Cres Cor H137SUA12CDJ1 Operating instructions

Cres Cor
Brand
Cres Cor
Model
H137SUA12CDJ1
Type
Operating instructions
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
5925 Heisley Road • Mentor, OH 44060-1833
Insulated
Hot Cabinet
FL-2251-J
Rev. 3 (3/07) Page 1 of 5
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
ELECTRICAL SPECIFICATIONS:
Model No. Volts Watts Amps Hertz Phase NEMA
H137UA12CDJ1
H137SUA12CDJ1
H137UA9CDJ1
H137SUA9CDJ1
H1381834CDJ1
H138N1834CDJ1
H138S1834CDJ1
100 1400 14 50/60 1 5-15P
H137UA12CDJ2
H137SUA12CDJ2
H1381834CDJ2
H138S1834CDJ2
208 2000 9.6 50/60 1 6-16P
H137UA9CDJ2
H137SUA9CDJ2
208 1500 7.2 50/60 1 6-15P
H137SUA5CDJ1
H137SUA6CDJ1
H138S1816CDJ1
100 1042 10.4 50/60 1 5-15P
H137SUA5CDJ2
H137SUA6CDJ2
H138S1816CDJ2
208 1000 4.8 50/60 1 6-15P
NOTE: The above model numbers are basic models. They may be followed by letters: M
L, or ending with S.
5925 Heisley Road • Mentor, OH 44060-1833
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
Insulated
Hot Cabinet
FL-2251-J
Rev. 3 (3/07) Page 2 of 5
HOW TO INSTALL UNIT:
Place cabinet on level fl oor.
Place cabinet in a well ventilated area.
Plug cord end into proper wall outlet.
1.
2.
3.
Turn the POWER switch on. The yellow light will
turn on.
Turn thermostat to #10.
Let unit operate for one hour.
Turn unit off and let cool.
Wipe inside clean with detergent and hot water.
1.
2.
3.
4.
5.
INITIAL OPERATION:
(For fi rst-time operation only):
NOTE: A new oven needs to “burn off” manufacturing
oils and excess adhesive before its fi rst use.
Do NOT load food into oven until this has
been done!
HOW TO START UNIT:
Turn the POWER switch on. The yellow light will
turn on.
Turn the thermostat to #6½.
Preheat cabinet for one (1) hour.
Put food into cabinet.
Turn thermostat to desired setting and close door.
No. 8 setting = approx. 85°C / 185°F
No.6 setting = approx. 71°C / 160°F
No.4 setting = approx. 54°C / 130°F
Proper food holding temperature is 60°C / 140°F or higher.
1.
2.
3.
4.
5.
TO TURN OFF UNIT:
Turn the POWER switch off. The yellow light will go out.
NOTE: The optional digital thermometer display
fl ashes when temperature in center of cabinet
is below 60°C (140°F) or above 121°C
(250°F). Call the factory if you need different
settings.
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
5925 Heisley Road • Mentor, OH 44060-1833
Insulated
Hot Cabinet
FL-2251-J
Rev. 3 (3/07) Page 3 of 5
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Cleaning hints:
Wipe up spills as soon as possible.
Clean cabinet regularly to avoid heavy dirt build-up.
Make a test spot with cleaner.
Follow manufacturer’s directions on cleaner.
Do not mix cleaners.
Avoid drips and splashes.
1.
2.
3.
4.
5.
6.
BEFORE CLEANING CABINET:
Allow the cabinet to cool.
Do NOT use abrasives or harsh chemicals.
Is your cabinet aluminum or stainless steel
construction? Be sure your cleaner is suitable
for that material.
Note: Stainless Steel cabinets hae an “S” in
their model numbers.
1.
2.
HOW TO CLEAN THE UNIT:
Soil Cleaner Method
Dirt
Mild Detergent* and hot water, or
mild abrasive cleaner.
1. Wipe with soft, damp cloth.
2. Rinse with hot water.
3. Wipe Dry.
Steam (no strong alkaline additive)
1. Rinse after steam cleaning.
2. Wipe Dry
Fingerprints, grease, oil
Mild abrasive cleaner.
Oily or waxy cleaner.
Apply with soft, clean cloth.
Chemical oven cleaner.
Follow oven cleaner manufacturer’s
instructions
Water Spots Mild abrasive cleaner.
1. Apply with soft, clean cloth.
2. Wipe with damp cloth.
*Mild detergent includes soaps and non-abrasive cleaners.
TROUBLE-SHOOTING CHART:
FAILURE: POSSIBLE CAUSE:
1. Yellow light at switch does NOT light.
1a. Circuit breaker/fuse to wall outlet is blown
1b. Cord is unplugged from wall outlet.
1c. Switch is “OFF.”
2. Unit does not heat.
2a. Thermostat set too low or is “OFF.”
2b. Switch is “OFF.”
3. Unit gets too hot or won’t shut off. 3a. Defective electrical parts.
UNPLUG UNIT FROM WALL OUTLET
4. Blower does not work or makes noise. 4a. Defective blower
5925 Heisley Road • Mentor, OH 44060-1833
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
Insulated
Hot Cabinet
FL-2251-J
Rev. 3 (3/07) Page 4 of 5
PART DESCRIPTION 100V 208V
Blower Kit 0769-005-K 0769-006-K1
Heater Kit (1042/1000W) 0811-265 0811-074-02
(1333/1500W) 0811-268 0811-266
(2000W) 0811-269
Thermometer – digital, °C 5238-034-K1 5238-034-K1
Transformer (used with digital thermometer) 0769-159 0769-159
Thermostat 0848-062-K 0848-062-K
Power Cord 0810-029-06 0810-039-07
Power Switch 0808-116 0808-116
Power Light 0766-094 0766-095
Vent Fan 0769-165 0769-174
Terminal Block 0852-091 0852-091
DESCRIPTION
Caster, Swivel, with Brake 0569-306-B
Caster, Swivel 0569-306
Door Latch 1006-122-01-K
Door Strike 1006-122-02-K
Corner Bumper Kit 1056-002-K
REPLACEMENT PARTS:
PART DESCRIPTION
H137UA12CDJ
H1381834CDJ
H137SUA12CDJ
H137SUA6CDJ
H138S1834CDJ
H138S1816CDJ
H138N834CDJ H137UA9CDJ H137SUA9CDJ
H137SUA5CDJ
Door Hinge 0519-087
0519-074 0519-087 0519-087 0519-074
0519-074
Door Gasket 0861-235
0861-185 0861-263 0861-236 0861-182
0861-250
Door Assembly complete 1221-524
1221-525 1221-554 1221-527 1221-526
1221-545
Power Unit complete 100V 0675-002-DC
0675-002-DC 0675-066-DC 0675-002-DC 0675-002-DC
0675-002-DC
Power Unit complete 208V 0675-005-DC
0675-005-DC - 0675-005-DC 0675-005-DC
0675-005-DC
Push Handle, full ht. cabinets 1087-101
1087-101 1087-115-K 1087-101 1087-101
-
Interior Insert – H137 Series 0621-281
0621-281 - 0621-281 0621-281
0621-281
Rack Insert – H138 Series 1103-103
1103-103 1103-107 - -
-
CABINET REPLACEMENT PARTS:
REPLACEMENT PARTS:
OPERATING and MAINTENANCE INSTRUCTIONS
Models: H137...CDJ & H13818...CDJ Series Hot Cabinets (Aluminum)
H137S...CDJ & H138S18...CDJ Series Hot Cabinets (Stainless)
5925 Heisley Road • Mentor, OH 44060-1833
Insulated
Hot Cabinet
FL-2251-J
Rev. 3 (3/07) Page 5 of 5
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
WIRING DIAGRAM
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5

Cres Cor H137SUA12CDJ1 Operating instructions

Cres Cor
Brand
Cres Cor
Model
H137SUA12CDJ1
Type
Operating instructions
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers