NOTE:
Please read all instructions
carefully before using this
product
Table of Contents
Safety Notice
Hardware Identifier
Assembly Instruction
Parts List
Warranty
Ordering Parts
Model
SB-685
Retain This
Manual for
Reference
07-08-08
OWNER'S
MANUAL
MARCY UTILITY BENCH
SB-685
IMPEX
®
INC.
14777 DON JULIAN RD., CITY OF INDUSTRY, CA 91746
Tel: (800) 999-8899 Fax: (626) 961-9966
www.impex-fitness.com
TABLE OF CONTENTS
BEFORE YOU BEGIN..................................................................................... 1
IMPORTANT SAFETY NOTICES.................................................................... 2
HARDWARE PACK….......…...........................................……………………… 4
ASSEMBLY INSTRUCTIONS..........................................……………………… 5
EXPLODED DIAGRAM…………………………………………………………….. 8
PARTS LIST………..………………………………………………………………. 9
WARRANTY.................................................................................................… 10
ORDERING PARTS......................................................................................... 10
BEFORE YOU BEGIN
Thank you for selecting the MARCY Utility Bench SB-685 by IMPEX
®
INC. For
your safety and benefit, read this manual carefully before using the machine.
As a manufacturer, we are committed to provide you complete customer
satisfaction. If you have any questions, or find there are missing or damaged
parts, we guarantee you complete satisfaction through direct assistance from
our factory. To avoid unnecessary delays, please call our TOLL-FREE
customer service number. Our Customer Service Agents will provide immediate
assistance to you.
1
Toll-Free Customer Service Number
1-800-999-8899
Mon. - Fri. 9 a.m. - 5 p.m. PST
www.impex-fitness.com
IMPORTANT SAFETY NOTICE
PRECAUTIONS
This exercise machine is built for optimum safety. However, certain precautions apply
whenever you operate a piece of exercise equipment. Be sure to read the entire manual
before you assemble or operate your machine. In particular, note the following safety
precautions:
1. Keep children and pets away from the machine at all times. DO NOT
leave children unattended in the same room with the machine.
2. Only one person at a time should use the machine.
3. If the user experiences dizziness, nausea, chest pain, or any other abnormal
symptoms, STOP the workout at once. CONSULT A PHYSICIAN IMMEDIATELY.
4. Position the machine on a clear, leveled surface. DO NOT use the machine
near water or outdoors.
5. Keep hands away from all moving parts.
6. Always wear appropriate workout clothing when exercising. DO NOT wear
robes or other clothing that could become caught in the machine. Running
or aerobic shoes are also required when using the machine.
7. Use the machine only for its intended use as described in this manual. DO
NOT use attachments not recommended by the manufacturer.
8. Do not place any sharp object around the machine.
9. Disabled person should not use the machine without a qualified person or
physician in attendance.
10. Before using the machine to exercise, always do stretching exercises to
properly warm up.
11. Never operate the machine if the machine is not functioning properly.
CARE AND MAINTENANCE
1. Lubricate moving parts with WD-40 or light oil periodically.
2. Inspect and tighten all parts before using the machine.
3. The machine can be cleaned using a damp cloth and mild non-abrasive detergent.
DO NOT use solvents.
4. Maximum user’s weight: 300 lbs.
WARNING: BEFORE BEGINNING ANY EXERCISE PROGRAM, CONSULT YOUR
PHYSICIAN. THIS IS ESPECIALLY IMPORTANT FOR INDIVIDUALS OVER THE AGE
OF 35 OR PERSONS WITH PRE-EXISTING HEALTH PROBLEMS. READ ALL
INSTRUCTIONS BEFORE USING ANY FITNESS EQUIPMENT. IMPEX INC.
ASSUMES NO RESPONSIBILITY FOR PERSONAL INJURY OR PROPERTY
DAMAGE SUSTAINED BY OR THROUGH THE USE OF THIS PRODUCT.
SAVE THESE INSTRUCTIONS.
2
WARNING LABEL PLACEMENT
The warning label shown here has been placed on the Rear Stabilizer. If the label is missing or
illegible, please call customer service at 1-800-888-8899 for replacements. Apply the label in the
location shown.
3
HARDWARE PACK
NOTE: The following parts are not drawn to scale. Please use your own ruler or scale to measure the size.
4
ASSEMBLY INSTRUCTION
Tools Required for Assembling the Machine: Two Adjustable Wrenches and Allen
Wrenches. NOTE: It is strongly recommended that two or more people assemble this
machine to avoid possible injury.
STEP 1 (See Diagram 1)
A.) Attach the Main Seat Support (#1) onto the Front Post (#2). Secure it with two M10 x 2 ¾”
Carriage Bolts (#21), one 5 1/8” x 2 ¾” Bracket (#13), two Ø ¾” Washers (#31), and two M10
Aircraft Nuts (#28). Do not tighten the Nuts and Bolts yet.
B.) Attach the Main Seat Support to the Rear Stabilizer (#4). Secure it with two M10 x 3 5/8”
Carriage Bolts (#22), one 5 1/8” x 2” Bracket (#14), two Ø ¾” Washers (#31), and two M10
Aircraft Nuts (#29).
C.) Securely tighten all Nuts and Bolts.
D.) Attach the Leg Support (#3) to the Front Post. Secure it with two M10 x 2 ¾” Carriage Bolts
(#21), one 4 3/8” x 2 ¾” Bracket (#12), two Ø ¾” Washers (#31), and two M10 Aircraft Nuts
(#29).
DIAGRAM 1
5
STEP 2 (See Diagram 2)
A.) Align the bracket on the Backrest Adjustment Support (#5) in between the two
Backrest Supports (#7). Secure it with four M8 x 1 5/8” Allen Bolts (#25), eight Ø 5/8”
Washers (#32), and four M8 Aircraft Nuts (#28). Do not tighten the Nuts and Bolts
yet.
B.) Insert the Backrest Adjustment Support into the opening on the Main Seat Support
(#1). Press or step down on the Backrest Adjustment Lever (#8) to allow the Support
to go through.
C.) Attach the bottom side-holes on the two Backrest Supports to the pivot on the Main
Seat Support(#1). Secure it with one M12 x 6 ½” Hex Bolt (#27), two Ø 1” Washers
(#33), and one M12 Aircraft Nut (#30). Securely tighten all Nuts and Bolts.
D.) Attach the two Seat Brackets (#6) to the Main Seat Support(#1). Secure each Seat
Bracket with two M10 x 3 5/8” Allen Bolt (#23), four Ø ¾” Washers (#31), and two
M10 Aircraft Nuts (#29).
DIAGRAM 2
6
STEP 3 (See Diagram 3)
A.) Place the Seat Pad (#10) onto the two Seat Brackets (#6). Secure it with four M8 x 1 5/8” Allen
Bolts (#25) and four Ø 5/8” Washers (#32).
B.) Attach the Backrest Board (#9) to the two Backrest Supports (#7). Secure it with four M8 x 1
5/8” Allen Bolts (#25) and four Ø 5/8” Washers (#32).
C.) When adjusting the Backrest Board to an incline position, simply pull up the Board. When
adjusting the Board to a decline position, press or step down on the Backrest Adjustment Lever
(#8) to disengage the Lever to allow the Board to go down.
DIAGRAM 3
7
EXPLODED DIAGRAM
8
PARTS LIST
KEY NO. DESCRIPTION Q’ty
1 Main Seat Support 1
2 Front Post 1
3 Leg Support 1
4 Rear Stabilizer 1
5 Backrest Adjustment Support 1
6 Seat Bracket 2
7 Backrest Support 2
8 Backrest Adjustment Lever 1
9 Backrest Board 1
10 Seat Pad 1
11 Foam Tube 1
12 4 3/8” x 2 ¾” Bracket 1
13 5 1/8” x 2 ¾” Bracket 1
14 5 1/8” x 2” Bracket 1
15 Foam Roll 2
16 Foam Roll End Cap 2
17 Wheel 2
18 1” Square End Cap 6
19 2” End Cap 1
20 2” x 2 ¾” End Cap” 1
21 M10 x 2 ¾” Carriage Bolt 4
22 M10 x 3 5/8” Carriage Bolt 2
23 M10 x 3 5/8” Allen Bolt 2
24 M8 x 1 ¾” Allen Bolt 2
25 M8 x 1 5/8” Allen Bolt 12
26 M10 x 2 ½” Allen Bolt 1
27 M12 x 6 ½” Hex Bolt 1
28 M8 Aircraft Nut 6
29 M10 Aircraft Nut 9
30 M12 Aircraft Nut 1
31 Ø ¾” Washer 12
32 Ø 5/8” Washer 20
33 Ø 1” Washer 2
34 Spring 1
35 Lever Cover 1
#6 Allen Wrench (Tool) 1
#5 Allen Wrench (Tool) 1
9
IMPEX
®
INC.
LIMITED WARRANTY
IMPEX Inc. ("IMPEX
®
") warrants this product to be free from defects in workmanship and material, under normal
use and service conditions, for a period of two years on the Frame from the date of purchase. This warranty
extends only to the original purchaser. IMPEX's obligation under this Warranty is limited to replacing or
repairing, at IMPEX's option.
All returns must be pre-authorized by IMPEX. Pre-authorization may be obtained by calling IMPEX Customer
Service Department at 1-800-999-8899. All freights on products returned to IMPEX must be prepaid by the
customer. This warranty does not extend to any product or damage to a product caused by or attributable to
freight damage, abuse, misuse, improper or abnormal usage or repairs not provided by an IMPEX authorized
service center or for products used for commercial or rental purposes. No other warranty beyond that specifically
set forth above is authorized by IMPEX.
IMPEX is not responsible or liable for indirect, special or consequential damages arising out of or in connection
with the use or performance of the product or other damages with respect to any economic loss, loss of property,
loss of revenues or profits, loss of enjoyments or use, costs of removal, installation or other consequential
damages or whatsoever natures. Some states do not allow the exclusion or limitation of incidental or
consequential damages. Accordingly, the above limitation may not apply to you.
The warranty extended hereunder is in lieu of any and all other warranties and any implied warranties of
merchantability or fitness for a particular purpose is limited in its scope and duration to the terms set forth herein.
Some states do not allow limitations on how long an implied warranty lasts. Accordingly, the above limitation
may not apply to you.
This warranty gives you specific legal right. You may also have other rights which vary from state to state.
Register on-line at www.impex-fitness.com
IMPEX
®
INC.
14777 Don Julian
City of Industry, CA 91746
ORDERING REPLACEMENT PARTS
Replacement parts can be ordered by calling our Customer Service Department toll-free at 1-800-999-8899
during our regular business hours: Monday through Friday, 9 am until 5 pm Pacific standard time.
info@impex-fitness.com
When ordering replacement parts, always give the following information.
1. Model
2. Description of Parts
3. Part Number
4. Date of Purchase
10
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
Impex Marcy SB-685 User manual
- Type
- User manual
- This manual is also suitable for
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI