abaco systems CPCI-7806RC Hardware Reference Manual

Hardware Reference Manual

CPCI-7806*/CPCI-7806RC* Pentium/

Celeron M Universal CompactPCI Single

Board Computer

THE CPCI-7806RC IS DESIGNED TO MEET THE EUROPEAN UNION (EU)

RESTRICTIONS OF HAZARDOUS SUBSTANCE (RoHS) DIRECTIVE (2015/863)

CURRENT REVISION.

Publication No. 500-657806-000 Rev. G

2 CPCI-7806*/CPCI-7806RC* Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

Document History

Waste Electrical and Electronic Equipment (WEEE) Returns

Revision Date Description

A.0 2004 Original Release

B April 2007 Change Number ECO-00001539

C February 2009 Change Number ECO-00006421

D

E January 2018 Change Number ECO-00009844

F July 2011 Change Number ECO-00013936

G March 2018 Rebranded to Abaco Systems

Abaco Systems is registered with an approved Producer Compliance Scheme (PCS) and, subject

to suitable contractual arrangements being in place, will ensure WEEE is processed in accordance

with the requirements of the WEEE Directive.

Abaco Systems will evaluate requests to take back products purchased by our customers before

August 13, 2005 on a case-by-case basis. A WEEE management fee may apply.

Publication No. 500-657806-000 Rev. G About This Manual 3

About This Manual

Conventions

Notices

This manual may use the following types of notice:

WARNING

Warnings alert you to the risk of severe personal injury.

CAUTION

Cautions alert you to system danger or loss of data.

NOTE

Notes call attention to important features or instructions.

TIP

Tips give guidance on procedures that may be tackled in a number of ways.

LINK

Links take you to other documents or websites.

Numbers

All numbers are expressed in decimal, except addresses and memory or register

data, which are expressed in hexadecimal. Where confusion may occur, decimal

numbers have a “D” subscript and binary numbers have a “b” subscript. The

prefix “0x” shows a hexadecimal number, following the ‘C’ programming

language convention. Thus:

One dozen = 12

D

= 0x0C = 1100

b

The multipliers “k”, “M” and “G” have their conventional scientific and

engineering meanings of x10

3

, x10

6

and x10

9

, respectively, and can be used to

define a transfer rate. The only exception to this is in the description of the size of

memory areas, when “K”, “M” and “G” mean x2

10

, x2

20

and x2

30

respectively.

In PowerPC terminology, multiple bit fields are numbered from 0 to n where 0 is

the MSB and n is the LSB. PCI terminology follows the more familiar convention

that bit 0 is the LSB and n is the MSB.

Text

Signal names ending with a tilde (“~”) denote active low signals; all other signals

are active high. “N” and “P” denote the low and high components of a differential

signal respectively.

4 CPCI-7806/CPCI-7806RC Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

Further Information

Abaco Website

You can find information regarding Abaco products on the following website:

LINK

https://www.abaco.com

Abaco Documents

This document is distributed via the Abaco website. You may register for access to

manuals via the website.

LINKS

https://www.abaco.com/products/cpci-7806rc

The following is a list of reference documentation related to CPCI-7806*/

CPCI-7806RC*:

VxWorks Board Support Package Abstraction BSPX

ACC-0584/ACC-0584RC Installation Guide

CPCI-7806RC Datasheet

ACC-0584RC Datasheet

Third-party Documents

PCI Local Bus Specification, Rev. 2.2

CMC Specification, P1386/Draft 2.0

PMC Specification, P1386.1/Draft 2.0

CompactPCI

®

Specification PICMG

®

2.0 R3.0

Packet Switching Backplane Specification PICMG 2.16 R1.0

The I

2

C Specification version 2.0

LINKS

https://pcisig.com/specifications/conventional/

https://standards.ieee.org/

https://www.picmg.org/

www.semiconductors.philips.com

NOTE

Technical literature describing components used on the CPCI-7806/CPCI-7806RC is available

from the manufacturers’ websites.

Publication No. 500-657806-000 Rev. G About This Manual 5

Compliance

This chapter provides the applicable information regarding regulatory

compliance for the CPCI-7806/CPCI-7806RC.

Abaco Systems’ CPCI-7806/CPCI-7806RC has been evaluated to and has met the

requirements for compliance to the following standards:

International Compliance

• EN55022:1998/CISPR 22:1997

• IEC61000-4-2

• IEC61000-4-3

• IEC61000-4-4

• IEC61000-4-5

• IEC61000-4-6

European Union (CE Mark)

• BS EN55024 (1998 w A1:01 & A2: 03)

• BS EN55022 (Class A)

United States

• FCC Part 15, Subpart B, Section 109, Class A

Australia/New Zealand

• AS/NZS CISPR 22 (2002) Class A

Canada

• ICES-003 Class A

6 CPCI-7806/CPCI-7806RC Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

FCC Part 15

This device complies with Part 15 of the FCC Rules. Operation is subject to the

following two conditions: (1) this device may not cause harmful interference, and

(2) this device must accept any interference received, including interference that

may cause undesired operation.

FCC Class A

NOTE

This equipment has been tested and found to comply with the limits for a Class A digital

device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable

protection against harmful interference when the equipment is operated in a commercial

environment. This equipment generates, uses, and can radiate radio frequency energy and, if

not installed and used in accordance with the instruction manual, may cause harmful

interference to radio communications. Operation of this equipment in a residential area is

likely to cause harmful interference in which case the user will be required to correct the

interference at his own expense.

CAUTION

Changes or modifications not expressly approved by the party responsible for compliance

could void the user’s authority to operate the equipment.

Canadian Regulations

The CPCI-7806/CPCI-7806RC Class A digital apparatus complies with Canadian

ICES-003.

NOTE

Any equipment tested and found compliant with FCC Part 15 for unintentional radiators or

EN55022 (previously CISPR 22) satisfy ICES-003.

Publication No. 500-657806-000 Rev. G About This Manual 7

Technical Support Contact Information

You can find technical assistance contact details on the website Support

page.

LINK

https://www.abaco.com/support

Abaco will log your query in the Technical Support database and allocate it a

unique Case number for use in any future correspondence.

Alternatively, you may also contact Abaco’s Technical Support via:

LINK

[email protected]

Returns

If you need to return a product, there is a Return Materials Authorization

(RMA) form available via the website Support page.

LINK

https://www.abaco.com/support

Do not return products without first contacting the Abaco Repairs facility.

8 CPCI-7806/CPCI-7806RC Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

Table of Contents

1 • Handling and Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

1.1 Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

1.2 Unpacking Procedures. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

1.3 Handling Precaution. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

1.4 Hardware Setup. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

1.5 Installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22

1.6 BIOS Setup. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23

1.7 Front/Rear Panel Connectors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24

1.7.1 LED Definition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

2 • Standard Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26

2.1 CPU. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26

2.2 Physical Memory. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27

2.3 I/O Port Map. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28

2.4 Interrupts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30

2.4.1 System Interrupts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30

2.4.2 PCI Interrupts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

2.5 PCI Device Interrupt Map. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33

2.6 Integrated Peripherals. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35

2.7 Ethernet Controller. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36

2.8 Video Graphics Adapter. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37

3 • Embedded PC/RTOS Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38

3.1 CompactPCI Bus Bridge. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38

3.1.1 PCI Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

3.1.2 Buffer Architecture . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38

3.1.3 Configuration Register and Control/Status Registers (CSRs) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38

3.1.4 Transaction Forwarding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

3.2 Watchdog Timer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39

3.2.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

3.2.2 Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39

3.2.3 Registers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

3.2.4 Register Unlocking Sequence . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48

3.2.5 Reload Sequence . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48

3.3 CompactFlash. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48

3.3.1 Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48

3.3.2 Functionality . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

3.4 Remote Ethernet Booting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51

3.5 PICMG 2.16 Ethernet. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51

3.6 IPMI 1.5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52

A.1 J1 Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53

A.2 J2 Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54

A.3 J3 Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55

A.4 J5 Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56

A.5 Ethernet Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57

A.6 Serial Connector Pinout (COM1) J8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58

A.7 PMC Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59

A.7.1 PMC #1 (J11)/PMC #2 (J21) Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59

A.7.2 PMC #1 (J12)/PMC #2 (J22) Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60

Publication No. 500-657806-000 Rev. G Table of Contents 9

A.7.3 PMC #1 (J13) Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61

A.7.4 PMC #1 (J14) Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62

B.1 First Boot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63

B.2 Main . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64

B.3 Advanced BIOS Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65

B.4 PCI/PnP Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66

B.5 Boot Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67

B.6 Security Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68

B.7 Chipset Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69

B.8 Exit Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70

C.1 Boot-from-LAN BIOS Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71

C.1.1 First Boot Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71

C.1.2 Boot Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72

C.1.3 BIOS Features Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72

C.2 Managed PC Boot Agent Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73

C.2.1 First Boot Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73

C.2.2 Boot Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74

C.2.3 BIOS Features Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74

D.1 Microsoft Windows 2000 Professional Software Driver Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77

D.1.1 Video Driver Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77

D.1.2 Hance Rapids Chipset Software Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77

D.1.3 USB 2.0 EHCI Host Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78

D.1.4 Ethernet Adapter Drivers Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78

D.2 Microsoft Windows XP Professional Software Driver Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79

D.2.1 Video Driver Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79

D.2.2 Hance Rapids Chipset Software Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79

D.2.3 USB 2.0 EHCI Host Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79

D.2.4 Ethernet Adapter Drivers Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80

E.1 Standard IPMI Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81

E.1.1 Get Device ID . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81

E.2 Cold Reset . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82

E.3 Warm Reset . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82

E.3.1 Get Self-Test Results . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82

E.3.2 SetACPI Power State . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83

E.3.3 Get ACPI Power State . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83

E.3.4 Get Device GUID command . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83

E.3.5 Broadcast Get Device ID . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84

E.3.6 Master-Write-Read . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84

E.3.7 Set Event Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85

E.3.8 Get Event Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85

E.3.9 Get Sensor Reading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85

E.3.10 FRU Inventory Area Info . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87

E.3.11 Read FRU Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87

E.3.12 Write FRU Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88

E.3.13 Get SDR Repository Info . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89

E.3.14 Reserve SDR Repository Command . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89

E.3.15 Get SDR Command . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89

E.4 FRU Data Specification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90

E.5 Platform Events . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91

E.6 Chassis Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92

E.6.1 Get Geographical Address . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92

E.7 BMC Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92

E.7.1 IPMB Relay . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92

E.7.2 Forwarding of Platform Events . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94

E.7.3 Set Platform Event Forwarding Address . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94

10 CPCI-7806/CPCI-7806RC Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

List of Figures

Figure 1 CPCI-7806/CPCI-7806RC Block Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Figure 1-1 CPCI-7806/CPCI-7806RC PMC and Jumper Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

Figure 1-2 Installing a PMC Card on the CPCI-7806/CPCI-7806RC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

Figure 1-3 Front Panel LED Positions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

Figure 2-1 Connections for the PC Interrupt Logic Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

Figure 3-1 Watchdog Timer Block Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40

Figure 3-2 Typical System Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

Figure A-1 J1 Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

Figure A-2 J2 Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54

Figure A-3 J3 Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55

Figure A-4 J5 Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56

Figure A-5 Ethernet Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57

Figure A-6 Serial Connector and Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58

Publication No. 500-657806-000 Rev. G List of Tables 11

List of Tables

Table 1-1 SBC Board Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Table 1-2 Battery Enable (User Configurable) - Jumper (E3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Table 1-3 Password Clear and Boot Continuation (User Configurable) - Jumper (E4) . . . . . . . . . . . . . . . . . . . . . . . 20

Table 2-1 CPCI-7806/CPCI-7806RC I/O Address Map . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28

Table 2-2 PC Hardware Interrupt Line Assignments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Table 2-3 PC Interrupt Vector Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

Table 2-4 PCI Device Interrupt Mapping by the BIOS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

Table 2-5 NMI Register Bit Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

Table 2-6 Supported Graphics Video Resolutions for Windows 2000 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

Table 2-7 Supported Graphics Video Resolutions for Windows XP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

Table 3-1 Configuration Registers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Table 3-2 Memory Mapped Registers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Table 3-3 Vendor Identification Register (VID) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Table 3-4 Device Identification Register (DID) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41

Table 3-5 Command Register (COM) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

Table 3-6 Details of Command Register (COM) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42

Table 3-7 Device Status Register (DS) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

Table 3-8 Details of Device Status Register (DS) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

Table 3-9 Revision Identification Register (RID) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

Table 3-10 Programming Interface Register (PI) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

Table 3-11 Sub Class Code Register (SCC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

Table 3-12 Base Code Class Register (BCC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

Table 3-13 Header Type Register (HEDT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

Table 3-14 Base Address Register 1 (BAR1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

Table 3-15 Details of Base Address Register 1 (BAR1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43

Table 3-16 Subsystem Vendor ID (SVID) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

Table 3-17 Subsystem ID (SID) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

Table 3-18 WDT Configuration Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

Table 3-19 Details of WDT Configuration Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

Table 3-20 WDT Lock Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

Table 3-21 Details of WDT Lock Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

Table 3-22 Manufacturer’s ID . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Table 3-23 Details of Manufacturer’s ID . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46

Table 3-24 Preload Value 1 Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Table 3-25 Details of Preload Value 1 Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Table 3-26 Preload Value 2 Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Table 3-27 Details of Preload Value 2 Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

Table 3-28 General Interrupt Status Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

Table 3-29 Details of General Interrupt Status Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

Table 3-30 Reload Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

Table 3-31 Details of Reload Register . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47

Table A-1 RJ45 - DB9 Adapter Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58

Table A-2 PMC #1 (J11)/PMC #2 (J21) Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59

Table A-3 PMC #1 (J12)/PMC #2 (J22) Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60

12 CPCI-7806/CPCI-7806RC Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

Table A-4 PMC #1 J13 Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61

Table A-5 PMC #1 J14 Connector Pinout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62

Table C-1 First Boot Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71

Table C-2 Boot-from-LAN BIOS Boot Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72

Table C-1 Intel Boot Agent First Boot Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73

Table C-2 Managed PC Boot Agent Boot Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74

Table C-3 RPL Default Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74

Table C-4 TCP/IP Default Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75

Table C-5 Netware Default Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75

Table C-6 PXE Default Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76

Table E-1 NetFn 0x06, Cmd 0x01 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81

Table E-2 NetFn 0x06, Cmd 0x02 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82

Table E-3 NetFn 0x06, Cmd 0x03 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82

Table E-4 NetFn 0x06, Cmd 0x04 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82

Table E-5 NetFn 0x06, Cmd 0x06 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83

Table E-6 NetFn 0x06, Cmd 0x07 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83

Table E-7 NetFn 0x06, Cmd 0x08 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84

Table E-8 NetFn 0x06, Cmd 0x52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84

Table E-9 NetFn 0x04, Cmd 0x00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85

Table E-10 NetFn 0x04, Cmd 0x01 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85

Table E-11 NetFn 0x04, Cmd 0x2D . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86

Table E-12 NetFn 0x0A, Cmd 0x10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87

Table E-13 NetFn 0x0A, Cmd 0x11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88

Table E-14 NetFn 0x0A, Cmd 0x12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88

Table E-15 NetFn 0x0A, Cmd 0x20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89

Table E-16 NetFn 0x0A, Cmd 0x22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89

Table E-17 NetFn 0x0A, Cmd 0x23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90

Table E-18 NetFn 0x04, Cmd 0x02 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91

Table E-19 NetFn 0x30, Cmd 0x01 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92

Table E-20 NetFn 0x32, Cmd 0x00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93

Table E-21 NetFn 0x32, Cmd 0x80 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94

Publication No. 500-657806-000 Rev. G 13

Overview

Abaco Systems’ CPCI-7806

*

/CPCI-7806RC

*

are full featured Pentium

®

M or

Celeron

®

M based, single board computers (SBCs) in a single-slot, passively

cooled, Eurocard form factor. These products utilize the advanced technology of

the Intel

®

855GME chipset. The CPCI-7806/CPCI-7806RC are compliant with the

CompactPCI Specification Rev. 2.2 and features a universal PCI-to-PCI bridge,

allowing the boards to function as a system controller or peripheral CPU in multi-

CPU systems.

Features

The CPCI-7806/CPCI-7806RC provide features typically found on desktop

systems:

• Up to 1 Gbyte DDR SDRAM

•Built-in SVGA support (requires ACC-0584

*

/ACC-0584RC

*

)

• Built-in Dual Gigabit Ethernet (GbE)

• Ultra IDE drive support (requires ACC-0584/ACC-0584RC)

• Serial ATA (requires ACC-0584/ACC-0584RC)

• Floppy drive support (requires ACC-0584/ACC-0584RC)

• USB 2.0 (requires ACC-0584/ACC-0584RC)

• Two RS232 serial ports (COM1 via front panel, COM2 via ACC-0584/

ACC-0584RC)

•Real-Time clock/calendar

• Front panel reset switch

• Miniature speaker

• Keyboard/Mouse port (requires ACC-0584/ACC-0584RC)

The 855GME chipset allows the CPCI-7806/CPCI-7806RC to provide enhanced

features such as integrated video and Ultra ATA/100 IDE support. The CPCI-7806/

CPCI-7806RC are capable of executing many of today’s desktop operating

systems such as Microsoft

®

’s Windows

®

XP, Windows 2000 and a wide variety of

Linux

®

based operating systems. The standard desktop features of the CPCI-7806/

CPCI-7806RC are described in Chapter 2

Standard Features, page 26 of this

manual.

The CPCI-7806/CPCI-7806RC provide features useful to embedded applications

such as:

•PICMG

®

2.16 support

• Universal CompactPCI support (system controller or peripheral)

• Remote Ethernet booting

• Up to 1 Gbyte of bootable CompactFlash (optional)

• Software-selectable Watchdog Timer with reset

14 CPCI-7806/CPCI-7806RC Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

• LVDS Flat Panel Video (requires ACC-0584/ACC-0584RC)

•IPMI Rev 1.5

NOTE

IPMI is no longer supported. Older boards may have IPMI.

Additionally, the CPCI-7806/CPCI-7806RC offers two PMC expansion sites with

front panel access and I/O routing to the J5 connector of the CompactPCI bus. The

CPCI-7806/CPCI-7806RC are capable of executing many of today’s embedded

operating systems such as VxWorks

®

or QNX

®

.

The embedded features of the CPCI-7806/CPCI-7806RC are described in

Chapter 3

Embedded PC/RTOS Features, page 38 of this manual.

The CPCI-7806/CPCI-7806RC are suitable for use in applications ranging from

telecommunications, simulation, instrumentation, industrial control, process

control and monitoring, factory automation, automated test systems, data

acquisition systems and anywhere that the highest performance processing

power in a single CompactPCI slot is desired.

Publication No. 500-657806-000 Rev. G 15

Intel 855GME Chipset

The CPCI-7806/CPCI-7806RC incorporate the latest Intel chipset technology, the

855GME. This chipset utilizes Advanced Hub Architecture (AHA). The AHA

allows for increased system performance by separating many high-bandwidth

I/O accesses from PCI accesses, relieving bottlenecks on the PCI bus. Furthermore,

the 855GME chipset brings new levels of integration to motherboard chipsets and

provides additional features such as Ultra ATA/100, Integrated LVDS and Serial

ATA.

Figure 1 CPCI-7806/CPCI-7806RC Block Diagram

32/33 PCI

Pentium M

or

Celeron M

Processor

DRR

SDRAM

SODIMM

Intel 855GME

Graphics and Memory

Controller Hub

(GMCH)

CompactPCI

Connector

32/33

PMC

Memory

System

Memory Bus

Digital Video

LVDS

SVGA

Compact

Flash

Socket

CompactPCI

Connector

CompactPCI

Connector

CompactPCI

Connector

IDE

USB1, USB2

USB 2.0

Serial ATA

Intel 6800ESB

I/O Controller

Hub

BIOS

LPC/FWH

Bus

Super

I/O

COM 1

COM 2

Floppy

PS/2 Keyboard

and Mouse

Front

Panel

CompactPCI

Connector

CompactPCI

Connector

CompactPCI

Connector

IPMI

64/66 PCI Bus

Universal

PCI-to-PCI

Bridge

PCI

Mezzanine

Expansion

Site

CompactPCI

Connector

CompactPCI Bus

PMC I/O

Intel 82546EB

Dual Ethernet

Controller

PICMG

2.16

Interface

SWX

Front

Panel

Ethernet Ethernet

Front

Panel

Notes: Intel 82546GB Dual Ethernet Controller is for CPCI-7806 RoHS product only.

Pentium M Processor

or

Celeron M Processor

DDR

SDRAM

SODIMM

Compact

Flash

Socket

Intel 6300ESB

I/O Controller

Hub

BIOS

32-bit/

33 MHz PCI

PMC I/O

Ethernet Ethernet

COM 1

COM 2

Floppy

PS/2 Keyboard

and Mouse

LPC/FWH

Bus

Super

I/O

Front

Panel

CompactPCI

Connector

CompactPCI

Connector

CompactPCI

Connector

CompactPCI

Connector

IPMI

64-bit/66 MHz PCI Bus

Universal

PCI-to-PCI

Bridge

PICMG

2.16

Interface

SWX

Front

Panel

Front

Panel

CompactPCI

Connector

CompactPCI Bus

Intel 82546EB

Dual Ethernet

Controller

PCI

Mezzanine

Expansion

Site

CompactPCI

Connector

CompactPCI

Connector

32-bit/

33 MHz

PMC

Memory

System

Memory Bus

Digital Video

LVDS

SVGA

IDE

Serial ATA

USB1, USB2

USB 2.0

Intel 855GME

Graphics and Memory

Controller Hub

(GMCH)

CompactPCI

Connector

Intel 82546GB

or

IPMI is no longer supported. Older boards may have IPMI.

16 CPCI-7806/CPCI-7806RC Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

Safety Summary

The following general safety precautions must be observed during all phases of

the operation, service and repair of this product. Failure to comply with these

precautions or with specific warnings elsewhere in this manual violates safety

standards of design, manufacture and intended use of this product.

Abaco Systems assumes no liability for the customerʹs failure to comply with

these requirements.

Ground the System

To minimize shock hazard, the chassis and system cabinet must be connected to

an electrical ground. A three-conductor AC power cable should be used. The

power cable must either be plugged into an approved three-contact electrical

outlet or used with a three-contact to two-contact adapter with the grounding

wire (green) firmly connected to an electrical ground (safety ground) at the power

outlet.

Do Not Operate in an Explosive Atmosphere

Do not operate the system in the presence of flammable gases or fumes. Operation

of any electrical system in such an environment constitutes a definite safety

hazard.

Keep Away from Live Circuits

Operating personnel must not remove product covers. Component replacement

and internal adjustments must be made by qualified maintenance personnel. Do

not replace components with power cable connected. Under certain conditions,

dangerous voltages may exist even with the power cable removed. To avoid

injuries, always disconnect power and discharge circuits before touching them.

Do Not Service or Adjust Alone

Do not attempt internal service or adjustment unless another person capable of

rendering first aid and resuscitation is present.

Do Not Substitute Parts or Modify System

Because of the danger of introducing additional hazards, do not install substitute

parts or perform any unauthorized modification to the product. Return the

product to Abaco Systems for service and repair to ensure that safety features are

maintained.

Dangerous Procedure Warnings

Warnings, such as the example below, precede only potentially dangerous

procedures throughout this manual. Instructions contained in the warnings must

be followed.

WARNING

Dangerous voltages, capable of causing death, are present in this system. Use extreme

caution when handling, testing and adjusting.

Publication No. 500-657806-000 Rev. G Handling and Installation 17

1 • Handling and Installation

1.1 Introduction

This chapter describes the hardware jumper settings, connector descriptions,

installation, system setup and operation of the CPCI-7806/CPCI-7806RC.

1.2 Unpacking Procedures

Any precautions found in the shipping container should be observed. All items

should be carefully unpacked and thoroughly inspected for damage that might

have occurred during shipment. The board(s) should be checked for broken

components, damaged printed circuit board(s), heat damage and other visible

contamination. All claims arising from shipping damage should be filed with the

carrier and a complete report sent to Abaco Customer Care.

1.3 Handling Precaution

Electronic assemblies use devices that are sensitive to static discharge. Observe

anti-static procedures when handling these boards. All products should be in an

anti-static plastic bag or conductive foam for storage or shipment. Work at an

approved anti-static workstation when unpacking boards.

18 CPCI-7806/CPCI-7806RC Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

1.4 Hardware Setup

The CPCI-7806/CPCI-7806RC are factory populated with user-specified options as

part of the CPCI-7806/CPCI-7806RC ordering information. The RAM size and

CompactFlash memory size are not user-upgradable. To change RAM or

CompactFlash size, contact Customer Care to receive a Return Material

Authorization (RMA).

Abaco Customer Care is available at:

www.abaco.com

The CPCI-7806/CPCI-7806RC are tested for system operation and shipped with

factory-installed header jumpers. The physical location of the jumpers and

connectors for the single board computers (SBCs) are illustrated in

Figure 1-1 on

page 19

. The definitions of the SBC board jumpers and connectors are included in

Table 1-1 through Table 1-3. Please note that the CPCI-7806/CPCI-7806RC offer

two PMC sites designated PMC #1 and PMC #2 as shown in

Figure 1-1 on

page 19

.

CAUTION

All jumpers marked

User Configurable

in the following tables may be changed or modified by the user.

All jumpers marked

Factory Configured

should not be modified by the user.

Care must be taken when making jumper modifications to ensure against improper settings or

connections. Improper settings may result in damage to the unit.

Modifying any jumper not marked

User Configurable

will void the Warranty and may damage the unit.

Publication No. 500-657806-000 Rev. G Handling and Installation 19

Figure 1-1 CPCI-7806/CPCI-7806RC PMC and Jumper Locations

PMC 1

PMC 2

20 CPCI-7806/CPCI-7806RC Pentium/Celeron M Universal CompactPCI Single Board Computer Publication No. 500-657806-000 Rev. G

NOTE

E3 Jumper Position 2 – 4 is for MFG test only. Do not install jumper.

The BIOS has the capability (not currently enabled) of password protecting casual access to the unit’s

CMOS set-up screens. The Password Clear jumper allows the user to clear the CMOS and password in

the case of a system BIOS malfunction or forgotten password.

NOTE

E4 jumper is factory installed 2-4 to hold jumper in place for shipping.

Table 1-1 SBC Board Connectors

Connector Function

J1, J2 CompactPCI

J3 COM2, Floppy

J5 USB, IDE, SATA, PMC I/O

J6, J7 Ethernet 1, Ethernet 2

J8 COM 1

J11, J12, J13, J14 PMC Slot 1

J21, J22 PMC Slot 2

J25 ITP

E2 Hotswap Switch

E3 Battery

E4 CMOS Clear and Boot

Continuation

Table 1-2 Battery Enable (User Configurable) - Jumper (E3)

Select Jumper Position 1-3 Jumper Position 2-4

Battery Enabled Jumper No Jumper

Battery Disabled No Jumper No Jumper

Table 1-3 Password Clear and Boot Continuation (User Configurable) - Jumper (E4)

Jumper Position

1-2

Jumper Position

3-4

Normal No Jumper

Clear CMOS/

Password

Jumper

Normal: Boot Halt

on POST error

No Jumper

Boot with POST

error

Jumper

Page is loading ...

abaco systems CPCI-7806RC Hardware Reference Manual

This manual is also suitable for

abaco systems CPCI-7806RC Hardware Reference Manual

Other documents