Murray G4618000 User manual

Brand: Murray

Model: G4618000

Category: Lawnmowers

Type: User manual

This manual is also suitable for

F4315-000

Model G461 8000

339587A O_

OWNER'S INFORMATION

Record the followinginformation about yourunit sothat you willbe able to provide it in case of loss or theft.

DATE PURCHASED:

STORE WHERE PURCHASED: ADDRESS

CITY

MODEL NO: SERIAL NO:

STATE

TELEPHONE

WAIlU NTY

dURRAY, INC. equipment limited warranty policy.

Whan warranty repair is justified, MURRAY, INC. will welcome such repairs by any of its Authorized Service Centers.

MUR RAY, INC. warrants every new MURRAY, INC. product ("NEW UNIT") purchased for noncommercia] useagainst defects in mateda] and

workmanship in any part or parts ofthe NEW UNIT (except for blades, shear pins, belts, grass catcher bags, blade hubs, impellers,

woodruff keys, pulleys, tires, shear bolts, due to the nature of thetr lunctlo ns are warranted for a period of 90 days, as they are subject

to normal wear and abuse), provided the purchaser returnsthe defective partor ports toone ofMURRAY INC.'s Authorized Service Centers

within a period of two (2) years from the date of purchase. NEW UNITS purchased for commercial use (including without limitation, NEW

UNITS purchased for rental sod commercial landscaping) are warranted inthe same manner and tothe same extent EXCEPT such NEW

UNITS are warranted for a period of thirty (30) days fromthe date of purchase MURRAY, INC.'s liability and the purchaser's soleand exclusive

remedy is limited to the repfecament of the part orparts found to be dafectJve. All transportation charges on parts submitted for replacement

under this warranty shall be paid by the purchaser.

This limited warranty applies only with respect to defects in material and workmanship under normal and proper use of the NEW UNIT in its

unmodified condition. This _imited warranty does not extend to the replacement ofparts which are notdefective, but where normal usage has

exhausted the life of the part M URRAY, INC. shall have no obiigatlen hereunder to make repairs orcause replacements necessitated in whole

or inpart by _e faultor negligence ofthe uset, orimproper orunauthorized use, oruse in amanner forwhich the NEW UNIT was not designed,

or by causes external to the equipment, components or parts.

EACH ENGINE IS WARRANTED BY THEIR RESPECTIVE MANUFACTURER, AND MURRAY, INC. ASSUMES NO RESPONSIBIUTY

WITH RESPECT TO SUCH ITEMS.

Warranty service can be arranged for by contacting either a MURRAY, INC. Authorized Service Center or MURRAY, INC. Customer Service

Department, PO Box 8000, Jackson, TN 38.308. Warranty service can only be performed by a MURRAY, INC. Authorized Service Center. At

the time of any WarTantyservice request, evidence mustbe presented as tothe date of the sale ofthe NEW UNIT, together with the unitmodel

number and the unitsedal nutuber contained on the equipment. Any charges coved ngservice calls and/or tran sporfationof the product to and

from the place of inspectJan will be borne by the Purchaser. Any damage incurred during transportation will be borne by the Purchaser.

MURRAY, INC.'S UMITED WARRANTY EXTENDS ONLY TO THE PURCHASER AND IS NOT TRANSFERABLE. ALL CLAIMS UNDER

THIS WARRANTY MUST ORIGINATE WITH THE ORIGINAL PURCHASER AND THE PURCHASER WILL INDEMNIFY AND HOLD

MURRAY INC. HARMLESS FROM ANY CLAIMS FOR BREACH OF WARRANTY ASSERTED AGAINST MURRAY, INC. BY ANY

PERSON OWNING THE NEW UNIT AFTER RESALE THEREOF BY THE PURCHASER.

THE EXPRESS WARRANTY SET FORTH IN THIS AGREEMENT IS IN LIEU OF ALL OTHER WARRANTIES EXPRESSED OR IMPUED

INCLUDING WITHOUT LIMITATION, ANY WARRANTIES OF MERCHANTABILITY OR FITNESS FOR ANY PARTICULAR PURPOSE

AND ALL SUCH OTHER WARRANTIES ARE HEREBY DISCLAIMED AND EXCLUDED BY MURRAY, INC.. IN NO EVENT SHALL

MURRAY, INC. BE UABLE FOR ANY DAMAGES WHATSOEVER ARISING OUT OF THE USE OR OPERATION OF THE EQUIPMENT

(INCLUDING, WITHOUT RESTRICTION THE GENERALITY OF THE FOREGOING, ANY PERSONAL OR PROPERTY DAMAGES OR

DAMAGES FOR LOSS OF USE OR PROFIT).

MURRAY, INC. does not authorize any person (whether natural or corporate) to assume for MURRAY, iNC. any obligation or liability in

connection with orwith respect to any part orparts of the NEW UNIT. The seller ordealer of any NEW UNIT manufactured by MURRAY, INC.

has no authority to make any representation or promises on behalf ofMURRAY, INC. or to modify the terms or limitationsof this warranty in

any way.

TO QUALIFY FOR THE ABOVE WARRANTY THIS CERTIFICATE AND YOUR RECEIPT MUST BE PRESENTED TO

YOUR AUTHORIZED SERVICE DEALER.

Date of Purchase Serial No. Where Purchased

MURRAY, INC.

PO Box 8000

Jackson, TN 38308

1-800-247-7464

TABLE OF €ONTENTS

WARRAN'[Y ........................................................................ 2

INTERNATIONAL SYMBOLS ............................................. 4

OWNER'S INFORMATION ................................................. 5

RESPONSIBILITY OF THE OWNER .................................. 5

SAFETY RULES .............................................................. 5-6

SAFE MOWING GUIDE ................................................... 7-9

STEPS TO FOLLOW ........................................................ 10

ASSEMBLY..................................................................11-14

OPERATION................................................................15-19

MAINTENANCE...........................................................20-26

ADJUSTMENTS...........................................................27-30

TROUBLESHOOTINGGUIDE.....................................31-32

STORAGE.........................................................................33

SLOPEGUIDE..................................................................34

Fill in and mail the registration card packed with the unit. For service other than covered in this manual, contact an authorized

service dealer. A nationwide parts and service organization has been established to provide locally available parts and service. A

list of authorized parts distributors has been included in the Repair Parts manual.

IS NOTE 1

ome tractor models may require different instructions for assembly and/or repair than shown in this manual. The

apalr Parts manual (supplied with tractor) will contain these instructionsif required on your model.

This lawn tractor Is equipped with an Internal combustion engine end should not be used on or near any

unimproved forest-covered, brush-covered, or grass-covered land unless the engine's exhaust system Is

equipped with s spark errester meeting applicable local or state laws (If any). If a spark arreeter Is used, It

should be maintained In effective working order by the operator.

In the State of California the above Is required by law (Secticn 4442 of the California Public Resources Code).

Other states may have similar laws. Federal laws apply on federal lands. A spark arrsster for the muffler Is

available through an Authorized Service Center

References throughout this manual concerning the right or left side are determined as you face forward while

seated in operator's seat.

Photographsand illustrationsin this manualmay notshow yourmodelbut are for reference.They are based on the latest

information.

California Proposition65 WARNING!

The engine exhaust from this product contains chemicals known to the State of

California to cause cancer, birth defects or other reproductive harm.

