Hansgrohe 39115001 Installation guide

Brand: Hansgrohe

Model: 39115001

Category: Sanitary ware

Type: Installation guide

Hansgrohe 39115001 is a piece of bathroom equipment that requires professional installation. It can be used in various bathroom settings for controlling the flow of water. Take into account that you will need a 13622181 rough-in kit before you can install it. The minimum water pressure required for this device is 15 PSI while the maximum is 145 PSI. As for the temperature, it can handle a minimum of 120°F and a maximum of 176°F. The flow rate of this device is 1.5 GPM.

Page is loading ...



Technical Information

Recommendedwaterpressure 15-75PSI

Max.waterpressure 145PSI

Recommendedhotwatertemp. 10°-140°F*

Max.hotwatertemp 176°F*

Flowrate 1.5GPM

*Pleaseknowandfollowallapplicablelocalplumbing

codeswhensettingthetemperatureonthewaterheater.

English

Installation Considerations

Forbestresults,Hansgroherecommendsthat

thisunitbeinstalledbyalicensed,professional

plumber.

Pleasereadovertheseinstructionsthoroughlybe

forebeginninginstallation.Makesurethatyou

havealltoolsandsuppliesneededtocomplete

theinstallation.

Thisfaucetrequiresrough136181(not

included).Theroughmustbeinstalledandthe

nishedwallcompletedandmadewatertight

beforeinstallationofthetrimkit.

This trim is not compatible with

old-style rough 38111181.

If rough 38111181 is already installed,

please contact Hansgrohe Technical Ser-

vice regarding the additional parts and

special instructions necessary to install

this trim kit.

Keepthisbookletandthereceipt(orotherproof

ofdateandplaceofpurchase)forthisproductin

asafeplace.Thereceiptisrequiredshoulditbe

necessarytorequestwarrantyparts.

•

Tools Required / Outiles Utiles /

Herramientas Útiles

8 mm

17 mm

30 mm

27 mm

A11.18.1-005

CSAB15.1-005

ICC/ANSIA117.1

Page is loading ...

English

Installation

Turn the water o at the main

before proceeding.

Removethecaps.

Cuttheplastershieldssothattheyextend¹⁄₁₆"out

sidethesurfaceofthenishedwall.

Seal the wall around the plaster

shields using waterproof sealant.

Failure to seal the wall can lead to

possible water damage.

Page is loading ...

English

Removetheplugfromthespoutport.

Removethenut,ushinsert,andsealingringfromthe

cartridgeport.

Installthecartridgeadapterandsealingringsonthe

cartridge.

Lightlylubricatethecartridgeo-ringusingwhite

plumbersgrease.

Insertthecartridgeinthecartridgecover,orientedas

shownonthediagram.

17 mm

30 mm

Page is loading ...

English

Installthecartridge.

Holdthecartridgestemsteadywithonehand.

Withtheotherhand,rotatethecoverclockwiseto

secureittotherough.

Tightenthecoverusinga7mmwrench.

27 mm

Page is loading ...

English

Installthehandle.

TightenthehandlescrewusingammAllenwrench.

Measurethedistancebetweenthewallandtheedge

ofthehandle.

Ifthedistancemeasures3¼"-3⅝",selectsleevesA.

3¼"-3⅝"

1¼"

2 mm

Page is loading ...

1

English

Ifthedistancemeasures3⅝"-4"selectsleevesB.

Ifthedistancemeasures4"-4⅜",selectsleevesC.

Connectthethreadedringstotheselectedsleeves.

3⅝"-4"

⅞"

4"-4⅜"

½"

Page is loading ...

English

Measurethedistancefromthesurfaceofthespout

portroughtotheoutsideedgeoftheplastershield

("X").

Add

1¾"mmtoX.

CutthethreadednipplesothatitisX+

1¾"long.

WrapthethreadsonthenipplewithTeontape.

X + 1¾"

Page is loading ...

English

Installthenipple.

Tightenthenippleusingan8mmAllenwrench.

Installthebaseplate.

Installthesleeve/threadedringassemblies.

8 mm

Page is loading ...

English

Tightenthethreadedringsusingtheservicekey.

Lightlylubricatetheo-ringonthespoutcover.Push

thecoverintoplace.

Pushthespoutoverthenipple.

Tightenthespoutscrewusinga3mmAllenwrench.

3 mm

Page is loading ...

0

English

Lightlylubricatetheo-ringonthehandlecover.

Installthecover.

Installtheange.

Page is loading ...

3

Replacement Parts / Pièces détachées / Repuestos

xx=colors/couleurs/acabados

00=chrome

8=brushednickel

13185xx0

96908xx0

9691xx0

3909xx0

96339000

9739xx0

97695xx0

96914xx0

1,95x1,78

31971000

34x

97971000

A C

978000

95644000

95645000

97601000

97660000

4

Cleaning Recommendation for Hansgrohe Products

Modernlavatoryfaucets,kitchenfaucets,andshowersconsistofverydierentmaterialstocomplywiththeneedsofthemarketwithregardto

designandfunctionality.Toavoiddamageandreturns,itisnecessarytoconsidercertaincriteriawhencleaning.

