Page is loading ...
DPX-620 III 6 Ch. Dimmer
Inst.
dimmer pack
User manual
Musikhaus Thomann
Thomann GmbH
Hans-Thomann-Straße 1
96138 Burgebrach
Germany
Telephone: +49 (0) 9546 9223-0
E-mail: [email protected]
Internet: www.thomann.de
23.06.2020, ID: 107990 (V2)
Table of contents
1 General information................................................................................................................................. 5
1.1 Further information........................................................................................................................... 6
1.2 Notational conventions.................................................................................................................... 7
1.3 Symbols and signal words............................................................................................................... 8
2 Safety instructions.................................................................................................................................. 10
3 Features....................................................................................................................................................... 15
4 Installation and starting up................................................................................................................ 16
5 Connections and controls................................................................................................................... 20
6 Operating.................................................................................................................................................... 24
7 Technical specications....................................................................................................................... 34
8 Plug and connection assignments.................................................................................................. 36
9 Protecting the environment.............................................................................................................. 37
Table of contents
DPX-620 III 6 Ch. Dimmer Inst.
3
dimmer pack
4
DPX-620 III 6 Ch. Dimmer Inst.
dimmer pack
1 General information
This user manual contains important information on the safe operation of the device. Read and
follow all safety notes and all instructions. Save this manual for future reference. Make sure
that it is available to all persons using this device. If you sell the device to another user, be sure
that they also receive this manual.
Our products and user manuals are subject to a process of continuous development. We there‐
fore reserve the right to make changes without notice. Please refer to the latest version of the
user manual which is ready for download under www.thomann.de.
General information
DPX-620 III 6 Ch. Dimmer Inst.
5
dimmer pack
1.1 Further information
On our website (www.thomann.de) you will nd lots of further information and details on the
following points:
Download This manual is also available as PDF le for you to download.
Keyword search
Use the search function in the electronic version to nd the topics of
interest for you quickly.
Online guides
Our online guides provide detailed information on technical basics
and terms.
Personal consultation For personal consultation please contact our technical hotline.
Service
If you have any problems with the device the customer service will
gladly assist you.
General information
6
DPX-620 III 6 Ch. Dimmer Inst.
dimmer pack
1.2 Notational conventions
This manual uses the following notational conventions:
The letterings for connectors and controls are marked by square brackets and italics.
Examples: [VOLUME] control, [Mono] button.
Texts and values displayed on the device are marked by quotation marks and italics.
Examples: ‘24ch’ , ‘OFF’ .
Letterings
Displays
General information
DPX-620 III 6 Ch. Dimmer Inst.
7
dimmer pack
The individual steps of an instruction are numbered consecutively. The result of a step is
indented and highlighted by an arrow.
Example:
1. Switch on the device.
2. Press [Auto].
ð
Automatic operation is started.
3. Switch o the device.
1.3 Symbols and signal words
In this section you will nd an overview of the meaning of symbols and signal words that are
used in this manual.
Instructions
General information
8
DPX-620 III 6 Ch. Dimmer Inst.
dimmer pack
Signal word Meaning
DANGER! This combination of symbol and signal word indicates an
immediate dangerous situation that will result in death or
serious injury if it is not avoided.
NOTICE! This combination of symbol and signal word indicates a pos‐
sible dangerous situation that can result in material and
environmental damage if it is not avoided.
Warning signs Type of danger
Warning – high-voltage.
Warning – danger zone.
General information
DPX-620 III 6 Ch. Dimmer Inst.
9
dimmer pack
2 Safety instructions
This appliance is designed for professional use only and is intended to be used to control the
brightness of connected spotlights. Use the device only as described in this user manual. Any
other use or use under other operating conditions is considered to be improper and may result
in personal injury or property damage. No liability will be assumed for damages resulting from
improper use.
This device may be used only by persons with sucient physical, sensorial, and intellectual
abilities and having corresponding knowledge and experience. Other persons may use this
device only if they are supervised or instructed by a person who is responsible for their safety.
Intended use
Safety instructions
10
DPX-620 III 6 Ch. Dimmer Inst.
dimmer pack
DANGER!
Danger for children
Ensure that plastic bags, packaging, etc. are disposed of properly and are not
within reach of babies and young children. Choking hazard!
Ensure that children do not detach any small parts (e.g. knobs or the like) from
the unit. They could swallow the pieces and choke!
Never let children unattended use electrical devices.
DANGER!
Electric shock caused by high voltages inside
Within the device there are areas where high voltages may be present.
Completely disconnect the device from the power supply before you open or
remove covers. Mount all covers and attach them rmly before connecting the
device again.
Do not use the device if covers, protectors or optical components are missing or
damaged.
Safety
Safety instructions
DPX-620 III 6 Ch. Dimmer Inst.
11
dimmer pack
DANGER!
Electric shock caused by short-circuit
Do not modify the mains cable or the plug. Failure to do so could result in electric
shock/death or re. If in doubt, seek advice from a registered electrician.
DANGER!
Hazardous voltage
Hazardous voltage may be present at cable ends and screw terminals.
The connection of screw terminals as well as all maintenance and repair work on
the electrical installation of the device must only be performed by qualied elec‐
trical personnel in volt-free condition. Failure to do so may result in electric shock
and risk of re and loss of life.
By all means you have to observe all electrical safety instructions applicable at the
place of operation.
Safety instructions
12
DPX-620 III 6 Ch. Dimmer Inst.
dimmer pack
NOTICE!
Risk of re
Do not block areas of ventilation. Do not install the device near any direct heat
source. Keep the device away from naked ames.
NOTICE!
Operating conditions
This device has been designed for indoor use only. To prevent damage, never
expose the device to any liquid or moisture. Avoid direct sunlight, heavy dirt, and
strong vibrations.
Safety instructions
DPX-620 III 6 Ch. Dimmer Inst.
13
dimmer pack
NOTICE!
Power supply
Before connecting the device, ensure that the input voltage (AC outlet) matches
the voltage rating of the device and that the AC outlet is protected by a residual
current circuit breaker. Failure to do so could result in damage to the device and
possibly injure the user.
Unplug the device before electrical storms occur and when it is unused for long
periods of time to reduce the risk of electric shock or re.
Safety instructions
14
DPX-620 III 6 Ch. Dimmer Inst.
dimmer pack
3 Features
n Six dimmer channels
n Output: Screw terminals
n Digital control system
n Control via DMX 512
n Single channel fuse (each 16 A)
n Phase correction for linear dimming
n Individually adjustable dimmer curve
n Power supply via 5-pin mains connection cable for CEE plug
Features
DPX-620 III 6 Ch. Dimmer Inst.
15
dimmer pack
4 Installation and starting up
Unpack and check carefully there is no transportation damage before using the unit. Keep the
equipment packaging. To fully protect the product against vibration, dust and moisture during
transportation or storage use the original packaging or your own packaging material suitable
for transport or storage, respectively.
Create all connections while the device is o. Use the shortest possible high-quality cables for
all connections. Take care when running the cables to prevent tripping hazards.
Installation and starting up
16
DPX-620 III 6 Ch. Dimmer Inst.
dimmer pack
DANGER!
Hazardous voltage
Hazardous voltage may be present at cable ends and screw terminals.
The connection of screw terminals as well as all maintenance and repair work on
the electrical installation of the device must only be performed by qualied elec‐
trical personnel in volt-free condition. Failure to do so may result in electric shock
and risk of re and loss of life.
By all means you have to observe all electrical safety instructions applicable at the
place of operation.
The device is designed for mounting in 19" racks, it occupies two rack units (RU).
1. On the back of the device, open the required cable glands for the connecting cables to
the loads. Unused cable glands should remain closed for safety reasons.
2. Feed the connecting cables through the cable glands.
3. Connect the loads to the screw terminals according to the diagram below.
Electrical connection
Installation and starting up
DPX-620 III 6 Ch. Dimmer Inst.
17
dimmer pack
4. If necessary, install a CEE plug on the power cord of the unit.
5. Establish the DMX link to the controller.
6. Finally, connect the CEE plug of the device to a CEE socket.
Installation and starting up
18
DPX-620 III 6 Ch. Dimmer Inst.
dimmer pack
Connect the DMX input of the device to the DMX output of a DMX controller or other DMX
device. Connect the output of the rst DMX device to the input of the second one and so on,
to form a series connection. Make sure that the output of the last DMX device in the chain is
terminated by a resistor (110 Ω, ¼ W).
Connections in ‘DMX’ mode
Installation and starting up
DPX-620 III 6 Ch. Dimmer Inst.
19
dimmer pack
5 Connections and controls
Front panel
Connections and controls
20
DPX-620 III 6 Ch. Dimmer Inst.
dimmer pack
/