INTERNATIONAL SYMBOLS

IMPORTANT! These symbolsmay appear on yourunitor In literaturesuppliedwith the product. Learn and understand

their meaning.

ENGINE ENGINE ENGINE ENGINE STOP ON FAST SLOW CHOKE

START RUN STOP

O4L FUEL BAI"rERY LIGHTS/ LIGHTSOFF HOUR METER ALL- NEUTRAL FORWARD

pRESSURE LIGHTSON SYSTEMS-GO

REVERSE CLUTCH PARKING MOWER MOWER MOWER MOWER MOWER MOWER

BRAKE HEIGHT CUTTING CUTi'ING BLADE BLADE BLADE

HEIGHT RAISE HEIGHT CLUTCH ENGAGE DISENGAGE

LOWER

ARROW INCREASE DECREASE

,D(;])O

OFF

_4 AKE

• )

PARKING READOWNER'S/ HEARING CAUTION

BRAKE OPEEATOR'S PROTECTION

MANUAL

DANGERI KEEP DANGER! KEEP

HANO6 AND FEET HANDS AND FEET

AWAY AWAY

WARNING

THROWN OBJECTS. KEEP BYRTANDERS

AWAY. READ USERS INSTRUCTIONS BEFORE

OPERATING THIS MACHINE.

DO NOTUSE THIS

AREAAS A STEP

DANGER WARNING WARNING

DISCONNECT DO NOT MOWWHEN GO UPAND DOWN

SPARK PLUG BEFORE CHILDREN & OTHERS SLOPES NOT

SERVICING UNIT. AREAROUND ACROSS._ NOT

USE THB MACHtNE

ON SLOPES OFMORE

THAN 10_

WARNING

DO NOT TOUCH HOT SURFACE

MAX ig0N MAX±150N

WARNING

USE CAUTION WHEN CONNECTING OR

DISCONNECTING ACCESSORIES

SHIELD EYES

EXPLO_NE GASES

CAN CAUSE

BLINONESS OR

INJURY

NOSPARKS, FLAMES,

OR SMOKING

SULFURIC ACID CAN

CADSE BLINDNESS FLUSH EYES

OR SEVERE BURNS IMMEDIATELY WITH

WATER. GET

MEDICAL HELP FAST

OWNER'S INFORMATION

This Ownar's/Operatol's Manual isforseveral differentmodels. The instructionsare writtenfora personwithsome mechanical abiitly.

Lke mostseMca books, notall the stepsare described. Stops on howto loosenor tightenfasteners are steps anyone can follow with

some mechanical ability. Read and followthese instructionsbefore you use the unit.

Know your product: Ifyou understandthe unitand howthe unitoperates, you willget the bestperformance. As you reed this manual,

compare the illustrationstothe unit. Learnthe iocat ionand thefunctionof the controls.To help preventan accident,followthe operating

instructionsand the safety rules. Keep this manual for future reference.

IMPORTANT: Many units am notassembled and am sold in cartons, it isthe responsibilityofthe owner to make sure the assembly

instructionsinthis manual are exactly followed. Other unitsare purchased in an assembled condition. On assembled units,it isthe

responsibility of the owner to make sure the unit iscorrectly assembled. The owner must carefully check the unit according to the

instructionsin this manual before it isfirst used.

RESPONSIBILITY OF THE OWNER

The responsibilityof the owner Is to followthe instructions

below.

1. Carefullyreadandfollowtherubesforsafeoperation.

2. Followall theassemblyinstructions.

3. Inspecttheunit.

4, Makesuratheoparatoroftheunitknowshowtocorrectlyuse

allstandardandaccessoryequipment.

5. Operatetheunitonlywithguards,shields,andothersafety

items inplaceandworkingcorrectly.

6. Correctlyadjustthe unit,

•7. Servicethe unitonlywithauthorizedor approvedreplace-

meritparts.

8. Completeallmaintenanceontheunit.

EnvironmentalAwareness

• Do notfilltheengine'sfueltankcompletelyfull.

• Drainfuelforoff-seasonstorage.

• Useonlyunleadedgasoline.

• Servicetheaircleanerregularly.

• Changeoilregularly.Use30Woilinsummer.

• Tune-uptheengineregularly.

• Keepequipmentinefficientoper_ingcondition,

• Disposeofusedengineoilpmpedy.

SAFETY RULES

Safe Operation Practices for Riding Vehicles

As Recommended by American National Standards Institute

WARNING: This cuffing machine Is capable of amputating hands and feet and throwing objects. Failure to observe

the following safety Inatructlona could result In serious Injury or death to the operator or bystanders.

GENERAL OPERATION:

1. Reed, understand and follow aU instructions in the Owner's/Operator's Manual, on the machine, the engine and with any

attachments before starting.

2. Only allow responsible adultsfamiliar withthe instructionsto operate the machine.

3. Clear the area of objects such as rocks, toys,wire, etc. which could bepicked upand thrown by the blade.

4. Be sure the area isclear of other psople bafore mowing. Stop ths machine if anyone enters ths area.

5. Never carry passengers.

6. Disengagepowertothemoweroranyattachmentsbaforebackingup. Donotmowinreverseuniessabsclutelynecessary. Allays

lookdown and behind before and while backing.

7. Beawaraofthedirectionthemowerdischargas. Donotpointdischargefromthemoweratanyoneoratplaceswherepeopiemay

be. Do not operate the mower without either the entire grass bagger or the mower guard in place.

8. Slow down before turning.

9. Nevarieaveamschineunatlendedwiththeenginerunning. Alwaysdisengagetheblade(s),settheparkingbrake, stoptheengine

and remove the key before dismounting.

10. Disengagepowertoattachment(s)whentranspertingornotinuse. Disangaga the blade(s) when not mowing.

11. Stop the engine before removing the grass bagger or uncloggingthe chute.

12. Mow only in daylight or good artificiallight.

13. Do not operate the machine while under the influence of alcohol or drugs or when very tired.

14. Do not operate thismachine it youara takingdrugsorother medication whichcen cause drowsiness oraffect yourabilitytooperate

this machine.

15. Do not use this machine it you are mentally or physicallyunable to operate this machine safely.

16. Watch for traffic when operating near or crossing roadways.

17. Use extra caution when loading or unloading the machine when using a trailer or truckfor transporting.

18. Disengage all attachment clutches and shifl into Neutral before attemptingto start the engine (on gear drive models).

19. Disangageallattachmantclutchesbaforeattemptingtostarttheengine(onhydromodela).

20. Allaysw_arsafetyg_asses_r_neyeshie_dwh_ny_u_perateth_unitt_pr_tacty_ureyesfmmf_reign_bjectsthatcanbathr_wn

from the unit. Always wear eye pmtectldn when you make an adjustment or repair to the machine.

21. Use care when pulling loads or usingheavy equipment.

a. Use only approved drawbar hitch points.

b. Limit loads tothose you can safely control.

c. DOnot turn sharply. Use care when backing.

d. Use counterweights when suggested inthe Owner's/Operator's Manual.

SLOPE OPERATION:

Slopesand roughterrain are majorfactors relatedto lossofcontroland tip overaccidentswhich canresult Insevereinjury

or death. ALLslopesrequireextra caution, if you cannot backupthe elopeor Hyou feeluneasy onthe slope,do not mow

It. See the "Slope Guide" Inthe back ofthis bookto check for safeoperaticn.

