Swisher LS11534 User manual

ReadandfollowallSafety

PrecautionsandInstructions

beforeoperatingthis

equipment.

LOG

SPLITTER

OWNER’S

MANUAL

1602CORPORATEDRIVE,WARRENSBURG,MISSOURI64093PHONE660-747-8183

FAX660-747-8650

MODELNO.

LS622

LS67525

LS928

LS11534

LS12534D

Manufacturingqualitylawncareequipmentsince1945

Safety

Assembly

Operation

ServiceandAdjustment

RepairParts

MadeInThe

USA

IMPORTANT

swisherinc.com

10032

Rev.04-303

2

Intheeventyouhaveaclaimunderthiswarranty,youmustreturntheproducttoanauthorizedservicedealer.

Alltransportationcharges,damage,orlossincurredduringtransportationofpartssubmittedforreplacementor

repairunderthis warrantyshallbe bornebythe purchaser.Should youhaveany questions concerningthis

warranty,pleasecontactustoll-freeat1-800-222-8183.Themodelnumber,serialnumber,dateofpurchase,

andthenameoftheauthorizedSwisherdealerfromwhomyoupurchasedthemowerwillbeneededbeforeany

warrantyclaimcanbeprocessed.

THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL

DAMAGESANDANYIMPLIEDWARRANTIESARELIMITEDTOTHESAMETIMEPERIODS

STATEDHEREINFORALLEXPRESSEDWARRANTIES.Somestatesdonotallowthelimitationof

consequentialdamagesorlimitationsonhowlonganimpliedwarrantymaylast,sotheabovelimitationsor

exclusionsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrightsandyoumayhaveotherrights,

whichvaryfromstate-to-state.ThisisalimitedwarrantyasdefinedbytheMagnuson-MossActof1975.

LIMITEDWARRANTY

Themanufacturer’swarrantytotheoriginalconsumerpurchaseris:Thisproductisfreefromdefectsin

materialsandworkmanshipforaperiodoftwo(2)yearfromthe dateofpurchasebytheoriginalconsumer

purchaser.Wewillrepairorreplace,atourdiscretion,partsfoundtobedefectiveduetomaterialsor

workmanship.Thiswarrantyissubjecttothefollowinglimitationsandexclusions:

TABLEOFCONTENTS

WARRANTY………………....….2

SAFETY..……………………….3-4

TOWING..….……..……………..5

OPERATION……………………6-8

MAINTENANCE.…………………….8-9

DECALS…..………….……………….10

PARTSBREAKDOWN…………….11-18

SPECIFICATIONS..…………………23

1) EngineWarranty Allenginesutilizedonourproductshaveaseparatewarrantyextended

tothembytheindividualenginemanufacturer.Anyengineservice

difficultyistheresponsibilityoftheenginemanufacturerandinno

wayisSwisherMowerCo.,Inc.oritsagentsresponsibleforthe engine

warranty.TheBriggs&StrattonEngineServiceHot-Lineis1-800-

233-3723.TheTecumsehEngineServiceHot-Lineis1-800-558-5402.

2) CommercialUse Thewarrantyperiodforanyproductusedforcommercialorrentalis

limitedtoninety(90)daysfromthedateoforiginalpurchase.

3) Limitation Thiswarrantyappliesonlytoproductswhichhavebeenproperly

assembled,adjusted,andoperatedinaccordancewiththeinstructions

containedwithinthismanual.Thiswarrantydoesnotapplytoany

productofSwisherMowerCo.,Inc.,thathasbeensubjecttoalteration,

misuse,abuse,improperassemblyorinstallation,shippingdamage,or

tonormalwearofproduct.

4) Exclusions Excludedfromthiswarrantyarenormalwear,normaladjustments, and

normalmaintenance.Thepump,valve,andcylindereachcarryseparate

manufacture’swarranties.Thevalveandcylinderbothcarryaone(1)year

limitedwarranty.Thepumpcarriesatwo(2)yearlimitedwarranty.

SAFETYPRECAUTIONS



WARNING:Theengineexhaustfromthisproductcontainschemicalsknowntothestateof

Californiatocausecancer,birthdefectsorotherreproductiveharm.



DANGER:Yourlogsplitterwasbuilttobeoperatedaccordingtotherulesforsafeoperationin

thismanual.Aswithanytypeofpowerequipment,carelessnessorerroronthepartofthe

operatorcanresultinseriousinjury.Ifyouviolateanyoftheserules,youmaycauseserious

injurytoyourselforothers.



• Readthemanual.Learntooperatethisequipmentinasafemanner.



• Donotunderanycircumstancesalterthislogsplitter.Thisequipmentwasdesignedand

engineeredinaccordancewithoperatinginstructions.Alteringthisequipment,orusing

thisequipmentinsuchawayastocircumventitsdesigncapabilitiesandcapacities,could

resultinseriousinjuryorfatalityandWILLVOIDTHEWARRANTY.



• Allowonlyresponsibleadultswhohavereadthismanualtooperatethismachine.Never

allowchildrentooperatethismachine.



• Neverusesplitterforanyotherpurposethansplittingwood.Anyotherusecanresultin

injury.Yoursplitterisaprecisionpieceofpowerequipment,notatoy.Therefore,

exerciseextremecautionatalltimes.



• Onlyasingleoperatoristoloadandoperatethelogsplitter.Keepallothers,including

petsandchildren,aminimumof20feetawayfromyourworkarea.Moreaccidents

occurwhenmorethanonepersonoperatesthelogsplitterthananyothertime.



• Alwaysdisconnectthesparkplugwireandplacethewirewhereitcannotcontactthe

sparkplug,topreventaccidentalstartingtheenginewhensettingup,transporting,

adjustingorrepairing.



• Alwayswearprotectivegearsuchassafetygoggles,protectivehearingdevice,steel-toed

shoes,andtight-fittinggloveswithoutdrawstringsorloosecuffs.



• Neverwearlooseclothingorjewelrythatcanbecaughtbymovingpartsofthesplitter

andpullyouintoit.Keephairawayfrommovingparts.



• Familiarizeyourselfwithallofthecontrolsinasafeenvironmentbeforestartingtowork

withthismachine.



ThisSafetyAlertSymbolindicatesimportantmessagesinthismanual.

Whenyouseethissymbol,carefullyreadthemessagethatfollowsandbe

alerttothepossibilityofpersonalinjury.

Readthismanualcompletely.Thismachinecanamputatehands,feet,andthrowobjects.

Failuretoobservethefollowingsafetyinstructionscouldresultinseriousinjuryordeath.

3

Fluidescapingfromaverysmallholecanbealmostinvisible.Donotcheckforleakswithyour

hand.Escapingfluidunderpressurecanhavesufficientforcetopenetrateskin,causingserious

personalinjury.Leakscanbelocatedbypassingapieceof

cardboardorwoodoverthesuspected

leakandlookingfordiscoloration.IFinjuredbyescapingfluid,seeadoctoratonce.Serious

infectionorreactioncandevelopifpropermedicaltreatmentisnotadministered

immediately.



• Splitonlyonelogatatime.Neverattempttosplittwologsontopofeachother.



• Donotstraddleorreachacrossthesplittingareawhileoperatingthesplitter.



• Donotstepoversplitterwhentheengineisrunning.Youmaytriporaccidentally

activatethesplittingwedge.Walkaroundtogettotheotherside.



•

Neverplacehandsorfeetbetweenlogandsplittingwedgeorbetweenlogandramduring

forwardorreversestroke.



• Neverattempttoloadsplitterwhilesplittingwedgeisinmotion.Whenloadinglog

splitter,placehandsonthesidesofthelog,nottheends.



• Onlyuseyourhandstooperatethecontrollever.Neverusefoot,knee,ropeorany

extensiondevice.



• Alwayskeepfingersclearofsplitsthatopeninlogduringsplitteroperation.



• Whensplitterisinthereturnmode,keephandsoffthemachine.



•

Onlyoperatesplitteronlevelground,notonthesideofahill.Itcouldtiporrollinglogs,

poorfooting,etc.couldcauseanaccident.



• Neveroperateorallowsomeonetooperatethisequipmentwhileundertheinfluenceof

alcoholordrugs.



• Alwaysblockthewheelstopreventmovementwhileusingsplitter.



• Neveroperateyoursplitteronwet,muddy,oricysurfaces.Safefootingisessentialin

preventingaccidents.



• Neveroperateyoursplitterwhileitisattachedtothetowvehicle.



• Nevermakeadjustmentsorrepairswiththeenginerunning.



• Neverattempttosplitwoodsacrossthegrain.Sometypesofwoodmayburstorflyout

ofyoursplitterandresultininjury.



• Bothendsofthelogshouldbecutassquarelyaspossibletopreventthelogfromsliding

outofthesplitterduringoperation.Loglengthshouldbekeptto24”orless.



4



TOWINGSAFETY



•

Donotallowpersonstorideonsplitter.Donotcarryanycargoorwoodonyour

splitter.Itmayfalloffandendangervehiclesthatarefollowingyou.



•

Besurejackstandisinthetravelpositionandcouplingsecure.Thismustalsobe

retractedsonottointerferewhiletowing.Retractkickstandbyremovingpin,

rotatingup,andreplacingpin.



• Neverexceed45MPHwhiletowingyoursplitter.Beextracautiouswhen

travelingoverroughterrain,especiallyoverrailroadtracks.



•

Alwaysbecarefulwhilebackingyoursplitter.Youcouldjackknifeyourlog

splitterifnotcareful.



•

Beforeusingsplitter,disconnectitfromtowvehicle.Alogcouldeasilybe

pushedforwardintothevehicle.



•

SeetireandwheelspecificationsforPSIwhiletowing.



• Beawareoftheextralengthofsplitterwhileturning,parking,crossing

intersections,andinalldrivingsituations.



•



OPERATIONINSTRUCTIONS

POSI-LOCKCOUPLER

ADJUSTCOUPLERLOCKINGPRESSUREONBALLBEFOREUSE.PLACEHANDLEINLOCKED

POSITIONWITHBALLINCOUPLER.TIGHTENLOCKNUTAGAINSTTENSIONSPRINGSOTHAT

COUPLERISNOTLOOSEONBALL.CORRECTADJUSTMENTWILLALLOWHANDLETOBE

RELEASEDWITHMODERATEPRESSUREAPPLIEDTOHANDLE.



TOOPEN,PULLUPONCOUPLERHANDLEANDROTATEFORWARD.PLACECOUPLERONBALL

WHENBALLISCOMPLETELYNESTEDINBALLSOCKET,ROTATECOUPLERHANDLE

BACKWARDUNTILHANDLEISINLOCKEDPOSITION.



AFTERTOWINGFOR50MILES,CHECKCOUPLERFORTIGHTNESSONBALL.ALWAYSCHECK

TIGHTNESSBEFORETOWING.BESURECOUPLERHANDLEISINLOCKEDPOSITION.



WARNING:

NEVEREXCEEDWEIGHTCAPACITYANDALWAYSUSESAFETYCHAINS.ALWAYSUSE

CORRECTBALLSIZE,MAKINGSUREBALLISCOMPLETELYINSERTEDINTOCOUPLER.LOCK

COUPLERHANDLESECURELYBEFORETOWING.ALWAYSCHECKFORDAMAGESAND

REPLACEIFDAMAGED.AVOIDSHARPTURNSANDSTEEPVERTICALANGLESWHENTOWING.

5

OPERATION



Intendeduse:Thislogsplitterisintendedanddesignedtoonlysplitwood.NEVERuse

foranyotherpurposes.DoingsocancauseinjuryorVOIDTHEWARRANTY.



ASSEMBLYINSTRUCTIONS

Thislogsplitterhasbeenpartiallyassembledatthefactory.Refertothedrawingsandpart

listsshoulditbecomenecessarytodisassembletheunitforrepairorreplacementofparts.

Inspectallcomponentsfordamage.

WARNING:Exerciseextremecaution,aspartsareveryheavy.Sufficientpersonsor

mechanicalhandlingequipmentshouldbeused.

IMPORTANT:Thisunitisshippedwithoilbutwithoutgasolineintheengine.After

assembly,seeseparateEngineManualforproperfuelandoilrecommendations.

1. GeneralAssembly:Removetop,sidesandendsofcrate.Placecratepanelsaside

toavoidpuncturingtires.Removetongueassemblyfromtop.

2. Carefullysetthebeampre-assemblyaside.

3. Attachtonguetotank/mountplatesusingtwoboltsandnuts.Becertainhardware

issecure.(SeeAssemblyFigure1)

4. Removetank/engineassemblyfrombaseofcrateanddiscardbanding.

5. FenderAssembly:Removefendersfrombox.Mounttofenderbracketswith5/16

hardwareprovided.Makesurefenderclearswheel.

6. Thecylinderistiedtothebase.Removetiesandslidecylinder/wedgeforward

aligningclevisatcylinderendtobeam.Insertpinandretainingclips,check

componenttoassureproperassembly.Standbeampre-assemblyverticaland

secureinposition.Rolltank/engineassemblyintoplace,aligningpivotholes

.Bolt

withprovidedhardware.Note:Donotovertighten;thisisthevertical/horizontal

pivotpoint.



7. Pivotbeamassemblyintothehorizontalpositionandlockwithpinprovided.

8. HoseAssembly:LocatethePressureHose,notedbythepipefittings,andattachit

tothelowerfittingonthevalve.Theremaininghoseattachestothetopfittingof

thevalve.Securewithprovidedhoseclamp.

9.

Checkboththehorizontalandverticalpositionsforany“kinks”inthehoses.Note:

Alwaysmakesurebeamislockedsecurelyintoplace.

SeeOPERATINGPOSITIONSforHorizontaltoVerticalSplitting



AssemblyFigure1

Tank/MountPlates

6

OPERATION



FILLINGTHEHYDRAULICRESERVOIR

FillthehydraulicreservoirwithatleastfivegallonsofDextronIIIAutomaticTransmissionfluidor

10WAWhydraulicfluid.Afterthehydraulicreservoirandtheenginecrankcasearefilled

correctlywiththeirrespectiveoils,starttheengine.Remembertosetthethrottleandturnonthe

fuelshut-offvalve.Thehydraulicpumpshouldprimeitself.Withtheenginerunning,movethe

hydraulicvalvelevertowardthewedge.Thiswillcausethecylindertoexte

ndandexpelair.When

thecylinderisfullyextended,retractit.Repeatthisprocedureseveraltimes.Anerraticmovement

ofthecylinderindicatesthatthereisstillairinthesystem.Moreoilshouldthenbeaddedtobring

thefluidleveluptoapproximately1”belowthefillhole.Afteraddingmoreoiltofillthetank,

cyclethecylinderagainuntilithasaconstantspeedindicatingthatallairhasbeenexpelled.Check

theoillevelinthereservoiragain.Standardmodelsrequireapprox.6.5gallonsofhydraulicfluid.



(Deluxemodels–9gallons)



NOTE:Ifthetankisoverfilled,itwilltendtoexpeloilfromthebreathercapwhenthecylinderis

retracted.



STARTUP

WARNING:DONOTSTARTORRUNTHELOGSPLITTERWITHOUTOILINTHE

ENGINEANDHYDRAULICRESERVOIR.

SeeseparateEngineManualforfuelandoilrecommendations.Yourlogsplitterhascome

equippedwithafuelshut-offvalvefortowingpurposes.

Beforestartingenginemakesurecrankcaseisfilledcorrectlywithoilandtheproperfuelhasbeen

used.Theenginewillonlystartwhenthethrottleleverandfuelshut-offvalveareturnedtotheir

ONpositions.



COLDWEATHERSTARTUP

TheColdWeatherClutchenablestheenginetobestartedwithouthavingtopullthroughcold,

thickenedhydraulicfluid.Simplypullthehandleoutandslideintolockedposition.Startengine,

letitwarmup,andreleaseColdWeatherClutch.Afterstarting,assurethattheleverhasreengaged.



TOWING

Thisunitshouldnotbetowedonanystreet,highway,orpublicroadwithoutcheckingtheexisting

federal,local,andstatelaws.Anylicensingormodificationssuchastaillights,etc.,needtocomply

withexistingfederal,local,orstatevehiclerequirementsisthesoleresponsibilityofthepurchaser.

Obeyallregulationswhentowingonpublicroadsandhighways.SeealsoTOWINGSAFETY.



Besureyouareusingthecorrectballhitchsizeforthehitchcoupleronthelogsplitter(2”ball).

Besuresafetychainsareproperlyconnected.Leaveenoughslackinchainsforturning.See

TOWINGSAFETYtoreadwarningsaboutcoupling.



Makesurebeamattachmentislockedinthehorizontalposition.NEVERtowsplitterinthevertical

position.



Turnthefuelshut-offvalveOFFtopreventfloodingoftheenginewhiletraveling.



TOWINGATNIGHT

TherequirementsfortaillightsarebasedonStatesregulations.Somestatesallowtowingatnight

aslongasthetowedequipmentdoesnotvisiblyimpairthetowvehicletaillights.Thisisbasedona

state,tostaterequirements.Thecustomerisresponsibleformeetingthestatesrequirements.A

TaillightKitAccessory(PartNo.7420)isavailableandrecommendedfornightdriving.



Ifa“StatementofOrigin”isrequiredinyourstate,seeyourlocaldealertoreceiveone.



7



OPERATION

1. Setupthelogsplitterinaclear,levelareaandblockthewheels.Thesuctionportonthetank

shouldalwaysbeonthelowersideofthelogsplitter.

2. Placealogonthebeam,againstthefootplate.Makesurethelogissecurelyonthefootplate

andupagainstthebeam.

3.

Depressthevalveleversothatthecylinderwilldrivethewedgeintothelog.Extendthecylinder

untilthelogsplitsortotheendofitsstroke.Iftheloghasnotcompletelysplitafterthecylinder

hasreachedtheendofitsextension,retractthecylinder.NOTE:

Leavingthevalveinthe“actuate”positionattheendofthestrokemaydamagethepump.



OPERATINGPOSITIONS

WARNING:THELOGSPLITTERBEAMISHEAVYANDCANPINCHHANDS/FINGERSIF

CAREISNOTTAKEN.



STANDARDHORIZONTALTOVERTICAL



TheStandardSplitterhas2operatingpositions:Horizontal,Vertical.

Removepinfrombelowbeam.Donotremoveboltandnut.Rotatebeamintoverticalpositionandpin

sobeamcannotfallintohorizontalposition.

DONOTTOWINVERTICALPOSITION!



IMPORTANT:

Whenoperatingsplitterinwoodedareas,obtainasparkarrestorfortheexhaustsystem.

Seeyourlocalenginedealer.



Whenpreparinglogs,cutendsassquareaspossible.Themaximumlengthofanylogsshouldbeonly

24”.



MAINTENANCE&STORAGE



WARNING:Disconnectsparkplugbeforeperforminganymaintenanceormakingadjustments.



RESERVOIRFLUID 

Checkthehydraulicfluidlevelinthereservoirtankbeforeeachuse.Operatingwithoutanadequateoil

supplywillcauseseveredamagetothepump.Changethehydraulicfluidinthereservoirper

manufacturersrecommendations.



Beawareoftheenvironmentwhendisposingofusedpetroleumproducts.Pleasedisposeofused

hydraulicfluid,engineoilandanybyproductsfromthemaintenanceofyourlogsplitterat

approvedrecyclingcenters.



Shoulditbecomenecessarytoloosenorremoveanyhydraulicfittingorline,besuretoremoveall

pressurebyshuttingofftheengineandmovingthecontrolhandlebackandforthseveraltimes.



NEVERremovethecapfromthehydraulictankorreservoirwhileyourunitisrunning.Hotoil

underpressurewillcauseinjury.



Alwaysstoregasolineinanapproved,tightlysealedcontainer.Storecontainerinadry,coolplac

e.Keep

fuelawayfromgasapplianceswherefumescouldcontactopenflame,pilotlightsorsparks.



8



Donotoperateyoursplitterinpoormechanicalconditionorwhenneedingrepair.Repairand

replacewornorbrokenpartsimmediately.



Periodicallytightennuts,bolts,andhydraulicfittings.



Thehydraulicsystemofyourlogsplitterrequirescarefulinspection,alongwiththemechanical

parts.Besuretoreplacefrayed,kinked,orotherwisedamagedhydrauliccomponents.



Thepressurereliefvalveonthesplitterispresetatthefactory.Donotadjustvalve.Onlya

qualifiedservicetechnicianshouldperformthisadjustment.



Ifthewedgebecomesdullornicked,itcanberemovedandsharpened.Thewedgeisheavyand

maystillhavesharpedges,weargloveswhilehandlingthewedge.



REPAIRPARTS



YourSwisherLogSplitterhasbeenproducedwithcomponentsdesignedspecificallytothis

machine.Althoughstandardsprings,hardware,etc.maylooksimilartopartsusedonother

machinery,theymayinsomecasesbemadeofadifferentconstructionand/ormaterials.



9

OD12– HYDRAULICFILLPLUG

DECAL

OD09– DANGER/POSITIONLOCK

DECAL

OD08– OPERATORINSTRUCTION

DECAL

OD16– FUELSHUTOFFDECAL

OD07– COLDWEATHERDECAL

SAFETYDECALS

Replacedecalsimmediatelyifdamaged.

OD22– POSITIONLOCKDECAL

OD23– TOWPOSITIONDECAL

10

ASSEMBLYDETAIL

LS622,LS67525,LS928,LS11534

MODELS

SEEDETAIL

1

2

3

B

4

5

6

7

8

9

10

A

11

16

15

14

13

12

18

17

8

20

25

21

23

24

2627

22

28

29

6

25

39

31

33

3432

35

36

30

42

41

40

38

37

43

44

45

46

47

48

49

50

42

16

51

55

18

52

54

53

52

58

57

56

49

6

5

SEEDETAIL

NOTALLPARTSAREONALLMODELS

57

B

FENDERSONLYON

LS11534MODEL

19

11

190

SERVICEPARTS

PleasehaveModelandSerialNumbersreadywhenorderingparts.

Colorcannotbeguaranteeduponserviceparts.

ITEMNUMBER DESCRIPTION PARTNUMBER

1 RETURNHOSE54" 7290

2 PRESSUREHOSE48" 7289

3 #12HOSECLAMP LS5001

4 HYDRAULICRESERVOIR 7319

5 1/2-13X31/2GR5BOLT NB577

6 1/2-13NYLOCKNUT NB281

7 RESERVOIRVENTPLUG 7379

8 3/8-16X1GR5BOLT NB604

9 1/2X31/2HITCHPINW/HAIRPIN NB648

10 SUCTIONHOSE18" 7346

11 #16HOSECLAMP LS4999

12 RETURNLINEFITTING 7329

13 FILTERHEAD LS1112

14 FILTERELEMENT LS1113

15 1/2-13X11/4GR5BOLT NB647

16 3/8-162-WAYLOCKNUT NB280

17 TANKBRACE 7352

18 3/8-16NYLOCKNUT NB182

19 TRAILERJACK/CENTERINGSPACER 7167/7165

20 HYDRAULICPUMP-LS622,LS67525MODEL LS2001H

HYDRAULICPUMP-LS928,LS11534MODELS LS2002B

21 1/8X1/2#3WOODRUFFKEY 024002

22 5/16-182-WAYLOCKNUT NB558

23 PUMPPULLEY 7306

24 SETSCREWW/NYLOCK NB312

25 5/16-18X3/4GR2BOLT NB143

26 FENDERBRACKET-RIGHTSIDE-LS11534ONLY 7417

FENDERBRACKET-LEFTSIDE-LS11534ONLY 7418

27 FENDER-LS11534ONLY 7428

28 KICKSTAND 7398

12

OnunitswithThrottle

190 ThrottlePlate 7104TC

191 KeySwitch(NotShown) KSM

192 ThrottleCable(NotShown) 7105

193 ThrottleDecal(NotShown) OD58TX

194 KeySwitchDecal(NotShown) OD99

SERVICEPARTS

PleasehaveModelandSerialNumbersreadywhenorderingparts.

