Powermate PMC523202 User manual

Brand: Powermate

Model: PMC523202

Category: Power generators

Type: User manual

Page is loading ...

*5.5 HP Tecumseh OHV engine

*Low oil sensor

*Receptacles on endbell

*3 gallon plastic fuel tank

*Spark arrester

*Portability Kit

A.120 V, 20 Ampere Duplex Receptacle

This duplex is split so that 20 amps of current may be

drawn from each half of the receptacle. However, total power

drawn must be kept within nameplate ratings.

B.Circuit Breakers

The receptacles are protected by an AC circuit breaker. If

the generator is overloaded or an external short circuit occurs,

the circuit breaker will trip. If this occurs, disconnect all

electrical loads and try to determine the cause of the problem

before attempting to use the generator again. If overloading

causes the circuit breaker to trip, reduce the load. NOTE:

Continuous tripping of the circuit breaker may cause

damage to generator or equipment. The circuit breaker may

be reset by pushing the button of the breaker.

Warranty Coverage: Powermate Corporation (the Company)

warrants to the original retail customer in North America that it

will repair or replace, free of charge, any parts found by the

Company or its authorized service representative to be

defective in material or workmanship. This warranty covers the

cost of replacement parts and labor for defects in material or

workmanship.

Not Covered:

· Transportation charges for sending the product to the

Company or its authorized service representative for

warranty service, or for shipping repaired or replacement

products back to the customer; these charges must be

borne by the customer.

· Engine is covered exclusively by a separate warranty from

the engine manufacturer, included with the engine Manual.

· Damages caused by abuse or accident, and the effects of

corrosion, erosion and normal wear and tear.

· Warranty is voided if the customer fails to install, maintain

and operate the product in accordance with the instructions

and recommendations of the Company set forth in the

owner's manual, or if the product is used as rental

equipment.

· The Company will not pay for repairs or adjustments to the

product, or for any costs or labor, performed without the

Company's prior authorization.

Warranty Period: Two (2) years from the date of purchase on

products used solely for consumer applications; if a product is

used for business or commercial applications, the warranty

period will be limited to one (1) year from the date of purchase.

For warranty service, the customer must provide dated proof of

purchase and must notify the Company within the warranty

period.

For warranty service: Call toll free 800-445-1805, or write

to Powermate Corporation, Product Services, 4970 Airport

Road, P. O. Box 6001, Kearney, NE 68848.

EXCLUSIONS AND LIMITATIONS: THE COMPANY MAKES

NO OTHER WARRANTY OF ANY KIND, EXPRESS OR

IMPLIED. IMPLIED WARRANTIES, INCLUDING

WARRANTIES OF MERCHANTABILITY AND OF FITNESS

FOR A PARTICULAR PURPOSE, ARE HEREBY

DISCLAIMED. THE WARRANTY SERVICE DESCRIBED

ABOVE IS THE EXCLUSIVE REMEDY UNDER THIS

WARRANTY; LIABILITY FOR INCIDENTAL AND

CONSEQUENTIAL DAMAGES IS EXCLUDED TO THE

EXTENT PERMITTED BY LAW.

This warranty gives you specific legal rights, and you may also

have other rights which vary from state to state. Some states

do not allow a disclaimer of implied warranties, or the exclusion

or limitation of incidental and consequential damages, so the

above disclaimers and exclusions may not apply to you.

English

ENDBELL

MAJOR GENERATOR FEATURES

LIMITED WARRANTY

CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT

YOUR WARRANTY RIGHTS AND OBLIGATIONS

The California Air Resources Board and Powermate Corporation (herein "Powermate") are pleased to explain the evaporative emission

control system (EECS) warranty on your 2006 generator. In California, new generators must be designed, built and equipped to meet the

State's stringent anti-smog standards. Powermate must warrant the EECS on your generator for the periods of time listed below, provided

there has been no abuse, neglect or improper maintenance of your generator.

Your EECS includes parts such as: fuel hoses.

MANUFACTURER'S WARRANTY COVERAGE:

This evaporative emission control system is warranted for two years. The warranty period begins on the date the generator is delivered to

an ultimate purchaser.

Powermate warrants to the ultimate purchaser and any subsequent owner that the generator is (i) designed, built and equipped so as to

conform with all applicable regulations; and (ii) free from defects in materials and workmanship that cause the failure of a warranted part

to be identical in all material respects to that part as described in Powermate's application for certification.

If any evaporative emission-related part on your generator is defective, the part will be repaired or replaced by Powermate.

OWNER'S WARRANTY RESPONSIBILITIES:

As the generator owner, you are responsible for performance of the required maintenance listed in your owner's manual. Powermate

recommends that you retain all receipts covering maintenance on your generator, but Powermate cannot deny warranty solely for the lack

of receipts. You should, however, be aware that Powermate may deny you warranty coverage if your generator or a part has failed due to

abuse, neglect or improper maintenance or unapproved modifications.

You are responsible for presenting your generator to an authorized Powermate warranty service center as soon as the problem exists. The

warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have a question regarding your

warranty coverage, you should call Powermate Product Service at 1-800-445-1805.

DETAILS OF YOUR WARRANTY

Subject to certain conditions and exclusions as stated below, the warranty on emission-related parts is as follows:

(1)Any warranted part that is not scheduled for replacement as required maintenance in the written instructions supplied, is warranted

for the period stated above. If the part fails during the period of warranty coverage, the part will be repaired or replaced by

Powermate according to Subsection (4) below. Any such part repaired or replaced under warranty will be warranted for the

remainder of the period.

(2)Any warranted part that is scheduled only for regular inspection in the written instructions supplied, is warranted for the warranty

period stated above. Any such part repaired or replaced under warranty will be warranted for the remaining warranty period.

(3)Any warranted part that is scheduled for replacement as required maintenance in the written instructions supplied, is warranted for

the period of time before the first scheduled replacement date for that part. If the part fails before the first scheduled replacement

date, the part will be repaired or replaced by Powermate according to Subsection (4) below. Any such part repaired or replaced under

warranty will be warranted for the remainder of the period prior to the first scheduled replacement date for the part.

(4)Repair or replacement of any warranted part under the warranty provisions herein must be performed at an authorized Powermate

warranty service center at no charge to the owner.

(5)The generator owner will not be charged for diagnostic labor that is directly associated with diagnosis of a defective,

emission-related warranted part, provided that such diagnostic work is performed at an authorized Powermate warranty service

center.

(6)Powermate is liable for damages to other engine or generator components proximately caused by a failure under warranty of any

warranted part.

(7)Throughout the generator warranty period stated above, Powermate will maintain a supply of warranted parts sufficient to meet the

expected demand for such parts.

(8)Any replacement part may be used in the performance of any warranty maintenance or repairs and must be provided without charge

to the owner. Such use will not reduce the warranty obligations of Powermate.

(9)Add-on or modified parts that are not exempted by the Air Resources Board may not be used. The use of any non-exempted add-on

or modified parts by the ultimate purchaser will be grounds for disallowing a warranty claims. Powermate will not be liable to war

rant failures or warranted parts caused by the use of a non-exempted add-on or modified part.

(10)The repair or replacement of any warranted part otherwise eligible for warranty coverage may be excluded from such warranty

coverage if the generator has been abused, neglected or improperly maintained, and such abuse, neglect or improper maintenance

was the direct cause of the need for repair or replacement of the part.

WARRANTED PARTS:

The following emission warranty parts list is covered:

Fuel Hose.

English

Page is loading ...

PARTS LIST / LISTE DES PIÈCES / LISTA DE PIEZAS

RefPartDescription Description DescripciónQty

No.No.

