Falcon Classic 110 Dual Fuel User guide

Brand: Falcon

Model: Classic 110 Dual Fuel

Category: Cookers

Type: User guide

This manual is also suitable for

Britain’s No.1 Range Cooker

USER GUIDE &

INSTALLATION INSTRUCTIONS

Kitchener 110 Dual Fuel

Professional+ 110 Dual Fuel

RANGEMASTER COOKWARE

Our range cookers are well known for providing

the best possible cooking performance and years

of faithful service. However, a great cooker alone

cannot guarantee perfect results every time. The

other vital ingredients are of course enthusiasm

and quality cookware.

We oer cookware to work perfectly with all

fuel types manufactured by Rangemaster,

including induction hobs. You can be assured of

functionality with style, as well as the quality and

meticulous attention to detail you expect from the

pioneers of range cooking.

www.rangemastercookshop.co.uk

Ingredients

• Oil for greasing

• 100 g strawberries

• 100 g raspberries

• 100 g redcurrants

• 100 g blackberries

• or a 400 g mixture of any soft

fruits

• 2 medium eggs

• 30 g caster sugar

• 80 ml skimmed milk

• 2 tsp vanilla extract

• 60 g plain our (sifted)

• 1 tsp baking powder

• Icing sugar to dust

Method

1. Preheat the oven to 200 °C (for a conventional oven),

180

C (for a fan oven) or gas mark 6.

2. Lightly grease a dish 26 cm wide x 4 cm deep.

3. Thickly slice any large strawberries and place them with the other fruits

into an ovenproof dish, deep enough so the berries are about 2 deep.

4. Whisk the eggs and caster sugar until pale and uy. Beat the milk and

vanilla extract into the mixture and then fold in the sifted our and

baking powder.

5. Pour the cake mix over the fruit and bake on the centre shelf of the

oven for 15-20 minutes, or until the mixture is cooked through and

golden on the top.

6. Dust with icing sugar and serve immediately with cream or crème

fraiche.

FRUITY BAKED PUDDING

Serves 4–6

Ingredients

• 3 kg (6½ lb) skinned and

boned loin of pork

• 2 x 70 g packs prosciutto

• Grated zest of 2 lemons

• Bay leaves

• Salt and freshly ground

black pepper

For the sauce:

• 1 tablespoons plain our

• 4 tablespoons lemon

juice

• Chicken stock/water

Method

1. Preheat the oven to 220 °C (for a conventional oven), 200 °C (for a fan

oven) or gas mark 7.

2. Spread one of the packs of prosciutto over a chopping board; place

the pork on top with the outer (fat) part of the pork resting on the

prosciutto.

3. Sprinkle the lemon zest onto the inside of the meat and season well. Lay

the remaining prosciutto on top of the zest and roll up.

4. Secure the pork with string or silicone bands and thread bay leaves

under the string, covering the whole piece of pork. Put the meat on to

a trivet over a large roasting tin containing enough water to cover the

base.

5. Place into the oven and cook for 30 minutes. Reduce the heat to 180 °C

conventional oven/160 °C fan oven/gas 4 and continue roasting for a

further 25 minutes per 500 g. Should the prosciutto start becoming too

brown, cover with some foil.

6. When the pork is cooked, place onto a warm plate, cover with foil and

allow to rest for at least 20 minutes.

7. Spoon o most of the fat from the roasting tin and stir the our into the

remaining. Gradually add the stock and lemon juice, adding more stock

until the desired consistency is reached and simmer for 5 minutes. Check

the seasoning, adding more pepper or lemon juice as necessary.

8. Remove the string or bands from the pork and carve into slices, serve

with the sauce.

ROAST LOIN OF PORK WITH PROSCIUTTO

& BAY LEAVES

iii

Kitchener/Professional+ 110 Dual Fuel U110109-05

Contents

1. Before You Start… 1

Important! 1

Installation and Maintenance 1

Peculiar Smells 1

If You Smell Gas 1

Ventilation 1

Personal Safety 1

Cooker Care 2

Cleaning 2

2. Cooker Overview 3

Hotplate Burners 3

Wok Burner 4

The Wok Cradle (optional) 5

The Griddle

(optional) 5

The Grill / Glide-out Grill 6

The Ovens 7

Operating the Ovens 7

The Browning Element 7

The 2-button LCD Clock 8

The 6-button Clock (Kitchener) 10

Accessories 12

Main Oven Lights 12

Storage 12

3. Cooking Tips 13

Tips on Cooking with the Timer 13

General Oven Tips 13

4. Cooking Table 14

5. Cleaning Your Cooker 15

Essential Information 15

Hotplate Burners 15

Grills 16

Control Panel and Doors 17

Ovens 17

Cleaning Table 18

6. Troubleshooting 19

7. Installation 21

Dear Installer 21

Safety Requirements and Regulations 21

Provision of Ventilation 21

Location of Cooker 22

Conversion 22

Positioning the Cooker 23

Moving the Cooker 23

Fitting the Stability Bracket or Chain 24

Repositioning the Cooker Following

Connection 24

Conversion to Another Gas 25

Levelling 25

Gas Connection 25

Electrical Connection 26

Final Checks 27

Final Fitting 27

Customer Care 27

8. Conversion to LP Gas 28

Injectors 28

Tap Adjustment 28

Stick on Label 28

Pressure Testing 28

9. Circuit Diagram 29

10. Technical Data 30

Kitchener 30

Professional+ 31

Hotplate Eciency 32

Oven Data 33

This User Guide covers a number of dierent models.

Although some of the illustrations will look dierent to

your particular model the functions will be the same. We

hope the meaning is clear.

Your cooker should give you many years of trouble-free

cooking if installed and operated correctly. It is important

that you read this section before you start, particularly if you

have not used a dual fuel cooker before.

Important!



CAUTION: This appliance is for cooking purposes

only. It must not be used for other purposes, for

example room heating. Using it for any other

purpose could invalidate any warranty or liability

claim. Besides invalidating claims this wastes fuel

and may overheat the control knobs.

Installation and Maintenance

This cooker must be installed in accordance with the relevant

instructions in this booklet, with the relevant national and

local regulations, and with the local gas and electricity supply

companies’ requirements.

Make sure that the gas supply is turned on and that the

cooker is wired in and switched on (the cooker needs

electricity).

Set the clock to make sure that the oven is functional – see

the relevant section in this manual.

It is recommended that this appliance is serviced annually.

Only a qualied service engineer should service the cooker,

and only approved spare parts should be used.

Always allow the cooker to cool and then switch it o at the

mains before cleaning or carrying out any maintenance work,

unless specied otherwise in this guide.

Peculiar Smells

When you rst use your cooker it may give o an odour. This

should stop after use.

Before using your cooker for the rst time, make sure that all

packing materials have been removed and then, to dispel

manufacturing odours, turn all the ovens to 200 °C and run

for at least an hour.

Before using the grill for the rst time you should also turn on

the grill and run for 30 minutes with the grill pan in position,

pushed fully back, and the grill door open.

Make sure the room is well ventilated to the outside air

(see ‘Ventilation’ below). People with respiratory or allergy

problems should vacate the area for this brief period.

If You Smell Gas

• DO NOT turn electric switches on or off

• DO NOT smoke

• DO NOT use naked flames

• DO turn off the gas at the meter or cylinder

• DO open doors and windows to get rid of the gas

• DO keep people away from the area affected

• Call your gas supplier

Ventilation



CAUTION: The use of a gas cooking appliance results

in the production of heat and moisture in the room

in which it is installed. Therefore, make sure that the

kitchen is well ventilated: keep natural ventilation

holes open or install a powered cooker hood that

vents outside. If you have several burners on, or use

the cooker for a long time, open a window or turn on

an extractor fan.

Personal Safety



DO NOT modify this appliance.



This appliance can be used by children aged from 8

years and above and persons with reduced physical,

sensory or mental capabilities or lack of experience

and knowledge if they have been given supervision

or instruction concerning use of the appliance in

a safe way and understand the hazards involved.

Children shall not play with the appliance. Cleaning

and user maintenance shall not be made by children

without supervision.



WARNING: The appliance and its accessible parts

become hot during use and will retain heat even

after you have stopped cooking. Care should be

taken to avoid touching heating elements. Children

less than 8 years of age shall be kept away unless

continuously supervised.



This appliance is not intended for use by young

children or inrm persons unless they have been

adequately supervised by a responsible person to

make sure that they can use the appliance safely.



CAUTION: A long term cooking process has to be

supervised from time to time. A short term cooking

process has to be supervised continuously.



Danger of re: DO NOT store items on the cooking

surfaces.



To avoid overheating, DO NOT install the cooker

behind a decorative door.



Accessible parts will become hot during use and will

retain heat even after you have stopped cooking.

Keep babies and children away from the cooker and

never wear loose-tting or hanging clothes when

using the appliance.

1. Before You Start…



DO NOT use a steam cleaner on your cooker.

Always be certain that the controls are in the OFF position

when the oven is not in use, and before attempting to clean

the cooker.



When the ovens are on, DO NOT open the doors

for longer than necessary to insert and remove

contents. The control knobs will become hot and

may cause cosmetic failure.



When using the grill, make sure that the grill pan

is in position and pushed fully in, otherwise the

control knobs may become very hot.



DO NOT use harsh abrasive cleaners or sharp metal

scrapers to clean the oven door glass or glass lid

since they can scratch the surface, which may result

in shattering of the glass.

Always keep combustible materials, e.g. curtains, and

ammable liquids a safe distance away from your cooker.



DO NOT spray aerosols in the vicinity of the cooker

while it is on.

Use dry oven gloves when applicable – using damp gloves

might result in steam burns when you touch a hot surface.

Do not use a towel or other bulky cloth in place of a glove – it

might catch re if brought into contact with a hot surface.



NEVER operate the cooker with wet hands.



DO NOT use aluminium foil to cover shelves, linings

or the oven roof.



DO NOT use hotplate protectors, foil or hotplate

covers of any description. These may aect the safe

use of your hotplate burners and are potentially

hazardous to health.



NEVER heat unopened food containers. Pressure

build up may make the containers burst and cause

injury.



DO NOT use unstable saucepans. Always make sure

that you position the handles away from the edge of

the hotplate.



DO NOT use cooking vessels on the hotplate that

overlap the edges.

Never leave the hotplate unattended at high heat settings.

Pans boiling over can cause smoking, and greasy spills may

catch on re. Use a deep fat thermometer whenever possible

to prevent fat overheating beyond the smoking point.



WARNING!

Unattended cooking on a hob with fat or oil can be

dangerous and may result in re.



NEVER leave a chip pan unattended. Always heat fat

slowly, and watch as it heats. Deep fry pans should

be only one third full of fat. Filling the pan too full

of fat can cause spill over when food is added. If you

use a combination of oils or fats in frying, stir them

together before heating, or as the fats melt.

