Tannoy CVS 6 (EN 54) User manual

Operation Manual

Mode d’emploi

Betriebsanleitung

Manual de instrucciones

CVS 4 (EN54)

CVS 6 (EN54)

CVS (EN54)

Compact and Medium Format Ceiling Loudspeakers

2

CVS (EN54) Operation Manual rev 1.1.1

Contents

3 English - Operation Manual

17 Français-Moded’emploi

31 Deutsch-Betriebsanleitung

45 Español-Manualdeinstrucciones

CVS (EN54) Operation Manual rev 1.1.1

3

Table of Contents

1. Introduction 4

2. Unpacking 4

3. Safety Notices 4

4. Product Feature Identication 5

5. Accessories 6

6.1. Installation Guide for Suspended Ceilings 7

6.2. Installation Guide for Sheetrock Ceilings 8

6.3. Installation Guide for Optional Plaster Ring 9

7. Wiring and Setting Up 10

8. CVS (EN54) Dimensions 11

9.1. CVS 4 (EN54) Technical Specications 12

9.2. CVS 6 (EN54) Technical Specications 13

10. Painting 14

11. Warranty 15

1. Introduction

4

CVS (EN54) Operation Manual rev 1.1.1

1. Introduction

ThankyouforpurchasingthisTannoyCeilingloudspeaker.Thisproductrangeissuitedforhigh-levelmusicand

speechreinforcementapplicationsrequiringexceptionalsonicqualitywithuncompromisedreliability.

2. Unpacking

EveryTannoyproductandaccessoryiscarefullyinspectedbeforepacking.Afterunpacking,pleaseinspectyour

producttomakesurenodamagehasoccurredintransit.Intheunlikelyeventofanydamage,wouldyouplease

notifyyourdealerimmediatelyandretainyourshippingcarton,asyourdealermayaskyoutoreturnthefaulty

unittothemforinspection.

EachCVS(EN54)loudspeakerispackedinpairsandprovidedwiththefollowingaccessoriesasstandard;

C-Ring,tile-bridgekit,cut-outtemplate,andpaintmask.Aplaster(mud)ringisalsoavailableasanoptionalextra.

3. Safety Notices

Someregionalconstructioncodesrequiretheuseofasecondarymethodofsecuringloudspeakersinceiling

toprovidesecurityofabackupsupport.Asecondarysupportlineshouldbeattachedfromthesafetyloopon

therearoftheproducttoasourcepointontheceiling.Pleaseconsulttherelevantconstructioncodesinyour

region.

Whenusingapowerdrivertoinstalltheproductitisessentialtousethecorrecttorquelevelsettingstoavoid

overtighteninganddamagetotheceilingmaterialorclamps.

Recommendedtorquesetting:1.5Nm

Tannoywillnotbeheldresponsibleforanydamagescausedbytheimproperinstallationoftheseloudspeakers.

SAFETY NOTE:

In order to comply with the relevant re safety regulations (ie. BS 5839:1998), it is required that in the event of

re, that failure of the circuit to which the loudspeaker is connected does not occur before evacuation of the

building is complete. Suitable measures include: -

a) use of terminal blocks (for connection to primary) with a melting point of not less than 650°C, for example

constructed from ceramic materials;

b) use of terminal blocks of a lower melting point but protected with thermal insulation;

c) use of terminal blocks such that, on melting, an open-circuit or a short-circuit does not occur.

4. Product Feature Identiﬁcation

CVS (EN54) Operation Manual rev 1.1.1

5

4. Product Feature Identiﬁcation

CVS 4 (EN54)

CVS 6 (EN54)

SafetyTab

CableClamp

MountingWings ScrewsforMountingWings

MountingWings

RotarySwitch

TuningPorts

ScrewsforMountingWings

RotarySwitch

TuningPorts

5. Accessories

6

CVS (EN54) Operation Manual rev 1.1.1

5. Accessories

Standard Accessories









Optional Accessories

C-Ring Tile-bridgekit

Note:Atile-bridgekit

mustalwaysbeused

wheninstallinginto

suspendedceilingtiles

Paintmask

Plaster(mud)

ring

Cut-outtemplate

6.1. Installation Guide for Suspended Ceilings

CVS (EN54) Operation Manual rev 1.1.1

7

6.1. Installation Guide for Suspended Ceilings

1. Removetheceilingtilefromitsframeandplaceitonaat

surface.Markthecut-outareaontheceilingtilebytracing

aroundthetemplateprovided.(Fig.1)



2.Cutouttheholeintheceilingtileusingapadsaw.(Fig.2)



3.PlacetheC-Ringandtile-bridgeontopoftheceilingpanel,

aligningtheC-Ringoverthehole,andscrewtheC-Ringtothe

tilebridgeusingthexingsprovided.(Fig.3)



4.Slidethespeakerassemblythroughtheholeandturnthe

screwsonthefrontofthespeakertoextendthemountingwings.

Tightenthescrewsuntilarmgripisachieved.Ifusingapower

driver,Tannoyrecommendsatorquesettingof1.5Nm.(Fig.4)

DO NOT OVERTIGHTEN!



5.Slidethetilepanelbackintothesuspendedceiling.Thetile

bridgeendswillcatchovertherailings,supportingtheweightof

thespeaker.(Fig.5)



6.Connectasecondarysupportlinetosafetytab.Some

constructioncodesrequireuseofthissecondarysupportpoint,

whichshouldconnecttoaseparatesecuresupportpointusinga

suitablesupportline.Consultconstructioncodesinyourregion.

Gotosection7forinstructionsonwiringandset-upinstructions.

Fig.1

Fig.2

Fig.3

Fig.4

Fig.5

6.2. Installation Guide for Sheetrock Ceilings

8

CVS (EN54) Operation Manual rev 1.1.1

6.2. Installation Guide for Sheetrock Ceilings

1. Markthecut-outareaontheceilingbytracingaroundthe

templateprovided.(Fig.1)



2.Cutouttheholeintheceilingusingapadsaw,thenslidethe

C-Ringintotheceiling,aligningitoverthecut-outhole.(Fig.2)



3.Gotosection7forwiringandset-upinstructionsthenreturn

topoint4below.



4.Slidethespeakerassemblythroughtheholeandturnthe

screwstoextendthemountingwings.Tightenthescrewsuntila

rmgripisachieved.Ifusingapowerdriver,Tannoyrecommends

atorquesettingof1.5Nm.(Fig.3)

DO NOT OVERTIGHTEN!



5.Connectasecondarysupportlinetosafetytab.Some

constructioncodesrequireuseofthissecondarysupportpoint,

whichshouldconnecttoaseparatesecuresupportpointusinga

suitablesupportline.Consultconstructioncodesinyourregion.



6.Insertgrillebypushingitontothespeaker.(Fig.4)

Fig.1

Fig.2

Fig.3

Fig.4

6.3. Installation Guide for Optional Plaster Ring

CVS (EN54) Operation Manual rev 1.1.1

9

6.3. Installation Guide for Optional Plaster Ring

1. Nailorscrewtheplasterringtothejoists.(Fig.1)



2.Laythespeakerwiringtowherethespeakerwillbettedand

completetheplasteringworkontheceiling.



3.Cutouttheholeintheceilingusingapadsaw.(Fig.2)



4.Gotosection7forinstructionsonwiringthenreturntopoint5

below.



5.Slidethespeakerassemblythroughtheholeandturnthe

screwstoextendthemountingwings.Tightenthescrewsuntila

rmgripisachieved.Ifusingapowerdriver,Tannoyrecommends

atorquesettingof1.5Nm.(Fig.3)

DO NOT OVERTIGHTEN!



6.Connectasecondarysupportlinetosafetytab.Some

constructioncodesrequireuseofthissecondarysupportpoint,

whichshouldconnecttoaseparatesecuresupportpointusinga

suitablesupportline.Consultconstructioncodesinyourregion.



7.Insertgrillebypushingitontothespeaker.(Fig.4)

Fig.1

Fig.2

Fig.3

Fig.4

Anoptionalplaster(mud)ringbracketisavailablefromTannoy.Thisbracketisdesignedtobepre-installed

intonewlyconstructed,non-suspendedceilings.

7. Wiring and Setting Up

10

CVS (EN54) Operation Manual rev 1.1.1

7. Wiring and Setting Up

1. Removethewiringcoveratthebackofthespeakercantoaccess

theEuro-typeconnectorplugandsocket.Feedthecablethroughthe

glandandattachtheEuro-typeconnector.(Fig.1)



2.Forconnectiontoanamplier,usePins1and2(Fig.2):

•Pin1ispositive

•Pin2isnegative

Forconnectiontoadditionalspeakersinadistributedline,

Pins3and4areinparallelwhere:

•Pin3isnegative

•Pin4ispositive



3.TightenthecableglandandplugintheEuro-typeconnector.

Replacethecoverandxusingthesuppliedscrews.

THESPEAKERISSUPPLIEDINLOWIMPEDANCEMODE.NEVER

CONNECTTHESPEAKERTOA70/100VOLTAMPLIFIERWHILEIT

ISSETFORLOWIMPEDANCE.



4.TheCVS4(EN54)isttedwitha30Wtransformer.Whenused

indistributed-linesystems,thetransformercanbetappedat30W,

15Wand7.5W,withanadditional3.75Wtappingfor70.7Vline

systems.(Fig.3)



5.TheCVS6(EN54)isttedwitha60Wtransformer.Whenused

indistributed-linesystems,thetransformercanbetappedat60W,

30W,and15W,withanadditional7.5Wtappingfor70.7Vline

systems.

Fig.1

Fig.2

Fig.3

8. CVS (EN54) Dimensions

CVS (EN54) Operation Manual rev 1.1.1

11

8. CVS (EN54) Dimensions

CVS 4 (EN54) Template Cut-out Size: 180 mm

CVS 6 (EN54) Template Cut-out Size: 250 mm

Ø174.8

[6.88"]

Ø213.0

[8.39"]

14.7

[0.58"]

197.9

[7.79"]

224.9

[8.85"]

15.9

[0.63"]

Ø279.6

[11.01"]

Ø244.6

[9.63"]

263.0

[10.35"]

236.0

[9.29"]

9.1. CVS 4 (EN54) Technical Speciﬁcations

12

CVS (EN54) Operation Manual rev 1.1.1

9.1. CVS 4 (EN54) Technical Speciﬁcations

CVS 4 (EN54)

Technical Data Sheet

tannoy.com/pro

V 1.00 - 18/09/13

Speciﬁ cations

Performance

System

CVS 4 (EN54)

Frequency response (-3 dB)

(1)

85 Hz - 19 kHz

Frequency range (-10 dB)

(1)

77 Hz - 22 kHz

Rated sensitivity (1 W, Lo Z)

(2)

87 dB

Sensitivity as per EN54

(4 m, through transformer)

(2)

73.2 dB

Directivity factor (Q)

5.6 averaged 1 kHz to 6 kHz

Directivity Index (DI)

7.1 averaged 1 kHz to 6 kHz

Power Handling

(3)

Average 40 W

Programme 80 W

Peak 160 W

Recommended Ampliﬁ er Power

80 W @ 6 ohms

Nominal Impedance (Lo, Z)

6 ohms

Maximum SPL as per EN54

(4 m, through transformer)

(2)

87 dB

Rated maximum SPL (1 m, Lo Z)

(2)

Average 103 dB

Peak 109 dB

Transformer Taps (via front rotary switch)

70 V

30 W (165 Ω) / 15 W (330 Ω) / 7.5 W (660 Ω) / 3.75 W (1320 Ω) /

OFF & low impedance operation

100 V

30 W (330 Ω) / 15 W (660 Ω) / 7.5 W (1320 Ω) /

OFF & low impedance operation

Crossover Point

2.7 kHz

Coverage angles

(4)

Horizontal plane Vertical plane

500 Hz

177° 177°

1 kHz

166° 168°

2 kHz

157° 150°

4 kHz

85° 83°

Distortion

10% full power Harmonics

2nd 3rd

250 Hz

0.231% 0.112%

1 kHz

0.229% 0.253%

10 kHz

0.163% 0.025%

1% full power

250 Hz

0.99% 0.169%

1 kHz

0.816% 0.027%

10 kHz

0.444% 0.07%

Transducers

Low Frequency

100 mm (4.00”) mineral loaded cone material

High Frequency

19 mm (0.75”) coaxially mounted

Physical

Enclosure

Blind Mount (BM)

Back can Painted steel

Bafﬂ e Reﬂ ex loaded UL 94V-0 rated ABS

Grille Steel, with weather resistant coating

Safety Features

Safety ring located at rear of enclosure for load bearing safety bond

Clamping Design

Security toggle clamp

Connectors

Euroblock-type connector with screw terminals

(with input cover and cable gland supplied)

Dimensions

Bezel diameter

213.0 mm (8.39”)

Front of ceiling to rear of back can

202.5 mm (7.97”)

Front of ceiling to top of safety loop

214.9 mm (8.46”)

Hole cutout diameter

180 mm (7.09”)

Net Weight (ea)

2.6 kg (5.72 lbs)

Included Accessories

C-Ring, tile-bridge kit, paint mask, cut-out template

Optional Accessories

Plaster (mud) ring

Packed Quantity

2

Ordering Information

Part Number Colour

8001 7620 White /

Paintable

8001 4180

Plaster (Mud) Ring Zinc Plated

(CVS 4) Steel

Notes:

1. Average over stated bandwidth. Measured in

an IEC bafﬂ e in an Anechoic Chamber

2. Unweighted pink noise input, measured at

1 metre on axis

3. Long term power handling capacity as deﬁ ned

in EIA - 426B test

4. The reference point for the reference axis

(on-axis) is the centre of the bafﬂ e. The

horizontal and vertical planes are deﬁ ned with

the speaker mounted with the transformer

tapping selector at the bottom

A full range of measurements, performance data,

CLF and Ease™ Data for CVS 4 can be downloaded

from www.tannoy.com. They also apply to the

CVS 4 (EN54).

Tannoy operates a policy of continuous research

and development. The introduction of new materials

or manufacturing methods will always equal or

exceed the publishing speciﬁ cations, which Tannoy

reserves the right to alter without prior notice. Please

verify the latest speciﬁ cations when dealing with

critical applications.

EN54

certiﬁed

9.2. CVS 6 (EN54) Technical Speciﬁcations

CVS (EN54) Operation Manual rev 1.1.1

13

9.2. CVS 6 (EN54) Technical Speciﬁcations

CVS 6 (EN54)

Technical Data Sheet

tannoy.com/pro

V 1.00 - 18/09/13

Speciﬁ cations

Performance

System

CVS 6 (EN54)

Frequency response (-3 dB)

(1)

79 Hz - 21 kHz

Frequency range (-10 dB)

(1)

60 Hz - 24 kHz

Rated sensitivity (1 W, Lo Z)

(2)

91 dB

Sensitivity as per EN54

(4 m, through transformer)

(2)

77.1 dB

Directivity factor (Q)

7.7 averaged 1 kHz to 6 kHz

Directivity Index (DI)

8.0 averaged 1 kHz to 6 kHz

Power Handling

(3)

Average 60 W

Programme 120 W

Peak 240 W

Recommended Ampliﬁ er Power

120 W @ 6 ohms

Nominal Impedance (Lo, Z)

6 ohms

Maximum SPL as per EN54

(4 m, through transformer)

(2)

94.9 dB

Rated maximum SPL (1 m, Lo Z)

(2)

Average 109 dB

Peak 115 dB

Transformer Taps (via front rotary switch)

70 V

60 W (83 Ω) / 30 W (165 Ω) / 15 W (330 Ω) / 7.5 W (660 Ω) /

OFF & low impedance operation

100 V

60 W (165 Ω) / 30 W (330 Ω) / 15 W (660 Ω) /

OFF & low impedance operation

Crossover Point

2.5 kHz

Coverage angles

(4)

Horizontal plane Vertical plane

500 Hz

175° 174°

1 kHz

159° 165°

2 kHz

140° 125°

4 kHz

66° 66°

Distortion

10% full power Harmonics

2nd 3rd

250 Hz

0.439% 0.140%

1 kHz

0.396% 0.458%

10 kHz

0.235% 0.023%

1% full power

250 Hz

1.16% 0.214%

1 kHz

1.014% 0.685%

10 kHz

0.944% 0.047%

Transducers

Low Frequency

150 mm (6.00”) mineral loaded cone material

High Frequency

19 mm (0.75”) coaxially mounted

Physical

Enclosure

Blind Mount (BM)

Back can Painted steel

Bafﬂ e Reﬂ ex loaded UL 94V-0 rated ABS

Grille Steel, with weather resistant coating

Safety Features

Safety ring located at rear of enclosure for load bearing safety bond

Clamping Design

Security toggle clamp

Connectors

Euroblock-type connector with screw terminals

(with input cover and cable gland supplied)

Dimensions

Bezel diameter

297.5 mm (11.01”)

Front of ceiling to rear of back can

246.5 mm (9.70”)

Front of ceiling to top of safety loop

258.5 mm (10.18”)

Hole cutout diameter

250 mm (9.84”)

Net Weight (ea)

4.75 kg (10.45 lbs)

Included Accessories

C-Ring, tile-bridge kit, paint mask, cut-out template

Optional Accessories

Plaster (mud) ring

Packed Quantity

2

Ordering Information

Part Number Colour

8001 7630 White /

Paintable

8001 4181

Plaster (Mud) Ring Zinc Plated

(CVS 6) Steel

Notes:

1. Average over stated bandwidth. Measured in

an IEC bafﬂ e in an Anechoic Chamber

2. Unweighted pink noise input, measured at

1 metre on axis

3. Long term power handling capacity as deﬁ ned

in EIA - 426B test

4. The reference point for the reference axis

(on-axis) is the centre of the bafﬂ e. The

horizontal and vertical planes are deﬁ ned with

the speaker mounted with the transformer

tapping selector at the bottom

A full range of measurements, performance data,

CLF and Ease™ Data for CVS 6 can be downloaded

from www.tannoy.com. They also apply to the

CVS 6 (EN54).

Tannoy operates a policy of continuous research

and development. The introduction of new materials

or manufacturing methods will always equal or

exceed the publishing speciﬁ cations, which Tannoy

reserves the right to alter without prior notice. Please

verify the latest speciﬁ cations when dealing with

critical applications.

EN54

certiﬁed

10. Painting

14

CVS (EN54) Operation Manual rev 1.1.1

10. Painting

Ifdesired,thegrilleandbafepanelmaybepaintedtomatchthesurroundingdécor.

Paintingthebafe:

• Carefullymaskoffthedriverassemblyusingthepaintmaskprovidedtoensurethatthepaintdoesnotcome

 intocontactwiththeconeandrollsurround.

• Applyseveralthincoatsofpaint–thiswillprovideabetternishthanoneoverlythickcoat.

Paintingthegrille:

• Carefullyremovetheacousticallytransparentfoamfromthereversesideofthegrille.

• Paintthegrilleandthenreplacethefoam-severalthincoatsofpaintwillprovideabetternishthanoneoverly

 thickcoat.

• Re-bondthefoamtothegrilleovertheentireareausingalightspray-adhesivetoavoidaudibleresonances.

11. Warranty

CVS (EN54) Operation Manual rev 1.1.1

15

11. Warranty

No maintenance of the CVS (EN54) loudspeaker is necessary.

All Tannoy professional loudspeaker products are covered by a 5 year warranty from the date of manufacture

subject to the absence of misuse, overload or accidental damage. Claims will not be considered if the serial

number has been altered or removed. Work under warranty should only be carried out by a Tannoy Professional

dealer or service agent. This warranty in no way affects your statutory rights. For further information please

contact your dealer or distributor in your country. If you cannot locate your distributor please contact Customer

Services, Tannoy Ltd. at the address given below.

CustomerServices

TannoyLtd.

RosehallIndustrialEstate

Coatbridge

Strathclyde

ML54TF

Scotland

Tel: 01236420199(National)

  +441236420199(International)

Fax: 01236428230(National)

  +441236428230(International)

Support: http://support.tannoy.com

ServiceInfo,TCGroupAmericas

Tel: (800)565-2523(tollfree)

  (519)745-1158

Fax: (519)745-2364

Support: http://support.tannoy.com

DONOTSHIPANYPRODUCTTOTANNOYWITHOUTPREVIOUSAUTHORISATION

PLEASENOTE:Inordertodirectyoutotheappropriateservicefacilityareturnauthorizationandinstructions

mustbeissuedinadvance-donotsendanyequipmenttoanyTannoyorTCGroupAmericasfacilitywithout

priorauthorizationoritwillberefused.Insomecasesalocalservicefacilitycanberecommended.

Ourpolicycommitsustoincorporatingimprovementstoourproductsthroughcontinuousresearchand

development.Pleaseconrmcurrentspecicationsforcriticalapplicationswithyoursupplier.

Page is loading ...

44

CVS (EN54) Manual de instrucciones rev 1.1.1

Índice

3 English-OperationManual

17 Français-Moded’emploi

31 Deutsch-Betriebsanleitung

45 Español - Manual de instrucciones

Page is loading ...

tannoypro.com

6481 0649/251115

Tannoy operates a policy of continuous research and development. The introduction of new materials or manufacturing

methods will always equal or exceed the published specications. All specications are subject to change without notice.

Tannoy CVS 6 (EN 54) User manual

Tannoy CVS 6 (EN 54) User manual

in other languages

Related papers

Other documents