GE ZISP480DXSS Installation guide

Brand: GE

Model: ZISP480DXSS

Category: Fridges

Type: Installation guide

Side by Side Refrigerators

Design Guide

With Installation Instructions

Installation

Instructions

01-13 GE

monogram.com

31-46514-1

224D1889P014

Safety Information

Skill Level – Installation of this refrigerator requires

basic mechanical, carpentry and plumbing skills.

Proper installation is the responsibility of the installer.

Product failure due to improper installation is not

covered under the GE Appliance Warranty.

See the Owner’s Manual for warranty information.

WARNING:

7KHVHUHIULJHUDWRUVDUHWRSKHDY\DQGPXVWEH

secured to prevent the possibility of tipping forward.

$QWL7LSSURWHFWLRQLVUHTXLUHG6HHSDJHIRU

details.

8VHWKLVDSSOLDQFHRQO\IRULWVLQWHQGHGSXUSRVH

,PPHGLDWHO\UHSDLURUUHSODFHHOHFWULFVHUYLFHFRUGV

that become frayed or damaged.

8QSOXJWKHUHIULJHUDWRUEHIRUHFOHDQLQJRUPDNLQJ

repairs.

5HSDLUVVKRXOGEHPDGHE\DTXDOLILHGVHUYLFH

technician.

AVERTISSEMENT

&HVUpIULJpUDWHXUVVRQWORXUGVHQKDXWHWLOIDXWOHV

DUULPHUSRXUpYLWHUOHXUEDVFXOHPHQW,OIDXWDYRLU

un système de protection contre le renversement.

9RLUOHVGpWDLOVSDJH

,OQHIDXWXWLOLVHUFHWDSSDUHLOTXHSRXUO·XWLOLVDWLRQ

DSSURSULpH

5pSDUHURXUHPSODFHULPPpGLDWHPHQWWRXWFRUGRQ

pOHFWULTXHHIILORFKpRXHQGRPPDJp

,OIDXWGpEUDQFKHUOHUpIULJpUDWHXUDYDQWOHQHWWR\DJH

ou toute intervention.

/HVUpSDUDWLRQVGRLYHQWrWUHIDLWHVSDUXQWHFKQLFLHQ

TXDOLILp

For Monogram local service in your area,

call 1.800.444.1845.

For Monogram service in Canada,

call 1.800.561.3344

For Monogram Parts and Accessories,

call 1.800.626.2002.

www.monogram.com

BEFORE YOU BEGIN

5HDGWKHVHLQVWUXFWLRQVFRPSOHWHO\DQGFDUHIXOO\

IMPORTANT – Save these instructions for

local inspector’s use. Observe all governing codes and

ordinances.

Note to Installer – Be sure to leave these

LQVWUXFWLRQVZLWKWKH&RQVXPHU

Note to Consumer – Keep these instructions with

your Owner’s Manual for future reference.

WARNING:

7KLVDSSOLDQFHPXVWEHSURSHUO\JURXQGHG6HH

´*URXQGLQJWKH5HIULJHUDWRUµSDJH

AVERTISSEMENT

&HWDSSDUHLOGRLWrWUHFRUUHFWHPHQWPLVjODWHUUH

&RQVXOWH]© 0LVHjODWHUUHGXUpIULJpUDWHXU ªSDJH

If you received a damaged refrigerator, you should

immediately contact your dealer or builder.

CAUTION:

'XHWRWKHZHLJKWDQGVL]HRIWKLVUHIULJHUDWRU

and to reduce the risk of personal injury or damage

WRWKHSURGXFW²7+5((3(23/($5(5(48,5('

)253523(5,167$//$7,212)$µ:,'(81,7

)2853(23/($5(5(48,5(')25,167$//$7,21

2)$µ25µ:,'(02'(/

PRUDENCE

FDXVHGXSRLGVHWGHODWDLOOHGHFHUpIULJpUDWRU

HWSRXUUpGXLUHOHULVTXHGHEOHVVXUHHWGHGRPPDJHV

,/)$87752,63(56211(63285,167$//(5

&255(&7(0(17'·81$33$5(,/'(FPSR

'(/$5*(,/)$8748$75(3(56211(63285

/·,167$//$7,21'·8102'Ê/('(28FP

28SR'(/$5*(

CONTENTS

Planning Guide

7KH,QVWDOODWLRQ6SDFH .......................................3

'LPHQVLRQVDQG&OHDUDQFHV ..........................3

130° Door Swing ..................................................4

90° Door Swing .....................................................5

&XVWRPL]DWLRQ%DVLFV ........................................ 6

µ)UDPHG3DQHO'LPHQVLRQV ....................

µ2YHUOD\3DQHO'LPHQVLRQV .................... 8

5DLVHG2YHUOD\3DQHO'HVLJQ ......................... 9

Side Panels ..........................................................10

Installation Instructions

7RROV+DUGZDUH0DWHULDOV .........................10

*URXQGLQJWKH5HIULJHUDWRU ........................10

6WHS5HPRYH3DFNDJLQJ .........................11

6WHS0RYH5HIULJHUDWRULQWR+RXVH ...11

6WHS,QVWDOO:DWHU/LQH......................11-12

6WHS+RXVHKROG:DWHU)LOWUDWLRQ ........ 12

Step 5, Install Side Panels ...........................12

6WHS,QVWDOO$QWL7LS%UDFNHWV................12

6WHS/HYHO5HIULJHUDWRU ............................13

6WHS$OWHUQDWH$QWL7LS3URFHGXUH ..... 13

Step 9, 6HFXUH5HIULJHUDWRUWR&DELQHWU\ .14

Step 10, Adjust Door Swing ........................14

Step 11, Install Grille Panel .........................14

Step 12, Install Framed Panels .................15

Step 12A, Install Overlay Panels ........²

6WHS,QVWDOO'LVSHQVHU7ULP...................18

6WHS&RQQHFW:DWHU6XSSO\ ...............18

6WHS&RQQHFW3RZHU ..............................19

Step 16, Start Icemaker ................................19

6WHS,QVWDOO7RHNLFN .................................19

ZKHSS2 Tubular Handle Kit

6WHS5HPRYH'RRU+DQGOHV ..................20

6WHS,QVWDOO+DQGOHVRQWR3DQHOV ........21

6WHS,QVWDOO$VVHPEOHG+DQGOHV ..........22

6WHS,QVWDOO'LVSHQVHU7ULP ....................22

Design Guide

THE INSTALLATION SPACE

Water And Electrical Locations

7KHRSHQLQJPXVWEHSUHSDUHGZLWKWKHHOHFWULFDO

and the cold water supply located as shown.

The cutout depth must be 24”

7KHUHIULJHUDWRUZLOOSURMHFWIRUZDUGVOLJKWO\EH\RQG

adjacent cabinetry, depending on your installation.

Cutout depth beneath a soffit:

When installed beneath a soffit, the soffit cannot

H[FHHGWKHµLQVWDOODWLRQGHSWKVKRZQ7KHWRSFDVH

trim overlaps the bottom of the soffit.

Additional Specifications

$YROW+]RUDPSSRZHUVXSSO\LV

required. An individual properly grounded branch

circuit or circuit breaker is recommended. Install

a properly grounded 3-prong electrical receptacle

recessed into the back wall. Electrical must be

located on the rear wall as shown.

NOTE:*),JURXQGIDXOWLQWHUUXSWHULVQRW

recommended.

7KHZDWHUOLQHFDQHQWHUWKHRSHQLQJWKURXJK

WKHIORRURUEDFNZDOO7KHZDWHUOLQHVKRXOGEHµ

2'FRSSHUWXELQJRU*(6PDUW&RQQHFW

™

kit between

the cold water line and water connection location,

long enough to extend to the front of the refrigerator.

Installation of an easily accessible shut-off valve

in the water line is required.

DIMENSIONS AND CLEARANCES

* Shipping height.

The refrigerator can

be adjusted to fit

into a cutout that

is 83-1/2” min. to

84-1/2” max. height.

Note that the top

case trim at the

front is 1/2” higher

and will overlap

upper cabinetry or

soffit. Use leveling

legs and wheels

for a maximum 1”

height adjustment.

Product Clearances

7KHVHUHIULJHUDWRUVDUHHTXLSSHGZLWKDSRVLWLRQGRRU

VWRS7KHIDFWRU\VHWGRRUVZLQJFDQEHDGMXVWHG

to 90° if clearance to adjacent cabinets or walls

is restricted.

*The finished cutout width must be:

35-1/2” for 36” models

41-1/2” for 42” models

47-1/2” for 48” models

90° Door Swing130° Door Swing

*Finished Width

Electrical

Area

84 1/2" max

83 1/2" min

Finished

Opening

75" From Flo

to Bottom

of Electrica

Area

24"

3 1/2"

Water Supply

3 1/2"

36" Models 1

42" Models 1

48" Models 2

$OORZPLQLPXPFOHDUDQFHVIRUWKHIUHH]HUGRRU

'LPHQVLRQ$DQGIUHVKIRRGGRRU'LPHQVLRQ%

for a full 130° door swing and to allow for pan removal.

)RUDGRRUVZLQJDOORZµPLQFOHDUDQFHWRDZDOO

IRUIUDPHGDQGVWDLQOHVVVWHHOPRGHOV$OORZµPLQ

clearance for professional series models. If the 90° door

stop position is used, pan access is maintained, but pan

removal is restricted.

See the illustrations on pages 4 and 5 to determine door

swing interaction with adjacent cabinets or countertops.

Models A B C

36” 13” 15” 20-5/8”

42” 13” 19” 26-5/8”

48” 15” 20” 28-5/8”

*84" From

Floor to

Top Frame

25-3/8" Framed Models

25-3/4" Stainless Steel Models

Depth Including Handles:

26-7/8" Framed Models

27-3/4" Stainless Steel Models

28-11/16" Professional Models

36", 42" or 48"

Frame to Frame

35", 41", or 47"

Case Width

*83-1/2"

Rear

23-7/8"

Behind

Frame

90 Door Swing

*Min. Distance

to Wall

*4” Stainless and

Trimmed Models.

5” Pro Series

1/4"

1/2"

3/4"

1-1/4"

3/4" Overlay

Panel

(Nominal Size)

Stainless Steel

1/4"

1/2"

3/4"

1-1/4"

1-1/2"

1-3/4"

2-1/4"

2-1/2"

2-3/4"

1/4"

1/2"

3/4"

Door

23-7/8" From

Rear of

Refrigerator

Case

Trim

Design Guide

Top View

130° DOOR SWING

(factory setting)

Scale 1:1

IMPORTANT NOTE –

FOR DISPENSER MODELS:

Dispenser models are supplied with two

dispenser trims, one to fit framed panels

and one for overlay panels. Dispenser trim

fit to the custom panel depends on correct

panel thickness. Framed panels must be

µQRPLQDO2YHUOD\SDQHOVVKRXOGEH

constructed as shown to accomplish a total

µWKLFNQHVV6HHSDJHVDQGIRUGHWDLOV

Frameless Cabinets: 7KHFDVHWULPRYHUODSV

FDELQHWVDWWKHWRSDQGVLGHV7KHUHIRUH

frameless cabinets may require filler strips

to prevent interfeence with cabinet door

VZLQJ7KHRSHQLQJPXVWDOORZIRUILOOHUVWULSV

1/4"

1/2"

3/4"

1-1/4"

1/4"

1/2"

3/4"

1-1/4"

1-1/2"

23-7/8"

From Rear of

Refrigerator

3/4" Overlay

Panel

(Nominal Size)

Case Trim

Refrigerator

Door

Stainless Steel

Top View

90° DOOR SWING

(optional setting)

Scale 1:1

IMPORTANT NOTE –

FOR DISPENSER MODELS:

Dispenser models are supplied

with two dispenser trims, one to fit

framed panels and one for overlay

panels. Dispenser trim fit to the

custom panel depends on correct

panel thickness. Framed panels

PXVWEHµQRPLQDO2YHUOD\

panels should be constructed as

VKRZQWRDFFRPSOLVKDWRWDOµ

WKLFNQHVV6HHSDJHVDQGIRU

details.

Frameless Cabinets:

7KHFDVHWULPRYHUODSV

cabinets at the top

DQGVLGHV7KHUHIRUH

frameless cabinets may

require filler strips to

prevent interference

with cabinet door swing.

7KHRSHQLQJPXVWDOORZ

for filler strips.

Design Guide

Standard Door Handles

3/4" Overlay Panel

.10" Thick Spacer Panel

1/4" Thick Backer Panel

CUSTOMIZATION BASICS:

Framed Or Overlay Panels, Custom Handles and Accessory Kits

Overlay panels

You may also choose to install custom overlay panels from

\RXUFDELQHWPDQXIDFWXUHU7KLVGHVLJQSURYLGHV

a seamless appearance which integrates smoothly with

surrounding cabinetry.

Standard supplied handles shown in 3/4” overlay panel position.

Professional Style Stainless Steel Refrigerators

Stainless steel wrapped refrigerators have beveled edges

DQGSURIHVVLRQDOVW\OHKDQGOHV7KHVHPRGHOVDUHVKLSSHG

ready for installation.

Stainless Steel Wrapped Refrigerators

Stainless Steel wrapped refrigerators have wrapped doors

and grille panel, beveled edges, and tubular stainless steel

handles that coordinate with other Monogram appliances.

7KHVHPRGHOVDUHVKLSSHGUHDG\IRULQVWDOODWLRQ

Trimmed Refrigerators

7ULPPHGUHIULJHUDWRUVDUHGHVLJQHGWREHFXVWRPL]HG

with decorative panels. Field installed custom door

and grille panels are required.

Framed panels

<RXPD\LQVWDOOµWKLFNFXVWRPSDQHOVIURP

\RXUFDELQHWPDQXIDFWXUHU7KHGHFRUDWLYHSDQHOVOLGHV

into the factory installed trim. Order black or stainless steel

accessory panels from your Monogram dealer.

Standard supplied handles shown in 1/4” panel position.

Door Handles

7KHVWDQGDUGVXSSOLHGKDQGOHVFDQEHDGMXVWHGWR

DFFRPPRGDWHERWKIUDPHGRURYHUOD\SDQHOV&XVWRP

handles of your choice, supplied by your cabinet maker

FDQDOVREHLQVWDOOHGRQµRYHUOD\SDQHOV,IGHVLUHG

\RXPD\RUGHU=.+660RQRJUDPVWDLQOHVVVWHHO

WXEXODUKDQGOHNLWIRUµRYHUOD\SDQHOV

Side Panels

Side panels must be used whenever the sides

of the refrigerator will be exposed.

Optional Accessory Kits

=.+660RQRJUDP7XEXODU6WDLQOHVV6WHHOKDQGOHV

GHVLJQHGWRILWµRYHUOD\SDQHOV

Accessory Panels

Black and stainless steel accessory panels are available

IURP\RXU0RQRJUDPGHDOHU3DQHOVDUHFXWWRVL]HDQG

ready to install.

Black Stainless

Models Acrylic Steel

ZISW480D ZPS480D

ZISB480D ZPB480D ZPS480D

=,61 =3%1 =361

ZISW420D ZPS420D

ZISB420D ZPB420D ZPS420D

=,61 =3%1 =361

ZISW360D ZPS360D

ZISB360D ZPB360D ZPS360D

=,61 =3%1 =361

Framed Panel

Standard Door Handles

Design Guide

1/4” FRAMED PANEL DIMENSIONS



If you choose to install framed panels, they must

EHFXWWRWKHGLPHQVLRQVVKRZQ7KHSDQHOVZLOOVOLGH

into the frame on the door and grille.

Non-Dispenser Models

,IWKHFXVWRPSDQHOLVOHVVWKDQµWKLFNDQGLWILWV

loosely in the door frame it can be backed up with

a piece of filler material or foam tape to improve

the fit.

Fresh

Food

Panel

Freezer

Panel

Grille Panel

Dispen-ser

Cutout

9-5/8"

Dispenser Cutout

15-3/8

6LGHE\6LGHLQLQFKHV

  $ % & ' ( ) *

µ0RGHOV        

µ0RGHOV        

µ0RGHOV        

Dispenser

&XWRXW3RVLWLRQ

IMPORTANT NOTE: Maximum total panel weight:

Fresh food door panel – 75 lbs.

Freezer door panel – 53 lbs.

Grille Panel – 18 lbs.

1/4"

Panel

Door

5/16"

Trim

Reveal

The framed panel must be 1/4” nominal

thickness to fit the dispenser trim.

IMPORTANT NOTE – DISPENSER MODELS

7KHUHIULJHUDWRULVVXSSOLHGZLWKWZRGLVSHQVHUWULPV

one for framed panels and one for overlay panels.

,IWKHSDQHOLVOHVVWKDQµWKLFNDQRWLFHDEOHJDS

may be created around the dispenser trim. Foam

tape may be applied on the door to improve the fit.

,IWKHSDQHOLVPRUHWKDQµWKLFNWKHGLVSHQVHU

trim cannot be secured to the door.

See Dispenser Trim Fit Example, page 9.

Design Guide

3/4” OVERLAY PANEL DIMENSIONS

For a more custom appearance, overlay panels may

EHLQVWDOOHGRQWULPPHGPRGHOV7KHRYHUOD\SDQHOPXVW

EHVHFXUHGWRDµWKLFNEDFNHUSDQHOZKLFKVOLGHV

LQWRWKHWULP$VSDFHUSDQHOµWKLFNPXVWEHSODFHG

between the overlay and backer panel.

Assemble the panels with glue and screws:

&HQWHUWKHVSDFHUSDQHORQWKHEDFNHUSDQHOOHIWWR

right and top to bottom. Secure the panels with glue.

&HQWHUWKHVSDFHUDQGEDFNHUSDQHORQWKHRYHUOD\

panel and secure with glue and screws. Screws must

be countersunk into the backer panel.

NOTE: Left-to-right offset is

not always equal to top-to-

bottom offset.

Spacer Panel

Overlay Panel

Backer Panel

Fresh

Food

Panel

Freezer

Panel

Grille Panel

Dispen-ser

Cutout

9-5/8"

Dispenser Cutout

15-3/8

&XWWKHGLVSHQVHURSHQLQJDIWHUWKHEDFNHUVSDFHUDQGRYHUOD\

panels have been assembled.

µ6LGHE\6LGHLQLQFKHV

  $ % & ' ( ) *

µ%DFNHU3DQHO       

µ6SDFHU3DQHO       

µ2YHUOD\3DQHO       

µ6LGHE\6LGHLQLQFKHV

  $ % & ' ( ) *

µ%DFNHU3DQHO       

µ6SDFHU3DQHO       

µ2YHUOD\3DQHO       

µ6LGHE\6LGHLQLQFKHV

  $ % & ' ( ) *

µ%DFNHU3DQHO      

µ6SDFHU3DQHO      

µ2YHUOD\3DQHO       

*Dispenser

&XWRXW3RVLWLRQ

IMPORTANT NOTE: Maximum total weight for the assembled

SDQHOV

)UHVKIRRGGRRUSDQHO²OEV

)UHH]HUGRRUSDQHO²OEV

Grille Panel – 18 lbs.

IMPORTANT NOTE – DISPENSER MODELS

7KHUHIULJHUDWRULVVXSSOLHGZLWKWZRGLVSHQVHUWULPV

RQHIRUIUDPHGSDQHOVDQGRQHIRURYHUOD\SDQHOV7KH

overlay dispenser trim is designed to fit a total panel

WKLFNQHVVRIµ

,IWKHSDQHOLVOHVVWKDQµDQRWLFHDEOHJDSPD\

be created around the dispenser trim.

,IWKHSDQHOLVPRUHWKDQµWKHGLVSHQVHUWULP

cannot be secured to the door.

See Dispenser Trim Fit Example, page 9.

.250” + .10” + .750” = 1.100” Total Panel Thickness

7KHRYHUOD\SDQHOPXVWEHFRQVWUXFWHGDFFRUGLQJWR

the specifications shown to achieve the correct total

thickness.

$OWHUQDWLYHSDQHOFRQVWUXFWLRQPHWKRGVVXFKDV

VHFXULQJDµSDQHOWRDµEDFNHUSDQHOFDQQRW

EHXVHG$QRWKHUPHWKRGURXWLQJDµWKLFNSDQHO

RQDOOVLGHVFDQQRWEHXVHG7KHVHPHWKRGVZLOOQRW

UHVXOWLQWKHUHTXLUHGµSDQHOWKLFNQHVV

When a raised panel design is to be used, a custom

middle rail is required. See page 9 for details.