1. Mow up and down slopes, not across.

2. Remove obstacles such as rocks, limbs, etc...

3. Watch for holes, ruts or bumps. Uneven terrain couldoverturn the machine. "Tall grass can hide obstacles."

4. Use slowspeed. Choose a low enough gear so that you will not have tostop or shiftwhile onthe slope (on gear drive models).

5. Use slow speed on slopes. Do not make sudden speed changes (on hydro models).

6. Followthe manufacturer's recommendations for wheel weights or counterweights to improve stability.

7. Use extra care with grass baggers or other attachments, they can change the stabilityof the machine.

8. Ksap afl movement on the slopes slow end gradual. Do not make suddon changes in speed or direction.

9. Avoid starting or stopping on a slope. Htires lose traction, disengage the blades and proceed slowly straight down the slope.

DO NOT

1. DO Ilot tum en slopes unless absolutely necessary, then only turn slowly and gradually downhill, ifpossible.

2. Donotmownsardmp-offs, ditchesorembankments. Awheelovertheedgeoranedgecavingincouldcauseasuddenoverturn

and an injuryor death.

3. Do nct mow on wet grass. Reduced trastlon could cause sliding.

4. Do nct tryto stabilize the machine by puttingyour foot on the ground.

5. Do not use a grass catcher or other rear mounted accessories on steep slopes (greater than 10 degrees).

CHILDREN:

Tragic accidents can occur If the operator is not alart to the presence of children. Children are often attracted to the machine

and the mowing actlvify. NEVER assume that children witl remain where you last saw them.

1. Ksap children out ofthe mowing area and inthe watchful care of an edult other than the operator.

2. Be alert and turnthe engine off it children enter the area.

3. Before and when backing, look behind and down for small children.

4. Never carry children or any passengers. They may fall off and be seriously injures or interfere with the safe operation of the

machine.

5. Never allow children to operate the machine. Instructchildren in the dangers of the machine.

6. Use extr_ care when approaching blind corners, shrubs,trees or other objects that may obscure vision.

SERVICE:

1. Use extra care when handling gasoline and other fuels. Fuels are flammable and the vapors are explosive.

e. Use only an approved container.

b. Never removethe gascap or add fuel withthe engine running. Allowthe engineto cool for several minutes before refueling.

Do not smoke.

c. Never refuel the machine indoors.

d. Never storethe machine withfuel inthe tank or fuel container inside where there is an open flame, suchas a water heater.

2. Never start or runthe engine inside a closed area.

3. Kaspaflnutsandboits, especiaily the blade attachment nuts tight. Frequentlycheckthebtade(a)forwearordamagesuchas

cracks and nicks. A blade that is bent or damaged must be immediately replaced with an original equipment blade(a) from an

authorized service dealer. For safety, replace the blade(s) every two years. Keep the equipment in good condition.

4. Nevertamperwiththesafetydevioes. Check their proper operatlon regutarly.

5. Toreducefirehazardskespthemachinefreeofgrass, leavasorotherdebrisbuild-up. Cleanupoilorfuelspills. Allowthemashine

to cool before storing.

6. Stop and inspect the equipment ifyour strike an object. Repair, if necessary, before restarting.

7. Never make adjustments or repairs with the engine running. The carburetor can be adjusted with the engine running. Do not

change the engine governor settings or over-speed the engine.

8. Grass begger components are subject towear, damage and deterioration,which could expose moving partsor allow objects to

bathrown. Forstorage, always make surethe grass bag isempty. Frequentlycheckcomponents and replace withmanufacturer's

recommended partswhen necessary.

9. Mower blade(s) are sharp and can cut. Wrap the blade(s) orwear gloves and use extracautionwhen servicingthem orthe mower

deck area.

10. Check the brake operation frequently. Adjust and service as required.

11. Wait for all movement to stop before servicing any part of the unit.

Look for thla symbol to Indicate important safety precautions. This symbol indicates: "Attention! Become Alert"

Your Safety Is At Rlak."

SAFE MOWING GUIDE

Each person that operates power equip-

ment must learn to use correct and safe

mowing procedures. To help you learn,

carefully read the followlng pages. Most

of the time the operator was not correctly

shown or did cot read the instructionson

theunitorinthe Ownar'siOperator'sManual

before using the unit. Also, some opera-

tots do not have enough experience. The

result is unsafe use, endangering the op-

erator, bystandersand the equipmant. An-

other result can be a poor appearance of

the area mowed.

Readthls book. Readtheinstructionson

the unit.Operatethemoweraccordingto

theSafe MowingGuide. Followalls_ety

ruios,cautionsorwarningsinthisbookand

onthe unit. Makesureanyonethatuses

the unitreadsthe instructionsand istold

howtosafelyoperatethemower.

The mower will give you good service and

durability, itoperatad innormalconditions.

Ifthe mower is not correctly serviced or is

used where the terrain is roughor unsuit-

able, product performance and safety will

be decreasad.

Correct clothingisan importantpartofsafe

mowing. Safety glasses will protect the

eyes from objectsdisoharged bythe mower.

Safety shoes with steel plates can protect

a footfrom injuryby the blade. For protec-

tion from objects discharged from the

mower, wear ck?.thingthat will cover the

arms and legs.

Before you start cuttingthe grass, practice

usingthe mower in a large open and level

area. Learn the locationofthe controls on

the mower. Know the purpose of the

controls and how they work. In an emer-

gancy, how fast you can stop the blade is

important. Learn howtocontrol the mower

at all times.

Many engines are startedby hand. When

youuse apullstart orrope start,place your

feet apart and away from the blade(s).

Holdthe ropehandle tight. Never wrap the

rope around yourarm orfingersfor a "Bet-

ter grip". To start the engine, follow the

instructionsonthe mower, inthis book and

inthe engine operating instructions.

For electric start engines, sit inthe seat to

startthe engine. The battary can be dan-

gerous. Follow the instructions on the

battery,the acid container, and inthisbook

when workingwiththe battery. Even small

batteries have enough voltagetocause an

injury. Always be careful.

The mower is designed to be operated by

one person. Never let another person ride

withyou on the unitor on any accessories.

A passenger will make the unit harder to

control, block the visibilityor distract the

operatorand isdangerousto the operator,

the passengerand the equipment+Without

a passenger seat, the passenger can fall

fromthe mower orcootactdangerous parts.

A mower isnot a toyfor showing off orfor

givingrides.

Never cutawet lawn. Wet grass can cause

an accident, affect mower performance

and can cause problems with future lawn

growth and appearance. Wet grass is

slipperyand can cause the mower to slip.

Someone can get injured by touching the

blade(s). Wet grass tends to clog the

mower, causing poor discharge. Cut wet

grass willcollectonthe lawn, retardingthe

growth of the grass. Also, getting the

mower wet will cause parts to rust and

decrease the lifeof the unit.

When you look over the lawn, remember

obstacles that cannot be removad, like

pipes, stumps or racks. Keep away from

these obstacles thatcan cause damage to

the mower or injury to the operator or a

person near the mower. Clear the areaof

rocks, toys, wire or other loose objects.

These itemscan damage themower orcan

be discharged by the mower blade.

The blade of power mower rotates very

fast. It can discharge rocks and other

objects over a long distance which can be

dangerous. The force of the objects can

break windows, cause injuries oreven put

an eye oat. Most ofthe timethe injuryisto

a person, like a child. Keep avery person

completely away from the area to be

mowed. Make sure the grass is cot dis-

charged toward anyone. Planning your

mowing patternhas a double advantage. It

can decrease the possibility of an injury

and makethe clean upaftermowing easier.

