Chief FCA540 Installation guide

Category
Wall & ceiling mounts accessories
Type
Installation guide
INSTALLATION INSTRUCTIONS
Instrucciones de instalación
Installationsanleitung
Instruções de Instalação
Istruzioni di installazione
Installatie-instructies
Instructions d´installation
Outlet Box Accessory
Spanish Product Description
German Product Description
Portuguese Product Description
Italian Product Description
Dutch Product Description
French Product Description
FCA540
FCA540 Installation Instructions
2
DISCLAIMER
Milestone AV Technologies and its affiliated corporations and
subsidiaries (collectively "Milestone"), intend to make this
manual accurate and complete. However, Milestone makes no
claim that the information contained herein covers all details,
conditions or variations, nor does it provide for every possible
contingency in connection with the installation or use of this
product. The information contained in this document is subject
to change without notice or obligation of any kind. Milestone
makes no representation of warranty, expressed or implied,
regarding the information contained herein. Milestone assumes
no responsibility for accuracy, completeness or sufficiency of
the information contained in this document.
Chief® is a registered trademark of Milestone AV Technologies.
All rights reserved.
IMPORTANT SAFETY INSTRUCTIONS
WARNING: A WARNING alerts you to the possibility of
serious injury or death if you do not follow the instructions.
CAUTION: A CAUTION alerts you to the possibility of
damage or destruction of equipment if you do not follow the
corresponding instructions.
WARNING: Failure to read, thoroughly understand, and
follow all instructions can result in serious personal injury,
damage to equipment, or voiding of factory warranty! It is the
installer’s responsibility to make sure all components are
properly assembled and installed using the instructions
provided.
WARNING: Use this mounting system only for its intended
use as described in these instructions. Do not use
attachments not recommended by the manufacturer.
WARNING: Never operate this mounting system if it is
damaged. Return the mounting system to a service center for
examination and repair.
WARNING: Do not use this product outdoors.
IMPORTANT ! :
The FCA540 accessory is designed to be
mounted to a Chief ceiling mount or array, and is compatible
with Raco 420 single gang box or similar style outlet boxes.
--SAVE THESE INSTRUCTIONS--
DIMENSIONS
0.34
8.6
2.50
63.5
COMPATIBLE WITH RACO 420 SINGLE GANG BOX
OR SIMILAR STYLE OUTLET BOXES
DIMENSIONS: INCHES
[MILLIMETERS]
Installation Instructions FCA540
3
LEGEND
TOOLS REQUIRED FOR INSTALLATION
PARTS
Tighten Fastener
Apretar elemento de fijación
Befestigungsteil festziehen
Apertar fixador
Serrare il fissaggio
Bevestiging vastdraaien
Serrez les fixations
Loosen Fastener
Aflojar elemento de fijación
Befestigungsteil lösen
Desapertar fixador
Allentare il fissaggio
Bevestiging losdraaien
Desserrez les fixations
Phillips Screwdriver
Destornillador Phillips
Kreuzschlitzschraubendreher
Chave de fendas Phillips
Cacciavite a stella
Kruiskopschroevendraaier
Tournevis à pointe cruciforme
Open-Ended Wrench
Llave de boca
Gabelschlüssel
Chave de bocas
Chiave a punte aperte
Steeksleutel
Clé à fourche
#2 11/32"
A (1)
[Outlet box]
B (1)
[Outlet box cover]
C (1)
[Outlet box bottom]
D (2)
10-24 x 1/2"
E (4)
10-24 x 3/8" F (4)
08-32 x 1/2" G (8)
08-32
H (4)
1/4-20 x 1/2" J (4)
1/4"
K (4)
1/4-20
FCA540 Installation Instructions
4
INSTALLATION
NOTE: The FCA540 is compatible with the Chief ceiling
mounts and arrays, and may be installed in a vertical or
horizontal orientation. Proceed to Attaching to Ceiling
Mount or Attaching to Arrays section.
Attaching to Ceiling Mount
1. Attach outlet box bottom (C) to back of ceiling mount using
two 10-24 x 1/2" Phillips tapping screws (D). (See Figure 1)
2. Proceed to Completing Installation section.
Figure 1
Attaching to Arrays
1. Insert four 1/4-20 weldnuts (K) into slot in mount rail. (See
Figure 2)
Figure 2
2. Attach outlet box bottom (C) to weld nuts (K) using four
1/4-20 x 1/2" Phillips pan head screw (H) and four 1/4" flat
washers (J) into installed weldnuts (K). (See Figure 3)
Figure 3
3. Proceed to Completing Installation section.
Completing Installation
1. Add outlet box cover (B) to side of outlet box (A) where
outlet won’t be located using four 08-32 nuts (G). (See
Figure 4)
Figure 4
1
(D) x 2
(C)
(K) x 4
Rail
slot
1
(C)
2
(H) x 4 (J) x 4
Mount
rail (K) x 4
(B)
(A)
(G) x 4
1
Installation Instructions FCA540
5
2. Add electrical box (not included) to outlet box (A) using four
08-32 x 1/2" Phillips cap head screws (F) and four 08-32
nuts (G). (See Figure 5)
Figure 5
3. Add outlet (not included) to assembly using hardware
included with outlet. (See Figure 6)
4. Add outlet cover (not included) using hardware included
with outlet. (See Figure 6)
Figure 6
5. Attach outlet box assembly to the previously installed outlet
box bottom using four 10-24 x 3/8" Phillips head cap screws
(E). (See Figure 7)
Electrical
box
(not included)
(A)
(G) x 4
2
(F) x 4
Outlet
(not included)
Outlet cover
(not included)
3
4
(Vertical attachment to ceiling mount shown as example)
5
(E) x 4
FCA540 Installation Instructions
6
Installation Instructions FCA540
7
FCA540 Installation Instructions
USA/International A 6436 City West Parkway, Eden Prairie, MN 55344
P800.582.6480 / 952.225.6000
F877.894.6918 / 952.894.6918
Europe A Franklinstraat 14, 6003 DK Weert, Netherlands
P+31 (0) 495 580 852
F+31 (0) 495 580 845
Asia Pacific A Office No. 1 on 12/F, Shatin Galleria
18-24 Shan Mei Street
Fotan, Shatin, Hong Kong
P852 2145 4099
F852 2145 4477
Chief Manufacturing, a products division
of Milestone AV Technologies
8800-002266 Rev00
2012 Milestone AV Technologies, a
Duchossois Group Company
www.chiefmfg.com
11/12
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

Chief FCA540 Installation guide

Category
Wall & ceiling mounts accessories
Type
Installation guide

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages