Simplicity 883015 User manual

Brand: Simplicity

Model: 883015

Type: User manual

This manual is also suitable for

OPERATOR'S MANUAL, 80V BATTERY & CHARGER

Simplicity 883015 is an 80V lithium-ion rechargeable battery and charger. It's intended for use with Victa 80V LI-ION products only. It features a battery guide, cooling fan, vents, top housing, bottom housing, and a plug and cord. The instruction/safety manual is included and provides important information on safety and handling.

80V LITHIUM-ION

RECHARGEABLE

BATTERY & CHARGER

OWNER'S MANUAL

WARNING! Read this manual before operating your product.

Not for

Reproduction

IMPORTANT NOTES

Warning!

Protect the machine

from rain and damp.

Read the directions

for use before operating

the machine.

Should NOT be disposed

of with household items.

Beware of electric

shock hazard.

Class 9 'Lithium-ion'

dangerous good.

Contact local authorities for

shipping requirements.

Caution corrosive materials

May cause skin & eye damage.

Caution contains material

which maybe hazardous to

your health.

GENERAL SAFETY & SYMBOLS

Thank you for purchasing your Victa product. Victa prides itself in the quality and performance

of all its products.

This instruction manual will aid in the safe operation and maintenance of your product.

Please read the following warnings to ensure safety and the long life of your product.

Do not attempt to operate this product until you have read thoroughly and understood

completely all instructions, safety rules, etc, contained in this manual. Failure to comply may

result in accidents involving electric shock, fire, and/or serious personal injury.

INTENDED USE

Battery: To power Victa 80V LI-ION products ONLY.

Charger: To charge Victa 80V LI-ION batteries ONLY.

Do not use the product for any task, except for that which it is intended.

WARNING

Class II

Double insulation

For indoor use only

Before charging, read the instructions

Time-lag fuse

8.0A

Details

Not for

Reproduction

Features & Definitions

Features & Supplied Items 3

Safety & Handling

First Aid 4

General Safety 4

Battery & Charger Disposal 5

Lithium-ion Hazard

& Precautions 6

Emergency Contact 6

Operating Instructions

Battery Capacity 6

Charging Procedure 7

Maintenance & Care

Cleaning 8

Servicing 8

Technical Specifications

Product Specification 9

Important Notes

Notes 10

NOTE: WARRANTY DETAILS ARE NOT WRITTEN WITHIN THIS OPERATOR’S MANUAL.

REFER TO OTHER DOCUMENTS SUPPLIED WITH THIS MACHINE FOR WARRANTY DETAILS.

THE WARRANTY DOCUMENTS MAY INCLUDE TECHNICAL SPECIFICATIONS THAT ARE

SPECIFIC TO EACH MODEL THAT ARE NOT WRITTEN WITHIN THIS OPERATOR’S MANUAL.

Table of Content

Not for

Reproduction

FEATURES DEFINITIONS

80V Battery Charger

1 Battery Guide

2 Cooling Fan

3 Vents

4 Top Housing

5 Bottom Housing

6 Plug and Cord

Instruction/Safety Manual (not shown)

80V Lithium-ion Battery

7 Charge Indication Panel

8 Ventilation Grills Battery

9 Battery Guides

Instruction/Safety Manual (not shown)

Battery ChargerLithium-ion Battery

Featured & Supplied Items

Not for

Reproduction

Each battery cell contains chemical materials that are stored in a hermetically sealed container

designed to withstand temperatures and pressures encountered during normal use. As a result,

during normal use, there is no physical danger of ignition or explosion and chemical danger of

hazardous materials' leakage.

However, if exposed to a fire, added mechanical shocks, decomposed or added electric stress

by miss-use, then hazardous materials maybe released. If this occurs please do the following:

Do not make contact with the leaking substance. If contact is made by a person apply the

appropriate first aid listed below:

Inhalation: If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is

difficult, give oxygen. Seek medical attention if breathing problems develop. This information is

relevant only if the battery is broken and therefore results in a direct contact with the ingredients.

Skin Contact: In case of skin contact, immediately remove contaminated clothing and wash

affected areas with water and soap. Seek medical attention. This information is relevant only if the

battery is broken and therefore results in a direct contact with the ingredients.

Eye Contact: In case of eye contact, rinse cautiously with water for several minutes. Remove

contact lenses, if present and easy to do. Continue rinsing. Seek medical attention. This

information is relevant only if the battery is broken and therefore results in a direct contact with

the ingredients.

Ingestion: Do not give anything by mouth to an unconscious person. Seek immediate medical

attention. This information is relevant only if the battery is broken and therefore results in a direct

contact with the ingredients.

For the proper use, maintenance and storage of this product, it is crucially important that you

read and understand the instructions given in this manual.

To avoid serious injury, risk of fire, explosion and danger of electric shock or electrocution:

• Do not probe the charger with conductive materials.

• If any parts are cracked or damaged, do not use and replace.

• Do not charge the battery with any other type of charger.

• Do not attempt to charge non-specified batteries in the charger

• Do not allow liquid or any other debris to enter the battery or charger.

• Do not attempt to use the charger for any product.

• Do not short circuit any terminals of the battery.

• Do not modify or alter the battery or charger in any way.

• Do not charge the battery in rain or in wet conditions.

• Do not immerse the product, battery or charger in water or any other liquid.

• Do not allow the battery or charger to get warm. If they are warm, allow them to cool down

for 1 hour before attempting to charge the battery. Recharge only at room temperature (10

to 35°C).

• Do not cover the ventilation slots on the top of the charger or the sides of the battery.

• Do not place the charger on a soft surface i.e. blanket, pillow as ventilation slot may be

blocked. Keep the ventilation slots of the product, battery & charger clear at all times.

• Do not allow metal items or material such as steel wool, aluminium foil, or other foreign

particles into the battery or charger cavity or to come in contact with the terminals.

• Unplug the charger before cleaning and when not in use.

First Aid

General Safety

Not for

Reproduction

All items must be disposed of in a specified manner to prevent contamination of the environment.

Take the batteries to a local recycling and/or disposal centre, certified for Lithium-ion disposal.

WARNING

If the battery cracks or breaks, with or without leaks, do not recharge it and do not use.

Dispose of it and replace with a new battery. DO NOT ATTEMPT TO REPAIR DAMAGED BATTERIES.

To avoid injury and risk of fire, explosion, or electric shock, and to avoid damage to the environment:

• Cover the battery's terminals with heavy-duty adhesive tape.

• Do not attempt to remove or destroy any of the battery components.

• Do not attempt to open the battery or charger.

• If a leak develops, the released electrolytes are corrosive and toxic. Do not get the solution in

the eyes or on skin, and do not swallow it.

• Do not place these batteries in your regular household trash.

• Do not incinerate.

• Do not place them in any waste landfill or municipal solid waste stream.

• Take them to a certified lithium-ion recycling or disposal centre.

AUSTRALIAN BATTERY RECYCLING INITIATIVE

The Australian Battery Recycling Initiative (ABRI) is a not-for-profit association established in 2008

to promote responsible environmental management of batteries at end of life. More information on

battery recycling can be found on their website at www.batteryrecycling.org.au.

SAFE STORAGE AND RECYCLING

Used batteries are potentially hazardous, so they need to be stored and handled carefully. They need

to be kept out of reach of children. Some of the materials inside batteries are toxic, so you need to

be careful of damaged or leaking batteries. Batteries must be kept away from direct sunlight or heat.

Store the battery at a temperature between 10°C to 35°C & between 40% to 85% relative humidity.

CORRECT DISPOSAL OF THE CHARGER

Waste electrical products should not be disposed of with household waste. Please recycle

where facilities exist. Check with your local authority or retailer for recycling advice.

• The battery or charger may under no circumstances be opened. If the a cover is damaged,

then the product may no longer be used and needs to be replaced.

• This appliance is not intended for use by persons (including children) with reduced physical,

sensory or mental capabilities, or lack of experience and knowledge.

• Do not allow children or impaired persons to operate the machine.

• If the charger power supply cord is damaged, do not use.

• It is recommended that the product should be connected to the mains through a Residual

Current Device (RCD) with a tripping current of not more than 30 mA.

• Store in shady, cool and dry condition (10 to 35°C).

• Use the charger indoors only. Do not charge the battery outdoors or in direct sunlight.

• Remove the battery from the product or the charger before cleaning and when not in use.

General Safety

Battery & Charger Disposal

Not for

Reproduction

OPERATINGINSTRUCTIONS

CHECKING BATTERY CAPACITY

Press the battery capacity indicator (BCI) button. The lights will illuminate according to the

batteries capacity level. See chart below:

Lithium-ion is harmful if swallowed or when in contact with skin.

Lithium-ion may cause serious eye damage.

Lithium-ion may cause an allergic skin reaction.

Lithium-ion may cause damage to organs through prolonged or repeated exposure.

Do not inhale Lithium-ion dust or vapours.

Avoid breathing Lithium-ion dust or vapours.

Wear personal protective equipment when handling damaged Lithium-ion battery pack.

Wash hands thoroughly after handling damaged Lithium-ion products.

Do not eat, drink or smoke when using Lithium-ion products.

Clothing with Lithium-ion contamination should be disposed of immediately.

Undamaged Lithium-ion battery packs are safe to use, hazard

& precautions only apply when battery pack is damaged &

Lithium-ion cells are exposed.

In the rare case that a battery leaks and the leaking content is ingested or comes into contact with

a persons skin or eyes follow the first aid instructions inside the battery & charger manual. If unsure

seek medical attention immediately!

Lithium-ion Hazard & Precautions

Emergency Contact

Battery Capacity

level. See chart below:

BATTERY CAPACITY

INDICATOR (BCI) BUTTON

LIGHT METER

Lights Capacity

3 Green Lights

The battery is more than 75% capacity

The battery is between 35% and 75% capacity

The battery is less than 35% capacity

The battery requires charging immediately

2 Green Lights

1 Green Lights

Lights go out

Not for

Reproduction

OPERATING INSTRUCTIONS

NOTE : The battery is not shipped fully charged. It is recommended to fully charge the

battery before use to ensure that maximum run time can be achieved. This lithium-ion

battery will not develop a memory and may be charged at any time.

1. Plug the charger into an AC power outlet.

2. Insert the battery pack (1) into the charger (2).

This is a diagnostic charger. The Charger LED Lights will illuminate in specific order to

communicate the current battery status. They are as follows:

False Defect Note:

When the battery is inserted into the charger, and the status LED flashes, remove the

battery from the charger for 1 minute, then reinsert. If the status LED indicates normal than

the battery pack is good. If the status LED is still blinking, remove the battery pack and

unplug the charger. Wait 1 minute and plug the charger back in and reinsert the battery

pack. If the status LED indicates normal than the battery pack is good. If the status LED is

still blinking then the battery pack is defective and needs to be replaced.

NOTE: When the red indictor flickers, pull out the battery from the charger and insert again

within 2 hours. If the indictor shows charging, that means the battery is good.

After 2 hours, please pull out the battery and also pull out the AC power plug of the charger

for 1 miniute, and then insert the AC power plug and the battery again. If the

indictor shows charging, that means the battery is good. If not, the battery needs to be

changed.

Charging Procedure

LED STATUS DESCRIPTION

Blinking Green Charging

Solid Green Fully Charged

Solid Red Over Temperature

Blinking Red Charging Fault

Not for

Reproduction

OPERATING INSTRUCTIONS

• If the battery pack does not charge properly:

• Check the current at the power outlet with another tool.

• Make sure that the outlet is not turned off.

• Check that the charger contacts have not been shorted

• by debris or foreign material.

• If the surrounding air temperature is not normal room

• temperature, move the charger and battery pack to a

• location where the temperature is between 7 ˚C and 40˚C .

• This product requires assembly.

To prevent serious personal injury, unplug the charger and remove the battery from the charger or product

before servicing, cleaning, or removing debris.

• Use a dry cloth, brush or vacuum to remove dirt, grease, oil or other debris before and after each use.

• Do not use any strong detergents on the plastic housing or the handle. They can be damaged by

certain aromatic oils such as pine and lemon, and by solvents such as kerosene.

• Moisture can cause a shock hazard. Wipe off any moisture with a soft dry cloth immediately.

• Use a small brush or the air discharge of a small vacuum cleaner to clean the air vents, terminals and

connector on the battery, charger and product.

• Keep the air vents free of obstructions.

WARNING

Do not use solvents, strong detergents, certain aromatic oils such as pine and lemon when cleaning plastic

parts. Many plastics are susceptible to damage from various types of chemicals and may be damaged by

their use. When servicing use only identical Victa replacement parts. Use of any other parts can create a

hazard or cause product damage.

Service

Servicing requires extreme care and knowledge and should be performed only by a qualified service

technician. For service we suggest you return the product to your nearest authorized service centre for

repair. When servicing, use only genuine replacement parts.

• Keep the handles dry, clean, and free of oil and grease.

• In order to reduce the risk of fire, keep the motor free of grass, leaves, and debris build-

up.

• Never tamper with safety devices. Check them regularly for proper operation.

NOTE: Refer to warranty card supplied with this product for service contact details.

Charging Procedure

Cleaning

Not for

Reproduction

TECHNICAL SPECIFICATIONS

Product Specification

BaƩery Volts 80V

BaƩery Amp Hours 2Ah

BaƩery WĂƩ,ŽƵƌƐ 144Wh

BaƩery Weight 1.4Kg

Charger Power Source 230V AC, 50Hz

Charge Time 100% 30 minutes

Charge Weight 1.3Kg

Charge Electrical Cord 1.8m

PRODUCT SPECIFICATION LITHIUM-ION BATTERY

LITHIUM-ION BATTERY

CHARGER

PRODUCT SPECIFICATION

Not for

Reproduction

_________________________________________________________

NOTES

Not for

Reproduction

LR02494A-B

Victa is a trademark of Briggs & Stratton Australia Pty. Ltd.

ABN 13 006 576 856

without prior written permission. All information herein is subject to change without notice.

1659 B JM PB REVIEW 22.06.15

1659 A JM PB PRODUCTION 10.06.15

ECN ISS DRN CKD DESCRIPTION DATE

Not for

Reproduction

Simplicity 883015 User manual

Brand: Simplicity

Model: 883015

Type: User manual

This manual is also suitable for

OPERATOR'S MANUAL, 80V BATTERY & CHARGER

Download PDF

report

Simplicity 883015 User manual

This manual is also suitable for

Simplicity 883015 User manual

Related papers

Other documents