Allen Sports SST1 Owner's manual

Allen Sports
Brand
Allen Sports
Model
SST1
Category
Car seat
Type
Owner's manual
INSTRUCTIONAL
OWNER’S MANUAL
p
1
MODEL SST1 JOGGER/BIKE TRAILER
Owner’s Manual should be kept for future reference
WARNING
WARNING
WARNING
WARNING
1. Completely read and understand Owner’s Manual before assembling or operating this product.
2. This product should be assembled by an adult
SAFETY TOWING TIPS
IMPORTANT SAFETY INFORMATION
WARNING #1:
• Failuretofollowthesewarningsandassemblyinstructionscouldresultinseriousinjuryordeath!
• Immediatelydiscardallplasticbagsandplasticwrappingmaterials!
• Maximumweightcapacityforthistrailerisone(1)childat50pounds,maxpayload!
• Neverusethistrailer/strollerifitbecomesdamaged!
• Toavoidseriousinjury,childrenshouldalwaysweartheseatbeltandtheshoulderstraps!
• Donotinstallacarseatoranyotherseatingdevicenotapprovedbythemanufacturerinsidethetrailer!
• AreectorthatcomplieswithCPSCregulationsmustbevisibleontherearoftrailer.
• Neverleavechildrenunattendedinoraroundthisproduct!
• Neverallowchildrentoassemble,fold,ordisassemblethisunit!
• Accessoriesorparcelsplacedintrailer/strollermaycauseittobecomeunstable!
• Notforusewithchildrenunder12monthsold!Childrenmustbeabletosupporttheirownheads!
• Beforeriding,checkthatallpartsareassembledaccordingtothemanufacturerinstructions!
Also,ensurethatthetrailerdoesnotinterferewithbraking,pedaling,orsteeringofthebicycle!
• Donotallowanyofthechild’sbody,clothing,shoelaces,ortoystocomeintocontactwithmovingparts!
• Makenomodicationstothetrailer!
• Tiresshouldbeinatedto25-35PSIformaximumcomfort!Checktirepressurebeforeeachuse!
• Useafootpumporhandpumptoinatetires!Pressurizedairhosescancauseoverination!
• Periodicallyre-checkallfastenerstomakesuretheyaretight!
• Cleantraileronlywithsoapandwater.Donotusesolvents!
TOWING TIPS:
• Makesureyourbikebrakesworkproperly!Brakingdistanceisincreasedwhenpullingatrailer!
• Thistraileriswide!Allowextraclearancenearcurbs,signs,parkedcars,andotherobstacles!
• Abicyclewithtrailerattachedrequiresawideturningradius!Donotturnsharply!
• Childrenmustwearanapprovedsafetyhelmetwhenusingthisproductintrailermode!
• Neverremoveprotectivecanopywhenpullingchildreninthetrailer!
• Alwaysusethesafetyagwhenpullingthistrailer!
• Donotrideovercurbs!Avoidbumpsandholes!Alwayssignalyourturns!
• Useextracautionwhenturningonunevenpavement,andgoingdownhill!
• Notforuseathighspeeds!Donotexceed10MPH!
• NEVERusethistraileratnight!
• Installarearviewmirroronyourbiketocheckonchildrenintrailer!
• Dresschildrenappropriatelytopreventthemfromgettingchilledoroverheatedwhileriding!
Protectagainstwind-chillincoldtemperatures,andprovideadequateventilationandhydrationduring
warmertemperatures.
INSTRUCTIONAL
OWNER’S MANUAL
p
2
FULLY ASSEMBLED JOGGER
QUANTITY DESCRIPTION
1 Framew/Canopy,Sling
Seatwith5pointsafety
harness,towbar,tow
bar coupler and rear
wheel bracket attached
2 16”Rearwheels
1 Safetyflag
1 Joggerfrontfork
1 12”QuickReleasefrontwheel
1 Joggerhandlebarwithwriststrap
PARTS LIST
INSTRUCTIONAL
OWNER’S MANUAL
p
3
TRAILER ASSEMBLY & OPERATING INSTRUCTIONS
STEP 1:
NOTE(S):
STEP2:
STEP3:
WARNING!: IMMEDIATELYDISCARDALLPLASTICBAGSANDWHEELWRAPPINGMATERIALS!