3/4"

Overlay

Panel

1/4"

Backer

Panel

Door

.10"

Spacer

Design Guide

DISPENSER MODELS:

RAISED OVERLAY PANEL DESIGN

When a raised panel design is to be used,

a custom wide middle rail is required to accept

the dispenser trim.

7KHPLGGOHUDLOPXVWEHZLGHHQRXJKWRDOORZ

for the dispenser trim to overlap the opening.

7KHPLGGOHUDLOPXVWEHµWRWDOWKLFNQHVV

to accept the dispenser trim.

DISPENSER TRIM FIT EXAMPLES:

(NOT TO SCALE)

1/4” FRAMED PANEL

7KHGLVSHQVHUWULPILWVRYHUWKHFXVWRP

SDQHODQGVQDSVLQWRWKHIUHH]HUGRRU

7KHFOLSVZLOOQRWHQJDJHWKHGRRU

LIWKHSDQHOLVPRUHWKDQµWKLFN

,IWKHSDQHOLVOHVVWKDQµWKLFN

a noticeable gap may be created

around the dispenser trim.

3/4” OVERLAY PANEL

7KHGLVSHQVHUWULPILWVRYHUWKHFXVWRP

SDQHODQGVQDSVLQWRWKHIUHH]HUGRRU

7KHFOLSVZLOOQRWHQJDJHWKHGRRU

LIWKHSDQHOLVPRUHWKDQµWKLFN

,IWKHSDQHOLVOHVVWKDQµWKLFN

a noticeable gap may be created

around the dispenser trim.

4" Backer Panel

.10" Spacer

3/4" Overlay Panel

Wide

Middle

Rail is

Required

Dispenser

Trim

16-3/4"

10-5/8"

Design Guide

GROUNDING THE REFRIGERATOR

IMPORTANT – (Please read carefully)

)253(5621$/6$)(7<7+,6$33/,$1&(0867

%(3523(5/<*5281'('

7KHSRZHUFRUGRIWKLVDSSOLDQFHLVHTXLSSHG

ZLWKDSURQJJURXQGLQJSOXJZKLFKPDWHV

ZLWKDVWDQGDUGSURQJJURXQGLQJZDOOUHFHSWDFOH

WRPLQLPL]HWKHSRVVLELOLW\RIHOHFWULFVKRFNKD]DUG

from this appliance.

+DYHWKHZDOORXWOHWDQGFLUFXLWFKHFNHGE\

a qualified electrician to make sure the outlet

is properly grounded.

Where a standard 2-prong wall outlet is encountered,

it is your personal responsibility and obligation

to have it replaced with a properly grounded

3-prong wall outlet.

'212781'(5

$1<&,5&8067$1&(6

&87255(029(

7+(7+,5'*5281'3521*

)5207+(32:(5&25'

'212786($1$'$37(53/8*72&211(&7

7+(5()5,*(5$72572$3521*287/(7

'212786($1(;7(16,21&25':,7+7+,6

$33/,$1&(

SIDE PANELS

Side panels must be used

whenever the sides of the

refrigerator will be exposed.

7KHµVLGHSDQHOVZLOO

slip into the side case trim.

Secure the panels to the

refrigerator with stick-on

hook and loop fastener

strips. Order the side

panels from the cabinet

manufacturer.

&XWDQRWFKLQWKHWRS

front corner as shown

to allow clearance for

corner keys in the front

side trim.

* Depending on installation height.

TOOLS AND MATERIALS REQUIRED

7LQVQLSVWRFXWEDQGLQJ

6WHSODGGHU

µ%LWH[WHQLRQ

7DSHPHDVXUH

*ORYHV

µ'U\ZDOOVFUHZV

*DO%XFNHWZLWKFRYHU

µ6SLULWOHYHO

$SSOLDQFHKDQGWUXFN

7XELQJFXWWHU

µRSHQHQGZUHQFK

3KLOOLSVVFUHZGULYHU

'ULOODQGDSSURSULDWHELWV

µµVRFNHW

6DIHW\JODVVHV

µRSHQHQGZUHQFK

3OLHUV

µµ&RPER5DFKHW

µORQJ[IRU$QWL7LSVXSSRUW

µFRSSHUZDWHUOLQHWXELQJRU*(6PDUW&RQQHFW

™

5HIULJHUDWRU7XELQJNLWV

:DWHUVKXWRIIYDOYH

&XVWRPSDQHOVIRUGRRUVDQGJULOOHSDQHO

6FUHZVWRVHFXUHUHIULJHUDWRUWRFDELQHWU\

6WLFNRQKRRNDQGORRSIDVWHQHUVWULSVIRU

µVLGHSDQHOV

FLOORING

For proper installation, this refrigerator must be placed

on a level surface of hard material that is at the same

KHLJKWDVWKHUHVWRIWKHIORRULQJ7KLVVXUIDFHVKRXOG

be strong enough to support a fully loaded refrigerator,

or approximately 1,500 lbs.

NOTE: 3URWHFWWKHILQLVKRIWKHIORRULQJ&XWDODUJH

section of the cardboard carton and place under

the refrigerator where you are working.

*84"

2-9/16"

24"

*3" to 4"

3/16"

1-7/8"

Design Guide

HARDWARE SUPPLIED

:DWHUILOWHUE\SDVVSOXJ

$QWL7LSEUDFNHWV

µQXWDQGIHUUXOH

'LVSHQVHUWULPVIRUµDQGµRYHUOD\SDQHOV

IRUXVHZLWK&XVWRP3DQHOPRGHOV

$OXPLQXPFRYHUWULPIRUµRYHUOD\SDQHOV

with custom handles. Includes 22 flat head screws

and 4 endcaps.

Installation Instructions

STEP 1 REMOVE PACKAGING

CAUTION 7KHUHIULJHUDWRULVPXFKKHDYLHUDW

WKHWRSWKDQDWWKHERWWRP³EHFDUHIXOZKHQPRYLQJ

When using a hand truck, handle from the side only.

PRUDENCE /HUpIULJpUDWHXUHVWEHDXFRXS

SOXVORXUGHQKDXWTX·HQEDV,OIDXWrWUHSUXGHQWORUV

GHVGpSODFHPHQWV6LXQGLDEOHHVWXWLOLVpLOIDXWVRXOHYHU

OHUpIULJpUDWHXUVXUOHF{WpVHXOHPHQW

&DUHIXOO\FXWEDQGLQJDWWKHWRSDQGERWWRP

remove the outer carton.

6OLGHRXWWKHEDFNFRUQHUSRVWV

6OLGHWKHFDUWRQRIIWKHWRSRIWKHFDELQHW

NOTE: ,7,61271(&(66$5<72/$<7+(&$%,1(7'2:1

,125'(5725(029(7+(6.,'

7KHXQLWLVVHFXUHGWRWKHVNLGZLWKVORWWHG

WLHGRZQVWUDSV5HPRYHWKHVL[µEROWV

from the base channels in the tie-downs.

