RAM Commercial Chassis Cab 2017 Owner's manual

2017 Chassis Cab

STICK WITH THE SPECIALISTS

®

Fourth Edition

Printed in U.S.A.

Ram is a registered trademark of FCA US LLC.

17DD43-126-AD

Chassis Cab

OWNER’S MANUAL

2017

VEHICLES SOLD IN CANADA

With respect to any Vehicles Sold in Canada, the name FCA

US LLC shall be deemed to be deleted and the name FCA

Canada Inc. used in substitution therefore.

DRIVING AND ALCOHOL

Drunken driving is one of the most frequent causes of

accidents.

Your driving ability can be seriously impaired with blood

alcohol levels far below the legal minimum. If you are

drinking, don’t drive. Ride with a designated non-

drinking driver, call a cab, a friend, or use public trans-

portation.

WARNING!

Driving after drinking can lead to an accident.

Your perceptions are less sharp, your reflexes are

slower, and your judgment is impaired when you

have been drinking. Never drink and then drive.

This manual illustrates and describes the operation of

features and equipment that are either standard or op-

tional on this vehicle. This manual may also include a

description of features and equipment that are no longer

available or were not ordered on this vehicle. Please

disregard any features and equipment described in this

manual that are not on this vehicle.

FCA US LLC reserves the right to make changes in design

and specifications, and/or make additions to or improve-

ments to its products without imposing any obligation

upon itself to install them on products previously manu-

factured.

TABLE OF CONTENTS

SECTION PAGE

1

INTRODUCTION ...................................................................3

2

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE ......................................9

3

UNDERSTANDING THE FEATURES OF YOUR VEHICLE ......................................97

4

UNDERSTANDING YOUR INSTRUMENT PANEL ...........................................193

5

STARTINGANDOPERATING.........................................................321

6

WHATTODOINEMERGENCIES ......................................................429

7

MAINTAININGYOURVEHICLE .......................................................451

8

MAINTENANCE SCHEDULES . . .......................................................511

9

IF YOU NEED CONSUMER ASSISTANCE .................................................517

10

INDEX..........................................................................523

1

2

3

4

5

6

7

8

9

10

INTRODUCTION

CONTENTS

䡵 INTRODUCTION .........................4

䡵 HOW TO USE THIS MANUAL ...............4

䡵 WARNINGS AND CAUTIONS ................6

䡵 VAN CONVERSIONS/CAMPERS ..............6

䡵 VEHICLE IDENTIFICATION NUMBER .........7

䡵 VEHICLE MODIFICATIONS/ALTERATIONS .....7

1

INTRODUCTION

Congratulations on selecting your new FCA US LLC ve-

hicle. Be assured that it represents precision workmanship,

distinctive styling, and high quality.

This Owner’s Manual has been prepared with the assis-

tance of service and engineering specialists to acquaint you

with the operation and maintenance of your vehicle. It is

supplemented by Warranty Information, and various

customer-oriented documents. Please take the time to read

these publications carefully. Following the instructions and

recommendations in this manual will help assure safe and

enjoyable operation of your vehicle.

If applicable, refer to the Diesel Supplement for diesel

related information.

NOTE: After reviewing the owner information, it should

be stored in the vehicle for convenient referencing and

remain with the vehicle when sold.

When it comes to service, remember that your authorized

dealer knows your vehicle best, has factory-trained techni-

cians and genuine MOPAR® parts, and cares about your

satisfaction.

HOW TO USE THIS MANUAL

Consult the Table of Contents to determine which section

contains the information you desire.

Since the specification of your vehicle depends on the items

of equipment ordered, certain descriptions and illustra-

tions may differ from your vehicle’s equipment.

The detailed index at the back of this Owner’s Manual

contains a complete listing of all subjects.

4 INTRODUCTION

Consult the following table for a description of the symbols

that may be used on your vehicle or throughout this

Owner’s Manual:

1

INTRODUCTION 5

WARNINGS AND CAUTIONS

This Owner’s Manual contains WARNINGS against operat-

ing procedures that could result in a collision, bodily injury

and/or death. It also contains CAUTIONS against proce-

dures that could result in damage to your vehicle. If you do

not read this entire Owner’s Manual, you may miss impor-

tant information. Observe all Warnings and Cautions.

VAN CONVERSIONS/CAMPERS

The New Vehicle Limited Warranty does not apply to body

modifications or special equipment installed by van

conversion/camper manufacturers/body builders. U.S.

residents refer to the Warranty Information book, Section

2.1.C. Canadian residents refer to the “What Is Not Cov-

ered” section of the Warranty Information book. Such

equipment includes video monitors, VCRs, heaters, stoves,

refrigerators, etc. For warranty coverage and service on

these items, contact the applicable manufacturer.

Operating instructions for the special equipment installed

by the conversion/camper manufacturer should also be

supplied with your vehicle. If these instructions are miss-

ing, please contact your authorized dealer for assistance in

obtaining replacement documents from the applicable

manufacturer.

For information on the Body Builder’s Guide refer to

www.rambodybuilder.com. This website contains dimen-

sional and technical specifications for your vehicle. It is

intended for Second Stage Manufacturer’s technical sup-

port. For service issues, contact your authorized dealer.

6 INTRODUCTION

VEHICLE IDENTIFICATION NUMBER

The Vehicle Identification Number (VIN) is found on the

left front corner of the instrument panel, visible through

the windshield. This number also appears on the vehicle

frame and underbody as well as the Automobile Informa-

tion Disclosure Label affixed to a window on your vehicle,

the vehicle registration and title.

NOTE: It is illegal to remove or alter the VIN.

VEHICLE MODIFICATIONS/ALTERATIONS

WARNING!

Any modifications or alterations to this vehicle could

seriously affect its roadworthiness and safety and may

lead to a collision resulting in serious injury or death.

Vehicle Identification Number

1

INTRODUCTION 7

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

CONTENTS

䡵 A WORD ABOUT YOUR KEYS ...............11

▫ Wireless Ignition Node (WIN) And Key Fob — If

Equipped .............................11

▫ Keyless Push Button Ignition And Key Fob — If

Equipped .............................12

▫ Emergency Key Removal ..................14

▫ Removing Key Fob From The (WIN) Ignition . . .15

▫ Key-In-Ignition Reminder .................17

▫ General Information .....................17

䡵 SENTRY KEY ...........................18

▫ Replacement Key Fobs ...................19

▫ Customer Key Fob Programming ............19

▫ General Information .....................19

䡵 VEHICLE SECURITY ALARM ...............19

▫ Rearming Of The System ..................20

▫ To Arm The System ......................20

▫ To Disarm The System ....................21

▫ Security System Manual Override ............21

䡵 ILLUMINATED APPROACH ................21

䡵 REMOTE KEYLESS ENTRY .................22

▫ Remote Unlock The Doors .................23

▫ To Lock The Doors.......................24

▫ Sound Horn With Remote Key Lock ..........24

▫ Using The Panic Alarm ...................24

▫ Programming Additional Key Fobs ...........25

▫ Key Fob Battery Replacement ..............25

▫ General Information .....................28

䡵 REMOTE STARTING SYSTEM — IF EQUIPPED . . .28

▫ How To Use Remote Start..................28

2

▫ Remote Start Abort Message ...............29

▫ To Enter Remote Start Mode ................29

▫ To Exit Remote Start Mode Without Driving The

Vehicle ...............................30

▫ To Exit Remote Start Mode And Drive The

Vehicle ...............................30

▫ Remote Start Comfort Systems — If Equipped . . .30

▫ General Information .....................30

䡵 DOOR LOCKS ..........................31

▫ Manual Door Locks ......................31

▫ Power Door Locks — If Equipped ...........32

▫ Child-Protection Door Lock ................33

䡵 KEYLESS ENTER-N-GO — PASSIVE ENTRY .....34

▫ General Information .....................37

䡵 WINDOWS .............................38

▫ Power Windows — If Equipped .............38

▫ Wind Buffeting .........................40

䡵 OCCUPANT RESTRAINT SYSTEMS ...........41

▫ Occupant Restraint Systems Features .........41

▫ Important Safety Precautions ...............41

▫ Seat Belt Systems .......................42

▫ Supplemental Restraint Systems (SRS) .........55

▫ Child Restraints ........................67

▫ Transporting Pets .......................91

䡵 ENGINE BREAK-IN RECOMMENDATIONS .....91

▫ Diesel Engine ..........................92

䡵 SAFETY TIPS ...........................92

▫ Transporting Passengers ...................92

▫ Exhaust Gas ...........................93

▫ Safety Checks You Should Make Inside The

Vehicle ...............................93

▫ Periodic Safety Checks You Should Make Outside

The Vehicle ...........................96

10 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

A WORD ABOUT YOUR KEYS

Your vehicle uses either a key start ignition system or

keyless ignition system. The key start ignition system

consists of a either a Wireless Ignition Node (WIN) system,

or a Keyless Push Button Ignition system.

Wireless Ignition Node (WIN) And Key Fob — If

Equipped

The Wireless Ignition Node (WIN) operates similar to an

ignition switch. It has four operating positions, three with

detents and one that is spring-loaded. The detent positions

are OFF, ACC, and ON/RUN. The START position is a

spring-loaded momentary contact position. When released

from the START position, the switch automatically returns

to the ON/RUN position.

Wireless Ignition Switch

1—OFF

2 — ACC (Accessory)

3 — ON/RUN

4 — START

2

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 11

Wireless Ignition Node (WIN) Key Fob

The key fob operates the ignition switch. Insert the square

end of the key fob into the ignition switch located on the

instrument panel and rotate to the desired position. The

WIN key fob also contains an emergency key which is

stored in the rear of the key fob.

Keyless Push Button Ignition And Key Fob — If

Equipped

This feature allows the driver to operate the ignition switch

with the push of a button as long as the Remote Keyless

Entry key fob is in the passenger compartment.

The Keyless Push Button Ignition has four operating

positions; three of which are labeled and will illuminate

when in position. The three positions are OFF, ACC, and

ON/RUN. The fourth position is START, during start RUN

will illuminate.

NOTE: In case the ignition switch does not change with

the push of a button, the key fob may have a low or dead

battery. In this situation, a back up method can be used to

operate the ignition switch. Put the nose side (side opposite

of the emergency key) of the key fob against the ENGINE

START/STOP button, with your foot applied on the brake

pedal, and push to operate the ignition switch.

Wireless Ignition Node (WIN) Key Fob

12 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

Keyless Push Button Ignition Key Fob

The keyless push button ignition key fob allows the driver

to operate the ignition switch with the push of a button, as

long as the key fob is in the passenger compartment. It also

contains an emergency key which is stored in the rear of

the key fob.

Keyless Push Button Ignition

1 — OFF

2 — ACC (Accessory)

3 — ON/RUN

Keyless Push Button Ignition Key Fob

2

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 13

Emergency Key Removal

The emergency key allows for entry into the vehicle should

the battery in the vehicle or the key fob go dead. You can

keep the emergency key with you when valet parking.

To remove the emergency key, slide the mechanical latch at

the top of the key fob sideways with your thumb and then

pull the key out with your other hand.

NOTE: When using the emergency key to gain access to

your vehicle, be aware that the security alarm may be

triggered. Insert the key fob into the ignition and place the

ignition in the ON/RUN mode to disarm the security

system.

WIN Key Fob

14 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

NOTE: You can insert the double-sided emergency key

into the door lock cylinder with either side up.

Removing Key Fob From The (WIN) Ignition

Place the gear selector in PARK (if equipped with an

automatic transmission). Turn the key fob to the OFF

position and then remove the key fob.

Keyless Push Button Key Fob

Key Fob With Remote Keyless Entry (WIN)

2

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 15

NOTE:

• The power window switches, radio, power sunroof (if

equipped), and power outlets will remain active for up

to 10 minutes after the ignition switch is turned to the

OFF position. Opening either front door will cancel this

feature. Refer to “Uconnect Settings” in “Understanding

Your Instrument Panel” for further information.

• For vehicles not equipped with a touchscreen radio,

refer to “Instrument Cluster Display⬙ in “Understanding

Your Instrument Panel” for further information.

• For vehicles equipped with a touchscreen radio, refer to

“Uconnect Settings” in “Understanding Your Instrument

Panel” for further information.

WARNING!

• Before exiting a vehicle, always shift the automatic

transmission into PARK or the manual transmission

into REVERSE, apply the parking brake, turn the

vehicle OFF, remove the key fobs from the vehicle,

and lock all doors. If equipped with Keyless Enter-

N-Go, always make sure the keyless ignition node is

in the OFF mode, remove the key fob from the

vehicle and lock the vehicle.

(Continued)

WARNING! (Continued)

• Never leave children alone in a vehicle, or with

access to an unlocked vehicle. Leaving children in a

vehicle unattended is dangerous for a number of

reasons. A child or others could be seriously or

fatally injured. Children should be warned not to

touch the parking brake, brake pedal or the gear

selector.

• Allowing children to be in a vehicle unattended is

dangerous for a number of reasons. A child or others

could be seriously or fatally injured. Children

should be warned not to touch the parking brake,

brake pedal or gear selector.

• Do not leave the key fob in or near the vehicle, or in

a location accessible to children, and do not leave the

ignition of a vehicle equipped with Keyless Enter-

N-Go in the ACC or ON/RUN mode. A child could

operate power windows, other controls, or move the

vehicle.

• Do not leave children or animals inside parked

vehicles in hot weather. Interior heat build-up may

cause serious injury or death.

16 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

CAUTION!

• If your vehicle battery becomes low or dead, your

key fobs will become locked in the ignition.

• Do not attempt to remove the key fobs while in this

condition, damage could occur to the key fobs or

ignition module. Only remove the emergency key for

locking and unlocking the doors.

• Leave the key fob in the ignition and either:

• Jump Start the vehicle.

• Charge the battery.

CAUTION!

An unlocked vehicle is an invitation. Always remove

the key from the ignition and lock all doors when

leaving the vehicle unattended.

Key-In-Ignition Reminder

Opening the driver’s door when the key fob is in the

ignition and the ignition switch position is OFF or ACC, a

chime will sound to remind you to remove the key fob.

NOTE:

• ⬙Keyed⬙ Ignition systems will chime in OFF or ACC

when the driver door is open.

• “Keyless⬙ Ignition systems will chime in ACC or RUN

when the driver door is open.

• The instrument cluster display will display “Key In

Ignition.”

General Information

The following regulatory statement applies to all Radio

Frequency (RF) devices equipped in this vehicle:

This device complies with Part 15 of the FCC Rules and

with Industry Canada license-exempt RSS standard(s).

Operation is subject to the following two conditions:

1. This device may not cause harmful interference, and

2. This device must accept any interference received, in-

cluding interference that may cause undesired opera-

tion.

NOTE: Changes or modifications not expressly approved

by the party responsible for compliance could void the

user’s authority to operate the equipment.

2

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 17

SENTRY KEY

The Sentry Key Immobilizer System prevents unauthor-

ized vehicle operation by disabling the engine. The system

does not need to be armed or activated. Operation is

automatic, regardless of whether the vehicle is locked or

unlocked.

The system uses a key fob, an Ignition Node Module,

Keyless Push Button Ignition and a RF receiver to prevent

unauthorized vehicle operation. Therefore, only key fobs

that are programmed to the vehicle can be used to start and

operate the vehicle. The system will not allow the engine to

crank if an invalid key fob is used to start and operate the

vehicle. The system will shut the engine off in two seconds

if an invalid key fob is used to start the engine.

NOTE: A key fob that has not been programmed is also

considered an invalid key.

During normal operation, after placing the keyless ignition

in the ON/RUN position, the vehicle security light will

turn on for three seconds for a bulb check. If the light

remains on after the bulb check, it indicates that there is a

problem with the electronics. In addition, if the light begins

to flash after the bulb check, it indicates that someone used

an invalid key fob to try to start the engine. Either of these

conditions will result in the engine being shut off after two

seconds.

If the vehicle security light turns on during normal vehicle

operation (vehicle running for longer than 10 seconds), it

indicates that there is a fault in the electronics. Should this

occur, have the vehicle serviced as soon as possible by an

authorized dealer.

CAUTION!

The Sentry Key Immobilizer system is not compatible

with some aftermarket remote starting systems. Use of

these systems may result in vehicle starting problems

and loss of security protection.

All of the key fobs provided with your new vehicle have

been programmed to the vehicle electronics.

18 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

Page is loading ...

RAM Commercial Chassis Cab 2017 Owner's manual

RAM Commercial Chassis Cab 2017 Owner's manual

Other documents