Coleman 533-700 User manual

Brand: Coleman

Model: 533-700

Category: Power generators

Type: User manual

This manual is also suitable for

533 Series

Dual-Fuel

Stove

Instructions for use

www.coleman.com

533 Series

CSA B140.9.2-2008 Proposed

Portable Pressurized Type Liquid

Petroleum Fuelled Camp Stoves

Sportster

Dual-Fuel

™

Stove

English

IMPORTANT

CONSUMER/USER:This instruction manual

contains important information necessary for the

proper assembly and safe use of the appliance.

Read and follow all warnings and instructions before

assembling and using the appliance. Follow all

warnings and instructions when using the appliance.

Keep this manual for future reference.

If you have questions about assembly, operation, servicing or repair of this

appliance, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707. In

Canada call 1-800-387-6161.

English-1

WARNING indicates a potentially hazardous

situation which, if not avoided, could result in

death or serious injury.

DANGER

DANGER indicates an imminently hazardous

situation which, if not avoided, will result in

death or serious injury.

This manual contains important information about

the assembly, operation and maintenance of this

outdoor liquid fueled appliance. General safety

information is presented on this page and is also

located throughout these instructions. Particular

attention should be paid to information accompa-

nied by the safety alert symbol “ DANGER”,

“ WARNING”, “ CAUTION”.

Keep this manual for future reference and

to educate new users of this product. This manual

should be read in conjunction with the labeling on

the product.

Safety precautions are essential when any

Coleman® fueled equipment is involved.These

precautions are necessary when using, storing,

and servicing. Using this equipment with the

respect and caution demanded will reduce the

possibilities of personal injury or property damage.

The following symbols shown below are used

extensively throughout these instructions. Always

heed these precautions, as they are essential when

using any Coleman® fueled equipment.

CAUTION

CAUTION indicates a potentially hazardous

situation which, if not avoided, may result in

minor or moderate personal injury, or

property damage.

Failure to comply with the precautions and

instructions provided with these stoves can

result in death, serious bodily injury and proper-

ty loss or damage from hazards of fire, explo-

sion, burn, asphyxiation, and/or carbon

monoxide poisoning.

Only persons who can understand and follow

the instructions should use or service

these stoves.

If you need assistance or information such

as an instruction manual or labels, contact

The Coleman Company, Inc.

CALIFORNIA PROPOSITION 65:

WARNING: This fuel, and byproducts of com-

bustion of this fuel, contain chemicals known to the

state of California to cause cancer, birth defects,

or other reproductive harm.

DANGER

Do not store or use

gasoline or other liquids

with flammable vapors in

the vicinity of this or any

other appliance.

FOR YOUR

SAFETY

CARBON MONOXIDE

HAZARD

• This appliance can pro-

duce carbon monoxide

which has no odor.

• Using it in an enclosed

space can kill you.

• Never use this appliance

in an enclosed space

such as a camper, tent,

car or home.

DANGER

WARNING

English-2

WARNING

DANGER

• EXPLOSION - FIRE HAZARD

• During lighting and operation, this product can

be a source of ignition. Never use the stove in

spaces that contain or may contain volatile or

airborne combustibles, or products such as

gasoline, solvents, paint thinner, dust particles

or unknown chemicals. Minimum clearances

from combustible materials: 24 inches from the

sides and 48 inches from the top.

• Provide adequate clearances around air

openings into the combustion chamber.

WARNING

Not for home or recreational vehicle use.

We cannot foresee every use which may be

made of our products.

Check with your local fire safety authority

if you have questions about use.

Other standards govern the use of fuel and

heat producing products for specific uses.

Your local authorities can advise you about

these.

• Use only Coleman

accessories or parts.

• During stove set-up, check all fittings for

leaks using soapy water. Never use a flame.

WARNING

• BURN HAZARD

• Never leave stove unattended when hot

or in use.

• Keep out of reach of children.

This multi-fuel appliance may be fueled by

Coleman

Liquid Fuel or unleaded gasoline.

• Never use kerosene or leaded automotive fuel.

• Store fuel in a clean, properly marked

container away from flame (including pilot

lights), other sources of ignition, or

excessive heat.

DANGER

• EXPLOSION - FIRE HAZARD

• Coleman® fuel and gasoline are extremely

flammable; handle with care. Fuel vapors are

invisible, explosive, and can be ignited by

ignition sources may feet away.

• Always fill outdoors.

• Never open a pressurized Coleman® fuel tank

or fill fuel tank near flame (including pilot

lights), or other ignition sources. It is normal

for a pressurized fuel tank to vent a small

amount of fuel mist when unscrewing the fuel

cap.Be sure stove has no flame before

unscrewing the fuel cap.

DANGER

• CARBON MONOXIDE HAZARD

• This stove is a combustion appliance.All com-

bustion appliances produce carbon monoxide

(CO) during the combustion process.This

product is designed to produce extremely

minute, non-hazardous amounts of CO if used

and maintained in accordance with all warn-

ings and instructions. Do not block air flow into

or out of the stove.

• Carbon Monoxide (CO) poisoning produces

flu-like symptoms, watery eyes, headaches,

dizziness, fatigue and possibly death.You

can’t see it and you can’t smell it. It’s an invisi-

ble killer. If these symptoms are present dur-

ing operation of this product get fresh

air immediately!

• For outdoor use only.

• Never use inside house, camper, tent, vehi-

cle or other unventilated or enclosed

areas.This stove consumes air (oxygen).

Do not use in unventilated or enclosed

areas to avoid endangering your life.

CAUTION

• SERVICE SAFETY

• Keep all connections and fittings clean.

Inspect fuel cap for dirt or damage after refill-

ing the fuel tank.Wipe up any spilled fuel and

dispose of in a safe place.

• Use as a cooking appliance only. Never alter

in any way or use with any device or part not

expressly approved by Coleman.

• Clean stove frequently to avoid grease

accumulation and possible grease fires.

• Check all connections for leaks. Liquid

Coleman® fuel present at connections

indicates a leak.

1. Coleman

Fuel is extremely

flammable, handle with extreme

care. Fuel vapors are invisible,

explosive, and can be ignited by

ignition sources many feet away.

2. Always fill outdoors. Never open or

fill fuel tank near flame (including

pilot lights), or other ignition

sources. It is normal for a pressur-

ized fuel tank to vent a small

amount of fuel mist when

unscrewing the fuel cap.

3. Always light and use stove

outdoors; never inside house,

camper, tent, or other unventilated

or enclosed areas.

4. This stove consumes air

(oxygen). Do not use in

unventilated or enclosed areas

to avoid endangering your life.

5. This stove is designed to use

Coleman

Fuel or unleaded

gasoline.

6. Store fuel in a clean, properly

marked container away from

flame (including pilot lights),

other sources of ignition, or

excessive heat.

7. Use for cooking only. Never alter

in any way or use with any device

or part not expressly approved

by Coleman. Never use as a

space heater. Never leave stove

unattended while burning.

8. Keep stove away from flamma-

bles. Never allow fabric, clothing,

or any flammable material come

within 48 inches of the top and 24

inches of all sides of the stove.

9. When stove is in use, all metal

parts of the stove assembly and

generator become extremely hot.

DO NOT TOUCH.

10. Never place heavy or large

capacity utensils on stove.

11. Keep out of reach of children.

WARNING

English-3

Technical

Characteristics

Input: 10,500 BTU/HR Coleman

fuel

or unleaded gasoline.

Category: Direct pressure

multi-fuel stove

Fuel:

Coleman

fuel

unleaded gasoline

To Set Up

DANGER

• CARBON MONOXIDE HAZARD

• For outdoor use only.

• Never use inside house, camper, tent, vehicle

or other unventilated or enclosed areas.This

lantern consumes air (oxygen). Do not use in

unventilated or enclosed areas to avoid

endangering your life.

Thank you for purchasing your new

Coleman

multi-fuel stove.We

recommend operating your new stove

in a safe location outside your home

to familiarize yourself with its multi-fuel

operation before your next outdoor

experience.

Helpful Hints

• Liquid Coleman

fuel is recommended

when using the stove in temperatures

below 40° F or in high elevation.

• For best results, always use Coleman

Filter/Funnel Part No. 5103A700T.

• If necessary, unleaded gasoline may

be substituted for liquid Coleman

fuel.

• Do not use kerosene in this stove.

Filling the tank

Always fill outdoors. Never fill tank,

loosen or remove fuel cap near flame

(including pilot lights), or other ignition

sources.

■ With stove on level surface, move red

fuel lever to off position. (Fig. 1)

Fig. 1

English-4

■ Close PUMP KNOB firmly. (Fig. 2)

Leak Check

• Perform leak test outdoors.

• Extinguish all open flames.

• NEVER leak test when smoking.

• Do not use the outdoor stove until connection

has been leak tested and does not leak.

WARNING

Fig. 2

■ Remove FUEL CAP. Using a funnel

or suitable filling device, fill with

clean, fresh fuel (Fig. 3). Do not tip

stove.

■ Replace FUEL CAP on fuel container.

Tighten firmly. Move fuel container

away from stove.WIPE UP ANY

SPILLED FUEL AND DISPOSE OF

IN A SAFE PLACE.

Fig. 3

Pumping

Be sure RED FUEL LEVER is in off

position. (Fig. 4)

■ Open PUMP KNOB one full turn.

(Fig. 5)

Fig. 4 Fig. 5

■ With thumb over hole in PUMP

KNOB, pump approximately 30 full

strokes. (Fig. 6)

■ Close PUMP KNOB. (Fig. 7)

Fig. 6

Fig. 7

WARNING

• BURN HAZARD

• Never leave stove unattended

when hot or in use.

• Keep out of reach of children.

To Light

■ Make sure FUEL VALVE is fully

“OFF”.

■ CHECK FOR LEAKS in one or more

ways. Look for fuel mist or a wet

appearance of fuel on surfaces. Listen

for hiss of escaping gas. Smell for fuel

odor. Never use a flame. Do not use if

leaking. (Fig. 8)

CHECK

FOR

LEAKS

CHECK

FOR

LEAKS

CHECK FOR

LEAKS

Fig. 8

English-5

■ Close PUMP KNOB. (Fig. 12)

To Turn Off

Fig. 12

Fig. 14

■ CAUTION: If fuel or flames appear

below BURNER, immediately turn

RED FUEL LEVER off. Allow stove to

cool.Turn stove upside down to

empty any fuel accumulated in burner

and wipe dry. Review instructions

then relight stove.

■ Adjust flame to desired heat with

RED FUEL LEVER. (Fig. 13)

Fig. 13

For temperatures below

freezing

■ Note: In temperatures below freezing

preheating paste may be required.

Place a generous amount of PRE-

HEATING PASTE on BURNER CAP

beneath the GENERATOR. (Fig. 15)

■ Additional pumping may be required

for full heat output (Fig. 14)

■ Light the paste (Fig. 16). After the

paste is almost consumed, follow the

previous lighting instructions.

Fig. 15

Fig. 16

Fig. 17

■ Move RED FUEL VALVE from off to

high” several times. (Fig. 17)

NEVER FILL OR LIGHT STOVE INSIDE

HOUSE, CAMPER, OR TENT

■ Hold lit match at BURNER, then turn

RED FUEL LEVER to high (LIGHT)

position. (Fig. 9)

Fig. 9

■ When burner lights, open PUMP

KNOB one turn (Fig. 10) and pump for

30 full strokes (Fig. 11).

Fig. 11Fig. 10

English-6

WARNING

• Always turn fuel valve off before

unscrewing fuel cap from fuel tank. Never

remove fuel cap near ignition sources,

while stove is lit, or hot to touch.

■ Be sure flame is extinguished. Flame

will linger on burner for 1-2 minutes

after fuel valve is “OFF”.

To Store

■ Make sure stove is cool.

■ Move stove away from flame (includ-

ing pilot lights) and other ignition

sources.

• MAINTENANCE

• Keep stove area clear and free

from combustible materials,

gasoline and other flammable

vapors and liquids.

• Do not obstruct the flow of

combustion and ventilation air.

• A good flame should be blue with

minimal yellow tip. Some yellow

tips on flames are acceptable as

long as no carbon or soot deposits

appear.

• Wipe clean with soft cloth and mild

dish detergent. Do not use abra-

sives.

Fig. 18

■ Latch Red FUEL VALVE in off

position. (Fig. 18)

English-7

Troubleshooting

Symptom

Burner will not

light or flame self-

extinguished.

Burner will not

light or flame is

low or flame self-

extinguished.

Burner self-

extinguishes

during one minute

warm-up.

Yellow flame.

Low heat.

Persistent small

yellow flame.

Persistent high

yellow flame.

Yellow smokey

flame.