Foods for frying should be as dry as possible. Frost on frozen

foods or moisture on fresh foods can cause hot fat to bubble

up and over the sides of the pan. Carefully watch for spills or

overheating of foods when frying at high or medium high

temperatures. Never try to move a pan of hot fat, especially a

deep fat fryer. Wait until the fat is cool.

Do not use the top of the ue (the slots along the back of

the cooker) for warming plates, dishes, drying tea towels or

softening butter.



DO NOT use water on grease res and never pick

up a aming pan. Turn the controls o and then

smother a aming pan on a surface unit by covering

the pan completely with a well tting lid or baking

tray. If available, use a multi-purpose dry chemical

or foam-type re extinguisher.

Cooking high moisture content foods can create a ‘steam

burst’ when the oven door is opened (Fig. 1.1). When

opening the oven stand well back and allow any steam to

disperse.

Take care that no water seeps into the appliance.



This appliance is heavy so take care when moving it.



The appliance is not intended to be operated by

means of external timer or separated remote-control

system.

Cooker Care

As steam can condense to water droplets on the cool outer

trim of the oven, it may be necessary during cooking to wipe

away any moisture with a soft cloth. This will also help to

prevent soiling and discolouration of the oven exterior by

cooking vapours.

Cleaning

In the interests of hygiene and safety, the cooker should be

kept clean at all times as a build up in fats and other food

stu could result in a re.

Clean only the parts listed in this guide. Clean with caution. If

a wet sponge or cloth is used to wipe spills on a hot surface,

be careful to avoid steam burns. Some cleaners can produce

noxious fumes if applied to a hot surface.

ArtNo.324-0001 Steam burst

Fig. 1.1

ArtNo.270-0001

Proplus control to high

The 110 dual fuel cooker (Fig. 2.1) has the following features:

A. 6 hotplate burners including a wok burner

B. Control panel

C. Glide-out grill

D. Conventional oven

E. Programmable fan oven

F. Storage drawer

Hotplate Burners

The drawing by each of the central knobs indicates which

burner that knob controls.

Each burner has a Flame Supervision Device (FSD) that

prevents the ow of gas if the ame goes out.

When the igniter button is pressed in, sparks will be

made at every burner – this is normal. Do not attempt to

disassemble or clean around any burner while another

burner is on, otherwise an electric shock could result.

To light a burner, press the igniter button, and push in and

turn the associated control knob to the high position as

indicated by the large ame symbol (), (Fig. 2.2).

Professional +

2. Cooker Overview

Fig. 2.1

Fig. 2.2

DocNo.020-0021 - Overview - 110DF - Kitchener-Prof+

ArtNo.311-0002 Pan with rim

The igniter should spark and light the gas. Keep holding the

knob pressed in to let the gas through to the burner for about

ten seconds.

If, when you let go of the control knob, the burner goes out,

then the FSD has not been bypassed. Turn the control knob

to the OFF position and wait for one minute before you try

again, this time making sure to hold in the control knob for

slightly longer.

Adjust the ame height to suit by turning the knob counter-

clockwise (Fig. 2.3).

Note: If a burner ame goes out, turn o the control knob

and leave it for one minute before relighting it.

Make sure that the ames are under the pans. Using a lid will

help the contents boil more quickly (Fig. 2.4).

Large pans should be spaced well apart.

Pans and kettles with concave bases or down-turned base

rims should not be used (Fig. 2.5).

Simmering aids, such as asbestos or mesh mats, are

NOT recommended (Fig. 2.6). They will reduce burner

performance and could damage the pan supports.

You should also avoid using unstable and misshapen pans

that may tilt easily, and pans with a very small base diameter,

e.g. milk pans, single egg poachers (Fig. 2.7).

The minimum recommended pan diameter is 120 mm. The

maximum allowable pan base diameter is 260 mm.

DO NOT use cooking vessels on the hotplate that overlap the

edges.

Wok Burner

The wok burner is designed to provide even heat over a large

area. It is ideal for large pans and stir-frying (Fig. 2.8).

For heating smaller pans, the aforementioned hotplate

burners may be more ecient.

You should wipe the enamel top surface of the cooker around

the hotplate burners as soon as possible after spills occur. Try

to wipe them o while the enamel is still warm.

Note: The use of aluminium pans may cause metallic marking

of the pan supports. This does not aect the durability of the

enamel and may be cleaned o with an appropriate metal

cleaner.

ArtNo.311-0001 Right pans gas

ArtNo.270-0003

Proplus control to low

Art No. 311-0003 Simmer aids

ArtNo.311-0004 Tipping wok

ArtNo.311-0005 Wok burner & pan support

Fig. 2.3

Fig. 2.4

Fig. 2.5

Fig. 2.6

Fig. 2.7

Fig. 2.8

The Wok Cradle (optional)

The wok cradle is designed to t a 35 cm wok. If you use a

dierent wok, make sure that it ts the cradle. Woks vary very

widely in size and shape. It is important that the wok sits

down on the pan support – however, if the wok is too small,

the cradle will not support it properly (Fig. 2.9).

The cradle should be used on the wok burner only. When

you t the cradle, check that it is located properly on the pan

support and that the wok is sitting level in the cradle (Fig.

2.10).

The cradle will get very hot in use – allow plenty of time for it

to cool before you pick it up.

The Griddle (optional)

The griddle ts the centre left pan support, front to back (Fig.

2.11). It is designed for cooking food on directly. DO NOT use

pans of any kind on it. The griddle surface is non-stick and

metal cooking utensils (e.g. spatulas) will damage the surface.

Use heat resistant plastic or wooden utensils.



DO NOT put it crossways – it will not t properly and

will be unstable (Fig. 2.12).



DO NOT put it on any other burner – it is not

designed to t in any of the other pan supports.

Position the griddle over the hotplate burners resting on the

pan support. Check that it is securely located.

The griddle can be lightly brushed with cooking oil before

use (Fig. 2.13). Light the hotplate burners. Adjust the ame

heights to suit.

Preheat the griddle for a maximum of 5 minutes before

adding food. Leaving it longer may cause damage. Turn the

control knobs towards the low position, marked with the

small ame symbol, to reduce the burner ames.



Always leave space around the griddle for the gases

to escape.



NEVER t two griddles side by side (Fig. 2.14).

After cooking, allow the griddle to cool before cleaning.

ArtNo.110-0013 Positioning the griddle on hotplate (right)

ArtNo.110-0014 Positioning the griddle on hotplate (wrong)

ArtNo.311-0006 Correct wok sizes

ArtNo.311-0007 Wok stand close-up

ArtNo.311-0009 Oil on griddle

ArtNo.311-0008 Griddle positioning

Fig. 2.9

Fig. 2.10

Fig. 2.11

Fig. 2.12

Fig. 2.13

Fig. 2.14

The Grill / Glide-out Grill



CAUTION: This appliance is for cooking purposes

only. It must not be used for other purposes, for

example room heating.



CAUTION: Accessible parts may be hot when the grill

is in use. Young children should be kept away.

Open the door and pull the grill pan (Fig. 2.15) or carriage

(Fig. 2.16) forward using the handle.

The grill has two elements that allow either the whole area of

the pan to be heated or just the right-hand half.

Adjust the heat to suit by turning the knob. To heat the whole

grill, turn the knob clockwise (Fig. 2.17).

To heat the right-hand half, turn the knob counter-clockwise.

The neon indicator light by the grill control will come on.

For best results, leave the grill pan in the grill chamber and

preheat the appropriate part(s) of the grill for two minutes.

The grill trivet can be removed and the food placed on it

while you are waiting for the grill to preheat.



DO NOT leave the grill on for more than a few

moments, without the grill pan underneath it,

otherwise the knobs may become hot.

Once the grill has preheated, take the grill pan out again and

put the trivet back in place with the food on it. Slide the grill

pan or carriage back into the grill chamber. Make sure that it

is pushed right in.

The grill pan trivet can be turned over to give two grilling

positions (Fig. 2.18).



Never close the grill door when the grill is on.

ArtNo.331-0002 Grill pan high/low position

ArtNo.330-0003 - Grill pan w handle pulled forwards

ArtNo.235-0007 - Classic

DL grill control

ArtNo.331-0001Grill pan pulled forwards

Fig. 2.15

Fig. 2.16

Fig. 2.17

Fig. 2.18

The Ovens

The clock must be set to the time of day before the right-

hand oven will work. See the following section on ‘The

Clock’ for instructions on setting the time of day.

References to ‘left-hand’ and ‘right-hand’ ovens apply as viewed

from the front of the appliance.

The left-hand oven is a conventional oven, while the right-

hand oven is a fan oven.

The Conventional Oven

The left-hand oven is a conventional oven and has two

heating elements – one visible in the top of the oven and the

other under the oven base.

Note: Be careful to avoid touching the top element and

element deector when placing or removing items from the

oven.

The exposed top element may cook some foods too quickly,

so we recommend that the food be positioned in the lower

half of the oven to cook. The oven temperature may also need

to be lowered.

Similar items being cooked will need to be swapped around

for even cooking.

The Fan Oven

The right-hand oven is a fan oven that circulates hot air

continuously, which means faster, more even cooking.

The recommended cooking temperatures for a fan oven are

generally lower than a conventional oven.

Note: Please remember that all cookers vary so temperatures

in your new ovens may dier to those in your previous

cooker.

Operating the Ovens

Turn the oven knob to the desired temperature (Fig. 2.19).

The oven indicator light will glow until the oven has reached

the temperature selected. It will then cycle on and o during

cooking (Fig.2-20).

The Browning Element

The browning element is positioned in the top of the left-

hand oven. It can be used at the end of a normal cooking

period to give extra browning to au gratin dishes or give a

crisper nish to meat.

After the normal cooking is nished turn the left-hand

oven thermostat knob clockwise to the browning position,

indicated by (

ArtNo.030-0003 Browning

element symbol

) on the fascia panel.

Only the browning element will operate when the thermostat

is turned to this position. The top and base cooking elements

will switch o automatically.

ArtNo.235-0005 - Classic

DL oven control 2

ArtNo.235-0004 -

Classic DL oven 1

Fig. 2.19

Fig. 2.20

The 2-button LCD Clock

You can use the clock to turn the left-hand oven on and o.

The clock must be set to the time of day before the oven

will work.

Setting the Clock

The 2-button LCD clock can only display a 24 hour clock. The

Multifunction Oven on the left will not operate unless the

clock has been set.

1. Once the cooker is connected and switched on, the

display will start to ash.

2. To set the time, turn and hold the Timer (A) knob to

the Clock (C) setting and at the same time turn the

Adjusting (B) knob either clockwise or counter-clockwise

(Fig. 2.21).

Once you have set the time release the Timer (A) knob.

Setting the Minute Minder

A Minute Minder (E) is a feature that can be set for a number

of minutes and sounds an alarm once the specied amount

of time has elapsed.

1. Turn the Timer (A) knob to the Minute Minder (E)

setting (Fig. 2.22).

2. Turn the Adjusting (B) knob to set the amount of time

required. e.g. 20 seconds (Fig. 2.23).

