Swisher 21200 Owner's manual
- Category
- Log splitters
- Type
- Owner's manual
This manual is also suitable for
8/23/2019
OWNER’S MANUAL
SWISHER ACQUISITION INC.
1602 CORPORATE DRIVE, WARRENSBURG, MISSOURI 64093
P
HONE 660-747-8183 FAX 660-747-8650
ade I The
USA
of US and Global Parts
swisherinc.com
CHANGING YOUR LANDSCAPE SINCE 1945
IMPORTANT
Read and follow all
Safety Precautions
and Instructions
Before Operating this
Equipment.
21199 REV 17-001
Kit – Swisher
®
Log Splitter Hitch Mount
21200 - Fits SWISHER
®
22 & 28 Ton H-Beam Log Splitters
2
1207 - Fits SWISHER
®
34 Ton H-Beam Log Splitters
21200 & 21207
In the event you have a claim under this warranty, you must return the product to an authorized
service dealer. All transportation charges, damage, or loss incurred during transportation of parts
submitted for replacement or repair under this warranty shall be borne by the purchaser. Should you
have any questions concerning this warranty, please contact us toll-free at 1-800-222-8183. The
model number, serial number, date of purchase, and the name of the authorized Swisher dealer from
whom you purchased the product will be needed before any warranty claim can be processed.
THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES AND ANY IMPLIED WARRANTIES ARE LIMITED TO THE SAME TIME
PERIODS STATED HEREIN FOR ALL EXPRESSED WARRANTIES. Some states do not
allow the limitation of consequential damages or limitations on how long an implied warranty may
last, so the above limitations or exclusions may not apply to you. This warranty gives you specific
legal rights and you may have other rights, which vary from state-to-state. This is a limited warranty
as defined by the Magnuson-Moss Act of 1975.
LIMITED WARRANTY
The manufacturer’s warranty to the original consumer purchaser is: This product is free from defects
in materials and workmanship for a period of 90 Days from the date of purchase by the original
consumer purchaser. We will repair or replace, at our discretion, parts found to be defective due to
materials or workmanship. This warranty is subject to the following limitations and exclusions:
1. Limitation This warranty applies only to products which have been properly
assembled, adjusted, and operated in accordance with the instructions
contained within this manual. This warranty does not apply to any
product of Swisher that has been subject to alteration, misuse, abuse,
improper assembly or installation, shipping damage, or to normal
wear of product.
2. Exclusions Excluded from this warranty are normal wear, normal adjustments, and
normal maintenance.
2
SAFETY PRECAUTIONS
3
CAUTION: Read and understand the manual. Do not allow anyone to use or assemble
this attachment unless they have read and understand how this attachment works.
This attachment is designed for mounting to the beam of a Swisher Log Splitter. It is intended for light duty
towing of the optional SWISHER
®
16 or 20 cubic foot poly dump carts around the home and farm. It is not
designed or intended for use on any public road or highway. Use of this Log Splitter attachment on any public
road or highway could cause property damage, serious injury, and death.
DO NOT exceed 100 pounds of tongue weight (TW) on this attachment. TW is the downward force that the
tongue of the trailer exerts on the hitch.
DO NOT exceed 1000 pounds gross trailer weight (GTWR). GTWR is the total weight of the trailer AND it’s
cargo.
Secure the Log Splitter to the tow vehicle BEFORE attaching a trailer to the accessory hitch. ALWAYS keep the
Log Splitter secured to the tow vehicle when a trailer is attached to the Log Splitter Accessory Hitch. The weight of
the trailer could cause the log splitter tongue to tilt up unexpectedly and is unsafe.
This accessory is for off-road use only.
Max speed should never exceed 5 Miles Per Hour (MPH) while using this attachment. Use appropriate speed for
the ground conditions and any added weight.
Turning radius may be increased while towing with this attachment.
DANGER OF JACKKNIFING! Driving in reverse/backing up while towing a trailer and a Log Splitter with this
hitch attachment is not recommended and may cause damage to the hitch or other connected equipment.
DO NOT allow any riders on the equipment or trailers being towed.
Consult and follow all limitation & warnings in your tow vehicles owners manual.
Allow only responsible adults who are familiar with these instructions to operate this equipment. Never allow
children to operate this equipment.
Be sure the area is clear of other people and animals before operating. Children are often attracted to machines
and their operating activity. Never assume that children will remain where you last saw them. Keep children
under the watchful care of another responsible adult.
DO NOT operate machinery or vehicles while under the influence of alcohol or drugs.
Never tamper with safety devices or labels. Check their proper operation regularly.
DO NOT operate this attachment on slopes or near drop-offs. There is significant risk of overturns or loss of
control when operating on slopes. Keep all movements slow and gradual. Do not make sudden changes in speed
or direction. Stop and inspect the equipment if you strike an object. Repair if necessary, before restarting.
Never make adjustments or repairs with the engine running. Keep hands and feet away from moving parts.
Anytime you need to leave the operators position stop on level ground, set the parking brake, and shut off the
engine.
Use wheel chocks to block the wheels of vehicles, logsplitters, and trailers before disconnecting them.
This Safety Alert Symbol indicates important messages in this
manual. When you see this symbol, carefully read the message that
follows and be alert to the possibility of personal injury.
4
KIT - LS HITCH MOUNT - ASSEMBLY
When ordering replacement parts
*USE PAINT CODE: TK=BLACK
Item # Part # Description
1 20117 Nut - Nyloc 1/2-13
2 NB177 Washer - Mach 1/2
21197* Mount - LS Hitch 22T & 28T Right
21206* Mount - LS Hitch 34T Right
21196* Mount - LS Hitch 22T & 28T Left
21205* Mount - LS Hitch 34T Left
5 21198 Bolt - HCS 1/2-13 X 10
6 21195 2" Hitch Ball/Washer/Nut
7 20236 Bolt - Carriage 5/16-18 X .75
8 20237 Nut - Serr Flange 5/16-18
3
4
Assembly Instructions
1. Slide notches of items 3 & 4 over the bottom flange of the log
splitter H-Beam, the large hole for the hitch should be towards
the base plate. The bottom of Item 4 will overlap and rest on top
of the base of Item 3.
2. Loosely fasten items 3 & 4 with hardware (1, 2 & 5) as shown.
3. Insert bolts (7) and nuts (8) through the two holes in the lower
portions of the brackets and loosely fasten.
4. Insert hitch ball (6) through the brackets and loosely fasten with
the large washer and nut included.
5. Tighten nut & bolt (1 & 5) enough to clamp items 3 & 4 securely
to the beam but do not over tighten (15-20 ft/lbs). Re-tighten as
needed after initial operation. The grooves are made to wear into
the bottom flange of the H-Beam.
6. Securely tighten the hitch ball installed in step 4 (160 ft/lbs).
7. Securely tighten the hardware installed in step 3 (12 ft/lbs).
When installing the hitch mount,
ensure that brackets 3 & 4 are
within a ½” of base plate on the
log splitter (see figure to the right).
WHEN ORDERING PARTS, PLEASE HAVE THE
FOLLOWING INFORMATION AVAILABLE:
* PRODUCT – ________________
* SERIAL NUMBER - _______________
* MODEL NUMBER - _______________
TYPE - _______________
* PART NUMBER WITH PAINT CODE
* PART DESCRIPTION
TELEPHONE - 1-800-222-8183
FAX - 1-660-747-8650
SWISHER ACQUISITION INC.
1602 CORPORATE DRIVE, WARRENSBURG, MISSOURI 64093
PHONE 660-747-8183 FAX 660-747-8650
ade I The
USA
of US and Global Parts
OWNER’S MANUAL
swisherinc.com
Kit – Swisher
®
Log Splitter Hitch Mount
21200 & 21207
CHANGING YOUR LANDSCAPE SINCE 1945
-
1
-
2
-
3
-
4
-
5
Swisher 21200 Owner's manual
- Category
- Log splitters
- Type
- Owner's manual
- This manual is also suitable for
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Swisher 20880 Owner's manual
-
-
-
-
-
-
-
-
-
