Outdoor LP Gas Barbecue Grill
Model No. GBC1273W / BH12-101-001-02
Manufactured in China for: Blue Rhino Global Sourcing, Inc
7INSTON3ALEM .# 53! s WWWBLUERHINOCOM
¥ "LUE 2HINO 'LOBAL 3OURCING )NC !LL 2IGHTS 2ESERVED
BETTER HOMES AND GARDENS and the Better Homes and Garden logo are trademarks of Meredith Corporation, licensed to and
DISTRIBUTED BY 7AL-ART 3TORES )NC !LL RIGHTS RESERVED '"#7?S/- %3
Table of Contents
Important Safeguards 0AGE
%XPLODED 6IEW (ARDWARE
Assembly Instructions
Assembly Instructions - Rotisserie
Installling LP Gas Tank
Insert LP Gas Tank
Secure LP Gas Tank
Connect LP Gas Tank
Disconnect LP Gas Tank
Installing natural gas line
Connect natural gas line
Disconnect natural gas line
Operating Instructions
Checking for Leaks
Operating Main Burners
Operating Infrared Sear Burner
Operating Side Burner
Operating Infrared Back Burner
Tips
Operating Rotisserie
Cleaning and Care
Product Registration
Limited Warranty
Troubleshooting
4HE USE AND INSTALLATION MUST CONFORM WITH LOCAL CODES OR IN THE ABSENCE OF LOCAL
CODES WITH EITHER THE National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas
and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2,or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA
Z240 RV Series, Recreational Vehicle Code, AS APPLICABLE
#ALIFORNIA 0ROPOSITION #OMBUSTION BYPRODUCTS PRODUCED WHEN USING THIS PRODUCT
CONTAIN CHEMICALS KNOWN TO THE 3TATE OF #ALIFORNIA TO CAUSE CANCER BIRTH DEFECTS AND
OTHER REPRODUCTIVE HARM
#ALIFORNIA 0ROPOSITION 7ASH YOUR HANDS AFTER HANDLING THIS PRODUCT
OWNER’S MANUAL
Made from 75% Bagasse
(Environmentally Friendly Sugar
Cane Pulp By-product)
3AVE THESE INSTRUCTIONS FOR FUTURE REFERENCE
If you are assembling this unit for someone else,
GIVE THIS MANUAL TO HIM OR HER TO READ AND SAVE
FOR FUTURE REFERENCE
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
property damage.
2. Read the installation, operation and
maintenance instructions thoroughly before
installing or servicing this equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury or death.
4. This instruction manual contains important
information necessary for the proper
assembly and safe use of the appliance.
5. Read and follow all warnings and
instructions before assembling and using
the appliance.
6. Follow all warnings and instructions when
using the appliance.
7. Keep this manual for future reference.
WARNING
FOR YOUR SAFETY:
1. Do not store or use gasoline or other
flammable liquids or vapors in the vicinity of
this or any other appliance.
2. An LP cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
DANGER
Never operate this appliance unattended.
DANGER
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Natural gas conversion
kit is available, model
number VFK1000W.
Outdoor LP Gas Barbecue Grill Model No. GBC1273W / BH12-101-001-02
This grill is for outdoor use only, and shall not be used in a building,
garage or any other enclosed area.
Do NOT operate, light or use this appliance within ten (10) feet (3.05 m) of
walls, structures or buildings.
For residential use only. This grill is NOT for commercial use.
This grill is not intended for and should never be used as a heater. TOXIC
fumes can accumulate and cause asphyxiation.
This grill is safety certified for use in the United States and/or Canada
only. Do not modify for use in any other location. Modification will result
in a safety hazard.
Apartment Dwellers: Check with management to learn the requirements
and fire codes for using an LP gas grill in your apartment complex. If
allowed, use outside on the ground floor with a ten (10) foot (3.05 m)
clearance from any structure. Do not use on or under balconies.
This grill is for use with liquid propane (LP) gas only. The conversion to
or attempted use of natural gas in this LP gas grill is dangerous and will
void your warranty.
LP gas Characteristics:
a. LP gas is flammable and hazardous if handled improperly. Become
aware of the characteristics before using any LP gas product.
b. LP gas is explosive under pressure, heavier than air, and settles and
pools in low areas.
c. LP gas in its natural state has no odor. For your safety, an odorant is
added that smells like rotten cabbage.
d. Contact with LP gas can cause freeze burns to skin.
Natural Gas ( NG) Characteristics:
a. NG is flammable and hazardous if handled improperly. Become
aware of the characteristics before using any NG product.
b. NG is explosive under pressure, heavier than air and settles and pools
in low areas.
c. NG in its natural state has no odor. For your safety, an odorant is
added that smells like rotten cabbage.
d. Contact with NG can cause freeze burns to skin.
LP gas tank needed to operate. Only tanks marked “propane” may be
used.
The LP gas tank must be constructed and marked in accordance
with the Specifications for LP gas Cylinders of the U.S. Department of
Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339,
Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods;
and Commission.
LP gas tank must be arranged for vapor withdrawal.
The LP gas tank must have a listed overfilling prevention device (OPD).
Only use LP gas cylinders equipped with a cylinder connection device
compatible with the connection for outdoor cooking appliances.
The LP gas tank must have a tank collar to protect the tank valve.
Never use an LP gas tank with a damaged body, valve, collar or footing.
Dented or rusted LP gas tanks may be hazardous and should be checked
by your LP gas supplier prior to use.
The LP gas tank should not be dropped or handled roughly.
LP gas tanks must be stored outdoors out of the reach of children and
must not be stored in a building, garage or any other enclosed area. Your
tank must never be stored where temperatures can reach over 125°F.
Do not insert any tool or foreign object into the valve outlet or safety
relief valve. You may damage the valve and cause a leak. Leaking
propane may result in explosion, fire, severe personal injury or death.
Do not block holes in sides or back of grill.
Never keep a filled LP gas tank in a hot car or car trunk. Heat will cause
the gas pressure to increase, which may open the relief valve and allow
gas to escape.
Place dust cap on cylinder valve outlet whenever the cylinder is not in
use. Only install the type of dust cap on the cylinder valve outlet that is
provided with the cylinder valve. Other types of caps or plugs may result
in leakage of propane.
If grill is not in use, the gas must be turned off at the supply tank and
disconnected.
Do not store a spare LP gas tank under or near this appliance.
Never fill the tank beyond 80 percent full.
A fire causing, serious injury or damage to property may occur if the
above is not followed exactly.
Never attempt to attach this grill to the self-contained LP gas system of a
camper trailer, motor home or house.
The use of alcohol, prescription or non-prescription drugs may impair the
consumer’s ability to properly assemble or safely operate the appliance.
Strong odors, colds, sinus congestion, etc. may prevent the detection of
propane. Use caution and common sense when testing for leaks.
Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene or alcohol
with this product.
Your grill has been checked at all factory connections for leaks. Recheck
all connections as described in the “Operating Instructions” section of
the manual, as movement in shipping can loosen connections.
Check for leaks even if your unit was assembled for you by someone
else.
Do not operate if gas leak is present. Gas leaks may cause a fire or
explosion.
You must follow all leak-checking procedures before operating. To
prevent fire or explosion hazard when testing for a leak:
a. Always perform leak test before lighting the grill and each time the
tank is connected for use.
b. No smoking. Do not use or permit sources of ignition in the area
while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do not use matches, lighters, or a flame to check for leaks.
e. Do not use grill until any and all leaks are corrected.
LP: If you are unable to stop a leak, disconnect the LP gas supply. Call a
gas appliance serviceman or your local LP gas supplier.
NG: If you are unable to stop a leak, turn off the main valve on the NG
supply line. Call a gas appliance serviceman or your local NG supplier.
NG: The appliance and its individual shutoff valve must be disconnected
from the gas supply piping system during any pressure testing of that
system at a pressures in excess of 1/2 psig (3.5 kpa).
NG: The appliance must be isolated from the gas supply piping system by
closing its individual manual shutoff valve during any pressure testing of
the gas supply piping system at test pressures equal to or less than 1/2
psig (3.5 kpa).
This grill is designed with to operate at an inlet pressure of: LP gas: 11
inches water column; NG 7 inches water column.
Do not store or use gasoline or other flammable liquids or vapors within
25 feet (7.62 m) of this appliance.
Do not use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
Minimum clearance from sides and back of unit to combustible
construction is 36 inches (91.4 cm). Do not use this appliance under any
type of overhang or roof.
It is essential to keep the grill’s valve compartment, burners and
circulating air passages clean.
Inspect grill before each use.
Do not alter grill in any manner. Any alteration will void your warranty.
Do not use the grill unless it is COMPLETELY assembled and all parts are
securely fastened and tightened.
Do not build this model of grill in any built-in or slide in construction.
Ignoring this warning could cause a fire or an explosion that can damage
property and cause serious bodily injury or death.
This grill should be thoroughly cleaned and inspected on a regular basis.
Clean and inspect the hose before each use of the appliance. If there is
evidence of abrasion, wear, cuts or leaks, the hose must be replaced prior
to the appliance being put into operation.
Use only the regulator and hose assembly provided. The replacement
regulator and hose assembly shall be that specified by the manufacturer.
Use only Blue Rhino Global Sourcing, Inc. factory authorized parts. The
use of any part that is not factory authorized can be dangerous. Doing so
will also void your warranty.
Do not operate this appliance without reading “Operating Instructions” in
this manual.
Do not touch metal parts of grill until it has completely cooled (about 45
min.) to avoid burns, unless you are wearing protective gear (pot holders,
gloves, BBQ mittens, etc.).
Do not install or use in or on boats or recreational vehicles.
When cooking, fire extinguishing materials shall be readily accessible. In
the event of an oil/grease fire, do not attempt to extinguish with water.
Use type BC dry chemical fire extinguisher or smother with dirt, sand or
baking soda.
Do not use grill in high winds.
Never lean over the grill when lighting.
Do not leave a lit grill unattended, especially keep children and pets
away from grill at all times.
Do not leave grill unattended while preheating or burning off food
residue on high. If grill has not been cleaned, a grease fire can occur that
may damage the product.
Do not place empty cooking vessels on the appliance while in operation.
Use caution when placing anything on the grill while the appliance is in
operation.
