Wallenstein BX Series Wood Chipper User manual

3 POINT HITCH WOOD CHIPPER

MODELS BX32, BX42R, BX42S,

BX62R,BX62S & BX92S

OPERATOR'S MANUAL

PRINTED IN CANADA

REV 080313 PART NUMBER: Z97032

BX62R

BX32 BX42R

BX62S BX92S

BX42S

EMB Manufacturing Inc.

4144 Boomer Line · St. Clements, On · N0B 2M0 · Canada

Ph: (519) 699-9283 · Fax: (519) 699-4146

www.embmfg.com

BY EMB MFG INC.

TABLE OF CONTENTS

WARRANTY .........................................................................3

DELIVERY INSPECTION REPORT .....................................4

SERIAL NUMBER LOCATION ............................................5

1 INTRODUCTION .....................................................6

2 SAFETY ..................................................................7

2.1 GENERALSAFETY...........................................8

2.2 EQUIPMENTSAFETYGUIDELINES................9

2.3 SAFETYTRAINING.........................................10

2.4 SAFETYSIGNS...............................................10

2.5 PREPARATION................................................ 11

2.6 MAINTENANCESAFETY................................ 11

2.7

OPERATINGSAFETY............................................. 12

2.8 HYDRAULICSAFETY.....................................13

2.9 STORAGESAFETY........................................13

2.10 TRANSPORTSAFETY....................................13

2.11 SIGN-OFFFORM............................................14

3 SAFETY SIGN LOCATIONS ...............................15

3.1 THREEPANELSAFETYSIGNS.....................15

3.2 TWOPANELSAFETYSIGNS.........................21

4 OPERATION .........................................................26

4.1 TOTHENEWOPERATOROROWNER........26

4.2 MACHINECOMPONENTS.............................27

4.3 MACHINEBREAK-IN......................................28

4.4 PRE-OPERATIONCHECKLIST......................28

4.5 DRIVELINEDIMENSION................................29

4.6 MOUNTINGANDUNHOOKINGTRACTOR...30

4.7 CONTROLS.....................................................33

4.8 FIELDOPERATION.........................................35

4.9 TRANSPORTING............................................42

4.10 STORAGE.......................................................43

4.10.1 PLACINGINSTORAGE.................................43

4.10.2 REMOVINGFROMSTORAGE......................43

5 SERVICE AND MAINTENANCE ....................... 44

5.1 FLUIDSANDLUBRICANTS......................... 44

5.2 GREASING................................................... 44

5.3 SERVICINGINTERVALS............................. 44

5.4 SERVICEILLUSTRATION............................ 45

5.5 SERVICERECORDCHART........................ 46

5.6 DRIVELINEMAINTENANCE........................ 47

5.7 DRIVEBELTTENSIONANDALIGNMENT

(MODELBX32)........................................................... 48

6 TROUBLE SHOOTING ...................................... 49

7 SPECIFICATIONS ............................................. 50

7.1 MECHANICAL.............................................. 50

7.2 BOLTTORQUE............................................ 51

7.3 HYDRAULICFITTINGTORQUE.................. 52

8 ACCESSORIES ................................................. 52

#C3540SELFCONTAINERPTOPOWERPACK...... 52

WALLENSTEIN

3 POINT HITCH WOOD CHIPPER

DELIVERY INSPECTION REPORT

DateOwner'sSignature

DateDealer’sRep.Signature

TheaboveequipmentandOperator’sManualhavebeenreceivedbymeandIhavebeenthoroughly

instructedastocare,adjustments,safeoperationandapplicablewarrantypolicy.

Thisformmustbelledoutbythedealerandsignedbyboththedealerandthecustomeratthetimeofdeliv-

ery.

Customer’sName DealerName

Address Address

City,State/Province,Code City,State/Province,Code

PhoneNumber() PhoneNumber()

ContactName   

Model    

SerialNumber   



DeliveryDate 

IhavethoroughlyinstructedthebuyerontheabovedescribedequipmentwhichreviewincludedtheOp-

erator’sManualcontent,equipmentcare,adjustments,safeoperationandapplicablewarrantypolicy.