3. Turn the Timer (A) knob to the Manual (D) setting to

see the current time and the ‘Bell’ symbol on the display

(Fig. 2.24).

4. Once the specied time has elapsed it will emit an alarm.

There are two ways to cancel the alarm:

I. Turn the Adjusting (B) knob counter-clockwise or

clockwise (Fig. 2.25).

II. Turn either the Timer (A) knob to the Clock (C) or to

the Minute Minder (E) setting. Return to Manual (D)

for normal cooking mode (Fig. 2.25).

• The ‘cook period’, which is the length of time you

want the oven to cook for.

• The ‘stop time’, which is the time of day you want the

oven to stop cooking.

ArtNo.300-0005 2BC

minute minder setting

A B

ArtNo.300-0006 2BC

minute minder setting 2

A B

ArtNo.300-0005 2BC

minute minder setting

A B

ArtNo.301-0007 2BC

Stopping the oven 1

A B

A – Timer knob, B – Adjusting knob

Fig. 2.21

Fig. 2.22

Fig. 2.23

ArtNo.300-0006 2BC

minute minder setting 2

A B

Fig. 2.24

Fig. 2.25

To Stop the Multifunction Oven at a Speciﬁc

Time of Day

You have set the required temperature and function mode for

the Multifunction Oven and you would like the Multifunction

Oven to automatically stop.

TOP TIP

Make a note of the current time so you do not forget.

1. Turn the Timer (A) knob to the Stop Time (G) setting

(Fig. 2.26).

2. Turn the Adjusting (B) knob clockwise, the display will

show the current time of day (Fig. 2.26).

3. Continue to turn the Adjusting (B) knob to the amount

of time required e.g. 1 minute. The display will show the

current time plus the required length of time you have

set (Fig. 2.27).

4. Turn the Timer (A) knob to the Auto (H) setting (Fig.

2.27). The display will show the current time, the Cooking

symbol and the word ‘AUTO’ (Fig. 2.27).

5. Once the specied time has elapsed it will emit an alarm

and the Multifunction Oven will stop working. The

‘Cooking’ symbol on the display will disappear and the

word ‘AUTO’ will ash (Fig. 2.28).

6. When you return, turn the Timer (A) knob to the Manual

(D) setting to return to manual cooking and reset the

Multifunction Oven modes once cooking is complete

(Fig. 2.28).

7. Once the specied time has elapsed it will emit an alarm.

There are two ways to cancel the alarm:

I. Turn the Adjusting (B) knob counter-clockwise or

clockwise (Fig. 2.29).

II. Turn either the Timer (A) knob to the Clock (C) or to

the Minute Minder (E) setting. Return to Manual (D)

for normal cooking mode (Fig. 2.29).

NOTE

If the alarm is not manually switched o it will stop after

approximately 2 minutes.

ArtNo.301-0008 2BC

Stopping the oven 2

A B

ArtNo.301-0007 2BC

Stopping the oven 1

A B

ArtNo.301-0007 2BC

Stopping the oven 1

A B

ArtNo.301-0008 2BC

Stopping the oven 2

A B

Fig. 2.26

Fig. 2.27

Fig. 2.28

Fig. 2.29

Reset to Manual Cooking

To cancel any automatic settings turn the Timer (A) knob to

the Clock (C) setting and release (Fig. 2.32).

Key Lock

The Key Lock will activate and deactivate the left-hand oven.

The right-hand tall oven can be operated as usual.

1. Cancel any active programs. Refer to ‘Reset to Manual

Cooking’.

2. Turn the Timer (A) knob to the Clock (C) setting and hold

for approx 8 seconds. The display will show ‘ON’ (Fig.

2.33).

3. Continue to hold the Timer (A) knob onto the Clock (C)

setting, turn the Adjusting (B) knob clockwise, the ‘OF‘

and the ‘Key’ symbol will display (Fig. 2.34). The left-

hand oven is now locked.

4. To activate repeat steps 1 to 2 and continue to hold

the Timer (A) knob onto the Clock (C) setting, turn the

Adjusting (B) knob clockwise to ‘ON’, the ‘Key’ symbol

will disappear and the left-hand oven is enabled.

The 6-button Clock (Kitchener)

Setting the Clock

The 6-button LCD clock is shown in Fig. 2.35. When the

clock is rst connected the display ashes ( 0.00 ) and (



)

alternately.

Press and hold both the [



] and [



] buttons down

(Fig. 2.36). now press the [+] button (or the [–] button) until

the correct time shows.

Do not forget that it is a 24-hour clock.

If you need to reset the cooker, turn o the power supply and

wait for a couple of minutes and start again.

Setting the Minute Minder

Press and hold the [



] button (Fig. 2.37), and then press the

[+] button until the length of time you want to cook for is

shown (Fig. 2.38).

You can check the time remaining by pressing [



]. When the

beeper sounds cancel it by pressing [



• The ‘cook period’, which is the length of time you

want the oven to cook for.

• The ‘stop time’, which is the time of day you want the

oven to stop cooking.

To Stop the Oven Automatically

Press and hold the Stop Time [



] button (Fig. 2.30) and then

press the [+] button (or [–] button) until the required ‘stop

time’ shows (Fig. 2.31). AUTO will show in the display.

Once the ‘stop time’ is reached, the beeper sounds. To stop the

beep turn the oven control knob to 0 rst and then press [



]

once; press [



] again to return to manual cooking.

