Swisher LS728C, LS10528C User manual

ReadandfollowallSafety

PrecautionsandInstructions

beforeoperatingthis

equipment.

LOG

SPLITTER

OWNER’S

MANUAL

1602CORPORATEDRIVE,WARRENSBURG,MISSOURI64093PHONE660-747-8183

FAX660-747-8650

MODELNO.

LS728C

LS10528C

Manufacturingqualitylawncareequipmentsince1945

Safety

Assembly

Operation

ServiceandAdjustment

RepairParts

MadeInThe

USA

IMPORTANT

swisherinc.com

11815

Rev.

2

Intheeventyouhaveaclaimunderthiswarranty,youmustreturntheproducttoanauthorizedservicedealer.

Alltransportationcharges,damage,orlossincurredduringtransportationofpartssubmittedforreplacementor

repairunderthis warrantyshallbe bornebythe purchaser.Should youhaveany questions concerningthis

warranty,pleasecontactustoll-freeat1-800-222-8183.Themodelnumber,serialnumber,dateofpurchase,

andthenameoftheauthorizedSwisherdealerfromwhomyoupurchasedthemowerwillbeneededbeforeany

warrantyclaimcanbeprocessed.

THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL

DAMAGESANDANYIMPLIEDWARRANTIESARELIMITEDTOTHESAMETIMEPERIODS

STATEDHEREINFORALLEXPRESSEDWARRANTIES.Somestatesdonotallowthelimitationof

consequentialdamagesorlimitationsonhowlonganimpliedwarrantymaylast,sotheabovelimitationsor

exclusionsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrightsandyoumayhaveotherrights,

whichvaryfromstate-to-state.ThisisalimitedwarrantyasdefinedbytheMagnuson-MossActof1975.

LIMITEDWARRANTY

Themanufacturer’swarrantytotheoriginalconsumerpurchaseris:Thisproductisfreefromdefectsin

materialsandworkmanshipforaperiodoftwo(2)yearfromthe dateofpurchasebytheoriginalconsumer

purchaser.Wewillrepairorreplace,atourdiscretion,partsfoundtobedefectiveduetomaterialsor

workmanship.Thiswarrantyissubjecttothefollowinglimitationsandexclusions:

TABLEOFCONTENTS

WARRANTY………………....….2

SAFETY..……………………….3-4

TOWING..….……..……………..5

OPERATION……………………6-8

MAINTENANCE.…………………….8-9

DECALS…..………….……………….10

PARTSBREAKDOWN…………….11-18

SPECIFICATIONS..…………………23

1) EngineWarranty Allenginesutilizedonourproductshaveaseparatewarrantyextended

tothembytheindividualenginemanufacturer.Anyengineservice

difficultyistheresponsibilityoftheenginemanufacturerandinno

wayisSwisherMowerCo.,Inc.oritsagentsresponsibleforthe engine

warranty.TheBriggs&StrattonEngineServiceHot-Lineis1-800-

233-3723.TheTecumsehEngineServiceHot-Lineis1-800-558-5402.

TheHondaEngineServiceHot-Lineis1-800-426-7701.

1) CommercialUse Thewarrantyperiodforanyproductusedforcommercialorrentalis

limitedtoninety(90)daysfromthedateoforiginalpurchase.

2) Limitation Thiswarrantyappliesonlytoproductswhichhavebeenproperly

assembled,adjusted,andoperatedinaccordancewiththeinstructions

containedwithinthismanual.Thiswarrantydoesnotapplytoany

productofSwisherMowerCo.,Inc.,thathasbeensubjecttoalteration,

misuse,abuse,improperassemblyorinstallation,shippingdamage,or

tonormalwearofproduct.

3) Exclusions Excludedfromthiswarrantyarenormalwear,normaladjustments, and

normalmaintenance.Thepump,valve,andcylindereachcarryseparate

manufacture’swarranties.Thevalveandcylinderbothcarryaone(1)year

limitedwarranty.Thepumpcarriesatwo(2)yearlimitedwarranty.

SAFETYPRECAUTIONS



WARNING:Theengineexhaustfromthisproductcontainschemicalsknowntothestateof

Californiatocausecancer,birthdefectsorotherreproductiveharm.



DANGER:Yourlogsplitterwasbuilttobeoperatedaccordingtotherulesforsafeoperationin

thismanual.Aswithanytypeofpowerequipment,carelessnessorerroronthepartofthe

operatorcanresultinseriousinjury.Ifyouviolateanyoftheserules,youmaycauseserious

injurytoyourselforothers.



• Readthemanual.Learntooperatethisequipmentinasafemanner.



• Donotunderanycircumstancesalterthislogsplitter.Thisequipmentwasdesignedand

engineeredinaccordancewithoperatinginstructions.Alteringthisequipment,orusing

thisequipmentinsuchawayastocircumventitsdesigncapabilitiesandcapacities,could

resultinseriousinjuryorfatalityandWILLVOIDTHEWARRANTY.



• Allowonlyresponsibleadultswhohavereadthismanualtooperatethismachine.Never

allowchildrentooperatethismachine.



• Neverusesplitterforanyotherpurposethansplittingwood.Anyotherusecanresultin

injury.Yoursplitterisaprecisionpieceofpowerequipment,notatoy.Therefore,

exerciseextremecautionatalltimes.



• Onlyasingleoperatoristoloadandoperatethelogsplitter.Keepallothers,including

petsandchildren,aminimumof20feetawayfromyourworkarea.Moreaccidents

occurwhenmorethanonepersonoperatesthelogsplitterthananyothertime.



• Alwaysdisconnectthesparkplugwireandplacethewirewhereitcannotcontactthe

sparkplug,topreventaccidentalstartingtheenginewhensettingup,transporting,

adjustingorrepairing.



• Alwayswearprotectivegearsuchassafetygoggles,protectivehearingdevice,steel-toed

shoes,andtight-fittinggloveswithoutdrawstringsorloosecuffs.



• Neverwearlooseclothingorjewelrythatcanbecaughtbymovingpartsofthesplitter

andpullyouintoit.Keephairawayfrommovingparts.



• Familiarizeyourselfwithallofthecontrolsinasafeenvironmentbeforestartingtowork

withthismachine.



ThisSafetyAlertSymbolindicatesimportantmessagesinthismanual.

Whenyouseethissymbol,carefullyreadthemessagethatfollowsandbe

alerttothepossibilityofpersonalinjury.

Readthismanualcompletely.Thismachinecanamputatehands,feet,andthrowobjects.

Failuretoobservethefollowingsafetyinstructionscouldresultinseriousinjuryordeath.

3

Fluidescapingfromaverysmallholecanbealmostinvisible.Donotcheckforleakswithyour

hand.Escapingfluidunderpressurecanhavesufficientforcetopenetrateskin,causingserious

personalinjury.Leakscanbelocatedbypassingapieceof

cardboardorwoodoverthesuspected

leakandlookingfordiscoloration.IFinjuredbyescapingfluid,seeadoctoratonce.Serious

infectionorreactioncandevelopifpropermedicaltreatmentisnotadministered

immediately.



• Splitonlyonelogatatime.Neverattempttosplittwologsontopofeachother.



• Donotstraddleorreachacrossthesplittingareawhileoperatingthesplitter.



• Donotstepoversplitterwhentheengineisrunning.Youmaytriporaccidentally

activatethesplittingwedge.Walkaroundtogettotheotherside.



•

Neverplacehandsorfeetbetweenlogandsplittingwedgeorbetweenlogandramduring

forwardorreversestroke.



• Neverattempttoloadsplitterwhilesplittingwedgeisinmotion.Whenloadinglog

splitter,placehandsonthesidesofthelog,nottheends.



• Onlyuseyourhandstooperatethecontrollever.Neverusefoot,knee,ropeorany

extensiondevice.



• Alwayskeepfingersclearofsplitsthatopeninlogduringsplitteroperation.



• Whensplitterisinthereturnmode,keephandsoffthemachine.



•

Onlyoperatesplitteronlevelground,notonthesideofahill.Itcouldtiporrollinglogs,

poorfooting,etc.couldcauseanaccident.



• Neveroperateorallowsomeonetooperatethisequipmentwhileundertheinfluenceof

alcoholordrugs.



• Alwaysblockthewheelstopreventmovementwhileusingsplitter.



• Neveroperateyoursplitteronwet,muddy,oricysurfaces.Safefootingisessentialin

preventingaccidents.



• Neveroperateyoursplitterwhileitisattachedtothetowvehicle.



• Nevermakeadjustmentsorrepairswiththeenginerunning.



• Neverattempttosplitwoodsacrossthegrain.Sometypesofwoodmayburstorflyout

ofyoursplitterandresultininjury.



• Bothendsofthelogshouldbecutassquarelyaspossibletopreventthelogfromsliding

outofthesplitterduringoperation.Loglengthshouldbekeptto24”orless.



4



TOWINGSAFETY



•

Donotallowpersonstorideonsplitter.Donotcarryanycargoorwoodonyour

splitter.Itmayfalloffandendangervehiclesthatarefollowingyou.



•

Besurejackstandisinthetravelpositionandcouplingsecure.Thismustalsobe

retractedsonottointerferewhiletowing.Retractkickstandbyremovingpin,

rotatingup,andreplacingpin.



• Neverexceed45MPHwhiletowingyoursplitter.Beextracautiouswhen

travelingoverroughterrain,especiallyoverrailroadtracks.



•

Alwaysbecarefulwhilebackingyoursplitter.Youcouldjackknifeyourlog

splitterifnotcareful.



•

Beforeusingsplitter,disconnectitfromtowvehicle.Alogcouldeasilybe

pushedforwardintothevehicle.



•

SeetireandwheelspecificationsforPSIwhiletowing.



• Beawareoftheextralengthofsplitterwhileturning,parking,crossing

intersections,andinalldrivingsituations.



•



OPERATIONINSTRUCTIONS

POSI-LOCKCOUPLER

ADJUSTCOUPLERLOCKINGPRESSUREONBALLBEFOREUSE.PLACEHANDLEINLOCKED

POSITIONWITHBALLINCOUPLER.TIGHTENLOCKNUTAGAINSTTENSIONSPRINGSOTHAT

COUPLERISNOTLOOSEONBALL.CORRECTADJUSTMENTWILLALLOWHANDLETOBE

RELEASEDWITHMODERATEPRESSUREAPPLIEDTOHANDLE.



TOOPEN,PULLUPONCOUPLERHANDLEANDROTATEFORWARD.PLACECOUPLERONBALL

WHENBALLISCOMPLETELYNESTEDINBALLSOCKET,ROTATECOUPLERHANDLE

BACKWARDUNTILHANDLEISINLOCKEDPOSITION.



AFTERTOWINGFOR50MILES,CHECKCOUPLERFORTIGHTNESSONBALL.ALWAYSCHECK

TIGHTNESSBEFORETOWING.BESURECOUPLERHANDLEISINLOCKEDPOSITION.



WARNING:

NEVEREXCEEDWEIGHTCAPACITYANDALWAYSUSESAFETYCHAINS.ALWAYSUSE

CORRECTBALLSIZE,MAKINGSUREBALLISCOMPLETELYINSERTEDINTOCOUPLER.LOCK

COUPLERHANDLESECURELYBEFORETOWING.ALWAYSCHECKFORDAMAGESAND

REPLACEIFDAMAGED.AVOIDSHARPTURNSANDSTEEPVERTICALANGLESWHENTOWING.

5

OPERATION



Intendeduse:Thislogsplitterisintendedanddesignedtoonlysplitwood.NEVERuse

foranyotherpurposes.DoingsocancauseinjuryorVOIDTHEWARRANTY.



ASSEMBLYINSTRUCTIONS

Thislogsplitterhasbeenpartiallyassembledatthefactory.Refertothedrawingsandpart

listsshoulditbecomenecessarytodisassembletheunitforrepairorreplacementofparts.

Inspectallcomponentsfordamage.

WARNING:Exerciseextremecaution,aspartsareveryheavy.Sufficientpersonsor

mechanicalhandlingequipmentshouldbeused.

IMPORTANT:Thisunitisshippedwithoilbutwithoutgasolineintheengine.After

assembly,seeseparateEngineManualforproperfuelandoilrecommendations.

1. GeneralAssembly:Removetop,sidesandendsofcrate.Placecratepanelsaside

toavoidpuncturingtires.Removetongueassemblyfromtop.

2. Carefullysetthebeampre-assemblyaside.

3. Attachtonguetotank/mountplatesusingtwoboltsandnuts.Becertainhardware

issecure.(SeeAssemblyFigure1)

4. Removetank/engineassemblyfrombaseofcrateanddiscardbanding.

5. FenderAssembly:Removefendersfrombox.Mounttofenderbracketswith5/16

hardwareprovided.Makesurefenderclearswheel.

6. Thecylinderistiedtothebase.Removetiesandslidecylinder/wedgeforward

aligningclevisatcylinderendtobeam.Insertpinandretainingclips,check

componenttoassureproperassembly.Standbeampre-assemblyverticaland

secureinposition.Rolltank/engineassemblyintoplace,aligningpivotholes

.Bolt

withprovidedhardware.Note:Donotovertighten;thisisthevertical/horizontal

pivotpoint.



7. Pivotbeamassemblyintothehorizontalpositionandlockwithpinprovided.

8. HoseAssembly:LocatethePressureHose,notedbythepipefittings,andattachit

tothelowerfittingonthevalve.Theremaininghoseattachestothetopfittingof

thevalve.Securewithprovidedhoseclamp.

9.

Checkboththehorizontalandverticalpositionsforany“kinks”inthehoses.Note:

Alwaysmakesurebeamislockedsecurelyintoplace.

SeeOPERATINGPOSITIONSforHorizontaltoVerticalSplitting



AssemblyFigure1

Tank/MountPlates

6

OPERATION



FILLINGTHEHYDRAULICRESERVOIR

FillthehydraulicreservoirwithatleastfivegallonsofGeneralPurposeHydraulicfluidor

AutomaticTransmissionfluid.Afterthehydraulicreservoirandtheenginecrankcasearefilled

correctlywiththeirr

espectiveoils,starttheengine.Remembertosetthethrottleandturnonthe

fuelshut-

offvalve.Thehydraulicpumpshouldprimeitself.Withtheenginerunning,movethe

hydraulicvalvelevertowardthewedge.Thiswillcausethecylindertoextendandexpelair.

Whenthecylinderisfullyextended,retractit.Repeatthisprocedureseveraltimes.(Anerratic

movementofthecylinderindicatesthatthereisairinthesystem).Youmayhavetoaddmore

fluidandrepeatthisprocedure.Oncethecylinderhasasmoothandconstantspeedindicating

thatalltheairhasbeenexpelled,moreoilshouldthenbeaddedtobringthefluidlevelupto

approximately3”belowthefillhole.Standardmodelsrequireapprox.4.5gallonsofhydraulic

fluid.



NOTE:

Ifthetankisoverfilled,itwilltendtoexpeloilfromthebreathercapwhenthecylinder

isretracted.



STARTUP

WARNING:DONOTSTARTORRUNTHELOGSPLITTERWITHOUTOILINTHE

ENGINEANDHYDRAULICRESERVOIR.

SeeseparateEngineManualforfuelandoilrecommendations.Yourlogsplitterhascome

equippedwithafuelshut-offvalvefortowingpurposes.