WARNING!: Thespring-releasepinsmustbeengagedforsafeoperationofthetrailer.FailuretoAssemble
properlymayresultininjury.Ifthespring-releasepinsdonotengageproperly,DONOTUSE.
Callthecustomerservicenumberasindicatedintheliteraturefor!
Removethetrailerfromtheboxandcheckcontentsagainstthe
partslist.
1.Laythetraileronthegroundwiththeblackfabricsidedown.
2.DonotremovethewhitefoamfromthewheelaxlesuntilSTEP4
OPEN FRAME
Removetrailerandallcomponentsfromcarton.Unfoldtrailerbypullingtheframeandremoveallcomponentsfrom
inside(Fig.2).
A. Liftbothsidepanelsintoanuprightposition(Fig2a).
B. InsertQRSnapPinsthroughholeinframeandclosethesnappinsotheloopofthepinisoverthepinshaft(Fig2b).
RELEASETHETOWBAR
1.Turnthetraileronitssidesothehitcharmisalongthetopedge[Fig.3].
2.Findthequick-releasepinthatholdsthetowbarinplaceinthetowbarbracket[Fig.3a]
3.Opentheloopofthequick-releasepinandremovethepin.
4.RotatethehitcharmforwarduntilitisseatedintheU-channel[Fig.3b].Re-installpininfront
holesintheU-channelandclosethesnappinsotheloopofthepinlockisoverthepinshaft.
FIGURE2.
FIGURE3. FIGURE3A. FIGURE3B.
FIGURE2A. FIGURE2B.
FIGURE1.
INSTRUCTIONAL
OWNER’S MANUAL
p
4
WHEELINSTALLATION
ATTACHINGTHEFOURSEASONCOVER
WARNING! Removethefoamfromthewheelaxlesanddiscardimmediately.Donotremovewashers.
WARNING!: Checkwheelsperiodicallyduringandbeforeeachusetobesurethattheyhavenot
becomeloose.FailuretodosocouldresultinSERIOUSINJURYtoyouortrailer’soccupants.
WARNING!: Neverusethetrailerwithoutthefourseasoncover.Thefrontwindoworbugscreenmustbe
attachedtoprotectchildrenfromyingobjects.
STEP 1:
STEP2:
STEP2:
STEP3:
STEP3:
STEP4:
STEP4:
STEP5:
STEP 1:
Liftthetrailerbacksotherightsideisup,andlocatetherightwheel.
Installthewheelaxlebyslidingtheaxlecompletelythroughthebracket
intheframeasshown.
WraptheVelcrobackedxingstrapsandsecurethecoveraroundtheframe.
Positionthefour-seasoncoveroverthetrailerwhereroll-upwindowisfacingtowardsthefrontsideofthetrailer.(Fig.12).
InserttheQuickReleasePin(tetheredtothetrailerframenearthewheelbracket)
throughtheholeintheaxleandlockthecliptosecurethepin.
SecuretheVelcromaterialatthebottomfrontofthecovertothematchingVelcromaterialon
thelowerfrontfabricpanel.
Repeatfortheleftwheel.Whencomplete,giveeachofthewheelsatugtobesure
thattheyaresecure.
NOTE: Wheelsmustbeproperlyinstalledwithquickreleasepinsclosedand
snappedshut.IfQRpinsarenotcorrectlyattached,wheelsmayfalloff.
DonotuseifQRpinsaremissing,oriftheclosureisdamagedormissing.
Connecttheslidereleasebucklesafxedtotherearcornersofthecovertothematchingbucklessewn
therearsideofthetrailercabin(Fig13).
