation does not have a "

fixed ceiling

" and responds

according the demands of the required load.

Engine

The DCA-15SPX4 is powered by a 4 cylinder, water cooled,

Kubota Model V2203-M diesel engine

. This engine is

designed to meet every performance requirement for the

generator. Reference Table 1 for engine specifications.

In keeping with MQ Power's policy of constantly improving

its products, the specifications quoted herein are subject to

change without prior notice.

Electric Governor System

The electric governor system controls the RPMs of the en-

gine. When the engine demand increases or decreases, the

governor system regulates the frequency variation to ±.25%.

Extension Cables

When electric power is to be provided to various tools or

loads at some distance from the generator, extension cords

are normally used. Cables should be sized to allow for

distance in length and amperage so that the voltage drop

between the generator and point of use (load) is held to a

minimum. Use the cable selection chart (Table 6) as a guide

for selecting proper extension cable size.

DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09) — PAGE 19

1

DCA-15SPX4 — MAJOR COMPONENTS

Figure 3. Major Components

4elbaT. stnenopmoCrojaMrotareneG

.ONMETINOITPIRCSED

1ylbmessAretliFriA

2ylbmessArelffuM

3ylbmessArotaidaRdnaenignE

4ylbmessArotareneG

5ylbmessAyr

ettaB

6ylbmessAknaTleuF

7ylbmessAlenaPlortnoCrotareneG

8ylbmessAelcatpeceRtuptuO

9ylbmessAlanimreTtuptuO

PAGE 20 — DCA-15SPX4— OPERATION MANUAL — REV. #0 (02/17/09)

Figure 4. Generator Control Panel

DCA-15SPX4 — GENERATOR CONTROL PANEL

U

N

V

14

A

V

HZ

WATERTEMP.

OIL PRESS.

BATT.LOW LEVEL

DECREASE

INCREASE

PREHEATLAMP

3

1

2

7

16

17

18

19

8

6

9

4

5

13

12

11

10

15

Page is loading ...

MQ Power DCA-15SPX4 User manual

This manual is also suitable for

MQ Power DCA-15SPX4 User manual

Related papers

Other documents