GE PTDS650GMWT Installation guide

Brand: GE

Model: PTDS650GMWT

Type: Installation guide

WARNING RISK OF FIRE

7RUHGXFHWKHULVNRIVHYHUHLQMXU\RUGHDWKIROORZDOOLQVWDOODWLRQLQVWUXFWLRQV

&ORWKHVGU\HULQVWDOODWLRQPXVWEHSHUIRUPHGE\DTXDOL¿HGLQVWDOOHU

,QVWDOOWKHFORWKHVGU\HUDFFRUGLQJWRWKHVHLQVWUXFWLRQVDQGLQDFFRUGDQFHZLWKORFDO

FRGHV,QWKHDEVHQFHRIORFDOFRGHVLQVWDOODWLRQPXVWFRPSO\ZLWK1DWLRQDO)XHO*DV

&RGH$16,=1)3$RUWKH&DQDGLDQ1DWXUDO*DVDQG3URSDQH,QVWDOODWLRQ&RGH

&6$%

California Safe Drinking Water and Toxic Enforcement Act.

7KLVDFWUHTXLUHVWKHJRYHUQRURI&DOLIRUQLDWRSXEOLVKDOLVWRIVXEVWDQFHVNQRZQWRWKH

VWDWHWRFDXVHFDQFHUELUWKGHIHFWVRURWKHUUHSURGXFWLYHKDUPDQGUHTXLUHVEXVLQHVVHV

WRZDUQFXVWRPHUVRISRWHQWLDOH[SRVXUHWRVXFKVXEVWDQFHV*DVDSSOLDQFHVFDQ

FDXVHPLQRUH[SRVXUHWRIRXURIWKHVHVXEVWDQFHVQDPHO\EHQ]HQHFDUERQPRQR[LGH

IRUPDOGHK\GHDQGVRRWFDXVHGSULPDULO\E\WKHLQFRPSOHWHFRPEXVWLRQRIQDWXUDOJDV

RU/3IXHOV3URSHUO\DGMXVWHGGU\HUVZLOOPLQLPL]HLQFRPSOHWHFRPEXVWLRQ([SRVXUH

WRWKHVHVXEVWDQFHVFDQEHPLQLPL]HGIXUWKHUE\SURSHUO\YHQWLQJWKHGU\HUWRWKH

RXWGRRUV

7KLVGU\HUPXVWEHH[KDXVWHGWRWKHRXWGRRUV

8VHRQO\µULJLGPHWDOGXFWLQJIRUH[KDXVWLQJWKHFORWKHVGU\HUWRWKHRXWGRRUV

DO NOTLQVWDOODFORWKHVGU\HUZLWKÀH[LEOHSODVWLFGXFWLQJPDWHULDOV,IÀH[LEOHPHWDO

VHPLULJLGRUIRLOW\SHGXFWLVLQVWDOOHGLWPXVWEH8/OLVWHGDQGLQVWDOOHGLQDFFRUGDQFH

ZLWKWKHLQVWUXFWLRQVIRXQGLQ´&RQQHFWLQJ7KH'U\HU7R+RXVH9HQWµRQSDJHRIWKLV

PDQXDO)OH[LEOHYHQWLQJPDWHULDOVDUHNQRZQWRFROODSVHEHHDVLO\FUXVKHGDQGWUDS

OLQW7KHVHFRQGLWLRQVZLOOREVWUXFWGU\HUDLUÀRZDQGLQFUHDVHWKHULVNRI¿UH

'RQRWLQVWDOORUVWRUHWKLVDSSOLDQFHLQDQ\ORFDWLRQZKHUHLWFRXOGEHH[SRVHGWRZDWHU

DQGRUZHDWKHU

6DYHWKHVHLQVWUXFWLRQV,QVWDOOHUV%HVXUHWROHDYHWKHVHLQVWUXFWLRQVZLWKWKH

FXVWRPHU

In the state of Massachusetts:

 InstaOOatLon Pust Ee SeUfoUPeG E\ a TuaOL¿eG oU OLcenseG contUactoU

SOuPEeU oU Jas¿tteU TuaOL¿eG oU OLcenseG E\ the state

 When usLnJ EaOOt\Se Jas shutoff YaOYes the\ shaOO Ee ThanGOe t\Se

 A Àe[LEOe Jas connectoU Zhen useG Pust not e[ceeG  feet

Installation

Instructions

Gas Dryer



4uestions on Installation" &all: GE&ARES 8S

RUYLVLWRXUZHEVLWHDWwww.GEAppliances.com (US)

%EFORE <O8 %EGIN

Read these instructions completely and

carefully



IM3ORTANT6DYHWKHVHLQVWUXFWLRQVIRU

ORFDOLQVSHFWRU·VXVH



IM3ORTANT2EVHUYHDOOJRYHUQLQJFRGHV

DQGRUGLQDQFHV

 Note to Installer %HVXUHWROHDYHWKHVH

LQVWUXFWLRQVZLWKWKHFXVWRPHU

Note to &ustomer .HHSWKHVHLQVWUXFWLRQV

ZLWK\RXU2ZQHU·V0DQXDOIRUIXWXUHUHIHUHQFH

%HIRUHWKHROGGU\HULVUHPRYHGIURPVHUYLFHRU

GLVFDUGHGUHPRYHWKHGU\HUGRRU

,QVSHFWWKHGU\HUH[KDXVWRXWOHWDQGVWUDLJKWHQ

WKHRXWOHWZDOOVLIWKH\DUHEHQW

6HUYLFHLQIRUPDWLRQDQGWKHZLULQJGLDJUDP

DUHORFDWHGLQWKHFRQWUROFRQVROH

'RQRWDOORZFKLOGUHQRQRULQWKHDSSOLDQFH

&ORVHVXSHUYLVLRQRIFKLOGUHQLVQHFHVVDU\ZKHQ

WKHDSSOLDQFHLVXVHGQHDUFKLOGUHQ

,QVWDOOWKHGU\HUZKHUHWKHWHPSHUDWXUHLV

DERYH)IRUVDWLVIDFWRU\RSHUDWLRQRIWKH

GU\HUFRQWUROV\VWHP

3URGXFWIDLOXUHGXHWRLPSURSHULQVWDOODWLRQLV

QRWFRYHUHGXQGHUWKH:DUUDQW\

LEVEL

8" PIPE WRENCH

10" ADJUSTABLE WRENCHES

(x2)

TOOLS YOU

WILL NEED

SLIP JOINT PLIERS

FLAT BLADE SCREWDRIVER

M ATERIALS YOU WILL NEED

EXHAUST HOOD

FLEXIBLE GAS LINE CONNECTOR

SOAP SOLUTION

FOR LEAK DETECTION

PIPE

COMPOUND

DUCT TAPE

GLOVES

SAFETY GLASSES

4" DIAM METAL ELBOW

4" DUCT CLAMPS

4" SPRING CLAMPS

(x2)

4" DIA. FLEXIBLE METAL (SEMI-RIGID)

UL LISTED TRANSITION DUCT

(IF NEEDED)

KIT WX08X10077 (INCLUDES 2 ELBOWS)

4" DIA. METAL DUCT

(RECOMMENDED)

4" DIA. FLEXIBLE METAL (FOIL TYPE)

UL LISTED TRANSITION DUCT

(IF NEEDED.)

234D1582P003 31-16225-2 03-12 GE

6WHS9HULI\<RXU*DV,QVWDOODWLRQVHHVHFWLRQ

6WHS3UHSDUHWKH$UHDDQG([KDXVWIRU,QVWDOODWLRQRI

1HZ'U\HUVHHVHFWLRQ

6WHS&KHFNDQG,QVXUHWKH([LVWLQJ([WHUQDO([KDXVWLV

&OHDQVHHVHFWLRQDQG0HHWV$WWDFKHG,QVWDOODWLRQ

6SHFL¿FDWLRQVVHHVHFWLRQ

6WHS5HPRYHWKH)RDP6KLSSLQJ3DGVVHHVHFWLRQ

6WHS0RYHWKH'U\HUWRWKH'HVLUHG/RFDWLRQ

6WHS/HYHO<RXU'U\HUVHHVHFWLRQ

6WHS&RQQHFWWKH*DV6XSSO\VHHVHFWLRQDQGFKHFNIRU

OHDNVVHHVHFWLRQ

6WHS&RQQHFWWKH([WHUQDO([KDXVWVHHVHFWLRQ

6WHS&RQQHFWWKH3RZHU6XSSO\VHHVHFWLRQ

6WHS&KHFNWKH2SHUDWLRQRIWKH3RZHU6XSSO\*DV

&RQQHFWLRQVDQG9HQWLQJ

6WHS3ODFHWKH2ZQHU·V0DQXDODQGWKH,QVWDOODWLRQ

,QVWUXFWLRQVLQDORFDWLRQZKHUHWKH\ZLOOEHQRWLFHG

 E\WKHRZQHU

)RU$OFRYHRU&ORVHW,QVWDOODWLRQVHHVHFWLRQ

)RU%DWKURRPRU%HGURRP,QVWDOODWLRQVHHVHFWLRQ

)RU0RELOHRU0DQXIDFWXUHG+RPHVHHVHFWLRQ

)RUJDUDJHLQVWDOODWLRQLIDOORZHGE\ORFDOFRGHVVHHVHFWLRQ



Installation Instructions

Minimum &learance Other Than AlcoYe or &loset Installation

0LQLPXPFOHDUDQFHWRFRPEXVWLEOHVXUIDFHVDQGIRUDLURSHQLQJDUHLQFOHDUDQFHERWKVLGHVDQGLQUHDU

&RQVLGHUDWLRQ mustEHJLYHQWRSURYLGHDGHTXDWHFOHDUDQFHIRULQVWDOODWLRQDQGVHUYLFH

GAS RE48IREMENTS

WARNING

 Installation must conform to local codes and

ordinances or in their aEsence the NATIONA/ F8E/

GAS &ODE ANSI =22

 This Jas dryer is eTuipped Zith a 9alYe  %urner

AssemEly for use only Zith natural Jas 8sinJ

conYersion Nit WE2;2 your local serYice

orJani]ation can conYert this dryer for use Zith

propane /3 Jas A// &ON9ERSIONS M8ST %E MADE %<

3RO3ER/< TRAINED AND 48A/IFIED 3ERSONNE/ AND

IN A&&ORDAN&E WIT+ /O&A/ &ODES AND ORDINAN&E

RE48IREMENTS

 The dryer must Ee disconnected from the Jas supply

pipinJ system durinJ any pressure testinJ of that

system at a test pressure in e[cess of  3SI  K3a

 The dryer must Ee isolated from the Jas supply pipinJ

system Ey closinJ the eTuipment shutoff YalYe durinJ

any pressure testinJ of the Jas supply pipinJ of test

pressure eTual to or less than  3SI  K3a

GAS S833/<

 $LQ1DWLRQDO3LSH7DSHUWKUHDGSOXJJHGWDSSLQJ

DFFHVVLEOHIRUWHVWJDXJHFRQQHFWLRQPXVWEHLQVWDOOHG

LPPHGLDWHO\XSVWUHDPRIWKHJDVVXSSO\FRQQHFWLRQWR

WKHGU\HU&RQWDFW\RXUORFDOJDVXWLOLW\VKRXOG\RXKDYH

TXHVWLRQVRQWKHLQVWDOODWLRQRIWKHSOXJJHGWDSSLQJ

 6XSSO\OLQHLVWREHLQULJLGSLSHDQGHTXLSSHGZLWK

DQDFFHVVLEOHVKXWRȺZLWKLQIWRIDQGLQWKHVDPH

URRPZLWKWKHGU\HU

 8VHSLSHWKUHDGVHDOHUFRPSRXQGRU7HÀRQWDSHDSSUR

SULDWHIRUQDWXUDORU/3JDV

 <RXPXVWXVHZLWKWKLVGU\HUDÀH[LEOHPHWDOFRQQHFWRU

OLVWHGFRQQHFWRU$16,=&6$7KHOHQJWKRIWKH

FRQQHFWVKDOOQRWH[FHHGIW

 &RQQHFWÀH[LEOHPHWDOFRQQHFWRUWRGU\HUDQGJDVVXSSO\

 2SHQVKXWRȺYDOYH

INTERNAL DUCT

OPENING

CHECK THAT EXHAUST

HOOD DAMPER OPENS

AND CLOSES FREELY.

WALL

TILT THE DRYER SIDEWAYS

AND REMOVE THE FOAM

SHIPPING PADS BY

PULLING AT THE SIDES

AND BREAKING THEM

AWAY FROM THE DRYER

LEGS. BE SURE TO

REMOVE ALL OF THE

FOAM PIECES AROUND

THE LEGS.



3RE3ARING FOR INSTA//ATION

OF NEW DRYER

TI3: Install your dryer Eefore installinJ your Zasher

This Zill alloZ Eetter access Zhen installinJ dryer

e[haust

DISCONNECTING GAS

REMO9ING /INT FROM WA//

E;+A8ST O3ENING

 RemoYe and discard e[istinJ plastic or metal foil

transition duct and replace Zith 8/ listed transition

duct

DISCONNECT AND DISCARD OLD

FLEXIBLE GAS CONNECTOR AND

OLD TRANSITION DUCTING

MATERIAL. REPLACE WITH NEW

CSA(AGA) APPROVED FLEXIBLE

GAS LINE CONNECTOR AND UL

APPROVED TRANSITION DUCT.

TURN GAS

SHUT-OFF VALVE

TO THE OFF

POSITION.

WARNING  NE9ER RE8SE O/D

F/E;I%/E CONNECTORS

7KHXVHRIROGÀH[LEOHFRQQHFWRUVFDQFDXVHOHDNV

DQGSHUVRQDOLQMXU\$OZD\VXVHQHZÀH[LEOHFRQQHF

WRUVZKHQLQVWDOOLQJJDVDSSOLDQFHV

DRYER GAS SUPPLY CONNECTION

2-5/8"

3/8" NPT MALE THREAD GAS SUPPLY

NOTE: Add to vertical dimension

the distance between cabinet

bottom to floor.

 *DVFORWKHVGU\HUVLQSXWUDWLQJVDUHEDVHGRQVHDOHYHO

RSHUDWLRQDQGQHHGQRWEHDGMXVWHGIRURSHUDWLRQDWRU

EHORZIWHOHYDWLRQ

)RURSHUDWLRQDWHOHYDWLRQVDERYHIWLQSXWUDWLQJV

VKRXOGEHUHGXFHGDWDUDWHRISHUFHQWIRUHDFK

IWDERYHVHDOHYHO

 ,QVWDOODWLRQPXVWFRQIRUPWRORFDOFRGHVDQGRUGLQDQFHVRU

LQWKHLUDEVHQFHWKH1$7,21$/)8(/*$6&2'($16,=

AD-8STING FOR E/E9ATION

Installation Instructions



/EAK TEST



RECONNECTING GAS

Note:7KHFRQQHFWRUDQG¿WWLQJVDUHGHVLJQHGIRUXVH

RQO\RQWKHRULJLQDOLQVWDOODWLRQDQGDUHQRWWREHUHXVHG

IRUDQRWKHUDSSOLDQFHRUDWDQRWKHUORFDWLRQ.HHSÀDUH

HQGRIDGDSWRUIUHHRIJUHDVHRLODQGWKUHDGVHDODQW

CA8TION: 8VHDGDSWHUVDVVKRZQ&RQQHFWRU

QXWVPXVWQRWEHFRQQHFWHGGLUHFWO\WRSLSHWKUHDGV

WARNING: NE9ER 8SE AN O3EN

F/AME TO TEST FOR GAS /EAKS

FLARE

NPT

PIPE SIZE

Listed connector ANSI Z21.24

CSA 6.10

1/8" NPT PIPE

PLUG FOR

CHECKING GAS

INLET PRESSURE

AT LEAST 1/2"

3/8" NPT

TIGHTEN THE FLEXIBLE

GAS LINE USING TWO

ADJUSTABLE WRENCHES.

TIGHTEN ALL CONNECTIONS

USING TWO ADJUSTABLE WRENCHES.

DO NOT OVERTORQUE GAS CONNECTIONS!

Installation Instructions



E/ECTRICA/ CONNECTION

INFORMATION

E/ECTRICA/ RE48IREMENTS

7KLVDSSOLDQFHPXVWEHVXSSOLHGZLWK9+]DQG

FRQQHFWHGWRDSURSHUO\JURXQGHGEUDQFKFLUFXLW

SURWHFWHGE\DRUDPSFLUFXLWEUHDNHURUWLPH

GHOD\IXVH,IHOHFWULFDOVXSSO\SURYLGHGGRHVQRWPHHWWKH

DERYHVSHFL¿FDWLRQVLWLVUHFRPPHQGHGWKDWDOLFHQVHG

HOHFWULFLDQLQVWDOODQDSSURYHGRXWOHW

WARNING  TO RED8CE T+E

RISK OF FIRE E/ECTRICA/ S+OCK

AND 3ERSONA/ IN-8RY:

DO NOT 8SE AN E;TENSION CORD OR AN ADA3TER

3/8G WIT+ T+IS A33/IANCE

'U\HUPXVWEHHOHFWULFDOO\JURXQGHGLQDFFRUGDQFH

ZLWKORFDOFRGHVDQGRUGLQDQFHVRULQWKHDEVHQFH

RIORFDOFRGHVLQDFFRUGDQFHZLWKWKH1$7,21$/

(/(&75,&$/&2'($16,1)3$12

WARNING  THIS DRYER IS

E48I33ED A THREE3RONG GRO8NDING

3/8G FOR YO8R 3ROTECTION AGAINST

SHOCK HA=ARD AND SHO8/D %E 3/8GGED

DIRECT/Y INTO A 3RO3ER/Y GRO8NDED

THREE3RONG RECE3TAC/E DO NOT C8T

OR REMO9E THE GRO8NDING 3RONG FROM

THIS 3/8G

ENSURE PROPER GROUND

EXISTS BEFORE USE.

IF LOCAL CODES PERMIT,

AN EXTERNAL GROUND WIRE

(NOT PROVIDED), WHICH MEETS

LOCAL CODES, MAY BE ADDED

BY ATTACHING TO THE GREEN

GROUND SCREW ON THE REAR

OF THE DRYER, AND TO A GROUNDED

METAL COLD WATER PIPE OR OTHER

ESTABLISHED GROUND.

E;HA8ST INFORMATION

E;HA8ST SYSTEM CHECK /IST

HOOD OR WA// CA3

7HUPLQDWHLQDPDQQHUWRSUHYHQWEDFNGUDIWVRUHQWU\RIELUGV

RURWKHUZLOGOLIH

7HUPLQDWLRQVKRXOGSUHVHQWPLQLPDOUHVLVWDQFHWRWKHH[KDXVW

DLUÀRZDQGVKRXOGUHTXLUHOLWWOHRUQRPDLQWHQDQFHWRSUHYHQW

FORJJLQJ

NeYerLQVWDOODVFUHHQLQRURYHUWKHH[KDXVWGXFW7KLVFRXOG

FDXVHOLQWEXLOGXS

:DOOFDSVPXVWEHLQVWDOOHGDWOHDVWLQDERYHJURXQGOHYHO

RUDQ\RWKHUREVWUXFWLRQZLWKWKHRSHQLQJSRLQWHGGRZQ

SE3ARATION OF T8RNS

)RUEHVWSHUIRUPDQFHVHSDUDWHDOOWXUQVE\DWOHDVWIWRI

VWUDLJKWGXFWLQFOXGLQJGLVWDQFHEHWZHHQODVWWXUQDQGH[KDXVW

KRRG

T8RNS OTHER THAN 

2QHWXUQRIRUOHVVPD\EHLJQRUHG

7ZRWXUQVVKRXOGEHWUHDWHGDVRQHWXUQ

(DFKWXUQRYHUVKRXOGEHWUHDWHGDVRQHWXUQ

SEA/ING OF -OINTS

$OOMRLQWVVKRXOGEHWLJKWWRDYRLGOHDNV7KHPDOHHQGRIHDFK

VHFWLRQRIGXFWPXVWSRLQWDZD\IURPWKHGU\HU

'RQRWDVVHPEOHWKHGXFWZRUNZLWKIDVWHQHUVWKDWH[WHQGLQWR

WKHGXFW7KH\ZLOOVHUYHDVDFROOHFWLRQSRLQWIRUOLQW

'XFWMRLQWVFDQEHPDGHDLUDQGPRLVWXUHWLJKWE\ZUDSSLQJ

WKHRYHUODSSHGMRLQWVZLWKGXFWWDSH



+RUL]RQWDOUXQVVKRXOGVORSHGRZQWRZDUGWKHRXWGRRUV

LQFKSHUIRRW

INS8/ATION

'XFWZRUNWKDWUXQVWKURXJKDQXQKHDWHGDUHDRULVQHDUDLU

FRQGLWLRQLQJVKRXOGEHLQVXODWHGWRUHGXFHFRQGHQVDWLRQDQG

OLQWEXLOGXS

WARNING  IN CANADA AND IN THE

8NITED STATES THE RE48IRED E;HA8ST D8CT

DIAMETER IS  IN 2mm DO NOT 8SE D8CT

/ONGER THAN S3ECIFIED IN THE E;HA8ST

/ENGTH TA%/E

8VLQJH[KDXVWORQJHUWKDQVSHFL¿HGOHQJWKZLOO

,QFUHDVHWKHGU\LQJWLPHVDQGWKHHQHUJ\FRVW

5HGXFHWKHGU\HUOLIH

$FFXPXODWHOLQWFUHDWLQJDSRWHQWLDO¿UHKD]DUG

The correct e[haust installation is YO8R RES3ONSI%I/ITY

3roElems due to incorrect installation are not coYered Ey

the Zarranty

5HPRYHDQGGLVFDUGH[LVWLQJSODVWLFRUPHWDOIRLOWUDQVLWLRQ

GXFWDQGUHSODFHZLWK8/OLVWHGWUDQVLWLRQGXFW

7KHMA;IM8M A//OWA%/EGXFWOHQJWKDQGQXPEHURI

EHQGVRIWKHH[KDXVWV\VWHPGHSHQGVXSRQWKHW\SHRIGXFW

QXPEHURIWXUQVWKHW\SHRIH[KDXVWKRRGZDOOFDSDQGDOO

FRQGLWLRQVQRWHGEHORZ7KHPD[LPXPGXFWOHQJWKIRUULJLG

PHWDOGXFWLVVKRZQLQWKHWDEOHEHORZ

EXHAUST LENGTH

4" DIA.

2-1/2"

RECOMMENDED MAXIMUM LENGTH

Exhaust Hood Types

Recommended

No. of 90º

Elbows

Rigid

Metal

Rigid

Metal

90 Feet

60 Feet

45 Feet

35 Feet

60 Feet

45 Feet

35 Feet

25 Feet

Use only

for short

run installations

Installation Instructions

GAS

INLET

PIPE

EXTERNAL

DUCT

OPENING

DUCT TAPE OR

DUCT CLAMP

DUCT TAPE OR

DUCT CLAMP

(CUT TO PROPER

LENGTH)

4" METAL DUCT

CSA (AGA) APPROVED

NEW FLEXIBLE GAS

LINE CONNECTOR

NOTE: WE STRONGLY RECOMMEND SOLID METAL EXHAUST DUCTING.

HOWEVER, IF FLEXIBLE DUCTING IS USED IT MUST BE UL-LISTED METAL

NOT PLASTIC.

FOR STRAIGHT LINE INSTALLATION, CONNECT THE DRYER EXHAUST TO

THE EXTERNAL EXHAUST HOOD USING DUCT TAPE OR CLAMP.

STANDARD REAR EXHAUST

(Vented at floor level)



E;HA8ST CONNECTION

THIS DRYER COMES READY FOR REAR

E;HA8STING IF S3ACE IS /IMITED 8SE

THE INSTR8CTIONS IN SECTION  TO

E;HA8ST DIRECT/Y FROM THE SIDES OR

%OTTOM OF THE CA%INET

RECOMMENDED

CONFIGURATION

TO MINIMIZE

EXHAUST

BLOCKAGE.

ELBOW HIGHLY

RECOMMENDED

ELBOW HIGHLY

RECOMMENDED

NOTE: ELBOWS WILL PREVENT DUCT

KINKING AND COLLAPSING.

STANDARD REAR EXHAUST

(Vented above floor level)

WARNING  TO RED8CE THE

RISK OF FIRE OR 3ERSONA/ IN-8RY:

 7KLVFORWKHVGU\HUPXVWEHH[KDXVWHGWRWKH

RXWGRRUV

 :HUHFRPPHQGWKDW\RXLQVWDOO\RXUGU\HUEHIRUH

LQVWDOOLQJ\RXUZDVKHU7KLVZLOOSHUPLWGLUHFWDFFHVV

IRUHDVLHUH[KDXVWFRQQHFWLRQ

 8VHRQO\µULJLGPHWDOGXFWLQJIRUWKHKRPHH[KDXVW

GXFW

 8VHRQO\µULJLGPHWDORU8/OLVWHGÀH[LEOHPHWDO

VHPLULJLGRUIRLOW\SHGXFWWRFRQQHFWWKHGU\HU

WRWKHKRPHH[KDXVWGXFW,WPXVWEHLQVWDOOHG

LQDFFRUGDQFHZLWKWKHLQVWUXFWLRQVIRXQGLQ

´&RQQHFWLQJ7KH'U\HU7R+RXVH9HQWµRQSDJHRI

WKLVPDQXDO

 'RQRWWHUPLQDWHH[KDXVWLQDFKLPQH\DZDOO

DFHLOLQJJDVYHQWFUDZOVSDFHDWWLFXQGHUDQ

HQFORVHGÀRRURULQDQ\RWKHUFRQFHDOHGVSDFH

RIDEXLOGLQJ7KHDFFXPXODWHGOLQWFRXOGFUHDWHD

SRWHQWLDO¿UHKD]DUG

 1HYHUWHUPLQDWHWKHH[KDXVWLQWRDFRPPRQGXFW

ZLWKDNLWFKHQH[KDXVWV\VWHP$FRPELQDWLRQRI

JUHDVHDQGOLQWFUHDWHVDSRWHQWLDO¿UHKD]DUG

 'RQRWXVHGXFWORQJHUWKDQVSHFL¿HGLQWKHH[KDXVW

OHQJWKWDEOH/RQJHUGXFWVFDQDFFXPXODWHOLQW

FUHDWLQJDSRWHQWLDO¿UHKD]DUG

 1HYHULQVWDOODVFUHHQLQRURYHUWKHH[KDXVWGXFW

7KLVZLOOFDXVHOLQWWRDFFXPXODWHFUHDWLQJD

SRWHQWLDO¿UHKD]DUG

 'RQRWDVVHPEOHGXFWZRUNZLWKDQ\IDVWHQHUV

WKDWH[WHQGLQWRWKHGXFW7KHVHIDVWHQHUVFDQ

DFFXPXODWHOLQWFUHDWLQJDSRWHQWLDO¿UHKD]DUG

 'RQRWREVWUXFWLQFRPLQJRUH[KDXVWHGDLU

 3URYLGHDQDFFHVVIRULQVSHFWLRQDQGFOHDQLQJRI

WKHH[KDXVWV\VWHPHVSHFLDOO\DWWXUQVDQGMRLQWV

([KDXVWV\VWHPVKDOOEHLQVSHFWHGDQGFOHDQHGDW

OHDVWRQFH\HDU

/E9E/ING DRYER

LEVEL

SIDE-TO-SIDE.

4 LEVELING LEGS

2 ANTI-TIP LEGS

LEVEL

FRONT-TO-BACK.

STAND THE DRYER UPRIGHT NEAR THE

FINAL LOCATION AND ADJUST THE 4 LEVELING

LEGS TO MATCH THE HEIGHT OF YOUR WASHER.

ADJUST THE 2 ANTI-TIP LEGS TO CONTACT

THE FLOOR.

Installation Instructions

CONNECTING THE DRYER TO HO8SE 9ENT

RIGID META/ TRANSITION D8CT

 )RUEHVWGU\LQJSHUIRUPDQFHDULJLGPHWDOWUDQVLWLRQGXFWLV

UHFRPPHQGHG



5LJLGPHWDOWUDQVLWLRQVGXFWVUHGXFHWKHULVNRIFUXVKLQJDQGNLQNLQJ

8//ISTED F/E;I%/E META/ SEMIRIGID TRANSITION D8CT

 ,IULJLGPHWDOGXFWFDQQRWEHXVHGWKHQ8/OLVWHGÀH[LEOH

PHWDOVHPLULJLGGXFWLQJFDQEHXVHG.LW:;;

 1HYHULQVWDOOÀH[LEOHPHWDOGXFWLQZDOOVFHLOLQJVÀRRUVRU

RWKHUHQFORVHGVSDFHV

 7RWDOOHQJWKRIÀH[LEOHPHWDOGXFWVKRXOGQRWH[FHHGIHHWP

 )RUPDQ\DSSOLFDWLRQVLQVWDOOLQJHOERZVDWERWKWKHGU\HU

DQGWKHZDOOLVKLJKO\UHFRPPHQGHGVHHLOOXVWUDWLRQVEHORZ

(OERZVDOORZWKHGU\HUWRVLWFORVHWRWKHZDOOZLWKRXWNLQNLQJ

DQGRUFUXVKLQJWKHWUDQVLWLRQGXFWPD[LPL]LQJGU\LQJ

SHUIRUPDQFH

 $YRLGUHVWLQJWKHGXFWRQVKDUSREMHFWV

8//ISTED F/E;I%/E META/ FOI/TY3E TRANSITION D8CT

 ,QVSHFLDOLQVWDOODWLRQVLWPD\EHQHFHVVDU\WRFRQQHFWWKH

GU\HUWRWKHKRXVHYHQWXVLQJDÀH[LEOHPHWDOIRLOW\SHGXFW

$8/OLVWHGÀH[LEOHPHWDOIRLOW\SHGXFWPD\EHXVHG21/<

LQLQVWDOODWLRQVZKHUHULJLGPHWDORUÀH[LEOHPHWDOVHPLULJLG

GXFWLQJFDQQRWEHXVHG$1'ZKHUHDµGLDPHWHUFDQEH

PDLQWDLQHGWKURXJKRXWWKHHQWLUHOHQJWKRIWKHWUDQVLWLRQGXFW

,Q&DQDGDDQGWKH8QLWHG6WDWHVRQO\WKHÀH[LEOHPHWDOIRLO

W\SHGXFWVWKDWFRPSO\ZLWKWKH´2XWOLQHIRU&ORWKHV'U\HU

7UDQVLWLRQ'XFW6XEMHFW$µVKDOOEHXVHG

 1HYHULQVWDOOÀH[LEOHPHWDOGXFWLQZDOOVFHLOLQJVÀRRUVRU

RWKHUHQFORVHGVSDFHV

 7RWDOOHQJWKRIÀH[LEOHPHWDOGXFWVKRXOGQRWH[FHHGIHHWP

 $YRLGUHVWLQJWKHGXFWRQVKDUSREMHFWV

 )RUEHVWGU\LQJSHUIRUPDQFH





6OLGHRQHHQGRIWKHGXFWRYHUWKHFORWKHVGU\HURXWOHW

SLSH





6HFXUHWKHGXFWZLWKDFODPS





:LWKWKHGU\HULQLWVSHUPDQHQWSRVLWLRQH[WHQGWKHGXFW

WRLWVIXOOOHQJWK$OORZµRIGXFWWRRYHUODSWKHH[KDXVW

SLSH&XWRȺDQGUHPRYHH[FHVVGXFW.HHSWKHGXFWDV

VWUDLJKWDVSRVVLEOHIRUPD[LPXPDLUÀRZ





6HFXUHWKHGXFWWRWKHH[KDXVWSLSHZLWKWKHRWKHUFODPS

ELBOWS HIGHLY

RECOMMENDED

ELBOW HIGHLY

RECOMMENDED

DO NOT

SIT DRYER

ON FLEXIBLE

EXHAUST

DO NOT USE

EXCESSIVE

EXHAUST

LENGTH

DO NOT

CRUSH

FLEXIBLE

EXHAUST

AGAINST

WALL.

DON’T



A/CO9E OR C/OSET INSTA//ATION

 ,I\RXUGU\HULVDSSURYHGIRULQVWDOODWLRQLQDQDOFRYHRUFORVHW

LWZLOOEHVWDWHGRQDODEHORQWKHGU\HUEDFN

 7KHGU\HUM8STEHYHQWHGWRWKHRXWGRRUV6HHWKHE;HA8ST

INFORMATIONVHFWLRQ

 0LQLPXPFOHDUDQFHEHWZHHQGU\HUFDELQHWDQGDGMDFHQW

ZDOOVRURWKHUVXUIDFHVLV

LQHLWKHUVLGH

LQIURQWDQGUHDU

 0LQLPXPYHUWLFDOVSDFHIURPÀRRUWRRYHUKHDGFDELQHWV

FHLOLQJHWFLVLQ

 &ORVHWGRRUVPXVWEHORXYHUHGRURWKHUZLVHYHQWLODWHGDQG

PXVWFRQWDLQDPLQLPXPRIVTLQRIRSHQDUHDHTXDOO\

GLVWULEXWHG,IWKHFORVHWFRQWDLQVERWKDZDVKHUDQGDGU\HU

GRRUVPXVWFRQWDLQDPLQLPXPRIVTLQRIRSHQDUHD

HTXDOO\GLVWULEXWHG

 7KHFORVHWVKRXOGEHYHQWHGWRWKHRXWGRRUVWRSUHYHQWJDV

SRFNHWLQJLQFDVHRIDJDVOHDNLQWKHVXSSO\OLQH

 1RRWKHUIXHOEXUQLQJDSSOLDQFHVKDOOEHLQVWDOOHGLQWKHVDPH

FORVHWZLWKWKHGU\HU



MO%I/E OR MAN8FACT8RED HOME INSTA//ATION

 ,QVWDOODWLRQPXVWFRQIRUPWRWKHMAN8FACT8RED HOME

CONSTR8CTION  SAFETY STANDARD TIT/E 2 3ART 28

RUZKHQVXFKVWDQGDUGLVQRWDSSOLFDEOHZLWKAMERICAN

NATIONA/ STANDARD FOR MO%I/E HOME NO %

 7KHGU\HUM8STEHYHQWHGWRWKHRXWGRRUVZLWKWKH

WHUPLQDWLRQVHFXUHO\IDVWHQHGWRWKHPRELOHKRPHVWUXFWXUH

6HHE;HA8ST INFORMATIONVHFWLRQ

 7KHYHQWM8ST NOTEHWHUPLQDWHGEHQHDWKDPRELOHRU

PDQXIDFWXUHGKRPH

 7KHYHQWGXFWPDWHULDOM8ST %E META/

 KIT D6 M8STEHXVHGWRDWWDFKWKHGU\HUVHFXUHO\WR

WKHVWUXFWXUH

 7KHYHQW0867127EHFRQQHFWHGWRDQ\RWKHUGXFWYHQWRU

FKLPQH\

 'RQRWXVHVKHHWPHWDOVFUHZVRURWKHUUHIDVWHQLQJGHYLFHV

ZKLFKH[WHQGLQWRWKHLQWHULRURIWKHH[KDXVWYHQW

 3URYLGHDQRSHQLQJZLWKDIUHHDUHDRIDWOHDVWVTLQRU

LQWURGXFWLRQRIRXWVLGHDLULQWRWKHGU\HUURRP

 6WDFNLQJRIDJDVGU\HULVQRWSHUPLWWHGLQDPRELOHKRPHRU

PDQXIDFWXUHGKRPH



%ATHROOM OR %EDROOM INSTA//ATION

 7KHGU\HUM8STEHYHQWHGWRWKHRXWGRRUV6HHE;HA8ST

INFORMATIONVHFWLRQ

 7KHLQVWDOODWLRQPXVWFRQIRUPZLWKORFDOFRGHVRULQWKH

DEVHQFHRIORFDOFRGHVZLWKWKHNATIONA/ F8E/ GAS CODE

ANSI =22

Installation Instructions



DRYER E;HA8ST TO RIGHT /EFT

OR BOTTOM CABINET

WARNING  BEFORE PERFORMING

THIS E;HA8ST

INSTA//ATION BE S8RE

TO DISCONNECT THE DRYER FROM ITS

E/ECTRICA/ S8PP/Y PROTECT YO8R

HANDS AND ARMS FROM SHARP

EDGES WHEN WORKING INSIDE THE

CABINET BE S8RE TO WEAR G/O9ES

Note: Only 4” round rigid metal ducting allowed inside

dryer.

TAB /OCATION

Detach and remove the bottom, right or left side knockout

as desired. Remove the screw inside the dryer exhaust duct

and save. Pull the duct out of the dryer.

REMOVE

SCREW

AND SAVE.

REMOVE

DESIRED

KNOCKOUT

(ONE ONLY).

ADDING NEW D8CT

ADDING E/BOW AND D8CT FOR

E;HA8ST TO /EFT SIDE OF CABINET

3UHDVVHPEOHµHOERZZLWKµGXFW:UDSGXFWWDSH

DURXQGMRLQW

,QVHUWGXFWDVVHPEO\HOERZ¿UVWWKURXJKWKHVLGH

RSHQLQJDQGFRQQHFWWKHHOERZWRWKHGU\HULQWHUQDO

GXFW

CA8TION: Be sure not to pull or damaJe

the electrical Zires inside the dryer Zhen insertinJ the

duct

$SSO\GXFWWDSHDVVKRZQRQWKHMRLQWEHWZHHQWKH

GU\HULQWHUQDOGXFWDQGWKHHOERZ

Cut the duct as shown and keep portion A.

FIXING HOLE

Through the rear opening, locate the tab in the middle of

the appliance base. Lift the tab to about 45º using a flat

blade screwdriver.

BEND TAB

UP 45

Reconnect the cut portion (A) of the duct to the blower

housing. Make sure that the shortened duct is aligned with

the tab in the base. Use the screw saved previously to secure

the duct in place through the tab on the appliance base.

LEFT SIDE

EXHAUST

PORTION "A"

FIXING

HOLE

EXHAUST CAN

BE ADDED TO

LEFT OR RIGHT SIDE

DUCT

TAPE

DUCT

TAPE

CA8TION:

Internal duct joints must be

secured Zith tape otherZise

they may separate and cause

a safety ha]ard

GARAGE INSTA//ATION IF A//OWED

BY /OCA/ CODES

'U\HUVLQVWDOOHGLQJDUDJHVPXVWEHHOHYDWHGLQFKHV

FPDERYHWKHÀRRU

2

Installation Instructions

ADDING E/BOW FOR E;HA8ST

THRO8GH BOTTOM OF CABINET

,QVHUWWKHHOERZWKURXJKWKHUHDURSHQLQJDQGFRQQHFW

LWWRWKHGU\HULQWHUQDOGXFW

$SSO\GXFWWDSHRQWKHMRLQWEHWZHHQWKHGU\HULQWHUQDO

GXFWDQGHOERZDVVKRZQRQSDJH

ADDING CO9ER P/ATE TO REAR OF

CABINET

&RQQHFWVWDQGDUGPHWDOHOERZVDQGGXFWVWRFRPSOHWH

WKHH[KDXVWV\VWHP&RYHUEDFNRSHQLQJZLWKDSODWH.LW

:(0DYDLODEOHIURP\RXUORFDOVHUYLFHSURYLGHU

3ODFHGU\HULQ¿QDOORFDWLRQ

WARNINGNE9ER /EA9E THE BACK

OPENING WITHO8T THE P/ATE

PL ATE

(KIT WE1M454)



CHANGING DIRECTION OF DOOR

OPENING

CAUTION:

Internal duct joints must be secured with tape,

otherwise they may separate and cause a

safety hazard.

ROTATE DOOR 180°

AND REINSTALL.

REMOVE 4

HINGE SCREWS.

REMOVE 4 HOLE PLUGS AND

PLACE THEM IN THE HOLES

ON THE OPPOSITE SIDE.

Installation Instructions

WATER S8PP/Y RE48IREMENTS

+RWDQGFROGZDWHUIDXFHWV0867EHLQVWDOOHGZLWKLQ

LQFPRI\RXUZDVKHU·VZDWHULQOHW7KHIDXFHWV

0867EHLQFPJDUGHQKRVHW\SHVRLQOHWKRVHV

FDQEHFRQQHFWHG:DWHUSUHVVXUH0867EHEHWZHHQ

DQGSRXQGVSHUVTXDUHLQFK<RXUZDWHUGHSDUWPHQW

FDQDGYLVH\RXRI\RXUZDWHUSUHVVXUH

NOTE: $ZDWHUVRIWHQHULVUHFRPPHQGHGWRUHGXFH

EXLOGXSRIVFDOHLQVLGHWKHVWHDPJHQHUDWRULIWKHKRPH

ZDWHUVXSSO\LVYHU\KDUG



CONNECTING IN/ET HOSES

(on some models)

7RSURGXFHVWHDPWKHGU\HUPXVWFRQQHFWWRWKHFROG

ZDWHUVXSSO\6LQFHWKHZDVKHUPXVWDOVRFRQQHFWWRWKH

FROGZDWHUD´<µFRQQHFWRULVLQVHUWHGWRDOORZERWKLQOHW

KRVHVWRPDNHWKDWFRQQHFWLRQDWWKHVDPHWLPH

NOTE:8VHWKHQHZLQOHWKRVHVSURYLGHGQHYHU

XVHROGKRVHV

7XUQWKHFROGZDWHUIDXFHWRȺ5HPRYHWKHZDVKHULQOHW

KRVHIURPWKHZDVKHU¿OOYDOYHFRQQHFWRUFROG

2(QVXUHWKHUXEEHUÀDWZDVKHULVLQSODFHDQGVFUHZWKH

IHPDOHFRXSOLQJRIWKHVKRUWKRVHRQWRWKHZDVKHU¿OO

YDOYHFRQQHFWRU7LJKWHQE\KDQGXQWLO¿UPO\VHDWHG

$WWDFKWKHIHPDOHHQGRIWKH¶·<··FRQQHFWRUWRWKH

PDOHFRXSOLQJRIWKHVKRUWKRVH(QVXUHWKHUXEEHUÀDW

ZDVKHULVLQSODFH7LJKWHQE\KDQGXQWLO¿UPO\VHDWHG

,QVHUWWKH¿OWHUVFUHHQLQWKHFRXSOLQJRIWKHZDVKHU·V

LQOHWKRVH,IDUXEEHUÀDWZDVKHULVDOUHDG\LQSODFH

UHPRYHLWEHIRUHLQVWDOOLQJWKH¿OWHUVFUHHQ$WWDFKWKLV

FRXSOLQJWRRQHPDOHHQGRIWKH¶·<··FRQQHFWRU7LJKWHQ

E\KDQGXQWLO¿UPO\VHDWHG

(QVXUHWKHUXEEHUÀDWZDVKHULVLQSODFHDQGDWWDFKWKH

GU\HU·VORQJLQOHWKRVHWRWKHRWKHUPDOHHQGRIWKH¶·<··

FRQQHFWRU7LJKWHQE\KDQGXQWLO¿UPO\VHDWHG

6(QVXUHWKHUXEEHUÀDWZDVKHULVLQSODFHDQGDWWDFK

WKHRWKHUHQGRIWKHGU\HU·VORQJLQOHWKRVHWRWKH¿OO

YDOYHFRQQHFWRUDWWKHERWWRPRIWKHGU\HUEDFNSDQHO

7LJKWHQE\KDQGXQWLO¿UPO\VHDWHG

8VLQJSOLHUVWLJKWHQDOOWKHFRXSOLQJVZLWKDQDGGLWLRQDO

WZR²WKLUGVWXUQ

NOTE:'RQRWRYHUWLJKWHQ'DPDJHWRWKHFRXSOLQJVPD\

UHVXOW

6

SER9ICING

WARNING /ABE/ A// WIRES

PRIOR TO DISCONNECTION WHEN

SER9ICING CONTRO/S WIRING ERRORS

CAN CA8SE IMPROPER AND DANGERO8S

OPERATION AFTER SER9ICING

INSTA//ATION

)RUVHUYLFLQJSKRQHQXPEHUVIRUUHSODFHPHQWSDUWVDQG

RWKHULQIRUPDWLRQUHIHUWR2ZQHU·V0DQXDORUYLVLWRXU

:HEVLWH



CONNECTING IN/ET HOSES cont

87XUQWKHZDWHUIDXFHWRQ

&KHFNIRUOHDNVDURXQGWKH¶·<··FRQQHFWRUIDXFHWDQG

KRVHFRXSOLQJV

5(*,67(5<2851(:$33/,$1&(725(&(,9($1<

,03257$17352'8&7127,),&$7,216

3OHDVHJRWRZZZGEAppliances.comRUPDLOLQ\RXU

3URGXFW5HJLVWUDWLRQ&DUG

)RUTXHVWLRQVRQLQVWDOODWLRQFDOO86RU

&DQDGD

Notes

GE PTDS650GMWT Installation guide

GE PTDS650GMWT Installation guide

GE PTDS650GMWT Installation guide

Related papers

Other documents