2
PRODUCT SPECIFICATIONS
8H-5124CB
Type: Infinite Control
2 Controls, 6.6 KW, 396 sq. in. (2555 sq. cm) Grid Area
Approximate weight: Installed - 98 lb. (45 kg); Shipping - 145 lb. (66 kg)
Dimensions: 24" W x 25 5/8" D x 14 1/4" H
(61cm W x 65cm D x 36cm H)
Volts: 240V, 3 PH Amps: x - 18.8 y - 18.8 z - 11.9
240V, 1 PH Amps: 27.5
208V, 3 PH Amps: x - 21.8 y - 21.8 z - 13.8
208V, 1 PH Amps: 31.8
8H-5136CB
Type: Infinite Control
3 Controls, 9.9 KW, 594 sq. in (3832 sq. cm) Grid Area
Approximate weight: Installed - 175 lb (80 kg); Shipping - 215 lb. (98 kg)
Dimensions: 36" W x 25 5/8" D x 14 1/4"H
(91 cm W x 65 cm D x 36 cm H)
Volts: 240V, 3 PH Amps: x - 23.9 y - 23.9 z - 23.9
240V, 1 PH Amps: 41.3
208V, 3 PH Amps: x - 27.6 y - 27.6 z - 27.6
208V, 1 PH Amps: 47.6
3
This symbol is intended to alert the user to the presence of
important operating and maintenance instructions in the manual
accompanying the appliance.
RETAIN THIS MANUAL FOR FUTURE REFERENCE
NOTICE
Using any part other than genuine Star factory supplied parts relieves the
manufacturer of all liability.
NOTICE
Star reserves the right to change specifications and product design without
notice. Such revisions do not entitle the buyer to corresponding changes,
improvements, additions or replacements for previously purchased equipment.
MAINTENANCE AND REPAIRS
Contact your local authorized service agent for service or required maintenance. Refer to the authorized
service center listing provided with the unit. The Star Service Help Desk (1-800-807-9054) is available during
normal business hours to answer any questions that may arise. Please have your model number and serial
number for faster service.
SAFETY SYMBOL
4
CAUTION
This equipment is designed and sold for commercial
use only by personnel trained and experienced in its
operation and is not sold for consumer use in and
around the home nor for use directly by the general
public in food service locations.
These Electric Char-broilers are equipped for the
voltage and wattage indicated on the nameplate
mounted on the inside immediately in back of the
water drawer front. These units are designed to
operate on alternating current (A.C.) only. DO
NOT CONNECT TO DIRECT CURRENT (D.C.).
INSTALLATION
The installation of this appliance should conform to
the national electric code and local electric codes and
ordinances and the local electric company rules and
regulations.
For your protection, we recommend that a qualified
electrician install this appliance. The electrician
should be familiar with electrical installations and your
local electrical requirements. The external wiring
should be in conduit or an approved type of flexible
cable suitable for operation at 90° C and of suitable
size to carry the load. The supply circuit should be
properly fused and equipped with a means of
disconnecting as required by local electrical code.
The body of the appliance should be grounded (Do
not ground to a gas supply pipe).
1. Locate the unit: Do not install the unit closer than
12 inches from a side wall and/or closer than 9
inches from a rear wall.
2. Level the char-broiler by adjusting the feet,
which have provision for 1 inch of adjustment.
This adjustment also allows a perfect alignment to
be achieved with other Star-Max™ units.
3. The terminal block can be accessed by removing
cover plate from back of broiler.
GENERAL INSTALLATION INSTRUCTIONS 4. Fill water pan on broiler prior to use. Water
should be flush with splash baffles. Make sure
water is present in pan at all times. Note: Pan is
easily removable for cleaning.
CAUTION
CARE MUST BE TAKEN WHEN OPENING
PAN TO PREVENT SPILLING.
5. The charbroiler is constructed of high quality,
modular grates that are also readily removable
for cleaning, and are designed to have a dedicated
heating element which is controlled by a heat
control switch.
6. Seasoning - Set the heat control switch to low
position and preheat for about 15 to 20 minutes.
Using a cloth, spread a thin film of cooking oil over
the entire broiling grill surface. Allow the film to
remain on broiling grill for about 5 minutes. Wipe
surface clean and apply another film of cooking oil.
Wipe surface clean again. The broiling grill is now
ready for use. The oil may tend to smoke - this is
normal.
7. Approximate grilling temperatures range from
(with no product on grill) 350° F on low setting to
570° F on high.
