Agri-Fab 45-03152 User manual

Agri-Fab
Brand
Agri-Fab
Model
45-03152
Category
Spreader
Type
User manual
FORM NO. 49456 (4/25/07)
BROADCAST SPREADER
ESPARCIDOR DE AMPLIO ALCANCE
ÉPANDEUR-AÉRATEUR À GRANDE PORTÉE
CAUTION:
Read Rules for
Safe Operation
and Instructions
Carefully
• Safety
• Operation
• Maintenance
• Parts
Model No.
Modelo No.
Modèle No.
45-03152
OWNERS MANUAL
MANUAL DEL USUARIO
NOTICE D’UTILISATION
• Seguridad
• Operación
• Mantenimiento
• Piezas de Repuesto
• Sécurité
• Utilisation
• Entretien
• Pièces de Rechange
ATTENTION:
Lire et suivre attentivement
les instructions et
consignes de sécurité de
cette notice.
PRECAUCION:
Lea cuidadosamente
los Procedimientos e
Instrucciones para la
Operación Segura de la
Máquina.
PRINTED IN USA
the fastest way to purchase parts
www.speedepart.com
™
2
Any power equipment can cause injury if operated improperly or if the user does not understand how to operate the equipment.
Exercise caution at all times when operating equipment.
• Read the towing vehicle owners manual and towing vehicle
safety rules. Know how to operate your tractor before using
the broadcast spreader attachment.
• Read the chemical label instructions and cautions for handling
and applying the chemicals purchased for spreading.
• Wear eye and hand protection when handling and when
applying lawn or garden chemicals.
• Never operate tractor and spreader attachment without wearing
substantial footwear, and do not allow anyone to ride or sit on
spreader attachment frame.
• Never allow children to operate the tractor or spreader
attachment, and do not allow adults to operate without proper
instructions.
• Alwaysbeginwiththetransmissioninrst(low)gearandwith
the engine at low speed, and gradually increase speed as
conditions permit. Maximum towing speed - 3 M.P.H.
• When towing broadcast spreader do not drive too close to a
creek or ditch and be alert for holes and other hazards which
could cause you to loose control of the broadcast spreader
and tractor.
• Before operating vehicle on any grade (hill) refer to the safety
rules in the vehicle owner's manual concerning safe operation
on slopes. Stay off steep slopes!
• Follow maintenance and lubrication instructions as outlined
in this manual.
• Lea el manual del usuario del vehículo de remolque y observe
las normas de seguridad para estos vehículos. Aprenda cómo
operar su tractor antes de usar el accesorio esparcidor o
distribuidor de fertilizantes, de amplio alcance.
• Lea las instrucciones de la etiqueta de las substancias
químicas y las precauciones de manejo y de aplicación de
las que compró para esparcir.
• Use protección para ojos y manos cuando maneje y cuando
aplique abonos químicos en el prado o jardín.
• Nunca opere el tractor y el accesorio esparcidor sin tener puesto
uncalzadosucientementefuerte,ynopermitaquenadie
maneje ni se siente en el marco del accesorio esparcidor.
• Nunca permita que los niños operen el tractor o el accesorio
esparcidor, y no permita tampoco que los adultos los operen
sin haber recibido instruccion adecuada.
• Empiece siempre con la transmisión en primera (bajo) y con el
motor a baja velocidad, y gradualmente aumente la velocidad
según lo permitan las condiciones. La máxima velocidad de
remolque es de 3 MPH (5 km/h).
• Cuando remolque el esparcidor de amplio alcance, no
conduzca demasiado cerca de arroyos o zanjas, y manténgase
alerta en cuanto a huecos u otros peligros que puedan ser
causa de que usted pierda el control del esparcidor de amplio
alcance y del tractor.
• Antes de operar el vehículo en cualquier pendiente ( o colina),
consulte las reglas de seguridad que aparecen en el manual
del usuario del vehículo, relativas a la forma segura de
operar en pendientes. ¡Manténgase alejado de pendientes
escarpadas!
• Observe las instrucciones de mantenimiento y lubricación,
según se describen en este manual.
Cualquier equipo movido por motor puede causar lesiones si se opera inadecuadamente o si el usuario no entiende cómo debe operarlo.
Manténgase atento y cauteloso siempre que opere el equipo.
PROCEDIMIENTOS PARA OPERACION SEGURA
• Lisez cette notice d’utilisation et les consignes de sécurité
avant de tenter d’assembler ou d’utiliser la remorque. Veillez
à bien connaître le fonctionnement du tracteur avant d’atteler