ArtNo.302-0001 - 6-button clock

ArtNo.302-0003 - 6BC

minute minder setting 1

ArtNo.302-0004 -

Minute minder setting 2

ArtNo.302-0005 -

6BC Stopping the oven 1

ArtNo.302-0002 - 6BC annotated

A B C D E F

ArtNo.302-0005a -

6BC Stopping the oven 1a

A – Minute minder, B – ‘Cook’ time, C – ‘Stop’ time,

D – Manual, E & F – Time setting buttons

Fig. 2.30 Fig. 2.31

Art No. 301-0011 2BC

Activating the key lock 1

A B

ArtNo.301-0012 2BC

Activating the key lock 2

A B

ArtNo.301-0007 2BC

Stopping the oven 1

A B

Fig. 2.32

Fig. 2.33 Fig. 2.34

Fig. 2.35

Fig. 2.36

Fig. 2.37 Fig. 2.38

ArtNo.302-0006 - 6BC

setting the cook time

ArtNo.302-0006 - 6BC

setting the cook time

ArtNo.302-0005 -

6BC Stopping the oven 1

ArtNo.302-0005a -

6BC Stopping the oven 1a

Fig. 2.39

Fig. 2.41

Fig. 2.40

Fig. 2.42

To Start and Stop the Oven Automatically

Before you set the clock you must have two numbers clearly

in mind – the ‘cook period’ and the ‘stop time’.

Note: You cannot set a start time directly – this is set

automatically by setting the ‘cook period’ and the ‘stop time’.

Press and hold the [



] button (Fig. 2.39) and then press the

[+] button (or [–] button) until the required ‘cook period’ shows

(Fig. 2.40).

now press and hold the [



] button (Fig. 2.41) and then press

the [+] button (or [–] button) until the required ‘stop time’

shows (Fig. 2.42). Release the buttons.

AUTO will now show in the display.

Set the oven to the required temperature. When cooking is

nished the beeper will sound. Turn the oven knob to the OFF

position rst, and then press the [



] button once to stop the

beep; press it again to return to manual cooking.

If you are out, do not worry about the beeper going o, it

stops after a while. When you return, turn the oven knob to

0rst, and then press [



] twice to return to manual cooking.

Reset to Manual Cooking

To return to manual cooking from any automatic setting,

the ‘cook period’ must be cancelled. Press and hold the [



]

button and then press the [–] button until the display reads

( 0.00 ).

Press the [



] button to return to manual cooking.

Key Lock

Activating the key lock will lock the programmable oven and

it will not come on.

To Activate the Key Lock

Make sure that the clock is in manual mode and cancel

any active programs.

Hold the [



] and [



] buttons. When ‘On’ appears on the

display (Fig. 2.43) press the [+] button once. The key symbol

[



] and ‘OF’ will now show on the display (Fig. 2.44). Release

the buttons.

The programmable oven is now locked, as conrmed by the

display showing the time of day alongside the key symbol [



]

(Fig. 2.45).

To Turn O the Key Lock

Hold the [



] and [



] buttons. When ‘OF’ appears on the

display (Fig. 2.46) press the [+] button once. The key symbol

[



] will go out and ‘On’ will show on the display (Fig. 2.47).

Release the buttons.

After a few seconds the display will revert to show the time of

day.

The oven can now be used normally.

ArtNo.302-0010 -

Activating the key lock 3

ArtNo.302-0008 -

Activating the key lock 1

ArtNo.302-0009 - Activating

the key lock 2

ArtNo.302-0011 - 6BC

Deactivating the key lock 1

ArtNo.302-0012 -

Deactivating the key lock 2

Fig. 2.43 Fig. 2.44

Fig. 2.45

Fig. 2.46

Fig. 2.47

Shelf guard

Front

ArtNo.320-0011 Removing the shelf 1

ArtNo.320-0013 Removing the shelf 3

ArtNo.320-0012 Removing the shelf 2

ArtNo.320-0014 Handyrack on LH door

ArtNo.320-0015

Fitting the Handyack 1

ArtNo.320-0016

Fitting the handyrack 2

Fig. 2.48

Fig. 2.49 Fig. 2.50

Fig. 2.51 Fig. 2.52

Fig. 2.53 Fig. 2.54

Accessories

Oven Shelves

The oven shelves (Fig. 2.48) are retained when pulled

forward but can be easily removed and retted.

Pull the shelf forward until the back of the shelf is stopped by

the shelf stop bumps in the oven sides (Fig. 2.49).

Lift up the front of the shelf so the back of the shelf will pass

under the shelf stop and then pull the shelf forward

(Fig. 2.50).

To ret the shelf, line up the shelf with a groove in the oven

side and push the shelf back until the ends hit the shelf stop.

Lift up the front so the shelf ends clear the shelf stops, and

then lower the front so that the shelf is level and push it fully

back (Fig. 2.51).

The Handyrack (Main Oven)

The Handyrack (Fig. 2.52) ts to the left-hand oven door

only. Food cooking on it is easy to attend to, because it is

accessible when the door is open.

The maximum weight that can be held by the Handyrack

is 5.5 kg (12 lb). It should only be used with the supplied

roasting tin, which is designed to t the Handyrack. Any other

vessel could be unstable.

It can be tted at two dierent heights. One of the oven

shelves must be removed and the other positioned to suit.

When the Handyrack is used in its highest position, other

dishes can be cooked on the bottom shelf position or base of

the oven.

When the Handyrack is used in its lowest position, other

dishes can be cooked on the second shelf position or base of

the oven.

To t the Handyrack, locate one side of it on the door bracket

(Fig. 2.53). Then spring the other side out to clip it onto the

other bracket (Fig. 2.54).

Main Oven Lights

Press the button to turn the lights on (Fig. 2.55).