Check the terrain ofthe area tobe mowed.

Mow inpatternthat willkeep youawayfrom

dangerous areas. Check the distanceyou

need to stop and the distance available to

turn. Slopes and rough terrain must be

mowed carefully and some areas must cot

be mowed at all. With ridingmowers, mow

upand down the hill. When you mustmow

roughterrain or on slopes, never change

directions or change speeds and stop in

these areas only in and emergency.

Before you ride upor down a slope, try to

back straight upthe slope. Do not rideup

or down a slope that istoo steep to beck

straight up. See the "Guide"in the back of

this Owner's/Operator's Manual to check

any slopes.

SAFE MOWING GUIDE

Before you start cutting, make sure the

mowerwas completely assembled accord-

ingto the Owner's/Operator's Manual. If

the mower was completely assembled at

the store, you must stillcheck the mower

according to the assembly instructions.

Make sure the mower is correctly as-

sembled and that all fasteners are tight.

Make sure the engine has the correct

amount of oil. Check these items often

during the life of the mower.

Your mower hasagasoline engine. Gaso-

line is a dangerous fuel. Keep gasoline

only in an approved safety gasoline con-

tainer. Do not keep large amounts of

gasoline. When you add gasoline to the

fueltank, donotsmoke. Storethe gasoline

container and the mower in an area that

hasgoodventilation. Also, keep the gaso-

lineaway fromany flameslikethe pilotlight

of afurnace or anyother soume of ignition.

Ifthe mower istobe stored for more than a

few weeks, remove the gasoline from the

fuel tank. When inside an enclosure, do

not add gasoline to the fuel tank. Before

you add gasoline move the mower outside

and add gasoline carefully. Before your

start theengine, remove anygasolinefrom

the outside of the fuel tank or from the

mower. Warm gasoline willexpand. Leave

somespace int_tefuel tank forthe gasoline

to expand. Also, the fuel cap has a vent

holefor fuelvapors. Always usethe correct

fuel cap. Failure to follow safety rules

aboutgasoline wigcause fires and explo-

sions, injury to you and damage to the

equipment and other property.

If you add gasoline to an engine that is

runningor hot, the resultcan be an explo-

sion. Before you add gasoline, stop the

engine and let the engine cootfor several

seconds. Remove dry grass and other

debris from the mower. Keep the mower

cleantoimprovetbe performance, helpthe

engine and transmission run cooler,ex-

tendthe likeof movingparts, anddecrease

the danger ofa fire.

Fires and explosions are notthe onlydan-

gers when working around a mower. The

engine, transmission, and the muffler will

get hotinseveral minutes when the engine

isrunning. Do not touch these parts of the

mower. Stop the engine. Let the engine

and transmissioncool before servicingthe

mower Remember, exhaust fumes aredan-

gerous. Never operate the engine insidea

building.

When you get anewmower, itcan be a new

experience for thefamily. Tell each person

how a mowercan be dangerous. Remem-

ber, a mower isnot a toy. A mower isnot

to be used by children or anyone not old

enough, strong enough or that does not

have experience.

Ifthe mower isnotcorrectlyassembled, not

operated correctly, or not regularly ser-

viced, the mower can be dangerous. The

most importantruletofollow is always use

goodjudgementand common sense. Mow

safely and carefully.

Your mower will easily cut thick grass.

Fingers, feet and other parts can also be

cut by the blade. Injuries occur when the

operator does not think and reaches into

the chute opening. Always operate the

mower as if the blade is rotating. Do not

service or make an adjustment, except to

thecarburetor, whilethe engine isrunning.

Use onlyaccessories that are factory ap-

proved foryour mower. The wrong acces-

sorycan decrease the safety of the mower

and can even damage the unit. Read and

follow the instructions included with the

accessory and the mower.

Use only original equipment or replace-

ment parts that are factory approved for

service, if you need service, select and

Authorized Service Center for your mower.

If you do the work on the unit, follow the

instructions in the Owner's/Operator's

Manual.

When you mow, remember that children

are attracted to the mower. Always use

caution when mowing around obstacles

like trees or shrubsor when moving back-

ward. Only mow in a forward direction if

passible. Your visibilityisdecreasad when

you mow backward. Also,the blades are

made to cut while the unit is moving for-

ward. If you mow backward, the cutting

performance decreases.

Before you leave the mower, stop the en-

gine. Remove the key. Disengage and

lower any attachment. Set the parking

brake. Never mount or dismountfrom the

seat while the engine is running. An acci-

dent can occurif you touchthe brake, shift

lever,throttle,clutch,ormowerclutch lever

while the engine is running. Mount and

dismount from the seat on the side oppo-

site the discharge chute.

Make sure you are in goodcondition when

you mow. When you mow for several

hours your reflexes willdecrease and your

mind willnotbe as alert. Take a shortbreak

or an accident can occur. Ifthe tempera-

ture ishot,use cautiontoprevent dehydra-

tion. If you are tired, angry or not com-

pletely alert, do not operate the mower. If

you use alcohol, medication or drugs, do

not use the mower or any type of power

equipment.

Engine speed is a key to safe mowing and

to a good looking lawn. The maximum

speed ofthe engine was set atthe factory.

Do not change the setting of the engine

governor.

Select the maximum engine and ground

speed that is rightfor the terrain and the

height of the grass. The blade cuts best

when the engine is operating at maximum

SAFE MOWING GUIDE

speed. Also,thegrass catcher willfunction

better when the engine is operating at

maximum speed. On slopes, decrease the

ground speed and use care making sure

mower feels safe to operate.

ff the weather conditions are bad, do not

mow. ff weather conditions become bed,

stopcuttingand finish later. Itisdangerous

tocutgrass inthe rain. Alwaysfind protec-

tion in an electrical storm. If the weather

conditionsare extra dry, protectyour eyes

with safety glasses from the dust and from

the objectsdischargedby themower. Also,

a dust or a pollen mask can help.

Your mower is equipped with a number of

safety devices which are important to the

safety ofthe operator and bystanders and

must never be changed or removed from

the mower. If a safety device is lost,

damaged or no longer functions, repairor

replace the device beforeyou operate the

mower.

it isbest to mow duringthe day. Ifyou must

mow at night, make sure there is enough

lightfor safe operation.

Your mower will require regular mainte-

nance and service. The maintenance

schedule depends on the hours of use.

Also, mowing conditions can change the

schedule. Check the Owner's/Operator's

Manualformore information. Correct main-

tenance willhelpthe mowerfunction safely.

Do notservice the mower

(except for the carburetor f/

adjustment) while the en-

gine is running. Beforeil_i

you servicethe unit,even _:i_

with the eng ne stopped, i_,-

alwaysdisconnectthewire

fromthe sparkplugtopre-

ventthe engine from start-

ing.

If you hit a large object during operation,

stopthe engine. Remove the wirefromthe

sparkplug. Carefully inspectthe mowerfor

damage. Before youstartthe engineagain,

make the necessary repairs. If you feel

new or excessive vibration, immediately

stopthe engine and checkforthe problem.

Vibrationcanbe a warningofa problem,

Keepall nuts,belts and screwstight.

The blade isthe most dangerous pert ofthe

mower. Frequently check the blade and

the blade mounting fasteners. Keep the

fasteners tight. If the blade hits a solid

object, stopthe engine. Remove the wire

from thespark plug. Check fora blade that

is bent, cracked or for other damages.

Before you start the engine, replace the

damaged blade. For safety, replace the

blade every two years.

A sharp blade decreases the work load on

the engine and more evenly cuts grass.

Frequently sharpen the blade for a better

lookingcut. Use the left sideof the mower

desk totrim near an object.

A grass catcher is a good a accessory for

your mower. For best performance and

safety, make sure the grass catcher is

approved for usewith yourmower. Follow

the assembly and operation instructions

included with the grass catcher.

Some grass catchers require a special

blade for best performance. Before you

attach, check, or empty the grass catcher,

alwaysstopthe angina. Before each useof

thegrass catcher,checkfor cracks,wearor

deterioration. Before you use the grass

catcher, replace a damaged part with a

replacement partapproved by the factory.

For you to have a good green lawn, follow

the mowing procedures below. Do notcut

the grass too short. Ifyou cut the grass to

short you can cause the grass to become

yellow or make the lawn lookbrown. Use

a lower height ofcut in cool monthswhen

the grass isthicker. Raise the heightofcut

inhot dryperiods. Ifyou cutthe grass with

abladethat isnotsharpor at aslowengine

speed you can damage the grass. Move

the throttle control to the FAST position

when mowing and usingthe grasscatcher.

Also, use a slower ground speed when

using the grass catcher.

Ifyouchange the direction orpattern ofcut

slightlyevery time you mow will make the

grass grow stronger and thicker. Do not

add oil or gasoline to the mower while on

the lawn. Spilled oilor gasolinecan killthe

grass. In high orthick grass, do nottry to

cut all the grass the first time. Raise the

heightof cut on the first cuttingand lower

the heightfor the nextcutting.Anotherway

istocut only partofthe width ofthe mower

and decrease your ground speed (not the

engine) to move more slowly so that the

mower can dischargethegrassas itmoves

forward.

Understand the controls and how they

work. Learn the ground speed(s) of your

mower. Check the stopping distance re-

quired at different travel speeds. Check

the turning radius of the mower. The

controlsonyour ridingmower are different

from an automobile. The throttle is oper-

ated by hand and holds the engine speed

constant untilitischanged. The lo_tion of

the shiftleverand the shiftpattern isdiffer-

ent from that of an automobile. Also, the

brake and clutch systems are different.

Remember the procedures tofollow in an

emergency. Remember, turning off the

ignition switchwill stop the blade and the

drive mechanism. If the traction of the

wheels is lostor does not feel safe, disen-

gage all systems and stop the engine.

Dismountfromthe mower. Pushthe unitto

a safe place before you begin mowing

again.

Your unit has an electrical system that

includes an seat switch in the seat. The

seat switchdetects ifthe operator is sitting

on the seat. The engine will stop If the

operator leaves the seat when the blade

engagement controlisengaged. Thisseat

switch isa safety device only. It must not

regularlybe usedto stopthe engine orthe

blade. There are other control systemson

the mower for this purpose. Always keep

the seat switch and other safety devices

andcontrols inplace and operatingforyour

protection.

Remember, your mower is atoofthat can

be dangerous if it is not correctly used.

Follow the instructions in this Owner's/

Operator's Manual. Safe and careful use

ofthe mower willgive youmany safe hours

of problem free use.

STEPS TO FOLLOW

BEFORE MOWING

Be sure to dress correctly, Wear hard shoes, not sandals or tennis shoes.

Examine the blade. A blade that is bent, cracked or damaged must be replaced with a factory replacement blade,

Fillthe fuel tank outside. Clean off spitledfuel.

Reed and follow the Owner's/Operator's Manual, the instructions with the engine, and the instructionswith any attachments.

Owner's/Operator's Manual instructionsare for your safety and the safety of others.

Exhaust fumes are dangerous. Start the engine outside.

Make sure all safety devices are in place and working correctly,

Operation of the mower isonly for a person that has experience.

Wet grass can be dangerous. Let the grass dry.

Instruct children and others to keep away from the work area.

Never cut the grasswithout good light.

Pick up loose objects. Remove them from the mowing area,

WHILE MOWING

Watch for fixed objects and avoid them. They can damage the mower or cause injury.

A hot angina, muffler, and transmission willcause a burn. Do not touch.

Inclines and slopes must be carefulry mowed. Sea the *Guide" in the back ofthis book tocheck a slope.

Lack of daylight or good artificial lightis cause to stop mowing.

Examine the mower, the blade, and other parts for damage after hittinga foreign object or ifthe unitvibrates excessively.

Do cot make adjustments or repairswithout stoppingthe engine (except for carburetor). Disconnect the spark plug wire.

On or near roads, watch out fortraffic, Direct discharge away from roads.

When mow ng, avoid areas where traction s unsure. Look back before changing direction oftravel.

In heavy grass, raise the cutting height. Cut slower. Stop the engine to remove cloggedgrass from the mower.

Never remove any safety related parts.

Do not pour gasoline intoa engine that is hot or running.

AFTER MOWING

Always let the mower cool before storing in an enclosed area.

Foreign matedal on the mower isdaagemus. Clean off grass, leaves, grease, and oil before storing.

Tighten all loose nuts, belts, and screws before you use the unit.

Empty and clean any grass catcher or other accessory.

Remove the key or disconnect the spark plug wire to prevent unauthorized use.

Make sure the mower is not kept near a source of ignition. Gas fumes can cause an explosion.

Only original parts or factory approved substitutescan be used to servicethe mower.

When storing the mower for an extended period, remove the fuel from the fuel tank,

Instruct children to leave the mower alone, if is cot a toy.

Never keep gasoline near a source of ignition. Always use an approved container. Keep gasoline away from children,

Lubricate according to the Owner's/operator's Manual. See "Lubrication'.

IMPORTANT- READ THE OWNER'S/OPERATOR'S MANUAL. KEEP THIS BOOK FOR FUTURE USE AND REFERENCE.

A_ WARNING: Look for this symbol to point out important safety precautions. It means: "Attention! Become Alert!

Your Safety Is involved."

ASSEMBLY

Your lawn tractor has a right side and left side as you face

forward while seated in operator's seat.

TO ACTIVATE BATTERY

IMPORTANT: : Before you attach the battery cables to the

battery,check the batterydate code. The batterydatecodetells

if the battery must be charged.

1. Check the battery date code on top of the battery.

2. If the battery is put into service before the battery date, the

batterycables can be attached withoutchargingthe battery.

See Battery Instaifatlon paragraph in Maintenance sec-

tionof this manual.

3. If the battery is put into service after the battery date, the

battery must be charged. To charge proceed:

STEERING WHEEL INSTALLATION

(FIG.=-ASSY)

1. Positionfront wheels straight forward.

2. Placa spacer (If so equipped) on steering shaft.

3. Place steering shaft cover (If so equipped) over spacer.

4. Aligncross holesin stesring wheel and steeringshaft. Make

sure wheel single wheel spoke points down. NOTE: Use a

smallPhillipsscrewdriver witha 114inchshaftto alignholes.

5. Drive springpin through holes with a hammer.

IA When you chargethe battery, do not moks.'_

Keepthe battery away from anysparks. Ths_

fumes from the battery acid can cause anJ

explosion. ._

TO CHARGE THE "MAINTENANCE FREE"BATEERY

NOTE: Before you attach the battery cables, make sure the

batteryisful;y charged. This willextsndthe lifeofthe battery and

providethe necessary power to start the engine.

