Lenovo G50-70 Specification

Lenovo G50-30/G50-45/

G50-70/G50-70m/Z50-70/

Z50-75/G50-80

Hardware

Maintenance

Manual

Notes:

•

Before using this information and the product it supports, be sure to read the general information under

“Notices” on page 91.

•

This manual applies to the following models: Lenovo G50-30/G50-45/G50-70/G50-70m/Z50-70/Z50-75/G50-80.

The illustrations used in this manual are for Lenovo G50-70 unless otherwise stated.

First Edition (Oct. 2014)

LIMITEDANDRESTRICTEDRIGHTSNOTICE:IfdataorsoftwareisdeliveredpursuantaGeneral

ServicesAdministration“GSA”contract,use,reproduction,ordisclosureissubjecttorestrictionsset

forthinContractNo.GS-35F-05925.

©2014Lenovo

iii

Contents

About this manual ....................................... iv

Safety information ........................................ 1

Generalsafety................................................ 2

Electricalsafety.............................................. 3

Safetyinspectionguide.................................. 5

Handlingdevicesthataresensitiveto

electrostaticdischarge.................................... 6

Groundingrequirements................................. 6

Safetynotices:multilingualtranslations.......... 7

Lasercompliancestatement......................... 14

Important service information ................... 16

StrategyforreplacingFRUs......................... 16

Strategyforreplacingaharddiskdrive............17

Importantnoticeforreplacingasystemboard.....17

Importantinformationaboutreplacing

RoHScompliantFRUs................................. 18

General checkout ...................................... 19

Whattodorst............................................. 20

Powersystemcheckout................................ 21

CheckingtheACadapter.................................21

Checkingoperationalcharging.........................21

Checkingthebatterypack................................22

Related service information ...................... 23

Restoringthefactorycontentsbyusing

OneKeyRecovery........................................ 23

Restoreoffactorydefault.................................23

Passwords.................................................... 24

Power-onpassword..........................................24

Hard-diskpassword..........................................24

Administratorpassword....................................24

Powermanagement..................................... 25

Screenblankstate............................................25

Puttingthecomputertosleepor

shuttingitdown.................................................25

Puttingyourcomputertosleep.........................25

Shuttingdownthecomputer.............................25

Lenovo G50-30/G50-45/G50-70/G50-70m/

Z50-70/Z50-75/G50-80 ................................. 26

Specications............................................... 26

Statusindicators........................................... 29

Hotkeys......................................................... 30

FRUreplacementnotices............................. 31

Screwnotices..................................................31

RemovingandreplacinganFRU................. 32

1010Batterypack.............................................33

1020Basecover...............................................34

1030Opticaldrive.............................................36

1040Harddiskdrive.........................................37

1050PCIExpressMiniCardforwirelessLAN.....39

1060DIMM.......................................................41

1070Fanassembly..........................................42

1080Keyboard.................................................44

1090

Keyboardbezel......................................... 47

1100ODDboardandUSB&audioboard..........50

1110

Systemboard............................................ 54

1120Heatsinkassembly..................................57

1130SpeakersandDC-incable.......................58

1140LCDunit...................................................60

1150LCDfrontbezel,LCDpanel,andhinges.....62

1160Camera....................................................65

1170LCDcableandantennaassembly...........67

Locations...................................................... 68

Frontviewandright-sideview..........................68

BottomandLeft-sideview...............................69

Partslist........................................................ 70

Overall..............................................................71

LCDFRUs........................................................82

Keyboard..........................................................84

Miscellaneousparts..........................................86

ACadapters......................................................87

Screws..............................................................87

Powercords......................................................88

Notices......................................................... 91

Trademarks.................................................. 92

iv

About this manual

Thismanualcontainsserviceandreferenceinformationforthefollowing

Lenovoproduct:

Lenovo G50-30/G50-45/G50-70/G50-70m/Z50-70/Z50-75/G50-80

Usethismanualtotroubleshootproblems.

Themanualisdividedintothefollowingsections:

• Thecommonsectionsprovidegeneralinformation,guidelines,andsafety

informationrequiredforservicingcomputers.

• Theproduct-specicsectionincludesservice,reference,andproduct-specic

partsinformation.

Important:

This manual is intended only for trained servicers who are familiar with Lenovo

products. Use this manual to troubleshoot problems effectively.

Before servicing a Lenovo product, make sure to read all the information under

“Safety information” on page 1 and “Important service information” on page 16.

1

Safety information

Thischapterpresentsthefollowingsafetyinformationthatyouneedtoget

familiarwithbeforeyouserviceaLenovoG50-30/G50-45/G50-70/G50-70m/

Z50-70/Z50-75/G50-80computer:

• “Generalsafety”onpage2

• “Electricalsafety”onpage3

• “Safetyinspectionguide”onpage5

• “Handlingdevicesthataresensitivetoelectrostaticdischarge”onpage6

• “Groundingrequirements”onpage6

• “Safetynotices:multilingualtranslations”onpage7

• “Lasercompliancestatement”onpage14

2

G50-30/G50-45/G50-70/G50-70m/Z50-70/Z50-75/G50-80 Hardware Maintenance Manual

General safety

Followtheserulesbelowtoensuregeneralsafety:

• Observeagoodhousekeeping inthe areawherethemachinesareput

duringandafterthemaintenance.

• Whenliftinganyheavyobject:

1. Makesurethatyoucanstandsafelywithoutslipping.

2. Distributetheweightoftheobjectequallybetweenyourfeet.

3. Useaslowliftingforce.Nevermovesuddenlyortwistwhenyouattempt

toliftit.

4. Liftitbystandingorpushingupwithyourlegmuscles;thisactioncould

avoidthestrainfromthemusclesinyourback.Donotattempttoliftany

objectthatweighsmorethan16kg(35lb)orthatyouthinkistooheavy

foryou.

• Donotperformany actionthatcauseshazardstothecustomer,or that

makesthemachineunsafe.

• Beforeyou startthe machine,makesurethatotherservicerepresentatives

andthecustomerarenotinahazardousposition.

• Pleaseremovecoversand otherparts ina safeplace,awayfromall

personnel,whileyouareservicingthemachine.

• Keepyourtoolcaseawayfromwalkareassothatotherpeoplewillnot trip

overit.

• Donotwearlooseclothingthatcanbetrappedinthemovingparts ofthe

machine.Makesurethatyoursleevesarefastenedorrolledupaboveyour

elbows.Ifyourhairislong,fastenit.

• Inserttheendsofyournecktieorscarfinsideclothingor fastenit withthe

nonconductiveclip,about8centimeters(3inches)fromtheend.

• Donotwearjewelry,chains,metal-frameeyeglasses,ormetalfastenersfor

yourclothing.

Attention:

Metalobjectsaregoodelectricalconductors.

• Wearsafetyglasses whenyouarehammering,drilling,soldering,cutting

wire,attachingsprings,usingsolvents,orworkinginanyotherconditions

thatmaybehazardoustoyoureyes.

• Afterservice, reinstallall safetyshields,guards,labels,and groundwires.

Replaceanysafetydevicethatiswornordefective.

• Reinstallallcoverscorrectlybeforereturningthemachinetothecustomer.

• Fanlouversonthemachinehelp toprevent theoverheating ofinternal

components.Donotobstructfanlouvers orcover themwith labelsor

stickers.

3

Safety information

Electrical safety

Observethefollowingruleswhenworkingonelectricalequipments.

Important:

Use only approved tools and test equipments. Some hand tools have handles

covered with a soft material that does not insulate you when working with live

electrical currents.

Many customers have rubber floor mats near their machines that contain small

conductive bers to decrease electrostatic discharges. Do not use such kind of mat

to protect yourself from electrical shock.

• Findtheroomemergency power-off(EPO)switch,disconnectingswitchor

electricaloutlet.Ifanelectricalaccident occurs,you canthen operatethe

switchorunplugthepowercordquickly.

• Donotworkalone underhazardousconditionsornear theequipment that

hashazardousvoltages.

• Disconnectallpowerbefore:

– Performingamechanicalinspection

– Workingnearpowersupplies

– Removingorinstallingmainunits

• Beforeyoustarttoworkonthemachine,unplug thepower cord.Ifyou

cannotunplugit,askthecustomerto power-offthewall boxthatsupplies

powertothemachine,andtolockthewallboxintheoffposition.

• Ifyouneedtoworkonamachinethathasexposedelectricalcircuits,

observethefollowingprecautions:

– Ensurethatanotherperson,familiarwiththepower-offcontrols,isnear

you.



Attention:

Anotherperson mustbe theretoswitchoffthepower,if

necessary.

– Useonlyonehandwhenworkingwithpowered-onelectricalequipment;

keeptheotherhandinyourpocketorbehindyourback.



Attention:

Anelectricalshockcanoccuronlywhenthereisacomplete

circuit.Byobservingtheaboverule,you maypreventacurrentfrom

passingthroughyourbody.

– Whenusingtesters,setthecontrolscorrectlyandusetheapproved

probeleadsandaccessoriesforthattester.

– Standonsuitablerubbermats(obtainedlocally,ifnecessary)toinsulate

youfromgroundssuchasmetaloorstripsandmachineframes.

Observethespecialsafetyprecautionswhenyouworkwithveryhighvoltages;

instructionsfortheseprecautionsareinthesafetysectionsofmaintenance

information.Beextremelycarefulwhenyoumeasurethehighvoltages.

• Regularlyinspectandmaintainyourelectricalhandtoolsforsafeoperational

condition.

• Donotusewornorbrokentoolsandtesters.

• Neverassumethatpowerhasbeendisconnectedfromacircuit.First,check

ittomakesurethatithasbeenpoweredoff.

4

G50-30/G50-45/G50-70/G50-70m/Z50-70/Z50-75/G50-80 Hardware Maintenance Manual

• Alwayslookcarefullyforpossiblehazardsinyourworkarea.Examplesof

thesehazardsaremoistoors,nongroundedpowerextensioncables,power

surges,andmissingsafetygrounds.

• Donottouchliveelectricalcircuits withthe reflectivesurface ofaplastic

dentalmirror.Thesurfaceisconductive;suchtouchingcancausepersonal

injuryandmachinedamage.

• Donotservicethefollowingpartswiththepoweronwhentheyareremoved

fromtheirnormaloperatingplacesinamachine:

– Powersupplyunits

– Pumps

– Blowersandfans

– Motorgenerators

andsimilarunits.(Thispracticeensurescorrectgroundingoftheunits.)

• Ifanelectricalaccidentoccurs:

– Caution:donotbecomeavictimyourself.

– Switchoffthepower.

– Sendthevictimtogetmedicalaid.

5

Safety information

Safety inspection guide

Thepurpose ofthis inspectionguideistoassistyouinidentifyingpotential

unsafeconditions.Aseachmachine wasdesigned andbuilt, requiredsafety

itemswereinstalledtoprotectusersandservicepersonnelfrominjury.This

guideaddressesonlythoseitems.You shoulduse goodjudgment toidentify

potentialsafetyhazardsaccordingtotheattachmentofnon-Lenovofeaturesor

optionsnotcoveredbythisinspectionguide.

Ifanyunsafeconditionsarepresent,youmustdetermine howserious the

apparenthazardcouldbeandwhetheryoucancontinuewithoutrstcorrecting

theproblem.

Considertheseconditionsandthesafetyhazardstheypresent:

• Electricalhazards,especiallyprimarypower(primaryvoltageontheframe

cancauseseriousorfatalelectricalshock)

• Explosivehazards,suchasadamagedCRTfaceorabulgingcapacitor

• Mechanicalhazards,suchaslooseormissinghardware

Todeterminewhetherthereareanypotentialunsafeconditions, usethe

followingchecklistatthebeginningofeveryservicetask.Beginthecheckswith

thepoweroff,andthepowercorddisconnected.

Checklist:

1. Checkexteriorcoversfordamage(loose,broken,orsharpedges).

2. Turnoffthecomputer.Disconnectthepowercord.

3. Checkthepowercordfor:

a. Athird-wiregroundconnectoringoodcondition.Useametertomeasure

third-wiregroundcontinuityfor0.1ohmorlessbetweentheexternal

groundpinandtheframeground.

b. Thepowercordshouldbethetypespeciedinthepartslist.

c. Insulationmustnotbefrayedorworn.

