Powermate PM0524000 User manual

Powermate
Brand
Powermate
Model
PM0524000
Category
Power generators
Type
User manual

Powermate PM0524000 is a heavy-duty generator powered by an 8 HP Tecumseh engine with cast-iron cylinder sleeves for enhanced durability. It features multiple power outlets, including 120 V and 240 V duplex receptacles, providing versatility in powering various devices and appliances. The generator is equipped with circuit breakers to protect against overloads and short circuits, ensuring safe and reliable operation.

Powermate PM0524000 is a heavy-duty generator powered by an 8 HP Tecumseh engine with cast-iron cylinder sleeves for enhanced durability. It features multiple power outlets, including 120 V and 240 V duplex receptacles, providing versatility in powering various devices and appliances. The generator is equipped with circuit breakers to protect against overloads and short circuits, ensuring safe and reliable operation.

Page is loading ...
* 8 HP Tecumseh engine
* Cast-iron cylinder sleeves
* Receptacles on endbell
A. 120 V, 20 Ampere Duplex Receptacle
This duplex is split so that 20 amps of current may be
drawn from each half of the receptacle. However, total power
drawn must be kept within nameplate ratings. These
receptacles may be used along with the 240 volt receptacle
provided the generator is not overloaded.
B. 240 V, 15 Ampere Duplex Receptacle
A maximum of 15 amps may be drawn from these
receptacles provided they are the only receptacles used.
However, current must be limited to the nameplate rating.
If these receptacles are used along with the 120 volt
receptacles, the total load drawn must not exceed the
nameplate ratings.
C. Circuit Breakers
The receptacles are protected by an AC circuit breaker. If
the generator is overloaded or an external short circuit occurs,
the circuit breaker will trip. If this occurs, disconnect all
electrical loads and try to determine the cause of the problem
before attempting to use the generator again. If overloading
causes the circuit breaker to trip, reduce the load. NOTE:
Continuous tripping of the circuit breaker may cause
damage to generator or equipment. The circuit breaker may
be reset by pushing the button of the breaker.
This product is warranted by Coleman Powermate, Inc. to
the original retail consumer against defects in material and
workmanship for a period of one year from the date of retail
purchase and is not transferable. This one year warranty
applies only to products used in consumer applications. If this
generator is used in a commercial application, then the period
of warranty coverage is limited to ninety (90) days from the date
of purchase.
Please complete and return the enclosed Customer
Information Card so that we can reach you in the unlikely event
a safety recall is needed. Return of this card is not required to
validate this warranty.
WHAT IS COVERED: Replacement parts and labor.
WHAT IS NOT COVERED: Transportation charges to
Coleman Powermate, Inc. for defective products.
Transportation charges to consumer for repaired products.
Brushes, fuses, rubber feet, and receptacles. Damages
caused by abuse, accident, improper repair, or failure to
perform normal maintenance. Power units or engines which
are covered exclusively by the warranties of their manufacturer.
Sales outside of the United States or Canada. Any other
expense including consequential damages, incidental
damages, or incidental expenses, including damage to
property. Some states do not allow the exclusion or limitation
of incidental or consequential damages, so the above limitation
or exclusion may not apply to you.
IMPLIED WARRANTIES: Any implied warranties, including
the Implied Warranties of Merchantability and Fitness For A
Particular Purpose, are limited in duration to one (1) year from
the date of retail purchase. Some states do not allow
limitations on how long an implied warranty lasts, so the above
limitation may not apply to you.
HOW TO OBTAIN WARRANTY PERFORMANCE:
Replacement parts and service are available from Coleman
Powermate, Inc. Service Centers. Locate your nearest Service
Center by calling TOLL FREE 1-800-445-1805. In the unlikely
event a Service Center can not be located you may call
Coleman Powermate, Inc. for a return authorization number.
Any unit returned WITHOUT an authorization number will
be refused.
To the extent any provision of this warranty is prohibited by
federal, state, or municipal law, and cannot be preempted, it
shall not be applicable. This warranty gives you specific rights,
and you may also have other rights which vary from state to
state.
2
English
ENDBELL
MAJOR GENERATOR FEATURES LIMITED WARRANTY
(NOT VALID IN MEXICO)
Page is loading ...
Page is loading ...
Page is loading ...
6
PARTS LIST / LISTE DES PIÈCES / LISTA DE REPUESTOS
Ref Part Description Description Descripción Qty
No. No.
1 Note A Engine, 8 hp Tecumseh Moteur Motor 1
2 0054052 Adapter, engine Adapateur por moteur Adaptor, motor 1
3 0000901.01 Bolt, Wz 5/16-24 x 5/8 Boulon, wz Perno, wz 4
4 0049619 Rotor, 4.0 KW Rotor Rotor 1
5 Note B Washer, lock 5/16 Contre-écrou Arandela, de cierre 1
6 0049004 Bolt, hex 5/16-24 x 7 1/4 Boulon, tête hex Perno, hexagonal 1
7 0050469 Stator, 4.0 KW, 60 Hz Stator Stator 1
8A 0034801 Connector hsg. set, Jeu pr logemt prise, Conjunto de conectores
endbell couvre-enroul del alojamiento 1
8B 0056718 Connector, stator Jeu pr logemt prise, stator Conjunto de conectores stator 1
10 0048838.02 Endbell, wired complete Covre-enroulement Placea lateral
câblage complet cableado completo 1
10A 0048844 Brush, E-4R Balais Escobilla 2
10B 0035188 Bearing, needle Roulement à aiguilles Cojinete, aguja 1
10C 0034819.01 Capacitor Capaciteur Capacitor 1
10D 0034843.01 Diode Diode Diodos 2
10E 0038976 Heat sink, diode Diode dissipatrice Sumidero térmico, diodos
de chaleur 1
10F 0038968 Cover, brush Couvre-balais Cubierta, escobill 1
10G
0049071 Circuit breaker, 20 amp Disjoncteur 20 A Cortacircuitos, 20 amp
11 0034561 Bolt, hex hd 1/4-20 x 5 Boulon, tête hex Perno, hexagonal 4
12 0008854 Lug, ground Oeillet de mise à la terre Terminal, tierra 1
13 Note B Washer flat 1/4 Rondelles plates Arandela plana 4
15 0040832 Nut, nyloc 1/4-20 Écrous nyloc Tuerca, nyloc 4
16 0055223 Carrier assembly Ensemble transport Transportador, conjunto 1
19 0052185 Isolator, engine Sectionneurs moteur Aislador, motor 2
20 0049743 Isolator, stator Sectionneurs stator Aislador, estator 1
23 0048736 Nut, nyloc 5/16-18 Écrous nyloc Tuerca, nyloc 6
25 Note B Washer, flat 5/16 Rondelles plates Arandela, plana 4
26 Note B Bolt, 5/16-18 x 1 1/2 Boulon Perno 2
27 0047796 Spacer, 3/4 Entretoises Espaciador 1
28 0049224 Assy, ground wire Ens fil de masse tressé Conjunto, cable trenzado
a tierra 1
29 Note B Washer, star external 5/16 Rondelles à dents ext. Arandela, estrella externa 2
30 Note B Bolt, hex 5/16-18 x 3/4 Boulon, tête hex Perno, hexagonal 1
Page is loading ...
4970 Airport Road
P. O. Box 6001
Kearney, NE 68848
1-800-445-1805
1-308-237-2181
Fax 1-308-234-4187
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

Powermate PM0524000 User manual

Powermate
Brand
Powermate
Model
PM0524000
Category
Power generators
Type
User manual

Powermate PM0524000 is a heavy-duty generator powered by an 8 HP Tecumseh engine with cast-iron cylinder sleeves for enhanced durability. It features multiple power outlets, including 120 V and 240 V duplex receptacles, providing versatility in powering various devices and appliances. The generator is equipped with circuit breakers to protect against overloads and short circuits, ensuring safe and reliable operation.

Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages

Related papers

Other documents