1Note A Engine, 5.5 hp OHVMoteurMotor1

20050448.01Adapter, engineAdapateur por moteurAdaptor, motor1

30000901.01Bolt, Wz 5/16-24 x 5/8Boulon, wzPerno, wz4

40051874Rotor, 3.0 KW RotorRotor1

5Note BWasher, lock 5/16Contre-écrouArandela, de cierre3

60035055Bolt, hex 5/16-24 x 6 5/8Boulon, tête hexPerno, hexagonal1

70055516Stator 3.0 KW 60 Hz Stator Stator1

80034801Connector hsg. set, Jeu pr logemt prise,Conjunto de conectores

endbellcouvre-enrouldel alojamiento1

100057478Endbell, wired completeCovre-enroulementCaja posterior con cable

câblage complet1

10A0050439Brush, E-4RBalaisEscobilla2

10C0034819.01Capacitor CapaciteurCapacitor1

10D0034843.01Diode DiodeDiodos2

10E0038976Heat sink, diodeDiode dissipatriceSumidero térmico, diodos

de chaleur1

10F0062745Cover, brushCouvre-balaisCubierta, escobill1

10G0049071Circuit breaker, 20 ampDisjoncteur 20 ACortacircuitos, 20 amp2

110051872.01Bolt, hex hd 1/4-20 x 4 1/2Boulon, tête hexPerno, hexagonal4

120008854Lug, groundOeillet de mise à la terreTerminal, tierra1

150040832Nut, nyloc 1/4-20Écrous nylocTuerca, nyloc9

160057375Carrier assemblyEnsemble transportTransportador, conjunto1

190051094Isolator, engineSectionneurs moteurAislador, motor2

200049743Isolator, statorSectionneurs stator Aislador, estator1

210012526Bolt, hex 1/4-20 x 3/4Boulon, tête hexPerno, hexagonal1

230057254Nut, flg 5/16-18Écrous 5/16Tuerca, 5/164

24Note BWasher, flat 5/16Rondelle plates 5/16Arandela, plana 5/162

250049352Washer, flat 5/16 WRondelle plates 5/16 largeArandela, plana 5/16 lejos 4

26Note BBolt, 5/16-18 x 1 1/4BoulonPerno2

270047796Spacer 3/4”EntretoisesEspaciador1

280049224Assy, ground wireEns fil de masse tresséConjunto, cable trenzado

a tierra1

29Note BWasher, star external 5/16Rondelles à dents ext.Arandela, estrella externa3

30Note BBolt, hex 5/16-18 x 3/4Boulon, tête hexPerno, hexagonal1

330055468Shield, heatÉcran de chaleurPantalla para el calor1

36Note CTank assy, completeAss.complet du réservoir Conjunto tanque completo1

36A0055340Cap, fuelCapuchonTapa de combustible1

36B

0062673Fuel BushingBague d’essenceBuje de combustible1

36C0061756Fuel shut off with filterRobinet de carburantVálvula combustible con filtro1

380048243Step bushingBagues de réduction àTornillo4

gradins

Note A:

Powermate Corporation will not provide engines as replacement parts. Engines are covered through the engine manufacturer's warranty. Consult the accompanying

engine manual or contact our service department for assistance.

Note B:

These are standard parts available at your local hardware store.

Note C:

Contact your nearest Coleman® Powermate® Service Center for replacement fuel tanks.

WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should

perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit.

Electrical: For models approved for the City of Los Angeles, the ampacity of the phase conductors from the generator terminals to the first over

current device shall not be less than 115 percent of the nameplate rating of the generator.

Remarque A:

Powermate Corporation ne fournit pas de moteurs dans ses pièces détachées. Les moteurs sont couverts par la garantie du fabricant de moteurs. Consulter le

manuel du moteur inclus ou contacter notre département de service après-vente pour toute assistance.

Remarque B:

Ces pièces sont des pièces standard disponibles en quincaillerie.

Remarque C:

Pour commander un réservoir de rechange, contacter Centre de service Coleman® Powermate® le plus proche.

DANGER: Pour éviter toute blessure personnelle ou dommage à l’équipement, l’installation et tout entretien devralent être effectués par un électricien

qualifié ou un préposé au service autorisé. En aucun cas, une personne non-qualifiée ne devrait essayer de faire le raccord au circuit principal.

Électricité: Pour les modèles a approuvé pour la ville de Los Angeles: La charge limite en ampères des fils de phase allant des bornes du groupe électrogène au

premier appareil en surcharge ne doit pas être inférieure à 115% de la puissance nominale indiquée sur la plaque des caractéristiques du groupe électrogène.

Nota A:

Powermate Corporation no proporcionará los motores como repuestos. Los motores están cubiertos por medio de la garantía del fabricante del motor. Consulte el

manual adjunto del motor o comuníquese con nuestro departamento de servicio para recibir ayuda al respecto.

Nota B:

Estas son piezas estándar disponibles en su ferretería local.

Nota C:

Para hacer pedidos de tanques, localice el Centro de Servicio de Coleman® Powermate® más cercano.

ADVERTENCIA: Para evitar posibles lesiones físcas o daños materiales, es necesario que la instalación y todo el servicio sea realizado por un electricista

matriculado o representatnte de servicio autorizado. Bajo ninguna circunstancia debe permitirse que una persona que no está capacitad trate de

manipular cables dentro del circuito de servicio eléctrico.

Eléctricos:

El amperaje de los conductores de fase desde los terminales del generador al primer dispositivo de sobrecorriente no podrâ ser menor que 115 porciento