2. Munters
  3. celdek maintenance

Munters celdek maintenance Use & Maintenance Manual

  • Hello! I am an AI chatbot trained to assist you with the Munters celdek maintenance Use & Maintenance Manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
www.celdek.com
Scale Control
•MaintainapHbetween7and9inthesumpand6and9formake-upwatersupply.
•Makesuretheowofwaterisevenfromoneendofthedistributorpipetothe
other.
•Waterowshouldbe0.75gpmperlinearfootfora6”pad.
•UseplentyofBleedOff.
AlgaeControl
•Shadethepadsandsump.
•Allowthepadstodryoutcompletelyevery24hours.
•Avoidcontaminantsfromcontactingthepadsandwater.Dust,fumes,fertilizer,
phosphates,etc.providenutrientsforalgaegrowth.
GeneralRules
•Donotcyclethepumponandoffusing10minutetimers.Thiscausesthepads
towearoutprematurely.
•UsechemicalstocleananddisinfectONLY-Nochlorineandnobromine
allowed!RefertoCareManualQM1128forrecommendedcleaningproducts.
Check
Weekly
Check
Monthly
Check
Quarterly
Date:
Initials:
Notes:
Date:
Initials:
Notes:
Date:
Initials:
Notes:
Check
Monthly
Check
Quarterly
•Checkbleed-offrateand
adjustifnecessary.
•Checkwaterowrateand
adjustifnecessary.
•Checkpumpsandclean
anydebrisfromtheinlet.
•Drainanddisinfectthe
entirewaterdistribution
system.
Check
Weekly
Visuallyinspectthepads
forbowing,saggingordry
streaks.
Inspectthesump,remove
anydebrisandmakesurethe
waterleveliscorrect.
Checkthewaterdistribution
systemforleaksandclogged
waterdistributorholes.
InspectionRecord
Bleed Off
•Bleedoffwatercontinuouslyto
preventtheconcentrationof
minerals.
•Startwith1gallon/hour(GPH)
foreachlinearfootofcooling
systemandadjustasneeded
•Thefollowingformulaandtable
istohelpincalculatingyour
bleedoffrate.
60min.
x5gal.=
timetollbucket
inminutes
GPHneeded
Cooling
Length
Bleedoff
ow
inGPH
Minutesto
ll5-gallon
bucket
10ft. 10 30
20ft. 20 15
30ft. 30 10
40ft. 40 7.5
50ft. 50 6
60ft. 60 5
70ft. 70 4.5
celdek check list v2.indd 1 4/17/2012 2:49:23 PM
MuntersCorporation•4215LegionDrive•Mason,MI48854•800-227-2376
MuntersCELdek
®
usesthinpaper.
CELdek is constructed using a speciality grade paper
developed exclusively for Munters. The result is that CELdek
wets faster than any other pad on the market. Faster wetting
means immediate cooling and potentially less run time, saving
you water, energy and money. Thinner paper is fast drying. If
the paper is too thick and does not dry out completely it could
breakdown from the inside out, reducing life of the pad. As
an added precaution CELdek is chemically treated to resist
deterioration.
MI-T-edg
®
improvespadlife.
The strongest most weather resistant edge coating available
and is the only edge coating with patented algae resistance.
SavemoneywithCELdek
®
.
CELdek is known in the industry for long pad life. If you can
add just two years to the life of your evaporative pad, you will
be saving thousands of dollars in the long run.
The Original premium pad manufacturer.
www.celdek.com
DrivenByTechnology
CELdekEvaporativeCoolingPads
BringUnbeatablePerformance,Longevity,andValue!
celdek check list v2.indd 2 4/17/2012 2:49:25 PM
/