5HPRYHWKHVL[µ

bolts securing the straps

to the skid.

CAUTION'2127

$77(0377252//81,7

OFF SKID.

PRUDENCE,/1(

)$873$6(66$<(5'()$,5(

528/(5/(5e)5,*e5$7(85

3285/·(1/(9(5'(/$<

3$/(77(

STEP 3 INSTALL WATER LINE

$FROGZDWHUVXSSO\LVUHTXLUHGIRUDXWRPDWLF

LFHPDNHURSHUDWLRQ7KHZDWHUSUHVVXUHPXVW

be between 40 and 120 p.s.i.

5RXWHµ2'FRSSHURU*(6PDUW&RQQHFW

™

plastic tubing between house cold water line

and the water connection location.

7KHWXELQJVKRXOGEHORQJHQRXJKWRH[WHQG

to the front of the refrigerator. Allow enough tubing

to accommodate the bend leading into the water line

connection.

Remov

Tie Dow

Toekick

7KHVXSSRUWEORFNVRQWKHERWWRPRIWKHUHIULJHUDWLRQ

case must be removed before the refrigerator is

WDNHQRIIWKHVNLGRUGDPDJHZLOORFFXU&DUHIXOO\

tilt the refrigerator and slide the blocks out from

beneath.

5HPRYHWKHWRHNLFNDQGVHWDVLGHIRUILQDOLQVWDOODWLRQ

/LIWWKHUHIULJHUDWRURIIWKHVNLGZLWKDQDSSOLDQFH

GROO\+DQGOHIURPWKHVLGHV

Floor

Cold Water Line

NOTE:7KHRQO\*(DSSURYHGSODVWLFWXELQJLVVXSSOLHG

LQWKH*(6PDUW&RQQHFW

™

5HIULJHUDWRU7XELQJNLWV

Do not use any other plastic water supply line because

the line is under pressure at all times. Other types

of plastic may crack or rupture with age and cause

water damage to your home.

*(6PDUW&RQQHFW

™

5HIULJHUDWRU7XELQJ.LWVDUH

DYDLODEOHLQWKHIROORZLQJOHQJWKV

·P:;;

·P:;;

·P:;;

·P:;;

STEP 2 MOVE THE REFRIGERATOR INTO THE HOUSE

5HXVHWKHFRUQHUSRVWVIURPWKHSDFNDJLQJWRSURWHFWVWDLQOHVVVWHHOPRGHOV5XQWKHDSSOLDQFHGROO\VWUDSVRYHU

the posts and under the handles.

/HDYHWKHSURWHFWLYHILOPRQWKHUHIULJHUDWRUXQWLOLQVWDOODWLRQLVFRPSOHWH

,03257$171HYHUOLIWWKHUHIULJHUDWRUE\WKHKDQGOHRUSXVKDJDLQVWWKHJULOOSDQHOWKLVFRXOGFDXVHGDPDJH

or misalignment.

$YRLGOD\LQJWKHXQLWRQLWVEDFNRUVLGHWRSUHYHQWVHDOHGV\VWHPUHVWULFWLRQV

STEP 4 INSTALLATION WITH

HOUSEHOLD WATER

FILTRATION SYSTEM

Skip this step if you do not have a household water

filtration system

If the water supply to the refrigerator is from

any household water filtration system, the filter

cartridge should be removed. For better ice and water

performance, remove the filter and install the filter bypass

plug.

STEP 5 INSTALL SIDE PANELS

Skip this step when not using side panels.

,I\RXDUHXVLQJµVLGHSDQHOVWKH\VKRXOG

be inserted into the case trim. Fasten the panels

to the refrigerator with stick-on hook and loop

fastener strips before setting the refrigerator in place.

STEP 6

INSTALL ANTI-TIP BRACKETS

:$51,1*: ANTI-TIP PRECAUTIONS

7KHUHIULJHUDWRULVWRSKHDY\DQGPXVWEHVHFXUHG

to prevent the possibility of tipping forward.

$77(17,21: PRECAUTIONS CONTRE

LES BASCULEMENTS

/HUpIULJpUDWHXUHVWEHDXFRXSSOXVORXUGHQKDXW

HWLOIDXWOHPDLQWHQLUHQSODFHSRXUpYLWHUODSRVVLELOLWp

de son basculement vers l’avant.

&XWDµ[µEORFNµORQJDQGVHFXUHWKHEORFN

WRWKHPRXQWLQJEUDFNHWVSURYLGHGXVLQJRU

wood screws.

6HFXUHWKHEUDFNHWZLWKZRRGEORFNWRWKHEDFNZDOO

VRWKDWLWLVµRU\RXULQVWDOODWLRQKHLJKWIURP

WKHILQLVKHGIORRU8VHRUZRRGVFUHZV

See the illustration.

7KHVFUHZVPXVWSHQHWUDWHDWOHDVWRQHLQFK

into the vertical wall studs.

Connect power cord:

%HIRUHSXVKLQJWKHUHIULJHUDWRULQWRWKHRSHQLQJSOXJ

the power cord into the receptacle. Open the grille

panel and reach into the opening at the back to grasp

the power cord. Pull the power cord into the opening

as you push the refrigerator back.

*HQWO\SXVKUHIULJHUDWRULQWRWKHRSHQLQJZLWKKDQGV

against front corners.

IMPORTANT NOTE: When the refrigerator is installed under a soffit

or if there is not enough height for this method of security, brackets

FDQQRWEHXVHG3URFHHGWRVWHSWROHYHOWKHUHIULJHUDWRUDQGWKHQWR

step 9 to secure refrigerator to cabinets. See step 8 if you have metal

ZDOOVWXGV7KHUHIULJHUDWRUPXVWEHVHFXUHGWRSUHYHQWWLSSLQJ

Installation Instructions

NOTE: &RPPRQZHDOWKRI0DVVDFKXVHWWV3OXPELQJ

&RGHV&05VKDOOEHDGKHUHGWR6DGGOHYDOYHV

are illegal and use is not permitted in Massachusetts.

&RQVXOWZLWK\RXUOLFHQVHGSOXPEHU

STEP 3 (continued)

Shut off the main water supply.

7XUQRQWKHQHDUHVWIDXFHWORQJHQRXJKWRFOHDUWKHOLQH

of water.

,QVWDOODVKXWRIIYDOYHEHWZHHQWKHLFHPDNHUZDWHU

valve and cold water pipe in a basement or cabinet.

7KHVKXWRIIYDOYHVKRXOGEHORFDWHGZKHUHLWZLOOEH

easily accessible.

7XUQRQWKHPDLQZDWHUVXSSO\DQGIOXVKGHEULV

5XQDERXWDTXDUWRIZDWHUWKURXJKWKHWXELQJLQWRD

bucket. Shut off the water supply at the shut-off valve.