Beforestartingenginemakesurecrankcaseisfilledcorrectlywithoilandtheproperfuelhas

beenused.Theenginewillonlystartwhenthethrottleleverandfuelshut-offvalveareturned

totheirONpositions.



COLDWEATHERSTARTUP

TheColdWeatherClutchenablestheenginetobestartedwithouthavingtopullthroughcold,

thickenedhydraulicfluid.Simplypullthehandleoutandslideintolockedposition.Start

engine,letitwarmup,andreleaseColdWeatherClutch.Afterstarting,assurethattheleverhas

reengaged.



TOWING

Thisunitshouldnotbetowedonanystreet,highway,orpublicroadwithoutcheckingthe

existingfederal,local,andstatelaws.Anylicensingormodificationssuchastaillights,etc.,

needtocomplywithexistingfederal,local,orstatevehiclerequirementsisthesole

responsibilityofthepurchaser.Obeyallregulationswhentowingonpublicroadsand

highways.SeealsoTOWINGSAFETY.



Besureyouareusingthecorrectballhitchsizeforthehitchcoupleronthelogsplitter(2”ball).

Besuresafetychainsareproperlyconnected.Leaveenoughslackinchainsforturning.See

TOWINGSAFETYtoreadwarningsaboutcoupling.



Makesurebeamattachmentislockedinthehorizontalposition.NEVERtowsplitterinthe

verticalposition.



Turnthefuelshut-offvalveOFFtopreventfloodingoftheenginewhiletraveling.



TOWINGATNIGHT

TherequirementsfortaillightsarebasedonStatesregulations.Somestatesallowtowingat

nightaslongasthetowedequipmentdoesnotvisiblyimpairthetowvehicletaillights.Thisis

basedonastate,tostaterequirements.Thecustomerisresponsibleformeetingthestates

requirements.ATaillightKitAccessory(PartNo.7420)isavailableandrecommendedfornight

driving.



Ifa“StatementofOrigin”isrequiredinyourstate,seeyourlocaldealertoreceiveone.



7



OPERATION

1. Setupthelogsplitterinaclear,levelareaandblockthewheels.Thesuctionportonthetank

shouldalwaysbeonthelowersideofthelogsplitter.

2. Placealogonthebeam,againstthefootplate.Makesurethelogissecurelyonthefootplate

andupagainstthebeam.

3.

Depressthevalveleversothatthecylinderwilldrivethewedgeintothelog.Extendthecylinder

untilthelogsplitsortotheendofitsstroke.Iftheloghasnotcompletelysplitafterthecylinder

hasreachedtheendofitsextension,retractthecylinder.NOTE:

Leavingthevalveinthe“actuate”positionattheendofthestrokemaydamagethepump.



OPERATINGPOSITIONS

WARNING:THELOGSPLITTERBEAMISHEAVYANDCANPINCHHANDS/FINGERSIF

CAREISNOTTAKEN.



STANDARDHORIZONTALTOVERTICAL



TheStandardSplitterhas2operatingpositions:Horizontal,Vertical.

Removepinfrombelowbeam.Donotremoveboltandnut.Rotatebeamintoverticalpositionandpin

sobeamcannotfallintohorizontalposition.

DONOTTOWINVERTICALPOSITION!



IMPORTANT:

Whenoperatingsplitterinwoodedareas,obtainasparkarrestorfortheexhaustsystem.

Seeyourlocalenginedealer.



Whenpreparinglogs,cutendsassquareaspossible.Themaximumlengthofanylogsshouldbeonly

24”.



MAINTENANCE&STORAGE



WARNING:Disconnectsparkplugbeforeperforminganymaintenanceormakingadjustments.



RESERVOIRFLUID 

Checkthehydraulicfluidlevelinthereservoirtankbeforeeachuse.Operatingwithoutanadequateoil

supplywillcauseseveredamagetothepump.Changethehydraulicfluidinthereservoirper

manufacturersrecommendations.



