Backyard Creations OOCCHE2-32 Owner's manual
- Category
- Barbecues & grills
- Type
- Owner's manual
CHEYENNE GRILL & FIREPIT
Owner’s Manual
SKU: 259-5062; Model: OOCCHE2-32
Assembly Required
The following tools (not included) are required for assembly:
Two adjustable wrenches (or 14mm sockets / wrenches)
OUTDOOR USE ONLY! NEVER USE INDOORS!
Read and follow all of these manufacturer instructions before beginning assembly or
operation. Failure to do so could result in fire, burns, or other serious personal injury.
Keep this owner’s manual for future reference. If you sell or give this product to someone
else, make sure this manual accompanies this product.
2
IMPORTANT SAFETY INFORMATION!
DANGER
CARBON MONOXIDE HAZARD!
Burning wood and charcoal releases carbon monoxide, a toxic odorless
gas which can cause serious injury or death. NEVER use this product
to burn wood or charcoal inside homes, inside vehicles, or inside any
other enclosed areas! If used indoors, toxic fumes, including carbon
monoxide, will accumulate and cause serious injury or death.
OUTDOOR USE ONLY!
WARNING
CALIFORNIA PROPOSITION 65
1) Combustible by-products produced when using this product contain chemicals known
to the State of California to cause cancer, birth defects, or other reproductive harm.
2) This product contains chemicals, including lead and lead compounds, known to the
State of California to cause cancer, birth defects, or other reproductive harm.
ALWAYS wash your hands after handling this product!
WARNING
This product is for OUTDOOR USE ONLY! NEVER use this product in an enclosed area or under
an overhead cover of any kind, including a tent, patio cover, or any other building or structure.
DO NOT use this product within 10 feet (3.05 meters) of any combustible material, including,
but not limited to, bushes, trees, wood or treated-wood decks, fences, patios, porches, walls,
vehicles, gasoline, lighter fluid, or any other flammable liquids.
ONLY use this product on a non-combustible, stable surface (e.g., concrete, masonry, brick, etc.)
that is able to support its weight. NEVER use on wood, grass, or other combustible surfaces.
NEVER use this product where children or pets could come into contact with the product.
DO NOT store or use this product near gasoline or other flammable liquids, gases or where
flammable vapors may be present.
Avoid fire. Keep a fire extinguisher nearby. Refer to your local authority to determine proper size
and type of fire extinguisher.
For residential use only! NOT for commercial use! DO NOT use this product for other than its
intended purpose. Any commercial use voids all warranties.
Use care when lifting or moving the grill and side box to prevent strains and back injuries.
DO NOT use this product in windy conditions.
3
WARNING
Burn wood logs only. DO NOT burn charcoal, leaves, or other combustible materials.
Use care when lifting or moving the grill and side box to prevent strains and back injuries.
DO NOT use this product in windy conditions.
AVOID DANGER! DO NOT overload the fire bowl with too much wood, or build a fire that is
too large.
NEVER leave this product unattended when hot, or in use.
This product is hot when in use. To avoid burns:
DO NOT attempt to move the product while the fire is lit, or it is still hot.
ALWAYS wear protective gloves or oven mitts during cooking.
DO NOT TOUCH any hot surfaces.
DO NOT wear loose clothing or allow hair to come in contact with the product.
AVOID BURNS! USE EXTREME CAUTION when adding wood to the fire while cooking.
AVOID INJURY! ALWAYS wear oven mitts or grilling gloves when adjusting the cooking grids, or
in any other way touching the product while it is hot.
NEVER place more than 8 pounds (3.6 kg) on any cooking grid. DO NOT lean on the grids.
ALWAYS make sure the cooking grids are attached securely to the grill.
When grilling, grease from food may drip onto the ashes and cause a grease fire. If this
happens, suffocate the flame. NEVER use water to extinguish grease fires!
NEVER try to remove ashes while they are hot. Doing so could cause burns.
ALWAYS allow grill and all components to cool completely before handling.
DO NOT remove ashes from the product until they are fully extinguished.
NEVER leave hot embers or ash unattended in the product. All extinguished embers and ash
must be removed and carefully placed in a non-combustible metal container. Saturate embers and
ash with water and allow them to remain in the metal container for 24 hours before disposing.
Keep extinguished embers and ashes safely away from combustible structures and materials.
Spray or douse the surfaces under and around the product with water until completely wet to
extinguish any ashes, coals, or embers that may have fallen during grilling or cleaning.
Store the product in a dry location out of reach of children and pets when not in use.
Preparation
Remove all parts and hardware from the carton and place them on a clean soft surface.
Compare the contents with the parts list and hardware list to make sure nothing is missing.
Dispose of all packaging materials properly. Please recycle whenever possible.
Tools Required for Assembly (Not included):
Two adjustable wrenches (or 14mm wrenches/sockets)
4
Parts Diagram
Parts and Hardware
No.
Image
Description
Qty
No.
Image
Description
Qty
A
Post Legs
2
G
Outer Ring
Segments
4
B
Fire Bowl
1
H
Adjustable Cooking
Grid Post - Tall
1
C
Standard Legs
2
I
Adjustable Cooking
Grid Post - Short
1
D
Ash Catcher
1
J
Large Cooking Grid
1
E
Vent
1
K
Small Cooking Grid
1
F
Cooking Grid
Handles
2
L
Ash Catcher
Hanger
1
S0
Short Allen
Screws
4
T1
Spring Bolts
(pre-attached)
2
S1
Long Allen
Screws
4
T2
Hex Nuts
4
S2
Hex Head
Bolts
8
T3
Allen Wrench
1
S3
Wing Bolts
2
B
K
G
G
H
F
J
I
F
A
A
D
C
L
5
Assembly
STEP 1. NOTE: The post legs (A) should be opposite each other.
Attach the post legs (A) and standard legs (C) to the rim of the fire bowl (B) with 4 hex head bolts (S2).
Partially tighten the bolts with an adjustable wrench. Do not tighten completely until Step 4.
STEP 2. Attach the standard legs (C) to the bottom of the fire bowl (B) with two hex head bolts (S2),
and two hex head nuts (T2).
NOTE: Attach the ash catcher hanger (L) and post legs (A) to the bowl at the same time.
Attach the post legs (A) and ash catcher hanger (L) to the bottom of the fire bowl (B) with two hex
head bolts (S2), and two hex head nuts (T2) as shown.
Partially tighten the bolts with an adjustable wrench. Do not tighten completely until Step 4.
STEP 3. Press the ends of the outer ring segments (G) together to form a complete ring as shown.
A
C
C
S2
B
C
C
C
S2
T2
T2
S2
T2
T2
S2
S2
A
L
A
A
C
G
6
STEP 4. Thread four long Allen screws (S1) through the outer ring (G) tube and into the legs.
Thread four short Allen screws (S1) through the outer ring (G) tabs and into the legs.
Check the alignment of the legs. Securely tighten all bolts and nuts from steps 1~4 with two adjustable
wrenches (or 14mm sockets/wrenches) and the Allen wrench (T3).
STEP 5. Attach the small cooking grid (K) to the tall post (H) with a wing bolt (S3).
Thread the cooking grid handle (F) onto the end of the cooking grid.
Repeat Step 5 for the large cooking grid (J), short post (I), and grid handle (F).
STEP 6. Slide the ends of the posts down into the openings in the post legs.
Note: The spring bolts (T1) engage the holes in the posts to hold them at the desired height. Pull the
spring bolts out to allow the posts to move up and down. Release the spring bolts to lock them in place.
Each cooking grid post can be adjusted to one of three heights.
S1
S0
G
K
F
H
S3
T1
7
STEP 7. Carefully set the vent (E) into the opening in the bottom of the fire bowl (B).
Set the ash catcher (D) onto the ash catcher hanger (L) underneath the fire bowl.
The grill is now ready to use. Before use, read the Important Safety Information in this manual.
Care and Maintenance
Wash cooking grids with hot, soapy water. Rinse well and dry completely with a towel. NEVER
allow grates to drip dry, or dry in a dishwasher. They will rust.
After washing and drying, lightly coat grates and grids with vegetable oil or vegetable oil spray.
Clean the inside and outside of the grill by wiping it with a damp cloth. Apply a light coat of
vegetable oil or vegetable oil spray to the interior surfaces to prevent rusting.
NEVER apply paint to the interior surface. Doing so could cause a fire resulting in
serious bodily harm or property damage.
If rust appears on the interior surface of your grill, clean and buff the affected area with steel
wool or fine grit emery cloth. Coat the interior lightly with vegetable oil or vegetable oil spray.
E
D
8
Limited Warranty
Manufacturer warrants this grill for replacement or repair of parts to the original purchaser for a period
of 90 days from original date of purchase. The original sales receipt is required for all warranty claims.
This warranty is limited to non-commercial residential use only. Any commercial, public, or institutional
use voids all warranties. This warranty does not cover normal wear and tear, damages resulting from
abuse, misuse, improper assembly, alteration of the product, weather, or accidental damages. Rust is
not a manufacturing defect. Shipping costs are not covered. Read and understand all assembly and
operating instructions, and all safety information and warnings before use.
Vendor Development Group, Inc.(hereafter, VDG), its directors, officers, or agents, will not be liable to
the purchaser or any third party, whether in contract, in tort, or on any other basis, for any indirect,
special, punitive, exemplary, consequential, or incidental loss, cost, or damage arising out of or in
connection with the sale, maintenance, use, or inability to use this product, even if VDG, or its directors,
officers, or agents have been advised of the possibility of such losses, costs or damages, or if such
losses, costs, or damages are foreseeable. In no event will VDG, or its officers, directors, or agents be
liable for any direct losses, costs, or damages that exceed the purchase price of the product. Some
states do not allow the exclusion or limitation of incidental or consequential damages, so the above
limitation or exclusion may not apply to the purchaser. This limited warranty gives you specific legal
rights, and you may also have other rights which vary by state.
Thank you for purchasing this charcoal grill!
If you need help, have missing or damaged parts, or have any questions, please e-mail us at
customerservice@vdgus.com
Or, call us toll free at
1-866-561-0731 (M-F 8:30 am – 4:30 pm CST)
Vendor Development Group, Inc.
Minneapolis, MN 55401
Made in China
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
Backyard Creations OOCCHE2-32 Owner's manual
- Category
- Barbecues & grills
- Type
- Owner's manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Other documents
-
Sunnydaze Decor SM-FRES101 Assembly Instructions
-
Sunnydaze Decor NB-OFPRHD37 Installation guide
-
Sunnydaze Decor NB-SMS202 Operating instructions
-
NewTechWood US-QD-PB-13-TK Installation guide
-
CobraCo FBCIWOVEN-BZ User guide
-
Catalina Creations AD389 Operating instructions
-
-
-
-
