Spagna Vetro SV190 Series Installation Manual And User's Manual

Installation Guide

and Users Manual

Wall Mount Range Hood

SPAGNA VETRO - 200 Series

IMPORTANT:

Read and save these instructions.

NOTICE:

Installer: Leave this guide with the homeowner

Homeowner: Keep this guide for future reference

www.SpagnaVetro.ca

Important Safety Notice

Read all Instructions before Installing and operating this appliance

• Theinstallationinthismanualisintendedforqualiedinstallers,servicetechniciansorpersonswith

similarqualiedbackground.Installationandelectricalwiringmustbedonebyqualiedprofession-

alsandinaccordancewithallapplicablecodesandstandards,includingre-ratedconstruction.

• DO NOTattempttoinstallthisapplianceyourself.Injurycouldresultfrominstallingtheunitdueto

lackofappropriateelectricalandtechnicalbackground.

• Rangehoodmayhaveverysharpedges;pleasewearprotectiveglovesifitisnecessarytoremoveany

partsforinstalling,cleaningorservicing.

• ActivatinganyswitchONbeforecompletinginstallationmaycauseignitionoranexplosion.

• Duetothesizeandweightofthisrangehood,twopeopleinstallationisrecommended.

To reduce the risk of re, electric shock, or injury to persons:

• Forgeneralventilatinguseonly.DO NOTusetoexhausthazardousorexplosivematerialsandva-

pors.

• Thecombustionairowneededforsafeoperationoffuel-burningequipmentmaybeaffectedbythis

unit’soperation.Followtheheatingequipmentmanufacturer’sguidelineandsafetystandardssuch

asthosepublishedbytheNationalFireProtectionAssociation(NFPA),andtheAmericanSocietyof

Heating,RefrigerationandAirConditioningEngineers(ASHRAE),andthelocalcodeauthorities.

• Beforeservicingorcleaningunit,switchpowerOFFatservicepanelandlockservicepaneltopre-

ventpowerfrombeingswitchedONaccidentally.

• Cleangreaseladensurfacesfrequently.Toreducetheriskofreandtodisperseairproperly,make

sure to vent air outside. DO NOTventexhaustintospacesbetweenwalls,crawlspaces,ceiling,attics

or garages.

• DuctedfansMUSTalwaysbeventedtotheoutdoors.

• UseonlymetalductworkandthisunitMUSTbegrounded.

• Sufcientairisneededforpropercombustionandexhaustingofgasesthroughtheducttoprevent

backdrafting.

• Whencuttingordrillingintowallorceiling,becarefulnottodamageelectricalwiringorotherhid-

den utilities.

• Allelectricalwiringmustbeproperlyinstalled,insulatedandgrounded.

• Oldductworkshouldbecleanedorreplacedifnecessarytoavoidthepossibilityofagreasere.

• Checkalljointsonductworktoinsureproperconnectionandalljointsshouldbeproperlytaped.

• Usethisunitonlyinthemannerintendedbythemanufacturer.Ifyouhavequestions,contactthe

vendor.

To reduce the risk of a stove top grease re:

• Keepallfan,bafe,spaces,lter,greasetunnel,oilcontainerandgrease-ladensurfacesclean.Grease

shouldnotbeallowedtoaccumulateonfan,bafe,spaces,lter,greasetunnelandoilcontainer.

• AlwaysturnrangehoodONwhencookingathighheatorwhencookingamingfoods.

• Usehighsettingsoncookingrangeonlywhennecessary.

• Neverleavesurfaceunitsunattendedathighsettings.Boiloverscausesmokingandgreasyspillovers

thatmayignite.Heatoilsslowlyonlowormediumsettings. Page1

Page2

Important Safety Notice

Read all Instructions before Installing and operating this appliance

The manufacturer and/or distributor/reseller declines all responsibility in the event of failure to ob-

serve the instructions given here for installation, maintenance and suitable use of the product.

The manufacturer and/or distributor/reseller further declines all responsibility for injury due to neg-

ligence and the warranty of the unit automatically expires due to improper maintenance.

The manufacturer and/or distributor/reseller will not be held responsible for any damages to per-

sonal property or real estate or any bodily injuries whether caused directly or indirectly by the range

hood.

• Cleanventilatingfanfrequently.

• Alwaysuseappropriatecookwareandutensilssize.

• Alwaysusecookwareappropriateforthesizeofthesurfaceelement.