Pump does not

pressurize the

liquid fuel

canister.

Intermittent yellow

flame after

extended use on

low heat setting.

Problem

Fuel tank empty.

Little or no pressure in fuel

tank.

Generator is not fully

warmed up.

Excess fuel in burner.

Generator tip plugged.

Faulty generator.

Failure in the fuel delivery

system.

Spider webs, insects, or

other obstruction in the

burner and air tube.

Pump seals are dry or

worn.

Flame requires adjustment.

Solution

Refill fuel tank with clean and

fresh Coleman

fuel or unleaded

fuel.

Check that fuel cap is tight and

pump 30 strokes.

In temperatures below freezing

preheating paste may be

required. Place a generous

amount of preheating paste on

burner cap beneath the generator.

A yellow flame is normal until the

generator warms up.If yellow

flame persists, turn off stove,

allow flame to self-extinguish and

the stove to cool. If necessary,

invert stove to remove excess

liquid fuel from the burner. Follow

lighting instructions.

Turn red fuel lever back and forth

several times to clean generator

tip.Be sure to use only fresh and

clean fuel.

Replace with a new generator.

This is a normal periodic

maintenance procedure.The

generator life is dependent on the

type of fuel used. Generator life is

extended by using clean

Coleman

fuel.

Replace with a new generator.

May need to replace pump

assembly. Please contact

Consumer Service (see page 9).

Remove burner to inspect and

clean the burner and air tube.

Squirt a few drops of oil in the

OIL HOLE in the pump cap.This

will keep the pump functioning

properly (Fig. 19). If this does not

correct the problem, replace the

pump seals or purchase a new

pump assembly.

Adjust the flame to a slightly

higher level with the red fuel lever.

English-8

Replacement Parts List

No. Part No. Description

1 220C1401 Fuel Cap

2 220A6201 Pump Repair Kit

3 533-5891 Generator

4 508A5571 Valve Assembly

5 400-3451 Burner Ring Set

6 413C3021 Burner Bowl

7 400-5401 Grate

8 639-1091 Pump Cup & Nut

9 400-5261 Burner Box Assembly

10 400A1261 Generator Bracket

11 400-0601 Screw Pkg. (6)

12 200-6381 Check Valve & Stem Assy.

13 400B5151 Valve Stem Assy.

11 9

English-9

Warranty

Limited Five Year Warranty

The Coleman Company, Inc. (“Coleman”) warrants that

for a period of five years from the date of original retail

purchase, this product will be free from defects in material

and workmanship. Coleman, at its option, will repair or

replace this product or any component of the product found

to be defective during the warranty period. Replacement

will be made with a new or remanufactured product or

component. If the product is no longer available, replacement

may be made with a similar product of equal or greater value.

This is your exclusive warranty.

This warranty is valid for the original retail purchaser from

the date of initial retail purchase and is not transferable.Keep

the original sales receipt. Proof of purchase is required to

obtain warranty performance. Coleman dealers, service

centers, or retail stores selling Coleman

products do not

have the right to alter, modify or in any way change the terms

and conditions of this warranty.

What This Warranty Does Not Cover

This warranty does not cover normal wear of parts, parts

that are not genuine Coleman

parts, or damage resulting

from any of the following: negligent use or misuse of the

product; use on improper voltage or current; commercial use

of the product; use contrary to the operating instructions;

disassembly, repair or alteration by anyone other than

Coleman or an authorized service center. Further, the

warranty does not cover Acts of God, such as fire, flood,

hurricanes and tornadoes. Warranty void if damage to

product results from the use of a part other than a genuine

Coleman

part.

COLEMAN SHALL NOT BE LIABLE FOR DEFECTS THAT

ARE CAUSED BY THE USE OF UNAUTHORIZED PARTS

OR SERVICE. COLEMAN SHALL NOT BE LIABLE FOR

ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES

CAUSED BY THE BREACH OF ANY EXPRESS OR

IMPLIED WARRANTY OR CONDITIONS. EXCEPT TO THE

EXTENT PROHIBITED BY APPLICABLE LAW, ANY

IMPLIED WARRANTY OF MERCHANTABILITY OR

FITNESS FOR A PARTICULAR PURPOSE IS LIMITED IN

DURATION TO THE DURATION OF THE ABOVE

WARRANTY OR CONDITIONS. SOME STATES,

PROVINCES, OR JURISDICTIONS DO NOT ALLOW THE

EXCLUSION OR LIMITATION OF INCIDENTAL OR

CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW

LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE

LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU.

THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS,

AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY

FROM STATE TO STATE OR PROVINCE TO PROVINCE.

How to Obtain Warranty Service

Take the product to an authorized Coleman service center.

You can find the nearest authorized Coleman service center

by visiting www.coleman.com or calling 1-800-835-3278 or

TDD 316-832-8707 in the United States or 1 800 387-6161 in

Canada. If a service center is not conveniently located, attach

to the product a tag that includes your name, address,

daytime telephone number and description of the problem.

Include a copy of the original sales receipt. Carefully package

the product and send either by courier or insured mail with

shipping and insurance prepaid to:

For products purchased in the United States:

The Coleman Company, Inc.

3600 North Hydraulic

Wichita, KS 67219

For products purchased in Canada:

Sunbeam Corporation (Canada) Limited

DBA Jarden Consumer Solutions

20B Hereford Street

Brampton, ON L6Y 0M1

The costs of transporting the product to Coleman or an

authorized service center for warranty service is the

responsibility of the purchaser.

Do not mail products with fuel in tanks, or with disposable

LPG canisters. Remove glass globes from lanterns and wrap

separately.

DO NOT RETURN THIS PRODUCT TO THE PLACE OF

PURCHASE.

If you have any questions regarding this warranty please

call 1-800-835-3278 or TDD 316-832-8707 in the United

States or 1 800 387-6161 in Canada.

Things You Should Know

1. Preheating paste is available at most stores

that sell backpacking equipment.

2. Rinse tank twice a year with fresh fuel to

remove sediment, gum formations, and

moisture accumulations.

3. Seasonally or before storage, squirt a few

drops of oil into the OIL HOLE in the pump

cap.This will keep the pump functioning

properly. (Fig. 19)

4.The red fuel lever moves a small needle in

and out of the generator gas tip. If stove is

hard to light or does not produce full heat

output, turn red fuel lever back and forth

several times to clean generator.

5. Unleaded fuels may vary in quality and can

affect generator life and performance. If you

are having a problem with your stove or

generator using unleaded fuel, replace the

generator and try a different brand of

unleaded fuel.

6.The usual storage areas for camping and

picnic equipment are the basement, attic, or

garage.To avoid the accumulation of dust,

cobwebs, etc., that is common in these

areas, place your stove in a plastic bag and

seal it with a rubber band.

7. For repair service call one of the numbers

listed below for location of your nearest

Coleman Service Center. If stove must be

mailed to a Service Center, attach to the

product a tag that includes your name,

address, daytime telephone number and a

description of problem. Do NOT send LPG

canister. Carefully package the product and

send either by courier or insured mail with

shipping and insurance prepaid to:

For products purchased in the United States:

The Coleman Company, Inc.

3600 N. Hydraulic • Wichita, KS 67219 U.S.A.

1-800-835-3278 • TDD: 316-832-8707

For products purchased in Canada:

Sunbeam Corporation (Canada) Limited

DBA Jarden Consumer Solutions

20B Hereford Street

Brampton, ON L6Y 0M1

1-800-387-6161

8. If not completely satisfied with the

performance of this product, please call one

of the numbers listed above.

OIL HOLE

Fig. 19

English-10

Notes:

4010003165 (20080310)

The Coleman Company, Inc. • 3600 North Hydraulic • Wichita, KS 67219 U.S.A.

1-800-835-3278 • TDD: 316-832-8707

Sunbeam Corporation (Canada) Limited • DBA Jarden Consumer Solutions

20B Hereford Street

Brampton, ON L6Y 0M1 • 1 800 387-6161

are registered trademarks and Dual Fuel™ is a trademark of The Coleman Company, Inc.

sont des marques déposées

alors que

Dual Fuel™

est une marque de commerce de

The Coleman Company, Inc.

son marcas registradas

Dual Fuel™

es una marca de la compañía

The Coleman Company, Inc.

www.coleman.com

Coleman 533-700 User manual

Brand: Coleman

Model: 533-700

Category: Power generators

Type: User manual

This manual is also suitable for

533 Series

Download PDF

report

Coleman 533-700 User manual

This manual is also suitable for

Coleman 533-700 User manual

Related papers

Other documents