Hansgrohe 39115001 Installation guide

Hansgrohe
Brand
Hansgrohe
Model
39115001
Category
Sanitary ware
Type
Installation guide

Hansgrohe 39115001 is a piece of bathroom equipment that requires professional installation. It can be used in various bathroom settings for controlling the flow of water. Take into account that you will need a 13622181 rough-in kit before you can install it. The minimum water pressure required for this device is 15 PSI while the maximum is 145 PSI. As for the temperature, it can handle a minimum of 120°F and a maximum of 176°F. The flow rate of this device is 1.5 GPM.

Hansgrohe 39115001 is a piece of bathroom equipment that requires professional installation. It can be used in various bathroom settings for controlling the flow of water. Take into account that you will need a 13622181 rough-in kit before you can install it. The minimum water pressure required for this device is 15 PSI while the maximum is 145 PSI. As for the temperature, it can handle a minimum of 120°F and a maximum of 176°F. The flow rate of this device is 1.5 GPM.

Page is loading ...
Technical Information
Recommendedwaterpressure 15-75PSI
Max.waterpressure 145PSI
Recommendedhotwatertemp. 10°-140°F*
Max.hotwatertemp 176°F*
Flowrate 1.5GPM
*Pleaseknowandfollowallapplicablelocalplumbing
codeswhensettingthetemperatureonthewaterheater.
English
Installation Considerations
Forbestresults,Hansgroherecommendsthat
thisunitbeinstalledbyalicensed,professional
plumber.
Pleasereadovertheseinstructionsthoroughlybe
-
forebeginninginstallation.Makesurethatyou
havealltoolsandsuppliesneededtocomplete
theinstallation.
Thisfaucetrequiresrough136181(not
included).Theroughmustbeinstalledandthe
nishedwallcompletedandmadewatertight
beforeinstallationofthetrimkit.
This trim is not compatible with
old-style rough 38111181.
If rough 38111181 is already installed,
please contact Hansgrohe Technical Ser-
vice regarding the additional parts and
special instructions necessary to install
this trim kit.
Keepthisbookletandthereceipt(orotherproof
ofdateandplaceofpurchase)forthisproductin
asafeplace.Thereceiptisrequiredshoulditbe
necessarytorequestwarrantyparts.
•
•
•
•
•
Tools Required / Outiles Utiles /
Herramientas Útiles
8 mm
17 mm
30 mm
27 mm
A11.18.1-005
CSAB15.1-005
ICC/ANSIA117.1
Page is loading ...
4
English
Installation
Turn the water o at the main
before proceeding.
Removethecaps.
Cuttheplastershieldssothattheyextend¹⁄₁₆"out
-
sidethesurfaceofthenishedwall.
Seal the wall around the plaster
shields using waterproof sealant.
Failure to seal the wall can lead to
possible water damage.
1
2
3
Page is loading ...
6
English
Removetheplugfromthespoutport.
Removethenut,ushinsert,andsealingringfromthe
cartridgeport.
Installthecartridgeadapterandsealingringsonthe
cartridge.
Lightlylubricatethecartridgeo-ringusingwhite
plumbersgrease.
Insertthecartridgeinthecartridgecover,orientedas
shownonthediagram.
17 mm
30 mm
!
4
5
6
Page is loading ...
8
English
Installthecartridge.
Holdthecartridgestemsteadywithonehand.
Withtheotherhand,rotatethecoverclockwiseto
secureittotherough.
Tightenthecoverusinga7mmwrench.
27 mm
7
8
9
Page is loading ...
10
English
Installthehandle.
TightenthehandlescrewusingammAllenwrench.
Measurethedistancebetweenthewallandtheedge
ofthehandle.