If an oven light fails, turn o the power supply before

changing the bulb. See the ‘Troubleshooting’ section for

details on how to change the bulb.

Storage

The bottom drawer is for storing oven trays and other

cooking utensils. It can get very warm, so do not store

anything in it that may melt or catch re.

The drawer can be removed completely by pulling it right out

and up (Fig. 2.56).

ArtNo.320-0017

Main oven light

ArtNo.340-0002 110 removing the drawer

Fig. 2.55

Fig. 2.56

3. Cooking Tips

Tips on Cooking with the Timer

If you want to cook more than one dish, choose dishes that

require approximately the same cooking time. However,

dishes can be ‘slowed down’ slightly by using small containers

and covering them with aluminium foil, or ‘speeded up’

slightly by cooking smaller quantities or placing them in

larger containers.

Very perishable foods such as pork or sh should be avoided

if a long delay period is planned, especially in hot weather.



DO NOT place warm food in the oven to be timed.



DO NOT use a timed oven that is already warm.



DO NOT use the timed oven if the adjoining oven is

already warm.

Whole poultry must be thoroughly defrosted before being

placed in the oven. Check that meat and poultry are fully

cooked before serving.

General Oven Tips

The wire shelves should always be pushed rmly to the back

of the oven.

Baking trays with food cooking on them should be placed

level with the front edge of the oven’s wire shelves. Other

containers should be placed centrally. Keep all trays and

containers away from the back of the oven, as overbrowning

of the food may occur.

For even browning, the maximum recommended size of a

baking tray is 340 mm (13½”) by 340 mm (13½”).

When the oven is on, do not leave the door open for

longer than necessary, otherwise the knobs may get very

hot.

• Always leave a “finger’s width” between dishes on the same

shelf. This allows the heat to circulate freely around them.

• To reduce fat splashing when you add vegetables to hot fat

around a roast, dry them thoroughly or brush lightly with

cooking oil.

• Where dishes may boil and spill over during cooking, place

them on a baking tray.

• The ‘Cook & Clean’ oven liners (see ‘Cleaning Your Cooker’)

work better when fat splashes are avoided. Cover meat

when cooking.

• Sufficient heat rises out of the oven while cooking to warm

plates in the grill compartment.

• If you want to brown the base of a pastry dish, preheat the

baking tray for 15 minutes before placing the dish in the

centre of the tray.

4. Cooking Table

ArtNo.050-0007

Oven shelf positions

Oven Shelf Positions

Top (T)

Centre (C)

Base (B)

The oven control settings and cooking times given in the table below are intended to be used

AS A GUIDE ONLY. Individual tastes may require the temperature to be altered to provide a

preferred result.

Food is cooked at lower temperature in a fan oven than in a conventional oven. When using

recipes, reduce the fan oven temperature by 10 °C and the cooking time by 5-10 minutes. The

temperature in the fan oven does not vary with height in the oven so you can use any shelf.

Food

Meat

Beef (no bone)

Lamb

Pork

Poultry

Chicken

Turkey

Duck

Casserole

Yorkshire Pudding

Cake

Very rich fruit - Christmas,

wedding, etc.

Fruit 180 mm tin

Fruit 230 mm tin

Madeira 180 mm

Small cakes

Scones

Victoria sandwich

180 mm tin

210 mm tin

Desserts

Shortcrust tarts

Fruit pies

Tartlets

Puff pastry

Meringues

Baked egg custard

Baked sponge pudding

Milk pudding

Bread

Fish

Fillet

Whole

Steak

Approximate Cooking Time

30-35 minutes per 500g +30-35 minutes.

20-25 minutes per 500g +20-25 minutes.

30-35 minutes per 500g +30-35 minutes.

25-30 minutes per 500g +25-30 minutes.

35-40 minutes per 500g +35-40 minutes.

25-30 minutes per 500g +25-30 minutes.

20-25 minutes per 500g +20-25 minutes.

15-20 minutes per 500g +15-20 minutes.

20 minutes per 500g +20 minutes.

15 minutes per 500g +15 minutes.

25-30 minutes per 500g.

20 minutes per 500g.

2-4 hours according to recipe.

Large tins 30-35 minutes; individual 10-20 minutes.

45-50 minutes per 500g of mixture.

2-2½ hours.

Up to 3½ hours.

80-90 minutes.

15-25 minutes.

10-15 minutes.

20-30 minutes.

30-40 minutes.

20-30 minutes on a preheated tray.

35-45 minutes.

10-20 minutes according to size.

20-40 minutes according to size.

2-3 hours.

45-60 minutes.

40-45 minutes.

2 to 3 hours.

20-30 minutes.

15-20 minutes.

15-20 minutes per 500g.

Steaks according to thickness.

Conventional Oven

Temperature °C

(Shelf Position)

160 (C)

200 (C)

160 (C)

200 (C)

160 (C)

200 (C)

160 (C)

200 (C)

160 (C)

200 (C)

160 (C)

200 (C)

140-150 (C)

220 (C)

140 (C/B)

150 (C/B)

160 (C/B)

170 (C/B)

200 (C/B)

170 (C/B)

200 (C/B)

180 (C/B)

210 (C/B)

100 (C/B)

160 (C/B)

180 (C/B)

140-150 (C/B)

210 (C)

Fanned Grilling

190 (C/B)

Fan Oven

Temperature

°C

150

190

150

190

150

190

150

190

150

190

150

190

130-140

210

130

140

150

160

190

160

190

170

200

150

170

130-140

200

190 (C/B)

Thoroughly thaw frozen joints before

cooking. Meat may be roasted at

220°C (210°C for fan oven) and the

cooking time adjusted accordingly.

For stuffed and rolled meats, add

approximately 10 minutes per 500g,

or cook at 200°C (190°C) for 20

minutes then 160°C (150°C) for the

remainder.

For stuffed poultry, you could cook

at 200°C (190°C) for 20 minutes

then 160°C (150°C) for remainder.

Do not forget to include the weight

of the stuffing.

For fresh or frozen prepacked

poultry, follow instructions on the

pack. Thoroughly thaw frozen

poultry before cooking.

Using the conventional oven: when

two tier cooking leave at least one

runner space between shelves.

Position the baking tray with the

front edge along the front of the

oven shelf.

ArtNo.050-0001 Gas cooking table

Using the conventional oven: for

even browning the maximum size of

baking tray recommended is 340 mm

x 340 mm. This ensures free heat

circulation.

If cooking a two tier load, the trays

should be interchanged

approximately halfway though the

cooking time.

Up to three tiers can be cooked in a

fan oven at the same time but make

sure to leave at least one runner

space between each shelf being

cooked on.

T - Top; C - Centre; B - Base

DocNo.031-0004 - Cooking table - electric & fan single cavity

ArtNo.311-0032 Burner layout FSD

ArtNo.311-0033 Wok burner details FSD

ArtNo.311-0016 Fitting the burner inner head

A – Cap, B – Head, C – Notch, D – Base, E – Electrode

A – Inner burner cap, B – Outer burner cap, C – Inner burner head,

D – Outer burner head, E – Wok burner base

A – Electrode notch, B – Ignition electrode

Essential Information

Isolate the electricity supply before carrying out any

thorough cleaning. Allow the cooker to cool.



NEVER use paint solvents, washing soda, caustic

cleaners, biological powders, bleach, chlorine based

bleach cleaners, coarse abrasives or salt.



DO NOT mix dierent cleaning products – they may

react together with hazardous results.

All parts of the cooker can be cleaned with hot soapy water

– but take care that no surplus water seeps into the

appliance.

Remember to switch on the electricity supply and reset the

clock before re-using the cooker.

Hotplate Burners

The burner heads and caps can be removed for cleaning.



DO NOT put the burner heads in a dishwasher.

Make sure they are absolutely dry before replacing them.

The Single Ring Burners

When retting the burner head, make sure that the notch

lines up with the electrode or hole in the base. Check that the

burner head is level and that the cap is tted centrally on the

burner head (Fig. 5.1).

The Wok Burner

The wok burner can also be taken apart for cleaning.

When reassembling the wok burner (Fig. 5.2), turn over the

large base ring and nd the ‘D’ shaped area (Fig. 5.3). Turn

the head until the ‘D’ matches the one on the burner base.

Flip the burner over once again and place it on the burner

base.

To t the small inner burner, nd the larger electrode notch in

the burner rim. Line this up with the white ignition electrode

and place the inner burner on the large base ring (Fig. 5.4).

Now t the two burner caps, making sure that they are seated

properly.

Check the burner ports are not blocked. If a blockage occurs,

remove stubborn particles using a piece of fuse wire.

The Wok Cradle

Recommended cleaning materials are hot soapy water, a

moistened soap pad, cream cleaner or a nylon scourer.

DocNo.040-0007 - Cleaning - 110DF GENERIC

5. Cleaning Your Cooker

Fig. 5.1

Fig. 5.2

Fig. 5.3

Fig. 5.4

ArtNo.331-0001Grill pan pulled forwards

ArtNo.331-0003 Grill frame out, no pan

ArtNo.331-0004 Removing the grill frame

ArtNo.331-0005 Removing the grill rail

ArtNo.331-0006 Grill pan plan

Grills

The grill pan and trivet should be washed in hot soapy water.

Alternatively, the grill pan can be washed in a dishwasher.

After grilling meats or any foods that soil, leave to soak for a

few minutes immediately after use. Stubborn particles may

be removed from the trivet using a nylon brush.



Before you remove any of the grill parts for cleaning,

make sure that they are cool, or use oven gloves.

Cleaning the Glide-out Grill

The grill pan can be easily removed for cleaning as follows:

Remove the grill pan support frame by pulling the grill pan

forward (Fig. 5.5).

Lift the grill pan clear of the support frame.

The support frame

is held to the side rails by two clips on each side (Fig. 5.6).

For each side, support the side rail with one hand and with

the other hand lift the frame up and out of the side clips (Fig.

5.7).

For safety, push the side rails back into the grill chamber.

If you need to remove the side rails to allow cleaning of the

grill chamber, you can unhook them from the grill chamber

sides (Fig. 5.8) and wipe the sides clean with a soft cloth and

mild detergent.



DO NOT put the side runners in a dishwasher.

Once you have nished, hook the side rails back onto the

sides of the chamber. To ret the frame, pull the side rails

forward and, for each side in turn, support the side rail and

press the frame down into the side rails. Replace the grill pan.

When retting the grill pan, make sure that the wide rim is at

the front (Fig. 5.9).

Fig. 5.5

Fig. 5.6

Fig. 5.7

Fig. 5.8

Fig. 5.9

Page is loading ...

Falcon Classic 110 Dual Fuel User guide

Brand: Falcon

Model: Classic 110 Dual Fuel

Category: Cookers

Type: User guide

This manual is also suitable for

Download PDF

report

Falcon Classic 110 Dual Fuel User guide

This manual is also suitable for

Falcon Classic 110 Dual Fuel User guide

Related papers

Other documents