la remorque de l’épandeur.
• Lisez les instructions du produit chimique et les consignes de
sécuritéandemanipuleretrépandrelesproduitschimiques
achetésand’êtreutilisésavecl’épandeur.
• Portez des lunettes de protection et des gants lorsque vous
manipulez et utilisez des produits chimiques pour jardins et
gazons.
• Ne jamais conduire le tracteur et l’épandeur sans porter des
chaussures adéquates. Ne transportez jamais personne sur
l’attelage de l’épandeur.
• Ne laissez jamais d’enfants utiliser le tracteur ni la remorque
et ne laissez aucun adulte utiliser le tracteur ni la remorque
sans lui avoir fourni auparavant les instructions adéquates.
Tout appareil mécanique risque de provoquer des blessures si ce dernier n’est pas utilisé correctement ou si l’utilisateur ne sait pas
comment l’utiliser. Faites preuve de prudence à tout moment lorsque vous utilisez un appareil mécanique.
CONSIGNES DE SÉCURITÉ
• Commencez toujours en veillant à ce que le levier de la
transmission se trouve en première vitesse (réglage bas sur
«low») et augmentez petit à petit votre vitesse si les conditions
le permettent. Vitesse de remorquage maximum: 3 m.p.h.
(5 km/h).
• Tractez l’épandeur à basse vitesse sur terrain accidenté, toute
penteouàproximitédetoutruisseauoufosséand’éviter
qu’elle ne se renverse en cas de perte de contrôle du tracteur
et de l’épandeur.
• Avant d’utiliser le véhicule sur toute inclinaison (pente),
reportez-vous aux consignes de sécurité de la notice
d’utilisation concernant la conduite du véhicule sur toute pente
ou colline. Demeurez à l’écart de toute pente forte!
• Veuillezsuivrelesinstructionsd’entretienetdelubrication
gurantdanscettenotice.
RULES FOR SAFE OPERATION
Estesimboloindicaprecaucionesimportantesdeseguridad.Signica-Atencion!Su
seguridad esta en riesgo.
Look for this symbol to point out important safety precautions. It means - Attention! Become
alert! Your safety is involved.
Cesymboleindiquelesconsignesdesécuritéimportantes.Ilsignie:Attention!Soyez
vigilant! Votre sécurité en dépend.
3
REF. QTY. DESCRIPTION
A 4 Hex Bolt, 1/4 x 1-3/4"
B 4 Hex Bolt, 1/4 x 2"
C 1 Hitch Pin
D 8 Nut
E 1 Hair Cotter Pin, 1/8"
SHOWN FULL SIZE
CARTON CONTENTS
1. Spreader Assembly
2. Control Cable
3. Hitch Tube, R.H. (Right Hand)
4. Hitch Tube, L.H. (Left Hand)
5. Hitch Control Tube
6. Hitch Brackets (2)
1
3
4
5
6
2
CONTENIDO DE LA CAJA
1. Conjunto del Esparcidor
2. Cable de Control
3. Tubo de Enganche, R.H. (Mano Derecha)
4. Tubo de Enganche, L.H. (Mano Izquierda)
5. Tubo de Control de Enganche
6. Soportes de Enganche (2)
CONTENU DU CARTON
1. Épandeur
2. Câble de commande
3. Tube d’attelage (R.H. - droit)
4. Tube d’attelage (L.H - gauche)
5. Tube de commande de l’attelage
6.Supportdexationdel’attelage(2)
MUESTRA DE TAMAÑO COMPLETO
REF. CANT. DESCRIPCIÓN
A 4 Perno Hexagonal, 1/4 x 1-3/4"
B 4 Perno Hexagonal, 1/4 x 2"
C 1 Pasador de Enganche
D 8 Tuerca
E 1 Pasador de Horquilla, 1/8"
RÉF. QTÉ DESCRIPTION
A 4 Boulon hexagonal, 1/4 x 1 3/4 po.
B 4 Boulon hexagonal, 1/4 x 2 po.
C 1 Boulon d’attelage
D 8 Écrou
E 1 Goupille fendue, 1/8 po.
PIÈCES À L’ÉCHELLE
A
B
C
D
E
4
TOOLS REQUIRED FOR ASSEMBLY
(2) 7/16" Wrenches
1. Assemble vinyl caps onto the ends of the R.H. and L.H.
HitchTubes.Seegure1.
2. Assemble the R.H. Hitch Tube to the spreader frame
tube using two 1/4" x 2" hex bolts and 1/4" nuts. Do not
tighten yet.RepeatforL.H.HitchTube.Seegure1.
FIGURE 1
3. Assemble the Hitch Control Tube between the Hitch
Tubes using two 1/4" x 1-3/4" hex bolts and 1/4" nuts.
Tighten allboltsandnuts.Seegure2.
FIGURE 2
4. Assemble the Hitch Brackets to the Hitch Control Tube
using two 1/4" x 1-3/4" hex bolts and 1/4" nuts. Tighten.
Seegure3.
5. Assemble the hitch pin through the hitch brackets and
securewiththe1/8"haircotterpin.Seegure3.
6. Assemble the vinyl cap onto the Hitch Control Tube. See
gure4.
7. Assemble the Control Cable to the Hitch Control Tube
usingthecarriageboltandnylonwingnut.Seegure
4.
FIGURE 4
FIGURE 3
ASSEMBLY INSTRUCTIONS
1/4" x 2"
HEX BOLT
1/4" NUT
VINYL CAP
1/4" NUT
1/4" x 1-3/4"
HEX BOLT
1/4" NUT
1/4" x 1-3/4"
HEX BOLT
HAIR COTTER PIN
HITCH PIN
REMOVAL OF PARTS FROM CARTON
Remove all parts and hardware packages from the carton.
Lay out all parts and hardware and identify using the
illustrations on page 3.
CARRIAGE BOLT
NYLON
WING NUT
VINYL CAP
5
HOW TO USE YOUR SPREADER
ADJUSTING THE FLOW RATE SETTING
1. Loosen the wing nut that fastens the control to the
handle.
2. Slide the Adjustable stop to the desired setting and
retightenthewingnut.Seegure5.
OPERATION
APPLICATION TIPS
1. This unit will cover a 4 to 8 foot wide area depending
on the material used and the towing speed.
2. To avoid misses or striping, make each pass about 5 feet
from the previous one so some overlapping of spread
pattern does occur.
3. For easiest application, spread across the shortest
edges oflawn rst, making two"header" stripsfora
turning area, and then spreading between the header
strips.Seegure6.
4. If lawn is odd shaped, spread a border around the edges
andthenspreadbetweentheborder.Seegure6.
5. Keep wheel approximately 4 feet from any area you do
not wish to spread.
IMPORTANT: Be careful when using spreader around
ornamental plants because weed control chemicals can
damage these plants.
USING YOUR SPREADER
1. Check the material package and the Spreader Settings
sheet included with your spreader for the proper spreader
setting and application rate.
2. Before lling spreader, move the control lever to the
"OFF" position.
3. Movespreaderontoaatsurface-eitherawalkora
driveway-andll.
4. Slide the Adjustable Stop to the desired setting.
5. Start the spreader in motion, then move the control
lever forward against the adjustable stop to begin
spreading.
6. Maximum towing speed - 3 M.P.H.
NOTE: Always place control lever in the "OFF" position while
llingspreader and whenstopping or turning, to prevent
release of excess fertilizer.
FIGURE 6
FIGURE 5
CHECK FOR LOOSE FASTENERS
1. Make a thorough visual check of the Spreader for any
bolts and nuts which may have loosened. Retighten any
loose bolts and nuts.
LUBRICATION
1. Apply a few drops of oil to all moving parts.
CLEANING
1. Always empty spreader after each use, storing leftover
material in it's original bag.
2. Wash the spreader and dry thoroughly after each
use.
STORAGE
1. Empty and clean the hopper as instructed in maintenance
section.
2. Store in a clean, dry area.
MAINTENANCE & STORAGE
FLOW CONTROL LEVER
ADJUSTABLE STOP
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
10
1 47994BLK 1 Hopper
2 49085 1 Frame Tube
3 49087 1 Hitch Tube (LH)
4 49088 1 Hitch Tube (RH)
5 49091 1 Hitch Control Tube
6 43648 2 Hex Bolt, 1/4-20 x 1-1/2"
7 1509-69 4 Hex Bolt, 1/4-20 x 1-3/4"
8 47189 10 Nylock Nut, 1/4-20
9 43088 2 Washer, 1/4 Std
10 45165 1 Carriage Bolt 1/4-20 x 2"
11 47141 1 Nylon Wing Nut 1/4-20
12 47983 1 Flow Slide
13 49820 1 Control Cable Asembly
(includes items 10 & 11)
14 46503 1 Wheel
15 48865 1 Drive Wheel
16 44663 2 Hub Cap (Push Nut)
17 49082 1 Axle
18 47851 2 Spacer
19 49084 1 Gearbox
20 47124 1 Impeller
21 47963 2 Hex Flange Bearing
22 24446 2 Hitch Bracket
23 47623 1 Hitch Pin
24 46699 4 Hex Bolt, 1/4-20 x 2"
25 44481 3 Vinyl Cap
26 48934 1 Hairpin, Agitator
27 43343 1 Hairpin, Cotter
49456 1 Owners Manual
REPAIR PARTS FOR MODEL 45-03152
REF. PART QTY. DESCRIPTION
NO. NO.
REF. PART QTY. DESCRIPTION
NO. NO.
the fastest way to purchase parts
www.speedepart.com
1
26
6
2
4
3
5
12
15
14
16
18
19
20
21
22
22
25
27
23
8
9
8
24
7
8
7
8
13
10
11
25
25
17
Page is loading ...
the fastest way to purchase parts
www.speedepart.com
REPAIR PARTS
Agri-Fab, Inc.
809 South Hamilton
Sullivan, IL. 61951
217-728-8388
www.agri-fab.com
© 2004 Agri-Fab, Inc.
This document (or manual) is protected under the U.S. Copyright Laws and the copyright laws of foreign countries,
pursuant to the Universal Copyright Convention and the Berne convention. No part of this document may be reproduced
or transmitted in any form or by an means, electronic or mechanical, including photocopying or recording, or by any
information storage or retrieval system, without the express written permission of Agri-Fab, Inc. Unauthorized uses and/or
reproductions of this manual will subject such unauthorized user to civil and criminal penalties as provided by the United
States Copyright Laws.
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12

Agri-Fab 45-03152 User manual

Agri-Fab
Brand
Agri-Fab
Model
45-03152
Category
Spreader
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages

Related papers

Other documents