IllustrIllustr
IllustrIllustr
Illustr
aa
aa
a
ted Pted P
ted Pted P
ted P
arar
arar
ar
ts Mants Man
ts Mants Man
ts Man
ualual
ualual
ual
Model Number:
TPE-260PF
PORTABLE EDGER
P/N 40814
Rev 000
Date 9-4-07
Nikko Tanaka Engineering U.S.A.,Ltd.• 1028 4
th
Street SW, Bldg B • Auburn, WA 98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212
www.tanakapowerequipment.com [email protected]
www.tanakapowerequipment.com
PARTS INFORMATION
Page 1
TPE-260PF
CYLINDER, PISTON, CRANKSHAFT, IGNITION • FIGURE 1
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
1-1 1570168090 CAP,SPARK PLUG ASS'Y 1
1-2 01802233200 PLUG,SPARK 1
1-6 0010760090 CYLINDER SET 1 Includes gasket
1-7 99461050184 BOLT,HEX,5X18,S 4
1-9 0170735020 GASKET,CYLINDER 1
1-11 04101601200 RING,PISTON 2
1-12 0300750090 PISTON SET 1 Includes rings and circlips
1-13 03901620200 CIRCLIP,PISTON PIN 2
1-14 0370704520 PIN,PISTON 1
1-16 0460735082 CRANKSHAFT 1
1-17 99962081225 BEARING,NEEDLE,F-810 1
1-40 1780168080 CORD,STOP 1
1-41 2740168080 CORD,EARTH 1
1-46 99464040184 BOLT,HEX 4x18WS 2
1-47 1820186A201 WASHER,SPECIAL 2
1-50 1672101290 COIL,INGITION 1
www.tanakapowerequipment.com
PARTS INFORMATION
Page 2
TPE-260PF
CRANKCASE, FLYWHEEL, PULLEY • FIGURE 2
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
2-19 33000200230 SHIM,12.2X19X.20 1
2-19 33000200240 SHIM,12.2X19X.30 1
2-31 0720304592 CRANKCASE ASSY 1 Includes bearings, seals and gasket
2-32 99966122206 SEAL,OIL,#TC12227 2
2-33 99961600115 BEARING,BALL,6001 C3 2
2-34 0900735022 GASKET,CRANKCASE 1
2-36 99461050164 BOLT,HEX,5X16,S 4
2-51 1552101281 FLYWHEEL 1
2-52 99201080011 WASHER,8 1
2-54 99101080011 NUT,8 1
www.tanakapowerequipment.com
PARTS INFORMATION
Page 3
TPE-260PF
FUEL SYSTEM • FIGURE 3
120
www.tanakapowerequipment.com
PARTS INFORMATION
Page 4
TPE-260PF
FUEL SYSTEM • FIGURE 3
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
3-80 4030702021 GASKET,INLET MANIFOLD 1
3-81 4040702091 INSULATOR SET 1 Includes gasket
3-82 99464050255 BOLT,HEX,5x25WS 2
3-85 4020656A200 GASKET 1
3-86 5280652N22 PLATE,CHOKE,2.0 1
3-88 4230652N80 BODY,AIR CLEANER 1
3-89 4460652N20 CLEANER,ELEMENT 1
3-90 4520304690 COVER,AIR CLEANER ASSY 1
3-91 4500702480 BOLT,CLEANER COVER 1
3-94 99011050552 SCREW,5X55 2
3-95 99210050012 WASHER,S,5 2
3-96 99200050011 WASHER,SMALL,5 2
3-98 4550304590 CARBURETOR SET 1 Includes gasket
3-99 5230652N20 LEVER,CHOKE 1
3-100 5910735F20 TANK,FUEL,EVAPO 1
3-101 9400735020 STAND 1
3-109 6590430020 COLLAR,C 3
3-110 53432710200 GROMMET,FUEL PIPE 1
3-111 70003005062 PIPE,FUEL,3X5X62 1
3-112 6750404280 FILTER,FUEL 1
3-113 68000731201 CLIP 6.3 1
3-114 2230162V900 PIPE,FUEL,ASS'Y 1
3-115 99464050255 BOLT,HEX,5x25WS 1
3-116 99463050204 BOLT,HEX 5X20 2
3-117 5950300290 CAP,TANK (BLACK/RED) 1
3-118 99075040154 SCREW,TAPPING,4X15 1
3-119 99201040011 WASHER,4 1
3-120 4100304690
A
IR CLEANER ASS'Y 1
www.tanakapowerequipment.com
PARTS INFORMATION
Page 5
TPE-260PF
CLUTCH, MUFFLER, ENGINE COVER • FIGURE 4
www.tanakapowerequipment.com
PARTS INFORMATION
Page 6
TPE-260PF
CLUTCH, MUFFLER, ENGINE COVER • FIGURE 4
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
4-1 0160750020 COVER,CYLINDER 1
4-4 99463050164 BOLT,HEX,5X16,PS 2
4-5 99051060653 BOLT,HEX,6x65 2
4-6 99201060011 WASHER,6 2