Do not attempt to move grill when in use. Allow the grill to cool before
moving or storing.
LP gas tank must be properly disconnected and removed prior to moving
this grill.
Storage of grill indoors is permissible only if the tank is disconnected,
removed from the grill and properly stored outdoors.
Always open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
Do not attempt to disconnect the gas regulator from the tank or any gas
fitting while the grill is in use.
Always place your grill on a hard, non-combustible, level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
Move gas hoses as far away as possible from hot surfaces and dripping
hot grease.
Keep all electrical cords away from a hot grill.
After a period of storage and/or nonuse, check for leaks, burner
obstructions and inspect for any abrasion, wear or cuts to the hose.
Failure to open lid while igniting the grill’s burners, or not waiting 5
minutes to allow the gas to clear if the grill does not light, may result in
an explosive flame-up.
Never operate grill without heat plates installed.
Always use a meat thermometer to ensure food is cooked to a safe
temperature.
Use protective gloves when assembling this product.
Do not force parts together as this can result in personal injury or
damage to the product.
Never cover entire cooking area with aluminum foil.
All electrical accessories (such as rotisserie) must be electrically
grounded in accordance with local codes, or National Electrical Code,
ANSI / NFPA 70 or Canadian Electrical Code, CSA C22.1. Keep any
electrical cords and/or fuel supply hoses away from any hot surfaces.
To protect against electric shock, do not immerse cord or plugs in water
or other liquid.
DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage
to property.
WARNING:
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com
PAGE NO
Tools Required for Assembly (Included)
0HILLIPS (EAD 3CREWDRIVER PC
-- 7RENCH PC
1
Parts List
1
Warming Rack
2
#OOKING 'RID
3
Temperature Gauge*
4
Branding Plate*
5
Lid Handle*
6
Lid*
7
(EAT 0LATE
8
Side Burner Grid
9
Side Burner
10
Regulator/Hose Assembly*
11
Infrared Back Burner*
12
"URNER
13
Infrared Sear Burner*
14
#ONTROL +NOB "EZEL
15
#ONTROL +NOB
16
Right Side Shelf
Assembly*
17
4OWEL "AR
18
4OOL (OOK
19
Left Side Shelf
20
Left Side Shelf Front Panel
21
Right Side Shelf Front
Panel
22
Rotisserie Motor
23
Rotisserie Motor Support
24
2OTISSERIE &ORK
25
Rotisserie Handle
26
2OTISSERIE #OUNTERWEIGHT
27
Rotisserie Rod
28
Grease Cup
29
Grease Tray
30
"ASKET
31
Cart Frame Support
32
"ASKET 3UPPORT
33
Left Side Panel
Exploded View
2
2
2
5
Hardware
A
3CREW
-X .ICKEL 0LATED 0HILLIPS 4RUSS (EAD
PCS
B
3CREW
-X .ICKEL 0LATED 0HILLIPS 4RUSS (EAD
PCS
C
3CREW
-X .ICKEL 0LATED 0HILLIPS 4RUSS (EAD
PCS
D
Bolt
-X .ICKEL 0LATED (EX (EAD
PCS
E
Nut
- .ICKEL 0LATED
PCS
F
Washer
.ICKEL 0LATED
PCS
G
Washer
.ICKEL 0LATED
PCS
H
Lock Washer
.ICKEL 0LATED
PCS
3
4
6
8
9
10
11
13
14
16
15
17
19
20
22
21
23
25
27
28
29
24
26
33
34
31
35
36
41
42
37
37
38
39
34
Rear Panel
35
LP Gas Tank Retainer
Wire*
36
Right Side Panel
37
$OOR (ANDLE
38
Left Door
39
Right Door
40
Lighting Hook*
41
Bottom Shelf
42
Front Cart Frame Support
43
$OOR -AGNET
44
2EAR ,OCKING 7HEEL
45
&RONT 7HEEL
46
Grill Body Assembly*
* Pre assembled
7
30
32
43
44
45
18
14
15
12
40
Unplug from the outlet when not in use and before cleaning. Allow to cool
before putting on or taking off parts.
Do not let the cord hang over the edge of a table or touch hot surface.
Do not use an outdoor cooking gas appliance for purposes other than
intended.
When connecting, first connect plug to the outdoor cooking gas
appliance then plug appliance into the outlet.
Use only a Ground Fault Interrupter (GFI) protected circuit with this
outdoor cooking gas appliance.
Never remove the grounding plug or use with an adapter of 2 prongs;
and use only extension cords with a 3 prong grounding plug, rated for
the power of the equipment, and approved for outdoor use with a W-A
marking.
OUTDOOR USE ONLY. DO NOT EXPOSE TO RAIN.
CAUTION: Risk of Electric Shock. Keep extension cord connection dry and
off the ground
Use only on properly grounded outlet.
Deaths, serious injury or damage to property may occur if the above is
not followed exactly.
46
43
Outdoor LP Gas Barbecue Grill Model No. GBC1273W / BH12-101-001-02
1
DO NOT RETURN PRODUCT TO STORE.
For assistance call 1.800.762.1142 TOLL FREE 0LEASE HAVE
YOUR OWNERS MANUAL AND MODEL NUMBER AVAILABLE FOR
REFERENCE
Note: The model number can be found on the back or side of the cart
ASSEMBLY
For Easiest Assembly:
s 4O AVOID LOSING ANY SMALL COMPONENTS OR HARDWARE ASSEMBLE
YOUR PRODUCT ON A LEVEL SURFACE THAT DOES NOT HAVE CRACKS OR
OPENINGS
s #LEAR AN AREA LARGE ENOUGH TO LAYOUT ALL COMPONENTS AND
HARDWARE AND THAT IS SOFT TO NOT SCRATCH OR DAMAGE ANY SURFACE
FINISHES
s 7HEN APPLICABLE TIGHTEN ALL HARDWARE CONNECTIONS BY HAND
FIRST /NCE THE STEP IS COMPLETED GO BACK AND FULLY TIGHTEN ALL
HARDWARE WHILE BEING CAUTIOUS NOT TO OVER TIGHTEN TO AVOID
DAMAGING SURFACES OR STRIPPING HARDWARE
s &OLLOW ALL STEPS IN ORDER TO PROPERLY ASSEMBLE YOUR PRODUCT
4O COMPLETE ASSEMBLY YOU WILL NEED
s ,EAK $ETECTION 3OLUTION )NSTRUCTIONS ON HOW TO MAKE
solution are included in the “Operating Instructions” section of
this manual)
s LP: 0RECISION &ILLED ,0 'AS 'RILL 4ANK WITH !CME 4YPE
EXTERNAL THREADED VALVE CONNECTION GALLON SIZE
s NG: .ATURAL 'AS #ONVERSION +IT MODEL NUMBER 6&+7
(not included)
4YPICAL ASSEMBLY APPROXIMATELY ONE HOUR
Assembly Instructions
4
Attach Front Cart Frame Support
A
x 4
B
x 4
G
x 4
2
Attach Wheels
B
x 8
E
x 8
F
x 8
H
x 8
3
Attach Side Panels and Rear Panel
B
x 11
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com
PAGE NO
Assembly Instructions
5
Attach Cart Frame Support
A
x 2
7
Insert Baskets
6
Attach Basket Supports
B
x 8
8
Attach Door Handles
C
x 4
G
x 4
Outdoor LP Gas Barbecue Grill Model No. GBC1273W / BH12-101-001-02
Assembly Instructions (continued)
9
Attach Doors
12
Attach Left Side Shelf
Note: ,EAVE MM OF BOLT THREADS EXPOSED
D
x 2
10
Attach Grill Body Assembly
D
x 4
G
x 4
11
Attach Side Shelf Front Panels and Towel Bar
A
x 2
D
x 6
G
x 2
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com
PAGE NO
Assembly Instructions (continued)
14
Attach Right Side Shelf
Note: ,EAVE MM OF BOLT THREADS EXPOSED
D
x 2
13
Secure Left Side Shelf
D
x 3
15
Secure Right Side Shelf
D
x 3
16
Attach Side Burner Regulator/Control Valve, Control
Knob Bezel and Control Knob
A
x 2
Outdoor LP Gas Barbecue Grill Model No. GBC1273W / BH12-101-001-02
Assembly Instructions (continued)
18
Insert Heat Plates and Cooking Grids
19
Insert Warming Rack
20
Insert Grease Tray and Grease Cup
17
Attach Side Burner, Igniter Wire and Side Burner Grid
A
x 2
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com
PAGE NO
Assembly Instructions (continued)
21
Insert Regulator/Control Valve
Natural gas conversion kit is available,
model number VFK1000W.
Outdoor LP Gas Barbecue Grill Model No. GBC1273W / BH12-101-001-02
Assembly Instructions – Rotisserie
1
Remove Warming Rack
2
Assemble Rotisserie Rod
4
Insert Rotisserie Rod
3
Attach Rotisserie Motor Support and Rostisserie Motor
B
x 2
E
x 2
F
x 2
H
x 2
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com
PAGE NO
Installing LP Gas Tank
4O OPERATE YOU WILL NEED PRECISIONFILLED STANDARD GRILL ,0 GAS
TANK WITH EXTERNAL VALVE THREADS
Note: !N EMPTY STANDARD GRILL ,0 GAS TANK WEIGHS APPROXIMATELY
LBS ! PRECISIONFILLED STANDARD GRILL ,0 GAS TANK SHOULD WEIGH
NO MORE THAN LBS
CAUTION: LP gas tank must be properly
disconnected and removed prior to moving this
grill.
Insert LP Gas Tank
Place precision filled LP gas tank upright into the notches in the right cart frame so the tank
VALVE IS FACING THE GAS LINE CONNECTION
Secure LP Gas Tank
3ECURE TANK BY SLIDING TANK RETAINER WIRE OVER SHOULDER OF ,0 GAS TANK
Connect LP Gas Tank
Before connecting, be sure that there is no debris caught in
THE HEAD OF THE ,0 GAS TANK HEAD OF THE REGULATOR VALVE OR
IN THE HEAD OF THE BURNER AND BURNER PORTS
Connect regulator/hose assembly to tank by turning knob
CLOCKWISE UNTIL IT STOPS
Disconnect LP Gas Tank
"EFORE DISCONNECTING MAKE SURE THE ,0 GAS TANK VALVE IS
h#,/3%$v
Disconnect regulator/hose assembly from LP gas tank by
TURNING KNOB COUNTERCLOCKWISE UNTIL IT IS LOOSE
CAUTION: LP gas tank must be properly
disconnected and removed prior to moving
this grill.