4. Checkforcrackedorbulgingbatteries.

5. Removethecover.

6. Checkforanyobviousnon-Lenovoalterations.Usegoodjudgmentastothe

safetyofanynon-Lenovoalterations.

7. Checkinside theunit forany obviousunsafeconditions,suchasmetal

filings,contamination,waterorotherliquids,orsignsoffireorsmoke

damage.

8. Checkforworn,frayed,orpinchedcables.

9. Checkthat thepower-supply coverfasteners(screwsorrivets) havenot

beenremovedortamperedwith.

6

G50-30/G50-45/G50-70/G50-70m/Z50-70/Z50-75/G50-80 Hardware Maintenance Manual

Handling devices that are sensitive to electrostatic discharge

Anycomputerpartcontainingtransistorsorintegratedcircuits(ICs)shouldbe

consideredsensitivetoelectrostaticdischarge(ESD).ESDdamagecanoccur

whenthere isa differenceinchargebetween objects.Protect againstESD

damagebyequalizingthechargesothatthemachine,thepart,theworkmat,

andthepersonhandlingthepartareallatthesamecharge.

Notes:

1. Use product-specific ESD procedures when they exceed the requirements

noted here.

2. Make sure that the ESD protective devices you use have been certied (ISO

9000) as fully effective.

WhenhandlingESD-sensitiveparts:

• Keepthepartsinprotectivepackagesuntiltheyareinsertedintotheproduct.

• Avoidcontactwithotherpeople.

• Wearagroundedwriststrapagainstyourskintoeliminate staticonyour

body.

• Preventthepartfromtouchingyourclothing.Mostclothingisinsulativeand

retainsachargeevenwhenyouarewearingawriststrap.

• Usetheblacksideofagroundedworkmattoprovideastatic-freework

surface.ThematisespeciallyusefulwhenhandlingESD-sensitivedevices.

• Selectagroundingsystem,suchasthoselistedbelow,toprovideprotection

thatmeetsthespecicservicerequirement.

Note:

The use of a grounding system to guard against ESD damage is desirable but not

necessary.

– AttachtheESDgroundcliptoanyframeground,groundbraid,orgreen-

wireground.

– Whenworkingonadouble-insulatedorbattery-operatedsystem,usean

ESDcommongroundorreferencepoint.Youcanusecoaxorconnector-

outsideshellsonthesesystems.

– Usetheroundgroundprongoftheacplugonac-operatedcomputers.

Grounding requirements

Electricalgroundingofthecomputerisrequiredforoperatorsafetyandcorrect

systemfunction.Propergroundingoftheelectricaloutletcanbeveriedbya

certiedelectrician.

Page is loading ...

9

Safety information

Safety notice 3

DANGER

The battery pack contains small amounts of nickel. Do not disassemble it, throw

it into re or water, or short-circuit it. Dispose of the battery pack as required by

local ordinances or regulations. Use only the battery in the appropriate parts listing

when replacing the battery pack. Use of an incorrect battery can result in ignition

or explosion of the battery.

La batterie contient du nickel. Ne la démontez pas, ne l’exposez ni au feu ni à l’eau.

Ne la mettez pas en court-circuit. Pour la mettre au rebut, conformez-vous à la

réglementation en vigueur. Lorsque vous remplacez la batterie, veillez à n’utiliser

que les modèles cités dans la liste de pièces détachées adéquate. En effet, une

batterie inappropriée risque de prendre feu ou d’exploser.

Akkus enthalten geringe Mengen von Nickel. Sie dürfen nicht zerlegt,

wiederaufgeladen, kurzgeschlossen, oder Feuer oder Wasser ausgesetzt werden.

Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll beachten. Beim

Ersetzen der Batterie nur Batterien des Typs verwenden, der in der Ersatzteilliste

aufgeführt ist. Der Einsatz falscher Batterien kann zu Entzündung oder Explosion

führen.

La batteria contiene piccole quantità di nichel. Non smontarla, gettarla nel fuoco

o nell’acqua né cortocircuitarla. Smaltirla secondo la normativa in vigore (DPR

915/82, successive disposizioni e disposizioni locali). Quando si sostituisce la

batteria, utilizzare soltanto i tipi inseriti nell’appropriato Catalogo parti. L’impiego

di una batteria non adatta potrebbe determinare l’incendio o l’esplosione della

batteria stessa.

Las baterías contienen pequeñas cantidades de níquel. No las desmonte, ni

recargue, ni las eche al fuego o al agua ni las cortocircuite. Deséchelas tal como

dispone la normativa local. Utilice sólo baterías que se encuentren en la lista de

piezas al sustituir la batería. La utilización de una batería no apropiada puede

provocar la ignición o explosión de la misma.

Page is loading ...

13

Safety information

Safety notice 8

DANGER

Before removing any FRU, turn off the computer, unplug all power cords from

electrical outlets, remove the battery pack, and then disconnect any interconnecting

cables.

Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension,

débranchez tous les cordons d’alimentation des socles de prise de courant, retirez

la batterie et déconnectez tous les cordons d’interface.

Die Stromzufuhr muß abgeschaltet, alle Stromkabel aus der Steckdose gezogen,

der Akku entfernt und alle Verbindungskabel abgenommen sein, bevor eine FRU

entfernt wird.

Prima di rimuovere qualsiasi FRU, spegnere il sistema, scollegare dalle prese

elettriche tutti i cavi di alimentazione, rimuovere la batteria e poi scollegare i cavi

di interconnessione.

Antes de quitar una FRU, apague el sistema, desenchufe todos los cables de

las tomas de corriente eléctrica, quite la batería y, a continuación, desconecte

cualquier cable de conexión entre dispositivos.

14

G50-30/G50-45/G50-70/G50-70m/Z50-70/Z50-75/G50-80 Hardware Maintenance Manual

Laser compliance statement

SomemodelsofLenovocomputerareequippedfromthefactorywithan

opticalstorage devicesuchasaCD-ROMdriveor aDVD-ROM drive.Such

devicesarealsosoldseparatelyasoptions.Ifoneofthesedrivesisinstalled,

itiscertiedintheU.S.toconformto therequirementsoftheDepartmentof

HealthandHumanServices21CodeofFederalRegulations(DHHS21CFR)

SubchapterJforClass1laserproducts.Elsewhere,the driveis certifiedto

conformtotherequirements ofthe InternationalElectrotechnicalCommission

(IEC)825andCENELECEN60825forClass1laserproducts.

IfaCD-ROMdrive,aDVD-ROMdrive,oranotherlaserdeviceisinstalled,note

thefollowing:

CAUTION

Use of controls or adjustments or performance of procedures other than those

specied herein might result in hazardous radiation exposure.

O uso de controles, ajustes ou desempenho de procedimentos diferentes daqueles

aqui especicados pode resultar em perigosa exposição à radiação.

Pour éviter tout risque d’exposition au rayon laser, respectez les consignes de

réglage et d’utilisation des commandes, ainsi que les procédures décrites.

Werden Steuer- und Einstellelemente anders als hier festgesetzt verwendet, kann

gefährliche Laserstrahlung auftreten.

L’utilizzo di controlli, regolazioni o l’esecuzione di procedure diverse da quelle

specicate possono provocare l’esposizione a.

El uso de controles o ajustes o la ejecución de procedimientos distintos de los aquí

especicados puede provocar la exposición a radiaciones peligrosas.

OpeningtheCD-ROMdrive,theDVD-ROMdrive,oranyotheropticalstorage

devicecouldresultinexposuretohazardouslaser radiation.Thereareno

serviceablepartsinsidethosedrives.

Do not open

.

15

Safety information

ACD-ROMdrive,aDVD-ROMdrive,oranyotherstoragedeviceinstalledmay

containanembeddedClass3AorClass3Blaserdiode.Notethefollowing:

DANGER

Emits visible and invisible laser radiation when open. Do not stare into the beam,

do not view directly with optical instruments, and avoid direct exposure to the

beam.

Radiação por raio laser ao abrir. Não olhe fixo no feixe de luz, não olhe

diretamente por meio de instrumentos óticos e evite exposição direta com o feixe

de luz.

Rayonnement laser si carter ouvert. Évitez de fixer le faisceau, de le regarder

directement avec des instruments optiques, ou de vous exposer au rayon.

Laserstrahlung bei geöffnetem Gerät. Nicht direkt oder über optische Instrumente

in den Laserstrahl sehen und den Strahlungsbereich meiden.

Kinyitáskor lézersugár ! Ne nézzen bele se szabad szemmel, se optikai

eszközökkel. Kerülje a sugárnyalábbal való érintkezést!

Aprendo l’unità vengono emesse radiazioni laser. Non fissare il fascio, non

guardarlo direttamente con strumenti ottici e evitare l’esposizione diretta al fascio.

Radiación láser al abrir. No mire jamente ni examine con instrumental óptico el

haz de luz. Evite la exposición directa al haz.

16

G50-30/G50-45/G50-70/G50-70m/Z50-70/Z50-75/G50-80 Hardware Maintenance Manual

Important service information

Thischapterpresentsthefollowingimportantserviceinformation:

• “StrategyforreplacingFRUs”onpage16

– “Strategyforreplacingaharddiskdrive”onpage17

– “Importantnoticeforreplacingasystemboard”onpage17

• “ImportantinformationaboutreplacingRoHScompliantFRUs”onpage18

Important:

BIOS and device driver xes are customer-installable. The BIOS and device drivers

are posted on the customer support site:

http://support.lenovo.com.



Strategy for replacing FRUs

Before replacing parts:

Makesurethatall softwarexes, drivers,andBIOSdownloadsareinstalled

beforereplacinganyFRUslistedinthismanual.

Afterasystemboardisreplaced,ensurethatthelatestBIOSisloadedtothe

systemboardbeforecompletingtheserviceaction.

Todownloadsoftwarexes,drivers,andBIOS,followthestepsbelow:

1. Gotohttp://support.lenovo.com.

2. Enterthe serialnumber orselectaproductoruseLenovosmart

downloading.

3. SelecttheBIOS/Driver/Applicationsanddownload.

4. Followthedirectionsonthescreenandinstallthenecessarysoftware.

17

Important service information

Usethefollowingstrategytopreventunnecessaryexpenseforreplacingand

servicingFRUs:

• IfyouareinstructedtoreplaceanFRU,butthereplacementdoesnotsolve

theproblem,reinstalltheoriginalFRUbeforeyoucontinue.

• Somecomputers havebothaprocessorboardandasystem board.Ifyou

areinstructedtoreplaceeitherofthem,andreplacingoneofthemdoesnot

solvetheproblem,reinstallthatboard,andthenreplacetheotherone.

• IfanadapteroradeviceconsistsofmorethanoneFRU,anyoftheFRUs

maybethecauseofthe error.Beforereplacingtheadapter ordevice,

removetheFRUsonebyonetoseeifthesymptomschange.Replaceonly

theFRUthatchangedthesymptoms.

Attention:

Thesetupconfigurationonthecomputeryouareservicing may

havebeencustomized.RunningAutomaticConfiguration mayalter the

settings.Notethecurrentcongurationsettings(usingtheViewConguration

option);then,whenservice hasbeen completed,verifythatthosesettings

remainineffect.

Strategy for replacing a hard disk drive

Alwaystrytorun alow-level formatbeforereplacingaharddiskdrive.This

willcauseallcustomerdataontheharddisk tobe lost.Make surethatthe

customerhasacurrentbackupofthedatabeforeperformingthisaction.

Attention:

Thedrivestartupsequenceinthecomputeryouareservicingmay

havebeenchanged.Beextremelycareful duringwrite operationssuch as

copying,saving,orformatting.Ifyouselectanincorrectdrive,dataorprograms

canbeoverwritten.

Important notice for replacing a system board

Somecomponentsmountedon asystem boardare verysensitive. Improper

handlingcancausedamagetothosecomponents,andmaycauseasystem

malfunction.