ConnecttheelasticcordsontherearcovertotheD-Ringswhicharelocatedonthebottomcabincorners
NOTE: Thefour-seasoncoverisdesignedtokeeppassengersandcargodryandwarmininclement
weather.Italsoprotectsthepassengersfromyingdebris.Thefour-seasoncovercanbe
rolleduptoallowforaddedventilationinhotweather.Velcroclosureskeepthefour-season
coverinplacewhenrolledup.
FIGURE12. FIGURE13.
INSTRUCTIONAL
OWNER’S MANUAL
p
5
SAFETY FLAG INSTALLATION
STEP 1: Assembletheagandinserttheendintothesmallsleeveonthesideofthe
trailerskin.ReattachtheVelcrotosecurethecover.
NOTE: Flagshouldberemovedbeforeattemptingtofoldtrailer
WARNING!: Thisagismeantforuseonlywiththetrailer.Thisagisnotatoy.Donotletyourchildplay
withthisagatanytime.Failuretocomplywiththiswarningcouldresultinseriousinjury
ofyourchild.
WARNING!: Yourtrailerisdesignedtoattachtomostfull-sizedbicycles.Thetrailer’shitchmustbe
attachedtotherearaxleofthebike.Donotusetrailerifthehitchcannotbesecurely
attachedtorearaxle.Itisrecommendedthatthebicycle(s)towhichthetrailerwillbe
attachedundergoasafetycheckbyaqualiedbicyclemechanicbeforeattachingtrailer.
Thistrailershouldneverbeusedwithelectricbicycles,oranymotorcycleoranymotorizedvehicle
ATTACHINGTRAILERTOBICYCLE
STEP2:
STEP3:
STEP4:
STEP 1:
Positionhitchoverleftrearaxleofbicycleframe(Fig16).
LoosenLEFTsiderearaxletoallowthetrailer’shitchtoattachtoframe(Fig15).
Tightenaxlenutsecurely,testingtoseethathitchisunabletopullloose.
LoopSafetyStraparoundframeandsecuretoD-ringonhitcharm(Fig17).
WARNING!: Safetystrapmustattachtothebikeframewhenusingthisproductintrailermode.
FIGURE15. FIGURE16. FIGURE17.
INSTRUCTIONAL
OWNER’S MANUAL
p
6
SECURINGCHILDWITH5-POINTSAFETYHARNESS
WARNING! Toavoidseriousinjury,childrenshouldalwaysweartheseatbelt,shoulderstrap,andahelmet!
STEP 1:
STEP2:
UndothelapbeltbuckleandseatthechildintheCENTERofthetrailer.Bucklethelapbelt[A]overthe
child’slap,andpullthestrapuntilthebeltistight.
Placethetwocentershoulderstraps[C]overthechild’sshoulders,andclipbothstrapsinto“D”
Ring[D]ofthecentercrotchstrap.Adjustshoulderstrapheightofthechild,thenpullthestraps
untiltheyaresnug.
NOTE: Cliptheoutershoulderstraponeithersideintothe“D”Ringofthe
outercrotchstrapdirectlybelow.Thiswillkeepthestrapsthatarenot
inuseoutoftheway.
WARNING!: Adjustthestrapssothatthecrotchstrapandshoulderstrapsmeetatthechild’sstomachlevel,
NOTatthechestlevel!
TRAILER MAINTENANCE
Yourtrailerwillgiveyoumanyyearsofservicewithminimalcare.Toensuresafeanddependable
operation,werecommendthefollowingregularmaintenance.Beforeeachride:
STEP2:
STEP3:
STEP4:
STEP5:
STEP 1:
Makesurethatwheelsarefullysecureontheframe.Wheelsmustbefullyinsertedtolockinplace.
Checkallfastenerstomakesurethattheyaretight,andtightenorreplaceasneeded.
Checktiresforwearandproperinationaslistedonthetiresidewall.Useonlyhand-operated
pumptoavoidtiredamage.Under-oroverinationcanresultinunsafehandling.
Doublecheckhitchattachment,makingsurethatQRPinislocked,andthatsafetystrapisinplace.
Checkharnessstrapforwear,andmadesurethatbuckleslockproperly.
ANNUALLY: Onceayear,orsoonerifneeded,havethetrailerinspectedbyaqualiedbicycle
mechanicforsignsofwearorneededadjustment.
ASNEEDED: Trailercanbecleanedwithamilddetergentandwater.Donotremoveseatorcover
forwashing.Donotuseharshchemicalsorwater,astheymaydamagefabricsor
theframematerialsorsurfaces.
INSTRUCTIONAL
OWNER’S MANUAL
p
FOLDING FOR STORAGE AND TRANSPORT
PARKING BREAKS
STEP2:
STEP3:
STEP4:
STEP5:
STEP6:
STEP7:
STEP 8:
STEP 9:
NOTE:
NOTE:
STEP 1:
Unclipthetowbarsafetystrapfromthe“D”ring,andremovepinto
removehitchfromframe.
Removechildrenandallcargofrominsidethepassengercompartment.
Yourtrailerisequippedwithastrapparkingbrakeforaddedsafety.Whenloadingorunloadingorparkingyourtrailer,
engagetheparkingbraketopreventthetrailerfrommoving.
Figure22showsthestrapbrakeonthetrailer,Fig23showsthestrapbrakeinoperation,asitloopsthroughthespokes,
andFig24showsthebrakeclippedandlocked.Forsafety,whennotinuse,wrapthestraparoundtheframeandclipitin
theclosedpositiontoxtotheframe.
Cliptheendofthestrapbackontothetowbar“D”ring.
Removetheagandpoleandseparatethethreesections.
Removethequick-releasepinsformthestubaxlesoftherearwheels.
Removethequick-releasepinfromthetowbarbracketatthefrontcornerof
Foldthetowbarbackunderthetrailer,andreplacethequick-releasepinthrough
thetowbarandU-channel
Placewheelsandaginsidethepassengercompartment,andclosethefrontcover.
Folduppercabinasshownabove:
a.Remove4-seasonRaincover
b.RemoveQRpinfrombothsides.
c.Foldframedownasshown.
d.Foldinuntiltrailerisat
Storetrailerinacool,dryenvironment,awayfromdirectsunlight.Afterextended
periodsofstorage,checktiresforwearorcracking,andfabricandstrapping
forsignsofwear.Afterextendedperiodsofstorage,itisrecommendedthatthe
trailerisinspectedbyaqualiedbicyclemechanicpriortouse.
FIGURE22. FIGURE23. FIGURE24.
7
INSTRUCTIONAL
OWNER’S MANUAL
p
8
INSTALLINGTHEFRONTFORK
NOTE:
NOTE:
TheJoggerKitincludes:
Front fork
Front wheel
Handlebar
FIGURE25.
FIGURE26.
FIGURE29.
FIGURE30. FIGURE31.
FIGURE27.
RemoveQRpinsfromhitcharm,andfoldhitcharmbacktofoldedawayposition(Fig26).RettheQRpintoxthehitch
arm(Fig27).RemovetheQRpinfromtherightsidereceivertomakewayforforkinstallation.
STEP2:
STEP3:
WARNING!: Afterxingforkinplace,push,pullandtugtheforktomakesureitissecureandstable.Failuretox
theforkproperlycouldresultinfailureandseriousinjurytoyouoryourchild.
STEP 1:
Whenyouslidetheforktubeintothebracket,theslotwillengagewiththebolttoholditinplace.Whenfullyengaged,
theholeintheU-bracketwillalignwiththeholeintheforktube(Fig30).
