Reznor R6GP 6, 7.5 - 10 Ton Archived 2/23/12 Product information

R6GP 6, 7.5 - 10 Ton Archived 2/23/12
Reznor
Brand
Reznor
Model
R6GP 6, 7.5 - 10 Ton Archived 2/23/12
Type
Product information

This manual is also suitable for

208-230/460 VOLT
R6GP-072 (C/D) Series
3 Phase / 60Hz.
WIRING DIAGRAM
NOTES:
1. This wire replaced when autotransformer is used.
2. For 072C models only. For 208V operation,remove
wire from 240V tap on transformer
and install on 208V tap.
3. Wires attached to normally open contacts.
4. Wires attached to normally closed contacts.
5. Disconnect all power before servicing.
6. For supply connections, use copper
conductors only.
7. If any of the original wire as supplied
with the unit must be replaced, it
must be replaced with wiring material
having a temperature rating of at
least 105C.
8. For supply wire ampacities and
overcurrent protection, see unit
rating label.
7107550
0209
FIELD WIRING
LEGEND:
LOW VOLTAGE
HIGH VOLTAGE
¢7107551¤
L1
L2
L3
T1
T2
T3
COMP 1
T2
T3
T1
123 5467810911121314 15
123 54678109111213
1514
R
Y1
Y2
W1
G
W2
C
R
Y1
Y2
G
W1
W2
C
S
R
1
2
3
1
2
3
L1
L2
T1
T2
L3
L1
L1
L2
L2
L3
L3
1
2
3
1
2
3
C
S
R
L1
L2
L3
T1
T2
T3
COM
L1L2
L3
T1
T2
T3
G
C
R
L
COM
NC
NO
T2
T1
T3
S1
S2
GAS VALVE
IND
MTR
UL
LL
CEN
SI
FS
24VAC
IND
L1
FS
K4
FLAME
SENSOR
P1-2
P1-4
P1-7
SPARK
TRANSFORMER
K1
K2
COMM
P2-1
3 AMP
AUTO
FUSE
ROLLOUT
WITCH
HIGH LIM
INPUT
P1-8
P1-3
W1 P2-3
W2 P2-4
R P2-2
P1-6
P1-9
GR
WH
BK
BK
BK BK BR
BR
BK
RD
YE
OR
RD
OD FAN1
OD FAN 2
BK
BL
OR
BK
BL
OR
HIGH VOLTAGE
TERM. BOARD
CHASSIS
GROUND
TO FIELD
SUPPLIED
DISCONNECT
(3 PHASE
POWER ONLY)
ECONOMIZER
PLUG
LOW VOLTAGE
TERMINAL BLOCK
FACTORY JUMPERS w/no ECONOMIZER
INDOOR
THERMOSTAT
TERMINALS
YE
BR
S1
FS
S1
LP
S1
HP
YE
BR
BR
BR
BR
BK
S1
COMP
CON
S1
CCH
ID
BLWR
CON
OPTIONAL
AUTO-
TRAN
TRAN
L3
L2
BK
BK
(NOTE 3)
BK-18(71)
RD-18(69)
YE-18(70)
(NOTE 3)
(NOTE 2)
RD
RD
INDOOR
MOTOR
OVERLOAD
(OPTIONAL)
CONTROL WIRING LEADS
Refer to Installation
Instructions for Connections
for Indoor Thermostat
OD FAN
CON
NOTE 1
S1 = STAGE 1
S2 = STAGE 2
FS = FREEZE STAT
HP = HIGH PRESSURE SWITCH
LP = LOW PRESSURE SWITCH
CCH = CRANK CASE HEATER
BLWR = BLOWER
TRAN = TRANSFORMER
MTR = MOTOR
CON = CONTACTOR
CAP = CAPACITOR
ID = INDOOR
OD = OUTDOOR
COMP = COMPRESSOR
CEN = CENTRIFICIAL SWITCH
UL = UPPER LIMIT (AIR)
LL = LOWER LIMIT (AIR)
FR = FLAME ROLLOUT SWITCH
FS = FLAME SENSOR
SI = SPARK IGNITOR
IND = EXHAUST INDUCER
ID BLWR
MTR
ORANGE
BLUE
GRAY
WHITE
BROWN
BLACK
BLACK
RED
YELLOW
ORANGE
ORANGE
ORANGE
WHITE
BROWN
BLACK
BLACK
RED
ORANGE
RED
GRAY
RED
RED
RED
BLACK
BLACK
RED
YELLOW
BLACK
BLACK (NOTE 4)
YELLOW
RED
BLACK
YELLOW/BLACK
RED/BLACK
BLACK/WHITE
RED
BLACK
BLACK
BLACK
BLUE
ORANGE
BLACK
BLUE
BLUE
ORANGE
ORANGE
RED
RED
BLACK
WHITE
BLACK
RED
ORANGE
RED
RED
GREEN
CAP
CAP
RED
BLACK
BLACK
BLUE
  • Page 1 1

Reznor R6GP 6, 7.5 - 10 Ton Archived 2/23/12 Product information

R6GP 6, 7.5 - 10 Ton Archived 2/23/12
Reznor
Brand
Reznor
Model
R6GP 6, 7.5 - 10 Ton Archived 2/23/12
Type
Product information
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents