Powermate PMA535202 User manual

Brand: Powermate

Model: PMA535202

Category: Power generators

Type: User manual

PMA535202

Insert

Additif

Adición

ELECTRIC GENERATOR

GROUPE ELECTROGENE

GENERADOR ELECTRICO

IMPORTANT – Please make certain that persons who are to use this equipment thoroughly read and

understand these instructions and any additional instructions provided prior to operation.

IMPORTANT - Prière de vous assurer que les personnes destinées à utiliser cet appareil ont pris soin d'en lire

et d'en comprendre le mode d'emploi ou les directives avant de le mettre en marche.

IMPORTANTE. Asegúrese que las personas que utilizarán este equipo lean y entiendan completamente estas

instrucciones y cualquier instrucción adicional proporcionada antes del funcionamiento.

www.colemanpowermate.com

05/05 0063130

*9 HP Briggs & Stratton OHV engine

*Cast-iron cylinder sleeve

*Low oil sensor

*Receptacles on control panel

*CordKeeper

*5 gallon plastic fuel tank

A.120 V, 20 Ampere Duplex Receptacle

20 amps of current may be drawn from each half of the

receptacle. However, total power drawn must be kept within

nameplate ratings. These receptacles may be used along with

the twistlock receptacle provided the generator is not

overloaded.

B.120/240 V, 20 Ampere Twistlock Receptacle

A maximum of 20 amps may be drawn from the 120/240

volt receptacle, provided it is the only receptacle used.

However, current must be limited to the nameplate rating. If the

120/240 volt receptacle is used along with the 120 volt

receptacle, the total load drawn must not exceed the nameplate

ratings.

C.Circuit Breakers

The receptacles are protected by an AC circuit breaker. If

the generator is overloaded or an external short circuit occurs,

the circuit breaker will trip. If this occurs, disconnect all

electrical loads and try to determine the cause of the problem

before attempting to use the generator again. If overloading

causes the circuit breaker to trip, reduce the load. NOTE:

Continuous tripping of the circuit breaker may cause

damage to generator or equipment. The circuit breaker may

be reset by pushing the button of the breaker.

D.CordKeeper™

The CordKeeper™ is a unique

feature used to prevent plugs from

being pulled out of the 120-volt

receptacles.

Warranty Coverage: Powermate Corporation (the Company)

warrants to the original retail customer in North America that it

will repair or replace, free of charge, any parts found by the

Company or its authorized service representative to be

defective in material or workmanship. This warranty covers the

cost of replacement parts and labor for defects in material or

workmanship.

Not Covered:

· Transportation charges for sending the product to the

Company or its authorized service representative for

warranty service, or for shipping repaired or replacement

products back to the customer; these charges must be

borne by the customer.

· Engine is covered exclusively by a separate warranty from

the engine manufacturer, included with the engine Manual.

· Damages caused by abuse or accident, and the effects of

corrosion, erosion and normal wear and tear.

· Warranty is voided if the customer fails to install, maintain

and operate the product in accordance with the instructions

and recommendations of the Company set forth in the

owner's manual, or if the product is used as rental

equipment.

· The Company will not pay for repairs or adjustments to the

product, or for any costs or labor, performed without the

Company's prior authorization.

Warranty Period: Two (2) years from the date of purchase on

products used solely for consumer applications; if a product is

used for business or commercial applications, the warranty

period will be limited to one (1) year from the date of purchase.

For warranty service, the customer must provide dated proof of

purchase and must notify the Company within the warranty

period.

For warranty service: Call toll free 800-445-1805, or write

to Powermate Corporation, Product Services, 4970 Airport

Road, P. O. Box 6001, Kearney, NE 68848.

EXCLUSIONS AND LIMITATIONS: THE COMPANY MAKES

NO OTHER WARRANTY OF ANY KIND, EXPRESS OR

IMPLIED. IMPLIED WARRANTIES, INCLUDING

WARRANTIES OF MERCHANTABILITY AND OF FITNESS

FOR A PARTICULAR PURPOSE, ARE HEREBY

DISCLAIMED. THE WARRANTY SERVICE DESCRIBED

ABOVE IS THE EXCLUSIVE REMEDY UNDER THIS

WARRANTY; LIABILITY FOR INCIDENTAL AND

CONSEQUENTIAL DAMAGES IS EXCLUDED TO THE

EXTENT PERMITTED BY LAW.

This warranty gives you specific legal rights, and you may also

have other rights which vary from state to state. Some states

do not allow a disclaimer of implied warranties, or the exclusion

or limitation of incidental and consequential damages, so the

above disclaimers and exclusions may not apply to you.

English

CONTROL PANEL

MAJOR GENERATOR FEATURES

LIMITED WARRANTY

Page is loading ...

PARTS LIST / LISTE DES PIÈCES / LISTA DE PIEZAS

RefPartDescription Description DescripciónQty

No.No.

1Note A Engine 9 hp OHVMoteurMotor1

20061777Adapter, engineAdapateur por moteurAdaptor, motor1

30000919.01Bolt, Wz 3/8-16 x 3/4Boulon, wzPerno, wz4

40049620Rotor, 5.0 KWRotorRotor1

5Note BWasher, lock 5/16Contre-écrouArandela, de cierre3

60035055Bolt, hex 5/16-24 x 6 5/8Boulon, tête hexPerno, hexagonal1

70062471Stator 5.0 KW 60 Hz Stator Stator1

9A0062196Connector hsg. set, Jeu pr logemt prise,Conjunto de conectores

panelpanneaupanel1

9B0056716Connector hsg. set, Jeu pr logemt prise,Conjunto de conectores

statorstatordel stator1

100062470Endbell, wired completeCovre-enroulementCaja posterior con cable

câblage complet1

10A0050439Brush, E-4RBalaisEscobilla2

10B0062455Assembly, bridge rectifierEnsemble de planche de Conjunto de la tabla del rectificador del puente

boardredresseur de pont1

10C0062466Connector plugPrise de connecteurTapón del conector1

10D0062264Cover, brushCouvre-balaisCubierta de escobillas1

110040816.01Bolt, hex hd 1/4-20 x 6Boulon, tête hexPerno, hexagonal4

120008854Lug, groundOeillet de mise à la terreTerminal, tierra1

150040832Nut, nyloc 1/4-20Écrous nylocTuerca, nyloc4

160059424Carrier assemblyEnsemble transportTransportador, conjunto1

180051094Isolator, engineSectionneurs moteurAislador, motor4

19Note BBolt HH 5/16-18 x 1.25BoulonPerno2

200049693Bracket, statorPatte de fixation statorSoporte, estator1

210049279Bolt, wz 5/16-18 x 1/2Boulon, wzPerno, wz3

220048736Nut, nyloc 5/16-18Écrous nylocTuerca, nyloc5

23Note BWasher, flat 5/16Rondelles platesArandela, plana5

250049224Assy, ground wireEns fil de masse tresséConjunto, cable trenzado

a tierra1

26Note BWasher, star external 5/16Rondelles à dents ext.Arandela, estrella externa2

27Note BBolt, hex 5/16-18 x 3/4Boulon, tête hexPerno, hexagonal1

280053320Screw #10-16 x 5/8VisTornilla4

300057634Shield, heatÉcran de chaleurPantalla para el calor1

31Note CFuel tank assemblyAssemb. complet du Conjunto tanque 1

réservoir

31A0055340Cap, fuelCapuchon, réservoir Tapa de combustible

d’essence1

31B0062673Fuel BushingBague d’essenceBuje de combustible1

31C0049114Fuel valve with bushingRobinet de carburant Válvula combustible con casquillo

avec bague1

330058618Screw, #10 x 1VisTornillo4

340057177Panel, wired completeTableau compl. câblePanel, cabeado completo1

34A0049072Circuit breaker, 25 ampDisjoncteur 25 ACortacircuitos, 25 amp2

Note A:

Powermate Corporation will not provide engines as replacement parts. Engines are covered through the engine manufacturer's warranty. Consult the

accompanying engine manual or contact our service department for assistance.

Note B:

These are standard parts available at your local hardware store.

Note C:

Contact your nearest Coleman® Powermate® Service Center for replacement fuel tanks.

WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should

perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit.

Remarque A:

Powermate Corporationne fournit pas de moteurs dans ses pièces détachées. Les moteurs sont couverts par la garantie du fabricant de moteurs. Consulter le

manuel du moteur inclus ou contacter notre département de service après-vente pour toute assistance.

Remarque B:

Ces pièces sont des pièces standard disponibles en quincaillerie.

Remarque C:

Pour commander un réservoir de rechange, contacter Centre de service Coleman® Powermate® le plus proche.

AVERTISSEMENT: Pour éviter toute blessure personnelle ou dommage à l’équipement, l’installation et tout entretien devralent être effectués par un

électricien qualifié ou un préposé au service autorisé. En aucun cas, une personne non-qualifiée ne devrait essayer de faire le raccord au circuit principal.

Nota A:

Powermate Corporationno proporcionará los motores como repuestos. Los motores están cubiertos por medio de la garantía del fabricante del motor. Consulte el

manual adjunto del motor o comuníquese con nuestro departamento de servicio para recibir ayuda al respecto.

Nota B:

Estas son piezas estándar disponibles en su ferretería local.

Nota C:

Para hacer pedidos de tanques, localice el Centro de Servicio de Coleman® Powermate® más cercano.

ADVERTENCIA: Para evitar posibles lesiones físcas o daños materiales, es necesario que la instalación y todo el servicio sea realizado por un electricista