0LACE THE PROTECTIVE CAP COVER ON THE ,0 TANK AND STORE
THE TANK OUTDOORS IN A WELL VENTILATED AREA OUT OF DIRECT
SUNLIGHT
Need a tank of gas? 4RY TANK EXCHANGE SERVICE )TS EASY FAST SAFE
AND AVAILABLE AT TENS OF THOUSANDS OF CONVENIENTLY LOCATED RETAIL OUTLETS
NATIONWIDE 9OU CAN PURCHASE A NEW FULL TANK OR EXCHANGE YOUR EMPTY FOR
A PRECISION FILLED ONE
20 lb
9 Kg
17.9 in. / 45.5 cm
12.2 in. / 31 cm
Operating Instructions
Checking for Leaks
Burner Connections
-AKE SURE THE REGULATOR VALVE AND HOSE CONNECTIONS
ARE SECURELY FASTENED TO THE BURNER AND THE TANK
6ISUALLY CHECK THE CONNECTION BETWEEN THE BURNER
VENTURI PIPE AND ORIFICE -AKE SURE THE BURNER
VENTURI PIPE FITS OVER THE ORIFICE
WARNING: Failure to inspect this
connection or follow these instructions
could cause a fire or an explosion
which can cause death, serious bodily
injury or damage to property.
0LEASE REFER TO DIAGRAM FOR PROPER INSTALLATION
&IGURES AND
)F THE BURNER PIPE DOES NOT REST FLUSH TO THE ORIFICE
PLEASE CONTACT FOR ASSISTANCE
Tank/Gas Line Connection
-AKE OZ OF LEAK SOLUTION BY MIXING ONE PART
LIQUID DISHWASHING SOAP WITH THREE PARTS WATER
-AKE SURE CONTROL KNOBS ARE
(OFF) position
&IGURE
LP: Connect LP gas tank per “Installing LP Gas Tank”
SECTION
NG: Connect NG main line per “Installing Natural Gas
,INEv SECTION
LP: 4URN ,0 GAS TANK VALVE TO h/0%.v
NG: 4URN h/.v NATURAL GAS MAIN VALVE
3POON LEAK CHECK SOLUTION AT ALL h8v LOCATIONS
&IGURES A AND B
A LP: )F ANY BUBBLES APPEAR TURN ,0 GAS TANK VALVE
TO h#,/3%$v RECONNECT AND RETEST
NG: If any bubbles appear turn natural gas main
VALVE h/&&v RECONNECT AND RETEST
B LP: )F YOU CONTINUE TO SEE BUBBLES AFTER SEVERAL
ATTEMPTS TURN ,0 GAS TANK VALVE TO h#,/3%$v AND
disconnect LP gas tank, per “Disconnect LP Gas
4ANKv INSTRUCTIONS AND CONTACT
FOR ASSISTANCE
NG: )F YOU CONTINUE TO SEE BUBBLES AFTER SEVERAL
ATTEMPTS TURN NATURAL GAS MAIN VALVE h/&&v
and disconnect natural gas line and contact
FOR ASSISTANCE
C LP: If no bubbles appear after one minute turn LP
GAS TANK VALVE h#,/3%$v WIPE AWAY SOLUTION AND
PROCEED
NG: If no bubbles appear after one minute turn
NATURAL GAS MAIN VALVE h/&&v WIPE AWAY SOLUTION
AND PROCEED
&IGURE
Burner
VENTURI
pipe
Back burner soft
pipe connection
LP gas
VALVE WITH
orifice
Main Burners
6ALVE
soft pipe
connection
&IGURE
LP Gas
Connection
,0 'AS 6ALVE
WITH /RIlCE
6ALVE
Soft Pipe
Connection
Side Burner
Burner
VENTURI
pipe
&IGURE
OFF
APAGADO
&IGURE A
X
X
X
X
X
&IGURE B
X
X
Installing Natural Gas Line
)NSTALLATION SHOULD BE DONE BY A QUALIFIED SERVICE PERSON
CAUTION: If young children are in the area, a locking valve should be
considered.
Connect Natural Gas Line
Before connecting, be sure that there is no debris caught in
the head of the natural gas line, head of the grill natural gas
LINE OR IN THE HEAD OF THE BURNER AND BURNER PORTS
#ONNECT GRILL NATURAL GAS LINE TO NATURAL GAS LINE
Disconnect Natural Gas Line
"EFORE DISCONNECTING MAKE SURE THE NATURAL GAS LINE VALVE IS
h/&&v
$ISCONNECT GRILL NATURAL GAS LINE FROM NATURAL GAS LINE
Outdoor LP Gas Barbecue Grill Model No. GBC1273W / BH12-101-001-02
Operating Main Burners
First Use
-AKE SURE ALL LABELS PACKAGING AND PROTECTIVE FILMS
HAVE BEEN REMOVED FROM THE GRILL
2EMOVE MANUFACTURING OILS BEFORE COOKING ON THIS
grill for the first time by operating the grill for at
LEAST MINUTES ON
()'( WITH THE LID CLOSED 4HIS
WILL hHEAT CLEANv THE INTERNAL PARTS AND DISSIPATE
ODORS
Lighting Instructions
CAUTION: Keep outdoor gas cooking
appliance area clear and free from
combustible materials, gasoline and
other flammable vapors and liquids.
CAUTION: Do not obstruct the flow of
combustion and ventilation air.
CAUTION: Check and clean burner/
venturi tubes for insects and insect
nests. A clogged tube can lead to a fire beneath the grill.
CAUTION: Attempting to light the burner with the lid closed may cause
an explosion.
/PEN LID
-AKE SURE THERE ARE NO OBSTRUCTIONS OF AIRFLOW TO THE BURNERS 3PIDERS AND INSECTS CAN NEST
WITHIN AND CLOG THE BURNER VENTURI TUBE AT THE ORIFICE ! CLOGGED BURNER TUBE CAN LEAD TO A
FIRE BENEATH THE APPLIANCE
!LL CONTROL KNOBS MUST BE IN THE
/&& POSITION &IGURE
LP: #ONNECT ,0 GAS TANK PER h)NSTALLING ,0 'AS 4ANKv SECTION
NG: #ONNECT .' MAIN LINE PER h)NSTALLING .ATURAL 'AS ,INEv SECTION
LP: 4URN ,0 GAS TANK VALVE TO h/0%.v
NG: 4URN h/.v NATURAL GAS MAIN VALVE
0USH AND TURN CONTROL KNOB SLOWLY TO
()'( UNTIL A CLICK IS HEARD 4HE BURNER SHOULD LIGHT
)F THE BURNER DOES NOT LIGHT REPEAT UP TO THREE TIMES
)F IGNITION DOES NOT OCCUR IN SECONDS TURN BURNER CONTROL KNOB
/&& WAIT MINUTES AND
REPEAT LIGHTING PROCEDURE
)F IGNITER DOES NOT LIGHT BURNER USE A LIT MATCH SECURED WITH THE LIGHTING ROD PROVIDED TO LIGHT
BURNERS MANUALLY !CCESS THE BURNERS THROUGH THE COOKING GRID AND HEAT PLATES 0OSITION THE
LIT MATCH NEAR SIDE OF THE BURNER &IGURE
Important: !LWAYS USE THE LIGHTING ROD PROVIDED WHEN LIGHTING BURNERS WITH A MATCH
!FTER LIGHTING OBSERVE THE BURNER FLAME MAKE SURE ALL BURNER PORTS ARE LIT AND FLAME HEIGHT
MATCHES ILLUSTRATION &IGURE
Note %ACH BURNER LIGHTS INDEPENDENTLY REPEAT STEPS FOR THE OTHER BURNERS
CAUTION: If burner flame goes out during operation, immediately turn
the control knobs to the
(OFF) position
(a) LP gas tank valve “CLOSED” or
(b) NG main valve “OFF”
and open lid to let the gas clear for 5 minutes before re-lighting.
Turning Off
LP: 4URN ,0 GAS TANK VALVE TO h#,/3%$v
NG: 4URN h/&&v NATURAL GAS MAIN VALVE
4URN ALL CONTROL KNOBS CLOCKWISE TO THE
/&& POSITION
Note: ! hPOOFv SOUND IS NORMAL AS THE LAST OF THE GAS IS BURNED
LP: $ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
NG: +EEP MAIN GAS LINE CONNECTED
Direct Cooking
CAUTION: Do not leave grill unattended while preheating, cooking or burning
off food residue on
(HIGH). If grill has not been cleaned, a grease fire can
occur.
#OOKING DIRECTLY OVER LIT BURNERS IS IDEAL FOR SEARING IN JUICES AND GRILLING FOOD REQUIRING LESS THAN
MINUTES OF GRILLING TIME SUCH AS STEAKS HAMBURGERS HOT DOGS CHICKEN PARTS VEGETABLES
AND FRUIT
/PEN LID AND IGNITE THE DESIRED BURNERS PER h,IGHTING )NSTRUCTIONSv SECTION
#LOSE LID AND PREHEAT GRILL ON
()'(
7EAR PROTECTIVE GLOVES AND USE LONG HANDLE TONGS TO PLACE FOOD ONTO COOKING GRIDS ABOVE THE
LIT BURNERS
!DJUST CONTROLS TO DESIRED FLAME HEIGHT
7ITH LID OPEN OR CLOSED COOK UNTIL DESIRED INTERNAL FOOD TEMPERATURES ARE ACHIEVED
4URN GRILL /&& PER h4URNING /FFv INSTRUCTIONS
For more tips on direct cooking please see “Tips for Better Cookouts and Longer Grill Life”
Indirect Cooking
CAUTION: Do not leave grill unattended while preheating, cooking or burning
off food residue on
(HIGH). If grill has not been cleaned, a grease fire can
occur.
.OT COOKING DIRECTLY OVER LIT BURNERS IS IDEAL FOR SLOW COOKING AND FOODS REQUIRING MORE THAN
MINUTES SUCH AS MOST ROASTS LOINS CHOPS WHOLE CHICKENS TURKEY FISH AND BAKED GOODS
/PEN LID AND IGNITE THE DESIRED BURNERS PER h,IGHTING )NSTRUCTIONSv SECTION
#LOSE LID AND PREHEAT GRILL ON
()'(
7EAR PROTECTIVE GLOVES AND USE LONG HANDLE TONGS TO PLACE FOOD ONTO COOKING GRIDS ABOVE THE
UNLIT BURNERS
!DJUST CONTROLS TO DESIRED FLAME HEIGHT
7ITH LID CLOSED COOK UNTIL DESIRED INTERNAL FOOD TEMPERATURES ARE ACHIEVED
4URN GRILL /&& PER h4URNING /FFv INSTRUCTIONS
For more tips on indirect cooking please see “Tips for Better Cookouts and Longer Grill Life”
Controlling Flare-ups
CAUTION: Putting out grease fires by closing the lid is not possible.
s )F A GREASE FIRE DEVELOPS TURN KNOBS
(OFF) position
(a) LP gas tank valve “CLOSED” or
(b) NG main valve “OFF”
Do not use water on a grease fire. This can cause the grease to
splatter and could result in serious burns, bodily harm or other
damage.
s $O NOT LEAVE GRILL UNATTENDED WHILE PREHEATING OR BURNING OFF FOOD
residue on
(HIGH). If grill has not been cleaned, a grease fire can
occur that may damage the product.
WARNING: When cooking, fire extinguishing materials shall be readily
accessible. In the event of an oil/grease fire. Use type BC dry chemical
fire extinguisher or smother with dirt, sand or baking soda. Do not
attempt to extinguish with water.
&LAREUPS ARE A PART OF COOKING MEATS ON A GRILL AND ADDS TO THE UNIQUE FLAVOR OF GRILLING
Excessive flare-ups can over-cook your food and cause a dangerous situation for you
and your grill.
Important: %XCESSIVE FLAREUPS RESULT FROM THE BUILDUP OF GREASE IN THE BOTTOM OF YOUR GRILL
Minimize Flare-ups:
4RIM EXCESS FAT FROM MEATS PRIOR TO COOKING
#OOK HIGH FAT CONTENTS MEATS ON
,/7 SETTING OR INDIRECTLY
%NSURE THAT YOUR GRILL IS ON HARD LEVEL NONCOMBUSTIBLE SURFACE AND THE GREASE IS ALLOWED TO
DRAIN INTO GREASE CUP
Operating Infrared Sear Burner
First Use
-AKE SURE ALL LABELS PACKAGING AND PROTECTIVE FILMS HAVE BEEN REMOVED FROM THE GRILL
2EMOVE MANUFACTURING OILS BEFORE COOKING ON THIS GRILL FOR THE FIRST TIME BY OPERATING THE GRILL
FOR AT LEAST MINUTES ON
()'( WITH THE LID CLOSED 4HIS WILL hHEAT CLEANv THE INTERNAL PARTS
AND DISSIPATE ODORS
Lighting
Caution: Keep outdoor gas cooking appliance area clear and free from
combustible materials, gasoline and other flammable vapors and
liquids.
Caution: Do not obstruct the flow of combustion and ventilation air.
Caution: Check and clean burner/venturi tubes for insects and insect
nests. A clogged tube can lead to a fire beneath the grill.
Caution: Attempting to light the burner with the lid closed may cause
an explosion.
./4% )NFRARED SEAR BURNER CAN BE USED WHILE MAIN
BURNERS ARE OPERATING
/PEN LID Attempting to light the burner with the
lid closed may cause an explosion!
-AKE SURE THERE ARE NO OBSTRUCTIONS OF AIRFLOW TO THE
BURNER 3PIDERS AND INSECTS CAN NEST WITHIN AND CLOG
THE BURNER VENTURI TUBE AT THE ORIFICE ! CLOGGED
BURNER TUBE CAN LEAD TO A FIRE BENEATH THE APPLIANCE
#ONTROL KNOB MUST BE IN THE
(OFF) position
&IGURE
LP: Connect LP gas tank per “Installing LP Gas
4ANKv SECTION
NG: Connect NG main line per “Installing Natural
'AS ,INEv SECTION
LP: 4URN ,0 GAS TANK VALVE TO h/0%.v
NG: 4URN h/.v NATURAL GAS MAIN VALVE
0USH AND TURN CONTROL KNOB SLOWLY TO
()'( UNTIL A CLICK IS HEARD 4HE BURNER SHOULD LIGHT
)F THE BURNER DOES NOT LIGHT REPEAT UP TO THREE TIMES
.OTE )NFRARED "URNER SHOULD TURN RED AFTER TO MINUTES
&IGURE
Operating Instructions (continued)
&IGURE
&IGURE
Burner
Flame
Slight
9ELLOW
Slight
Blue
Dark
Blue
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com
PAGE NO
Operating Infrared Back Burner
First Use
-AKE SURE ALL LABELS PACKAGING AND PROTECTIVE FILMS HAVE BEEN REMOVED FROM THE GRILL
2EMOVE MANUFACTURING OILS BEFORE COOKING ON THIS GRILL FOR THE FIRST TIME BY OPERATING THE GRILL
FOR AT LEAST MINUTES ON
()'( WITH THE LID CLOSED 4HIS WILL hHEAT CLEANv THE INTERNAL PARTS
AND DISSIPATE ODORS
Lighting
Caution: Keep outdoor gas cooking appliance area clear and free from
combustible materials, gasoline and other flammable vapors and
liquids.
Caution: Do not obstruct the flow of combustion and ventilation air.
Caution: Check and clean burner/venturi tubes for insects and insect
nests. A clogged tube can lead to a fire beneath the grill.
Caution: Attempting to light the burner with the lid closed may cause
an explosion.
./4% )NFRARED SEAR BURNER CAN BE USED WHILE MAIN BURNERS ARE OPERATING
/PEN LID Attempting to light the burner with the
lid closed may cause an explosion!
-AKE SURE THERE ARE NO OBSTRUCTIONS OF AIRFLOW TO
THE BURNER 3PIDERS AND INSECTS CAN NEST WITHIN
AND CLOG THE BURNER VENTURI TUBE AT THE ORIFICE !
clogged burner tube can lead to a fire beneath the
APPLIANCE
#ONTROL KNOB MUST BE IN THE
(OFF) position
&IGURE
LP: Connect LP gas tank per “Installing LP Gas
4ANKv SECTION
NG: Connect NG main line per “Installing Natural
'AS ,INEv SECTION
LP: 4URN ,0 GAS TANK VALVE TO h/0%.v
NG: 4URN h/.v NATURAL GAS MAIN VALVE
0USH AND TURN CONTROL KNOB SLOWLY TO
()'( UNTIL A CLICK IS HEARD 4HE BURNER SHOULD LIGHT
)F THE BURNER DOES NOT LIGHT REPEAT UP TO THREE TIMES
.OTE )NFRARED "URNER SHOULD TURN RED AFTER TO MINUTES
)F IGNITION DOES NOT OCCUR IN SECONDS TURN BURNER CONTROL KNOB
/&& WAIT MINUTES AND
REPEAT LIGHTING PROCEDURE
)F IGNITER DOES NOT LIGHT BURNER USE A LIT MATCH SECURED WITH THE LIGHTING ROD PROVIDED TO LIGHT
BURNER MANUALLY 0OSITION THE LIT MATCH NEAR SIDE OF THE BURNER &IGURE
Important: !LWAYS USE THE LIGHTING ROD PROVIDED WHEN LIGHTING BURNERS WITH A MATCH
CAUTION: If burner flame goes out during operation, immediately turn
the control knobs to the
(OFF) position
(a) LP gas tank valve “CLOSED” or
(b) NG main valve “OFF”
and open lid to let the gas clear for 5 minutes before re-lighting.
Turning Off
LP: 4URN ,0 GAS TANK VALVE TO h#,/3%$v
NG: 4URN h/&&v NATURAL GAS MAIN VALVE
4URN ALL CONTROL KNOBS CLOCKWISE TO THE
/&& POSITION
Note: ! hPOOFv SOUND IS NORMAL AS THE LAST OF THE GAS IS BURNED
LP: $ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
NG: +EEP MAIN GAS LINE CONNECTED
Tips for Better Cookouts and Longer Grill Life
&OR GREAT RECIPES AND TIPS VISIT RECIPESUNIFLAMECOM
&OR FOOD SAFETY TIPS VISIT HTTPWWWFSISUSDAGOV&ACT?3HEETS"ARBECUE?&OOD?3AFETY
5SE THE UPPER COOKING GRID WARMING RACK FOR KEEPING COOKED FOOD WARM TOASTING BREADS OR
COOKING DELICATE FOODS IN ALUMINUM FOIL POUCHES
5SE THE SIDE BURNER OF THIS APPLIANCE LIKE A NORMAL KITCHEN RANGE FOR BOILING SAUTÏING OR
FRYING
4O KEEP FOOD FROM STICKING TO THE GRIDS SPRAY OR COAT WITH COOKING OIL BEFORE LIGHTING
4O REDUCE FLAREUP KEEP GRILL CLEAN USE LEAN CUTS OF MEAT OR TRIM FAT AND AVOID COOKING ON
VERY HIGH TEMPERATURES
0LACE DELICATE FOODS LIKE FISH AND VEGETABLES IN ALUMINUM FOIL POUCHES AND INDIRECT COOK OR
PLACE ON UPPER COOKING LEVELS WARMING RACK
WARNING: Never cover entire cooking area with aluminum foil.
4O AVOID LOSING NATURAL JUICES USE LONG HANDLED TONGS OR SPATULAS INSTEAD OF FORKS AND TURN
FOODS OVER JUST ONCE DURING COOKING
7HEN DIRECT COOKING ADJUST YOUR BURNERS TO DIFFERENT LEVELS SO FOODS CAN BE PREPARED TO
DIFFERENT INTERNAL TEMPERATURES IN THE SAME TIME FRAME
7HEN INDIRECT COOKING ROASTS AND LARGER CUTS OF MEAT PLACE MEAT ONTO A ROASTING RACK
INSIDE A HEAVY GAUGE METAL PAN 0LACE PAN OVER THE UNLIT BURNERS
4RY WATER PANS TO REDUCE FLAREUPS AND COOK JUICER MEATS "EFORE STARTING GRILL REMOVE
COOKING GRIDS AND PLACE A HEAVY DUTY SHALLOW PAN DIRECTLY ON HEAT PLATES &ILL HALF WAY WITH
WATER FRUIT JUICES OR OTHER FLAVORED LIQUIDS 2EPLACE COOKING GRIDS AND POSITION FOOD OVER THE
LOADED PAN
)F IGNITION DOES NOT OCCUR IN SECONDS TURN BURNER CONTROL KNOB /&& WAIT MINUTES AND
REPEAT LIGHTING PROCEDURE
)F IGNITER DOES NOT LIGHT BURNER USE A LIT MATCH SECURED WITH THE LIGHTING ROD PROVIDED TO LIGHT
BURNER MANUALLY 0OSITION THE LIT MATCH NEAR SIDE OF THE BURNER &IGURE
Important: !LWAYS USE THE LIGHTING ROD PROVIDED WHEN LIGHTING BURNERS WITH A MATCH
CAUTION: If burner flame goes out during operation, immediately turn
the control knobs to the
(OFF) position
(a) LP gas tank valve “CLOSED” or
(b) NG main valve “OFF”
and open lid to let the gas clear for 5 minutes before re-lighting.
Turning Off
LP: 4URN ,0 GAS TANK VALVE TO h#,/3%$v
NG: 4URN h/&&v NATURAL GAS MAIN VALVE
4URN ALL CONTROL KNOBS CLOCKWISE TO THE
/&& POSITION
Note: ! hPOOFv SOUND IS NORMAL AS THE LAST OF THE GAS IS BURNED
LP: $ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
NG: +EEP MAIN GAS LINE CONNECTED
Operating Side Burner
NOTE: 3IDE BURNER CAN BE USED WHILE MAIN BURNERS ARE OPERATING
.EVER USE SIDE BURNER AS A GRILL
CAUTION: Maximum load for sideburner and side shelf is 33 lbs.
CAUTION: Using pots larger than 6 quarts in capacity could exceed
weight limit of the side burner shelf, resulting in failure of grill cart
components.
CAUTION: DO NOT lean on the side burner shelf.
Lighting
/PEN LID Attempting to light the burner with the
lid closed may cause an explosion!
-AKE SURE THERE ARE NO OBSTRUCTIONS OF AIRFLOW TO THE
BURNER 3PIDERS AND INSECTS CAN NEST WITHIN AND CLOG
THE BURNER VENTURI TUBE AT THE ORIFICE ! CLOGGED
BURNER TUBE CAN LEAD TO A FIRE BENEATH THE APPLIANCE
#ONTROL KNOB MUST BE IN THE
(OFF) position (Figure
LP: Connect LP gas tank per “Installing LP Gas
4ANKv SECTION
NG: Connect NG main line per “Installing Natural
'AS ,INEv SECTION
LP: 4URN ,0 GAS TANK VALVE TO h/0%.v
NG: 4URN h/.v NATURAL GAS MAIN VALVE
0USH AND TURN CONTROL KNOB SLOWLY TO
()'( UNTIL A CLICK IS HEARD 4HE BURNER SHOULD LIGHT
)F THE BURNER DOES NOT LIGHT REPEAT UP TO THREE TIMES
)F IGNITION DOES NOT OCCUR IN SECONDS TURN BURNER CONTROL KNOB
/&& WAIT MINUTES AND
REPEAT LIGHTING PROCEDURE
)F IGNITER DOES NOT LIGHT BURNER USE A LIT MATCH SECURED WITH THE LIGHTING ROD PROVIDED TO LIGHT
BURNER MANUALLY 0OSITION THE LIT MATCH NEAR SIDE OF THE BURNER &IGURE
Important: !LWAYS USE THE LIGHTING ROD PROVIDED WHEN LIGHTING BURNERS WITH A MATCH
!FTER LIGHTING OBSERVE THE BURNER FLAME MAKE SURE ALL BURNER PORTS ARE LIT AND FLAME HEIGHT
MATCHES ILLUSTRATION &IGURE
CAUTION: If burner flame goes out during operation, immediately turn
the control knobs to the
(OFF) position
(a) LP gas tank valve “CLOSED” or
(b) NG main valve “OFF”
and open lid to let the gas clear for 5 minutes before re-lighting.
Turning Off
LP: 4URN ,0 GAS TANK VALVE TO h#,/3%$v
NG: 4URN h/&&v NATURAL GAS MAIN VALVE
4URN ALL CONTROL KNOBS CLOCKWISE TO THE
/&& POSITION
Note: ! hPOOFv SOUND IS NORMAL AS THE LAST OF THE GAS IS BURNED
LP: $ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
NG: +EEP MAIN GAS LINE CONNECTED
Cooking
/PEN LID AND IGNITE THE SIDE BURNER PER h,IGHTING )NSTRUCTIONSv SECTION
!DJUST CONTROL KNOB TO DESIRED FLAME HEIGHT
0LACE PAN ON CENTER OF GRID
#OOK AND ADJUST TEMPERATURE AS NEEDED
4URN GRILL /&& PER h4URNING /FFv INSTRUCTIONS
Operating Instructions (continued)
&IGURE
&IGURE
Outdoor LP Gas Barbecue Grill Model No. GBC1273W / BH12-101-001-02
%NHANCE FOOD FLAVORS BY USING WOOD CHIPS IN SMOKER BOXES OR ALUMINUM FOIL POUCHES
&OLLOW THE WOOD MANUFACTURERS INSTRUCTIONS
2OTISSERIES GRILL BASKETS VERTICAL POULTRY HOLDERS AND OTHER ACCESSORIES CAN ENHANCE YOUR
EXPERIENCES REDUCE COOKING TIMES AND AID IN CLEANUP
#LEAN COOKING GRIDS AND RACKS AFTER EVERY USE WITH A QUALITY GRILL BUSH DESIGNED FOR YOUR
GRID MATERIAL 7EAR PROTECTIVE GLOVES AND GENTLY REMOVE THE BUILDUP WHILE GRIDS ARE HOT
!FTER EVERY USE ALLOW GRILL TO COOL 4HEN PROTECT CLEAN COOKING GRIDS WITH A LIGHT COAT OF
COOKING OIL EMPTY GREASE PAN WIPE OUTSIDE SURFACES WITH A SUITABLE KITCHEN CLEANER AND
PROTECT SURFACES WITH A QUALITY COVER THAT PROPERLY FITS YOUR GRILL
7ATCH BARBECUE THEMED 46 SHOWS OR PURCHASE RELATED BARBECUE COOKBOOKS TO LEARN MORE
interesting tips like –
A gas grill is ideal for reheating leftover pizza. Set burners on low and place pizza slices
directly on preheated cooking grid. Close lid and cook until cheese starts to bubble.
Operating Rotisserie
WARNING: When using electrical appliances, basic safety precautions
should always be used, including the following:
1. Always attach Rotisserie to grill first, then plug cord into a grounded outlet. To
disconnect, turn Rotisserie “OFF” then remove plug from outlet.
2. Most grill surfaces and accessories are hot during and after cooking. Use caution
around grill, wear flame retardant BBQ mitt.
3. Do not use accessory attachments on Rotisserie not suppied by the manufacturer. This
may cause injuries. Do not use this appliance for other than intended use.
4. Never cover bottom of your grill bowl with aluminum foil, sand or any grease
absorbent substance.
5. Should a grease fire occur, turn burners to (OFF) position,
(a) LP gas tank valve “CLOSED” or
(b) NG main valve “OFF”
leave lid CLOSED until fire is out.
6. To protect against electrical shock, do NOT immerse electrical cord, plug or motor in
water or expose to rain. Protect electrical elements from burners, hot grill surfaces
and grease.
7. Do NOT operate rotisserie with a damaged cord or plug, or if the rotisserie
malfunctions or has been damaged in any manner.
8. Do NOT let children operate grill or rotisserie, and do NOT let children play nearby.
9. Unplug rotisserie motor from electrical outlet when not in use and before cleaning.
Allow to cool before adding or removing parts.
10. When rotisserie cooking, place a drip pan of some sort under the food to be cooked.
This will capture the drippings and keep grill clean of excess grease which could
cause a fire. Use caution when moving a drip pan containing hot oils.
11. The motor is set for 120VAC, 50/60 Hz current.
12. This rotisserie is for use outdoors only and with this grill only.
CAUTION: If burner flame goes out during operation, immediately turn
the gas
(OFF) and open lid to let the gas clear for about 5 minutes
before re-lighting.
WARNING: Keep rotisserie motor electric cord away from the heated
surface of the grill.
WARNING: The rotisserie motor must be electrically grounded in
accordance with local codes or, in the absence of local codes, with the
National Electric Code, ANSI/NFPA 70-1990.
WARNING: Do NOT operate the
rotisserie with a damaged cord or plug,
or if the Rotisserie malfunctions or has
been damaged in any manner. Call our
Customer Care at 1.800.762.1142 for
replacement.
WARNING: The power supply cord has
a 3-prong grounded plug. For your
personal safety do not remove the
grounding prong. It must be plugged
into a mating 3-prong grounding type
receptacle, grounded in accordance
with the National Electrical Codes and
local codes and ordinances.
WARNING: If an extension cord is
used it must be properly grounded
and suitable for use with outdoor
appliances. Keep the extension cord
connection dry, off of the ground and
out of the reach of children.
WARNING: When rotisserie motor is not
in use remove and store in a dry indoor
area.
WARNING: OUTDOOR USE ONLY. DO NOT
EXPOSE TO RAIN.
CAUTION: Risk of Electric Shock. Keep
extension cord connection dry and off
the ground
WARNING: Use only on properly
grounded outlet.
Attaching Meat or Poultry
!TTACH ROTISSERIE MOTOR PER h!SSEMBLY )NSTRUCTIONS n
2OTISSERIEv INSTRUCTIONS
)NSERT AND SECURE ROTISSERIE COUNTERWEIGHT AND
ROTISSERIE HANDLE ONTO ROTISSERIE ROD &IGURE
)NSERT ONE ROTISSERIE FORK ONTO ROTISSERIE ROD
&IGURE
0USH ROTISSERIE ROD THROUGH THE MIDDLE OF THE FOOD
AND INSERT THE FOOD EVENLY INTO THE PRONGS OF THE
ROTISSERIE FORK &IGURE
#ENTER FOOD ON ROTISSERIE ROD 4IGHTEN ROTISSERIE FORK
)NSERT REMAINING ROTISSERIE FORK ONTO ROTISSERIE ROD
AND INSERT ROTISSERIE FORK PRONGS INTO FOOD 4IGHTEN
ROTISSERIE FORK &IGURE
)NSERT ROTISSERIE ROD INTO ROTISSERIE MOTOR AND PLACE
OTHER END OF ROTISSERIE ROD INTO GROVES ON BOTTOM
BOWL &IGURES AND
4URN ROTISSERIE MOTOR h/.v TO TEST FOOD PLACEMENT
.OTE (EAVY SIDE OF MEAT OR POULTRY SHOULD
ROTATE DOWN TOWARDS THE BOTTOM BOWL !DJUST
COUNTERWEIGHT IF NEEDED FOR A PROPER BALANCE )F MEAT OR POULTRY STILL DOES NOT ROTATE PROPERLY
REMOVE FOOD AND REMOUNT FOOD FOR A PROPER BALANCE
,IGHT GRILL PER h)NFRARED "ACK "URNERv LIGHTING INSTRUCTIONS
!FTER GRILL IS LIT AND TEMPERATURE IS SET KEEP LID CLOSED
Rotisserie Cooking Tips
-EATS EXCEPT FOR POULTRY AND GROUND MEATS SHOULD BE BROUGHT TO ROOM TEMPERATURE PRIOR TO
COOKING
5SE COOKING STRING TO TIE AROUND THE UNEVEN SHAPED MEAT OR POULTRY
0LACE A DISPOLABLE ALUMINUM DRIP PAN DIRECTLY UNDER THE FOOD AND ON TOP OF THE HEAT PLATES
&OOD PREPERATION STEPS ARE THE SAME FOR ROTISSERIE COOKING AS THEY ARE FOR REGULAR GRILLING
)F MEAT OR POLUTRY IS TOO LARGE OR DO NOT ROTATE PROPERLY ON THE ROTISSERIE THE MEAT SHOULD BE
REMOVED FROM THE ROTISSERIE AND INDIRECTLY COOK
Cleaning and Care
CAUTION:
1. All cleaning and maintenance should be done when grill is cool and
with the fuel supply disconnected.
2. DO NOT clean any grill part in a self cleaning oven. The extreme heat
will damage the finish.
3. Do not enlarge valve orifices or burner ports when cleaning the
valves or burners.
Notices
1. This grill should be thoroughly cleaned and
inspected on a regular basis.
2. Abrasive cleaners will damage this product.
3. Never use oven cleaner to clean any part of grill.
Before Each Use:
+EEP THE GRILL AREA CLEAN AND FREE FROM ANY
combustible materials, gasoline, and other
FLAMMABLE VAPORS AND LIQUIDS
$O NOT OBSTRUCT THE FLOW OF THE COMBUSTION OF ,0
AND THE VENTILATION AIR
+EEP THE VENTILATION OPENINGS OF THE ,0 GAS TANK
AREA FREE AND CLEAR FROM DEBRIS
6ISUALLY CHECK THE BURNER FLAMES TO MAKE SURE YOUR
GRILL IS WORKING PROPERLY &IGURE
3EE SECTIONS BELOW FOR PROPER CLEANING INSTRUCTIONS
#HECK AND CLEAN THE BURNERVENTURI TUBES FOR INSECTS
AND INSECT NESTS ! CLOGGED TUBE CAN LEAD TO A FIRE
BENEATH THE GRILL
Cleaning Surfaces
7IPE SURFACES CLEAN WITH MILD DISHWASHING
DETERGENT OR BAKING SODA MIXED WITH WATER
&OR STUBBORN SURFACES USE A CITRUS BASED DEGREASER
AND A NYLON SCRUBBING BRUSH
2INSE CLEAN WITH WATER
!LLOW TO AIR DRY
Operating Instructions (continued)
&IGURE
Burner Flame Conditions
Use this chart check to see if your
BURNERS NEED TO BE CLEANED
1-2 in. /
25.4 - 50.8 mm
1-2 in. /
25.4 - 50.8 mm
Normal: 3OFT BLUE FLAMES WITH
YELLOW TIPS BETWEEN IN IN
HIGHT
Needs Cleaning: .OISY WITH HARD
BLUE FLAMES
Has to be cleaned or replaced:
7AVY WITH YELLOW FLAMES
&IGURE
&IGURE
&IGURE
&IGURE
&IGURE
&IGURE
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com
PAGE NO
Limited Warranty
"LUE 2HINO 'LOBAL 3OURCING )NC h6ENDORv WARRANTS TO THE ORIGINAL RETAIL PURCHASER OF THIS
product, and to no other person, that if this product is assembled and operated in accordance
WITH THE PRINTED INSTRUCTIONS ACCOMPANYING IT THEN FOR A PERIOD OF ONE YEAR FROM THE DATE
OF PURCHASE ALL PARTS IN SUCH PRODUCT SHALL BE FREE FROM DEFECTS IN MATERIAL AND WORKMANSHIP
6ENDOR MAY REQUIRE REASONABLE PROOF OF YOUR DATE OF PURCHASE 4HEREFORE YOU SHOULD RETAIN
YOUR SALES SLIP OR INVOICE 4HIS ,IMITED 7ARRANTY SHALL BE LIMITED TO THE REPAIR OR REPLACEMENT OF
PARTS WHICH PROVE DEFECTIVE UNDER NORMAL USE AND SERVICE AND WHICH 6ENDOR SHALL DETERMINE
IN ITS REASONABLE DISCRETION UPON EXAMINATION TO BE DEFECTIVE "EFORE RETURNING ANY PARTS YOU
SHOULD CONTACT 6ENDORS #USTOMER 3ERVICE $EPARTMENT USING THE CONTACT INFORMATION LISTED
BELOW )F 6ENDOR CONlRMS AFTER EXAMINATION A DEFECT COVERED BY THIS ,IMITED 7ARRANTY IN ANY
RETURNED PART AND IF 6ENDOR APPROVES THE CLAIM 6ENDOR WILL REPLACE SUCH DEFECTIVE PART WITHOUT
CHARGE )F YOU RETURN DEFECTIVE PARTS TRANSPORTATION CHARGES MUST BE PREPAID BY YOU 6ENDOR WILL
RETURN REPLACEMENT PARTS TO THE ORIGINAL RETAIL PURCHASER FREIGHT OR POSTAGE PREPAID
4HIS ,IMITED 7ARRANTY DOES NOT COVER ANY FAILURES OR OPERATING DIFlCULTIES DUE TO ACCIDENT
abuse, misuse, alteration, misapplication, improper installation or improper maintenance or
SERVICE BY YOU OR ANY THIRD PARTY OR FAILURE TO PERFORM NORMAL AND ROUTINE MAINTENANCE ON
THE PRODUCT AS SET OUT IN THIS OWNERS MANUAL )N ADDITION THE ,IMITED 7ARRANTY DOES NOT COVER
DAMAGE TO THE lNISH SUCH AS SCRATCHES DENTS DISCOLORATION RUST OR OTHER WEATHER DAMAGE
AFTER PURCHASE
4HIS ,IMITED 7ARRANTY IS IN LIEU OF ALL OTHER EXPRESS WARRANTIES 6ENDOR DISCLAIMS ALL WARRANTIES
for products that are purchased from sellers other than authorized retailers or distributors,
INCLUDING THE WARRANTY OF MERCHANTABILITY OR THE WARRANTY OF lTNESS FOR A PARTICULAR PURPOSE
6%.$/2 !,3/ $)3#,!)-3 !.9 !.$ !,, )-0,)%$ 7!22!.4)%3 ).#,5$).' 7)4(/54
,)-)4!4)/. 4(% )-0,)%$ 7!22!.4)%3 /& -%2#(!.4!"),)49 !.$ &)4.%33 &/2 ! 0!24)#5,!2
0520/3% 6%.$/2 3(!,, (!6% ./ ,)!"),)49 4/ 052#(!3%2 /2 !.9 4()2$ 0!249 &/2 !.9
30%#)!, ).$)2%#4 05.)4)6% ).#)$%.4!, /2 #/.3%15%.4)!, $!-!'%3 6ENDOR FURTHER
DISCLAIMS ANY IMPLIED OR EXPRESS WARRANTY OF AND ASSUMES NO RESPONSIBILITY FOR DEFECTS IN
WORKMANSHIP CAUSED BY THIRD PARTIES
4HIS ,IMITED 7ARRANTY GIVES THE PURCHASER SPECIlC LEGAL RIGHTS A PURCHASER MAY HAVE OTHER
RIGHTS DEPENDING UPON WHERE HE OR SHE LIVES 3OME JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR
LIMITATION OF SPECIAL INCIDENTAL OR CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW LONG A WARRANTY
LASTS SO THE ABOVE EXCLUSION AND LIMITATIONS MAY NOT APPLY TO EVERYONE
Vendor does not authorize any person or company to assume for it any other obligation or
LIABILITY IN CONNECTION WITH THE SALE INSTALLATION USE REMOVAL RETURN OR REPLACEMENT OF ITS
EQUIPMENT AND NO SUCH REPRESENTATIONS ARE BINDING ON 6ENDOR
Blue Rhino Global Sourcing, Inc
7INSTON3ALEM .ORTH #AROLINA 53!
Cleaning Main Burners
LP: Turn control knobs to /&& POSITION AND ,0 GAS TANK VALVE TO h#,/3%$v
NG: Turn control knobs to
/&& POSITION AND .' VALVE TO h/&&v
LP: $ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
NG: $ISCONNECT MAIN GAS LINE PER h$ISCONNECT .ATURAL 'AS ,INEv INSTRUCTIONS
2EMOVE COOKING GRIDS AND HEAT PLATES
2EMOVE BURNERS BY REMOVING THE FASTENERS SECURING THE BURNERS TO THE GRILL BOTTOM
,IFT BURNERS UP AND AWAY FROM GAS VALVE ORIFICE
$ISCONNECT WIRE FROM SPARK ELECTRODE
#LEAN INLET VENTURI OF EACH BURNER WITH SMALL BOTTLE BRUSH OR COMPRESSED AIR
2EMOVE ALL FOOD RESIDUE AND DIRT ON BURNER SURFACES
#LEAN ANY CLOGGED PORTS WITH A STIFF WIRE SUCH AS AN OPENED PAPER CLIP
)NSPECT BURNERS FOR ANY DAMAGE CRACKS OR HOLES )F DAMAGE IS FOUND REPLACE WITH NEW
BURNERS FROM MANUFACTURER
2EINSTALL BURNERS CHECKING TO INSURE THAT GAS VALVE ORIFICE IS CORRECTLY POSITIONED INSIDE
EACH BURNER INLET VENTURI !LSO CHECK POSITION OF SPARK ELECTRODE
2EPLACE HEAT PLATES AND COOKING GRIDS
LP: #ONNECT ,0 GAS TANK PER h)NSTALLING ,0 'AS 4ANKv SECTION
NG: #ONNECT ,0 GAS TANK PER h)NSTALLING .ATURAL 'AS ,INEv SECTION
0ERFORM LEAK TEST 3EE h#HECKING FOR ,EAKSv
Cleaning Side Burner
LP: Turn control knobs to /&& POSITION AND ,0 GAS TANK VALVE TO h#,/3%$v
NG: Turn control knobs to
/&& POSITION AND .' VALVE TO h/&&v
LP: $ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
NG: $ISCONNECT MAIN GAS LINE PER h$ISCONNECT .ATURAL 'AS ,INEv INSTRUCTIONS
2EMOVE SIDE BURNER GRID
2EMOVE BURNER BY REMOVING THE SCREWS SECURING THE BURNER TO THE SIDE SHELF
,IFT BURNER UP AND AWAY FROM GAS VALVE ORIFICE
#LEAN INLET VENTURI OF BURNER WITH SMALL BOTTLE BRUSH OR COMPRESSED AIR
2EMOVE ALL FOOD RESIDUE AND DIRT ON BURNER SURFACE
#LEAN ANY CLOGGED PORTS WITH A STIFF WIRE SUCH AS AN OPENED PAPER CLIP
)NSPECT BURNER FOR ANY DAMAGE CRACKS OR HOLES )F DAMAGE IS FOUND REPLACE WITH NEW BURNER
FROM MANUFACTURER
2EINSTALL BURNER CHECK TO INSURE THAT GAS VALVE ORIFICE IS CORRECTLY POSITIONED INSIDE BURNER
INLET VENTURI !LSO CHECK POSITION OF SPARK ELECTRODE
2EPLACE COOKING GRID
LP: #ONNECT ,0 GAS TANK PER h)NSTALLING ,0 'AS 4ANKv SECTION
NG: #ONNECT ,0 GAS TANK PER h)NSTALLING .ATURAL 'AS ,INEv SECTION
0ERFORM LEAK TEST 3EE h#HECKING FOR ,EAKSv
Before Storing
LP: Turn control knobs to /&& POSITION AND ,0 GAS TANK VALVE TO h#,/3%$v
NG: Turn control knobs to
/&& POSITION AND .' VALVE TO h/&&v
LP: $ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
NG: $ISCONNECT MAIN GAS LINE PER h$ISCONNECT .ATURAL 'AS ,INEv INSTRUCTIONS
#LEAN ALL SURFACES
,IGHTLY COAT THE BURNERS WITH COOKING OIL TO PREVENT EXCESS RUSTING
)F STORING THE GRILL OUTDOORS COVER THE GRILL WITH A GRILL COVER FOR PROTECTION FROM THE WEATHER
Product Registration
&OR FASTER WARRANTY SERVICE REGISTER YOUR PRODUCT IMMEDIATELY AT WWWBLUERHINOCOM OR CALL
Cleaning and Care (continued)
Outdoor LP Gas Barbecue Grill Model No. GBC1273W / BH12-101-001-02
Troubleshooting
Problem Possible Cause Prevention/Cure
Burner will not light using ignitor
,0 GAS TANK VALVE IS CLOSED
.' MAIN VALVE IS CLOSED
LP: Make sure regulator is securely attached to the LP gas tank, turn LP gas
TANK VALVE TO h/0%.v
NG: Make sure regultor and NG main line are securely attached, turn NG main
VALVE TO h/0%.v
,0 GAS TANK IS LOW OR EMPTY Replace or refill LP gas tank
LP gas / NG leak
4URN ,0 GAS TANK .' MAIN VALVE TO h#,/3%$v
7AIT MINUTES FOR GAS TO CLEAR
&OLLOW h#HECKING FOR ,EAKSv IN THE OWNERS MANUAL
Battery needs to be changed 2EPLACE THE h!!v BATTERY FOLLOW ASSEMBLY STEP FOR INSERTING BATTERY
7IRES OR ELECTRODE COVERED WITH COOKING RESIDUE #LEAN WIRE ANDOR ELECTRODE WITH RUBBING ALCOHOL
%LECTRODE AND BURNERS ARE WET 7IPE DRY WITH CLOTH
Electrode cracked or broken - sparks at crack Replace electrode
Wire loose or disconnected 2ECONNECT WIRE OR REPLACE ELECTRODEWIRE ASSEMBLY
7IRE IS SHORTING SPARKING BETWEEN IGNITOR AND ELECTRODE 2EPLACE IGNITOR WIREELECTRODE ASSEMBLY
Bad ignitor Replace ignitor
Burner will not light with match
.O GAS FLOW
LP: Check if LP gas tank is empty
! )F EMPTY REPLACE OR RElLL
" )F ,0 GAS TANK IS NOT EMPTY REFER TO h3UDDEN DROP IN GAS mOW OR REDUCED
mAME HEIGHTv
.' #HECK IF .' MAIN VALVE IS CONNECTED
! Make sure regultor and NG main line are securely attached, turn NG main
VALVE TO h/0%.v
" )F .' MAIN VALVE IS h/0%.v REFER TO h3UDDEN DROP IN GAS mOW OR REDUCED
mAME HEIGHTv
,0 GAS TANK IS LOW OR EMPTY Replace or refill LP gas tank
LP gas / NG leak
4URN ,0 GAS TANK .' MAIN VALVE TO h#,/3%$v
7AIT MINUTES FOR GAS TO CLEAR
&OLLOW h#HECKING FOR ,EAKSv IN THE OWNERS MANUAL
Coupling nut and regulator not fully connected
Turning the coupling nut about one-half to three quarters additional turn until
SOLID STOP Tighten by hand only-do not use tools.
/BSTRUCTION OF GAS FLOW
#LEAR BURNER TUBES
#HECK FOR BENT OR KINKED HOSE
$ISENGAGEMENT OF BURNER TO VALVE 2EENGAGE BURNER AND VALVE
3PIDER WEBS OR INSECT NEST IN VENTURI #LEAN VENTURI AND BURNER TUBE
Burner ports clogged or blocked Clean burner ports
Sudden drop in gas flow or reduced flame height
LP: Out of gas Replace or refill LP gas tank
NG: No main line pressure #ALL YOUR .ATURAL 'AS PROVIDER TO INSPECT .ATURAL 'AS ,INE
,0 %XCESS FLOW SAFETY DEVICE MAY HAVE BEEN ACTIVATED
4URN CONTROL KNOBS TO
(OFF)
7AIT SECONDS AND LIGHT GRILL
)F mAMES ARE STILL TOO LOW RESET THE EXCESSIVE mOW SAFETY DEVICE
A 4URN CONTROL KNOBS
(OFF)
B 4URN ,0 GAS TANK VALVE TO h#,/3%$v
C $ISCONNECT REGULATOR
D 4URN CONTROL KNOBS TO
(HIGH)
E 7AIT MINUTE
F 4URN CONTROL KNOBS TO
(OFF)
G 2ECONNECT REGULATOR AND LEAK CHECK CONNECTIONS
H ,IGHT GRILL PER h,IGHTING )NSTRUCTIONSv
Irregular flame pattern, flame does not run the
full length of burner
Burner ports are clogged or blocked Clean burner ports
Flame is yellow or orange
.EW BURNER MAY HAVE RESIDUAL MANUFACTURING OILS
"URN GRILL FOR MINUTES ON
()'( WITH THE LID CLOSED
3PIDER WEBS OR INSECT NEST IN VENTURI #LEAN VENTURI
&OOD RESIDUE GREASE ETC Clean burner
0OOR ALIGNMENT OF VALVE TO BURNER VENTURI !SSURE BURNER VENTURI IS PROPERLY ENGAGED WITH VALVE
Flame blow out
(IGH OR GUSTING WINDS $O NOT USE GRILL IN HIGH WINDS
,OW ON ,0 'AS Replace or refill LP gas tank
%XCESS FLOW VALVE TRIPPED 2EFER TO h3UDDEN DROP IN GAS FLOW OR REDUCED FLAME HEIGHTv
Flare-up
Grease buildup
2EMOVE AND CLEAN ALL GRILL PARTS PER h#LEANING AND #AREv INSTRUCTIONS IN THE
OWNERS MANUAL
Excess fat in meat Trim fat from meat before grilling
%XCESSIVE COOKING TEMPERATURE !DJUST LOWER COOKING TEMPERATURE
Persistent grease fire
Grease trapped by food buildup around burner system
4URN CONTROL KNOBS TO
(OFF)
4URN ,0 GAS TANK VALVE .' MAIN VALVE TO h#,/3%$v
,EAVE LID IN CLOSED POSITION AND LET lRE BURN OUT
!FTER GRILL COOLS REMOVE AND CLEAN ALL PARTS PER h#LEANING AND #AREv
INSTRUCTIONS IN THE OWNERS MANUAL
Flashback (fire in burner tube(s))
Burner and/or burner tubes are blocked Clean burners and/or burner tubes
Inside of lid is peeling (like paint peeling)
The lid is stainless steel, not painted
Baked on grease buildup has turned to carbon and is flaking off, clean
THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL
The lid is coated/painted
s 4HIS CAN BE FROM BAKED ON GREASE BUILDUP THAT HAS TURNED INTO CARBON AND IS
flaking off
s #LEAN THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL
s !FTER CLEANING IF YOU CAN SEE STEEL PLEASE CALL #USTOMER #ARE AT
For more assistance please visit us online at www.bluerhino.com or call 1.800.762.1142.
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com
PAGE NO
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Si necesita ayuda llame al 1.800.762.1142. No vuelva al lugar de compra.
Para obtener excelentes recetas y sugerencias, visite recipes.uniflame.com
página
Resolución de problemas
Problema Causa posible Prevención/solución
El quemador no se enciende utilizando el
encendedor.
,A VÉLVULA DEL TANQUE DE GAS PROPANO ESTÉ CERRADA
,A VÉLVULA DE LA LÓNEA PRINCIPAL DE GAS NATURAL ESTÉ
cerrada
02/0!./ ,0 !SEGÞRESE DE QUE EL REGULADOR ESTÏ CONECTADO DE MANERA SEGURA
EN EL TANQUE DE GAS PROPANO GIRE LA VÉLVULA DEL TANQUE DE GAS PROPANO A LA
POSICIØN h/0%.v ABIERTA
'!3 .!452!, '. !SEGÞRESE DE QUE EL REGULADOR ESTÏ CONECTADO DE MANERA
SEGURA EN LA LÓNEA PRINCIPAL DE GAS NATURAL GIRE LA VÉLVULA DE LA LÓNEA PRINCIPAL DE
GAS NATURAL A LA POSICIØN h/0%.v ABIERTA
%L TANQUE DE GAS PROPANO ESTÉ BAJO O VACÓO 2EEMPLACE O VUELVA A LLENAR EL TANQUE DE GAS PROPANO
&UGA DE GAS PROPANO &UGA DE GAZ NATURAL
'IRE LA VÉLVULA DEL TANQUE DE GAS PROPANO O DE LA LÓNEA PRINCIPAL DE GAS NATURAL A
la posición “CLOSED” (cerrada)
%SPERE MINUTOS PARA QUE SE DISPERSE EL GAS
3IGA LAS INDICACIONES DE h)NSPECCIØN DE FUGASv DESCRITAS EN EL MANUAL DEL USUARIO
3E DEBE REEMPLAZAR LA PILA
2EEMPLACE LA PILA !! VEA EL PASO DE INSTALACIØN DE LA PILA DE LAS INSTRUCCIONES DE
armado)
#ABLES O ELECTRODOS CUBIERTOS CON RESTOS DE ALIMENTOS ,IMPIE EL CABLE YO ELECTRODO CON ALCOHOL ISOPROPÓLICO
,OS ELECTRODOS Y LOS QUEMADORES ESTÉN MOJADOS 3ÏQUELO CON UN PA×O
%LECTRODO AGRIETADO O ROTO CHISPAS EN LAS GRIETAS 3USTITUYA EL ELECTRODO
#ABLE SUELTO O DESCONECTADO 6UELVA A CONECTAR EL CABLE O SUSTITUYA EL CONJUNTO ELECTRODOCABLE
El cable tiene un cortocircuito (chispeo) entre el encendedor
Y EL ELECTRODO
2EEMPLACE EL CONJUNTO CABLE DEL ENCENDEDORELECTRODO
%NCENDEDOR DEFECTUOSO 2EEMPLACE EL ENCENDEDOR
El quemador no se enciende con una cerilla.
.O HAY FLUJO DE GAS
02/0!./ ,0 #OMPRUEBE SI EL TANQUE DE PROPANO LÓQUIDO ESTÉ VACÓO
! 3I ESTÉ VACÓO REEMPLÉCELO O VUELVA A LLENARLO
" 3I EL TANQUE DE PROPANO LÓQUIDO NO ESTÉ VACÓO CONSULTE LA SECCIØN h#AÓDA
REPENTINA DEL mUJO DE GAS O ALTURA DE LLAMA INSUlCIENTEv DE ESTA PÉGINA
'!3 .!452!, '. #OMPRUEBE SI LA LÓNEA PRINCIPAL DE GAS NATURAL ESTÉ CONECTADA
! !SEGÞRESE DE QUE EL REGULADOR Y LA LÓNEA PRINCIPAL DE GAS NATURAL ESTÏN
CONECTADOS DE MANERA SEGURA GIRE LA VÉLVULA DE LA LÓNEA PRINCIPAL DE GAS
NATURAL A LA POSICIØN h/0%.v ABIERTO
" 3I LA VÉLVULA DE LA LÓNEA PRINCIPAL DE GAS NATURAL ESTÉ ABIERTA /0%. CONSULTE LA
SECCIØN h#AÓDA REPENTINA DEL mUJO DE GAS O ALTURA DE LLAMA INSUlCIENTEv DE ESTA
PÉGINA
%L TANQUE DE GAS PROPANO ESTÉ BAJO O VACÓO 2EEMPLACE O VUELVA A LLENAR EL TANQUE DE GAS PROPANO
&UGA DE GAS PROPANO &UGA DE GAS NATURAL
'IRE LA VÉLVULA DEL TANQUE DE GAS PROPANO O DE LA LÓNEA PRINCIPAL DE GAS NATURAL A
la posición “CLOSED” (cerrada)
%SPERE MINUTOS PARA QUE SE DISPERSE EL GAS
3IGA LAS INDICACIONES DE h)NSPECCIØN DE FUGASv DESCRITAS EN EL MANUAL DEL USUARIO
,A TUERCA DE ACOPLAMIENTO NO ESTÉ CONECTADA POR COMPLETO
'IRE LA TUERCA DE ACOPLAMIENTO ENTRE MEDIA VUELTA Y TRES CUARTOS DE VUELTA HASTA
QUE HAGA TOPE CON FIRMEZA Apriete únicamente a mano, sin utilizar ninguna
herramienta.
/BSTRUCCIØN DEL FLUJO DE GAS ,IMPIE LOS TUBOS DEL QUEMADOR 6ERIFIQUE QUE LA MANGUERA NO ESTÏ TORCIDA O DOBLADA
$ESACOPLAMIENTO DEL QUEMADOR A LA VÉLVULA 6UELVA A CONECTAR EL QUEMADOR Y LA VÉLVULA
4ELARA×AS O NIDOS DE INSECTOS EN EL VENTURI ,IMPIE EL TUBO DE VENTURI
"OCAS DEL QUEMADOR ATASCADAS U OBSTRUIDAS ,IMPIE LAS BOCAS DEL QUEMADOR
Caída repentina del flujo de gas o altura de la llama
insuficiente.
02/0!./ ,0 3IN GAS
2EEMPLACE EL TANQUE O VUELVA A LLENARLO
'!3 .!452!, '. .O HAY PRESIØN EN LA LÓNEA PRINCIPAL ,LAME AL PROVEEDOR DE GAS NATURAL PARA QUE INSPECCIONE LA LÓNEA DE GAS NATURAL
&LUJO EXCESIVO PUEDE QUE SE HAYA ACTIVADO EL DISPOSITIVO DE
SEGURIDAD DE EXCESO DE FLUJO
'IRE LAS PERILLAS DE CONTROL A LA POSICIØN
(apagado)
%SPERE SEGUNDOS Y ENCIENDA LA PARRILLA
3I LAS LLAMAS CONTINÞAN SIENDO DEMASIADO BAJAS REINICIE EL DISPOSITIVO DE
SEGURIDAD DE mUJO EXCESIVO
A 'IRE LAS PERILLAS A LA POSICIØN
APAGADO
B #IERRE EL GAS GIRANDO LA VÉLVULA DEL TANQUE DE PROPANO LÓQUIDO A LA POSICIØN
h#,/3%$v CERRADO
C $ESCONECTE EL REGULADOR
D 'IRE LAS PERILLAS DE CONTROL A LA POSICIØN
ALTO
E %SPERE MINUTO
F 'IRE LAS PERILLAS DE CONTROL A LA POSICIØN
APAGADO
G 6UELVA A CONECTAR EL REGULADOR Y VERIlQUE LAS CONEXIONES PARA AVERIGUAR QUE NO
HAYA FUGAS
H %NCIENDA LA PARRILLA CONFORME A LAS INSTRUCCIONES DE ENCENDIDO
Falta de uniformidad en la llama, la llama no cubre
toda la longitud del quemador.
,AS BOCAS DEL QUEMADOR ESTÉN ATASCADAS U OBSTRUIDAS ,IMPIE LAS BOCAS DEL QUEMADOR
La llama es de color amarillo o naranja.
0UEDE QUE EL NUEVO QUEMADOR TENGA ACEITES RESIDUALES DEL
PROCESO DE FABRICACIØN
(AGA FUNCIONAR LA PARRILLA DURANTE MINUTOS CON LA TAPA CERRADA
4ELARA×AS O NIDOS DE INSECTOS EN EL VENTURI ,IMPIE EL VENTURI
Restos de alimentos, grasa o sal para condimentar en el
QUEMADOR
,IMPIE EL QUEMADOR
!LINEACIØN INCORRECTA ENTRE LA VÉLVULA Y EL QUEMADOR DE
VENTURI
!SEGÞRESE DE QUE EL QUEMADOR VENTURI ESTÉ CONECTADO ADECUADAMENTE A LA VÉLVULA
La llama se apaga.
6IENTOS FUERTES O RACHEADOS .O USE LA PARRILLA CUANDO HAY VIENTOS FUERTES
.IVEL DE GAS DEL TANQUE DE PROPANO BAJO 2EEMPLACE EL TANQUE O VUELVA A LLENARLO
6ÉLVULA DE EXCESO DE FLUJO OBSTRUIDA
#ONSULTE LA SECCIØN h#AÓDA REPENTINA DEL FLUJO DE GAS O ALTURA DE LLAMA INSUFICIENTEv
DE ESTA PÉGINA
Fogonazo.
&ORMACIONES DE GRASA ,IMPIE LA PARRILLA
#ARNE CON EXCESO DE GRASA 2ETIRE LA GRASA DE LA CARNE ANTES DE PONERLA EN LA PARRILLA
3I ESTÉ UTILIZANDO UNA TEMPERATURA EXCESIVA PARA COCINAR !JUSTE BAJE LA TEMPERATURA SEGÞN CORRESPONDA
Page is loading ...
Page is loading ...
/