4. Removebatteryfromlawntractor(see Battery Removal

paragraph In Maintenancesection ofthis manual).

S. Removstheprotectivecapsfromthebattaryterminais.

6. Use a 12 volt batterycharger to charge the battery. Charge

at a rate of 6 amperes for one hour. If you do not have a

battery charger, have an authorized servicecenter charge

the battery. Complate assembly secticnofthis manualwhile

waiting for battery to charge.

7. Reinstallbattery (see Battery Installation paragraph In

Maintenance sectionof this manual),

ASSEMBLY

SEAT INSTALLATION

1. Attach seat and seat plate to seat supportbracket with two

5/16-18 shoulder bolts end two hex head Iocknuts. Tighten

securely (FIG. 3A-ASSY).

CHUTE DEFLECTOR ASSEMBLY

1. Place discharge chute deflector onto tractor deck

(FIG. 4-ASSY).

2. Slidesmoothendof pivotrodthroughrear tabon chute

deflectorandrearmountingbrackettab(exposeapproxi-

mately 2 Inchesofpivot rod).

3. Spreadspringopenwitha twisting motionandplaceonto

pivotrodwithbentendofspringascloseaspossibletorear

mountingbrackettabandoverchutedeflector.Straightend

ofspringshouldbetowardfronttabofchutedeflectorand

overmowerdeck(RG. 4-ASSY Inset).

4. Tapgroovedandofpivotrod(as Indicatedby snow) with

a hammeruntilrodisflushwithreartabonchutedeflector.

S. Install push nuton end ofpivot rod (FIG. 4-ASSY inset).

2. Connect seat switohto wire harnass. NOTE: Ifseat switch is

notconnected towire harness, engine willstop when mower

clutch lever isengaged (FIG. 3B-ASSY).

3. Attach wire harness to seat plate with press clip.

I_VOT Roo

CHUTE DEFLECTOR TORSION SPRING

MOWERDECK

REARTAB

REAR MOUNTING BRACKET TAB

STSAIGHT END OF

SPRING

LE_'_OR FRONT

CHUTE DEF MOUNTING

BRACKET

TAS

PUSH

FRONTTAB NUT

INSET- TORSIONSPRING INSTALLATION

TO ADJUST QUICK ADJUST SEAT

(FIG.3C-ASSY)

If adjustment Is needed:

1. Move seat adjustlevertothe leftand hold,while movingseat

forward or rearward todesired operator'sposition. Release

seat adjust lever.

NOTE: Make sure lever latches in slot.

MOWER DECK WHEEL ASSEMBLY

1. Attachmower deck wheelsto deck wheel mounting brackets

withwheel axle boltsand 3/8 inchIocknutsas shownin(FIG.

4A-ASSY). NOTE: Use top hole on both rightand left wheel

mountingbrackets as shown in (FIG. 4A-ASSY).

NOTE: If more adjustment is necessary see Mower Deck

Wheel Adjustment in the Adjustment sectldn of this manual.

AXLE BOLT

ASSEMBLY

MOWER DECK INSTALLATION

1. Depress brake clutch pedal and set perking brake.

2. Place cuttingheightadjustmentlever in highestcutting

position.

NOTE: Besurefrontadjustmenteccentricsaremountedin the

secondholefrom top of mowerdeckmountingbracketand

grooveon eccentricispointedforward (FIG. 5-ASSY). Make

adjustmentsifnecessaryand proceed.

GROOVE

FRONT

ADJLBTMENI"

ECCENTRIC

MOWER DECK

MOUNTING

BRACKET

MOWER DECK LEVELINGADJUSTMENTHOLES

3. Place mower deck on rightside of tractor with chute away

from tractor.

4. Turn front wheels allthe way to the left.

S. Lift deck hitch.Slide mowerdeckhalfwayundertractor,

rotatingmowerdeckcounterclockwiseand loweringdeck

hitch.Slidemowerdeckforward undertractortoa centered

position.

6. Slide mower deck rearward. Connect mower deck

engagement cable to mower deck clutch spring

(FIG. 5A-ASSY). Besure openend of springispointeddown

(FIG. 5A-ASSY inset).

I LIWER ENGINE PULLEY

ENGINE

PULLEY

8. Remove hairpincottersandflat washer from the left and right

hand hanger pins (RG. 6-ASSY), remove hitch rod and

hairpincotter from front mounting bracket (RG. 6A-ASSY)

and lay allparts aside for later use.

9. Place cutting heightadjustment lever in lowest cuttingposi-

tion. NOTE: Be sure mower deck lift arms are on inside of

mower deck liftbrackets.

10. Slide left mowerdeck liftbracket on hanger pinof leftrear lift

arm and secure in place with flat washer and hairpincotter

removed in step 8. Repeat attachment assembly for right

rear mower deck liftbracket.

11.Place cuttingheightadjustmentlever in highestcutting

position.

HANGER PIN

MOWER DECK

LIFT BRACKET

REAR LIFT ARM

7. Slide deck toward front oftractor. Flex lower engine pulley

belt guides away from engine pulley and slipdeck drive belt

on lower engine pulley. Reposition belt guides to 1/16" from

pulley (FIG. 5B-ASSY).

12. L_t front of mower desk and place a 2 x 4 up on edge,

between front tires and under front center of m,,-,er deck.

Thiswillbe usedfor leverage to raiseand k)wermower deck

as needed to alignfront hitch mounting holes in step 13.

ASSEMBLY

13. Lift front deck hitch. NOTE: Be sure earsof deck hitchare

to outside offront mounting brackat. Liftfrontof mower deck

with 2x 4 and align left hand deck hitch mounting hole with

lefthandfront mountingbracket hole, installhitchrodthru left

hand holes and intoright hand front mounting bracket hole.

(RG. 6A-ASSY) NOTE: Once the 2 x 4 has been placed

under front edge of mower deck, cutting height adjustment

levercan be moved to a lower position ifneeded for easier

alignment of holes to install hitch rod.

14. Plane 2 x 4 on side, under front center of mower deck. This

willbe used for leverage to raise and lowerdeck as neadad

to align mounting holes in step 16.

15.Placecuttingheightadjustment leverin lowestcuttingposi-

tion.

16. Liftfront ofmower deck with 2 x 4 and align righthand deck

hitch mounting hole with right hand front mountingbracket

hole, and install hitch rod thru deck hitch mounting hole.

Install hairpin cotter removed in step 8.

17.Check mower deck leveling and adjustment as required.

See Mower Deck Leveling Adjustment paragraph in

Adjustments section ofthis manual.

TO SERVICE ENGINE (FIG. 7-ASSY)

1. Place tractor so engine is in a level position.

2. Raise hood to gain access to engine. NOTE: Raise and

lower slowlyto avoid personal injuryor damage totractor.

3. Remove oil_i!lcep/dipstick. Clean dipstick with a rag.

4. Check oil level. Use a funnel to add oil to the engine

crankcase, ifthe oillevel isbelow the full mark. See Engine

Operating and Maintenance manual for proper procedure.

5. Reinstall oil fill cap/dipstick and tighten securely.

6, Checktomakesurethatsparkplugwire(s)is/areattached

tosparkplug(s).

