Artos Engineering Company CD-17 Owner's manual

1



Machine Model CD-17 Coiling bowls Owners Manual

P/N 6-119923A Rev. 1.1 Date 15 Jul 2014



Artos Engineering Company

21605 Gateway Court

Brookfield, WI 53045

Phone 262-252-4545 Fax 262-252-4544

www.artosnet.com

[email protected]



2



WARNING

NEVERREACHINTOTHECOILINGBOWLWHILEITISTURNING.INJURYMAYRESULT



CD‐17Operatorcontrols



Thedial0‐100controlsthewindingrateofthebowls.ThefasterthewireisfedintheCS327machine

thehigherthisnumberneedstobe.

TheClutchpressurecontrols howtightlythebowlisheldtotherotatingdrivemechanism.Youwantto

adjustthisvalueso

thatthebowlisabletorotateandcollectthewire,butatthesametimeifthewire

stopsfeedingthebowlwillstopalso.Inadditionif an operatorputstheirhandinitwhileitisstill

rotatingitwillstopeasily.Ifthebowlkeepsrotating

whenthewirestopsfeeding,thewireinthebowl

willbepulledoutandtwisted.Itworksbesttostartwithalowvaluelike20PSIandincreaseituntilyou

noticethatthebowlproperlycominguptospeedforthewiretofeedin.Theitemthataffects

this

settingistheweightofthewireinthebowl.Whenyouhaveacoilthatisveryheavytheclutchpressure

shouldbereduced.

TheBrakepressurecontrolshowfastthebowlcomestoastop.Ifthisvalueissettoohighthebowlwill

stopand

thewireinthebowlwillkeepspinningthuscausingatangle.Theitemthataffectsthissetting

istheweightofthewireinthebowl.Whenyouhaveacoilthatisveryheavythebrakepressurewill

havetobeincreased.



3



CD‐17Coilingbowls

Thefollowingsizecoilingbowlsizesareavailable.

14368918inchbowl

14369024inchbowl

14369130inchbowl



WARNING: Whenusing14368918inchbowls,guardpartnumber146080mustbe

installedunderthebowls.Injurycanresultifthebeltisnotcoveredwiththisguard.

146080



WARNING:Whenusing14369024inchbowlsor14369130inchbowls,guardpart

number146079mustbeinstalledunderthebowls.Injurycanresultifthebeltisnot

coveredwiththisguard.

146079



4



Changingbetweencoilingbowls.



1. Removethe3screwsfromthetopofeachofthebowls.Thenliftthebowlsoff.

2. Removethesheetmetalbeltcover.

3. Loosenthebelttensioner.

4. Thebowlspindlescanbemountedin3locations.Thereare4screwsthatholdeachonein

place.Movethespindletothedesiredlocation.

a. Theinsidelocation(bowlsclosesttogether)isforthe18”bowls.

b. Themiddlelocationisforthe24”bowls.

c. Theoutsidelocation(bowlsfurthestapart)isforthe30”bowls.

5. Tensionthebelt.

6. Forthe18”bowlinstallsheet

metalcover146079.Forthe24or30”bowlinstallsheetmetal

cover146080.

7. Setthebowlsinpostionandinstallthe3screwsinthetopofeachbowl.

8. Replacetheguidetubeif neededForthe18”bowluse146081.For24and30”bowluse

143763.146081is5incheslongerthan143763.

9. Adjusttheguidetubesothatthetubeproperlyalignswiththebowl.



Beltcover

Artos Engineering Company CD-17 Owner's manual

Other documents