127(6DGGOHW\SHVKXWRIIYDOYHVDUHLQFOXGHGLQPDQ\

water supply kits. Before purchasing, make sure a saddle

type valve complies with your local plumbing codes.

Filter Bypass

Plug

Rotate Clockwise To

Remove

STEP 7 LEVEL REFRIGERATOR

$OOPRGHOVKDYHSRLQWOHYHOLQJ7KHIURQWLV

supported by leveling legs, the rear is supported

by adjustable wheels. Both are accessible from

the front of the refrigerator.

7ROHYHOWKHEDFNRIWKHUHIULJHUDWRUWXUQWKHµ

KH[QXWORFDWHGDERYHWKHIURQWZKHHOV7XUQ

clockwise to raise or counterclockwise to lower the

refrigerator.

)RUIURQWOHYHOLQJXVHDµRSHQHQGZUHQFK

$GMXVWKHLJKWRIUHIULJHUDWRUWRPDWFKLQVWDOODWLRQ

FXWRXWRSHQLQJµWRµ7KHUHIULJHUDWRU

should be level and plumb with cabinetry.

STEP 8 ALTERNATE ANTI-TIP

PROCEDURE

The refrigerator must be secured to prevent tipping.

The anti-tip brackets cannot be used on metal

wall studs. Use this Alternate Procedure to secure

the refrigerator against tip-over whenever metal

wall studs are encountered and there is no soffit.

5DLVHWKHJULOOHSDQHOWRDFFHVVFDVHWULP

8VHDµELWWRGULOOIRXUHYHQO\VSDFHGFOHDUDQFH

holes through the metal top case trim.

8VHDµELWWRGULOOWRSLORWKROHVWKURXJKWKHPHWDO

FOHDUDQFHKROHVDQGLQWRWKHZRRGVRIILW7KHKROHV

VKRXOGEHFHQWHUHGLQWKHVRIILWRUDµPLQZRRG

EUDFH7KHEUDFHVSDQQLQJWKHHQFORVXUHPXVW

be securely fastened to cabinets on both sides.

,QVWDOOIRXUµGU\ZDOOVFUHZVLQWRWKHSLORWKROHV

CAUTION:

7KHUHDUOHYHOLQJZKHHOVDQGIURQWOHYHOLQJOHJV

DUHOLPLWHGWRDPD[LPXPKHLJKWDGMXVWPHQWRIµ

,IWKHLQVWDOODWLRQUHTXLUHVPRUHWKDQµKHLJKW

the installer should elevate the refrigerator on a sheet

RISO\ZRRGRUUXQQHUV&DELQHWU\WULPFRXOGDOVR

be added across the top of the opening to shorten

the opening. If you attempt to raise the refrigerator

more than 1”, you will damage the front leveling

legs and the rear leveling wheels. Make adjustments

in small increments.

PRUDENCE

/HVURXHVGHQLYHOOHPHQWDUULqUHHWOHVSDWWHVGH

QLYHOOHPHQWDYDQWSHUPHWWHQWXQUpJODJHPD[LPDO

GHPPSR6LO·RXYHUWXUHSRXUOHUpIULJpUDWHXU

DXQHKDXWHXUVXSpULHXUHjPSR

O·LQVWDOODWHXUGRLWpOHYHUOHUpIULJpUDWHXUVXUXQHIHXLOOH

GHFRQWUHSODTXpRXGHVJOLVVLqUHV,OHVWpJDOHPHQW

possible d’ajouter des baguettes de finition des

SODFDUGVVXUOHKDXWGHO·RXYHUWXUHDILQGHODUpGXLUH

Lever le réfrigérateur de plus de 25 mm (1 po)

endommage les pattes de nivellement avant

et les roues de nivellement arrière.

Installation Instructions

STEP 11 INSTALL GRILLE PANEL

(for Custom Panel Models only)

To insert the framed or overlay panel into the grille:

5DLVHWKHJULOOHSDQHOWRWKHVWRSSRVLWLRQ

/RRVHQWKHVFUHZVRQWKHVLGHWULPEHKLQGWKHIUDPH

5HPRYHWKHERWWRPWULP

CAUTION: 7KHPHWDOSDQHOPD\EH

slippery. Grip the metal panel firmly so the panel does

not slip out of the frame and cause personal injury or

damage to the frame.

PRUDENCE : /HSDQQHDXHQPpWDO

SHXWErWUHJOLVVDQW7HQLUIHUPHPHQWOHSDQQHDXHQ

PpWDOGHPDQLqUHjFHTXHOHSDQQHDXQHJOLVVHSDV

en dehors du cadre en provoquant des blessures

corporelles ou des dommages au cadre.

6OLGHWKHSDQHORYHUWKHPHWDOEDFNHUSDQHODQGLQWR

the trim.

,IQHFHVVDU\WDSZLWKDZRRGEORFNXQWLOWKHSDQHO

slips under the top trim piece.

5HDVVHPEOHWKHERWWRPWULP7LJKWHQWKHVFUHZV

$GMXVWWKHKLQJHVSULQJWRDFFRPPRGDWHWKHSDQHO

weight, if necessary.

Adjust Nut Below

Spring to Accommodate

Panel Weight

Loosen

Side

Trim

Screw

Loosen

Side

Trim

Screw

Installation Instructions

STEP 10 ADJUST DOOR SWING

127(7KLVUHIULJHUDWRUKDVDSRVLWLRQGRRUVWRS

When space does not allow the door to swing open

fully to 130°, you may change the door swing to a 90°

opening. Skip this step if door opening is satisfactory

for your installation situation.

2SHQWKHGRRUWRYLHZWKHERWWRPKLQJH

1RWHWKHGRRUVWRSSLQORFDWLRQV7KHSLQLVIDFWRU\

installed in the 130° position.

&ORVHWKHGRRU)URPEHORZXVHSOLHUVWRXQVFUHZ

the door stop and reinstall into the 90° position.

STEP 9 SECURE REFRIGERATOR

TO CABINETRY

Whenever possible, perform this step for anti-tip

security, or when anti-tip brackets cannot be used.

The refrigerator must be secured to prevent tipping.

5DLVHWKHJULOOHSDQHOWRDFFHVVWKHFDVHWULP

'ULOODKROHLQWKHWULPDQGGULYHDVFUHZWKURXJK

the trim into the adjacent cabinet.

)ROORZWKHVDPHSURFHGXUHRQWKHRSSRVLWHVLGH

STEP 12 INSTALL 1/4” FRAMED PANELS

Install door panels:

2SHQWKHGRRUWR5HPRYHWKH3KLOOLSVKHDGVFUHZV

from the door handle.

