Miller GOUGE REMOTE CONTROL 258046 Owner's manual

Category
Car kits
Type
Owner's manual

This manual is also suitable for

OWNER’S MANUAL
E2019 Miller Electric Mfg. LLC
FORM: OM-258422D 201910
Use above FORM number when ordering extra manuals.
For Gouge Remote Control 258046
DANGER! Indicates a hazardous situation which, if not
avoided, will result in death or serious injury. The pos-
sible hazards are shown in the adjoining symbols or
explained in the text.
DANGER ! - Indique une situation dangereuse qui, si
elle n’est pas évitée, entraînera la mort ou des blessures
graves. Les éventuels risques sont représentés par les
symboles joints ou expliqués dans le texte.
Fsafe1 2013-10
Beware of electric shock from wiring. Stop engine and
disconnect negative () cable from battery before install-
ing this kit. Reinstall all panels and covers.
Attention au risque d’électrocution due au contact avec
l’électrode de soudage ou les fils. Le fait de toucher
l’électrode tout en étant en contact avec la pièce ou la
terre peut provoquer une électrocution. Toujours porter
des gants secs. Tous les panneaux et couvercles
doivent rester fermés.
Engsafe1 2013-10
Indicates a hazardous situation which, if not avoided,
could result in death or serious injury. The possible ha-
zards are shown in the adjoining symbols or explained in
the text.
Indique une situation dangereuse qui, si elle n’est pas
évitée, entraînera la mort ou des blessures graves. Les
éventuels risques sont représentés par les symboles
joints ou expliqués dans le texte.
Fsafe2 2013-10
Welding sparks can cause fire or explosion. Move
flammables away. Do not weld on closed tanks or
barrels, or on containers that have held combustibles
they can explode. Clean tanks or barrels properly.
Les étincelles de soudure peuvent provoquer un in-
cendie ou une explosion. Éloigner les produits inflam-
mables. Ne pas couper des cuves ou des barils fermés
ou des récipients ayant contenu des combustibles au
risque qu’ils explosent. Nettoyer soigneusement les
cuves ou tonneaux.
Ugsafe8 2018-01
NOTICE
Indicates statements not related to personal injury.
Signale des consignes non associées aux dommages
corporels.
Indicates special instructions.
Fournit des instructions spéciales.
Fsafe3 2013-10
Wear safety glasses with side shields.
Porter des lunettes de sécurité avec écrans latéraux.
Fsafe8 2013-10
CALIFORNIA PROPOSITION 65 WARNINGS
WARNING: Cancer and Reproductive Harm www.P65Warnings.ca.gov
PROPOSITION CALIFORIENNE 65 AVERTISSEMENTS
AVERTISSEMENT : cancer et troubles de la reproduction www.P65Warnings.ca.gov.
Fsafe26 2018-01
1. Typical Connection
1 Gouge Remote Control
2 Polarity / Isolation Switch
Insert 14 Pin Plug from remote into
Process 2 Receptacle.
3 Mounting Panel for Swing
ARC.
1
Ref. 300884-B
3
2
OM-258422 Page 2
2. Wiring Diagram
258068-B
OM-258422 Page 3
3. Parts List
.
Hardware is common and
not available unless listed.
258046E
7
3
6
2
8
9
10
11
12
13
! Read warning label on
remote control before
servicing.
4
5
1
Figure 1. Complete Assembly
Description
Part
No.
Item
No.
Complete Assembly
Quantity
1 258039 Switch, Wall 1P15A 120-277V Style Line 1... ... .............. ............................
2 258248 Pot, CP Std Slot 1T 2. W 10K Linear W/Lead 1... ... .............. ........................
3 131749 Nut, 010-24 .37HEX .22H Stl Pld Ser Flange .50D 3... ... .............. ....................
4 221380 Box, Outlet / Control 1... ... .......... ... ..............................................
5 221383 Strain Relief, 3/4 NPT Galv Steel .520-.730 Cord 1... ... .............. .....................
6 258045 Cord Set 1... ... .............. ........................................................
7 132729 Screw, 010-24x1.00 Pan HD-PHL Stl Pld Sems Ext T 3... ... .............. .................
8 234988 Cage, Hand Control 1... ... .............. ..............................................
9 171007 Knob, Pointer 1.670 Dia X .250 Id W/Set Screwsplstc 1... ... .............. .................
10 072590 Lock, Shaft Pot .375-32 X .250 Dia Shaft Tall 1... ... .............. ........................
11 257775 Plate, Ident Remote Hand Control 1... ... .............. ..................................
12 212810 Label, On-Off W/Symbols 1... ... .............. .........................................
13 257683 Terminal Block, 5 Pole 20A 600V 12-22 AWG 1... ... .............. ........................
1 / 1

Miller GOUGE REMOTE CONTROL 258046 Owner's manual

Category
Car kits
Type
Owner's manual
This manual is also suitable for

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Ask the document