To reduce the risk of injury to persons in the event of a stove top grease re:

• SMOTHERFLAMESwithaclose-ttinglid,cookiesheet,ormetaltray,thenturnOFFtheburner.

BECAREFULTOPREVENTBURNS.NEVERPICKUPAFLAMINGPAN—youmaybeburned.

KEEPFLAMMABLEORCOMBUSTIBLEMATERIALAWAYFROMFLAMES.IftheamesDO

NOTgooutimmediately,EVACUATEANDCALLTHEFIREDEPARTMENTordialyourlocal

emergencyserviceimmediately.

• DONOTUSEWATER,includingwetdishclothsortowels—aviolentsteamexplosionwillresult.

• UseanextinguisherONLYif:

• YouknowyouhaveaClassA,B,Cextinguisher,andyoualreadyknowhowtooperateit.

• Thereissmallandcontainedintheareawhereitisstarted.

• Theredepartmentisbeingcalled.

• Youcanghttherewithyourbacktoanexit.

To reduce the risk of injury to persons in the event of a gas leaks:

• Extinguishanyopename.

• DONOTturnontherangehoodfanoranytypeofventilator.

• DONOTturnonthelightsoranytypeofappliance.

• Openalldoorsandwindowstodispersethegas.Ifyoustillsmellgas,callthegascompanyandre

department,ordialyourlocalemergencyserviceimmediately.

WARNING

Yoursafetyandthesafetyofothersisveryimportant.Wehaveprovidedmanyimportantsafetymes-

sagesinthismanualandonyourappliance.Alwaysreadandobeyallsafetymessages.Allsafetymes-

sageswilltellyouwhatthepotentialhazardis,tellyouhowtoreducethechanceofinjury,andtellyou

what can happen if the instructions are not followed.

Thisisthesafetyalertsymbol.Thissymbolalertsyoutopotentialhazardsthatcanhurtyouandothers.

Allsafetymessageswillfollowthesafetyalertsymbolandtheword“WARNING”.

Tools needed:

Page3

Level

Flat-bladeand

Phillipsscrew-

drivers

Powered

screwdriver

or drill

Measuring

tape

Utilityknife

Markeror

pencil

Table of Contents

INSTALLATION

Toolsneeded....................................................3

Partssupplied...................................................4

Ventingrequirements.......................................5

Mountheights&clearance...........................5-6

Calculatingventsystemlength.......................6

Ventingmethods&ductlessconversion..........7

Charcoallters&electricalrequirements.......8

Preparation......................................................9

Installation................................................10-12

Range hood operations............................13-22

USE AND CARE

Troubleshooting...........................................23

Useandcareinformation...............................24

Specications..............................................24

MAINTENANCE

Cleaning...............................................25

Replacinglter&lightbulb....................25-26

WARRANTY

Coverage& exceptions.................................27

Disclaimer&contactinformation..................28

Page4

Air diverter

(Optionalre-circulatingkit)

CharcoalFilter

(Optionalre-circulatingkit)

Description Quantity

Toggle Bolts 2Pcs

DuctSet 1Set

BodyHook(varywithmodel) 2Pcs

ChimneyMountingBracket 1Set

ThisGuideandWarrantyCard 1Set

5mmx16mmScrewwithWasher 4Set

Optional:4mmx16mmTappingScrew 6Pcs

Optional;4mmx10mmTappingScrew 16Pcs

Optional:ToggleBoltwithTappingScrewforAirDiverter 2Set

Optional:ScrewforCharcoalFilter 3Pcs

StainlessSteelBafeor

AluminumFilter(s)

Lowerstandardchimney Upperstandardchimney

FlexibleDuctTube(Optional)

Flappers

Parts supplied: Range Hood

(varywithmodel)

MountingBracket

Page5

Max*:110”

Standard

Upper

Chimney

Extensionavailable*

Range hood

Mounting

Bracket

Standard

Lower

Chimney

Extensionavailable*

36”base

Maximum*ceilingclearance

110”at31”hoodmounting

heightabovecountertop/stove

(mayvarywithdifferent

model).Chimneyextensions

availableforhigherceiling.

*Higherceilingrequireschim-

neyextension.Availableatyour

local resellers.

Min:

28”

Max:31”

Venting Requirements Height & Clearance

• Vent system must terminate to the outside

(rooforsidewall).

• DONOTterminatetheventsysteminanat-

tic or other enclosed area.

• DONOTuse4”(10.2cm)laundry-typewall

caps.

• Usemetal/aluminumventonly.Rigidmetal/

aluminum vent is recommended.

• DO NOT use plastic vent.

• Alwayskeeptheductcleantoensureproper

airow.

• Calculatethefollowingguresbeforeinstal-

lation:

1. Distance from the oor to the ceiling.

2. Distance between the oor to the coun-

tertop/stove (recommend* 28” to 31”).

3. Distance between the countertop/stove

to the range hood.

4. Height of hood and duct cover.

For the most efcient & quiet operation:

• Adistance of 28”to31” is recommended*

betweenstove topandthebottom ofrange

hood.

• It is recommended that the range hood be

ventedverticallythroughtheroofthrough6”

(15.2cm) or bigger roundmetal/aluminum

ventwork.

• Thesizeoftheventshouldbeuniform.

• Usenomorethanthree90°elbows.

• Make sure there is a minimum of 24” (61

cm) of straight vent between the elbows if

morethanoneelbowisused.

• DONOTinstalltwoelbowstogether.

• The length of vent system and number of

elbowsshouldbekepttoaminimumtopro-

videefcientperformance.

• The vent system must have a damper. If

roof or wall cap has a damper, DO NOT

usedamper(ifsupplied)ontopoftherange

hood.

• Usesilvertapeorducttapetosealalljoints

intheventsystem.

• Use caulking to seal exterior wall or roof

opening around the cap.

*Duetodifferentceilingheightcongurations,rec-

ommendedheightmaynotbeapplicable.

Countertop/Stove

IMPORTANT:

• Aminimumof6”round(standardforthisrangehood)or3-1/4x10”rectangularduct(purchasedseparately)

mustbeusedtomaintainmaximumairowefciency.

• Flexible6”roundductprovidedforconvenience,alwaysuserigidtypemetal/aluminumductsifavailableto

maximizeairowwhenconnectingtoprovidedduct.

• PleaseuseDuct Run Calculationbelowtocomputethetotalavailableductrunwhenusingelbows,transitions

and caps.

• ALWAYS,whenpossible,reducethenumberortransitionsandturns.Iflongductrunisrequired,increase

ductsizefrom6”to7”or8”.Ifareducerisused,installalongreducerinsteadofapancakereducer.Reduc-

ingductsizewillrestrictairowanddecreaseairow,thusreduceductsizeasfarawayfromopeningaspos-

sible.

• Ifturnsortransitionsarerequired:Installasfarawayfromopeningandasfarapart,between2,aspossible.

• Minimummountheightbetweenstovetoptohoodbottomshouldbenolessthan28-inch*.

• Maximummountheightbetweenstovetoptohoodbottomshouldbenohigherthan31-inch*.

• Itisimportanttoinstallthehoodatthepropermountingheight.Hoodsmountedtoolowcouldresultinheat

damageandrehazard;whilehoodsmountedtoohighwillbehardtoreachandwilllooseitsperformance

andefciency.

• Ifavailable, alsorefer to stovetop manufacturer’sheight clearance requirementsand recommendedhood

mountingheightaboverange.

*Duetodifferentceilingheightcongurations,recommendedheightmaynotbeapplicable.

Minimum Duct Size:

• Round-6”minimum

• Rectangular-3-1/4x10”minimum(requiresa6”to3-1/4x10”adaptor,notsupplied)

Page6

Duct Run Calculation:

Recommendedmaximumrun

6”or3-1/4x10”duct 50ft

Ventpiecededuction

Each90ºelbowused 9ft

Each45ºelbowused 5ft

Each6”to3/14x10”transitionused 7ft

Sidewallcapwithdamper 0ft

Roof cap 0ft

Duct Run Calcuation example:

One roof cap, two 90º elbow, and one 45º elbow used:

0ft + 9ft + 9ft + 5ft = 23ft used.

Deduct 23ft from 50ft, 27ft maximum available for

straight duct run.

Tocalculatethelengthofthesystemyouneed,deducttheequivalentfeetforeachventpieceusedinthesystem

fromtherecommendedmaximumductrun.

Calculating Vent System Length

Venting Methods

Page7

• Thisrangehoodisfactorysetforventingthroughtherooforwall.Fornon-vented(re-circulating)installa-

tions,seeRecirculating (Non-Vented) KitonPage11.

• Ventworkcanterminateeitherthroughtherooforwall.Toventthroughawall,a90°elbowisneeded.

IMPORTANT:

• NEVERexhaustairorterminateductworkintospacesbetweenwalls,crawlspaces,ceiling,atticsorgarages.

Allexhaustmustbeductedtotheoutside.

• Usemetal/aluminumductworkonly.

• FastenallconnectionswithsheetmetalscrewsandtapealljointswithcertiedSilverTapeorDuctTape.

• Usecaulkingtosealexteriorwallorroofopeningaroundthecap.

Ductless Conversion

Option 2:

Sidewallcap

Vertical roof venting

Roof cap

Horizontal wall venting

Option 1:

• Ductlessconversionisintendedforapplicationswhereanexhaustductworkisnotpossibletobeinstalled.

Whenconverted,thehoodfunctionsasapurifyinghoodratherthananexhausthood.Fumesandexhaust

fromcookingisdrawnandlteredbyasetofcharcoallters.Theairisthenpuriedandre-circulatedback

within the home.

• WerecommendtoALWAYSexhaustairoutsideofthehomebyemployingexistingorinstallingnewduct

work,ifpossible.Onlywhentheexhaustoptionisnotpossibleshouldyourecoursetoconvertingthehood

intoapurifyingunit.

• Whenconvertedtobea“purifying”unit,asetofcharcoalltersandanair-diverterarerequiredinadditionto

itsstandardaluminumlterset.Availableatyourlocalresellers.Thestandardaluminumltersareintended

tocaptureresiduefromcooking,theoptionalcharcoalltershelptopurifyfumesexhaustedfromcooking,

andtheoptionalair-diverterredirectslteredcleanairbacktothehouse.

Page8

Electrical Requirements

IMPORTANT:Observeallgoverningcodesandordinances.

It is the customer’s responsibility:

Tocontactaqualiedelectricalinstaller.

ToassurethattheelectricalinstallationisadequateandinconformancewithNationalElectricalCode,ANSI/

NFPA70—latestedition*,orCSAStandardsC22.1-94,CanadianElectricalCode,Part1andC22.2No.0-M91

-latestedition**andalllocalcodesandordinances.

• Ifcodespermitandaseparategroundwireisused,itisrecommendedthataqualiedelectriciandetermine

that the ground path is adequate.

• A120-volt,60Hz,AC-only,fusedelectricalsupplyisrequiredonaseparate15-ampcircuit,fusedonboth

sides of the line.

• Do not ground to a gas pipe.

• Do not have a fuse in the neutral or ground circuit.

• RISKOFELECTRICALSHOCK.Thisrangehoodmustbeproperlygrounded.Checkwithaqualiedelec-

tricianifyouarenotsurewhethertherangehoodisproperlygrounded.

• Therangehoodshouldbeconnecteddirectlytothefuseddisconnect(orcircuitbreaker)boxthroughexible

armoredornon-metallicsheathedcoppercable.AU.L.-orC.S.A.-listedstrainreliefmustbeprovidedat

eachendofthepowersupplycable.Donotuseextensioncordoradapterplugwiththisappliance.

• Therangehoodmustbeconnectedwithcopperwire/plugonly.

• Alwaysuseplug provided.Ifnot possible, connectthreewires according toitscolor (blacktohot, white

to neutral, and green to ground)

to house wires and cap with wire

connectors:

Wire sizes (copper wire only) and

connections must conform with

the rating of the appliance as speci-

ed on the model/serial rating label. Wire sizes must conform to the requirements of the National Electrical

CodeANSI/NFPA 70 — latest edition*, or CSA Standards C22. 1-94, Canadian Electrical Code Part 1 and

C22. 2 No.  0-M91 - latest edition** and all local codes and ordinances.A U.L. - or C.S.A. - listed conduit

connectormustbeprovidedateachendofthepowersupplycable(attherangehoodandatthejunctionbox).

Copiesofthestandardslistedmaybeobtainedfrom:

*NationalFireProtectionAssociation ** CSAInternational

BatterymarchPark   8501EastPleasantValleyRoad

Quincy,Massachusetts02269  Cleveland,Ohio44131-5575

Charcoal Filter Installation

White

Green

Black

NOTE: Thecharcoalltersarepreinstalledifyoupurchasedtherangehoodwithre-circulatingkitfromus.