First,takethejoggerfork,andinserttheslottedswagedtubeendsintotheU-shapedbracketsonthefrontoftheframe
(Fig29).YouwillnoticethereisaboltthroughtherearpartoftheU-channeloneachside.
Finishassembly,insertQRpinthroughtheU-bracket,andlockthepin(Fig31).
INSTRUCTIONAL
OWNER’S MANUAL
p
9
INSTALLINGJOGGERWHEEL
FIGURE32.
FIGURE35
FIGURE33.
FIGURE34.
STEP2:
STEP3:
STEP3:
WARNING!: FailuretoproperlyinstallandadjustwheelswithQuickReleaseleverscouldallowwheeltocomeoff
duringuse.Thiscouldleadtoseriousinjuryordeath.
STEP 1:
NOTE:
CAUTION:
NOTE:
Afteraligningthefrontwheelintheforkslots,slidethewheelallthewayintothe
front fork (Fig33).
Thefrontaxlehasaatareaonitthatyoumustalignwiththeslotsinthefront
fork(Fig32).
IMPORTANT:PLEASEFOLLOWINSTRUCTIONSFORQUICKRELEASELEVER
TheJoggingStrollerisequippedwithaQuickReleasefrontwheel.Placethe
Strollersotherearwheelsandhandlearetouchingtheoor.
YoucannottightentheQuickReleaseleverbymerelytwistingthelever.Youcan
onlyensureitislockedbyproperlytighteningthengernutandthenippingthe
QuickReleaseleverfrom“Open”to“Closed”
Ifjoggerfailstorollstraight,loosenQRleverandrepositionwheelinthefork
slotstocorrecttherealignthewheel,andthenretightentheQR.
Withthewheelinpositionandthequickreleaseleverinthe“Open”position,
tightenthengernutontheaxleuntilitisveryclosetocontactingthefork
(Fig34).
Movetheleverintothe“Closed”position.Youshouldfeelsignicantresis-
tancewhenclosingthelever.Ifyoudonot,opentheleverandtightenthe
ngernutabitmoreandclosetheleveragain.Continuetodothisuntilthe
movementoftheleverresultsintensionontheleverwhenclosingandthe
wheelistightintheframe(Fig35).
Whenyoucompletethewheelinstallationprocess,attempttopullwheel
fromframe;ifwheelmoves,tightenthengernutandrepeatthetest.
INSTRUCTIONAL
OWNER’S MANUAL
p
10
INSTALLINGJOGGERHANDLEBAR
FIGURE36.
NOTE: Thehandlebarattachestotherearofthetrailerframewithclamps,securedwithlargehandknobs.Toinstall,rstloosen
thehandknobstoopentheclampssufcientlytotovertheframe,Positionthehandlebaratacomfortableheight,and
retightenthehandknobs.
Reattachthetopcoverbeforeuse.Thecoverhascutoutstoallowusewiththehandlebarinplace.
WARNING!: Makecertainhandlebarislockedinplaceonframe.Ifthehandlebarislooseormovesontheframe,
relocateandtightenthehandknobssecurelypriortouse.Failuretoproperlyinstallthehandlebar
couldresultinseriousinjurytoyouoryourchild.Whenusingthejoggingstroller,alwaysusethe
safetywriststrap.
WARRANTY
IFYOURPRODUCTREQUIRESWARRANTYSERVICE,PLEASEDONOTRETURNITTORETAILSTORE.
PLEASE CONTACT:
ALLEN SPORTS USA
(800)722-5536~CUSTOMERSER[email protected]
Pleasenotethatallreturnsandexchangesaresubjecttothereturnpolicyoftheretailerwhere
theproductwasoriginallypurchased
R.A.ALLENCO.,INC.-505BEACHLANDBLVD.-STE.5-VEROBEACH,FL32963
ProductdesignedinUSA,MadeinNingbo,China
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10

Allen Sports SST1 Owner's manual

Allen Sports
Brand
Allen Sports
Model
SST1
Category
Car seat
Type
Owner's manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents