FLIR Assistant 2 (Enterprise Series) User manual

Brand: FLIR

Model: Assistant 2 (Enterprise Series)

Type: User manual

Maintenance Guide

Matrice 200 Series

Toensureightsafetyandoptimalperformance,performingcomprehensiveandregularmaintenanceisrecommended.This

manualisintendedtohelpusersmaintaintheiraircraftaswellaspossibleandmaximizereliability.Pleasenotethatthemost

effectivewaytoextendthelongevityofyouraircraftistoinspectyouraircraftbeforeandaftereachighttocheckforlodged

objectsanddamagedpartsandarrangerepairifnecessary.

Werecommendconductingapreandproightchecklisteachtimeyouusetheaircraftasoutlinedbelow.

2017.12

V1.0

I. Pre-Flight Checklist

1. Checkthemotorstoconrmthattheyarerotatingsmoothly.

2. Checkthepropellerstoconrmthattheyhavenotcomeloose.

3. Checkthearmconnectorstoconrmthattheyaremountedrmly.

4. Ensurethatthegimbalisrotatingsmoothly.

5. Ensurethatthelandinggearsaremounted rmly andcheckthepinstoconrm that

theyareinsertedfullyandtightly.(Fig.1)

6. EnsurethattheSDcardcoverandtherearcoverareclosedtightly.

7. Whenmountinganupwardgimbal,ensurethegimbalcablesaretiedproperlytoavoid

affectingthepropellers.

8. AnexternalGPSmoduleisrequiredwhentheupwardgimbalisused.EnsuretheGPS

cableisconnectedtotherearportandthecableistiedproperly.(Fig.2)

9. WhenusingtheM210RTK,checkthattheRTKantennascrewshavebeentightened.

(Fig.3)

II. Post-Flight Checklist

Check below parts to avoid damage from water intrusion:

1. IntelligentFlight Batteries:Checkthattheconnectorsbetween the batteriesand

aircraftaredry.Drytheaircraftandbatterieswithatowelbeforestorage.

2. FPVcamera:Checkthatthecameraisdry,especiallyalong the rollaxiswherethe

camerameetsthegimbalframe.

3. Aircraftarms:Ensurethatthearmsand arm locksaredrybeforeunlockingand

folding.

4. RearaircraftportwherepairbuttonandUSBportarehoused:Keepdryandclosed

whileying.Ensurethisareaisdrybeforestorage.

5. Downwardgimbalconnector:Keepdry,avoid disconnecting acameraandleaving

thegimbalconnectorexposedintherainorotherwet-weatherconditions.

6. Keepthegimbalandcameraawayfromsandandwater,and wipe them downif

they’vebeenexposedtosandorwater.

Check below parts to avoid damage from sand intrusion:

1. Aircraftarms:Incaseswheresmallobjectslikesandbecomelodgedintheconnector

orarm,useacompressedairdustertoremovetheseobjects.

2. FPVcamera:Checkthatthecamerarotatessmoothlyalongeach axis. Thecamera

willjudderifobjectsarelodgedinside.

3. Motors:Detachthepropellersandstartthemotors.Listencarefullytoseeifthereis

anyabnormalnoise,pleasereplacethemotors.

4. Speakerport:keepitclean.

Fig.2

Fig.3

Fig.1

Thecontentissubjecttochange.

Download the latest version from

https://www.dji.com/matrice-200-series

Support Center Contact Info:

http://www.dji.com/support

Checking for worn and loose parts:

1. Checkthatthegimbalprotectioncableisproperlyaffixed to thegimbalframe.

Replaceitwitha0.5mmshinglineifitisdamaged.(Fig.4)

2. Checkthatthelanding gear lockscrewistightenedproperly,and ensure thatthe

landinggearrmlylockswhenconnectedtothedrone.(Fig.5)

3. Checkthatthebatteryreleasebuttonisworkingnormally,andthebatterycanbe

mountedrmly.

4. Checkthepropellerbasescrewsaretightened.Ensurethespringelasticityis good

andnoforeignobjectsarestuckinthespring.

5. Ensurethattheframearmconnectorsarerotatingsmoothly.

6. Keeptheupwardinfraredsensorlenscleanandavoidwearandtear.

7. Checkthefollowingpartsforsignsofwearing:propellers,landinggearsandmotors.

Ifthesepartsseemwornordamaged,pleasecontactyourresellertoscheduleparts

replacements.

8. Landing gears:Checkthedrawnlineonthelandinggearwhenmounted to ensure

ithasbeeninstalled.Todeterminewhetherthe landing gearisproperlymounted,

rmlypulloutthelandinggear.Iftheattemptfails,thisindicatesithasbeenproperly

mounted.

9. Keepthevisionsystemcameralensescleanandavoidscratchingthem.

10. Checkthebatterybuttonisfunctioningnormally.DONOTpressthebuttonwithsharp

objects.

11. Checkthebatterylightwaterproofcoversandmakesurethecovershavenosignsof

comingoff.

12. ChecktheexternalGPScableandconnectortoavoiddamage.

13. Checkthegimbaldampenerstoavoidaging,cracking,orleaking.(Fig.6)

IV. Storage Tips

1. Avoidlayingthedroneonthebatterycompartment,asthiswillcausedamagetothe

visionpositioningsystem.

2. Besuretostoreyourbatteriesinadryplace.

3. DetachtheupwardsinglegimbalandtheGPSmoduleforstorage.

V. Updating Apps and Firmware

Makesureyouareusingthe latest firmwareandappswhenflyingyour M200 Series

drone:

1. Checkthelatestrmwareversioninthereleasenotes:

https://www.dji.com/matrice-200-series/info#downloads

2. DJIPilotappdownloadlink:

http://dl.djicdn.com/djipilot-ofcial.apk

Fig.4

Fig.5

Fig.6

MATRICE is a trademark of DJI.

Printed in China.

FLIR Assistant 2 (Enterprise Series) User manual

FLIR Assistant 2 (Enterprise Series) User manual

FLIR Assistant 2 (Enterprise Series) User manual

Other documents