Denso RT1 Owner's manual

RT1 AIR CONDITIONING UNIT

OWNERS MANUAL

DENSO AUTOMOTIVE SYSTEMS AUSTRALIA PTY LTD

AL00Z00004E

Published: October 2012

REV #1: May 2013

DENSO AUTOMOTIVE SYSTEMS AUSTRALIA PTY. LTD.

2-46 Merrindale Drive

Croydon Victoria 3136

tel: 03 8761 1449

email: ser[email protected]om.au

Width: 110 mm X Length: 210 mm Note: All components must be printed.

The artwork components must not be re-scaled. Re-scaling will create

processing problems.

Delivery Address:

2 -46 Merrindale Dr

CROYDON SOUTH VIC 3136

Denso

Reply Paid 88460

CROYDON SOUTH VIC 3136

Filename: D60744436001110210Y130116.pdf date: 16/01/2013 15:27:18

Please note:

• It is the customer's responsibility to check that the artwork is correct, please check the delivery address details and the addressee details below the barcode. Contact Australia Post if any changes are

required.

• Failure to adhere to correct addressing and formatting standards will result in higher customer charge s or cancellation of service.

• Refer to the Reply Paid Service Guide or visit www.auspost.com.au/replypaid

• Please check the artwork details thoroughly. Australia Post is not responsible for any errors.

Summary: Envelope Paper Requirements:

- weight of 65 to 100gsm;

- thickness of 0.08 to 0.18 mm;

- stiffness: machine direction of 3 mN; and,

- stiffness: cross direction of 1.5mN.

No print content can appear in the bottom 15 mm on the front of the article or 20mm on the

rear of the article.

WARNING

Changes to this artwork not complying with

Reply Paid Service Guidelines may result in

cancellation of your Reply Paid service.

Operation

1. Foreword    2

2. Inventory    2

3. GeneralInformation   3

4. Controls    5

5. Operation    8

6. Maintenance    10

7. TechnicalData    11

8. TroubleShooting   13

TABLEOFCONTENTS

May 2013

This book may not be reproduced or copied, in whole or in

part, without the written permission of the publisher.

DENSO reserves the rights to make changes without

prior notice.

Operation

  

   Indicatesapossibilitythat“improperhandlingbytheusermay

   resultindeathorseriousinjury”.

   Indicatesapossibilitythat“improperhandlingbytheuser,may

   resultininjuryand/ormaterialloss”.

1.FOREWORD

DENSO’sRT1air-conditioningunitisdesignedforinstallationontherooftopoffixedroof

caravansandmotorhomes.Beforeusingtheunit,pleasetaketimetoreadthismanualin

detail,andfollowtheinstructionsonhowtooperatethisproduct.Keepthismanualinyour

caravan,andshouldyoueverdecidetosellyourcaravan,pleasemakesuretopassthis

manualontothenextowner.

1.1DEFINITIONOFTERMS

SYMBOLS     MEANINGS

WARNING

CAUTION

2.INVENTORY

Yourair-conditionerunitcomprisesthefollowingitems.

1.ExternalRoofTopunit

2.AirDistributionUnit

RemoteControlUnit

includingawallbracket

andbatteries

NOTE:Imagesnottoscale

Operation

The ability of the air-conditioner to maintain a desired temperature depends

upon theheatenteringorleavingyourvehicle.Thefollowingsimpleguidelines

shouldbefollowedtoachievethebestcomfort,lowestenergyuseandquietest

operatingnoise.

 a. Parkyourvehicleinashadedarea.

 b. Keepallwindows,doors,curtainandblindsclosedwhileoperating.

 c. Selecthigherfanspeedsforhighercoolingperformance.

 d. Switchyourair-conditionertocoolingearlyintheday,beforetheinterior

  ofthevehiclehasbecometoohot.

 e. Iftheinteriorofthevehicleisalreadyhotterthantheoutsideair,briefly

  opendoorsandwindowstoexhaustthehotairbeforestartingthe

  air-conditionercooling.

 f. Avoidusingstovesandovensthataddheattothevehicle’sinterior

  whiletheair-conditioneriscooling.    

  

3.GENERAL INFORMATION

3.1

Inhumidconditions,theoperationofanair-conditionercancausetheformationof

condensateoncoldsurfacesinsideyourvehicle.Caremustbetakentoprevent

thiscondensatefromdamagingpersonalitems,orcausingabuildupofmould.

Itemsthatmaybedamagedbythecondensatemustbekeptclearoftheair

distributionunit.Inrarecircumstances,condensatecanformonthisunitduring

use.Shouldtherebeformationofcondensate,allowittodrythoroughlyafteruse.

3.2

NOTE: Condensation can be reduced by keeping all doors and windows closed during

air-conditioner operation, preventing humid air from entering the vehicle. The likelihood of

condensation on the air distribution unit can be reduced by ensuring that the caravan is properly

sealed, preventing entry of moisture laden air.

WARNING

All electrical work and permanent wiring must be carried out by an appropriately

qualifiedpersoninaccordancewithnationalwiringregulationsandallotherapplicable

localcodesandregulatoryauthorityrequirements.

Repair to electrical components by non-certified technicians may result in death,

personalinjuryand/ordamagetotheunit.Allelectricalcomponentsreplacedmustbe

genuinereplacementparts,purchasedfromanauthorisedreseller.

Operation

WARNING

Thisapplianceisnot intendedforusebypersons(includingchildren)withreduced

physical,sensoryormentalcapabilities,orlackofexperienceorknowledge,unless

theyaresupervisedandgiveninstructionsconcerningtheuseoftheappliancebya

personresponsiblefortheirsafety.

Children must be supervised at all times to ensurethat they do not play with this

appliance.

Priorto operation,familiariseyourselfwiththelocation ofthesafety circuitbreaker

andisolation switch fortheair-conditioneronyourcaravan.Inthe eventofa fault

ordamage,switchoffthepowersupply,andcontactanapprovedserviceagentfor

assistance.

 a. Onlyalicencedelectricianmayreplacetheunitfuse.Thefuseis

  locatedintheelectricalcontrolhousinginsidetherooftopunit.Fuse

  ratingis250V/500VAC,10A,T-Delay,5x20mmsuppliedbyDENSO.

 b. Thesafetycircuitbreakermustbeswitchedto‘off’positionto 

  disconnectitfromthepowersupplybeforeanydisassemblyorrepairs.

 c. Theair-conditionerusestherefrigerantR410aunderhighpressure.It

  isbothdangerousandillegaltotamperwiththesealedrefrigerant

  systemwithoutappropriatelicensing.Intentionalreleaseofrefrigerant

  isillegalinAustraliaandNewZealand.

Theairintake,exhaustandcondensatedrainonthesidesoftheexternalunit

must be kept clear of any material that may block airflow or water drainage.

Failuretokeeptheseareasclearcouldcausepoorperformance,waterleakage

intoyourvehicleandpermanentdamagetotheair-conditioner.

Theair-conditionermustneverbeoperatedwhilethevehicleismoving.Before

operatingtheair-conditioner,ensurethatthevehicleisparkedwiththeunittilted

nomorethan5˚fromthehorizontal.

Thisunitisdesignedtobeoperatedon230-240V50Hzpowerfromtheelectricity

gridorasinewaveinverterequippedgenerator.Therecommendedgenerator

capacityforthisunitis2.4kVAContinousPower.Whenchoosingagenerator,

pleasebearinmindthatotherdevicesandappliancesmayaddtothedemandon

thegenerator.Inthiscase,thegeneratorcapacityshouldbeselectedaccordingly.

3.3

3.4

Operation

4.CONTROLS

4.1REMOTECONTROL

A/ Power

  On/Offswitch

B/ Temperature Decrease

  Lowerstothedesiredroomtemperature(16-30˚C)

C/ Temperature increase

  Raisestothedesiredroomtemperature(16-30˚C)

D/ Fan Speed

  Cyclestheinteriorfanthrough3speedsettings.