DEALER INSPECTION REPORT



SAFETY



____ AllDecalsInstalled

____ GuardsandShieldsInstalledandSecured

____ ReviewOperatingandSafetyInstructions

____ CheckBladeClearance

____ BlowerTurnsFreely

____ FastenersTight

____ LubricateMachine

____ RetainerInstalledThroughMountingPins

To activate warranty, register your product online at

www.embmfg.com

SERIAL NUMBER LOCATION

AlwaysgiveyourdealertheserialnumberofyourWallenstein3PointHitchWoodChipperandFeed

Hopperwhenorderingpartsorrequestingserviceorotherinformation.

Theserialnumberplatesarelocatedwhereindicated.Pleasemarkthenumbersinthespacesprovided

foreasyreference.

SERIAL NUMBER LOCATION

Model Number ____________________________________________________

Chipper Serial Number _____________________________________________

Fig. 1 BX42S BX42R Fig. 2 BX32

Fig. 3 BX62S BX62R BX92S

1 INTRODUCTION

CongratulationsonyourchoiceofaWallenstein3PointHitchWoodChippertocomplimentyouropera-

tion.Thisequipmenthasbeendesignedandmanufacturedtomeettheneedsofadiscerningtimberor

landscapingindustry.

Safe,efcientandtroublefreeoperationofyourWallensteinWoodChipperrequiresthatyouandanyone

elsewhowillbeusingormaintainingthechipper,readandunderstandtheSafety,Operation,Mainte-

nanceandTroubleShootinginformationcontainedwithintheOperator'sManual.

ThismanualcoverstheWallenstein3PointHitchWoodChipperBX32,BX42S,BX42R,BX62S,BX62R

andBX92S.UsetheTableofContentsorIndexasaguidetolocaterequiredinformation.

Keepthismanualhandyforfrequentreferenceandtopassontonewoperatorsorowners.Callyour

WallensteindealerortheDistributorifyouneedassistance,informationoradditionalcopiesofthemanu-

als.

OPERATOR ORIENTATION -Thedirectionsleft,right,frontandrear,asmentionedthroughoutthis

manual,aredeterminedwhensittinginthetractordriver'sseatandfacinginthedirectionoftravel.

BX42S

BX62R

BX32 BX42R

BX62S BX92S

2 SAFETY

SAFETY ALERT SYMBOL

WhyisSAFETYimportanttoyou?

TheSafetyAlertsymbolidenties

importantsafetymessagesonthe

Wallenstein3PointHitchWood

Chipperandinthemanual.When

youseethissymbol,bealertto

thepossibilityofpersonalinjuryor

death.Followtheinstructionsinthe

safetymessage.

ThisSafetyAlertsymbolmeans

ATTENTION! BECOME ALERT!

YOUR SAFETY IS INVOLVED!

Accidents Disable and Kill

Accidents Cost

Accidents Can Be Avoided

3 Big Reasons

Ifyouhaveanyquestionsnotansweredinthismanualorrequireadditionalcopiesorthemanualisdam-

aged,pleasecontactyourdealerorWallenstein,4144BoomerLine,St.Clements,ON,N0B2M0.Phone

(519)699-9283orFax(519)699-4146.

DANGER - Indicatesanimminentlyhazardous

situationthat,ifnotavoided,will

resultindeathorseriousinjury.This

signalwordistobelimitedtothe

mostextremesituationstypicallyfor

machinecomponentswhich,forfunc-

tionalpurposes,cannotbeguarded.

WARNING - Indicatesapotentiallyhazardous

situationthat,ifnotavoided,could

resultindeathorseriousinjury,and

includeshazardsthatareexposed

whenguardsareremoved.Itmay

alsobeusedtoalertagainstunsafe

practices.

CAUTION - Indicatesapotentiallyhazardous

situationthat,ifnotavoided,may

resultinminorormoderateinjury.It

mayalsobeusedtoalertagainst

unsafepractices.