CLEANING
1. Clean with a clean soft cloth daily. Any
discoloration can be removed with a non-abrasive
cleaner.
2. Remove water pan, and modular cooking grates;
wash in sink.
3. To clean heating element, first remove modular
grate corresponding to element. Swing element
to vertical position and lock in place with the
support located in center of element housing.
Clean elements with stiff wire brush or equivalent.
4. Heat baffles are located directly below heating
elements and are removable for cleaning in sink.
Part# 2M-4497-2 10/02 RB
The foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty.
FOR ASSISTANCE
Should you need any assistance regarding the Operation or Maintenance of any Star equipment; write, phone, fax or email our Service Department.
In all correspondence mention the Model number and the Serial number of your unit, and the voltage or type of gas you are using.
ALL:
* Pop-Up Toasters
* Butter Dispensers
* Pretzel Merchandisers
* Pastry Display Cabinets
* Nacho Chip Merchandisers
* Accessories of any kind
* Sneeze Guards
* Pizza Ovens
* Heat Lamps
* Hot Cups
* Pumps
Visit our Website at: www.star-mfg.com Email: [email protected] For Fax-On-Demand Literature: (800) 807-9814
THOROUGHLY INSPECT YOUR UNIT ON ARRIVAL
This unit has been tested for proper operation before leaving our plant to insure delivery of your unit in perfect condition. However, there are instances in
which the unit may be damaged in transit. In the event you discover any type of damage to your product upon receipt, you must immediately contact the
transportation company who delivered the item to you and initiate your claim with same. If this procedure is not followed, it may affect the warranty
status of the unit.
LIMITED EQUIPMENT WARRANTY
All workmanship and material in Star products have a one (1) year limited warranty on parts & labor in the United States and Canada. Such warranty is
limited to the original purchaser only and shall be effective from the date the equipment is placed in service. Star's obligation under this warranty is limited
to the repair of defects without charge, by the factory authorized service agency or one of its sub-agencies. Models that are considered portable (see below)
should be taken to the closest Star service agency, transportation prepaid.
>Star will not assume any responsibility for loss of revenue.
>On all shipments outside the United States and Canada, see International Warranty.
*The warranty period for the JetStar series six (6) ounce popcorn machines is two (2) years.
*The warranty period for the Chrome-Max Griddles is five (5) years on the griddle surface. See detailed warranty provided with unit.
* The warranty period for Teflon/Dura-Tec coatings is one year under normal use and reasonable care. This warranty does not apply if damage occurs to
Teflon/Dura-Tec coatings from improper cleaning, maintenance, use of metallic utensils, or abrasive cleaners. This warranty does not apply to the
“non-stick” properties of such materials.
>This warranty does not apply to "Special Products" but to regular catalog items only. Star's warranty on "Special Products" is six (6) months on parts
and ninety (90) days on labor.
>This warranty does not apply to any item that is disassembled or tampered with for any purpose other than repair by a Star Authorized Service Center or
the Service Center's sub-agency.
>This warranty does not apply if damage occurs from improper installation, misuse, wrong voltage, wrong gas or operated contrary to the Installation and
Operating instructions.
>This warranty is not valid on Conveyor Ovens unless a "start-up/check-out" has been performed by a Factory Authorized Technician.
PARTS WARRANTY
Parts that are sold to repair out of warranty equipment are warranted for ninety (90) days. The part only is warranted. Labor to replace the part is
chargeable to the customer.
SERVICES NOT COVERED BY WARRANTY
PORTABLE EQUIPMENT
Star will not honor service bills that include travel time and mileage charges for servicing any products considered "Portable" including items listed below.
These products should be taken to the Service Agency for repair:
1. Travel time and mileage rendered beyond the 50 mile radius limit
2. Mileage and travel time on portable equipment (see below)
3. Labor to replace such items that can be replaced easily during a daily cleaning
routine, ie; removable kettles on fryers, knobs, grease drawers on griddles, etc.
4. Installation of equipment
5. Damages due to improper installation
6. Damages from abuse or misuse
7. Operated contrary to the Operating and Installation Instructions
8. Cleaning of equipment
9. Seasoning of griddle plates
10. Voltage conversions
11. Gas conversions
12. Pilot light adjustment
13. Miscellaneous adjustments
14. Thermostat calibration and by-pass adjustment
15. Resetting of circuit breakers or safety controls
16. Replacement of bulbs
17. Replacement of fuses
18. Repair of damage created during transit, delivery, &
installation OR created by acts of God
* The Model 510F Fryer.
* The Model 526TO Toaster Oven.
* The Model J4R, 4 oz. Popcorn Machine.
* The Model CFS Series Food Steamer.
* The Model 526WO Warming Oven.
* The Model 518CM & 526CM Cheese Melter.
* The Model 12MC & 15MC & 18MCP Hot Food Merchandisers.
* The Model 12NCPW & 15NCPW Nacho Chip/Popcorn Warmer.
* All Hot Dog Equipment except Roller Grills & Drawer Bun Warmers.
* All Nacho Cheese Warmers except Model 11WLA Series Nacho Cheese Warmer.
* All Condiment Dispensers except the Model CSD & HPD Series Dispenser.
* All Specialty Food Warmers except Model 130R, 500, 11RW Series, and 11WSA Series.
9
MODELS
8H-5124CB and 8H-5136CB Electric Counter Char-Broilers
1 2R-Z3436 5124CB/5136CB 2/3 KNOB-INFINITE CONTROL
2 H1-Z3556 5124CB 1 FRONT PANEL
H1-Z3558 5136CB 1 FRONT PANEL
3 H1-524031 5124CB 1 DRAWER
H1-536028 5136CB 1 DRAWER
4 H1-Z3606 5124CB/5136CB 2/3 BRACKET-INFINITE CONTROL
5 H1-524008 5124CB 1 LOWER BAFFLE ASSY
H1-536009 5136CB 2 LOWER BAFFLE ASSY
6 H1-524007 5124CB 1 UPPER BAFFLE ASSY
H1-536007 5136CB 1 SHORT UPPER BAFFLE ASSY
H1-536008 5136CB 1 LONG UPPER BAFFLE ASSY
7 H1-524016 5124CB 1 ELEMENT SUPPORT ASSY
H1-157007 5136CB 1 ELEMENT SUPPORT ASSY
8 2N-Y3083 5124CB/5136CB 2/3 ELEMENT-HEATING - 240V, BENT
2N-Y3084 5124CB/5136CB 2/3 ELEMENT-HEATING - 208V, BENT
9 2N-Y3085 5124CB/5136CB 2/3 ELEMENT-HEATING -240V, STRAIGHT
2N-Y3086 5124CB/5136CB 2/3 ELEMENT-HEATING - 208V, STRAIGHT
10 2C-2560 5124CB/5136CB 12/18 NUT 10-24, HEX
11 2C-9704 5124CB/5136CB 12/18 SCREW 10-24X1
12 2F-Y3107 5124CB/5136CB 4/6 GRATE
13 2I-7370 2 GASKET
14 H1-8746 2 SUPPORT-ELEMENT HOUSING
15 H1-155244 5124CB 1 ELEMENT HOUSING COVER ASSY
H1-157001 5136CB 1 ELEMENT HOUSING COVER ASSY
16 2A-5401 1 COTTER PIN
17 2C-1811 1 WASHER
18 2P-7969 1 SPRING
19 H1-524017 5124CB 1 ELEMENT PIVOT BRACKET ASSY
H1-536015 5136CB 1 ELEMENT PIVOT BRACKET ASSY
20 H1-155247 1 ELEMENT HOUSING SUPPORT ASSY
21 H1-Y3115 5124CB 2 STRAP - ELEMENT
H1-Y3266 5136CB 2 STRAP - ELEMENT
22 2A-Z3610 5124CB/5136CB 6/9 SPACER, INSTALLED AT FRONT ROW ONLY
23 H1-Y3265 1 BRACKET - TERMINAL BLOCK
24 H1-Z3554 5124CB 1 COVER BACK
H1-Z3562 5136CB 1 COVER BACK
25 2E-Y2849 1 BLOCK - TERMINAL
26 2C-Y2344 1 TERMINAL - GROUNDING
27 2A-Z0314 4 FOOT 4" DIE CAST
28 2J-Z3157 5124CB/5136CB 2/3 INDICATOR LIGHT
29 2J-6403 5124CB/5136CB 2/3 CONTROL-INFINITE
30 2M-Z3566 5124CB 1 SIGN 24" CHAR BROILER
2M-Z3567 5136CB 1 SIGN 36" CHAR BROILER
PARTS LIST EFFECTIVE
IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED PAGE
INCLUDE MODEL AND SERIAL NUMBER OF
Some items are included for illustrative purposes only and in certain instances may not be available.
Number
Per
Unit Description
Part
Number
Key
Number
Star Manufacturing International, Inc.
6/25/02 Rev. C
1
1
Model
Number
/
