White Mountain Hearth Madison Premium Clean-Face Gas Conversion LP to NAT Owner's manual

Brand: White Mountain Hearth

Model: Madison Premium Clean-Face Gas Conversion LP to NAT

Type: Owner's manual

This manual is also suitable for

Tahoe Premium Clean-Face Gas Conversion LP to NAT

37113-1-1019 Page 1Empire Comfort Systems Inc. • Belleville, IL

GAS CONVERSION KIT

INSTALLATION INSTRUCTIONS

FOR CONVERSION TO PROPANE (LP) GAS

WARNING

This conversion kit is to be installed by an Empire Comfort Systems, Inc., distributor (or other

qualied agency¹)*in accordance with the manufacturer’s instructions and all codes and

requirements of the authority having jurisdiction. Failure to follow instructions could result

in serious injury or property damage. The qualied agency performing this work assumes

responsibility for this conversion.

1National Fuel Gas Code Z223.1 (Latest Edition)

*The term “qualied individual, rm, corporation or company which either in person or through

a representative is engaged in and is responsible for (a) the installation of gas piping or (b)

the connection, installation repair, or servicing of equipment, who is experienced in such

work, familiar with all precautions required, and has complied with all the requirements of the

authority having jurisdiction.

CHECK SAFETY SHUTDOWN PERFORMANCE

WARNING

Perform the safety shutdown test anytime work is done on a gas system to avoid the possibility

of re or explosion with property damage, personal injury or loss of life.

SAFETY SHUTDOWN SYSTEM

Continuous Ignition Systems (Standing Pilot)

1. Place gas control knob in PILOT position. Main burner should go off and pilot should remain lit.

2. Extinguishpilotame.Pilotgasowshouldstopwithin30seconds.Safetyshut-offofpilotgasprovescomplete

shutdownsincesafetyshut-offvalveblocksowofgastomainburnerandpilot.

3. Relightpilotburnerandoperatesystemthroughonecompletecycletomakesureallcontrolsoperateproperly.

Intermittent Ignition Systems (Intermittent Pilot)

100%Shut-OffIPSecondLockout

DIRECT VENT GAS FIREPLACE CONVERSION KITS

DVCP36(PP,SP)30-1 CONVERSION KIT DVCP36(PP,SP)70-1 CONVERSION KIT

PartNumber35395 PartNumber35397

FOR CONVERSION TO NATURAL GAS

37113-1-1019Page 2 Empire Comfort Systems Inc. • Belleville, IL

PARTS LIST

PART DESCRIPTION CONVERSION KIT - 35395 CONVERSION KIT - 35397 QUANTITY SUPPLIED

PilotOrice R7659 R10425 1

MainBurnerOrice P244 P244 1

NG Flue Restrictor

34054 34054 1

SITGasValveConversionKit

R7656 R11168 1

GasConversionLabel 2139 2139 1

Tools Needed:StandardScrewdriver,1/4"HexDriver,5/16"HexDriver,3/8"and1/2"Wrenches

Gas input for direct vent replace insert converted to Natural Gas:

• DVCP36(PP,SP)3034,000Btuperhour

• DVCP36(PP,SP)7034,000Btuperhour

ThedirectventgasreplacewhenconvertedtoNaturalGaswillhaveamanifoldpressureapproximately3.5"w.c.

(.871kPa)foramaximuminputor1.7"w.c.(.423kPa)foraminimuminputatthevalveoutletwiththeinletpressuretothe

valvefromaminimumof5.0"w.c.(1.244kPa)forthepurposeofinputadjustmenttoamaximumof10.5"w.c.(2.61kPa).

INSTRUCTIONS FOR CONVERSION

1. Ifthereplaceinsertisinstalled,turnOFFgasandelectricsupplytoreplacebeforemakinggasconversion.

2. Removeaccesspanelbelowglass;liftandpullawayfromreplace.

3. Releasethetwoglassframespringclampsbeneathoneofthetwoglassframes.

4. Removetheglassframeandscreenframeasanassembly.

5. Removelogsfromburnerassembly.

6. Removethetenscrewsaroundtheburnerperimeter,andremovethefalseoorfromtheburnerassembly.

7. Removethefourscrewsretainingtheburnertotheburnerbase,andremoveburner.

8. RemovePropaneGasmainburneroricefromoricetting.

9. InstallNaturalGasmainburneroriceintooricetting:

• forDVCP36(PP,SP)30,OriceisMARKED #33

• forDVCP36(PP,SP)70,OriceisMARKED #33

10. Pullupwardonpilothoodtoremoveandgainaccesstopilotinjectororice.

11. RemovePropaneGaspilotinjectororicefrompilotburnerwith5/32"hex(Allen)wrench.

12. InsertIncludedNaturalGaspilotinjectororiceintopilotburnerusinga5/32"hexwrench.

13. Re-installpilothoodtopilotassembly.Pushdownwardtosnapinplace.

14. ForDVCP36(PP,SP)30only,convertgasvalveasinstructedinS.I.T.NaturalGasValveConversionKit.

15.

ForDVCP36(PP,SP)70only,removePropaneGasvalvefrommanifoldpipeandreplacewithincludedNaturalGasvalve.

16. Adjustairshuttersettingto3/16”open(1/8”with40ft.verticalvent).

17. Replacetheburnerassemblyontotheburnerbase.

18. Replacethefalseoortotheburner.

19. Forverticallyventedinstallationsonly,replacetheuerestrictorwithincludedNaturalGasuerestrictor.

20. Replacelogset.

21. Replaceglassandscreenframes,andloweraccesspanel.

22.

Theconvertedreplacemustbeconnectedtoasupplyoftheconversiongasandcheckedforleaksatallconnections.

White Mountain Hearth Madison Premium Clean-Face Gas Conversion LP to NAT Owner's manual

Brand: White Mountain Hearth

Model: Madison Premium Clean-Face Gas Conversion LP to NAT

Type: Owner's manual

This manual is also suitable for

Tahoe Premium Clean-Face Gas Conversion LP to NAT

Download PDF

report

White Mountain Hearth Madison Premium Clean-Face Gas Conversion LP to NAT Owner's manual

This manual is also suitable for

White Mountain Hearth Madison Premium Clean-Face Gas Conversion LP to NAT Owner's manual

Related papers

Other documents