ITEMNUMBER DESCRIPTION PARTNUMBER

29 MOTORBASE/AXLE 7297

30 TIRE/WHEEL 7296

31 COTTERPIN NB633

32 WHEELDUSTCOVER 2203DC

33 CASTLENUT 2203CN

34 WASHER NB184

35 TAPEREDBEARING 2203B

36 BEARINGSEAL 2203S

37 BELT 644

38 IDLERARM 6681TK

39 CLUTCHLEVER 7358

40 SPRING 682S

41 3/8-16JAMNUT NB174

42 HARDENEDWASHER NB196

43 3/8-16X21/2GR5BOLT NB619

44 5/16-18FLANGENUT NB170

45 IDLERSPRINGMOUNT 2046

46 WIRELINKFORIDLERSPRING BRS6H

47 SHOULDERBOLT NB220

48 IDLERPULLEY B527

49 WASHER NB272

50 BELTCOVER 7321

51 #14x3/4SELF-TAPPINGSCREW NB161

52 SAFETYCLIPPIN H11

53 TOWINGTONGUE 7343

TOWINGTONGUE-LS11534 7168

54 TRAVELLOCK 7441

55 SAFETYCHAINW/HOOK 7366

56 2"BALLCOUPLER 7365

57 3/8-16X3GR5BOLT NB164

58 3/8-16X31/2GR5BOLT NB649

Colorcannotbeguaranteeduponserviceparts.

13

ITEMNUMBER DESCRIPTION PARTNUMBER

59 CLIPPIN NB642

60 STEELPIN 7293

61 HYDRAULICFITTING 7291

62 STATIONARYLINEASSEMBLY 7288

63 RAMCYLINDER-LS622MODELS 7284

RAMCYLINDER-LS928&LS67525MODEL 7354

RAMCYLINDER-LS11534&LS12534DMODEL 7355

64 1/2-13X3GR5BOLT NB131

65 SPLITTINGWEDGE 7233

66 1/2-13X21/2GR5CARRIAGEBOLT NB643

67 RETURNLINEFITTING 7329

68 1/2-13JAM2-WAYLOCKNUT NB121

69 2-WAYPIPENIPPLE 7292

70 MASTERCHAINLINK 7424

71 COTTERPIN NB597

72 VALVEINLETFITTING 7387

73 VALVECONTROLW/LEVER 7287

74 BEAMWELDMENT 7624

BEAMWELDMENT-LS12534DMODEL 7384

75 1/4X1CLEVISPIN NB522

76 1/2-13NUT NB213Z

77 VALVELEVER&GRIP 7423/7425

78 THINGIBPLATE 7388

79 THICKGIBPLATE 7237

80 BOTTOMGIBPLATE 7333

81 LOCKWASHER NB508

81A FLATWASHER NB555

62

61

64

68

60

70

69

67

66

65

61

74

72

71

73

75

77

79

80

81

78

76

BEAMDETAIL

ALLMODELS

NOTALLPARTSAREONALLMODELS

59

63

81A

14

ENGINEDETAIL

LS622,LS67525MODELS

ITEM# DESCRIPTION PART#

89 ENGINE N/A

90 5/16-18X11/4GR5BOLT NB504

91 5/16-182-WAYLOCKNUT NB558

92 UPPERSPACER BB105SL

93 ENGINEPULLEY BB105

94 LOWERSPACER BB105S

95 BELLEVILLEWASHER 699

96 7/16-20X1GR5BOLTW/NYLOCK NB452N

106 KEYSTOCK 9031

182 WASHER TR150W

NOTSHOWN WIRINGHARNESS-LS12534DMODEL 7416

NOTSHOWN OILDRAINVALVE AS122

NOTSHOWN FUELSHUTOFFVALVE(INLINE) 7414

ITEM# DESCRIPTION PART#

97 ENGINE N/A

98 5/16-18X21/2GR5BOLT NB138

99 5/16-182-WAYLOCKNUT NB558

100 5/16-18X11/4GR5BOLT NB504

101 KEYSTOCK 9030

102 SETSCREWW/NYLOCK NB312

103 ENGINEPULLEY-LS622 7323

104 BELLEVILLEWASHER 699

105 3/8-24X1BOLTW/NYLOCK NB238N

89

90

91

94

93

92

182

96

100

98

97

99

101

105

102

104

103

106

15

ENGINEDETAIL

LS928,LS11534,LS12534DMODELS

95

127

113

126

112

110

129

107

124

108

127

110

114

110

107

126

124

109

122

124

128

110

134

130

146

128

131

112

117

125

131

128

145

131

149

116

128

147

124

148

115

129

113

129

123

119

133

132

130

121

120

123

135

136

137

138

140

139

142

151

150

144

143

141

SeeDetail

152

153

154

155

156

157

156

158

159

160

161

166

164

162

165

163

167

168

169

170

169

SeeDetail

ASSEMBLYDETAIL

MODELLS12534D

171

NOTALLPARTSAREONALLMODELS

173

172

16

174

175

176

177

178

179

180

181

ITEMNUMBER DESCRIPTION PARTNUMBER

107 3/8-16X31/2GR5BOLT NB649

108 3/8-16X3GR5BOLT NB164

109 1/2-13X31/2GR5BOLT NB577

110 1/2-13X11/4GR5BOLT NB647

112 3/8-16X1GR5BOLT NB604

113 5/16-18X1GR5BOLT NB143

114 5/16-18X3/4FLANGEBOLT NB596

115 #14X3/4SELFTAPPINGSCREW NB161

116 SHOULDERBOLT NB220

117 3/8-16X21/2GR5BOLT NB619

119 3/4-10X71/2GR5BOLT NB655

120 1/4-20X1GR5BOLT NB102

121 5/16-18X4GR5BOLT NB513

122 SAFETYCLIPPIN H11

123 1/2X21/2BALLLOCKPIN NB651

124 WASHER NB272

125 HARDENEDWASHER NB196

126 3/8-16NYLOCNUT NB182

127 1/2-13NYLOCNUT NB281

128 3/8-162WAYLOCKNUT NB280

129 5/16-182WAYLOCKNUT NB558

130 5/16-18NYLOCNUT NB181

131 3/8-16JAMNUT NB174

132 1/4-20NYLOCNUT NB180

133 3/4-10NYLOCNUT NB313

134 SETSCREWW/NYLOC NB312

135 SAFETYCHAINW/HOOK 7366

136 2"BALLCOUPLER 7365

137 TONGUE 7168

138 TUBERECIEVER 7362

139 KICKSTAND 7386

140 KICKSTANDBRACKET 7385

141 HYDRAULICPUMP LS2002B

142 HYDRAULICELBOW 7291

143 PUMPPULLEY 7306

144 MOTORBASE 7399

145 BELT32.5 7345

146 IDLERARM 6681

147 IDLERPULLEY B527

148 CLUTCHLEVER 7358

149 SPRING 682S

150 BOTTOMCOVER 7336

151 MOTORBASESUPPORTARM 7375

152 DUSTCOVER 2203DC

SERVICEPARTS

PleasehaveModelandSerialNumbersreadywhenorderingparts.

Colorcannotbeguaranteeduponserviceparts.

17

ITEMNUMBER DESCRIPTION PARTNUMBER

153 COTTERPIN NB633

154 CASTLENUT 2203CN

155 WASHER NB184

156 TAPEREDBEARING 2203B

157 TIRE&WHEEL 7296

158 BEARINGSEAL 2203S

159 FENDER 7428

160 DELUXETANKWELDMENT 7400

161 RESERVOIRVENTPLUG 7379

162 14"SUCTIONHOSE 7419

163 #16HOSECLAMP LS4999

164 FILTERELEMENT LS1113

165 FILTERHEAD LS1112

166 FITTINGRETURNLINE 7329

167 82"RETURNHOSE 7326

168 90"PRESSUREHOSE 7325

169 #12HOSECLAMP LS5001

170 PIVOT 7402

171 TRAILERJACK/CENTERINGSPACER 7167/7165

172 ROPEGUIDE 2046

173 5/16-18FLANGENUT NB170

174 KEYSWITCHNUT 9087

175 KEYSWITCHLOCKWASHER 9088

176 8-32KEPNUT NB201

177 THROTTLEASSEMBLY 10036

178 THROTTLEKNOB 686K

179 8-32X1/2PHILTRUSSZP NB197

180 KEYSWITCHON-OFF,2PRONG KSM

181 THROTTLEPLATE 10034

NOTSHOWN BEAMLOCK 7439

NOTSHOWN COMPRESSIONSPRING 7429

SERVICEPARTS

PleasehaveModelandSerialNumbersreadywhenorderingparts.

Colorcannotbeguaranteeduponserviceparts.

18

19

NOTES

:

______________________________________________________________________

20

NOTES

:

______________________________________________________________________

Page is loading ...

Swisher LS11534 User manual

This manual is also suitable for

Swisher LS11534 User manual

Related papers

Other documents