SIGNAL WORDS:

NotetheuseofthesignalwordsDANGER,

WARNING andCAUTIONwiththesafety

messages.Theappropriatesignalwordfor

eachmessagehasbeenselectedusingthe

followingguide-lines:

SAFETY

YOUareresponsiblefortheSAFEoperationand

maintenanceofyourWallenstein3PointHitch

WoodChipper.YOUmustensurethatyouand

anyoneelsewhoisgoingtouse,maintainorwork

aroundthe3PointHitchWoodChipperbefamil-

iarwiththeusingandmaintenanceprocedures

andrelatedSAFETYinformationcontainedinthis

manual.Thismanualwilltakeyoustep-by-step

throughyourworkingdayandalertsyoutoall

goodsafetypracticesthatshouldbeusedwhile

usingthe3PointHitchWoodChipper.

Remember,YOUarethekeytosafety.Good

safetypracticesnotonlyprotectyoubutalsothe

peoplearoundyou.Makethesepracticesawork-

ingpartofyoursafetyprogram.Becertainthat

EVERYONEusingthisequipmentisfamiliarwith

therecommendedusingandmaintenanceproce-

duresandfollowsallthesafetyprecautions.Most

accidentscanbeprevented.Donotriskinjuryor

deathbyignoringgoodsafetypractices.

• 3PointHitchWoodChipperownersmustgive

operatinginstructionstooperatorsorem-

ployeesbeforeallowingthemtooperatethe

machine,andatleastannuallythereafter.

• Themostimportantsafetydeviceonthis

equipmentisaSAFEoperator.Itistheop-

erator’sresponsibilitytoreadandunderstand

ALLSafetyandOperatinginstructionsinthe

manualandtofollowthese.Mostaccidents

canbeavoided.

• Apersonwhohasnotreadandunderstoodall

usingandsafetyinstructionsisnotqualied

tousethemachine.Anuntrainedoperator

exposeshimselfandbystanderstopossible

seriousinjuryordeath.

• Donotmodifytheequipmentinanyway.

Unauthorizedmodicationmayimpairthe

functionand/orsafetyandcouldaffectthelife

oftheequipment.

• ThinkSAFETY!WorkSAFELY!

1. ReadandunderstandtheOp-

erator’sManualandallsafety

signsbeforeusing,maintain-

ing,adjustingorcleaningthe

3PointHitchWoodChipper.

2.1 GENERAL SAFETY

2. Havearst-aidkitavailable

foruseshouldtheneed

ariseandknowhowtouse

it.

3. Haveareextinguisher

availableforuseshouldthe

needariseandknowhowto

useit.

4. Donotallowriders.

5. Wearappropriate

protectivegear.This

listincludesbutisnot

limitedto:

 - Ahardhat

 - Protective

  shoeswithslip

  resistantsoles

 - Protectiveglasses,

 gogglesorfaceshield

 - Heavygloves

 - Wetweathergear

 - HearingProtection

 - Respiratororltermask

6. Installandsecureallguards

beforestarting.

7. Wearsuitableearprotection

forprolongedexposureto

excessivenoise.

8. Turnmachineoff,stopand

disableengine,removeignitionkeyandplace

inyourpocket,setparkbrakeandwaitforall

movingpartstostopbeforeservicing,adjust-

ing,repairingorunplugging.

9. Cleartheareaofpeople,especiallysmall

children,beforeusingtheunit.

10. Reviewsafetyrelateditemsannuallywithall

personnelwhowilloperatingormaintaining

the3PointHitchWoodChipper.

2.2 EQUIPMENT SAFETY GUIDELINES

1. Safetyoftheoperatorandbystandersisone

ofthemainconcernsindesigningandde-

velopingequipment.However,everyyear

manyaccidentsoccurwhichcouldhavebeen

avoidedbyafewsecondsofthoughtanda

morecarefulapproachtohandlingequipment.

You,theoperator,canavoidmanyaccidents

byobservingthefollowingprecautionsinthis

section.Toavoidpersonalinjuryordeath,

studythefollowingprecautionsandinsist

thoseworkingwithyou,orforyoutofollow

them.

2. Inordertoprovideabetterview,certain

photographsorillustrationsinthismanual

mayshowanassemblywithasafetyshield

removed.However,equipmentshouldnever

beusedinthiscondition.Keepallshieldsin

place.Ifshieldremovalbecomesnecessary

forrepairs,replacetheshieldpriortouse.