1. Removealuminumltersonhood.

2. Removethesafetylterunderthealuminumlterbyunscrewingtwoscrews,thenpositionthecharcoallter

andalignthescrewholes,reinstallandfastentwoscrews.

3. Reinstallthealuminumltersbacktothehood.

4. Charcoalltersmustbereplacedafter120hoursofuse(orapproximatelyevery2to3monthsbasedonthe

averageof1to2hoursofdailycookingtime).Availableatyourlocalreseller.

Page9

Advanced Preparations:

1. Readtheentireinstallationguideandusersmanualthoroughly,understandinstructionsandwarnings.

2. BefamiliarwiththecontrolsoftherangehoodbyreadingthroughRange Hood Operations,Page13.

3. Placetherangehoodonaat,stablesurface.Connecttherangehoodtoadesignatedstandardoutlet(please

refertheproductlabelforthesuitablevoltageofthisunit)andverifynodebrishasenteredtheventopenings,

thenturnontherangehood.VerifyalloperationsoftherangehoodbyreferringtoRange Hood Operations,

Page13.

4. Placeallsuppliedpartsandrequiredhardwareonaat,stablesurfaceandverifytheexistenceofallsupplied

partslistedonPage4.

5. Carefullyremovethewhiteplasticprotectivecoatfromthechimneycoversandrangehood.

Preparations:

NOTE: To avoid damage to your hood, prevent debris from entering the vent opening.

1. Determineandmarkthecenterlineontheceilingwheretherangehoodwillbeinstalled.Makesurethereis

properclearancewithintheceilingorwallforexhaustvent.

2. Duetotheweightandsizeofthisunit,pleasemakesurethatthesupportsystemorframeworkbeingusedis

stableandsecureintheceiling.

3. Putathick,protectivecoveringovercountertop,cooktoporrangetoprotectfromdamageordirt.Remove

anyhazardousobjectsaroundtheareawheninstalling.

4. Markthelocationsofthesupportmountingbracketholes,ventcutout(ifused)andpowersupplycablecutout

ontheceiling.Usedrillandsabersaworkeyholesawtocutopeningsforpowersupplycableandvent(see

Venting requirements and Electrical requirements,Pages5-8).

5. Ifventingtotheoutsideinstallventsystem(seeVenting Methods,Page7).Usecaulkingtosealexteriorwall

or roof openings.

6. Disconnectmainelectricalsupply,prepareandrunelectricalwiringthroughceiling.Leaveapproximately

12”ofelectricalcordhangingfromtheceiling.Donotrestorepoweruntilwiringiscompleted.

7. Disconnectpowercord,removethealuminumlterbypressingonthelatchandgentlypullthealuminum

lterdown.

8. Ifcharcoallterispresent,unscrewthetwoscrewsandremovethelter.

9. Setasidethealuminumltersandcharcoallteruntiltherangehoodisproperlyinstalled.

10. If the range hood comes with a glass canopy and has not already been mounted to the hood, loosen the four

canopy screws and washers from the hood top, carefully place the canopy on the hood top, and loosely tighten

the four canopy screws along with washers. DO NOT put excessive pressure against the glass.

WARNING

Severe Injury

Rotating fan can cause

severe injury. Stay clear of

fan when motor is running.

WARNING

Severe Injury

Hood may have very shape edges. Please wear

protective gloves if it is necessary to remove

any parts for installing, cleaning or servicing.

Preparation

WARNING

Excessive Weight

Require three or more person to move and

install this range hood. Spinal or other bodily

injuries could occur if it is not followed.

Page10

3. Install the Duct Set using six 4mm x 16mm Tapping

Screws,theninstallAluminumDuctTubeasshownin

Figure3Aand3B.Proceedtostep6onPage12.

Figure2

Installations(refertoPage4forparts):

Due to excessive weight, two or more person is recommended for this step.

1. Locateanoptimallocationtoplacetherangehood.Markthe

levelingpointsfortwoBodyHooks(Figure1)onthewalland

drilltwoholeswithdiameternotexceeding5/8”.Inserttwo

toggleboltsthenfastentwo4mmx16mmTappingScrews,

reserveapproximately1/8”forthebodyhooks.Besuretouseappropriateanchorsforyourwall.

2. Find an optimal loca-

tionfortheChimney

Mounting Bracket.

Thechimneymount-

ing bracket must be

placed directlyabove

and align with the

two body hooks, see

Figure 2. Drill two

more holes with di-

ameternotexceeding

5/8” and insert two

toggle bolts. Secure

the chimney mount-

ingbracket withtwo

4mmx 16mmTappingScrewsas shown

inFigure2.Besuretouseappropriatean-

chorsforyourwall.Usefoursetsof5mm

x16mmScrewwithWashertoinstallthe

bodyhooksontothehood.Thenhangthe

hood on the wall and tighten the screws.

CAUTION: MAKE SURE the range hood

is secure before releasing!

Figure3A

Figure1

DuctSet

InstalltheDuctSet

and Aluminum duct

onthebodyofhood. Figure3B

Installation

If Recirculating (Non-Vented) Kit is purchased, please skip this step and proceed to Page 11.

WARNING

Excessive Weight

Require three or more person to move and

install this range hood. Spinal or other bodily

injuries could occur if it is not followed.

DuctSet

Page11

4. Find an optimal location for the Air Diverter. The air diverter must be placed directly above and align

with the two body hooks, see Figure 4. Drill four more holes with diameter not exceeding 5/8” and in-

sert four toggle bolts. Secure the air diverter with four 4mm x 16mm Tapping Screws as shown in Fig-

ure 4. Be sure to use appropriate anchors for your wall. Use four sets of 5mm x 16mm Screw with

Washer to install the body hooks onto thehood.Then hang the hoodon thewall andtighten thescrews.

CAUTION: MAKE SURE the range hood is secure before releasing!

Figure4

5. InstallAluminumDuctTubeasshowninFigure5A.In-

stallationofcharcoallterduringthisstepisalsorecom-

mended,pleaseseeCharcoal Filter InstallationonPage

Figure5B

Figure5A

Air Divertor

SafetyFilter

Charcoal

Filter

Installation (Continued)

If Recirculating (Non-Vented) Kit is NOT purchased, please go back to step 2 on Page 10.

WARNING

Excessive Weight

Require three or more person to move and

install this range hood. Spinal or other bodily

injuries could occur if it is not followed.

Page12

6. Connecttheducttubetotheexteriorexhaustsystemortheoptionalairdiverter.Makesurealljointsaresecure

and air tight. Use of duct tape is recommended.

7. PlaceUpperChimneyandLowerChimneyoverthebodyofthehoodasshowninFigure7A(orFigure7Bof

airdiverterispresent).Slideuptheupperductcovertowardsthechimneymountingbracketortheoptional

airdiverter.Usefour4mmx10mmTappingScrewstosecuretheupperchimneyontothechimneymounting

bracketortheoptionalairdiverter.Finallysecurethelowerchimneytothehoodbodybyusingtwo4mmx

10mmTappingScrews.

Page12

Figure7A

Figure7B Air Divertor

Upper

Chimney

(hasvent-

ingholes)

Lower

Chimney

ChimneyMountingBracket

Upper

Chimney

(hasvent-

ingholes)

Lower

Chimney

4x10Screw

Installation (Continued)

WARNING

Excessive Weight

Require three or more person to move and

install this range hood. Spinal or other bodily

injuries could occur if it is not followed.

Page13

PowerSwitch

LowSpeed

MediumSpeed

HighSpeed

LightSwitch

Range Hood Operations & Wiring Diagram

TurnOn:

• Pressthespeedcontrol(LowSpeed,MediumSpeed,HighSpeed)switchtoselectthedesiredlevelofpower.

Oncebuttonispressed,thepreviousspeedmodewillcancel.

• PresstheLightSwitchtopoweronthelights.

CAUTION: DO NOT touch the lights until switched OFF and cooled.

TurnOff:

• PressthePowerSwitchtoturnoffthepower.

• PresstheLightSwitchtopoweroffthelights

SV200SeriesStandardClass(3SpeedMechanicalControl)

NOTE:WiringDiagramsshownabovewithGU10lightconguration.AtransformerisrequiredforMR16Lights.

SV200SeriesStandardClassWiringDiagram

Page14

Power

DecreaseValue

Light

IncreaseValue

BlowerPowerIndicator

BlowerSpeedIndicator

Power-OnElapsedDigitalTimer

Power-OffDelayDigitalTimer

Power-OffDelayTimerIndicator

LightPowerIndicator

Thisrangehoodisdesignedtoremovesmoke,cookingvaporsandodorsfromthecooktoparea.Forbestresults,

starttherangehoodbeforecookingandallowittooperateseveralminutesafterthecookingiscompletedtoclear

allsmokeandodorsfromthekitchen.

• Buttonfunctions:

• Power:PowerON/OFFtherangehoodandactivatepower-offdelaytimer.

• DecreaseValue:Blower(motor)speeddecrease,timervaluedecrease,andentertimermode.

• IncreaseValue:Blower(motor)speedincreasetimervalueincrease,andcumulativetimerreset.

• BlowerPowerIndicator:Lightsupwhenblower(motor)isrunning.

• BlowerSpeedIndicator:Showscurrentblower(motor)speed(1-6).

• LightPowerIndicator:Lightsupwhenlightsturnedon.

• Light:TurnsON/OFFanddimhalogenlights.

• Power-OnElapsedDigitalTimer:Indicatestheaccumulatedtimethesystemisrunning.

• Power-OffDelayDigitalTimer:Indicatesthelengthoftimeleftfordelayofffunction.

• Power-OffDelayTimerIndicator:Lightsupwhenauto-shutdowndelaytimerfunctionison.

• Controls:

• Automaticcleaningreminder:

• Thisrangehoodisequippedwithacleaningreminderthatwillactivatefollowing30hoursofuse.

Whenblower(motor)startstorotate,cumulativerunningtimewillbeshowninPower-On Elapsed

Digital Timer.Thistimericonasheswhen30hoursisupandremindsusertocleanthealuminum

lter.

• Aftercleaningthelterandwhenthemotorisnotinuse,pressandholdIncrease Valuebuttonover3

secondstoresetthetimer.PleasenotethatturningoffthesystemwillnotresetthePower-On Elapsed

Digital Timer.

• Adjustingtheblower(motor)speed:

• PressPowerbuttononcetoturnonthesystem.TheBlower Power Indicatoriconashesshowingthat

theblower(motor)isready.Decrease Valuebuttonwilldecreasethespeedoftheblower(motor)from

6to1(strongesttoquietest).Increase Valuebuttonwillincreasethespeedoftheblower(motor)from

1to6(quietesttostrongest).

• PressPowerbuttononcetoturnoffthesystem.

Note: The system saves user congurations, settings such as light, timer and blower (motor) speed will re-

main the same the next time it is turned on.

Range Hood Operations & Wiring Diagram (Continued)

SV168/198Series“E”Class(6SpeedElectronicTouchControl)

Page15

• Controls:

• Adjustingthetimerfunction:

• Whiletheblower(motor)isnotrunning,pressandholdDecrease Value buttonover3secondsto

entertimermode.AdjusttodesiredperiodofdelayofftimerbypressingIncrease Value or Decrease

Valuebutton(minimum1minutetomaximum15minutes).Thissettingwillbesavedimmediately.

• Activatingthetimerfunction:

• Whiletheblower(motor)isrunning,pressandholdPower buttonforover3secondstoactivate

delayofftimer.Power-offdelayindicatorwilllitupandpower-offdelaydigitaltimerwillbeginto

countdown,whenitreacheszero,theblower(motor)willshutdown.

• Adjustingthelight:

• PressLightbuttononcetoturnonthelights,andonceagaintoturnoffthelights.

• Whilethelightsareoff,pressandholdLightbuttonforover3secondstodimthelightsfromlowto

high.Levelofbrightnesswillbestoredinsystem’smemory.

CAUTION: DO NOT touch the lights until switched OFF and cooled.

Note: Light settings are independent from other settings (including power-off delay) and lights has to be

manually turned on or off.

Note: The system saves user congurations, settings such as light, timer and blower (motor) speed will re-

main the same the next time it is turned on.

Power

DecreaseValue

Light

IncreaseValue

BlowerPowerIndicator

BlowerSpeedIndicator

Power-OnElapsedDigitalTimer

Power-OffDelayDigitalTimer

Power-OffDelayTimerIndicator

LightPowerIndicator

Range Hood Operations & Wiring Diagram (Continued)

SV200Series“E”Class(6SpeedElectronicTouchControl)

Page16

Wiring Diagram

SV200Series“E”ClassWiringDiagram(6SpeedwithGU10Bulb)

Page17

Troubleshooting

1. Iftherangehoodorhalogenlightdoesnotoperate

afterinstallation:

• Checkiftherangehoodhasbeenpluggedin,make

surethatallpowerhasbeenturnedbackON,fused

notblownandallelectricalwiringareproperlycon-

nected.

• Swapoutlightassemblytoworkingonestodeter-

minewhetheritiscaused by defectivebulbs. See

Replacing the light bulbsonPage22-23.

2. Therangehoodvibrateswhentheblowerison: • Therangehoodmightnothavebeensecuredprop-

erlyontotheceilingorwall.Checkwithyourin-

staller

3. Theblowerorfanseemsweak: • Checkthattheductsizedusedisatleast6”or3-1/4

x10”.RangehoodWILLNOTfunctionefciently

with insufcient duct size. For example: 8” duct

over6”holeandlooselysecured.

• Checkifductiscloggedorifdamperunit(half-cir-

cularapper)isnotinstalledcorrectlyoropening

properly.Atightmeshonasidewallcapunitmight

alsocauserestrictiontotheairow.

4. Thelightsworkbuttheblowerisnotspinningatall,

isstuckorisrattling.

• Theblowermightbejammedorscrapingthebot-

tomduetoshippingdamage.Pleasecontactusim-

mediately.

5. Thehoodisnotventingoutproperly: • Makesurethedistancebetweenthestovetopand

thebottomofthehoodiswithin*28”and31”in

distance.*Due to different ceiling height congura-

tions, recommended height may not be applicable.

• Reduce the number of elbows and length of duct

work. Check if all joints are properly connected,

sealed,andtaped.

• Make sure the power is on high speed for heavy

cooking.

NOTE: For all other inquiries, please contact your SPAGNA VETRO local reseller.

6. Purposeoftheslots/holes/openingsnearthetopof

theupperchimney:

• These slots/holes/openings are used to exhaust

cleanedairwith optional re-circulatingkit.Ifyou

didnotinstallone,youdonotneedthem.

Page18

Specications*:

Body StainlessSteel/TemperedGlass

PowerRating 120V/60Hz(USA&Canadastandard)

GeneralInputPower 160W+#ofLightxVotageofLight

MotorInputPower 160W

Motor Revolution 800RPM(±10%)to1300RPM(±10%)

LevelsOfSpeedControl 3Levels

MaximumAirow 600CFM

AirPressure 150Pa(200PaMaximum)

NoiseLevel(dB/sone) Approximately35/0.7to67/6.5(LowesttohighestSpeed)

MotorType SingleChamberUltraQuiet

FanType Centrifugal/Sirocco

ControlType 3SpeedMechinicalorElectronicTouch

FiltrationType AluminumFilterorStainless

Illumination 35W(GU10)110VMax.

VentingSize Top,6inchesRound

InterferenceProtection RadioFrequencyInterferenceProtected

Specications

Use and Care Information

Operations:

• Readandunderstandallinstructionsandwarningsinthismanualbeforeoperatingtheappliance.Savethese

instructions for future reference.

• Alwaysleavesafetygrillsandltersinplace.Withoutthesecomponents,operatingblowerscouldcatchonto

hair,ngersandlooseclothing.

• NEVERdisposecigaretteashes,ignitablesubstances,oranyforeignobjectsintoblowers.

• NEVERleavecookingunattended.Whenfrying,oilinthepancaneasilyoverheatandcatchre.Theriskof

selfcombustionishigherwhentheoilhasbeenusedseveraltimes.

• NEVERcookon“open”amesundertherangehood.Checkdeep-fryersduringuse:Superheatedoilmaybe

ammable.

Cleaning:

• Thesaturationofgreasyresidueintheblowerandltersmaycauseincreasedinammability.Keepunitclean

andfreeofgreaseandresiduebuild-upatalltimestopreventpossibleres.

• Filtersmustbecleanedperiodicallyandfreefromaccumulationofcookingresidue(seecleaning instructions

onPage22).Oldandwornltersmustbereplacedimmediately.

• Donotoperateblowerswhenltersareremoved.Neverdisassemblepartstocleanwithoutproperinstruc-

tions.Disassemblyisrecommendedtobeperformedbyqualiedpersonnelonly.Readandunderstandall

instructionsandwarningsinthismanualbeforeproceeding.

*Subjecttochangewithoutnotice,pleasecontactyourlocalresellerfordetails.

Page is loading ...

Spagna Vetro SV190 Series Installation Manual And User's Manual

Related papers

Other documents