4-7 7060750080 MUFFLER 1
4-8 7510725020 GASKET,MUFFLER 1
4-10 7340725090 TAIL PIPE 1
4-11 99436040081 SCREW,4X18WS 2
4-13 7320725020 ARRESTER,SPARK 1
4-16 1330750020 SHIELD,HEAT 1
4-17 7380750020 COVER,MUFFLER 1
4-24 99464040185 BOLT,HEX,4x18WS 2
4-30 2570304520 PROTECTOR,SPARK PLUG 1
4-31 35902103200 WASHER,CLUTCH,B 2
4-32 29001620800 SHOE,CLUTCH 2
4-33 3420630B200 SPRING,CLUTCH 1
4-34 3480630A20 PLATE,CLUTCH 2
4-35 3570075T200 BOLT,STEP 2
4-36 99463050204 BOLT,HEX 5X20 3
4-38 99205080030 WASHER,8 2
4-39 99072045164 SCREW,TAPPING,4.5X16 1
www.tanakapowerequipment.com
PARTS INFORMATION
Page 7
TPE-260PF
RECOIL STARTER • FIGURE 5
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
5-0 7620304590 STARTER ASS'Y 1
5-1 7720304580 BODY,STARTER 1
5-2 7740304520 PULLEY,STARTER 1
5-3 7790304520 SPRING,RECOIL 1
5-4 7770304520 ARM,SWING 1
5-5 8390304520 SCREW,SET 1
5-6 7710304520 STAY,PULLEY 1
5-7 7830304520 ROPE,STARTER 1
5-8 7850304520 HANDLE,STARTER 1
5-22 7980304520 PULLEY,STARTER 1
5-24 99464040185 BOLT,HEX,4x18WS 2
www.tanakapowerequipment.com
PARTS INFORMATION
Page 8
TPE-260PF
CARBURETOR • FIGURE 6
0
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
6-0 4550304590 CARBURETOR SET 1 Includes gasket
6-2 5752515380 BODY,PUMP 1
6-3 4422515180 PUMP,PRIMING 1
6-4 4762515120 COVER,DIAPHRAGM 1
6-5 44725108200 BULB,PRIMING 1
6-6 ~ ~ ~ DIAPHRAGM,METERING 1 Included in Carb Kit #650.25124.90
6-7 ~ ~ ~ GASKET,DIAPHRAGM 1 (items not available individually)
6-8 ~ ~ ~ DIAPHRAGM,PUMP 1
6-9 ~ ~ ~ GASKET,PUMP 1
6-10 5992001W38 JET,MAIN LONG #38 1
6-11 55025100200 O-RING 1
6-12 48925100200 RING,STOP 1
6-13 53925120200 SWIVEL 1
6-15 51425100200 SCREW,THROTTLE SET 2
6-16 54425164200 STAY,ADJUST,CABLE 1
6-17 99101060013 NUT,6 1
6-18 61425137200 ADJUSTER,CABLE 1
6-19 4310634C200 GASKET,CLEANER 1
6-20 5482515120 SCREW,SET 4
6-21 5492516520 WASHER,THRUST 1
6-201 57825007200 SCREEN,INLET 1
www.tanakapowerequipment.com
PARTS INFORMATION
Page 9
TPE-260PF
FAN CASE • FIGURE 7
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
7-1 2890750380 SHAFT,CLUTCH 1
7-5 5990098021 CUSHION,RUBBER 1
7-6 99051050163 BOLT,HEX,5X16 1
7-8 99461050254 BOLT,HEX HOLE,5X25S 1
7-11 1120304580 CASE,FAN 1
7-15 3600099620 PIPE HOLDER 1
7-26 99201050061 WASHER,5 1
7-27 3243735020 WASHER,GEAR CASE 1
7-28 3610099020 FITTING,METAL 1
www.tanakapowerequipment.com
PARTS INFORMATION
Page 10
TPE-260PF
HANDLE, SHAFT & THROTTLE • FIGURE 8
www.tanakapowerequipment.com
PARTS INFORMATION
Page 11
TPE-260PF
HANDLE, SHAFT & THROTTLE • FIGURE 8
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
8-1 3533729090 SET,DRIVE SHAFT PIPE 1
8-2 3413729020 PIPE,DRIVE SHAFT 1
8-3 3443729020 SHAFT,FLEXIBLE 1
8-4 3503729020 LINER,FLEXIBLE 1
8-5 3203729020 SPACER 1
8-9 8853739480 WIRE,THROTTLE 1
8-20 5003331620 HANDLE 1
8-21 50633316200 BRACKET,HANDLE A 1
8-22 99023060401 BOLT,P,6X40 2
8-23 99101060011 NUT,6 2
8-24 99201060011 WASHER,6 2
8-25 8703728690 LEVER,THROTTLE ASS'Y 1
8-26 1623710120 SWITCH,STOP 1
8-27 99342030081 SCREW,TAPPING,3X8 3
8-28 25937101200 BASE,STOP SWITCH 1
8-29 26237101200 SPRING,STOP SWITCH 1
8-30 17737101200 TERMINAL,EARTH B 1
8-31 17637101200 TERMINAL,EARTH A 1
8-32 3153334020 NUT,SPECIAL 5MM 1
8-33 99355060001 RING,STOP,6 1