3. Replaceanysafetysignorinstructionsign

thatisnotreadableorismissing.Locationof

suchsafetysignsisindicatedinthismanual.

4. Neverusealcoholicbeveragesordrugswhich

canhinderalertnessorcoordinationwhileus-

ingthisequipment.Consultyourdoctorabout

usingthismachinewhiletakingprescription

medications.

5. Under no circumstances should young

children be allowed to work with this

equipment. Do not allow persons to use or

assemble this unit until they have read this

manual and have developed a thorough

understanding of the safety precautions

and of how it works.Reviewthesafety

instructionswithallusersannually.

6. Thisequipmentisdangeroustochildrenand

personsunfamiliarwithitsoperation.The

operatorshouldbearesponsible,properly

trainedandphysicallyablepersonfamiliar

withmachineryandtrainedinthisequipment's

operations.Iftheelderlyareassistingwith

work,theirphysicallimitationsneedtobe

recognizedandaccommodated.

7. Neverexceedthelimitsofapieceofmachin-

ery.Ifitsabilitytodoajob,ortodososafely,

isinquestion-DON'T TRY IT.

8. Donotmodifytheequipmentinanyway.Un-

authorizedmodicationmayresultinserious

injuryordeathandmayimpairthefunction

andlifeoftheequipment.

9. Inadditiontothedesignandcongurationof

thisimplement,includingSafetySignsand

SafetyEquipment,hazardcontrolandac-

cidentpreventionaredependentuponthe

awareness,concern,prudence,andproper

trainingofpersonnelinvolvedintheoperation,

transport,maintenance,andstorageofthe

machine.ReferalsotoSafetyMessagesand

operationinstructionineachoftheappropri-

atesectionsofthetractorandmachinemanu-

als.PaycloseattentiontotheSafetySigns

afxedtothetractorandthemachine.

2.3 SAFETY TRAINING

1. Safetyisaprimaryconcerninthedesignand

manufactureofourproducts.Unfortunately,

oureffortstoprovidesafeequipmentcan

bewipedoutbyasinglecarelessactofan

operatororbystander.

2. Inadditiontothedesignandcongurationof

equipment,hazardcontrolandaccidentpre-

ventionaredependentupontheawareness,

concern,prudenceandpropertrainingof

personnelinvolvedintheoperation,transport,

maintenanceandstorageofthisequipment.

3. Ithasbeensaid,"The

bestsafetyfeatureisan

informed,carefulopera-

tor."Weaskyoutobethat

kindofanoperator.Itisthe

operator'sresponsibilitytoreadandunder-

standALLSafetyandUsinginstructionsinthe

manualandtofollowthese.Accidentscanbe

avoided.

4. Working with unfamiliar equipment can

lead to careless injuries. Read this manual

before assembly or using, to acquaint

yourself with the machine. If this machine

is used by any person other than yourself,

or is loaned or rented, it is the machine

owner's responsibility to make certain that

the operator, prior to using:

a. Read and understand the operator's

manuals.

b. Is instructed in safe and proper use.

5. Knowyourcontrolsandhowtostoptractor

 andmachinequicklyinanemergency.Read

thismanualandtheoneprovidedwithtractor.

6. Trainallnewpersonnelandreviewinstruc-

tionsfrequentlywithexistingworkers.Be

certainonlyaproperlytrainedandphysically

ablepersonwillusethemachinery.Aperson

whohasnotreadandunderstoodallusing

andsafetyinstructionsisnotqualiedtouse

themachine.Anuntrainedoperatorexposes

himselfandbystanderstopossibleseriousin-

juryordeath.Iftheelderlyareassistingwith

thework,theirphysicallimitationsneedtobe

recognizedandaccommodated.

2.4 SAFETY SIGNS

1. Keepsafetysignscleanandlegibleatall

times.

2. Replacesafetysignsthataremissingorhave

becomeillegible.

3. Replacedpartsthatdisplayedasafetysign

shouldalsodisplaythecurrentsign.

4. SafetysignsdisplayedinSection3eachhave

apartnumberinthelowerrighthandcorner.

Usethispartnumberwhenorderingreplace-

mentparts.

5. Safetysignsareavailablefromyourauthor-

izedDistributororDealerPartsDepartmentor

thefactory.

How to Install Safety Signs:

• Besurethattheinstallationareaiscleanand

dry.

• Besuretemperatureisabove50°F(10°C).

• Determineexactpositionbeforeyouremove

thebackingpaper.

• Removethesmallestportionofthesplitback-

ingpaper.

• Alignthesignoverthespeciedareaand

carefullypressthesmallportionwiththeex-

posedstickybackinginplace.

• Slowlypeelbacktheremainingpaperand

carefullysmooththeremainingportionofthe

signinplace.

• Smallairpocketscanbepiercedwithapin

andsmoothedoutusingthepieceofsign

backingpaper.

2.5 PREPARATION

1. Neverusethemachineuntilyouhaveread

andcompletelyunderstandthismanual,the

tractorOperator'sManualandeachofthe

SafetyMessagesfoundonthesafetysignson

thetractorandmachine.

2. Personalpro-

tectionequip-

mentincluding

hardhat,safety

glasses,safety

shoes,and

glovesarerec-

ommendeddur-

ingassembly,

installation,operation,adjustment,maintain-

ing,repairing,removal,cleaning,ormoving

theunit.Donotallowlonghair,loosetting

clothingorjewellerytobearoundequipment.

3. PROLONGED EXPOSURE

TO LOUD NOISE MAY

CAUSE PERMANENT

HEARING LOSS!

 Powerequipmentwithor

withoutequipmentattached

canoftenbenoisyenough

tocausepermanent,partial

hearingloss.Werecommendthatyouwear

hearingprotectiononafull-timebasisifthe

noiseintheOperator'spositionexceeds80db.

Noiseover85dbonalong-termbasiscan

causeseverehearingloss.Noiseover90db

adjacenttotheOperatoroveralong-termba-

sismaycausepermanent,totalhearingloss.

NOTE:Hearinglossfromloudnoise(from

tractors,chainsaws,radios,andothersuch

sourcesclosetotheear)iscumulativeovera

lifetimewithouthopeofnaturalrecovery.

4. Clearworkingareaofstones,branchesor

hiddenobstaclesthatmightbehookedor

snagged,causinginjuryordamage.

5. Useonlyindaylightorgoodarticiallight.

6. Besuremachineisproperlymounted,adjust-

edandingoodoperatingcondition.

7. Ensurethatallsafetyshieldingandsafety

signsareproperlyinstalledandingoodcondi-

tion.

2.6 MAINTENANCE SAFETY

1. Goodmaintenanceisyourresponsibility.Poor

maintenanceisaninvitationtotrouble.

2. Followgoodshoppractices.

 - Keepservice

 areacleanand

 dry.

 - Besureelectrical

 outletsandtools

 areproperly

 grounded.

 - Useadequate

 lightforthejobat

 hand.

3. Makesurethereis

plentyofventilation.Neveroperatetheen-

gineofthetowingvehicleinaclosedbuilding.

Theexhaustfumesmaycauseasphyxiation.

4. Beforeworkingonthismachine,shutoffthe

engine,setthebrake,andturnfuelvalveoff.

5. Neverworkunderequipmentunlessitis

blockedsecurely.

6. Alwaysusepersonalprotectiondevicessuch

aseye,handandhearingprotectors,when

performinganyserviceormaintenancework.

Useheavyorleathergloveswhenhandling

blades.

7. Wherereplacementpartsarenecessaryfor

periodicmaintenanceandservicing,genuine

factoryreplacementpartsmustbeusedto

restoreyourequipmenttooriginalspecica-

tions.Themanufacturerwillnotberesponsi-

bleforinjuriesordamagescausedbyuseof

unapprovedpartsand/oraccessories.

8. Areextinguisherandrstaidkitshouldbe

keptreadily

accessiblewhile

performingmain-

tenanceonthis

equipment.