 

Operation

E/ Timer

(i) On Timer

  Pressingthisbuttonwhiletheunitisoffwillsettheontimer.Each

  buttonpressadds1hourtothewaittimeuntiltheunitstarts 

  (1-12hours).Aftercyclingthrough12hours,thenextbuttonpresswill

  cancelthe‘on’timer.

  (ii)Off Timer

  Pressingthisbuttonwhiletheunitisonwillsettheofftimer.Each

  buttonpressadds1hourtothewaittimeuntiltheunitstops

  (1-12hours).Aftercyclingthrough12hours,thenextbuttonpresswill

  cancelthe‘off’timer.

F/ Mode

  Cyclesthroughthe3modesofairconditioneroperation.

(i) Fan Mode

  Usedforventilationonly.Fanspeedcanbechangedbetweenlow,

  mediumandhighbypressingD-FanSpeed.

(ii) Cooling Mode

  Thecompressorandexternalfanwilloperateautomaticallytocool

  thecabintoachievethedesiredtemperature.Fanspeedcanbe

  adjustedbetweenlow,mediumandhighbypressingD-FanSpeed.

  (iii)Heating Mode

  Thecompressorandexternalfanwillautomaticallyoperate 

 toheatthecabintoachievethedesiredtemperature.Theinteriorfan

  speedcanbeadjustedbetweenlow,mediumandhighbypressing

  pressingD-FanSpeedtoachieveanoptimumheatingperformance.

G/ Quick Cool

  Theair-conditionerwillchangetomaximumcoolingmodeand 

  maximumfanspeedforaperiodof15minutesduringwhichtheQuick

  CoolIndicatorKwillilluminate.After15minutes(orifthequickcool

  buttonGispressedagain)theair-conditionerwillresumeoperation

  withtheprevioussettings.

Operation

H/ Directional Airow Controls

  Verticalairflowdirectionalcontrol.

I/ Power Indicator (Blue)

  Illuminateswhentheair-conditionerisswitchedon.

J/ Infrared Remote Control Receiver

  Electronicreceiverforremotecontrolsignal.

K/ Quick Cool Mode Indicator (White)

  Illuminateswhiletheair-conditionerisoperatinginquickcoolmode.

4.2UNIT

HIJKH

Operation

5. OPERATION

CAUTION

Alwaysensurethatthecaravan’spowersupplycordisfullyuncoiledbeforeoperating

theunittopreventoverheating.

Switchtheair-conditioneronbypressingthePowerButton(A)ontheremote

controlwhileaimingthecontrolinthedirectionoftheInfraredRemoteControl

Receiver(J)ontheceilingmountedairdistributionunit.Theair-conditionerwill

beepandthePowerIndicator(I)willilluminatetoacknowledgethesignal.

Setthedesiredoperatingmode(Fan,CoolingorHeating),FanSpeed(low,Medium

orHigh)andthedesiredtemperature(16-30˚C).Theinteriorfan,exteriorfanand

compressorwilloperateautomaticallydependinguponthesettingschosen.Fan

speedshouldbeselectedmanuallytothelowestlevelthatachievesthedesired

roomtemperature.

5.1

5.2

5.3

ThePowerindicator(I)willilluminatebrieflywhenthepowersupplyisconnectedand

switchedon.

Once the desired room temperature is reached, the air-conditioner will cycle the

compressorandexteriorfantomaintainthetemperaturelevel.

Iftheair-conditionercannotreachacomfortabletemperatureincoolingmode,increase

thefanspeedtoincreaseperformance.

Thedesiredtemperaturecanbeadjustedifyouaretoohotorcold.

SwitchtheunitoffbypressingthePowerbutton(A)ontheremotecontrol.The

PowerIndicator(I)willextinguish.

Alternatively,theunitcanbesettoswitchoffautomaticallyusingtheOffTimer.While

theunitisswitchedon,presstheTimerbutton(E)ontheremotecontrolrepeatedlyuntil

thedisplayshowsthedesirednumberofhoursuntiltheairconditionerwillswitchoff.

NOTE: Whenever the remote control is used, it must be aimed in the direction of the Infrared

Remote Receiver (J) on the Air Distribution Unit from a distance of less than 8m. The air

distribution unit will beep once and the Power Indicator (I) will ash once to acknowledge the

command.

Ensurethatthecaravanisconnectedtoaclean230-240Vpowersupply.Ifconnected

toagenerator,itmustbeofthesine-wavetype,andadequatelyrated.

Operation

Thecompressorandexteriorfanspeedaremicroprocessorcontrolledtoautomatically

ensurealonglifeforyourair-conditionerwhilemaintainingthebestpossiblecomfort.

Dependingupontheconditionsandair-conditionersettings,youmaynoticesomeof

thefollowing:

a. Automatic Compressor Start Protection: Thecompressorstartmaybe

  delayedforupto3minutesafterselectingcoolingorheatingmode.

b. Exterior Fan Speed:Theexteriorfanmayswitchbetweenhighandlow

 speedstominimizetheoperatingnoiseoftheairconditionerforyouandyour

 neighbours.

c. Cooling Operating Range: Thecompressormaynotoperateincooling

 modeiftheoutsidetemperatureisgreaterthan45°Cinordertoprotectthe

 refrigerantsystem.

d. Heating Operating Range: Theairconditionerisdesignedtooperatein 

 heatingmodewhentheoutsidetemperatureisbetween0-25°C.Ifthe 

 temperatureisoutsidethisrangethecompressormaynotoperateinorderto

 protecttherefrigerantsystem.

e. Preheat: Theinteriorfanwillnotswitchoninheatingmodeuntiltheair- 

 conditionerhaswarmedupsufficientlytodelivercomfortablywarmair.At

 verylowtemperaturesthiscouldtakeupto10minutesfromthestartofthe

 compressorandexteriorfan.

f. De-icing:Theair-conditioneroperatesasaheatpumpwheninheatingmode.

 Heatisdrawnfromtheoutsideairtowarmthevehicle.Astheoutsideair

 temperaturedrops,lessheatisavailabletotheair-conditioneranda 

 decreaseintheheatingperformancemaybenoticed.Whentheoutside 

 temperatureisverylow(below8°C)icemayformonthecondenserinthe

 air-conditioner.Themicroprocessorcontrolhasafullyautomaticprotection

 functionthatwillremovetheicewhenrequired.Dependinguponthe 

 conditions,youmaynoticethecompressor,interiorandexteriorfansswitching

 offasoftenasevery15minutestoprotectyourair-conditionerandprovide

 maximumcomfort.

Operation

6. MAINTENANCE

WARNING

Always ensure that the air-conditioner is isolated from the mains power supply by

switchingofftheACswitchandsafetycircuitbreaker,beforeperformingandduring

anymaintenance.

6.1INLETAIRFILTER

Twodustfiltersarefittedtothereturnairinletoftheair-conditioner.Thesefiltersare

essentialto preventa buildupofdust blockingthe evaporator.Thefilters(PartNo.

TA145520-2230)mustbecleanedatleasttwiceperyearbywashinginwarmwaterwith

amildhouseholddetergent.Allowthefilterstodry,beforere-installing.Replacement

filtersareavailableforpurchaseassparepartsshouldtheoriginalbedamaged.

Flipdownthetwotabsonthesides

ofthefilter,asshownintheimage.

Flipdownthecentretab,anduseitto

pulltheairfilterapproximately

20-30mmsoutoftheunit.

Once the outer tabs are exposed,

usethemtogentlypullthefilterout

oftheunit.

After cleaning the filters carefully

insertthembackintotheslotswhich

areprovided.Oncethefilterisfully

inplace,pressdown the threetabs

tolockitin.

Repeat steps a, b and c above for

thesecondfilterontheothersideof

theunit.

CAUTION

Failuretocleanthefilterwillresultindecreasedair-conditionerperformance,increased

noiseandpossibleoverheatinganddamagetotheair-conditioner.Theair-conditioner

shouldneverbeoperatedwithoutthefiltersinstalled.