Ifthedistancemeasures3¼"-3⅝",selectsleevesA.
A
3¼"-3⅝"
1¼"
2 mm
10
11
12
Page is loading ...
1
English
Ifthedistancemeasures3⅝"-4"selectsleevesB.
Ifthedistancemeasures4"-4⅜",selectsleevesC.
Connectthethreadedringstotheselectedsleeves.
3⅝"-4"
B
⅞"
C
4"-4⅜"
½"
13
Page is loading ...
14
English
Measurethedistancefromthesurfaceofthespout
portroughtotheoutsideedgeoftheplastershield
("X").
Add
1¾"mmtoX.
CutthethreadednipplesothatitisX+
1¾"long.
WrapthethreadsonthenipplewithTeontape.
X + 1¾"
14
15
16
Page is loading ...
16
English
Installthenipple.
Tightenthenippleusingan8mmAllenwrench.
Installthebaseplate.
Installthesleeve/threadedringassemblies.
8 mm
17
18
19
Page is loading ...
18
English
Tightenthethreadedringsusingtheservicekey.
Lightlylubricatetheo-ringonthespoutcover.Push
thecoverintoplace.
Pushthespoutoverthenipple.
Tightenthespoutscrewusinga3mmAllenwrench.
3 mm
20
21
22
Page is loading ...
0
English
Lightlylubricatetheo-ringonthehandlecover.
Installthecover.
Installtheange.
23
24
Page is loading ...
Page is loading ...
3
Replacement Parts / Pièces détachées / Repuestos
xx=colors/couleurs/acabados
00=chrome
8=brushednickel
13185xx0
96908xx0
9691xx0
3909xx0
96339000
9739xx0
97695xx0
96914xx0
1,95x1,78
31971000
34x
34x
97971000
A C
B
978000
95644000
95645000
97601000
97660000
4
Cleaning Recommendation for Hansgrohe Products
Modernlavatoryfaucets,kitchenfaucets,andshowersconsistofverydierentmaterialstocomplywiththeneedsofthemarketwithregardto
designandfunctionality.Toavoiddamageandreturns,itisnecessarytoconsidercertaincriteriawhencleaning.
Cleaning Materials for Faucets and Showers
Acidsareanecessaryingredientofcleaningmaterialsforremovinglime,howeverpleasepayattentiontothefollowingpointswhencleaning
faucetsandshowers:
Onlyusecleaningmaterialswhichareexplicitlyintendedforthistypeofapplication.
Neverusecleaningmaterialswhichcontainhydrochloric,formic,phosphoric,oraceticacid,astheycauseconsiderabledamage.
Nevermixonecleaningmaterialwithanother.
Neverusecleaningmaterialsorapplianceswithanabrasiveeect,suchasunsuitablecleaningpowders,spongepads,ormicrober
cloths.
Cleaning Instructions for Faucets and Showers
Pleasefollowthecleaningmaterialmanufacturer’sinstructions.Inaddition,payattentiontothefollowingpoints:
Cleanthefaucetsandshowersasandwhenrequired
Usetheamountofcleaningproductandtheamountoftimerecommendedbythemanufacturer.Donotleavethecleaneronthexture
longerthannecessary.
Regularcleaningcanpreventcalcication.
Whenusingspraycleaners,sprayrstontoasoftclothorsponge.Neverspraydirectlyontothefaucetasdropletscanenteropenings
andgapsandcausedamage.
Aftercleaning,rinsethoroughlywithcleanwatertoremoveanycleanerresidue.
Important
Residuesofliquidsoaps,shampoos,andshowerfoamscanalsocausedamage,sorinsewithcleanwaterafterusing.
Please note:ifthesurfaceisalreadydamaged,theeectofcleaningmaterialswillcausefurtherdamage.
Components with damaged surfaces must be replaced or injury could result.
Damage caused by improper treatment is not covered under the warranty.
•
•
•
•
•
•
•
•
•
Recommandations pour le nettoyage des produits Hansgrohe
Lesrobinetteriesmodernesdelavabo,decuisineetdedoucheutilisentdesmatériauxtrèsdiérentspourrépondreauxbesoinsdumarchéen
termesdeconceptionetdefonctionnalité.Certainesrèglesdebasedoiventêtrerespectéeslorsdunettoyagedecesproduitsand’éviterde
lesendommageroud’avoiràlesretourner.
Produits de nettoyage pour robinetteries et douches
Lesacidessontunepartieintégrantenécessairedetouslesproduitsdedétartrage;ilfautcependantprendrelesprécautionssuivanteslorsdu
nettoyagedesrobinetsetdesdouches:
N’utilisezquedesproduits/articlesdenettoyageconçusspéciquementpourlesarticlesderobinetterieetdedouche.
N’utilisezjamaisdeproduits/articlesdenettoyagecontenantdel’acidechlorhydrique,formique,phosphoriqueouacétiquecarils
pourraientcauserdesdommagesconsidérables.
Nemélangezjamaisdeuxproduitsdenettoyage.
N’utilisezjamaisdeproduits/articlesdenettoyagedenatureabrasivetelsquepoudresdenettoyage,tampons-épongeouchions
microbrenonappropriés.
Instructions de nettoyage pour robinetteries et douches
Veuillezsuivrelesinstructionsdufabricantdeproduits/articlesdenettoyage.Deplus,tenezcomptedesconseilssuivants:
•
•
•
•
Page is loading ...
6
Limited Consumer Warranty
ThisproducthasbeenmanufacturedandtestedtothehighestqualitystandardsbyHansgrohe,Inc.(“Hansgrohe”).
ThiswarrantyislimitedtoHansgroheproductsthatarepurchasedbyaconsumerintheUnitedStatesorCanadaafter
March1,1996,andinstalledineitherintheUnitedStatesorinCanada.
WHO IS COVERED BY THE WARRANTY
Thiswarrantyextendstotheoriginalpurchaseronly.Thiswarrantyisnon-transferable.
WHAT IS COVERED BY THE WARRANTY
ThewarrantycoversonlyyourHansgrohemanufacturedproduct.Hansgrohewarrantsthisproductagainstdefectsin
materialorworkmanshipasfollows:
Hansgrohewillreplaceatnochargeforpartsonlyor,atitsoption,replaceanyproductorpartoftheproductthatproves
defectivebecauseofimproperworkmanshipand/ormaterial,undernormalinstallation,use,serviceandmaintenance.If
Hansgroheisunabletoprovideareplacementandrepairisnotpracticalorcannotbemadeintimelyfashion,Hansgrohe
mayelecttorefundthepurchasepriceinexchangeforthereturnoftheproduct.
LENGTH OF WARRANTY
Replacementorrepairedpartsofproductswillbecoveredforthetermofthiswarranty,asstatedinthefollowingtwo
sentences.Ifyouareaconsumerwhopurchasedtheproductforuseprimarilyforpersonal,familyorhouseholdpurposes,
thiswarrantyextendsforaslongasyouowntheproductandthehomeinwhichtheproductisoriginallyinstalled.Ifyou
purchasedtheproductforuseprimarilyforanyotherpurpose,including,withoutlimitation,acommercialpurpose,this
warrantyextendsonly(i)for1year,withrespecttoHansgrohe&Commercialproducts,and(ii)for5years,withrespectto
Axorproducts.
THIS WARRANTY DOES NOT COVER, AND HANSGROHE WILL NOT PAY FOR:
A.Conditions,malfunctionsordamagenotresultingfromdefectsinmaterialorworkmanship.
B.Conditions,malfunctionsordamageresultingfrom(1)normalwearandtear,improperinstallation,improper
maintenance,misuse,abuse,negligence,accidentoralteration;()theuseofabrasiveorcausticcleaningagentsor“no-
rinse”cleaningproducts,ortheuseoftheproductinanymannercontrarytotheproductinstructions;or(3)conditionsin
thehomesuchasexcessivewaterpressureorcorrosion.
C.Laborandotherexpensesfordisconnection,deinstallation,orreturnoftheproductforwarrantyservice
(includingbutnotlimitedtoproperpackagingandshippingcosts),orforinstallationorreinstallationoftheproduct.
D.Accessories,connectedmaterialsandproducts,orrelatedproductsnotmanufacturedbyHansgrohe.
E.AnyHansgroheorAxorproductsoldfordisplaypurposes.
F.RubbedBronzenishissubjecttoa3-yearlimitedwarranty.ChromeandallPVDnishesarecoveredbythelimited
