Aeg-Electrolux EBC GL60 Installation guide

Brand: Aeg-Electrolux

Model: EBC GL60

Category: Electric griddles

Type: Installation guide

TD_Classic_EBCGL60_0907_2_EN 5.8.2009 10:48 Uhr Seite 2

Probedruck

C M Y CM MY CY CMY K

The Electrolux Group.

EBC GL6

(55 cm)

EBC GL60

(60 cm)

SOS

892 9378 39_08/2009

Technical data/Problem solving

Customer service/Warranty

Safety instructions

Installations

This document is an integral part of the documentation for the

installation compact oven EBC GL 6/60

Safety instructions

This applicance meets the EC directives:

- 73/23/EWG Low voltage directive including amendment 90/683/EWG

- 89/336/EWG EMV directive including amendment 92/31/EWG

- 93/68/EWG CE identification directive

Customer service

4052 Basel

St. Jakob Turm

Birsstrasse 320B

3018 Bern

Morgenstrasse 131

1028 Préverenges

Le Trési 6

Zürich/Mägenwil

5506 Mägenwil

Industriestrasse 10

9000 St. Gallen

Zürcherstrasse 204 e

6020 Emmenbrücke

Seetalstrasse 11

7000 Chur

Comercialstrasse 19

6916 Grancia

Zona Industriale E

One number for all locations

- 044 405 81 11

Cooking advice/Sales

8048 Zürich

Badenerstrasse 587

- 0848 848 023

Replacement parts

sales

5506 Mägenwil

Industriestrasse 10

- 0848 848 111 http://www.electrolux.ch

Built-in Compact oven

Fan cooking, Grill

- ONLY use appliance once you have read and understood these instructions

- Only use for standard home cooking and roasting, in accordance with these instructions

- Only use when installed and in-house. Electric shocks, risk of injury!

- Keep these instructions safe for other persons using the oven

- Disregarding these instructions/safety instructions can result in this appliance

posing a danger

- After use check whether the appliance is switched off

- In the case of emergency immediately pull out the mains plug or

switch circuit breaker to OFF

- NEVER use for heating purposes or purposes other than those described

- NEVER use when defective or you suspect there are defects/damage

- Installation only by specialist while observing the installation instructions and

the local regulations

- Installation in combustible materia: Adhere to NIN2000 guidelines

and fire prevention act

- Install appliance at a suitable working height (eye level)

Dangerous voltage

- The power supply must comply with details on appliance. The appliance has to be

connected to power supply and protective earthing by a specialist as standard,

via mains plug or permantely connected via network circuit breaker

(all-pin 3 mm contact gap)

- The mains plug or circuit breaker must be within reach at ally times

Do not allow the cord to come into contact with the back of the appliance/hot parts

CAUTION!

f the appliance is used, the basic safety precautions

have to be complied with, in order to elimiate the risk of fire,

electric shock and injuries to persons

- Appliance parts become hot during use. Burn hazard!

- An oven that is switched off must not be used for storing hot, cold or

cooled meals. Moisture from the food can cause corrosion in the appliance.

- Only use supplied accessories and suitable, heat-resistant dishware,

observe manufacturer's instructions.

- In using alcoholic ingredients in the oven, highly inflammable gas can

emerge, Caution when opening the door, no flames, sparks, blaze nearby.

- Always grill with the oven door closed. Do not leave the appliance unattended

during operation. Keep children away. Window is especially hot; Burn hazard!

- Only handle hot cookware with oven gloves or thermo gloves

- People (including children) who, because of their physical, sensory or

mental capabilities or their inexperience or ignorance are not able to use

the device safely, should not use this device without supervision or

instruction by a responsible person.

- Caution when closing the oven door. Risk of catching parts of your

own body or someone else’s.

Caution when taking out grills/shelves with cooked food. The grills/shelves

can slide down when in a sloping position. Caution: Burn hazard

- Containers with hot liquid can tip if they hang over the edge of the grill.

Caution: Burn hazard

- Avoid overheating: Detrimental steam can develop, alcohol can ignite,

food can dry out and inflame

- Clean appliance and remove food residues regularly (hygiene,

Fire hazard, service life of appliance)

- Clean appliance and remove food residues regularly (hygiene,

Fire hazard, service life of appliance

- Switch off the oven after use. Disconnect the appliance from the mains

for long periods of non-use.

- Do not load, climb or sit on over door.

- Do not pull mains plug from power socket by the cable.

Do not touch mains plug/-socket with wet hands

- Always supervise when heating oil/fat, do not overheat -

it can become inflamed: Fire risk!

Extinguish fire with fire blanket or foam extinguisher

Do not use appliance in the case of defect or suspicion of defect,

immediatley disconnect from mains. Repair work to be carried out by

authorised customer service.

