2. Home
  3. Do-It-Yourself tools
  4. Garden tools
  5. Log splitters
  6. Swisher
  7. Logger LS67526S

Swisher Logger LS67526S, LS67526S User manual

  • Hello! I am an AI chatbot trained to assist you with the Swisher Logger LS67526S User manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
ReadandfollowallSafety
PrecautionsandInstructions
beforeoperatingthis
equipment.
LOGSPLITTER
OWNER’S
MANUAL
1602CORPORATEDRIVE,WARRENSBURG,MISSOURI64093PHONE660-747-8183
FAX660-747-8650
MODELNO.
LS67526S
Manufacturingqualitylawncareequipmentsince1945
Safety
Assembly
Operation
ServiceandAdjustment
RepairParts
MadeInThe
USA
Rev.07.23.2003
IMPORTANT
ONLS03S
BySwisher
LIMITEDWARRANTY
Themanufacturer’swarrantytotheoriginalconsumerpurchaseris:Thisproductisfreefromdefectsin
materialsandworkmanshipforaperiodoftwo(2)yearsfromthedateofpurchasebytheoriginal
consumerpurchaser.Wewillrepairorreplace,atourdiscretion,partsfoundtobedefectivedueto
materialsorworkmanship.Thiswarrantyissubjecttothefollowinglimitationsandexclusions:
1)EngineWarranty Allenginesutilizedonourproductshaveaseparatewarrantyextendedto
thembytheindividualenginemanufacturer.Anyengineservicedifficultyis
theresponsibilityoftheenginemanufacturerandinnowayisSwisher
MowerCo.,Inc.oritsagentsresponsiblefortheenginewarranty.The
Briggs&StrattonEngineServiceHot-Lineis1-800-233-3723.The
TecumsehEngineServiceHot-Lineis1-800-558-5402.
2)CommercialUse Thewarrantyperiodforanyproductusedforcommercialorrentalislimited
toninety(90)daysfromthedateoforiginalpurchase.
3)Limitations Thiswarrantyappliesonlytoproductswhichhavebeenproperlyassembled,
adjusted,andoperatedinaccordancewiththeinstructionscontainedwithin
thismanual.ThiswarrantydoesnotapplytoanyproductofSwisherMower
Co.,Inc.,thathasbeensubjecttoalteration,misuse,abuse,improper
assemblyorinstallation,shippingdamage,ortonormalwearoftheproduct.
4)Exclusions Excludedfromthiswarrantyarenormalwear,normaladjustments,and
normalmaintenance.Thepump,valveandcylindereachcarryseparate
manufacture’swarranties.Thevalveandcylinderbothcarryaone(1)year
limitedwarranty.Thepumpcarriesatwo(2)yearlimitedwarranty.
Intheeventyouhavea claimunderthiswarranty,youmustreturntheproducttoanauthorizedservi
ce
dealer.Alltransportation charges,damage,orlossincurredduringtransportationofpartssubmittedfor
replacementorrepairunderthiswarrantyshallbebornebythepurchaser.Shouldyouhaveanyquestions
concerningthiswarranty,pleasecontactustoll-freeat1-800-222-
8183.Themodelnumber,serialnumber,
dateofpurchase,andthenameoftheauthorizedSwisherdealerfromwhomyoupurchasedthemowerwill
beneededbeforeanywarrantyclaimcanbeprocessed.
THISWARRANTYDOESNOTAPPLYTO
ANYINCIDENTALORCONSEQUENTIALDAMAGES
AND ANY IMPLIED WARRANTIES ARE LIMITED TO THE SAME TIME PERIODS STATED
HEREIN FOR ALL EXPRESSED WARRANTIES. Some states do not allow the limitation of
consequentialdamagesorlimitationsonhowlonganimpliedwar
rantymaylast,sotheabovelimitations
orexclusionsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrightsandyoumayhaveother
rights,whichvaryfromstate-to-state.ThisisalimitedwarrantyasdefinedbytheMagnuson-
MossActof
1975.
Pleasefillouttheserialnumbersandmodelnumbersforboththeengineandthelogsplitterontheback
pageofthismanual.
2
3
SAFETYPRECAUTIONS
WARNING:Theengineexhaustfromthisproductcontainschemicalsknowntothestateof
Californiatocausecancer,birthdefectsorotherreproductiveharm.
DANGER:Yourlogsplitterwasbuilttobeoperatedaccordingtotherulesforsafeoperationin
thismanual.Aswithanytypeofpowerequipment,carelessnessorerroronthepartofthe
operatorcanresultinseriousinjury.Ifyouviolateanyoftheserules,youmaycauseserious
injurytoyourselforothers.
• Readthemanual.Learntooperatethisequipmentinasafemanner.
• Donotunderanycircumstancesalterthislogsplitter.Thisequipmentwasdesignedand
engineeredinaccordancewithoperatinginstructions.Alteringthisequipment,orusing
thisequipmentinsuchawayastocircumventitsdesigncapabilitiesandcapacities,could
resultinseriousinjuryorfatalityandWILLVOIDTHEWARRANTY.
• Allowonlyresponsibleadultswhohavereadthismanualtooperatethismachine.Never
allowchildrentooperatethismachine.
• Neverusesplitterforanyotherpurposethansplittingwood.Anyotherusecanresultin
injury.Yoursplitterisaprecisionpieceofpowerequipment,notatoy.Therefore,
exerciseextremecautionatalltimes.
• Onlyasingleoperatoristoloadandoperatethelogsplitter.Keepallothers,including
petsandchildren,aminimumof20feetawayfromyourworkarea.Moreaccidents
occurwhenmorethanonepersonoperatesthelogsplitterthananyothertime.
• Alwaysdisconnectthesparkplugwireandplacethewirewhereitcannotcontactthe
sparkplug,topreventaccidentalstartingtheenginewhensettingup,transporting,
adjustingorrepairing.
• Alwayswearprotectivegearsuchassafetygoggles,protectivehearingdevice,steel-toed
shoes,andtight-fittinggloveswithoutdrawstringsorloosecuffs.
• Neverwearlooseclothingorjewelrythatcanbecaughtbymovingpartsofthesplitter
andpullyouintoit.Keephairawayfrommovingparts.
• Familiarizeyourselfwithallofthecontrolsinasafeenvironmentbeforestartingtowork
withthismachine.
ThisSafetyAlertSymbolindicatesimportantmessagesinthismanual.
Whenyouseethissymbol,carefullyreadthemessagethatfollowsandbe
alerttothepossibilityofpersonalinjury.
Readthismanualcompletely.Thismachinecanamputatehands,feet,andthrowobjects.
Failuretoobservethefollowingsafetyinstructionscouldresultinseriousinjuryordeath.
4
Fluidescapingfromaverysmallholecanbealmostinvisible.Donotcheckforleakswithyour
hand.Escapingfluidunderpressurecanhavesufficientforcetopenetrateskin,causingserious
personalinjury.Leakscanbelocatedbypassingapieceof
cardboardorwoodoverthesuspected
leakandlookingfordiscoloration.IFinjuredbyescapingfluid,seeadoctoratonce.Serious
infectionorreactioncandevelopifpropermedicaltreatmentisnotadministered
immediately.
• Splitonlyonelogatatime.Neverattempttosplittwologsontopofeachother.
• Donotstraddleorreachacrossthesplittingareawhileoperatingthesplitter.
• Donotstepoversplitterwhentheengineisrunning.Youmaytriporaccidentally
activatethesplittingwedge.Walkaroundtogettotheotherside.
•
forwardorreversestroke.
• Neverattempttoloadsplitterwhilesplittingwedgeisinmotion.Whenloadinglog
splitter,placehandsonthesidesofthelog,nottheends.
• Onlyuseyourhandstooperatethecontrollever.Neverusefoot,knee,ropeorany
extensiondevice.
• Alwayskeepfingersclearofsplitsthatopeninlogduringsplitteroperation.
• Whensplitterisinthereturnmode,keephandsoffthemachine.
•
Onlyoperatesplitteronlevelground,notonthesideofahill.Itcouldtiporrollinglogs,
poorfooting,etc.couldcauseanaccident.
• Neveroperateorallowsomeonetooperatethisequipmentwhileundertheinfluenceof
alcoholordrugs.
• Alwaysblockthewheelstopreventmovementwhileusingsplitter.
• Neveroperateyoursplitteronwet,muddy,oricysurfaces.Safefootingisessentialin
preventingaccidents.
• Neveroperateyoursplitterwhileitisattachedtothetowvehicle.
• Nevermakeadjustmentsorrepairswiththeenginerunning.
• Neverattempttosplitwoodsacrossthegrain.Sometypesofwoodmayburstorflyout
ofyoursplitterandresultininjury.
• Bothendsofthelogshouldbecutassquarelyaspossibletopreventthelogfromsliding
outofthesplitterduringoperation.Loglengthshouldbekeptto24”orless.
5
TOWINGSAFETY
•
Donotallowpersonstorideonsplitter.Donotcarryanycargoorwoodonyour
splitter.Itmayfalloffandendangervehiclesthatarefollowingyou.
•
Besurejackstandisinthetravelpositionandcouplingsecure.Thismustalsobe
retractedsonottointerferewhiletowing.Retractkickstandbyremovingpin,
rotatingup,andreplacingpin.
•
Neverexceed45MPHwhiletowingyoursplitter.Beextracautiouswhen
travelingoverroughterrain,especiallyoverrailroadtracks.
•
Alwaysbecarefulwhilebackingyoursplitter.Youcouldjackknifeyourlog
splitterifnotcareful.
•
Beforeusingsplitter,disconnectitfromtowvehicle.Alogcouldeasilybe
pushedforwardintothevehicle.
•
SeetireandwheelspecificationsforPSIwhiletowing.
•
Beawareoftheextralengthofsplitterwhileturning,parking,crossing
intersections,andinalldrivingsituations.
•
OPERATIONINSTRUCTIONS
POSI-LOCKCOUPLER
ADJUSTCOUPLERLOCKINGPRESSUREONBALLBEFOREUSE.PLACEHANDLEINLOCKEDPOSITIONWITHBALLINCOUPLER.
TIGHTENLOCKNUTAGAINSTTENSIONSPRINGSOTHATCOUPLERISNOTLOOSEONBALL.CORRECTADJUSTMENTWILLALLOW
HANDLETOBERELEASEDWITHMODERATEPRESSUREAPPLIEDTOHANDLE.
TOOPEN,PULLUPONCOUPLERHANDLEANDROTATEFORWARD.PLACECOUPLERONBALLWHENBALLISCOMPLETELY
NESTEDINBALLSOCKET,ROTATECOUPLERHANDLEBACKWARDUNTILHANDLEISINLOCKEDPOSITION.
AFTERTOWINGFOR50MILES,CHECKCOUPLERFORTIGHTNESSONBALL.ALWAYSCHECKTIGHTNESSBEFORETOWING.BE
SURECOUPLERHANDLEISINLOCKEDPOSITION.
WARNING:
NEVEREXCEEDWEIGHTCAPACITYANDALWAYSUS
ESAFETYCHAINS.ALWAYSUSECORRECTBALLSIZE,MAKINGSUREBALL
ISCOMPLETELYINSERTEDINTOCOUPLER.LOCKCOUPLERHANDLESECURELYBEFORETOWING.ALWAYSCHECKFOR
DAMAGESANDREPLACEIFDAMAGED.AVOIDSHARPTURNSANDSTEEPVERTICALANGLESWHENTOWING.
OD16– FUELSHUT
OFFDECAL
OD07– COLDWEATHER
DECAL
OD12– HYDRAULICFILL
PLUGDECAL
OD08– OPERATORINSTRUCTIONDECAL OD09– DANGER/POSITIONLOCKDECAL
SAFETYDECALS
Replacedecalsimmediatelyifdamaged.
6
OPERATION
Intendeduse:Thislogsplitterisintendedanddesignedtoonlysplitwood.NEVERuseforanyother
purposes.DoingsocancauseinjuryorVOIDTHEWARRANTY.
ASSEMBLYINSTRUCTIONS
Thislogsplitterhasbeenpartiallyassembledatthefactory.Refertothedrawingsandpartlistsshouldit
becomenecessarytodisassembletheunitforrepairorreplacementofparts.Inspectallcomponentsfor
damage.