Attention:

Whenhandlingasystemboard:

• Donotdropthesystemboardorapplyanyexcessiveforcetoit.

• Avoidroughhandlingofanykind.

• Avoidbendingthe systemboardandhardpushingtopreventcrackingat

eachBGA(BallGridArray)chipset.

18

G50-30/G50-45/G50-70/G50-70m/Z50-70/Z50-75/G50-80 Hardware Maintenance Manual

Important information about replacing RoHS compliant FRUs

RoHS, The Restriction of Hazardous Substances in Electrical and

Electronic Equipment Directive (2002/95/EC) is a European Union legal

requirement affecting the global electronics industry. RoHS requirements

must be implemented on Lenovo products placed on the market after

June 2006. Products on the market before June 2006 are not required to

have RoHS compliant parts. If the original FRU parts are non-compliant,

replacement parts can also be non-compliant. In all cases if the original

FRU parts are RoHS compliant, the replacement part must also be RoHS

compliant.

Note:

RoHSandnon-RoHSFRUpartnumberswiththesametandfunction

areidentiedwithuniqueFRUpartnumbers.

Lenovoplans totransit toRoHScompliancewellbefore theimplementation

dateandexpectsits supplierstobereadytosupportLenovo’srequirements

andscheduleintheEU.Productssoldin2005and2006will containsome

RoHScompliantFRUs.Thefollowingstatementpertainstotheseproductsand

anyproductLenovoproducescontainingRoHScompliantFRUs.

RoHScompliant FRUshaveuniqueFRUpartnumbers.Before orafterthe

RoHSimplementationdate,failedRoHScompliantpartsmustalwaysbe

replacedwithRoHScompliantones,soonlytheFRUsidentiedascompliant

inthesystemHMMordirectsubstitutionsforthoseFRUsmaybeused.

Products marketed before June 2006 Products marketed after June 2006

Current or

original part

Replacement FRU Current or

original part

Replacement FRU

Non-RoHS CanbeNon-RoHS

MustbeRoHS MustbeRoHS

Non-RoHS CanbeRoHS

Non-RoHS CansubtoRoHS

RoHS MustbeRoHS

Note:

AdirectsubstitutionisapartwithadifferentFRUpartnumberthatis

automaticallyshippedbythedistributioncenteratthetimeoftheorder.

19

General checkout

Thischapterpresentsthefollowinginformation:

• “Whattodorst”onpage20

• “Powersystemcheckout”onpage21

Beforeyougotothecheckout,makesuretoreadthefollowingimportantnotes:

Important notes:

• Onlycertiedtrainedpersonnelcanservicethecomputer.

• BeforereplacinganyFRU, readthe entirepageonremovingandreplacing

FRUs.

• CarefullyremovescrewsforreusewhenreplacingFRUs.

• Beextremelycarefulduringsuchwrite operationsascopying,saving,or

formatting. Drives in the computer that you are servicing sequence might

have been altered. If you select an incorrect drive, data or programs might be

overwritten.

• ReplaceanFRUonlywith anotherFRUofthecorrectmodel. When you

replace an FRU, make sure that the machine model and the FRU part number are

correct by referring to the FRU parts list.

• AnFRUshouldnotbereplacedjustbecauseofasingle,unreproduciblefailure.

Single failures can occur for a variety of reasons that have nothing to do with a

hardware defect, such as cosmic radiation, electrostatic discharge, or software

errors. Consider replacing an FRU only when a problem recurs. If you suspect that

an FRU is defective, clear the error logs and run the test again. If the error does

not recur, do not replace the FRU.

• BecarefulnottoreplaceanondefectiveFRU.

20

G50-30/G50-45/G50-70/G50-70m/Z50-70/Z50-75/G50-80 Hardware Maintenance Manual

What to do rst

WhenyoudoreturnanFRU,youmustincludethefollowinginformationinthe

partsexchangeformorpartsreturnformthatyouattachtoit:

1. Nameandphonenumberofservicer

2. Dateofservice

3. Dateonwhichthemachinefailed

4. Dateofpurchase

5. ProcedureindexandpagenumberinwhichthefailingFRUwasdetected

6. FailingFRUnameandpartnumber

7. Machinetype,modelnumber,andserialnumber

8. Customer’snameandaddress

Note for warranty:

During thewarranty period,thecustomermaybe

responsiblefor repaircosts ifthe computerdamagewascausedbymisuse,

accident,modification,unsuitablephysicaloroperatingenvironment,or

impropermaintenancebythecustomer.

