Pilote G650C 2018 User manual

Brand: Pilote

Model: G650C 2018

Type: User manual

USER MANUAL - 2018 COLLECTION

Standard motorhome conﬁ guration

The pictograms and di erent areas shown on this basic diagram

do not necessarily reﬂ ect the layout of your motorhome.

Baggage

compartment

230 V connection Water heater

draining

Fresh water inlet Fuel ﬁ ller cap

Garage space Wastewater tank Cassette toilet Control panel Battery

unit

Fire extinguisher

(depending on country)

Gas

compartment

Despite being the exclusive property of Pilote Group, the photographs and illustrations published here

are not contractual. Pilote reserves the right to modify, add or remove components or technical

characteristics at any time, without notice, for the sole purpose of improving the quality of its products.

Despite the care taken in preparing it, this catalogue is not a contractual document.

1 - Welcome

1.1 Welcome aboard! ......................................................5

1.2 How to use this manual ............................................5

1.3 Legal framework ........................................................7

1.3.1 Regulations .............................................................7

1.3.2 Warranty .................................................................. 7

1.4 Motorhome manners ............................................... 8

1.4.1 General principles .................................................8

1.4.2 Parking .....................................................................8

1.4.3 Waste........................................................................9

2 - Discover your motorhome

2.1 The base .................................................................... 10

2.1.1 The chassis ...........................................................10

2.1.2 The wheels ...........................................................10

2.1.3 The accessories ..................................................10

2.2 The living area ..........................................................11

2.2.1 Hatches, openings and valves ......................... 11

2.2.2 Boots and storage compartments ................ 11

2.2.3 Interior layout ...................................................... 11

2.3 Basic ﬂuid diagrams ................................................12

2.3.1 Water system .......................................................12

2.3.2 Electrical system .................................................13

2.3.3 Gas ........................................................................17

2.3.4 Ventilation, heating system .............................. 18

2.4 Safety ........................................................................ 19

2.4.1 Fire ..........................................................................19

2.4.2 Gas .........................................................................19

2.4.3 Electrical system ................................................ 20

2.4.4 Emergency exits ................................................ 20

3 - Preparing to travel

3.1

Servicing after a an extended stationary period

.... 23

3.1.1 Drinking water ..................................................... 23

3.1.2 Refrigerator.......................................................... 23

3.2 Fill up and levels ...................................................... 23

3.2.1 Fuel ........................................................................ 23

3.2.2 Tyre pressure ...................................................... 23

3.2.3 Drinking water .................................................... 24

3.2.4 Gas ........................................................................ 24

3.2.5 Battery .................................................................. 25

3.3 Practical and emergency equipment .................. 25

3.3.1 Bulbs ...................................................................... 25

3.4 Load ........................................................................... 26

3.4.1 Technical speciﬁcations ................................... 26

3.4.2 Calculating loads ................................................27

3.4.3 Storing baggage ..................................................27

3.4.4 Trailer..................................................................... 28

4 - Travelling

4.1 Safety checks before departure ........................... 30

4.2 Adjustments ..............................................................31

4.3 Driving........................................................................31

4.4 Authorised seats.......................................................31

5 - Stops and parking

5.1 Choosing a spot ...................................................... 33

5.2 Safety when stationary .......................................... 33

5.3 Supply systems ........................................................ 33

5.3.1 Turning on the water ........................................ 33

5.3.2 Turning on the gas ............................................ 34

5.3.3 230 V power system ......................................... 34

5.4 Draining .................................................................... 35

5.4.1 Wastewater .......................................................... 35

5.4.2 WC ......................................................................... 35

5.5 Insulation .................................................................. 35

5.6 Locking ..................................................................... 35

6 - Using the equipment

6.1 Openings .................................................................. 36

6.1.1 Windows ............................................................. 36

6.1.2 Rooﬂight .............................................................. 39

6.2 Kitchen ......................................................................40

6.2.1 Sink ........................................................................ 40

6.2.2 Extractor hood (optional) ................................. 41

6.2.3 Gas-powered appliances .................................41

6.3 Table ......................................................................... 45

6.3.1 Table attached to vehicle side ........................ 45

6.3.2 Central table with ﬁxed base .......................... 46

6.3.3 Table with folding extension ...........................47

6.3.4 Table with retracting extension ......................47

6.4 Television ..................................................................48

6.5 Car radio, car radio DVD player and GPS ...........48

6.6 Reverse camera .......................................................49

6.7 Bathroom .................................................................50

6.7.1 Shower and washbasin ..................................... 50

6.7.2 WC ......................................................................... 50

6.8 Sleeping area ........................................................... 50

6.8.1 The coachbuilt area .......................................... 50

6.8.2 Dinette sleeping area ........................................51

6.8.2 Pull-down bed ................................................... 52

7 - Maintenance and winterisation

7.1 Gas installation ........................................................ 57

7.2 Maintenance of the interior .................................. 57

7.2.1 Cab..........................................................................57

7.2.2 Cushions, mattresses, curtains........................57

7.2.3 Maintenance of the windows ..........................57

7.2.4 Furniture ............................................................... 58

7.2.5 Bathroom ﬁxtures .............................................. 59

7.2.6 Cooking appliances .......................................... 59

7.2.7 Refrigerator ....................................................... 59

7.2.8 Water heater ....................................................... 59

7.2.9 Control panel ...................................................... 59

7.3 Cleaning the exterior .............................................. 59

7.3.1 Washing the bodywork ..................................... 59

7.3.2 Tar ..........................................................................60

7.3.3 Small scratches ..................................................60

7.4 Winterisation or long stops ................................... 61

7.4.1 Batteries .................................................................61

7.4.2 Water ..................................................................... 63

7.4.3 Turning o the refrigerator .............................. 64

7.4.4 Ventilation device ............................................... 64

7.4.5 Cushions, mattresses, curtains ....................... 64

7.4.6 Repairs ..................................................................64

8 - List of dealers

8.1 Dealers in Europe .................................................... 65

8.2 Dealers in France .................................................... 73

1 - Welcome

1.1 Welcome aboard!

Dear Sir or Madam,

Thank you for choosing Pilote.

It is very important to read this user manual carefully as well as the instructions provided with all the ﬁttings: refrigerator, water

heater, heater, oven, etc.

Proper use of your motorhome will aord you a superior level of comfort while preserving the value of your vehicle.

The Pilote network and the Pilote Customer Relations department are at your disposal (see contact details in chapter 8).

Any infringement, translation or copy of all or part of this document is strictly forbidden. Any full or partial copy requires our

prior written permission.

Enjoy your trip with your Pilote motorhome.

1.2 How to use this manual

Always keep the user manual to hand in the motorhome and inform the other users of the safety instructions. This document

contains some important remarks concerning personal safety. You should read them carefully. Below you will ﬁnd the

meanings of the various pictograms used in this document.

Warning, risk of injury

If you ignore this remark, you may place yourself

or other people in danger.

Warranty restriction

Warning, you may restrict or lose the warranty

if you do not heed these recommendations.

Cold weather use

Beware of hazards caused by cold weather.

Protecting the environment

Certain uses or handling may cause damage to the environment.

Further information

These remarks provide further information

or draw your attention to useful details.

Warning, risk of property damage

If you ignore this remark, you may damage the appliance(s) concerned.

1.3 Legal framework

1.3.1 Regulations

The vehicle must be registered according to the regulations. There are no speciﬁc regulations that apply to the use of

a motorhome. Motorhomes are both vehicles and a form of accommodation that are subject to the following codes,

depending on the country:

• the highway code when driving the vehicle

• general local legislation and the highway code when parking on the public highway

• urban land use code when parking on private property.

1.3.2 Warranty

• The warranty, guaranteed by the dealership, lasts 24 months from delivery and key handover. The date is speciﬁcally

mentioned by the dealer in the box reserved for the purpose on the warranty certiﬁcate.

• The warranty only applies to the living area as well as to any transformations made by GP SAS to the chassis base; the chassis

part is covered by the car manufacturer warranty.

• The warranty should, as far as possible, be redeemed by the dealership where the vehicle was purchased, both for the living

area itself and for defective parts that may be changed separately.

• The motorhome shall be made available to the dealer for any exchange or repair. No refund shall be made for the cost of

transport to and from the dealer (both for the motorhome and the people) or other related expenses incurred directly or

indirectly.

• If household appliances are covered by their own manufacturer's warranty (fridge, heating system, etc.) then contact your

nearest brand representative (see list of representatives provided with the appliance) or, where this is not possible, your Pilote

dealer.

•

It is important to ﬁll out the warranty documents for appliances when provided and to return them to the various

manufacturers.

The warranty will not apply in the following cases:

• The buyer has not complied with the instructions for use

• The motorhome has been modiﬁed by a non-approved person or by installing non-original parts

• The damage or the defect is due to failure to observe the Highway Code

• The damage results from improper or negligent use

• Normal wear and tear

• The motorhome was repaired in a workshop not approved by GP SAS or without its prior written agreement

• The motorhome has been transformed or equipped with accessories not ﬁtted by the manufacturer and which are liable to

aect key vehicle characteristics

1.4 Motorhome manners

1.4.1 General principles

Good motorhome owners are discreet and must be careful not to leave any trace of their stay. Motorhome owners must

have good manners, respect others and protect the environment. The use of a motorhome as accommodation implies

respecting the rules with regard to the inhabitants of the places visited.

1.4.2 Parking

In city centres and urban areas, it is advisable to ﬁnd parking in sparsely populated areas and to avoid obstructing the visibility

and conducting of business, so as to ensure the motorhome does not constitute an obstacle to circulation. Likewise, using

motorhomes as accommodation shall take place in such areas:

• without spreading to the area around the vehicle

• without causing inconvenience to residents

• without monopolising the public area

• without allowing pets to run riot, foul or otherwise disturb the neighbours

1.4.3 Waste

Wastewater emptying must take place:

• In appropriate places and never near to housing, rivers, streams or crops.

• the emptying of "black" water (lavatory) into the rain water drainage network is strictly prohibited.

All water drainage valves must be closed whilst travelling. Even fresh water should be emptied discretely, to avoid suspicion.

It is always worth asking the local authorities about how to safely get rid of wastewater. Household garbage must be placed

in plastic bags and disposed of in designated places.

Wastewater must be drained o in appropriate places,

never near housing, rivers, streams or crops.

By observing all of these common-sense rules, everyone may fully enjoy the multitude of pleasures provided by the passion

for motorhomes.

2 - Discover your motorhome

2.1 The base

2.1.1 The chassis

The chassis number is located

on the right front wheel arch.

Your dealer should give you the user manual and the chassis maintenance book published by the car manufacturer when

your motorhome is delivered. We recommend that you take note of the contents and follow the instructions relating to

chassis. The wheel alignment is set by the chassis manufacturer before leaving the factory.

Chassis number

< on Low-Proﬁle

Chassis number

on A-Class >

2.1.2 The wheels

See chapter 3 for the tyre pressure. In case of puncture, use the quick repair kit located in one of

the boots.

2.1.3 The accessories

Motorbike racks and coupling systems must be approved and ﬁtted with the appropriate electrical

circuit.

These accessories reduce the load capacity of the motorhome and aect road handling.

The driver should adapt his driving or even reduce speed in some countries.

The wheel alignment must be imperatively checked at 1,500km (900 miles).

An additional veriﬁcation is also strongly recommended at 20,000km (12,000 miles).

The cost for such inspections shall be borne by the user.

2.2 The living area

2.2.1 Hatches, openings and valves

Your motorhome has several types of openings on the outside:

2.2.2 Boots and storage compartments

Several interior and exterior baggage compartments are installed in your motorhome.

2.2.3 Interior layout

Your motorhome is made up of four equipment zones for your comfort and safety. The layout may dier according to the

models and the options delivered.

• Driving: seats ﬁtted with safety belts

• Meals: table, seats, sink, cooking appliances, refrigerator

• Bathroom: washbasin, shower, WC

• Living room: TV ﬁxture, cupboards

Opening lights

• Cab entrance door(s)

• Entrance door to living area

• Side window(s)

• Skylights (translucent)

• Access doors to storage

compartments

• Compartment door to cassette WC

for draining

Hatches

• Fuel

• Fresh water inlet

Drainage valves

• Draining the fresh water tank

• Draining the water heater

• Wastewater disposal

Ventilation devices

• Foul air grilles and/or ventilation

shafts (for cooking appliances,

refrigerator, heating system...

depending on the model)

• Devices integrated into the rooﬂights

and in the ﬂoor of the vehicle

Wastewater

The wastewater is collected in a

tank under the vehicle. It is drained

by means of a discharge valve

located behind the side skirt or in

the double ﬂ oor.

2.3 Basic ﬂ uid diagrams

Drinking water

Filling up is done using an external

nozzle ﬁ tted with a locked cap,

identiﬁ ed by a pictogram. The tank

is located in one of the bench-seat

chests or in the double ﬂ oor.

Tank

draining

Water heater

purge

Wastewater

draining

Wastewater

tank

WC module

Fresh water

tank

DO NOT PIERCE THE FLOOR OF LOW PROFILE MOTORHOMES.

Tubing for evacuating gas and water are built into the ﬂ oor.

Never make any alterations or modiﬁ cations, except if performed by a recognised installer. .

2.3.1 Water system

Supply diagram

2.3.2 Electrical system

Supply diagram

The power supply is made up of a 230V alternating current part and a

12 V direct current part.

230 V supply

Connecting to the mains supply allows you to:

• recharge the leisure battery

• use power outlets

• run the refrigerator on 230 V

• operate the heating system if your vehicle is ﬁtted with a 230V

heating system

12 V supply

The 12V power supply comes from two batteries:

the engine battery and the cell battery. The engine battery supplies

all electrical equipment in the vehicle section. The leisure battery

supplies the electrical appliances in the living quarters. It is placed in a

compartment. This battery is of the "semi-stationary" type. Under no

circumstances may it be replaced by a vehicle start-up battery. For

any replacement, please contact your dealer. The two batteries are

connected by a charger/coupler unit that maintains the charge via the alternator (motor running) or via the mains (230 V).

The electrical unit charger provides a booster charge to the battery when the motorhome is plugged into the mains. Under

no circumstances will this operation completely recharge a depleted battery.

Never carry out or allow modiﬁcations to installations and electrical appliances,

unless performed by approved ﬁtters. A cable reel must be completely unwound

to prevent the electric power supply cable from overheating.

Incorrect assembly of the electrical and electronic accessories may seriously

damage the motorhome and lead to loss of warranty.

Circuit breaker

Sensors

Fresh water

tank

Wastewater

tank

Control panel

Electrical unit

Solar panel

A solar panel may be plugged into connector 2 of the electrical unit (option). It is important to correctly follow the assembly

instructions supplied by the solar panel manufacturer.

A cable is available between the control panel (above the unit door) and the electrical unit.

Generator set

When using a generator set, please carry out the following

steps in the right order:

• First start the generator set

• Connect the 230 V cable to the motorhome

The circuit elements

Electrical unit

The electrical unit includes a charger, a transformer (complete 12V distribution) and fuses (circuit protection). Depending on

the model, it is located either under the front right or forward-facing bench seat, in the storage compartment or behind a

removable panel on the front left side.

Circuit breaker

The circuit breaker is next to the electrical unit.

Sensors

The sensors measure the fresh water and wastewater tank

levels.

Solar panels often do not provide adequate additional charge when several electric appliances are

used simultaneously at night.

The current consumed should not

exceed 90 % of the nominal value

of the corresponding fuse on

the electric unit.

A generator set connected to

the motorhome’s 230 V system

must be perfectly adjusted (risk

of damage to the internal charger).

Fuses - Electrical unit

Description Function Location Amp Colour

F1 Leisure battery Fuse holder near the leisure battery 50 A Red

F2 Engine battery Fuse holder near electrical unit 50 A Red

F3 12 V refrigerator On the relay/fuse module 20 A Yellow

F4 Leisure battery detection On the relay/fuse module 2 A Blue

RL Footstep relay (according to model) On the relay/fuse module

Heating system Combined heating system/water heater Electrical unit 10 A Red

Light 1 Right side interior lighting Electrical unit 15 A Blue

Light 2 Left side interior lighting / Extractor hood* Electrical unit 15 A Blue

Auxiliary 1 Oven* Electrical unit 10 A Red

Outside light Awning light Electrical unit 5 A Orange

Electric bed Electric bed Electrical unit 20 A Yellow

Footstep Footsteps* Electrical unit 20 A Yellow

Auxiliary 3 No function Electrical unit 15 A Blue

Auxiliary 4 USB plug kitchen/living area * Electrical unit 15 A Blue

Auxiliary 5 No function Electrical unit 15 A Blue

Auxiliary 6 No function Electrical unit 15 A Blue

Television/ Antenna SAT 12 V socket TV Fuse holder near the cell battery 10 A Red

Over-cab bed Over-cab bed* Fuse holder near the leisure battery 25 A White

Pump WC / Pump Electrical unit 7.5 A Brown

Car radio Car radio power* Electrical unit 15 A Blue

Auxiliary 2

Car radio signal* Electrical unit 10 A Red

Fiat F49 fuse box 5 A Yellow

Refrigerator control panel

Automatic resettable polyswitch in the electrical unit.

2.5 A

Electric window command

and electric rear-view mirrors. Fiat fuse box (see manufacturer's manual)

* depending on options and models

The control panel

The control panel commands the electrical functions in the motorhome’s accommodation unit and displays the level of the

batteries and water tanks. It is located above the entrance door to the living area. See the manufacturer’s instructions for

operating the control panel.

Technical reservations

The motorhome’s electrical installation must comply with required standards. Any interference or modiﬁcations made to the

electrical installation may aect safety to persons and to the vehicle and is hence forbidden.

It is formally prohibited to carry out modiﬁcations to the control panel. Only qualiﬁed technicians are allowed to intervene on

the electrical connections, as speciﬁed in the manufacturer's assembly manual.

Service voltage

The rated voltage is 12 V.

2.3.3 Gas

Supply diagram

The gas pressure regulator may be equipped with an automatic inverter, depending on the models.

Connector hose

Pressure

regulator

Flow regulator with

manual reset

Installation

Your motorhome is ﬁtted with a gas cupboard that

can hold two bottles, only one of which is connected

at a time. The gas bottles should be placed in the

external compartment provided for this purpose.

The installation operates only on propane, in all

countries.

The pressure for use is 30 mbar.

For all connections of additional elements on your

installation, consult your dealer (cf. manual delivered

with the motorhome).

• Do not change the type of regulator

• Do not use the apparatus under a dierent service

pressure

•

Change the ﬂexible supply hoses (tubes) before

the limit date indicated with an approved model,

identical to the original.

Only qualiﬁed ﬁtters

are authorised to work

on gas-powered appliances.

Gas system allowing heating while driving

The pressure regulator has a built-in impact detector. In case of an accident, with a strong deceleration, a mechanical protection

system cuts o the gas inlet. It complies with European regulations and allows you to use the gas heater while driving.

Apart from the heating, no other appliances are designed to be used when driving.

2.3.4 Ventilation, heating system

The existence of permanent upper and lower ventilation is essential in order to ensure constant air renewal.

• The lower ventilation is generally provided through a vent at the bottom of the furniture and in the ﬂoor.

• The upper ventilation is provided through the roof windows, which are permanently aired.

These devices enable natural air circulation, including inside the bench seats.

The ventilation devices should never be blocked, even during the winter.

They must be kept clean and dustfree.

The “Twiny” gas cylinder may not function properly in cold weather

when gas consumption is at a peak (heating system).

Use a 13kg bottle preferably, with the "Twiny" in reserve.

2.4 Safety

Never leave children unattended in your motorhome. This safety precaution is fundamental in a motorhome due to the

presence of medium and low voltage electrical appliances and gas-powered equipment.

Using the electric window command can be dangerous. Ensure that there is no risk of the passengers' limbs getting caught

in the electric window.

2.4.1 Fire

Provide an approved dry powder ﬁre extinguisher with a capacity of at least 1 kg and familiarise yourself with the instructions.

Keep a ﬁre blanket near the kitchen area. Consult the local ﬁre safety measures.

Do not store aerosol cans in the motorhome; there is a risk that they could explode at temperatures above 50°C, which can

often occur in the summer. Never use cooking or heating devices other than those installed in the motorhome. If you must

plug in a cooking appliance or electric heater, it must work on the principle of direct radiation to avoid ﬁre and asphyxia hazards.

Refer to “Emergency exits”, page 21, for a diagram of the emergency exit(s) in your motorhome.

2.4.2 Gas

Gas leak

If you notice the smell of gas, do not turn on lights, hand torches, lighters, matches, or any electrical item (e.g. switch), until

the smell disappears.

You should immediately:

1. Shut o the gas cylinders

2. Ventilate by opening all openings.

Keep away from the electric windows when they are operating.

2.4.3 Electrical system

Any modiﬁcation or repairs to the electrical circuit carried out in a non-compliant manner or without taking account of

the technical speciﬁcations of the circuit may cause malfunctioning or a ﬁre hazard. The liquid contained inside the leisure

battery, just like that in the main battery is toxic and corrosive. Avoid all contact with the skin or eyes. Keep the battery away

from ﬂames, any source of sparks or aerosol cans : risk of ﬁre or explosion

The battery is a dangerous piece of equipment and incorrect handling may provoke intense electric shocks. Keep the battery

away from ﬂames or a lighted cigarette. Do not generate any sparks : risk of ﬁre or explosion

2.4.4 Emergency exits

The diagrams below show the emergency exits in your motorhome, in accordance with the applicable regulations.

Always wear suitable eye protection when working on the battery or nearby.

Page is loading ...

Pilote G650C 2018 User manual

Brand: Pilote

Model: G650C 2018

Type: User manual

Download PDF

report

Pilote G650C 2018 User manual

Pilote G650C 2018 User manual

Other documents