WARNING:Exerciseextremecaution,aspartsareveryheavy.Sufficientpersonsormechanical
handlingequipmentshouldbeused.
IMPORTANT:Thisunitisshippedwithoutgasolineoroilintheengine.Afterassembly,seeseparate
EngineManualforproperfuelandoilrecommendations.
1. GeneralAssembly:Removetop,sidesandendsofcrate.Placecratepanelsasidetoavoid
puncturingtires.Removetongueassemblyfromtop.
2. Carefullysetthebeampre-assemblyaside.
3. Attachtonguetotank/mountplatesusingtwoboltsandnuts.Becertainhardwareissecure.
(See
AssemblyFigure1)
4. FenderAssembly:Removefendersfrombox.Mounttofenderbracketswith5/16hardware
provided.Makesurefenderclearswheel.
5. Removetank/engineassemblyfrombaseofcrateanddiscardbanding.Thecylinderistiedtothe
base.Removetiesandslidecylinder/wedgeforwardaligningclevisatcylinderendtobeam.
Insertpinandretainingclips,checkcomponenttoassureproperassembly.Standbeampre-
assemblyverticalandsecureinposition.Rolltank/engineassemblyintoplace,aligningpivot
holes.Boltwithprovidedhardware.Note:Donotovertighten;thisisthevertical/horizontal
pivotpoint.
6. Pivotbeamassemblyintothehorizontalpositionandlockwithpinprovided.
7. HoseAssembly:LocatethePressureHose,notedbythepipefittings,andattachittothelower
fittingonthevalve.Theremaininghoseattachestothetopfittingofthevalve.Securewith
providedhoseclamp.
8.
Checkboththehorizontalandverticalpositionsforany“kinks”inthehoses.Note:Alwaysmake
surebeamislockedsecurelyintoplace.
SeeOPERATINGPOSITIONSforHorizontaltoVerticalSplitting
STARTUP
WARNING:DONOTSTARTORRUNTHELOGSPLITTERWITHOUTOILINTHE
ENGINEANDHYDRAULICRESERVOIR.
SeeseparateEngineManualforfuelandoilrecommendations.Yourlogsplitterhascomeequippedwith
afuelshut-offvalvefortowingpurposes.
Beforestartingenginemakesurecrankcaseisfilledcorrectlywithoilandtheproperfuelhasbeenused.
Theenginewillonlystartwhenthethrottleleverandfuelshut-offvalveareturnedtotheirONpositions.
COLDWEATHERSTARTUP
TheColdWeatherClutchenablestheenginetobestartedwithouthavingtopullthroughcold,thickened
hydraulicfluid.Simplypullthehandleoutandslideintolockedposition.Startengine,letitwarmup,
andreleaseColdWeatherClutch.Afterstarting,assurethattheleverhasreengaged.
AssemblyFigure1
Tank/MountPlates
7
FILLINGTHEHYDRAULICRESERVOIR
FillthehydraulicreservoirwithatleastfivegallonsofDextronIIIAutomaticTransmissionfluidor10W
AWhydraulicfluid.Afterthehydraulicreservoirandtheenginecrankcasearefilledcorrectlywiththeir
respectiveoils,starttheengine.Remembertosetthethrottleandturnonthefuelshut-offvalve.The
hydraulicpumpshouldprimeitself.Withtheenginerunning,movethehydraulicvalvelevertowardthe
wedge.Thiswillcausethecylindertoextendandexpelair.Whenthecylinderisfullyextended,retract
it.Repeatthisprocedureseveraltimes.Anerraticmovementofthecylinderindicatesthatthereisstill
airinthesystem.Moreoilshouldthenbeaddedtobringthefluidleveluptoapproximately
1”belowthe
fillhole.Afteraddingmoreoiltofillthetank,cyclethecylinderagainuntilithasaconstantspeed
indicatingthatallairhasbeenexpelled.Checktheoillevelinthereservoiragain.Standardmodels
requireapprox.6.5gallonsofhydraulicfluid.
NOTE:Ifthetankisoverfilled,itwilltendtoexpeloilfromthebreathercapwhenthecylinderis
retracted.
TOWING
Thisunitshouldnotbetowedonanystreet,highway,orpublicroadwithoutcheckingtheexisting
federal,local,andstatelaws.Anylicensingormodificationssuchastaillights,etc.,needtocomplywith
existingfederal,local,orstatevehiclerequirementsisthesoleresponsibilityofthepurchaser.Obeyall
regulationswhentowingonpublicroadsandhighways.SeealsoTOWINGSAFETY.
Besureyouareusingthecorrectballhitchsizeforthehitchcoupleronthelogsplitter(2”ball).Besure
safetychainsareproperlyconnected.Leaveenoughslackinchainsforturning.SeeTOWING
SAFETYtoreadwarningsaboutcoupling.
Makesurebeamattachmentislockedinthehorizontalposition.NEVERtowsplitterinthevertical
position.
Turnthefuelshut-offvalveOFFtopreventfloodingoftheenginewhiletraveling.
TOWINGATNIGHT
TherequirementsfortaillightsarebasedonStatesregulations.Somestatesallowtowingatnightaslong
asthetowedequipmentdoesnotvisiblyimpairthetowvehicletaillights.Thisisbasedon
astate,tostate
requirements.Thecustomerisresponsibleformeetingthestatesrequirements.ATaillightKit
Accessory(PartNo.7420)isavailableandrecommendedfornightdriving.
Ifa“StatementofOrigin”isrequiredinyourstate,seeyourlocaldealertoreceiveone.
OPERATION
1. Setupthelogsplitterinaclear,levelareaandblockthewheels.Thesuctionportonthetank
shouldalwaysbeonthelowersideofthelogsplitter.
2. Placealogonthebeam,againstthefootplate.Makesurethelogissecurelyonthefootplate
andupagainstthebeam.
3. Depressthevalvelevers
othatthecylinderwilldrivethewedgeintothelog.Extendthecylinder
untilthelogsplitsortotheendofitsstroke.Iftheloghasnotcompletelysplitafterthecylinder
hasreachedtheendofitsextension,retractthecylinder.NOTE:
Leavingthevalveinthe“actuate”positionattheendofthestrokemaydamagethepump.
OPERATINGPOSITIONS
WARNING:THELOGSPLITTERBEAMISHEAVYANDCANPINCHHANDS/FINGERSIF
CAREISNOTTAKEN.
8
STANDARDHORIZONTALTOVERTICAL
TheStandardSplitterhas2operatingpositions:Horizontal,Vertical.
Removepinfrombelowbeam.Donotremoveboltandnut.Rotatebeamintoverticalpositionandpin
sobeamcannotfallintohorizontalposition.
DONOTTOWINVERTICALPOSITION!
IMPORTANT:
Whenoperatingsplitterinwoodedareas,obtainasparkarrestorfortheexhaustsystem.
Seeyourlocalenginedealer.
Whenpreparinglogs,cutendsassquareaspossible.Themaximumlengthofanylogsshouldbeonly
24”.
MAINTENANCE&STORAGE
WARNING:
Disconnectsparkplugbeforeperforminganymaintenanceormakingadjustments.
RESERVOIRFLUID
Checkthehydraulicfluidlevelinthereservoirtankbeforeeachuse.Operatingwithoutan
adequateoilsupplywillcauseseveredamagetothepump.Changethehydraulicfluidinthe
reservoirpermanufacturersrecommendations.
Beawareoftheenvironmentwhendisposingofusedpetroleumproducts.Pleasedisposeof
usedhydraulicfluid,engineoilandanybyproductsfromthemaintenanceofyourlog
splitteratapprovedrecyclingcenters.
Shoulditbecomenecessarytoloosenorremoveanyhydraulicfittingorline,besuretoremove
allpressurebyshuttingofftheengineandmovingthecontrolhandlebackandforthseveral
times.
NEVERremovethecapfromthehydraulictankorreservoirwhileyourunitisrunning.
Hotoilunderpressurewillcauseinjury.
Alwaysstoregasolineinanapproved,tightlysealedcontainer.Storecontainerinadry,cool
place.Keepfuelawayfromgasapplianceswherefumescouldcontactopenflame,pilotlightsor
sparks.
Donotoperateyoursplitterinpoormechanicalconditionorwhenneedingrepair.Repairand
replacewornorbrokenpartsimmediately.
Periodicallytightennuts,bolts,andhydraulicfittings.
Thehydraulicsystemofyourlogsplitterrequirescarefulinspection,alongwiththemechanical
parts.Besuretoreplacefrayed,kinked,orotherwisedamagedhydrauliccomponents.
Thepressurereliefvalveonthesplitterispresetatthefactory.Donotadjustvalve.Onlya
qualifiedservicetechnicianshouldperformthisadjustment.
Ifthewedgebecomesdullornicked,itcanberemovedandsharpened.Thewedgeisheavyand
maystillhavesharpedges,weargloveswhilehandlingthewedge.
REPAIRPARTS
YourSwisherLogSplitterhasbeenproducedwithcomponentsdesignedspecificallytothis
machine.Althoughstandardsprings,hardware,etc.maylooksimilartopartsusedonother
machinery,theymayinsomecasesbemadeofadifferentconstructionand/ormaterials.
9
BEAMDETAIL
ENGINEDETAIL
ITEM# DESCRIPTION PART#
33 6.75HPBRIGGSANDSTRATTONENGINE N/A
34 5/16-18X21/2GR5BOLT NB138
35 5/16-182-WAYLOCKNUT NB558
36 5/16-18X11/4GR5BOLT NB504
37 KEYSTOCK 9030
38 SETSCREWW/NYLOCK NB312
39 ENGINEPULLEY-LS622MODELONLY 7323
40 BELLEVILLEWASHER 699
41 3/8-24X1BOLTW/NYLOCK NB238N
ITEM# DESCRIPTION PART#
1 CLIPPIN NB642
2 STEELPIN 7293
3 HYDRAULICFITTING 7291
4 STATIONARYLINEASSEMBLY 7288
5 RAMCYLINDER 7354
6 1/2-13X3GR5BOLT NB131
7 SPLITTINGWEDGE 7233
8 1/2-13X21/2GR5CARRIAGEBOLT NB643
9 RETURNLINEFITTING 7329
10 1/2-13JAM2-WAYLOCKNUT NB121
11 2-WAYPIPENIPPLE 7292
12 MASTERCHAINLINK 7424
13 COTTERPIN NB597
14 VALVEINLETFITTING 7387
15 VALVECONTROLW/LEVER 7287
16 BEAMWELDMENT 7624
17 1/4X1CLEVISPIN NB522
18 1/2-13NUT NB213Z
19 VALVELEVER&GRIP 7423/7425
20 THINGIBPLATE 7388
21 THICKGIBPLATE 7237
22 BOTTOMGIBPLATE 7333
23 LOCKWASHER NB508
24 WASHER NB555
25 STRIPPERBRACKET 7448
26 STRIPPERSPACER(1Required) 7449
27 STRIPPERWELDMENT 7444
28 SPLITTERTABLE 7621
29 5/16-18ZP2WAYLOCKNUT NB558
30 5/16-18X3/4HCCGR2ZPBOLT NB143
31 3/8-16X51/2GR5ZP NB575
32 3/8-16NYLOCNUT NB182
29
16
30
18
23
24
22
21
20
8
7
19
25
3
17
13 14
15
12
9
11
10
6
27
32 1
26
2
5
3
4
31
28
33
36
35
38
40
41
39
35
34
37
10
ASSEMBLYDETAIL
PartsListPage11
SEEDETAIL
1
2
3
B
4
5
6
7
8
9
10
A
A
11
16
15
14
13
12
17
17
8
19
24
20
22
23
2526
21
21
21
27
28
6
24
38
30
32
3331
34
34
35
29
41
40
39
37
36
42
43
44
45
46
47
48
49
41
16
50
54
18
51
53
52
51
57
56
55
48
6
5
OverheadValveEngine
SeeDetail(Page9)
56
B
11
SERVICEPARTS
PleasehaveModelandSerialNumbersreadywhenorderingparts.
Colorcannotbeguaranteedonserviceparts.
ITEM# DESCRIPTION PART# ITEM# DESCRIPTION PART#
1 RETURNHOSE54" 7290 29 TIRE/WHEEL 7296
2 PRESSUREHOSE48" 7289 30 COTTERPIN 2203CP
3 #12HOSECLAMP LS5001 31 WHEELDUSTCOVER 2203DC
4 HYDRAULICRESERVOIR 7319 32 CASTLENUT 2203CN
5 1/2-13X31/2GR5BOLT NB577 33 WASHER 2203W
6 1/2-13NYLOCKNUT NB281 34 TAPEREDBEARING 2203B
7 RESERVOIRVENTPLUG 7379 35 BEARINGSEAL 2203S
8 3/8-16X1GR5BOLT NB604 36 BELT 644
9 1/2X31/2HITCHPINW/HAIRPIN NB648 37 IDLERARM 6681TK
10 SUCTIONHOSE18" 7346 38 CLUTCHLEVER 7358
11 #16HOSECLAMP LS4999 39 SPRING 682S
12 RETURNLINEFITTING 7329 40 3/8-16JAMNUT NB174
13 FILTERHEAD LS1112 41 HARDENEDWASHER NB196
14 FILTERELEMENT LS1113 42 3/8-16X21/2GR5BOLT NB221
15 1/2-13X11/4GR5BOLT NB646 43 5/16-18FLANGENUT NB170
16 3/8-162-WAYLOCKNUT NB280 44 IDLERSPRINGMOUNT 2046
17 TANKBRACE 7352 45 WIRELINKFORIDLERSPRING BRS6H
18 3/8-16NYLOCKNUT NB182 46 SHOULDERBOLT NB220
19 HYDRAULICPUMP LS2001H 47 IDLERPULLEY B527
20 1/8X1/2#3WOODRUFFKEY 7440 48 WASHER NB272
21 5/16-182-WAYLOCKNUT NB558 49 BELTCOVER 7321
22 PUMPPULLEY 7306 50 1/4-20SELF-TAPPINGSCREW NB114
23 SETSCREWW/NYLOCK NB312 51 CLIPHITCHPIN H11
24 5/16-18X3/4GR2BOLT NB143 52 TOWINGTONGUE 7343
25 FENDERBRACKET-RIGHTSIDE 7417 53 TRAVELLOCK 7441
FENDERBRACKET-LEFTSIDE 7418 54 SAFETYCHAINW/HOOK 7366
26 FENDER 7428 55 2"BALLCOUPLER 7365
27 KICKSTAND 7398 56 3/8-16X3GR5BOLT NB164
28 MOTORBASE/AXLE 7297 57 3/8-16X31/2GR5BOLT NB649
OWNER’S
MANUAL
MODELNO.
LS67526S
HOWTOORDER
REPAIRPARTS:
LOGSPLITTER
EachLogSplitterhasitsownserialnumber.Eachenginehas
itsownserialnumber.TheserialnumberfortheLogSplitter
willbefoundontherighthandsideofthehydraulicoil
reservoir.Theserialnumberfortheenginewillbefoundon
thetopoftheblowerfanhousing.
AllLogSplitterpartslistedhereinmaybeordereddirectly
fromSwisherMower&MachineCo.Inc.,yournearest
Swisherdealer,orfromourwebsite.
Allenginepartsmaybeorderedfromthenearestdealerofthe
enginesuppliedwithyourmower
.
Partssubjecttochange
withoutnotice.
WHENORDERINGPARTS,PLEASEHAVETHE
FOLLOWINGINORMATIONAVAILABLE:
*PRODUCT– SWISHERLOGSPLITTER
*SERIALNUMBER- _______________
*MODELNUMBER- _______________
*ENGINEMODELNUMBER- _______________
TYPE- _______________
*PARTNUMBER
*PARTDESCRIPTION
www.swisherinc.com
TELEPHONE- 1-800-222-8183
FAX- 1-660-747-8650
SWISHERMOWER&MACHINECO.INC.
1602CORPORATEDRIVE
WARRENSBURG,MO64093
SWISHERMOWER&MACHINECO.INC.
/