5HPRYHWKHKDQGOH5HWDLQDOOVFUHZV

5HPRYHWKHVFUHZVKROGLQJWKHWULPWKHQOLIWRII

WKHWULP5HWDLQWKHVFUHZV

6OLGHWKHIUDPHGSDQHOLQWRWKHGRRUWULP

Dispenser Models Only:

7KHGLVSHQVHUFRQWUROVSURWUXGHEH\RQGWKHIDFH

RIWKHIUHH]HUGRRU7RDYRLGGDPDJHWRWKHGLVSHQVHU

the trim at the top of the door should be removed.

5HPRYHWKHVFUHZVKROGLQJWKHWRSWULPLQSODFH

3ODFHWKHIUHH]HUSDQHOLQWRWKHERWWRPFKDQQHO

and slide into the hinge side trim.

5HLQVWDOOWKHWRSWULPSLHFHZLWKVFUHZV

7KHUHDUHWZRVHWVRIKROHVLQWKHKDQGOHVLGHWULP

5HSODFHWKHKDQGOHVLGHWULPE\LQVWDOOLQJWKHRULJLQDO

VFUHZVLQWKH)5217VFUHZKROHV

6HFXUHWKHKDQGOHWRWKHGRRUXVLQJWKH5($5VFUHZ

holes.

)ROORZWKHVDPHSURFHGXUHVWRLQVWDOOWKHRSSRVLWHSDQHO

&KHFNWREHVXUHWKHKDQGOHVDUHHYHQO\DOLJQHGZLWK

HDFKRWKHUDWWKHWRS7RDGMXVWORRVHQWKHKDQGOH

VFUHZVDQGVOLGHXSRUGRZQ7LJKWHQWKHVFUHZV

NOTE: Aluminum cover trim is supplied for use with

custom handles on overlay panels. It is not intended for

XVHZLWKµSDQHOV'LVFDUGWKHFRYHUWULPZKHQXVLQJ

µIUDPHGSDQHOV

Go to Step 12A for Overlay Panels

Supplied

Handle Shown

in 1/4” Panel

Position

Installation Instructions

STEP 12A INSTALL OVERLAY PANELS

Install door panels:

2SHQGRRUWR5HPRYHWKH3KLOOLSVKHDGVFUHZV

from the door handle.

5HPRYHWKHKDQGOH5HWDLQDOOVFUHZV

5HPRYHWKHVFUHZVKROGLQJWKHWULPWKHQOLIWRII

WKHWULP5HWDLQWKHVFUHZV

6OLGHWKHRYHUOD\SDQHOLQWRWKHGRRUWULP

Dispenser Models Only:

7KHGLVSHQVHUFRQWUROVSURWUXGHEH\RQGWKHIDFH

RIWKHIUHH]HUGRRU7RDYRLGGDPDJHWRWKHGLVSHQVHU

the trim at the top of the door should be removed.

5HPRYHWKHVFUHZVKROGLQJWKHWRSWULPLQSODFH

3ODFHWKHDVVHPEOHGIUHH]HUSDQHOLQWRWKHERWWRP

channel and slide into the hinge side trim.

5HLQVWDOOWKHWRSWULPSLHFHZLWKWKHVFUHZV

7KHUHDUHWZRVHWVRIKROHVLQWKHKDQGOHVLGHWULP

5HSODFHKDQGOHVLGHWULPE\LQVWDOOLQJWKHRULJLQDOVFUHZV

in the 5($5 screw holes.

6HFXUHWKHKDQGOHWRWKHGRRUXVLQJWKH)5217

screw holes.

)ROORZWKHVDPHSURFHGXUHVWRLQVWDOOWKHRSSRVLWHSDQHO

&KHFNWREHVXUHWKHKDQGOHVDUHHYHQO\DOLJQHGZLWK

HDFKRWKHUDWWKHWRS7RDGMXVWORRVHQWKHKDQGOH

VFUHZVDQGVOLGHXSRUGRZQ7LJKWHQWKHVFUHZV

Supplied Handle

Shown in Overlay

Panel Position

Installation Instructions



STEP 12A (continued)

Custom Handles

,I\RXDUHXVLQJFXVWRPKDQGOHVWKHKDQGOHPXVW

be properly secured to the overlay panel before sliding

the panel into the trim.

7KHFDELQHWPDQXIDFWXUHUZLOOVXSSO\WKHFXVWRP

handle and hardware.

'LVFDUGWKHVXSSOLHGKDQGOH

5HPRYHWKHWULP3HHODZD\DIHZLQFKHV

of the adhesive backing.

IMPORTANT: 7KHWDSHLVYHU\VWLFN\DQGVWURQJ2QFH

it adheres to a surface, it cannot be removed without

damaging both surfaces. Do not install the trim before

the final wood panels are in place. Be sure to align

the trim carefully before removing the paper backing.

Reinstall all original screws.

5HLQVWDOOWKHKDQGOHVLGHWULPXVLQJDOOVXSSOLHG

flat-head screws, plus the 12 flat-head screws

originally installed in the handle trim.

,QVWDOODVXSSOLHGHQGFDSRQWRWKHWRSRIWKHGRRU

using a Phillips head screwdriver and the 2 screws

provided. Hand-tighten the screws into the end caps.

Do not overtighten; damage will occur.

&OHDQWKHDOXPLQXPWULPZLWKUXEELQJDOFRKRO³

do not use alcohols with oil or lanolin that will prevent

adhesion of double-sided tape.

6OLSWKHDOXPLQXPFRYHUWULPEHKLQGWKHWRSHQGFDS

WRFKHFNWKHILW7KHDOXPLQXPFRYHUWULPKDVDUHFHVV

on each end which fits the end cap.

Installation Instructions

Top End Cap

Fits Over the

Aluminum Trim.

Secure Cap with

2 Screws.

End Cap

STEP 12A (continued)

&DUHIXOO\SODFHWKHDOXPLQXPFRYHUWULPLQWRWRS

end cap so that the recess is aligned with the cap.

8VHWKHWRSWRERWWRPJURRYHVDORQJWKHKDQGOHVLGH

to align the cover trim accurately. Pull the tape a few

inches at a time while pressing the trim against

the door. Press and hold approximately 10 seconds

before continuing along the length of the door.

,QVWDOODQRWKHUHQGFDSDWWKHERWWRPRIWKHGRRU

WRVHFXUHWKHFRYHUWULP8VHDVWXEE\3KLOOLSVKHDG

screwdriver and the 2 screws provided.

 NOTE: Make sure there are no gaps in the installation.

)ROORZWKHVDPHSURFHGXUHRQWKHRSSRVLWHGRRU

Insert Aluminum

Trim Into End

Cap.

Cover Trim

End Cap

STEP 14 CONNECT WATER SUPPLY

/RFDWHDQGEULQJWKHWXELQJWRWKHIURQW

of the cabinet.

7XUQWKHZDWHURQWRIOXVKGHEULVIURPWKHOLQH

5XQDERXWDTXDUWRIZDWHUWKURXJKWKHWXELQJ

into a bucket, then shut off the water.

Copper Tubing:

6OLSDµQXWDQGIHUUXOHSURYLGHGRYHUERWKHQGVRI

the copper tubing. Insert the tube into the union fitting

on the unit and tighten the nut to the union.

7XUQRQWKHZDWHUWRFKHFNIRUOHDNV

GE SmartConnect

™

Tubing:

,QVHUWWKHPROGHGHQGRIWKHWXELQJ

LQWRWKHUHIULJHUDWRUFRQQHFWLRQ7LJKWHQ

the compression nut until it is just hand tight.

7LJKWHQRQHDGGLWLRQDOWXUQZLWKDZUHQFK

2YHUWLJKWHQLQJFDQFDXVHOHDNV

7XUQRQWKHZDWHUWRFKHFNIRUOHDNV

NOTE: Make sure excess tubing length does not

interfere with the toekick installation.

STEP 13 INSTALL DISPENSER TRIM

Skip this step is you are installing a stainless steel

wrapped or a non-dispenser refrigerator.

7KHUHDUHWZRGLVSHQVHUWULPVVKLSSHGZLWK\RXU

refrigerator. Select the appropriate trim for your

application.

3UHVVDQGVQDSWKHGLVSHQVHUWULPLQWRWKHGLVSHQVHU

recess on the refrigerator door.

If an excessive gap exists around the dispenser trim

or if the panel fits loosely in the door frame, foam tape

PD\EHDSSOLHGWRKHOSLPSURYHWKHILW5HPRYH

the trim and panel and apply the foam tape

to the door around the dispenser and in the corners.

&RPSDUHWKHGLVSHQVHUWULPV1RWHWKDW

the inside depth of the frames are different.

&KRRVHWKHWULPZLWKOHVVGHSWKIRUIUDPHG

panels, choose the deeper one for overlay

panels.

Dispenser trim fit over the custom panel depends on

FRUUHFWSDQHOWKLFNQHVV6HHSDJHVDQGIRUSDQHO

construction information.

Framed

Panel

Trim

Overlay

Panel

Trim

Refrigerator

Water Supply

House

Water Supply

Installation Instructions

STEP 17 INSTALL TOEKICKS

/RFDWHWKHVXSSOLHGWRHNLFNVVKLSSHGWDSHGWR

WKHVLGHRIWKHUHIULJHUDWRU

)LUVWDWWDFKWKH/$5*(5WRHNLFNWRWKHUHILJHUDWRU

XVLQJ21/<WKHWRSFHQWHUKROH

1H[WDWWDFKWKHWRHNLFNH[WHQVLRQWRWKHUHIULJHUDWRU

XVLQJWKHWKUHHORZHUVORWV

$FXVWRPWRHNLFNFDQEHLQVWDOOHGWRPDWFKRU

FRPSOHPHQWWKHVXUURXQGLQJFDELQHWU\8VHWKH

supplied toekick as a template to cut the shape.

STEP 16 START ICEMAKER

6OLGHWKHVZLWFKWR217KHLFHPDNHUZLOOEHJLQ

operation automatically.

%HVXUHQRWKLQJLQWHUIHUHVZLWKWKHVZHHS

of the feeler arm.

'LVFDUGWKHILUVWIXOOEXFNHWRILFHFXEHV

7RWXUQWKHLFHPDNHURIIVOLGHWKHVZLWFKWR2))

STEP 15 CONNECT POWER, CLOSE

GRILLE PANEL

2SHQWKHJULOOSDQHO

3OXJLQWKHSRZHUFRUGLIQHFHVVDU\E\UHDFKLQJ

into the opening next to the water filter. If access is

too tight, remove the 2 screws holding the water filter

bracket and move aside. Plug in the power cord and

secure the bracket with the original screws.

&KHFNWRPDNHVXUHSRZHUWRUHIULJHUDWRULVRQ

by opening refrigerator door to see if interior lights

are on.

7KHWHPSHUDWXUHFRQWUROVDUHSUHVHWDW)IRU

WKHIUHVKIRRGVHFWLRQDQG)IRUWKHIUHH]HU

$OORZKRXUVWRVWDELOL]HEHIRUHPDNLQJ

adjustments.

INSPECT FINAL INSTALLATION

&KHFNGRRUDOLJQPHQW

Stand back away from the refrigerator to inspect

the final installation.

&KHFNWREHVXUHWKHKDQGOHVDUHHYHQO\DOLJQHGZLWK

HDFKRWKHUDWWKHWRS7RDGMXVWORRVHQWKHKDQGOH

VFUHZVDQGVOLGHXSRUGRZQ7LJKWHQWKHVFUHZV

6KLSSLQJRUWKHDGGLWLRQRIKHDY\GRRUSDQHOV

may have caused the doors to move slightly out

of alignment.

,IQHFHVVDU\WKHIUHVKIRRGGRRUPD\EHDGMXVWHGXS

RUGRZQWRDOLJQZLWKWKHIUHH]HUGRRU

8VHDµZUHQFKWRDGMXVWWKHKLQJHSLQDVVKRZQ

Bushing

Door Hinge

Case Hinge

5/16" Wrench

Raise

Door Out of

Alignment

Master Light

Switches

Electrical

Outlet Access

Bracket

Screws

Installation Instructions

Icemaker

Feeler Arm

Power

Switch





PARTS LIST

2 Stainless tubular handles

8 Handle standoffs 3/32” Allen wrench for set screws

10 Screws for handle 10 Plastic spacers standoffs #10-

32x1” pan head machine (8 required, 2 extra)

screws (8 required, 2 extra)

10 Set screws (8 required, 2 extra)

ZKHSS2 Tubular Stainless Steel Handles

TOOLS AND MATERIALS REQUIRED

,QDGGLWLRQWRWKHFXVWRPGRRUSDQHOV\RXQHHG

3KLOOLSVVFUHZGULYHU  &HQWHUSXQFK

'ULOODQG” ELW  +DPPHU

and 7/8” spade bit

6DIHW\JODVVHV   3HQFLO

7KLVNLWSURYLGHVIRUWKHLQVWDOODWLRQRI7XEXODU6WDLQOHVV6WHHO

KDQGOHVRQµRYHUOD\FXVWRPSDQHOV

STEP 1 REMOVE DOOR HANDLES

2SHQWKHUHIULJHUDWRUGRRUWR5HPRYH

the 6 screws holding the handle to the door.

5HPRYHWKHVFUHZVKROGLQJWKHKDQGOHVLGHWULP

5HWDLQDOOVFUHZVDQGWULP'LVFDUGWKHKDQGOH

)ROORZWKHVDPHSURFHGXUHWRUHPRYHWKHIUHH]HU

handle and trim.

Page is loading ...

GE ZISP480DXSS Installation guide

Brand: GE

Model: ZISP480DXSS

Category: Fridges

Type: Installation guide

Download PDF

report

GE ZISP480DXSS Installation guide

GE ZISP480DXSS Installation guide

Related papers

Other documents