Chefsrange BH30B Owner's manual

GCBH30BSERIESFOODMIXERS

MainSpecialty:

 Accordingtotheplanetmovementtheory，beatermoveslikeplanetsinthe

bowlssothatthefoodismixedcompletely.

 Theyhavethree‐rangerotationspeed.

 Allthesparepartsinthemachinesaremadeofpremiumstainlesssteelto

ensurethattheymeetthenationalhygienestandardforfood.

 Themachineisgoodlooking,easyoperableandhighinefficiency.

TechnicalSpecifications:



Model

Bowl

Volume

(L)

Voltage

(V)

Rated

Frequency(Hz)

Power

(KW)

Max.

Kneading

Capacity(kg)

MixingSpeed

(r/min)Size(mm)

GCBH30B30220501.13.5105/180/408545×440×882



OperationandNotes:

Beforeuse，checkthatpowersupplycorrespondstothatrequiredbythemachine.

Checkthattheexternearthingwireisreliablyconnected.

Themachinewhich3phasemotormustbecheckedthatthemachinerotatesin

thedirectionindicatedbytherotationmark.Iftherotationdirectioniswrong,

changethetwoofthethreelivewireseachother.NoteFortestofmachine，mixing

toolsshouldneverbeinstalledotherwisetheywouldfalloutincaseofwrong

rotationdirectionandcausedamagetomachineparts.

Selectspeedandagitator:

a)Dougharm:Itisfrequentlyusedforheavybreaddough，theweightofflour

indicatedbythemark，theweightofwateris47%~50%ofthefillflour，and

preferabletobeusedatlowspeed.

b)Beater:Itiscommonlyusedforthinbatters，cakesandmashingpotatoes，like

stuffing，andpreferabletobeusedatmiddlespeed.

c)Wirewhip:Itisbestforwhippingcreamandbeatingeggs,andpreferabletobe

usedathighspeed.

Importantnotice:Stopthemachinetochangespeed，don’tmixdoughatmiddle

orhighspeed.

Bowllift:

a)Whenmixing，rotatethehandwheeltoraisethebowluntilyoufeelittouchthe

stop，thisalsomakesthebowlmoreaccessibleforfilling.

b)Aftermixing，rotatethehandwheeltolowerthebowl.Itisnecessarytolower

thebowltochangeagitators,availtoremovethebowloragitators.

Note:Whenassemblinganagitatorthebowlmustbeinthedownposition,Slip

theagitatorupontheshaftandturnuntilthedrivingpinintheshaftreachesthe

L‐shapedslotintheagitatorshank,avoidtheagitatortobefallendownin

running.

Maintenance

Afteruseeachtime，ancarefullythebowlagitatorsetc，makesuretokeepthe

machineclear.

Lubricatethebowlslidewaysoccasionallybyapplyingasmallamountofoilor

greasewiththetipoflinger.

Troubleshooting：

TroubleProbablecauseRemedy

Themixingshaftdon’trotates

afterswitchonElectricconnectorsarelooseCheckheelectriccircuit,tighten

thoselooseconnectors

OilleakageOilsealsarewornoutReplacethoseoilseals

Theraisinghandleistootight

GuidewaysarecorrodedCleanandoiltheguideways

Theleadscrew,bevelgearand

handwheelshaftetcisdryOilthem

Temperatureriseofmotoristoo

high,belowspeed

LackofvoltageCheckthesupplyvoltage

OverloadLessload

Theworkingspeedselectedistoo

highoragitatorisnotsuitable

Selectasuitablespeedand

agitator

Thenoiseofthegearboxisserious,

itstemperatureistoohighLubricationisinsufficientAddorreplacetheoil

TheagitatorknockswiththebowlTheagitatororthebowlis

deformedRepairorreplacedeformedpart

Chefsrange BH30B Owner's manual

Other documents