Thefollowingisa listof somecommon itemsthatarenotcoveredunder

warrantyandsomesymptoms thatmight indicatethat thesystemwas

subjectedtostressbeyondnormaluse.

Beforecheckingproblemswiththecomputer,determinewhetherthedamageis

coveredunderthewarrantybyreferringtothefollowinglist:

The following are not covered under warranty:

• LCDpanelcrackedfromtheapplicationofexcessive forceor frombeing

dropped

• Scratched(cosmetic)parts

• Distortion,deformation,ordiscolorationofthecosmeticparts

• Plasticparts,latches,pins,orconnectorsthathavebeencrackedorbroken

byexcessiveforce

• Damagecausedbyliquidspilledintothesystem

• DamagecausedbytheimproperinsertionofaPCCardortheinstallationof

anincompatiblecard

• Improperdiskinsertionoruseofanopticaldrive

• Diskettedrivedamagecausedbypressure onthe diskettedrive cover,

foreignmaterialinthedrive,ortheinsertionofadiskettewithmultiplelabels

• Damagedorbentdisketteejectbutton

• Fusesblownbyattachmentofanonsupporteddevice

• Forgottencomputerpassword(makingthecomputerunusable)

• Stickykeyscausedbyspillingaliquidontothekeyboard

• UseofanincorrectACadapteronlaptopproducts

The following symptoms might indicate damage caused by nonwarranted

activities:

• Missingpartsmightbeasymptomofunauthorizedserviceormodication.

• Ifthespindleofaharddiskdrivebecomesnoisy,itmayhavebeensubjected

toexcessiveforce,ordropped.

21

General checkout

Power system checkout

Toverifyasymptom,followthestepsbelow:

1. Turnoffthecomputer.

2. Removethebatterypack.

3. ConnecttheACadapter.

4. Makesurethatpowerissuppliedwhenyouturnonthecomputer.

5. Turnoffthecomputer.

6. DisconnecttheACadapterandinstallthechargedbatterypack.

7. Make surethat thebattery packsupplies powerwhen youturnonthe

computer.

Ifyoususpectapowerproblem,seetheappropriateoneofthefollowingpower

supplycheckouts:

• “CheckingtheACadapter”onpage21

• “Checkingoperationalcharging”onpage21

• “Checkingthebatterypack”onpage22

Checking the AC adapter

YouareherebecausethecomputerfailsonlywhentheACadapterisused.

• Ifthepower-onindicatordoesnotturnon,checkthepowercordoftheAC

adapterforcorrectcontinuityandinstallation.

• Ifthecomputerdoes notcharge duringoperation,goto“Checking

operationalcharging”.

TochecktheACadapter,followthestepsbelow:

1. UnplugtheACadaptercablefromthecomputer.

2. Measuretheoutputvoltage atthe plugoftheACadaptercable.Seethe

followinggure:

1

2

9ROWDJH9'&





3LQ





Note:

OutputvoltagefortheACadapterpinNo.2maydifferfromtheoneyou

areservicing.

3. Ifthevoltageisnotcorrect,replacetheACadapter.

4. Ifthevoltageisacceptable,dothefollowing:

• Replacethesystemboard.

• Iftheproblempersists,goto“LenovoG50-30/G50-45/G50-70/G50-70m/

Z50-70/Z50-75/G50-80”onpage26.

Note:

NoisefromtheACadapterdoesnotalwaysindicateadefect.

Checking operational charging

Tocheckwhetherthebatterychargesproperly duringoperation,usea

dischargedbatterypackorabatterypackthathaslessthan50%ofthetotal

powerremainingwheninstalledinthecomputer.

Page is loading ...

Lenovo G50-70 Specification

This manual is also suitable for

Lenovo G50-70 Specification

Related papers

Other documents