Southbend EZ-3 Simple Steam - 3 Pan Countertop Steamer Datasheet

Brand: Southbend

Model: EZ-3 Simple Steam - 3 Pan Countertop Steamer

Category: Cookers

Type: Datasheet

This manual is also suitable for

EZ-5

Southbend EZ-3 Simple Steam - 3 Pan Countertop Steamer is a 3-pan countertop steamer designed for commercial use. It is made of stainless steel and has a boilerless design, which means it requires no routine maintenance. The steamer has a low water and energy usage, and it produces steam on demand required by the product being cooked. It also has a simple ON/OFF control and is front serviceable. The steamer comes with a one-year parts and labor warranty. The EZ-3 steamer is perfect for steaming vegetables, fish, and other foods. It can also be used to reheat food or to keep food warm.

Job Item#

www.yatesgd.com www.yatesgraphicdesign.com

Countertop Steamer

Simple Steam - 3 and 5 pan

Standard Features

- ENERGYSTAR

qualied

-StainlessSteelConstruction

- Availablein3and5Pan

- BoilerlessDesign-Requiresnoroutinemaintenance

- NoWaterConnection

- EquippedwithDrainpan-NOdrainrequired

- LowWaterandEnergyUsage

- SimpleON/OFFControls

- FrontServiceable

- Noroutinedeliming

- Fieldreversibledoor

- Zerosideclearance

- Producessteamondemandrequiredbyproductbeingcooked

- OneyearPartsandLaborWarranty

PrintedinUSA

FormEZRev1(November/2009)

EZ-3 (3 Pan); EZ-5 (5 Pan)

WATER QUALITY STATEMENT

Waterqualityisthemajorfactoraffectingtheperformanceofyourappliance.Ifyouareunsureofwaterquality,consultalocal

watertreatmentspecialistandhavethewateranalyzed.Yourwatersupplymustbewithinthesegeneralguidelines:

 Totaldissolvedsolids-lessthan60PPM

 Totalalkalinity-lessthan20PPM

 Silica-lessthan13PPM

 Chlorine-lessthan1.5PPM

 pHFactor-7.0-8.5

Waterwhichfailstomeetthesestandardsshouldbetreatedbyinstallationofwaterconditioner.

FAILURE OR MALFUNCTION OF THIS APPLIANCE DUE TO POOR WATER QUALITY IS NOT COVERED UNDER WARRANTY

STANDARD CONSTRUCTION SPECIFICATIONS

Exterior Finish:  304 stainless steel nish with #4 sanitary

nish.

Interior Finish: 304Stainlesssteel.FullyInsulatedcooking

compartment

Power Source:  Electric.  One power source for controls

andelementsaswellasonegroundwire.Apositiveground

connectionisessential.

Controls: 

ON/OFF Lever:Inthe“OFF”positionthepowerisoffandthe

drainvalveisopen.Inthe“ON”position,thepowerisonad

thedrainvalveisclosed.

60-Minute Timer:Timecanbesetbetween1and60minutes.

Whenthetimeexpires,buzzersounds.Buzzercanbedisabled

byturningknobtomanualposition.Timerhasnoeffectonthe

operationofthesteamer.

Automatic Operation:Steamisonlygeneratedwhenrequired

byfoodbeingcooked.Withnofoodinthecavity,theunitidles

atoperatingtemperature.

“CHECK WATER LEVEL” Light:Indicatesthatthecavitydoes

nothavesufcientwater.Watercanbeaddedthroughthetrough

overthedoorwithoutopeningthedoor,ifdesired.

Legs:4”stainlesssteeladjustablelegs

EZ-5

EZ-3

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

(919) 762-1000 www.southbendnc.com

Models:

www.yatesgd.com www.yatesgraphicdesign.com

INTENDED FOR COMMERCIAL USE ONLY.

NOT FOR HOUSEHOLD USE.

MISCELLANEOUS

UTILITY INFORMATION

FormEZRev1(November/2009)

OPTIONS AND ACCESSORIES

-Checklocalcodesforreandsanitaryregulations.

NOTICE:

Southbendhasapolicyofcontinuousproductresearch

andimprovement.Wereservetherighttochange

specicationsandproductdesignwithoutnotice.Such

revisionsdonotentitlethebuyertocorresponding

changes,improvements,additionsorreplacementsfor

previouslypurchasedequipment.

 EZ-3  EZ-5

FRONT VIEW

SIDE VIEW

TOP VIEW

= Electrical Connection Terminal Block

4" Adjustable Legs

16-1/2" (419)

30-1/2" (775)

Height

(see

table

below)

2" (51)

2-1/2" (63)

* Add 4” to height if 4” adjustable legs are used

** “Pan Capacity” is the number of 1”, 2.5”, or 4” high standard pans (12” wide x 20” deep) that the steamer will hold

IMPORTANT: UNIT MUST BE LEVEL FOR PROPER OPERATION. WARRANTY WILL BE VOIDED FOR IMPROPER INSTALLATION.

Dimensions:in(mm)

Electric:EZ-3-TotalkW:8;EZ-5-TotalkW:11

-Onefuseelectricalconnectionisrequiredtotheterminalblockofthesteamer.

Allunitsareshippedpercustomerorder,threeorsinglephase.(Akitisavailable

foreldconversiontothreephaseorsinglephase.)Thefusedconnectionmust

bewiredfortherequiredvoltageandmaximumamperageaslistedintheabove

chart.

 SS-6Stand

 SS-36Stand

 SS-44Stand

 Panguidesforstands

 Tablemountstand

 208Vor240V

 220V50/60Hz,3-phase

 480V60Hz,3-phase

Model HeigHt*

interior diMensions Pan CaPaCity** Crate diMensions

Crate

VoluMe

Crated

WeigHt

WidtH dePtH HeigHt 1” 2.5” 4” WidtH dePtH HeigHt

EZ-3

21”

(533)

13.5”

(343)

22”

(559)

9.5”

(241)

6 3 2

19.5”

(495)

31.5”

(800)

28.5”

(724)

10.1cu.ft.

0.29cu.m.

150lbs.

68kg.

EZ-5

27.125”

(689)

13.5”

(1067)

22”

(559)

15.5”

(394)

9 5 3

20”

(508)

34”

(864)

38”

(965)

15.1cu.ft.

0.43cu.m.

175lbs.

79.4kg.

total ConneCted aMPs

Max. aMPs Per line

eZ-3 eZ-5

1-PHase 3-PHase 1-PHase 3-PHase

208V60Hz 40 24 57 33

220V50-60HZ 38 23 54 31

240V60Hz 35 21 49 29

380/220V50Hz 23 14 31 19

415/240V50Hz 21 13 29 17

480V60Hz 18 13 25 15

Southbend EZ-3 Simple Steam - 3 Pan Countertop Steamer Datasheet

Brand: Southbend

Model: EZ-3 Simple Steam - 3 Pan Countertop Steamer

Category: Cookers

Type: Datasheet

This manual is also suitable for

EZ-5

Download PDF

report

Southbend EZ-3 Simple Steam - 3 Pan Countertop Steamer Datasheet

This manual is also suitable for

Southbend EZ-3 Simple Steam - 3 Pan Countertop Steamer Datasheet

Related papers

Other documents