lifetimewarranty.
G.HansgroheWaterFiltrationSystemissubjecttoa1-yearlimitedwarranty.Warrantydoesnotincludereplacement
lters.
TO OBTAIN WARRANTY PARTS OR INFORMATION
ContactyourHansgroheretailer,orcontactTechnicalServiceat:
Hansgrohe,Inc.
149BluegrassLakesParkway
Alpharetta,GA30004
Toll-free800-334-0455
Inrequestingwarrantyservice,youwillneedtoprovide:
1.Thesalesreceiptorotherevidenceofthedateandplaceofpurchase.
.Adescriptionoftheproblem.
3.Deliveryoftheproductorthedefectivepart,postageprepaidandcarefullypackedandinsured,to:
Hansgrohe,Inc.
149BluegrassLakesParkway
Alpharetta,GA30004
Toll-free800-334-0455
7
Whenwarrantyserviceiscompleted,anyrepairedorreplacementproductorpartwillbereturnedtoyoupostageprepaid.
EXCLUSIONS AND LIMITATIONS
REPAIR OR REPLACEMENT (OR, IN LIMITED CIRCUMSTANCES, REFUND OF THE PURCHASE PRICE) AS
PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE PURCHASER. HANSGROHE
NEITHER ASSUMES NOR AUTHORIZES ANY PERSON TO CREATE FOR IT ANY OTHER OBLIGATION OR
LIABILITY IN CONNECTION WITH THIS PRODUCT. HANSGROHE SHALL NOT BE LIABLE TO PURCHASER
OR ANY OTHER PERSON FOR ANY INCIDENTAL, SPECIAL OR CONSEQUENTIAL DAMAGES, ARISING OUT
OF BREACH OF THIS WARRANTY OR ANY IMPLIED WARRANTY (INCLUDING BUT NOT LIMITED TO ANY
IMPLIED WARRANTY OF MERCHANTABILITY).
SomeStatesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamages,sotheabovelimitationor
exclusionmaynotapplytoyou.Thiswarrantygivesyouspeciclegalrights,andyoumayalsohaveotherrightsthatvary
fromstatetostate.
TO THE EXTENT PERMITTED BY LAW, ANY IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS
FOR A PARTICULAR PURPOSE, ARE LIMITED TO THE DURATION OF THE EXPRESS WARRANTY.
Somestatesdonotallowlimitationsonhowlonganimpliedwarrantymaylast,sotheabovelimitationsmaynotapplyto
you.Youmayberequiredbylawtogiveusareasonableopportunitytocorrectorcureanyfailuretocomplybeforeyou
canbringanyactionincourtagainstusundertheMagnuson-MossWarrantyAct.
PRODUCT INSTRUCTIONS AND QUESTIONS
Uponpurchaseorpriortoinstallation,pleasecarefullyinspectyourHansgroheproductforanydamageorvisibledefect.
Priortoinstalling,alwayscarefullystudytheenclosedinstructionsontheproperinstallationandthecareandmaintenanceof
thisproduct.Ifyouhavequestionsatanytimeabouttheuse,installationorperformanceofyourHansgroheproduct,orthis
warranty,pleasewriteusorcallustoll-freeat800-334-0455.
Hansgrohe,Inc.•1490BluegrassLakesParkway•Alpharetta,GA30004
Tel.770-360-9880
•Fax770-360-9887
www.hansgrohe-usa.com
US-InstallationInstructions•PartNo.90575807•Revised04/011
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28

Hansgrohe 39115001 Installation guide

Hansgrohe
Brand
Hansgrohe
Model
39115001
Category
Sanitary ware
Type
Installation guide

Hansgrohe 39115001 is a piece of bathroom equipment that requires professional installation. It can be used in various bathroom settings for controlling the flow of water. Take into account that you will need a 13622181 rough-in kit before you can install it. The minimum water pressure required for this device is 15 PSI while the maximum is 145 PSI. As for the temperature, it can handle a minimum of 120°F and a maximum of 176°F. The flow rate of this device is 1.5 GPM.

Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages

Related papers

Other documents