9. Periodicallytightenallbolts,

nutsandscrewsandcheckthatallelectrical

andfuelconnectionsareproperlysecuredto

ensureunitisinasafecondition.

10. Whencompletingamaintenanceorservice

function,makesureallsafetyshieldsand

devicesareinstalledbeforeplacingunitin

service.

2.7

OPERATING SAFETY

1. Pleaserememberitisimportantthatyouread

andheedthesafetysignsonthe3PointHitch

WoodChipper.Cleanorreplaceallsafety

signsiftheycannotbeclearlyreadandunder-

stood.Theyarethereforyoursafety,aswell

asthesafetyofothers.Thesafeuseofthis

machineisstrictlyuptoyou,theoperator.

2. Allthingswithmovingpartsarepotentially

hazardous.Thereisnosubstituteforacau-

tious,safe-mindedoperatorwhorecognizes

potentialhazardsandfollowsreasonable

safetypractices.Themanufacturerhas

designedthis3PointHitchWoodChipperto

beusedwithallitssafetyequipmentproperly

attached,tominimizethechanceofaccidents.

Studythismanualtomakesureyouhaveall

safetyequipmentattached.

3. Closeandsecurerotorcoverbeforeoperat-

ing.

4. Closeandsecureallguards,deectorsand

shieldsbeforestartingandoperating.

5. Readandunderstandoperator'smanual

beforestarting.Reviewsafetyinstructions

annually.

6. Personalprotectionequipmentincludinghear-

ingprotection,hardhat,safetyglasses,safety

shoes,andglovesarerecommendedduring

assembly,installation,operation,adjustment,

maintaining,repairing,removal,ormoving.

Donotallowlonghair,loose-ttingclothing,or

jewellerytobearoundmovingparts.

7. Keephydrauliclinesandttingstight,ingood

conditionandfreeofleaks.

8. Neverplaceanypartofyourbodywhereit

wouldbeindangerifmovementshouldoccur

duringassembly,installation,operation,main-

tenance,repairing,unpluggingormoving.

9. Turnmachineoff,stopanddisableengine,

removeignitionkeyandplaceinyourpocket,

setparkbrakeandwaitforallmovingpartsto

stopbeforeservicing,adjusting,repairingor

unplugging.

10. Donotrunmachineinsideaclosedbuildingto

preventasphyxiationfromengineexhaust.

11. Usecarewhenfeedingmaterialintochipper.

Donotsendmetal,bottles,cans,rocks,glass

orotherforeignmaterialintowoodchipper.If

foreignmaterialenterschipper,stopmachine,

turnengineoffandplaceignitionkeyinyour

pocketandwaitforallmovingpartstostop

beforeremovingmaterialand/orunplugging.

Inspectmachinefordamagedorlooseparts

beforeresumingwork.

12. Neverusealcoholicbeveragesordrugswhich

canhinderalertnessorcoordinationwhile

operatingthisequipment.Consultyourdoc-

toraboutoperatingthismachinewhiletaking

prescriptionmedications.

13. Donotallowridersonthismachineatany

time.Thereisnosafeplaceforanyriders.

14. Neverallowchildrenorunauthorizedpeople

tooperateorbearoundthismachine.

15. Donotreachintorotororfeedhopperopen-

ingswhentheengineisrunning.Installand

secureaccesscoversbeforestartingengine.

16 Keeptheworkingareacleanandfreeofde-

bristopreventtripping.Operateonlyonlevel

ground.

17 Donotpointdischargeatpeople,animalsor

buildings.Rotorcanexpelwoodchipsfast

enoughtocauseinjury.

18. Donotmoveortransportchipperwhenthe

rotoristurning.

19. Donotexceedasafetravelspeedwhen

transporting.

2.8 HYDRAULIC SAFETY

1. Makesurethatallthecomponentsinthehy-

draulicsystemarekeptingoodconditionand

areclean.

2. Beforeapplyingpressuretothesystem,make

sureallcomponentsaretight,andthatlines,

hosesandcouplingsarenotdamaged.

3. Donotattemptanymakeshiftrepairstothe

hydrauliclines,ttingsorhosesbyusing

tapes,clampsorcements.Thehydraulicsys-

temoperatesunderextremelyhighpressure.

