EN
User manual
Condenser dryer
ZDC 37200W
Contents
Important safety information _ _ _ _ _ _ _ _ _ 2
Environment _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 4
Installation _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 4
Product description _ _ _ _ _ _ _ _ _ _ _ _ _ _ 7
Control panel _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 7
Before first use _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 7
Programme chart _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 7
Sorting and preparing laundry _ _ _ _ _ _ _ _ 8
Daily use _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 9
Cleaning and maintenance _ _ _ _ _ _ _ _ _ 10
What to do if ... _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 11
Technical data _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 12
Machine settings _ _ _ _ _ _ _ _ _ _ _ _ _ _ 12
Subject to change without notice.
Important safety information
Important! In the interest of your safety
and to ensure the correct use, before
installing and first using the appliance,
read this user manual carefully, including
its hints and warnings. To avoid
unnecessary mistakes and accidents, it is
important to ensure that all people using
the appliance are thoroughly familiar with
its operation and safety features. Save
these instructions and make sure that
they remain with the appliance if it is
moved or sold, so that everyone using it
through its life will be properly informed
on appliance use and safety.
- Please read the instruction book before
using this appliance.
General safety
• It is dangerous to alter the specifications or
attempt to modify this product in any way.
• This appliance is not intended for use by per-
sons (including children) with reduced physi-
cal and sensory conditions or lack of experi-
ence and knowledge, unless they have been
given supervision or instruction concerning
use of the appliance by a person responsible
for their safety.
• Make sure that small children and pets do not
climb inside the drum. To avoid this, please
check into the drum before using.
• Any objects such as coins, safety pins, nails,
screws, stones or any other hard, sharp ma-
terial can cause extensive damage and must
not be placed into the machine.
• In order to avoid danger of fires caused by
excessive drying, do not use appliance to dry
the following items: Cushions, quilts and the
like (these items accumulate heat).
• Items such as foam rubber (latex foam),
shower caps, waterproof textiles, rubber
backed articles and clothes or pillows fitted
with foam rubber pads should not be dried in
the tumble dryer.
• Always unplug the appliance after use, clean-
ing and maintenance.
• Under no circumstances should you attempt
to repair the machine yourself. Repairs car-
ried out by inexperienced persons may cause
injury or serious malfunctioning. Contact your
local Service Centre. Always insist on genu-
ine spare parts.
• Items that have been soiled with substances
such as cooking oil acetone, petrol, kerosene,
spot removers, turpentine, waxes and wax re-
movers should be washed in hot water with
an extra amount of detergent before being
dried in the tumble dryer.
• Danger of explosion: Never tumble dry
items that have been in contact with inflam-
mable solvents (petrol, methylated spirits, dry
cleaning fluid and the like). As these substan-
ces are volatile, they could cause an explo-
sion. Only tumble dry items washed with wa-
ter.
• Risk of fire: items that have been spotted or
soaked with vegetable or cooking oil consti-
tute a fire hazard and should not be placed in
the tumble dryer.
2
www.zanussi.com
• If you have washed your laundry with stain re-
mover you must execute an extra rinse cycle
before loading your tumble dryer.
• Please make sure that no gas lighters or
matches have accidentally been left in pock-
ets of garments incase they are loaded into
appliance
Warning!
• Risk of fire! Never stop a tumble dry
before the end of the drying cycle
unless all items are quickly re-
moved and spread out so that the
heat is dissipated.
• Lint must not be allowed to accu-
mulate around the tumble dryer.
• Risk of electric shock! Do not spray down
the appliance with jets of water.
• The final part of a tumble dryer cycle occurs
without heat ( cool down cycle ) to ensure
that the items are left at a temperature that
ensures that items will not be damaged.
• The tumble dryer is not to be used if industrial
chemicals have been used for cleaning.
• Ensure you have good ventilation in the instal-
lation room to avoid the back flow of gases
into the room from appliances burning other
fuels, including open fires.
Installation
• This appliance is heavy. Care should be taken
when moving it.
• When unpacking the appliance, check that it
is not damaged. If in doubt, do not use it and
contact the Service Centre.
• All packaging must be removed before use.
Serious damage can occur to the product
and to property if this is not adhered to. See
relevant section in the user manual.
• Any electrical work required to install this ap-
pliance should be carried out by a qualified
electrician or competent person.
• If the machine is situated on a carpeted floor,
please adjust the feet in order to allow air to
circulate freely under the appliance.
• After having installed the appliance, check
that it is not pressing or standing on its elec-
trical supply cable.
• If the tumble dryer is placed on top of a
washing machine, it is compulsory to use the
stacking kit (optional accessory).
Use
• This appliance is designed for domestic use.
It must not be used for purposes other than
those for which it was designed.
• Only wash fabrics which are designed to be
machine dried. Follow the instructions on
each garment label.
• Do not dry unwashed items in the tumble dry-
er.
• Do not overload the appliance. See the rele-
vant section in the user manual.
• Clothes which are dripping wet should not be
placed in the dryer.
• Garments which have been in contact with
volatile petroleum products should not be
machine dried. If volatile cleaning fluids are
used, care should be taken to ensure that the
fluid is removed from the garment before
placing in the machine.
• Never pull the power supply cable to remove
the plug from the socket; always take hold of
the plug itself.
• Never use the tumble dryer if the power sup-
ply cable, the control panel, the working sur-
face or the base are damaged so that the in-
side of the tumble dryer is accessible.
• Fabric softeners, or similar products should
be used as specified by the fabric softener in-
structions.
• Caution - hot surface : Do not touch the
door light cover surface when the light is
switched on.
(Only dryers equipped with internal drum
light)
Child safety
• This machine is not intended for use by
young children or infirm persons without su-
pervision.
• Children often do not recognise the hazards
associated with electrical appliances. Chil-
3
www.zanussi.com
dren should be supervised to ensure that they
do not play with the appliance.
Warning!
• Danger of suffocation! The packaging
components (e.g. plastic film, polystyr-
ene) can be dangerous to children -
Keep them out of children’s reach.
• Keep all detergents in a safe place out of
children’s reach.
• Make sure that children or pets do not climb
inside the drum.
Environment
Recycle the materials with the symbol . Put
the packaging in applicable containers to
recycle it.
Help protect the environment and human health
and to recycle waste of electrical and electronic
appliances. Do not dispose appliances marked
with the symbol
with the household waste.
Return the product to your local recycling facility
or contact your municipal office.
Environmental tips
• In the dryer, laundry becomes fluffy and soft.
Fabric softeners are not therefore needed
when washing.
• Your dryer will function most economically if
you:
– Always keep the ventilation slots on the
base of the dryer unobstructed;
– Use the loading volumes specified in the
programme overview;
– Ensure you have good ventilation in the in-
stallation room;
– Clean the micro-fine filter and fine strainer
after each drying cycle;
– Spin the laundry well before drying.
Energy consumption depends on spinning
speed set in washing machine. Higher
spinning speed - lower energy consumption.
Environmental information
The packaging materials are environmentally
friendly and can be recycled. The plastic com-
ponents are identified by markings, e.g. >PE<,
>PS<, etc. Please dispose of the packaging
materials in the appropriate container at the
community waste disposal facilities.
Warning! When the unit is no longer
being used:
• Pull the plug out of the socket.
• Cut off the cable and plug and dispose of
them.
• Dispose of the door catch. This prevents chil-
dren from trapping themselves inside and en-
dangering their lives.
Installation
Important! The appliance must be moved in
vertical position for transport.
Appliance positioning
• It is recommended that, for your convenience,
the machine is positioned close to your wash-
ing machine.
• The tumble dryer must be installed in a clean
place, where dirt does not build up.
• Air must be able to circulate freely all round
the appliance. Do not obstruct the front venti-
lation grille or the air intake grilles at the back
of the machine.
• To keep vibration and noise to a minimum
when the dryer is in use, it should be placed
on a firm, level surface.
• Once in its permanent operating position,
check that the dryer is absolutely level with
the aid of a spirit level. If it is not, raise or low-
er the feet until it is.
• The feet must never be removed. Do not re-
strict the floor clearance by using deep pile
4
www.zanussi.com
carpets, strips of wood or similar. This might
cause heat built-up which would interfere
with the operation of the appliance.
Important!
• The hot air emitted by the tumble dryer can
reach temperatures of up to 60°C. The appli-
ance must therefore not be installed on floors
which are not resistant to high temperatures.
• When operating the tumble dryer, the room
temperature must not be lower than +5°C
and higher than +35°C, as it may affect the
performance of the appliance.
• Should the appliance be moved, it must be
transported vertically.
• The appliance must not be installed behind
the lockable door, a sliding door a door with a
hinge on the opposite side to that of the ap-
pliance in such a way that a full opening of
the dryer is restricted.
Ensure min. 5cm free space around the appli-
ance.
Removing transport safety packaging
Caution! Before use all parts of the
transport packaging must be removed.
1. Open loading door 2. Pull off adhesive
strips from inside ma-
chine on top of drum.
3. Remove foil hose and polystyrene padding
from the machine.
Electrical connection
Details on mains voltage, type of current and the
fuses required should be taken from the rating
plate. The rating plate is fitted near the loading
aperture (see “Product description” chapter).
Connect the machine to an earthed socket, in
accordance with current wiring regulations.
Warning! The manufacturer declines
any responsibility for damage or
injury through failure to comply with the
above safety precautions.
Should the appliance power supply cable
need to be replaced, this must be carried
out by an authorised service engineer or a
qualified electrician. .
The appliance is supplied with a 13 amp plug
fitted. In the event of having to change the fuse
in the plug supplied, a 13 amp ASTA approved
BS 1363/A fuse must be used.
1
2
3
4
The wires in the mains lead are coloured in ac-
cordance with the following code:
1
Blue - Neutral
2
cord clamp
3
Brown - Live
4
Green and Yellow - Earth
The wire coloured green and yellow must be
connected to the terminal marked with the letter
«E» or by the earth symbol
or coloured green
and yellow.
5
www.zanussi.com
The wire coloured blue must be connected to
the terminal «N» or coloured black.
The wire coloured brown must be connected to
the terminal marked «L» or coloured red.
Upon completion there must be no cut, or stray
strands of wire present and the cord clamp
must be secure over the outer sheath.
Warning! A cut off plug inserted into a
13 amp socket is a serious safety
(shock) hazard.
Ensure that the cut off plug is disposed of
safely.
Warning! The plug must be accessible
after installing the machine.
Permanent connection
In the case of permanent connection it is neces-
sary that you install a double pole switch be-
tween the appliance and the electricity supply
(mains), with a minimum gap of 3 mm between
the switch contacts and of a type suitable for
the required load in compliance with the current
electrical regulations.
The switch must not break the yellow and green
earth cable at any point.
Door reversal
To make it easier to load or unload the laundry,
the door can be reversed.
Warning! The door must only be reversed
by an authorised service engineer.
Please contact your local Service Force Centre.
The engineer will carry out the door reversal at
your cost.
Special accessories
• stack kit
Available from your Service Force Centre
or your specialist dealer
These intermediate installation kits can be
used to arrange the dryer and an washing
machine (60 cm wide, front loaded) as a
space-saving washer/dryer stack. The wash-
ing machine is at the bottom and the dryer is
at the top.
Read carefully the instructions supplied with the
kit.
• drain kit
Available from your Service Force Centre
or your specialist dealer
Installation kit for direct draining of conden-
sate into a basin, siphon, gully, etc. The con-
densate tank then no longer has to be
drained, it must however remain in its inten-
ded position in the machine.
Read carefully the instructions supplied with the
kit.
• pedestal with the drawer
Available from your Service Force Centre
or your specialist dealer
To situate the dryer in optimal high and have
some additional space to store (e.g. laundry).
Read carefully the instructions supplied with the
kit.
6
www.zanussi.com
Product description
1
3
5
7
9
10
2
6
8
4
1
Worktop
2
Rating Plate
3
Heat exchanger
4
Water reservoir
5
Heat exchanger door
6
Control panel
7
Fluff filters
8
Loading door
9
Ventilation grille
10
Adjustable feet
Control panel
1 2
3
4 5
1
Programme knob and
OFF switch
2
Delicate button
3
Cotton / Synthetic selection button
4
Function status led: Drying , Anti-crease/
End , Condenser , Filter , Tank lights
5
Start/Pause button
Before first use
In order to remove any residues which may have
been produced during production, wipe the dry-
er drum with a damp cloth or carry out a brief
drying cycle (ca. 30 min.) with damp cloths in
the machine.
Programme chart
Programmes
Time in
minutes
(about)
max. load (weight when dry)
Application/properties
Care mark
COTTON EXTRA
DRY
140 7 kg
Thorough drying of thick or multi- layered fabrics, e.g.
terry towelling items, bathrobes.
7
www.zanussi.com
Programmes
Time in
minutes
(about)
max. load (weight when dry)
Application/properties
Care mark
COTTON STRONG
DRY
130 7 kg
Thorough drying of thick or multi- layered fabrics, e.g.
terry towelling items, bathrobes.
COTTON STOR-
AGE DRY
1)
125 7 kg
Thorough drying of fabrics of even thicknesses, e.g.
terry towelling items, knitwear, towels.
COTTON DAMP
1)
110 7 kg
For thin textiles which are still to be ironed, e.g. knit-
ted items, cotton shirts.
COTTON IRON
DRY
1)
85 7 kg
For thin fabrics which are also to be ironed, e.g. knit-
wear, cotton shirts.
SYNTHETICS EX-
TRA DRY
50 3 kg
Thorough drying of thick or multi-layered fabrics, e.g.
pullovers, bedding, table linen.
SYNTHETICS
STORAGE DRY
1)
40 3 kg
For thin fabrics which are not ironed, e.g. easy care
shirts, table linen, baby clothes, socks, lingerie with
bones or wires.
SYNTHETICS IRON
DRY
30 3 kg
For thin fabrics which are also to be ironed, e.g. knit-
wear, cotton shirts.
JEANS 125 7 kg
For leisure clothing, such as jeans, sweat-shirts, etc.,
of different material thicknesses (e.g. at the neck,
cuffs and seams).
1) In accordance with IEC61121
Programme chart in accordance with IEC61121 The appliance should be tested based on time
controlled programmes.
Sorting and preparing laundry
Sorting laundry
• Sort by fabric type:
– Cotton/linen for programmes in COTTONS
programme group.
– Mixtures and synthetics for programmes in
SYNTHETICS programme group.
• Sort by care label: The care labels mean:
Drying in the tumble dryer possible in
principle
Drying at normal temperature
8
www.zanussi.com
Drying at reduced temperature
Drying in the tumble dryer not possible
Important! Do not place in the appliance any
wet laundry which is not specified on the care
label as being suitable for tumble-drying.
This appliance can be used for all wet laundry
items which are labelled as suitable for tumble-
drying.
• Do not dry new, coloured textiles together
with light-coloured laundry items. Textile col-
ours may bleed.
• Do not dry cotton jersey and knitwear with
the EXTRA DRY programme. Items may
shrink!
Preparing laundry
• To avoid laundry becoming tangled: close
zips, button up duvet covers and tie loose ties
or ribbons (e.g. of aprons).
• Empty pockets. Remove metal items (paper
clips, safety pins, etc).
• Turn items with double-layered fabrics inside
out (e.g. with cotton-lined anoraks, the cotton
layer should be outermost). These fabrics will
then dry better.
Important! Do not overload the appliance.
Observe max. loading volume.
Laundry weights
Type of laundry Weight
Bathrobe 1200 g
Napkin 100 g
Quilt cover 700 g
Sheet 500 g
Pillow case 200 g
Tablecloth 250 g
Towelling towel 200 g
Tea cloth 100 g
Night dress 200 g
Ladies' briefs 100 g
Man's work shirt 600 g
Man's work shirt 200 g
Man's pyjamas 500 g
Blouse 100 g
Men's underpants 100 g
Daily use
Switching machine on
Turn the programme selector to any programme.
The machine switches on.
Operating
Drying options
DELICATE
gentle drying with reduced heat of sensitive fabrics
and temperature-sensitive textiles (e.g. acrylic, vis-
cose) marked on care label with:
COTTONS SYNTHETICS
type of laundry - selection for time controlled pro-
grammes
Starting the programme
Press the Start/Pause button.
Changing programme
To change a programme which has been selec-
ted by mistake once the programme has started,
first turn the programme selector to
off and
then set the programme again.
9
www.zanussi.com
Drying cycle complete / removing laundry
Once the drying cycle is complete, the LED An-
ti-crease/End is on as well as warning LED's:
Filter and Tank. If the Buzzer button has been
pressed, an acoustic signal sounds intermittent-
ly for about one minute. Remove the laundry:
1. Open door.
2. Remove visible fluff from the fluff filters. It is
best to use a damp hand for this purpose.
(see chapter: Maintenance and cleaning)
3. Remove laundry.
4.
Turn the programme selector to
off.
Important! after each drying cycle:
- clean the fluff filters
- drain the water reservoir
(see chapter: Maintenance and cleaning)
5. Close the door.
The drying cycles are automatically fol-
lowed by an anti-crease phase which lasts
around 30 minutes. The drum rotates at inter-
vals during this phase to protect the laundry
from creases. The laundry can be removed at
any time during the anti-crease phase.
Cleaning and maintenance
Cleaning fluff filters
The filters collect all the fluff which accumulates
during drying. To ensure that the dryer works
perfectly, the fluff filters (fine filters and fluff fil-
ters) must be cleaned after each drying cycle.
Caution! Never operate the dryer without
fluff filters or with damaged or blocked fluff
filters.
65
2 3
1
4
7
II
I
II
I
Clean the door seal
Wipe the door seal with a damp cloth immedi-
ately after the drying cycle has finished.
Emptying the water reservoir
Empty the water reservoir after every drying cy-
cle.
Caution! The condensed water is not
suitable for drinking or for preparing
foodstuffs.
If the programme has been interrupted as a
result of the water reservoir being full:
Press the Start/Pause button to continue the
drying cycle.
10
www.zanussi.com
Cleaning condenser
Important!
• Never operate the dryer without condenser.
• Clogged condenser cause higher energy
consumption (drying cycle elongation) and
dryer damage.
• Do not use sharp objects to clean.
6
7
Cleaning the drum
Caution! Do not use abrasives or steel
wool to clean the drum.
Lime in the water or cleaning agents may
form a barely visible lining on the inside of
the drum. The degree to which the laundry has
been dried is then no longer detected reliably.
The laundry is damper than expected when re-
moved from the appliance.
Use a standard domestic cleaner (e.g. vinegar-
based cleaner) to wipe down the inside of the
drum and drum ribs.
Clean control panel and housing
Caution! Do not use furniture cleaners or
aggressive cleaning agents to clean the
machine.
Use a damp cloth to wipe down the control
panel and housing.
What to do if ...
Troubleshooting by yourself
Problem
1)
Possible cause Remedy
Dryer does not
work.
Dryer not connected to mains supply.
Plug in at mains socket. Check fuse in fuse
box (domestic installation).
Loading door opened. Close loading door
The START PAUSE button not pressed. Press the START PAUSE button.
Unsatisfactory
drying results.
Incorrect programme set.
Set suitable programme.
2)
Fluff filters clogged.
Clean fluff filters.
3)
Heat exchanger clogged.
Clean heat exchanger.
3)
Max. loading exceeded. Respect max. loading volume.
Covered ventilation grill. Uncover ventilation grill in base area.
Residue inside the drum. Clean the drum inside.
To little free space around the appliance
Ensure min. 5cm free space around the ap-
pliance
Loading door
does not close
Filters not locked in place.
Install fine filter and/or snap course filter into
place.
Programme in-
active
Full water reservoir.
Empty water reservoir
3)
, press START
PAUSE button.
11
www.zanussi.com
Drying cycle to
short
Small laundry volume./Too dry laundry for
selected programme.
Select time programme or higher drying level
(e.g. EXTRA DRY ).
Drying cycle to
long
4)
Fluff filters clogged. Clean fluff filters.
To high loading volume. Respect max. loading volume.
Laundry insufficiently spun. Spun adequately the laundry.
Particularly high room temperature - no ma-
chine fault.
Lower the room temperature if possible.
1) Switch the dryer off. Set programme/time. Press the START PAUSE button.
2) follow program recommendation - see Programme overview chapter
3) see Care and cleaningchapter
4) Note: After around 5 hours the drying cycle ends automatically (see Drying cycle complete section).
Technical data
Dimensions (mm) Width / Height / Depth 85 x 60 x 58 cm
Max. depth
(with the appliance door open)
1090 mm
Max. width
(with the appliance door open)
950 mm
Electrical connection Voltage 230-240 V
Frequency 50 Hz
Fuse 13 A
Total power 2350 W
Drum volume 108 l
Weight of the appliance 36 kg
Laundry: max. weight 7 kg
Type of use Household
Ambient temperature Min. 5 °C
Max. 35 °C
Energy consumption
1)
kWh/cycle 4,70 kWh
Annual energy consumption
2)
552 kWh
Energy efficiency class C
Power consumption Left-on mode 0 W
Off-mode 0 W
1) With reference to EN 61121. 7 kg of cotton and a spin speed at 1000 rpm.
2) Energy consumption per year in kWh, based on 160 drying cycles of the standard cotton programme at full
and partial load, and the consumption of the low-power modes. Actual energy consumption per cycle will
depend on how the appliance is used (REGULATION (EU) No 392/2012).
Machine settings
BUZZER permanent off
12
www.zanussi.com
1. Turn the programme selector to any pro-
gramme.
2. Press simultaneously the Delicate and
Cotton / Synthetic buttons and hold
down for approx. 5 seconds.
3. The buzzer is by default always off.
13
www.zanussi.com
14
www.zanussi.com
15
www.zanussi.com
www.zanussi.com/shop
136910962-A-142013
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