7. Fill gas tank with clean, fresh lead-free gasoline with a

minimum rating of 77 octane. Low-lead or regular grade

leaded gasolines are acceptable. Do not mix oil with gaso-

line. Becertain container isclean and freefrom rustor other

foreign particles. Never usa gasolinethat may be stale from

long periods of storage in the container.

_ ever fill the gas tank while the engine Is |

running or Is hot. Immediately wipe off any

spilled gasoline before attempting to start

engine.

TO SERVICE TRACTOR

1. Check tire pressure. Recommended operating tire pressure

is 10 to 14 pounds per square inch.Check side wall of tires

for manufacturer's maximum tire pressure. Do not exceed

thispressure. Equaltirepressure shouldbe maintained in all

tires.

2. Check all nutsand bolts to be sure none are loose.

3. Return totheTo Activate Battery paragraph inthissection

and complete the battery installation.

OPERATION

The operation of this lawn tractor can

result in objects being thrown into the

eyes, which can resultin severe eye darn-

age. Always wear safety glasses or eye

shieldswhile operating a lawntractor. We

recommend standard safety glasses or a

wide vision safety mask for over

spectacles.

Get toknowyourlawntractoranditscontrols.Besureyou(or

any othw operator) have reed and understoodthe Safety

Pageslistedinthefrontofthismanual.

Your new lawn tractor will give years of service if cared for

properly. Never run intotrees, curbs, etc.Service regularlyand

store inadry area. Operate your lawntractor atslowspeeds until

you become familiar withthe machine. Avoidsharpturnsat high

speed and uphillor downhillturns. Operate tractor carefully. Be

especially cautious on hills. When riding down inclines, keep

shiftcontrolinlowspeed withbrake-clutchpedal out.This allows

the engine tocontrolthe speed. Use brake forfast stopson hills.

KEEP MOWER CLEAN. Grass clippings may pack under the

mower deck due to the internal moisturecontent of the grass.

This accumulation of cut grass should be removed after each

mowing. Remove ignitionkey and scrape accumulationoffwith

a putty knifeor similar tool. Cleaning ofthe underside iseasier

if mower deck is removed. See Mower Deck Removal para-

graph inMalntenanca section ofthis manual. Remove dirtand

debris from engine area with a brushor cloth.

Do Not operate this tractor without a chute_

deflector in place.A lawn tractor can be dan-

gerous to operate If misused. On slopes, be

very cautious and avoid sharp turns to pre-

vent tipping or loss of control. NEVER carry

passengers. ,e

€ONTROLS

FIG. 1-OP shows all operating controls. The controls and their

functions are as follows:

• , I\1

L - Regulates engine and blade speed.

Engine should always be run at fast speed for best grass cut-

ting. NOTE: For models without a choke control button the

choke is regulated with the throttle control lever.

Ionitlon Switch - Used to start and stop engine. Turn key all

the way rightto 3rd position to start engine. When key is re-

leased after starting engine it will return to 2nd position. To

stop engine, turn kay to 1st position. Remove key to lock igni-

tion.

Headlloht Switch - Turns headlights on and off. With

engine running, push ON end of switchto turn headlights on.

To turn headlights off push OFF end of switch.

OPERATION

Choke Control (if so eOUlDDed) - Used to start cold engine.

All Svmma Go Lloht (If so eouleoed_ - If this indicator islit,

the engine will not start.

1. Your clutch-brake pedal may not be fully depressed.

2. The mower clutch lever may not be in the DISENGAGE

position.

Ammeter (If so soUlDDedl - Indicates whether bakery is be-

ing recharged when engine is running. If charge is not indi-

cated while engine is running at full throttle, have engine

charging system checked by an authorized engine service

dealer.

Transmission Coptrol Levtr - Used to select ground speed

ranges as well as direction of motion (forward-neutral-re-

verse). Forward speed ranges are labeled (1 -2-3-4-5) or (1-2-

3-d-S-S).

No. 1 range isslowest forward speed, usedfortravelingup

or down steep hills or for snow removal.

No. 2 range is used for cuttingtailor heavy grass.

No. 3 range is used for average mowing conditions.

No. 4 range is used for light mowing.

NO. 5 range is usedfor very light mowing on smooth flat

surfaces on a 6 speed. On a 5 speed it is used for

transportingthe unit.

No. 6 range should be used for transporting unitonly,

l A Come toe full stop before changing dlrection_

• °fm°t=- )

_- Usedto lockbrake-clutch pedal inbrake

position. NOTE: Check gear shift position and know o p• r-

ating intentions before releasing brake.

1. Depress brake-clutch pedal fully, engaging brake.

2. Push parking brake lever forward and engage notch in

parking brake lever against main frame.

3. To release parking brake, apply pressure to pedal and

swing will release parking brake lever.

Brake-Clutch Pedal - This is a dual purpose control. Press

pedal halfwaydown to disengage clutch,it isusedforchanging

speed rangeordirectionoftravel (forward or reverse). Release

pedalto engage clutch.With pedalcompletely depressed, brake

is applied.

OPERATION

_- Usedtoengageordisengagethepower

tothemowerdeckbledes.Withmowerclutchlevermovedallthe

waytoDISENGAGE (rearward)position,bladesshouldstopin

asaleperiodoftime.UseDISENGAGEpositionwhenusingas

atractorfor yardjobssuchas pullinga miler, seeder,sweeper

or otheraccessories.

Move lever slowly (Never"snap" the lever) toward frontof

lawn tractor to engage power to the blades. It is important

to engage mower clutch leverwhile engine is runningat full

speed.

2. Move lever slowlytoward rearof lawn tractor to disengage

power to blades and to apply blade brakes.

Mower clutch lever must always he In full DISENGAGE

position to start engine. Never place lever In ENGAGE

position until engine Is warmed up and operator Is on seat,

ready to start mowing. Always return lever to DISENGAGE

position before dismounting from tractor.

Cuttlna Haloht Adlustment Lever - Used to change heightof

cut. The bottom position of lever is the lowest

cutting height and the top position isthe highest cuttingheight.

Other positions change height of cut approximately 1/2 inch

each,

Grasp lever (FIG.I-OP) with left hand and pull upward to

raise mower deck. You will hear a click sound as lever

passes to next height position.

Grasp leverwith lefthand andpull upward slightly.Depress

button on end oflever with thumb to release height adjust-

ment lever latch and lower mower deck to

desired height. Release latchbuttonand allow leverto latch

in place.

_ Blades will not stop Immediately. Keap"_

hands and feet from under the mower deck _

and away from the discharge chute. |

OPERATION

TO START ENGINE

Read Operstlon section in this manual and Engine Operat-

Ing and Malntenanne manual before trying to start engine.

NOTE: Be sure engine ¢rancass Is filled to the full mark

before starting engine. Never run engine unless crank-

case Is properly filled with oil and dipstick Is tightened se-

curely.

IMPORTANT: When starting engine, the brake-clutch pedal

must be fullydepressed and mower clutch lever must be in full

DISENGAGE positionto engage the lockout switches. The All

Systems Go light (If so equipped) on dash will glow and

engine will not crank unless these conditions are met.

Your lawn tractor is equipped with a seat switch. The

engine will stop If operator Is not firmly seated In

operator's seat when mower clutch lever Is engaged.

Lssnlng forward or to one side on the seat may cause the

engine to stop. To leave operstor's seat, the brake-clutch

pedal must be pushed all the way down and locked or

engine will stop.