Suchrepairswillfailsuddenlyandcreatea

hazardousandunsafecondition.

4. Wearproperhandandeye

protectionwhensearching

forahighpressurehy-

draulicleak.Useapiece

ofwoodorcardboardasa

backstopinsteadofhands

toisolateandidentifya

leak.

5. Ifinjuredbyaconcentratedhigh-pressure

streamofhydraulicuid,seekmedicalatten-

tionimmediately.Seriousinfectionortoxic

reactioncandevelopfromhydraulicuid

piercingtheskinsurface.

6. Relievepressureonhydraulicsystembefore

maintainingorworkingonsystem.

2.9 STORAGE SAFETY

1. Storetheunitinanareaawayfromhuman

activity.

2. Donotchildrentoplayonoraroundthe

storedmachine.

3. Storetheunitinadry,levelarea.Supportthe

framewithplanksifrequired.

2.10 TRANSPORT SAFETY

1. Complywithstateandlocallawsgoverning

safetyandtransportingofmachineryonpublic

roads.

2. Checkthatallthelights,reectorsandother

lightingrequirementsareinstalledandingood

workingcondition.

3. Donotexceedasafetravelspeed.Slow

downforroughterrainandcornering.

4. Foldupandsecurefeedhopperbeforemov-

ingortransporting.

5. Besurethemachineishitchedpositivelyto

thetractorandaretainerisusedthroughthe

mountingpins.

6. Donotdrinkanddrive.

7. Beasafeandcourteousdriver.Alwaysyield

tooncomingtrafcinallsituations,including

narrowbridges,intersections,etc.Watchfor

trafcwhenoperatingnearorcrossingroad-

ways.

8. Neverallowridersonthemachine.

2.11 SIGN-OFF FORM

WallensteinfollowsthegeneralSafetyStandardsspeciedbytheAmericanSocietyofAgriculturaland

BiologicalEngineers(ASABE)andtheOccupationalSafetyandHealthAdministration(OSHA).Anyone

whowillbeusingand/ormaintainingthe3PointHitchWoodChippermustreadandclearlyunderstandALL

Safety,UsageandMaintenanceinformationpresentedinthismanual.

Donotuseorallowanyoneelsetousethischipperuntilsuchinformationhasbeenreviewed.Annually

reviewthisinformationbeforetheseasonstart-up.

MaketheseperiodicreviewsofSAFETYandOPERATIONastandardpracticeforallofyourequipment.We

feelthatanuntrainedoperatorisunqualiedtousethismachine.

Asign-offsheetisprovidedforyourrecordkeepingtoshowthatallpersonnelwhowillbeworkingwiththe

equipmenthavereadandunderstandtheinformationintheOperator’sManualandhavebeeninstructedin

theoperationoftheequipment.

EMPLOYEES SIGNATURE EMPLOYERS SIGNATURE

SIGN-OFF FORM

DATE

REMEMBER-Ifsafetysignshavebeendamaged,removed,becomeillegibleorpartsreplacedwithout

safetysigns,newsignsmustbeapplied.Newsafetysignsareavailablefromyourauthorizeddealer.

3 SAFETY SIGN LOCATIONS

3.1 THREE PANEL SAFETY SIGNS

Z94006

Z94007

Thetypesofsafetysignsand

generallocationsontheequip-

mentareshownintheillustrations

thatfollow.Goodsafetyrequires

thatyoufamiliarizeyourselfwith

thevarioussafetysigns,thetype

ofwarningandthearea,orpar-

ticularfunctionrelatedtothat

area,thatrequiresyourSAFETY

AWARENESS.

•ThinkSAFETY!WorkSAFELY!

Fig. 4

REMEMBER-Ifsafetysignshavebeendam-

aged,removed,becomeillegibleorparts

replacedwithoutsafetysigns,newsignsmust

beapplied.Newsafetysignsareavailablefrom

yourauthorizeddealer.

Thetypesofsafetysignsandlocationsontheequipmentareshownintheillustrationsthatfollow.Good

safetyrequiresthatyoufamiliarizeyourselfwiththevarioussafetysigns,thetypeofwarningandthe

area,orparticularfunctionrelatedtothatarea,thatrequiresyourSAFETYAWARENESS.

•ThinkSAFETY!WorkSAFELY!

HIGH PRESSURE FLUID HAZARD

To prevent serious injury or death from

high-pressure uid:

• Relieve pressure on system before

repairing or adjusting.

• Wear proper hand and eye protection

when searching for leaks. Use wood

or cardboard instead of hands.

• Keep all components in good repair.

WARNING

Z94005

Fig. 5

REMEMBER-Ifsafetysignshavebeen

damaged,removed,becomeillegibleorparts

replacedwithoutsafetysigns,newsignsmust

beapplied.Newsafetysignsareavailable

fromyourauthorizeddealer.

Thetypesofsafetysignsandlocationsontheequipmentareshownintheillustrationsthatfollow.Good

safetyrequiresthatyoufamiliarizeyourselfwiththevarioussafetysigns,thetypeofwarningandthe

area,orparticularfunctionrelatedtothatarea,thatrequiresyourSAFETYAWARENESS.

THROWN OBJECT HAZARD

To prevent serious injury or death from

thrown objects:

• Turn machine off, stop and disable en-

gine, remove ignition key and place in

your pocket, set park brake and wait for

all moving parts to stop before adjusting,

servicing, maintaining, repairing or un-

plugging.

• Do not direct discharge duct towards

people, animals or property. Always wear

appropriate safety gear. Keep hands and

feet out of discharge openings.

• Keep others away.

DANGER

Z94008

Z94013

Fig. 6

REMEMBER-Ifsafetysignshavebeendam-

aged,removed,becomeillegibleorpartsreplaced

withoutsafetysigns,newsignsmustbeapplied.

Newsafetysignsareavailablefromyourauthor-

izeddealer.

Thetypesofsafetysignsandlocationsontheequipmentareshownintheillustrationsthatfollow.Good

safetyrequiresthatyoufamiliarizeyourselfwiththevarioussafetysigns,thetypeofwarningandthe

area,orparticularfunctionrelatedtothatarea,thatrequiresyourSAFETYAWARENESS.

Fig. 7

REMEMBER-Ifsafetysignshavebeendamaged,removed,becomeillegibleorpartsreplacedwithout

safetysigns,newsignsmustbeapplied.Newsafetysignsareavailablefromyourauthorizeddealer.

Thetypesofsafetysignsandlocationsontheequipmentareshownintheillustrationsthatfollow.Good

safetyrequiresthatyoufamiliarizeyourselfwiththevarioussafetysigns,thetypeofwarningandthe

area,orparticularfunctionrelatedtothatarea,thatrequiresyourSAFETYAWARENESS.

Fig. 8 Fig. 9

Fig. 10

REMEMBER-Ifsafetysignshavebeendamaged,removed,becomeillegibleorpartsreplacedwithout

safetysigns,newsignsmustbeapplied.Newsafetysignsareavailablefromyourauthorizeddealer.

Thetypesofsafetysignsandlocationsontheequipmentareshownintheillustrationsthatfollow.Good

safetyrequiresthatyoufamiliarizeyourselfwiththevarioussafetysigns,thetypeofwarningandthe

area,orparticularfunctionrelatedtothatarea,thatrequiresyourSAFETYAWARENESS.

GUARDS MISSING

DO NOT OPERATE

DANGER

GUARDS MISSING

DO NOT OPERATE

DANGER

Z94013

ROTATING DRIVELINE HAZARD

CONTACTCANCAUSEDEATH

KEEP AWAY!

DO NOT OPERATE WITHOUT:

• ALL DRIVELINE, TRACTOR AND

EQUIPMENT SHIELDS IN PLACE.

• DRIVELINES SECURELY AT-

TACHED AT BOTH ENDS.

• DRIVELINE SHIELDS THAT TURN

FREELY ON DRIVELINE.

DANGER

Z94010

Fig. 11

Page is loading ...

Wallenstein BX Series Wood Chipper User manual

Related papers

Other documents