8-34 83237101200 SPRING,RETURN 1
8-35 8803728620 ARM,THROTTLE 1
8-36 99431050201 SCREW,5X20 2
8-37 85337101200 SHAFT,LOCK BUTTON 1
8-38 95837101200 SPRING,LOCK,BUTTON 1
8-39 95637101200 BUTTON,LOCK 1
8-40 2603331720 BODY,STOP BUTTON,B 1
8-41 1783739480 CORD,STOP 430mm 2
8-47 1641001900 TUBE,PROTECTION,10X190 1
8-49 50437300200 GRIP,SHAFT 1
www.tanakapowerequipment.com
PARTS INFORMATION
Page 12
TPE-260PF
GEAR CASE, SAFETY GUARD, WHEEL, BLADE • FIGURE 9
www.tanakapowerequipment.com
PARTS INFORMATION
Page 13
TPE-260PF
GEAR CASE, SAFETY GUARD, WHEEL, BLADE • FIGURE 9
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
9-30 99106080001 NUT,8/L.H. 1
9-31 99201080011 WASHER,8 1
9-32 3113729020 CAP,CUTTER HOLDER 1
9-33 4353729020 BLADE,TPE-250 1
9-34 3103729022 HOLDER,CUTTER 1
9-40 3003729090 CASE,GEAR,ASSY 1
9-41 99351032002 RING,STOP,C-32 IN 1
9-42 99961620103 BEARING,BALL #6201D 1
9-43 3043729020 SHAFT,GEAR 1
9-44 99961628000 BEARING,BALL,#628 1
9-45 3013729000 SET,GEAR/PINION 1
9-46 99423080100 BOLT,8X10 1
9-47 32433410201 WASHER,GEAR CASE 1
9-48 3003729021 CASE,GEAR 1
9-49 99051050103 BOLT,HEX.HOLE,5X10 1
9-50 99461050254 BOLT,HEX HOLE,5X25S 1
9-53 99961609000 BEARING,BALL,#609 1
9-54 99961609002 BEARING,BALL,#609Z 1
9-55 99350009002 RING,STOP,C9 1
9-56 99351024002 RING,STOP,C-24,IN 1
9-60 2103729080 HANDLE,LOCK 1
9-71 99210080012 WASHER,S,8 1
9-72 99201080011 WASHER,8 1
9-73 1203729480 WHEEL,TPE,6" 1
9-74 0493729420 COLLAR 1
9-75 4413729022 GUARD,BLADE 1
9-76 3143729420 BOLT,SPECIAL 1
9-77 4813729420 STAY,WHEEL 1
9-78 99210060062 WASHER,S,6 2
9-79 99053060153 BOLT,HEX,6X15 2
9-80 4423729021 BRACKET,COVER 1
9-81 4453729420 HOLDER,BLADE GUARD 1
9-82 99210060062 WASHER,S,6 2
9-83 99053060353 HEX, HOLE BOLT 6X35 2
9-88 4963729020 HOLDER,MUD FLAP 1
9-89 5003729020 FLAP,MUD 1
9-90 99461050124 BOLT,HEX,5X12S 3
www.tanakapowerequipment.com
PARTS INFORMATION
Page 14
TPE-260PF
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
10-1 81320000200 WRENCH,HEX,4 1
10-2 8292000080 SPANNER,COMBI,13X19 1
TOOLS • FIGURE 10
www.tanakapowerequipment.com
PARTS INFORMATION
Page 15
TPE-260PF
DECALS • FIGURE 11
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
11-1 9060750020 DECAL,PUREFIRE 1
11-2 9290750320 DECAL,TPE-260PF 1
11-3 91505015200 DECAL,SYMBOL 1
11-4 92337400200 DECAL,LEVEL 1
11-6 91933111201 DECAL,CAUTION 1
11-7 9293810020 DECAL,SYMBOL,PF 1
11-16 9193728620 DECAL,CAUTION 1
11-17 9203246620 DECAL,CAUTION 1
Nikko Tanaka Engineering U.S.A. ,Ltd.• 1028 4
th
Street SW, Bldg B • Auburn, WA 98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212
Model & Serial: TPE-250
All Units
Reason: The newer style of guard assembly is now available as an assembly. This
assembly can be used to update the older style edgers, thus improving ease of
height adjustment.
All components depicted below are included. Individual part numbers can be
found in the parts catalog for the TPE-2510, TPE-270PF or TPE-270PN.
Gear cases are common between all models, so it is not necessary to replace
the gear case when updating an older model to the newer style guard.
Part Number Changes:
Old Part # New Part # Description Remarks
441-37294-00 Safety Guard Assembly
TECHNICAL SERVICE BULLETIN NUMBER PI 3113
Date: September 2000
/