Operation

6.3REMOTECONTROLBATTERIES

The infrared remote control is powered by 2 x AAA (LR03, 24A, MN2400) 1.5V

batteries.Depleted batteriesin theremotecontrol willcausepoor remoteoperating

range.Thebatteriesshouldbereplacedasrequiredwithnewbatteriesofthesame

typebyremovingthecoverfromtherearoftheremotecontrol.Takecaretoinsertthe

newbatterieswiththecorrectpolarityasindicatedinthebatterycompartment.

CAUTION

Dead batteries may leak and damage the remote if left for long periods. Batteries

shouldberemovedfromtheremoteifdeadoriftheair-conditionerisnottobeusedfor

alongperiod.Damagetotheremotecontrolcausedbyleakingbatteriesisnotincluded

inthetermsofthemanufacturer’sdefectwarranty.

6.4GENERALCONDITION

Regularlyinspecttheconditionoftheunitforsignsofdamage,wearormalfunction.

If used correctly, this air-conditioner should give you years of comfortable function.

However,ifyouencounteranyproblemsatanytime,pleaseswitchpowerofftheunit

byswitchingofftheACswitchandthesafetycircuitbreakeronyourcaravanbefore

gettingintouchwithyournearestServiceAgentforassistance.

7. TECHNICAL DATA

Unit: RT1Air-Conditioner.PartNo.TA448006-9260

Application: Fixedroofcaravansandmotorhomes

TypicalCoolingCapacity: 2.5kW

TypicalHeatingCapacity: 2.0kW

Dimensions: 1096x739x207(H)

Weight: 39Kg.

PowerSupply: 230-240VAC,50Hz

MaximumRatedCurrent: 8A

Airflowvolume: 340m³/happrox.

Refrigerant: R410a

Refrigerantamount: 635g±10

Maximumoperatingincline: 5˚

TypicalTemperatureRange: Cooling(16-48˚C)Heating(-3to25˚C)

Operation

7.1WIRINGDIAGRAM

BLACK

VIOLET

BLACK

BLUE

RED

BLACK

GREY

WHITE

BLUE

GREEN/YELLOW

GREY

WHITE

BLUE

BROWN

BLACK

BROWN

GREY

BLACK

BROWN

RED

ORANGE

BLUE

POWER LED

IR RECEIVER

QUICK COOL LED

BUZZER

USE ONLY SPECIFIED

REPLACMENT FUSES &

ELECTRICAL COMPONENTS.

CONNECTION MUST COMPLY

WITH LOCAL LAWS AND

REGULATIONS.

SUPPLY CONNECTION

COMPRESSOR

THERMAL SWITCH

PRESSURE SWITCH

CAPACITOR

PTC STARTER

CAPACITOR

EXTERIOR FAN

CAPACITOR

INTERIOR FAN

CAPACITOR

TRANSFORMER

SOLENOID

MAIN PCB

10A FUSE

REMOTE PCB

REMOTE HARNESS

BROWN

BLUE

GREEN/

YELLOW

RED

CONNECTION BY INSTALLER

Operation

8. TROUBLESHOOTING

Symptom Cause Remedy

Unitdoesnot

operate

Powersupplyisoff Checkandconfirmthatthecaravanmain

powerisswitchedon.ChecktheACswitch

andthesafetycircuitbreakeronthecaravan.

Alltheseshouldbeswitchedon.

Powerinterruption Toprotectitselffromdamage,theunitmay

switchoff(returntostandby)ifpoweris

momentarilyinterrupted.Ensurethatthe

caravanisconnectedtoacleanpowersupply

withinthespecifiedpoweroperatingrange

beforeattemptingtorestarttheunit.

Remotecontrolnot

working

Remotecontrolinstructionsareconfirmedbya

beepandthepowerLEDblinkingonce.There

isashortdelaybetweenacommandbeing

sentandtheunitresponding.Ensurethat

theremotecontrolispointedtowardstheair

distributionunitfromadistancelessthan8m.

Replacethebatteriesifnecessary.

Exteriorfan

changes

speed.

Thespeedofthe

exteriorfanchanges

orswitchesoff

occasionally

Theexternalfanisadjustedbasedonsystem

andambientconditions.Wherepossible,the

exteriorfanwillswitchtolowspeedforless

disturbancetoyouandyourneighbours.In

heatingmode,theexteriorfanmayswitchoff

periodicallytoallowcondensatetodrainaway

Poor

performance

Blockedcondenser Checkthatthecondenser(ontherooftop)is

notblockedwithdust,leavesorrubbish.Clean

ifneccesary.

Blockedfilter Inspecttheindoorairfilterontheinnerairdistri-

butionunit.Cleanorreplaceifnecessary.

Outsideofoperating

temperature

Usewithinoperatingtemperaturerangeand

followguidelinesinsection3.1

Compressor

cutsordoes

notstart.

Thesystemhas

anumberof

inbuiltprotection

mechanisms

toprotectthe

compressorfrom

operatingoutsideits

designlimits

Ensurethattheunitisbeingusedwithinit’s

operatingtemperaturerange.Refertothe

technicaldatafordetailsoftheoperating

rangesinsection3.1.

Operation

Symptom Cause Remedy

Unit

operating

continously

Systemunable

toreachdesired

setpoint.

Changetemperaturesettingonremotecontrol

(confirmedbybeep&LEDblink).Closeall

doors,windowsandcurtainstoimprove

insulationandreducetheloadonthesystem.

BothLED’s

flashing.Unit

doesnot

operate.

BothLED’sflash

together.

Powersupplyvoltageisoutofacceptable

rangeforsafeoperationoftheunit.Ensurethat

thecaravanisconnectedtosupplyofcorrect

voltage.

BothLED’sflash

alternately.

Internalfaultdetected.Contactservicecentre

forassistance.

Condensate

formation

Condensatemay

formoncold

surfaceswhen

operatinginhumid

conditions.

Ensurealldoorsandwindowsareproperly

sealedwhenrunningtheair-conditioner.Keep

allcupboardsanddrawersclosed.

Theevaporator

condensatedrain

isblocked.This

maybeindicatedby

waterdropletsbeing

carriedintheair.

Checkandconfirmthatthecondensatedrains

ontherooftopunitareclearofdirtorother

foreignmaterial.

8. TROUBLESHOOTING - cont...

Ifsymptomspersistaftertheaboveactionshavebeentaken,switchoffpowertothe

air-conditioningunitatthesafetycircuitbreakerandtheair-conditionerswitchonyour

caravan,andcontactyournearestdealeroraqualifiedtechnicianforhelp.

Operation

DENSOWARRANTY

ANIMPORTANTMESSAGEFROMDENSO

ThankyouforpurchasingaDENSOProduct.

ToensurethatYourDENSOProductperformsproperlyandtoensurethevalidityofDENSO’sWarranty,pleasefollowallthe

instructionsandrecommendationsconcerningtheinstallation,use,servicing,maintenanceandrepairoftheProduct,asset

outinthedocumentationprovidedwiththeProduct.IfYourequirefurtherassistanceconcerningtheProductafterreadingall

suchinstructionsandrecommendations,pleasecontactUs,usingthecontactdetailsinclause3below.

WerecommendthatYoucontactUsoranAuthorisedDENSOServiceRepresentativeforallYourserviceneeds.

NOTICETOCONSUMERSUNDERAUSTRALIANCONSUMERLAW

ThefollowingappliesifYouarea‘consumer’undertheAustralianConsumerLaw:

Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You

are entitled to a replacement or refund for a major failure and compensation for any other reasonably

foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the goods

fail to be of acceptable quality and the failure does not amount to a major failure.

The benefits provided by DENSO’s Warranty are in addition to any other rights and remedies of a

consumer under the Australian Consumer Law and any other law which may apply to the Product.

1.WHATISCOVEREDBYTHISWARRANTY?

WewarrantthatYourDENSOProductpurchasedinAustraliaisfreefromdefectsinmaterialandworkmanship,subjectto

theExclusionssetoutinclause7andtheothertermsandconditionscontainedinthisdocument.

2.WARRANTYPERIOD

ThisWarrantyappliestoanydefectinYourDENSOProductwhichappearswithintheperiod:

(a)commencingonthedatetheProductwaspurchasedfromtheSupplier;and

(b)terminating12monthsaftercommencement.

AnyProductWerepairorreplaceunderthisWarrantywillbewarrantedbyUsunderthisWarrantyforthebalanceofthis

WarrantyPeriodonly.

3.WHOGIVESTHISWARRANTY?

DENSOAutomotiveSystemsAustraliaPtyLtd

2-46MerrindaleDrive

Croydon,Vic,3136

TechnicalServiceDepartment:

Tel:0387611449

Fax:0387611502

Email:service.department@denso.com.au

4.WHATWEWILLDO

TohonourthisWarranty,Wewill:

(a)repairorreplacetheProduct,atOuroptionandexpense;

(b)arrangefortheProducttoberepairedorreplaced,atOuroptionandexpense;or

(c)payYouanamountequivalenttothecostofrepairingorreplacingtheProduct.

5.WHATYOUMUSTDO

ToensurethatYouremainentitledtoclaimunderthisWarranty,Youmust:

(a)provideUswithsatisfactoryproofofpurchaseoftheProduct,whichclearlyindicatesthenameandaddressofthe

Supplier,thedateandplaceofpurchase,andidentifiestheProduct(WerecommendthatYouprovideUswithalegible

andunmodifiedreceiptorsalesinvoicefortheProduct);

(b)install,use,service,maintainandrepairtheProductinaccordancewithOurinstructionsandrecommendations;and

(c)ensurethatnoneoftheExclusionsinclause7apply.

6.PROCEDURETOCLAIMUNDERTHISWARRANTY

TomakeaclaimunderthisWarranty,Youmusttakethefollowingsteps:

STEP1

ContactUs,duringtheWarrantyPeriod,usingthecontactdetailsinclause3,andprovideUswithYourname,address,

telephonenumber,detailsoftheProduct,detailsoftheSupplierandanoutlineofYourclaiminrelationtotheProduct.We

willdirectYoutotaketheproducttoanAuthorisedDensoServiceRepairer,theSupplierorus.

Operation

STEP2

YoumustthentaketheProducttoanAuthorisedDensoServiceRepairer,theSupplierorusinaccordancewithour

directions.Youmustprovidesatisfactoryproofofpurchase.

STEP3

FollowinginspectionoftheProduct,YouwillbeinformedwhetherYourclaimhasbeenacceptedand,ifso,whether

theProductwillberepairedorreplacedatourexpense,orwhetherYouwillbepaidanamountequivalenttothecostof

repairingorreplacingtheProduct.

NeithertheSupplieroranyAuthorisedDENSOServiceRepairerareauthorisedtoacceptYourclaimonourbehalf,unless

expresslyauthorisedbyUstodoso..

PleasenotethatthisWarrantydoesnotcoveranyexpensesYoumayincurinmakingaclaimunderthisWarranty,

includinganycostofhavinganAuthorisedDENSOServiceRepairertraveltothepremisesatwhichtheProduct

islocated,thecostofremovingtheProductfromitsplaceofinstallationorreinstallingtheProduct,andthecostof

transportingtheProductforthepurposesofrepairorreplacement.

7.EXCLUSIONS

ThisWarrantydoesnotapplyiftheProductisoutsideAustraliaoriftheclaimiswhollyorpartlyattributabletoany:

(a)failuretoproperlyinstall,use,service,maintainandrepairtheProduct,inaccordancewithanyinstructionsor 

recommendationsfromUs;

(b)misuseoftheProductincludinguseoftheProductforpurposesotherthanitsintendedpurpose,useoftheProduct

contrarytoOurinstructionsandrecommendations,anduseoftheProductafteritbecomesapparentthatitrequires

service,maintenanceorrepair;

(c)accidentaldamageincludingfire,theftandexplosion;

(d)actsofGodanddamageorcorrosiontotheProductcausedbyenvironmentalconditionsincludingexcessive 

moisture,acidrain,airbornefallout,stones,salt,sand,hail,wind,storms,lightning,floods,infestationbyrodentsor

othervermin;

(e)modificationoftheProductinamannernotauthorisedbyUs;

(f)incorporationofpartsotherthanDENSOpartsorotherpartsauthorisedbyUs;

(g)normalwearanddeterioration,havingregardtotheoperatingenvironmentoftheProduct,includingdiscoloration;

(h)routineserviceormaintenancecosts;

(i)componentswarrantedbyothermanufacturers;

(j)failuretorespondinatimelymannertoanymalfunctionoftheProduct;

(k)non-DENSOproduct,oranyinstallation,service,maintenanceorrepairbyapersonotherthananAuthorisedDENSO

ServiceRepairerorotherpersonapprovedbyUs;or

(l)commercialuseoftheProduct.

8.LIMITATIONOFLIABILITYUNDERTHISWARRANTY

Asindicatedinclause4,YourrightsunderthisWarrantyarelimitedtorepairorreplacementoftheProduct,orbeing

paidthecostofrepairingorreplacingtheProduct.WewillnotbeliableunderthisWarrantyforanyconsequentialloss

including,withoutlimitation,theinjuryordeathofanyperson,damagetoanyotherproperty,orlossofanyincome,profit

orbusiness.

9.EXCLUSIONANDLIMITATIONOFANYOTHERLIABILITIES

ExceptasprovidedunderthisWarrantyandbylaw,WegiveYounowarranty,guaranteeorsimilarrightinrelationtothe

Product.Tothefullextentpermittedbylaw,Weexcludeanywarranty,guaranteeorsimilarrightprovidedorimpliedby

law.

Ifanywarranty,guaranteeorsimilarrightprovidedorimpliedbylawappliestotheProduct,tothefullextentpermittedby

lawWelimitOurliabilitytoYoutotherepairorreplacementoftheProduct,orthecostofhavingtheProductrepairedor

replaced.

Exceptasprovidedbylaw(includingtheAustralianConsumerLaw,ifapplicable),WewillnotbeliabletoYou,whetherin

contract,tortorotherwise,foranylossordamagesufferedasaresultofYouacquiringtheProduct.

10.DEFINITIONS

“AuthorisedDENSOServiceRepairer”meansapersonorcompanyauthorisedbyUstoprovideserviceforsuch

Products.

“Product”means[theRT1caravanair-conditionerunit]suppliedwiththisWarrantyinAustralia,andusedexclusivelyin

Australia.

“Supplier”meanstheauthoriseddistributororretaileroftheProductwhosoldYoutheProductorUsifWesoldyouthe

Product.

“WarrantyPeriod”meanstheperiodoftimedefinedinclause2.

“We”or“Us”or“Our”meansDENSOAutomotiveSystemsAustraliaPtyLtdACN007110929.

“You”or“Your”meanstheretailpurchaseroftheProductfromtheSupplierortheoriginalend-useroftheProduct.

PLEASE REMOVE AND RETURN OWNER’S REGISTRATION CARD WITHIN 30 DAYS OF PURCHASE

Location of the Serial Number on the roof top unit:

REGISTRATION OF YOUR UNIT

Once installed, owners are encouraged

to register their product with DENSO.

Please follow the link, via the QR code to

complete on-line registration or log on

to www.denso.com.au/caravan and look

for the “on-line registration forms - Caravan Airconditioning.”

Alternatively, complete the below form and mail it to DENSO.

Name:

Address:

Telephone:

Caravan brand:

Caravan model:

Date of purchase:

Place of purchase:

Installed by:

Serial No: **

** See page #17 for location of Serial No.

All electrical work and permanent wiring must be carried out by an

appropriately qualified person in accordance with national wiring regulations

and all other applicable local codes and regulatory authority requirements.

This unit must be earthed & connected through a suitably rated two-

pole switch allowing disconnection of the active & neutral conductors.

Operation

Denso RT1 Owner's manual

Related papers

Other documents