Cleaning Materials for Faucets and Showers

Acidsareanecessaryingredientofcleaningmaterialsforremovinglime,howeverpleasepayattentiontothefollowingpointswhencleaning

faucetsandshowers:

Onlyusecleaningmaterialswhichareexplicitlyintendedforthistypeofapplication.

Neverusecleaningmaterialswhichcontainhydrochloric,formic,phosphoric,oraceticacid,astheycauseconsiderabledamage.

Nevermixonecleaningmaterialwithanother.

Neverusecleaningmaterialsorapplianceswithanabrasiveeect,suchasunsuitablecleaningpowders,spongepads,ormicrober

cloths.

Cleaning Instructions for Faucets and Showers

Pleasefollowthecleaningmaterialmanufacturer’sinstructions.Inaddition,payattentiontothefollowingpoints:

Cleanthefaucetsandshowersasandwhenrequired

Usetheamountofcleaningproductandtheamountoftimerecommendedbythemanufacturer.Donotleavethecleaneronthexture

longerthannecessary.

Regularcleaningcanpreventcalcication.

Whenusingspraycleaners,sprayrstontoasoftclothorsponge.Neverspraydirectlyontothefaucetasdropletscanenteropenings

andgapsandcausedamage.

Aftercleaning,rinsethoroughlywithcleanwatertoremoveanycleanerresidue.

Important

Residuesofliquidsoaps,shampoos,andshowerfoamscanalsocausedamage,sorinsewithcleanwaterafterusing.

Please note:ifthesurfaceisalreadydamaged,theeectofcleaningmaterialswillcausefurtherdamage.

Components with damaged surfaces must be replaced or injury could result.

Damage caused by improper treatment is not covered under the warranty.

•

Recommandations pour le nettoyage des produits Hansgrohe

Lesrobinetteriesmodernesdelavabo,decuisineetdedoucheutilisentdesmatériauxtrèsdiérentspourrépondreauxbesoinsdumarchéen

termesdeconceptionetdefonctionnalité.Certainesrèglesdebasedoiventêtrerespectéeslorsdunettoyagedecesproduitsand’éviterde

lesendommageroud’avoiràlesretourner.

Produits de nettoyage pour robinetteries et douches

Lesacidessontunepartieintégrantenécessairedetouslesproduitsdedétartrage;ilfautcependantprendrelesprécautionssuivanteslorsdu

nettoyagedesrobinetsetdesdouches:

N’utilisezquedesproduits/articlesdenettoyageconçusspéciquementpourlesarticlesderobinetterieetdedouche.

N’utilisezjamaisdeproduits/articlesdenettoyagecontenantdel’acidechlorhydrique,formique,phosphoriqueouacétiquecarils

pourraientcauserdesdommagesconsidérables.

Nemélangezjamaisdeuxproduitsdenettoyage.

N’utilisezjamaisdeproduits/articlesdenettoyagedenatureabrasivetelsquepoudresdenettoyage,tampons-épongeouchions

microbrenonappropriés.

Instructions de nettoyage pour robinetteries et douches

Veuillezsuivrelesinstructionsdufabricantdeproduits/articlesdenettoyage.Deplus,tenezcomptedesconseilssuivants:

•

Page is loading ...

6

Limited Consumer Warranty

ThisproducthasbeenmanufacturedandtestedtothehighestqualitystandardsbyHansgrohe,Inc.(“Hansgrohe”).

ThiswarrantyislimitedtoHansgroheproductsthatarepurchasedbyaconsumerintheUnitedStatesorCanadaafter

March1,1996,andinstalledineitherintheUnitedStatesorinCanada.

WHO IS COVERED BY THE WARRANTY

Thiswarrantyextendstotheoriginalpurchaseronly.Thiswarrantyisnon-transferable.

WHAT IS COVERED BY THE WARRANTY

ThewarrantycoversonlyyourHansgrohemanufacturedproduct.Hansgrohewarrantsthisproductagainstdefectsin

materialorworkmanshipasfollows:

Hansgrohewillreplaceatnochargeforpartsonlyor,atitsoption,replaceanyproductorpartoftheproductthatproves

defectivebecauseofimproperworkmanshipand/ormaterial,undernormalinstallation,use,serviceandmaintenance.If

Hansgroheisunabletoprovideareplacementandrepairisnotpracticalorcannotbemadeintimelyfashion,Hansgrohe

mayelecttorefundthepurchasepriceinexchangeforthereturnoftheproduct.

LENGTH OF WARRANTY

Replacementorrepairedpartsofproductswillbecoveredforthetermofthiswarranty,asstatedinthefollowingtwo

sentences.Ifyouareaconsumerwhopurchasedtheproductforuseprimarilyforpersonal,familyorhouseholdpurposes,

thiswarrantyextendsforaslongasyouowntheproductandthehomeinwhichtheproductisoriginallyinstalled.Ifyou

purchasedtheproductforuseprimarilyforanyotherpurpose,including,withoutlimitation,acommercialpurpose,this

warrantyextendsonly(i)for1year,withrespecttoHansgrohe&Commercialproducts,and(ii)for5years,withrespectto

Axorproducts.

THIS WARRANTY DOES NOT COVER, AND HANSGROHE WILL NOT PAY FOR:

A.Conditions,malfunctionsordamagenotresultingfromdefectsinmaterialorworkmanship.

B.Conditions,malfunctionsordamageresultingfrom(1)normalwearandtear,improperinstallation,improper

maintenance,misuse,abuse,negligence,accidentoralteration;()theuseofabrasiveorcausticcleaningagentsor“no-

rinse”cleaningproducts,ortheuseoftheproductinanymannercontrarytotheproductinstructions;or(3)conditionsin

thehomesuchasexcessivewaterpressureorcorrosion.

C.Laborandotherexpensesfordisconnection,deinstallation,orreturnoftheproductforwarrantyservice

(includingbutnotlimitedtoproperpackagingandshippingcosts),orforinstallationorreinstallationoftheproduct.

D.Accessories,connectedmaterialsandproducts,orrelatedproductsnotmanufacturedbyHansgrohe.

E.AnyHansgroheorAxorproductsoldfordisplaypurposes.

F.RubbedBronzenishissubjecttoa3-yearlimitedwarranty.ChromeandallPVDnishesarecoveredbythelimited

lifetimewarranty.

 G.HansgroheWaterFiltrationSystemissubjecttoa1-yearlimitedwarranty.Warrantydoesnotincludereplacement

lters.

TO OBTAIN WARRANTY PARTS OR INFORMATION

ContactyourHansgroheretailer,orcontactTechnicalServiceat:

Hansgrohe,Inc.

149BluegrassLakesParkway

Alpharetta,GA30004

Toll-free800-334-0455

Inrequestingwarrantyservice,youwillneedtoprovide:

1.Thesalesreceiptorotherevidenceofthedateandplaceofpurchase.

.Adescriptionoftheproblem.

3.Deliveryoftheproductorthedefectivepart,postageprepaidandcarefullypackedandinsured,to:

Hansgrohe,Inc.

149BluegrassLakesParkway

Alpharetta,GA30004

Toll-free800-334-0455

7

Whenwarrantyserviceiscompleted,anyrepairedorreplacementproductorpartwillbereturnedtoyoupostageprepaid.

EXCLUSIONS AND LIMITATIONS

REPAIR OR REPLACEMENT (OR, IN LIMITED CIRCUMSTANCES, REFUND OF THE PURCHASE PRICE) AS

PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE PURCHASER. HANSGROHE

NEITHER ASSUMES NOR AUTHORIZES ANY PERSON TO CREATE FOR IT ANY OTHER OBLIGATION OR

LIABILITY IN CONNECTION WITH THIS PRODUCT. HANSGROHE SHALL NOT BE LIABLE TO PURCHASER

OR ANY OTHER PERSON FOR ANY INCIDENTAL, SPECIAL OR CONSEQUENTIAL DAMAGES, ARISING OUT

OF BREACH OF THIS WARRANTY OR ANY IMPLIED WARRANTY (INCLUDING BUT NOT LIMITED TO ANY

IMPLIED WARRANTY OF MERCHANTABILITY).

SomeStatesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamages,sotheabovelimitationor

exclusionmaynotapplytoyou.Thiswarrantygivesyouspeciclegalrights,andyoumayalsohaveotherrightsthatvary

fromstatetostate.

TO THE EXTENT PERMITTED BY LAW, ANY IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS

FOR A PARTICULAR PURPOSE, ARE LIMITED TO THE DURATION OF THE EXPRESS WARRANTY.

Somestatesdonotallowlimitationsonhowlonganimpliedwarrantymaylast,sotheabovelimitationsmaynotapplyto

you.Youmayberequiredbylawtogiveusareasonableopportunitytocorrectorcureanyfailuretocomplybeforeyou

canbringanyactionincourtagainstusundertheMagnuson-MossWarrantyAct.

PRODUCT INSTRUCTIONS AND QUESTIONS

Uponpurchaseorpriortoinstallation,pleasecarefullyinspectyourHansgroheproductforanydamageorvisibledefect.

Priortoinstalling,alwayscarefullystudytheenclosedinstructionsontheproperinstallationandthecareandmaintenanceof

thisproduct.Ifyouhavequestionsatanytimeabouttheuse,installationorperformanceofyourHansgroheproduct,orthis

warranty,pleasewriteusorcallustoll-freeat800-334-0455.

Hansgrohe,Inc.•1490BluegrassLakesParkway•Alpharetta,GA30004

Tel.770-360-9880

•Fax770-360-9887

www.hansgrohe-usa.com

US-InstallationInstructions•PartNo.90575807•Revised04/011

Hansgrohe 39115001 Installation guide

Brand: Hansgrohe

Model: 39115001

Category: Sanitary ware

Type: Installation guide

Download PDF

report

in other languages

français: Hansgrohe 39115001 Guide d'installation
español: Hansgrohe 39115001 Guía de instalación

Hansgrohe 39115001 Installation guide

Hansgrohe 39115001 Installation guide

in other languages

Related papers

Other documents