Parklands HS100ATV Owner's manual

  • I'm a chat assistant who has read the HISUN owner's manual for the HS100ATV and HS110ATV models. This document covers everything from basic operation and safety to maintenance and troubleshooting. I am ready to answer your questions about your ATV, including periodic maintenance procedures, control functions, or safety guidelines. Just ask!
  • What should I check before using the ATV?
    What type of fuel should I use?
    What is the maximum gradient that the ATV can climb?
    What should I do when parking on a slope?
Owner's Manual
Owner's Manual
INTRODUCTION
Congratulations on your purchase of the HS100ATV/HS110ATV. This Owner’s / Operators
manual will provide you information regarding safe operation, operational instructions , maintenance
and care. Fully understanding this manual and following all of the instructions herein will provide the
knowledge needed to have a safe and enjoyable ATV operation.
For questions regarding this ATV, please call (972) 446-0760.
IMPORTANT SAFETY MESSAGES
READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE OPERATING YOUR ATV. MAKE
SURE YOU UNDERSTAND ALL INSTRUCTIONS.
PAY CLOSE ATTENTION TO THE WARNING AND CAUTION LABELS ON THE ATV.
NEVER OPERATE THE ATV WITHOUT PROPER TRAINING OR INSTRUCTION.
Owner's Manual
IMPORTANT MANUAL INFORMATION
Please read this manual carefully before operating ATV.Until you have mastered enough
driving and operation method, to operate, driving the vehicle.Regular inspection and
maintenance, as well as the correct operation, driving skills will ensure that your use of the
vehicle safety and reliability.
Please read this manual carefully before operation, driving.So that you can thoroughly
familiar with your ATV, driving method, proper operation and product features, performance,
and limitations.Regular inspection and maintenance, as well as the correct operation,
driving skills will ensure that your use of the vehicle safety and reliability.
Your ATV can in order to ensure the long term and the use of no problem, please follow this
manual describes the methods for maintenance and maintenance.
This manual includes detailed dis-assembly and maintenance information.For some users
want to maintenance must have a qualified mechanical skills and have special tools
mentioned in this manual.
Put this manual has been in your vehicle so that you can at any time for the inspection.
Owner's Manual
This manual is a permanent part of the vehicle, after the vehicle was sold, must be equipped
with this manual.
Without our prior written consent, the publication of any content is not allowed to copy.
IMPORTANT MANUAL INFORMATION
FAILURE TO FOLLOW THE WARNINGS CONTAINED IN THIS MANUAL CAN RESULT IN SERIOUS
INJURY OR DEATH. Particularly important information is distinguished in this manual using the
following notations:
The Safety Alert Symbol means ATTENTION!
YOUR SAFETY IS INVOLVED!
Failure to follow WARNING instructions could result in severe injury or
death to the machine operator, a bystander or a person inspecting or
repairing the machine.
A CAUTION indicates special precautions that must be taken to avoid
damage to the machine.
Owner's Manual
A NOTE provides key information to make procedures easier or clearer.
IMPORTANT NOTICE
This ATV only according to the technical requirements for design and production of road
transport.In any public streets, roads or high-speed road is illegal.
This ATV conforms to the ATV motor vehicle regulations and spark plug radio interference
noise regulations.
Please confirm your local driving relevant provisions of the laws and regulations before
drive this ATV.
NOTE:
Owner's Manual
Location of the Warning and
Specification Labels
1-1
Safety Information
2-1
Description and Vehicle
Identification
3-1
Identification number records
3-3
Vehicle identification number
3-3
Engine identification number
3-4
Control Functions
4-1
Gear position “F” & “R”
4-2
Parking brake “P”
4-2
Multi-function meter
4-3
Odometer patterns
4-4
Clock patterns
4-4
Fuel level meter
4-5
Brake pedal
4-7
Shift lever
4-7
Fuel cap
4-8
Adjustment of front and rear
vibration damper
4-8
Use specified spanner
4-9
Chain adjustment
4-10
Seat removal
4-11
Pre Operation Checks List
5-1
Before using this ATV, check
the following points
5-1
Brake system
5-3
Ensure full tank of fuel
5-4
Mixed fuel(alcohol-gasoline)
5-4
Engine oil
5-5
Tire
5-5
Tire wear limit
5-6
1
2
3
4
1-7 Location of the Warning and Safety Labels
Start a cold engine
5-8
Operation
6-1
Starting a cold engine
6-1
Starting a hot engine
6-1
Warm up
6-3
Ensure the gear shift bar is in
the position.
6-4
Gear shift : neutral to reverse
6-4
Engine manual reverse
6-5
0-10 hours
6-5
10-20 hours
6-6
Parking
6-6
Parking on a slope
6-6
Accessories and load
6-8
Your Vehicle
7-1
Driving Your Vehicle
7-1
Driving
7-1
Learn how to operate the vehicle
7-1
Brake
7-3
Climbing uphill
7-3
Riding downhill
7-5
When approaching roadblocks
7-5
Periodic Maintenance and
Adjustment
8-1
Periodic Maintenance and Adjustment
8-1
Periodic maintenance chart for
the emission control system
8-2
General maintenance and
lubrication chart
8-3
EFI System
8-5
Throttle Valve
8-6
Idle control step motor
8-6
Fuel Injection Tap
8-6
Inlet temperature sensor
8-6
7
8
1-8 Location of the Warning and Safety Labels
Inlet pressure sensor
8-6
Ignition signal
8-6
EFI system examination
8-7
Oil and oil filter
8-7
Oil checking
8-7
Oil changing (need or do not
need to change the oil filter)
8-8
Disassembling
8-10
Checking
8-11
Assembling
8-11
Inspection
8-12
Installation
8-12
Install the spark plug
8-13
Clean the spark plug brake
8-15
Adjust the throttle
8-17
Idle-speed adjustment
8-17
Valve clearance
8-18
Check the front brake pads
8-18
Check for the rear brake pads
8-19
Check brake fluid
8-20
Maintenance cables and
lubricate
8-21
Lubricate steering
8-22
Wheel hub removal
8-22
Wheel Hub Installation
8-22
Battery
8-23
Maintenance Battery
8-24
Displace fuses
8-25
Change headlight bulb
8-26
Reconnect the lights to the
harness
8-29
Replace the taillight bulb
8-29
ATV common fault inspection
and solution charts
8-33
Cleaning and Storage
10-1
9
1-9 Location of the Warning and Safety Labels
Cleaning
10-1
Storage
10-2
Specifications
11-1
Fault codes for the
Electronic Injection System
12-1
YOUR WARRANTY RIGHTS
AND OBLIGATIONS
13-1
10
11
12
1-10 Location of the Warning and Safety Labels
LOCATION OF THE WARNING AND SPECIFICATION LABELS
FOR Utility model
1-11 Location of the Warning and Safety Labels
Read and understand all of the labels on your ATV. They contain important information for
safe and proper operation of your ATV.
Never remove any labels from your ATV. If a label becomes difficult to read or comes off, a
replacement label is available from your dealer.
1-12 Location of the Warning and Safety Labels
1-13 Location of the Warning and Safety Labels
1-14 Location of the Warning and Safety Labels
1-15 Location of the Warning and Safety Labels
FOR Sport model
1-16 Location of the Warning and Safety Labels
Read and understand all of the labels on your ATV. They contain important information for
safe and proper operation of your ATV.
Never remove any labels from your ATV. If a label becomes difficult to read or comes off, a
replacement label is available from your dealer.
1-17 Location of the Warning and Safety Labels
2-18 Safety Information
2-19 Safety Information
2-20 Safety Information
This ATV is different from other vehicles,please carefully read the following safety
precautions and strictly abide by,otherwise,will cause deaths and injuries.
Read the instructions carefully and paste on the vehicle all the warning labels.
safety
safety warning:
Improper operation may cause collision of ATV, out of control and excessive turning, and
cause personal injury or death.
Carefully read the following warning about driving risk and preventive measures, the following
safety warning about the safety of your child.Please let your child try to avoid when driving ATV
in the users manual specifically marked to security threats.Carefully read the user manual in
driving rules and operation section, to ensure the correct operation.
driver and driver’s age limit
The vehicle is limited to children riders recreational use under adult supervision, children under
the age of 10 operation is prohibited.
Check work ignore before operation.
SAFETY INFORMATION
/