- Do not damage mains cable, e.g. jamming, sharp edges, heat etc.

Do not use appliance with defective mains cable, disconnect immediately.

ONLY have mains cable/plug and oven door replaced by customer service,

in order to avoid hazards

- Do not open oven housing. Oven doors must only be removed by service technician.

Risk of injury

- Always keep the oven clean (build up of odours)

- Clean inside carefully. Do not use sharp objects (Damage)

- Prior to cleaning, disconnect appliance from mains and leave to cool down!

- Before exchanging oven lamp disconnect appliance from mains, pull out mains

plug or disconnect the mains fuse

- Do not clean appliance with steam or high pressure device.

Do not use combustible cleaning agent

- If oven shelf runners are removed for cleaning, always ensure you reinstall them

correctly. Otherwise there is a risk of grills or shelves falling. Burn hazard

- For safety reasons only use original replacement parts and accessories

- Only use accessories recommended by the manufacturer and

oven-suited dishware

IMPORTANT! Please read carefully.

Important information concerning your personal safety and information on how to avoid damaging the appliance.

Page

- Adhere to national and regional regulations when disposing of range

- Packaging: Recyclable, the foil and the hard foam parts hav e been

labelled accordingly. Dispose of at a public waste-disposal site

- Range: Pull the out of power socket. Cut off mains cable.

Take appliance and mains cable to public waste-disposal site/

dealer or the official SENS collection points / recyclers. A list of

official collection points is available at www.sens.ch

The symbol on the product or its packaging indicates that this product

should not be treated as normal household waste, but must be left at a

collection point for the recycling of electrical and electronic appliances.

In correctly disposing of this product you are making a contribution to the

protection of the environment and the health of the rest of the population.

The environment and health are at danger through incorrect waste disposal.

TD_Classic_EBCGL60_0907_2_EN 5.8.2009 10:48 Uhr Seite 1

Probedruck

C M Y CM MY CY CMY K

231

40 cm

37,8 cm

20,5 cm

1. 2.

Change halogen lamp

, always handle

with cloth, to avoid fatty residues burning

Assembly in

reverse order

EBC GL60

Depth

EBC GL6

Width

59,254,8

Height

38,837,8

56,7 56,7

81,9 81,9

Depth when

door open

Warranty

For each product we issue a warranty of 2 years (display by letter of guarantee, invoice or sales document) to the end consumer from sale or

delivery date. The warranty covers the costs for materials, work and travel time, it is not applicable in the event of non observance of instructions

for use and operating regulations, improper installation and damage caused by external influences, force majeure, third party interferences

and use of non-original parts.

Before changing lamp, disconnect or unscrew fuses!

Changing Lamps

- Bakery volumen 31 l

Read label

Customer service needs this data

for all enquiries/orders!

Fan cooking (Rear wall

heating element): 1650 W

Exernal dimensions for:

Technical Data

According to model 2 glass recesses are visible on the left side of the front panel. These are conditional on production technique and

have no impact on quality and life span of the appliance.

Indications conditional of manufacture

Problem Solving

Problem Cause Solution

The oven is not working - Check fuses

- Mains plug connected?

Fault in the power supply

Improper work can result in damage to persons or property. If you cannot

remove interferences with these tips, please contact your customer

service (see page B).

- The oven is not getting hot even though the

mode of operation and temperature are

switched on

- Automatic programm with delayed

cooking start was set

Cancel automatic settings or reset

-> Clock functions see 5, operating instructions

Service-Symbol

light (Errorr-Code)

According to error

Notify customer service

Symbol time of day is flashing Power cut Set time of day -> see page 4, Instructions for use

- Heating element and fan are not working

Oven light is not working

Bulb is defective!

Exchange bulb -> see page B

- Possible that the demo mode is activated! Switch off

demo mode:

At the same time press until

the signal is audible

Switch off

Installation Instructions

Installation

WARNING: do not trap the cable!

When plugging in at the top, fasten

cable with the cable routing on the

left-hand side.

Push the oven into the recess Fix the oven on the both sides with

2 screws (detail A)

Place the appliance in front of the

recess and connect the mains plug.

During installation in combustible matter, NIN 2000, section 4.2.2 and fire protection guidelines and

regulations of the Association of Cantonal Fire Insurance shall be strictly adhered to.

Variants

If the compact oven is built in directly over the installation oven in combinations, this must be done with the enclosed support

bracket set no. 315 68 3900. Look at installation sheet no. 315 6837 00 for the installation standard.

EBC GL6 (55 cm, 230 V) EBC GL60 (60 cm, 230 V)

Details see safety instructions page C

Grill size: 1500 W

Turbo grill: 1500 W

Connection by means of a power socket shall be provided by the customer, so that the power socket is available and outside the range of coordination

1. Clamp connection as per the connection diagram

2. Secure the strain relief

The electro connection has to be carried out by a licensed fitter.

For a network connecting line, use line version H05VV-F or higher.

Installation has to be carried out using a supply line with plug or it shall be provided with a separator laid in the home installation with at

least 3 mm contact gap, which separates the equipment at the same time and all-pin, according to NIN 2000.

For servicing the appliance must be disconnected!

Electrical connection / supply

- Cable length: 2.50 m from appliance

- Plug: version 12

...

5…

Halogen lamp 25 W, 230 V -G9

constant up to 300 °C

-> Electro specialist dealer or central

replacement part service

Squared lamp cover

Remove griddle guide,

Unclip glass carefully!!

Subject to technical modifications.

cable routing

N 560-568

Page

Temperature in the oven compartment is measured according to an internationally applicable standard while appliance is empty.

Your own measurements can be inaccurate and are not suitable for verifying temperature accuracy.

TD_Classic_EBCGL60_0907_2_EN 5.8.2009 10:48 Uhr Seite 1

Probedruck

C M Y CM MY CY CMY K

231

40 cm

37,8 cm

20,5 cm

1. 2.

Change halogen lamp

, always handle

with cloth, to avoid fatty residues burning

Assembly in

reverse order

EBC GL60

Depth

EBC GL6

Width

59,254,8

Height

38,837,8

56,7 56,7

81,9 81,9

Depth when

door open

Warranty

For each product we issue a warranty of 2 years (display by letter of guarantee, invoice or sales document) to the end consumer from sale or

delivery date. The warranty covers the costs for materials, work and travel time, it is not applicable in the event of non observance of instructions

for use and operating regulations, improper installation and damage caused by external influences, force majeure, third party interferences

and use of non-original parts.

Before changing lamp, disconnect or unscrew fuses!

Changing Lamps

- Bakery volumen 31 l

Read label

Customer service needs this data

for all enquiries/orders!

Fan cooking (Rear wall

heating element): 1650 W

Exernal dimensions for:

Technical Data

According to model 2 glass recesses are visible on the left side of the front panel. These are conditional on production technique and

have no impact on quality and life span of the appliance.

Indications conditional of manufacture

Problem Solving

Problem Cause Solution

The oven is not working - Check fuses

- Mains plug connected?

Fault in the power supply

Improper work can result in damage to persons or property. If you cannot

remove interferences with these tips, please contact your customer

service (see page B).

- The oven is not getting hot even though the

mode of operation and temperature are

switched on

- Automatic programm with delayed

cooking start was set

Cancel automatic settings or reset

-> Clock functions see 5, operating instructions

Service-Symbol

light (Errorr-Code)

According to error

Notify customer service

Symbol time of day is flashing Power cut Set time of day -> see page 4, Instructions for use

- Heating element and fan are not working

Oven light is not working

Bulb is defective!

Exchange bulb -> see page B

- Possible that the demo mode is activated! Switch off

demo mode:

At the same time press until

the signal is audible

Switch off

Installation Instructions

Installation

WARNING: do not trap the cable!

When plugging in at the top, fasten

cable with the cable routing on the

left-hand side.

Push the oven into the recess Fix the oven on the both sides with

2 screws (detail A)

Place the appliance in front of the

recess and connect the mains plug.

During installation in combustible matter, NIN 2000, section 4.2.2 and fire protection guidelines and

regulations of the Association of Cantonal Fire Insurance shall be strictly adhered to.

Variants

If the compact oven is built in directly over the installation oven in combinations, this must be done with the enclosed support

bracket set no. 315 68 3900. Look at installation sheet no. 315 6837 00 for the installation standard.

EBC GL6 (55 cm, 230 V) EBC GL60 (60 cm, 230 V)

Details see safety instructions page C

Grill size: 1500 W

Turbo grill: 1500 W

Connection by means of a power socket shall be provided by the customer, so that the power socket is available and outside the range of coordination

1. Clamp connection as per the connection diagram

2. Secure the strain relief

The electro connection has to be carried out by a licensed fitter.

For a network connecting line, use line version H05VV-F or higher.

Installation has to be carried out using a supply line with plug or it shall be provided with a separator laid in the home installation with at

least 3 mm contact gap, which separates the equipment at the same time and all-pin, according to NIN 2000.

For servicing the appliance must be disconnected!

Electrical connection / supply

- Cable length: 2.50 m from appliance

- Plug: version 12

...

5…

Halogen lamp 25 W, 230 V -G9

constant up to 300 °C

-> Electro specialist dealer or central

replacement part service

Squared lamp cover

Remove griddle guide,

Unclip glass carefully!!

Subject to technical modifications.

cable routing

N 560-568

Page

Temperature in the oven compartment is measured according to an internationally applicable standard while appliance is empty.

Your own measurements can be inaccurate and are not suitable for verifying temperature accuracy.