To start engine proceed as follows:

1. Check to make sure fuel tank contains clean, fresh gaso-

line, and engine crankcase is properlyfilled with oil.

2. Depress and hold brake-clutch pedal all the way down.

Place shift lever in NEUTRAL position.

3. Place mower clutch lever in DISENGAGE position.

4. Place throttlecontrol lever to FAST position.

A warmengine willrequirelittleor no choking.Forcold

startsplace'throttlecontrol leverinchokepositionor pull

chokecontrol out.Thiswilldependonthetypechokeyour

unitisequippedwith,

Turn ignition key to START position. Release key when

engine has started. NOTE: Continuous cranking of more

than 15 seconds per minute can cause starterto overheat.

Allow starter to cool two minutes after prolonged cranking

of more than 15 seconds per minute.

After engine starts, move throttle control out of choke

positionto desired engine speed or gradually push choke

control all the way in and move throttle control lever to

desired engine speed. This willdepend onthe type choke

your unitis equipped with.

8. To stop engine, turn ignitionkey to OFF position.

I IMPORTANT

Move throttle to slow before turning Ignition off to

reduce muffler "POP".

Failure to do so will result In engine and exhaust

system damage.

If engine cranks but fells to start, proceed as follows:

1. Checkto make surefueltank contains clean, freshgasoline.

2. Check to make surespark plug(s)is/are tightened securely

intoengine and spark plug wire(s) is/are attached to spark

plug(s).

3. Carburetor adjustment may be necessary (see Engine

Operating and Malntanence manual).

If engine does not crank, check the following:

1. Be sure brake-clutch pedal is fully depressed and mower

clutch lever is in DISENGAGE position.

2. Be sure the battery has been serviced and charged.

3. Check fuse in red wire near beck of ignitionswitch.

LAWN TRACTOR OPERATION

Take a comfortable riding position on seat of lawn tractor

and start engine as outlined. After engine warm-up, move the

transmissioncontrol leverto a slowspeed position to get used

to your lawn tractor.After you become familiar with the opera-

tion of your tractor, move the transmission control lever to a

faster speed. With mower blades stopped, make your first run

in a large, open, level area. Learn to start, stop, and change

direction in this area. Once you learn to maneuver your lawn

tractor, move throttle control to FAST position. Slowly move

mower clutchlever to ENGAGE positionand start mowing. To

stop blades, move lever to DISENGAGE position. To stop

engine, movethrottlecontroltoSLOWposition,t urnignitionkey

to OFF position. CAU'nON: Disengage mower clutch lever,

set parking brake, stop engine, lower mower deck and

remove key before leaving operator's position. Always

dismount from left side.

Your lawn tractor Is equipped with a seat switch. The

• nglna will stop Ifoperator Isnot firmly seated In operator's

seat when mower clutch lever isengaged. Leaning forward

or to one side onthe seat may cause the engine to stop. To

leave operator's seat, the brake-clutch pedal must be

pushed all the way down and locked or engine will stop.

OPERATION

TO AVOID SERIOUS INJURY OR DEATH

Read Owner's'Operator's Manual(s).

Know location & function of all controls.

Keep guards, safety shields and switches In

place and working.

Remove objects that could be thrown by

blade(s).

_ Do not mowwhen chlldren &othersare around.

Never carry chlldren or passengers.

Look down and behind before and whlle back-

Ing.

Do not mow where machlns could tlp or sllp.

If machlne stops going uphill, dleangage

blade(s) and back down slowly.

Remove key when leaving machine.

Avoid sudden turns.

Go up and down slopes, not across.

MOWING HINTS

Forbestmowing results,engine shouldbe runat fastthrottleand

groundspeed controlledby shiftcontrollever position. Forward

speed of the lawntractor mustbe controlled in accordance with

thetypeand quantityofgrassbeing mowed. The more grassthat

must be cut, the slower the speed forward should be. When

cutting light grass, the forward speed can be increased. By

observing the cutting actionofyour mower, you can determine

how fast you can travel.

Your mower may tend to leave unmowed stripswhen longand

tender grass isbeing mowed. Tender grass has a highintemal

moisture content and is easily depressed by the lawn tractor

wheels, and may not always spring back in time to be cut. To

overcome this condition, we advise mowing the lawn in a

counterclockwise direction, overlapping previous cut, which

allowsthe liftingactionofthe rotatingblades toliftthe grassinto

the cutting path.

The rear wheals are driven by a transaxla, similar to an

automobile differential. This makes short turns po_s_e and

prevents marring of the lawn. It is possible to spin the drive

wheels ofthe lawntractor under adverse conditions.When one

wheel slips, shift your weight over this wheel to obtain more

pullingpower. Your lawntractor isvery maneuverable and can

be reversed toback out ofdead ends. CAUTION: Dlcengsga

mower blades before backing up. Carefully check area

behind tractor for children or pets before becking up.

MAINTENANCE

The warranty on this lawn tractor does not cover items that

have been subjected to operator abuse or negligence. To

receive full value from the warranty, operator must maintain

lawn tractor as instructed in this manual. The following Main-

tsnanca Check List is supplied to assist operator to pmpedy

maintain lawn tractor. This is a check list only.

Adjustments referred to will be found in Adjustments section

ofthis manual.

BEFORE STORAGE

BEGINNING EACH SEASON

EVERY 100 HOURS

EVERY 50 HOURS

EVERY 25 HOURS

MONTHLY

FREQUENTLY

AFTER FIRST 5 HOURS

MAINTENANCE CHECK LIST

SERVICE RECORD

FILL IN DATES

AS YOU COMPLETE

REGULAR SERVICE

BEFORE EACH USE

CheckEngineOilLevel

ChangeEngineOil

ChangeOil Filter(ifsoequipped)

CleanAirFilter

ChangeSparkPlug(s)

ReplaceAirFilterPaper Cartridge

CleanAirScreen

InspectMuffler/SparkArrestor

ReplaceFuelFilter

CheckBatteryFluidLevel/Recharge (i

CleanBatteryandTerminals

AdjustMotionDr_veBeltTension

CheckBrakeOperation

CheckTransmissionCooling

CheckTire Pressure(10-14 Ibs)

AdjustMowerDeckBelt

Sharpenor ReplaceMower Blades

Checkfor LooseFasteners

CleanLawnTractor

See LubricationChart

i I

I I

NOTES: 1, Change more often when operating under a heavy load or in HIGH temperatures. (90°and above)

2. Service more often when operating in dirty or dusty conditions. 3. Replace more often when mowing in sandy soil.

• _ LUBRICA110N

At no time during maintenance or adjustments

can the lawn tractor be lifted more than 20

Inches from level position without taking the

_ following precautions:

1. Remove gasollna from tank and run engine

until carburetor is dry.

2. Remove battery. (see BATTERY REMOVAL

paragraph In MAINTENANCE section.)

3. Remove oil from crankcase.

For lubrication frequency see Maintenance Check List. For

lubrication points and type of lubricant see Lubrication

Chart. The transmission has been lubricated for life.

Page is loading ...

Murray G4618000 User manual

Brand: Murray

Model: G4618000

Category: Lawnmowers

Type: User manual

This manual is also suitable for

F4315-000

Download PDF

report

Murray G4618000 User manual

This manual is also suitable for

Murray G4618000 User manual

Related papers

Other documents