Beawareoftheenvironmentwhendisposingofusedpetroleumproducts.Pleasedisposeofused

hydraulicfluid,engineoilandanybyproductsfromthemaintenanceofyourlogsplitterat

approvedrecyclingcenters.



Shoulditbecomenecessarytoloosenorremoveanyhydraulicfittingorline,besuretoremoveall

pressurebyshuttingofftheengineandmovingthecontrolhandlebackandforthseveraltimes.



NEVERremovethecapfromthehydraulictankorreservoirwhileyourunitisrunning.Hotoil

underpressurewillcauseinjury.



Alwaysstoregasolineinanapproved,tightlysealedcontainer.Storecontainerinadry,coolplac

e.Keep

fuelawayfromgasapplianceswherefumescouldcontactopenflame,pilotlightsorsparks.



8



Donotoperateyoursplitterinpoormechanicalconditionorwhenneedingrepair.Repairand

replacewornorbrokenpartsimmediately.



Periodicallytightennuts,bolts,andhydraulicfittings.



Thehydraulicsystemofyourlogsplitterrequirescarefulinspection,alongwiththemechanical

parts.Besuretoreplacefrayed,kinked,orotherwisedamagedhydrauliccomponents.



Thepressurereliefvalveonthesplitterispresetatthefactory.Donotadjustvalve.Onlya

qualifiedservicetechnicianshouldperformthisadjustment.



Ifthewedgebecomesdullornicked,itcanberemovedandsharpened.Thewedgeisheavyand

maystillhavesharpedges,weargloveswhilehandlingthewedge.



REPAIRPARTS



YourSwisherLogSplitterhasbeenproducedwithcomponentsdesignedspecificallytothis

machine.Althoughstandardsprings,hardware,etc.maylooksimilartopartsusedonother

machinery,theymayinsomecasesbemadeofadifferentconstructionand/ormaterials.



9

OD12– HYDRAULICFILLPLUG

DECAL

OD09– DANGER/POSITIONLOCK

DECAL

OD08– OPERATORINSTRUCTION

DECAL

OD16– FUELSHUTOFFDECAL

OD07– COLDWEATHERDECAL

SAFETYDECALS

Replacedecalsimmediatelyifdamaged.

10

ASSEMBLYDETAIL

LS728C,LS10528CMODELS

SEEDETAIL

1

2

3

B

4

5

6

7

8

9

10

A

11

16

15

14

13

12

18

17

8

20

25

21

23

24

2627

22

28

29

6

25

39

31

33

3432

35

36

30

42

41

40

38

37

43

44

45

46

47

48

49

50

42

16

51

55

18

52

54

53

52

58

57

56

49

6

5

SEEDETAIL

NOTALLPARTSAREONALLMODELS

57

B

FENDERS&FENDER

BRACKETSSOLD

SEPERATELY

11

SERVICEPARTS

PleasehaveModelandSerialNumbersreadywhenorderingparts.

Colorcannotbeguaranteeduponserviceparts.

ITEMNUMBER DESCRIPTION PARTNUMBER

1 RETURNHOSE54" 7290

2 PRESSUREHOSE48" 7289

3 #12HOSECLAMP LS5001

4 HYDRAULICRESERVOIR 7319

5 1/2-13X31/2GR5BOLT NB577

6 1/2-13NYLOCKNUT NB281

7 RESERVOIRVENTPLUG 7379

8 3/8-16X1GR5BOLT NB604

9 1/2X31/2HITCHPINW/HAIRPIN NB648

10 SUCTIONHOSE18" 7346

11 #16HOSECLAMP LS4999

12 RETURNLINEFITTING 7329

13 FILTERHEAD LS1112

14 FILTERELEMENT LS1113

15 1/2-13X11/4GR5BOLT NB647

16 3/8-162-WAYLOCKNUT NB280

17 TANKBRACE 7352

18 3/8-16NYLOCKNUT NB182

20 HYDRAULICPUMP-LS622,LS67525MODEL LS2001H

HYDRAULICPUMP-LS928,LS11534MODELS LS2002B

21 1/8X1/2#3WOODRUFFKEY 024002

22 5/16-182-WAYLOCKNUT NB558

23 PUMPPULLEY 7306

24 SETSCREWW/NYLOCK NB312

25 5/16-18X3/4GR2BOLT NB143

26 FENDERBRACKET-RIGHTSIDE-LS11534ONLY 7417

FENDERBRACKET-LEFTSIDE-LS11534ONLY 7418

27 FENDER-LS11534ONLY 7428

28 KICKSTAND 7398

12

SERVICEPARTS

PleasehaveModelandSerialNumbersreadywhenorderingparts.

ITEMNUMBER DESCRIPTION PARTNUMBER

29 MOTORBASE/AXLE 7297

30 TIRE/WHEEL 7296

31 COTTERPIN NB633

32 WHEELDUSTCOVER 2203DC

33 CASTLENUT 2203CN

34 WASHER NB184

35 TAPEREDBEARING 2203B

36 BEARINGSEAL 2203S

37 BELT 644

38 IDLERARM 6681TK

39 CLUTCHLEVER 7358

40 SPRING 682S

41 3/8-16JAMNUT NB174

42 HARDENEDWASHER NB196

43 3/8-16X21/2GR5BOLT NB619

44 5/16-18FLANGENUT NB170

45 IDLERSPRINGMOUNT 2046

46 WIRELINKFORIDLERSPRING BRS6H

47 SHOULDERBOLT NB220

48 IDLERPULLEY B527

49 WASHER NB272

50 BELTCOVER 7321

51 #14x3/4SELF-TAPPINGSCREW NB161

52 SAFETYCLIPPIN H11

53 TOWINGTONGUE 7343

TOWINGTONGUE-LS11534 7168

54 TRAVELLOCK 7441

55 SAFETYCHAINW/HOOK 7366

56 2"BALLCOUPLER 7365

57 3/8-16X3GR5BOLT NB164

58 3/8-16X31/2GR5BOLT NB649

Colorcannotbeguaranteeduponserviceparts.

13

ITEMNUMBER DESCRIPTION PARTNUMBER

59 CLIPPIN NB642

60 STEELPIN 7293

61 HYDRAULICFITTING 7291

62 STATIONARYLINEASSEMBLY 7288

63 RAMCYLINDER-LS622MODELS 7284

RAMCYLINDER-LS928&LS67525MODEL 7354

RAMCYLINDER-LS11534&LS12534DMODEL 7355

64 1/2-13X3GR5BOLT NB131

65 SPLITTINGWEDGE 7233

66 1/2-13X21/2GR5CARRIAGEBOLT NB643

67 RETURNLINEFITTING 7329

68 1/2-13JAM2-WAYLOCKNUT NB121

69 2-WAYPIPENIPPLE 7292

70 MASTERCHAINLINK 7424

71 COTTERPIN NB597

72 VALVEINLETFITTING 7387

73 VALVECONTROLW/LEVER 7287

74 BEAMWELDMENT 7624

BEAMWELDMENT-LS12534DMODEL 7384

75 1/4X1CLEVISPIN NB522

76 1/2-13NUT NB213Z

77 VALVELEVER&GRIP 7423/7425

78 THINGIBPLATE 7388

79 THICKGIBPLATE 7237

80 BOTTOMGIBPLATE 7333

81 LOCKWASHER NB508

81A FLATWASHER NB555

62

61

64

68

60

70

69

67

66

65

61

74

72

71

73

75

77

79

80

81

78

76

BEAMDETAIL

ALLMODELS

NOTALLPARTSAREONALLMODELS

59

63

81A

14

ENGINEDETAIL

LS728CMODELS

ITEM# DESCRIPTION PART#

89 ENGINE N/A

90 5/16-18X11/4GR5BOLT NB504

91 5/16-182-WAYLOCKNUT NB558

92 UPPERSPACER BB105SL

93 ENGINEPULLEY BB105

94 LOWERSPACER BB105S

95 BELLEVILLEWASHER 699

96 7/16-20X1GR5BOLTW/NYLOCK NB452N

106 KEYSTOCK 9031

182 WASHER TR150W

NOTSHOWN WIRINGHARNESS-LS12534DMODEL 7416

NOTSHOWN OILDRAINVALVE AS122

NOTSHOWN FUELSHUTOFFVALVE(INLINE) 7414

ITEM# DESCRIPTION PART#

97 ENGINE N/A

98 5/16-18X21/2GR5BOLT NB138

99 5/16-182-WAYLOCKNUT NB558

100 5/16-18X11/4GR5BOLT NB504

101 KEYSTOCK 9030

102 SETSCREWW/NYLOCK NB312

103 ENGINEPULLEY-LS622 7323

104 BELLEVILLEWASHER 699

105 3/8-24X1BOLTW/NYLOCK NB238N

89

90

91

94

93

92

182

96

100

98

97

99

101

105

102

104

103

106

15

ENGINEDETAIL

LS10528CMODELS

95

19

NOTES

:

______________________________________________________________________

20

NOTES

:

______________________________________________________________________

22

NOTES

:

______________________________________________________________________

LS728C LS10528C

Splitting

Force

28Tons 28Tons

Engine

7HPBriggs and

StrattonIntek

10.5HPBriggs 

andStrattonI/C

Splitting

Positions

Horizontaland

Vertical

Horizontaland

Vertical

Cylinder

Size

41/2"X24" 41/2"X24"

Pump

2StagewithHeavy

DutyBearings 

2StagewithHeavy

DutyBearings

Pump

Specs

11Gallons Per

Minute

16Gallons Per

Minute

Valve

AutoReturn AutoReturn

Oil

Capacity

Approx.4.5Gallon Approx.4.5Gallon

Maximum

Loglength

24" 24"

TireSpecs

4.00X4.80X8

withHighSpeed

Bearings

4.00X4.80X8

withHighSpeed

Bearings

Metal

Fenders

No No

BallHitch

2"Ball 2"Ball

Unit

Weight

535Lbs

550Lbs

Models

23

SPECIFICATIONS

OWNER’S

MANUAL

MODELNO.

LS728C

LS10528C

HOWTOORDER

REPAIRPARTS

:

LOGSPLITTER

EachLogSplitterhasitsownserialnumber.Eachenginehas

itsownserialnumber.TheserialnumberfortheLogSplitter

willbefoundontherighthandsideofthehydraulicoil

reservoir.Theserialnumberfortheenginewillbefoundon

thetopoftheblowerfanhousing.

AllLogSplitterpartslistedhereinmaybeordereddirectly

fromSwisherMower&MachineCo.Inc.,yournearest

Swisherdealer,orfromourwebsite.

Allenginepartsmaybeorderedfromthenearestdealerofthe

enginesuppliedwithyourlogsplitter

.

Partssubjecttochange

withoutnotice.

WHENORDERINGPARTS,PLEASEHAVETHE

FOLLOWINGINFORMATIONAVAILABLE:

*PRODUCT– SWISHERLOGSPLITTER

*SERIALNUMBER- _______________

*MODELNUMBER- _______________

*ENGINEMODELNUMBER- _______________

TYPE- _______________

*PARTNUMBER

*PARTDESCRIPTION

www.swisherinc.com

TELEPHONE- 1-800-222-8183

FAX- 1-660-747-8650

SWISHERMOWER&MACHINECO.INC.

1602CORPORATEDRIVE

WARRENSBURG,MO64093

SWISHERMOWER&MACHINECO.INC.

Swisher LS728C, LS10528C User manual

This manual is also suitable for

Swisher LS728C, LS10528C User manual

Related papers

Other documents