Powermate PM0401858 User manual

Brand: Powermate

Model: PM0401858

Category: Power generators

Type: User manual

Page is loading ...

*3.5 HP Briggs & Stratton engine

*Receptacles on endbell

*1.35 gallon plastic fuel tank

*Spark arrester

*Brushless generator

A .120 V, 15 Ampere Duplex Receptacles

15 amps of current may be drawn from each half of the

receptacle. However, total power drawn must be kept within

nameplate ratings.

B.Circuit Breaker

The receptacles are protected by an AC circuit breaker. If

the generator is overloaded or an external short circuit occurs,

the circuit breaker will trip. If this occurs, disconnect all

electrical loads and try to determine the cause of the problem

before attempting to use the generator again. If overloading

causes the circuit breaker to trip, reduce the load. NOTE:

Continuous tripping of the circuit breaker may cause

damage to generator or equipment. The circuit breaker may

be reset by pushing the button of the breaker.

C.Engine Switch

CAUTION: Keep fuel tank area free of all

debris, water, and ice. Do not block vent.

“Tank must breathe.”

This engine is equipped with a U.S. Forest Service

approved spark arrest muffler. It should periodically be cleaned

to prevent the screen from becoming clogged, which could

hamper engine performance.

To clean, remove the muffler shield. Remove the four

screws and pull the plate with the screen attached. Clean off

any particles with a brush and reinstall. Be sure gasket is in

place.

Check engine oil . . . . . . . . . . . . . . . . . . . . . . Before each use

Change engine oil . . . . . . . . . . . . After first 20 hours and then

every 50 hours of operation

Clean air filter. . . . . . . . . . . . . . . . Every 50 hours of operation

Clean spark plug . . . . . . . . . . . . Every 100 hours of operation

Clean spark arrestor . . . . . . . . . . Every 50 hours of operation

Oil Type. Use new good quality oil such as SC, SD, and

SE grades. The oil to be used depends upon the temperature

at which the engine is operated:

Summer: (temperatures of over 40 degrees F/10 degrees

C) SAE 30 or SAE 10W-30, SAE 10W-40

Winter: (temperatures of below 40 degrees F/10 degrees

C) SAE 20 or SAE 10W-30

English

ENDBELL

MAJOR GENERATOR FEATURES

RECEPTACLE PANEL RECOIL PANEL

FUEL TANK VENTING

SPARK ARRESTER MUFFLER

ENGINE MAINTENANCE SCHEDULE

English

Warranty Coverage: Powermate Corporation (the Company) warrants to the original retail customer in North America that it will

repair or replace, free of charge, any parts found by the Company or its authorized service representative to be defective in

material or workmanship. This warranty covers the cost of replacement parts and labor for defects in material or workmanship.

Not Covered:

· Transportation charges for sending the product to the Company or its authorized service representative for warranty service,

or for shipping repaired or replacement products back to the customer; these charges must be borne by the customer.

· Engine is covered exclusively by a separate warranty from the engine manufacturer, included with the engine Manual.

· Damages caused by abuse or accident, and the effects of corrosion, erosion and normal wear and tear.

· Warranty is voided if the customer fails to install, maintain and operate the product in accordance with the instructions and

recommendations of the Company set forth in the owner's manual, or if the product is used as rental equipment.

· The Company will not pay for repairs or adjustments to the product, or for any costs or labor, performed without the

Company's prior authorization.

Warranty Period: Two (2) years from the date of purchase on products used solely for consumer applications; if a product is

used for business or commercial applications, the warranty period will be limited to one (1) year from the date of purchase. For

warranty service, the customer must provide dated proof of purchase and must notify the Company within the warranty period.

For warranty service: Call toll free 800-445-1805, or write to Powermate Corporation, Product Services, 4970 Airport

Road, P. O. Box 6001, Kearney, NE 68848.

EXCLUSIONS AND LIMITATIONS: THE COMPANY MAKES NO OTHER WARRANTY OF ANY KIND, EXPRESS OR IMPLIED.

IMPLIED WARRANTIES, INCLUDING WARRANTIES OF MERCHANTABILITY AND OF FITNESS FOR A PARTICULAR

PURPOSE, ARE HEREBY DISCLAIMED. THE WARRANTY SERVICE DESCRIBED ABOVE IS THE EXCLUSIVE REMEDY

UNDER THIS WARRANTY; LIABILITY FOR INCIDENTAL AND CONSEQUENTIAL DAMAGES IS EXCLUDED TO THE EXTENT

PERMITTED BY LAW.

This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. Some states do

not allow a disclaimer of implied warranties, or the exclusion or limitation of incidental and consequential damages, so the above

disclaimers and exclusions may not apply to you.

LIMITED WARRANTY

Page is loading ...

Ref No Part No

ArtNº / P

Art NúmPièces Núm Description Description DescripciónQty

1Note AEngine 3.5 hp B&SMoteurMotor1

20050448.01Engine AdapterAdaptateur de moteurAdaptador motor1

30000901.01Bolt Whz 5/16-24 x 5/8Boulon, whzPerno, whz4

40062910StatorStatorEstator1

50062621RotorRotorRotor1

6Note BWasher, Lock 5/16Rondelle, plateArandela, cierre1

70035022Bolt, Rotor 5/16-24 x 5-1/8Boulon, rotorPerno, rotor1

80062911Assy, Stator BracketAssemblage, supportEnsamble, soporte estator1

de stator

90063113EndbellCouvre-enroulementPlaca lateral1

10Note BBolt, Hex HD 1/4-20 x 3Boulon, hexPerno, hex2

110062006Screw, Torx T30 1/4-20 x 3.25Vis, Torx T30Tornillo, Torx T302

120040832Nut, Nyloc 1/4-20Ecrou, nylocTuerca, nyloc7

130062011Assembly, handle bracketAssemblage, support deEnsamble, soporte mango1

manche

140062069Shield, heatÉcran de chaleurPantalla para el calor1

150063112Panel, recoilPanneauPanel1

160061952Bracket, recoilSupportSoporte1

170062015Screw, Torx T30 1/4-20 x .63 Vis, TorxTornillo, Torx12

180049892Gasket, Muf B&SJoint silJunta, silenciador1

190062002Muffler B&SSilencieuxSilenciador1

20Note BWasher, Lock 1/4Rondelle, contre-ecrouArandela, cierre2

210049161Screw SHC 1/4-20 x 5/8VisTornillo2

220049846ClipAttachePresilla2

230047774Foot, Rubber 106-WPied, caoutchoucPie, caucho2

240062007Screw, Torx T30 1/4-20 x 1.50 Vis, Torx T30Tornillo, Torx T302

250063121Panel, wiredTableau, câblePanel con cable1

260062020Screw #6-19 x .50VisTornillo4

27Note CAssy, Fuel TankAssemblage, réservoirEnsamble, tanque combustible1

280062122Cap, FuelCapuchon, réservoir d’essence Tapa, combustible1

29Note BWasher, Flat 5/1 6Rondelle, plateArandela, plana3

30Note BNut 5/16-18 EcrouTuerca3

310050144Bolt, Whz 1/4-20 x 3/8Boulon, whzPerno, whz2

320062673Fuel BushingBague d’essenceBuje de combustible1

330050298Switch, rockerInterrupteurInterruptor1

340008854Lug, GroundPatte, mise à la terreOreja, tierra1

35Note BBolt, Hex 1/4-20 x 1-1/2Boulon, hexPerno, hex1

360062093Washer Nylon .25 IDRondelle en nylonArandela del nilón4

390063114Panel Side CoverPanneau de couverture côtéCubierta lateral panel1

400063115Shield, MufflerTole, silencieuxEscudo, silenciador1

410062021Screw, Torx T20 #10-24 x .50Vis, Torx T20Tornillo, Torx T208

420049953Circuit Breaker, 12ADisjoncteursCortacircuitos1

430051367.01Fuel FilterEpurateur d’essenceFiltro de combustible1

440049920Fuel Shut Off, InlineFermeture d’essenceApagado combustible, en línea1

450035857Clamp, Hose 1/2”Crampon, tuyauAbrazadera, manguera2

460055955Screw CRPH #10-24 x .50VisTornillo1

470062197Bushing, breatherBagueBuje1

480061835Assembly, duck bill fuel valveAssemblage, Robinet de Ensamble, Válvula combustible1

carburant

490047806CapacitorCondensateurCondensador1

500055853Assembly, Fuel lineEssence ligne assembléeTubería de alimentación de combustible1

asamblea

510047706Clamp, Nylon 1/2”Crampon, nylonAbrazadera, nylon1

520001537Screw Hex Hd 8-32 x 3/8VisTornillo1

PARTS LIST / LISTE DES PIÈCES / LISTA DE PIEZAS

Note A:

Powermate Corporation will not provide engines as replacement parts. Engines are covered through the engine manufacturer's warranty. Consult the accompanying

engine manual or contact our service department for assistance.

Note B:

These are standard parts available at your local hardware store.

Note C:

Contact your nearest Powermate CorporationService Center for replacement fuel tanks.

WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should

perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit.

Remarque A:

Powermate Corporation ne fournit pas de moteurs dans ses pièces détachées. Les moteurs sont couverts par la garantie du fabricant de moteurs. Consulter le

manuel du moteur inclus ou contacter notre département de service après-vente pour toute assistance.

Remarque B:

Ces pièces sont des pièces standard disponibles en quincaillerie.

Remarque C:

Pour commander un réservoir de rechange, contacter Centre de service Powermate Corporationle plus proche.

AVERTISSEMENT: Pour éviter toute blessure personnelle ou dommage à l’équipement, l’installation et tout entretien devralent être effectués par un

électricien qualifié ou un préposé au service autorisé. En aucun cas, une personne non-qualifiée ne devrait essayer de faire le raccord au circuit principal.

Nota A:

Powermate Corporation no proporcionará los motores como repuestos. Los motores están cubiertos por medio de la garantía del fabricante del motor. Consulte el

manual adjunto del motor o comuníquese con nuestro departamento de servicio para recibir ayuda al respecto.

Nota B:

Estas son piezas estándar disponibles en su ferretería local.

Nota C:

Para hacer pedidos de tanques, localice el Centro de Servicio de Powermate Corporation más cercano.

ADVERTENCIA: Para evitar posibles lesiones físcas o daños materiales, es necesario que la instalación y todo el servicio sea realizado por un electricista