Parkinson Cowan SIG454WN User manual

SIG 454

Operating

and

Installation Instructions

Introduction

This gas appliance has been designed and manufactured to all the

necessary British Standards. It also carries the C.E. mark. The

appliance complies with European Council Directive 90/396/EEC.

It is important that you understand how to use and care for the

appliance properly before you use it for the first time.

We have written this booklet with your safety in mind. Read the booklet

thoroughly before you use the appliance. Keep the booklet in a safe

place so that anyone who uses the appliance can read it. Pass the

booklet on with the appliance if you give or sell it to someone else.

We have included several drawings to show the right and wrong way

of doing things.

The right way will have a smiling face by it.

A sad face shows something is wrong.

RATING PLATE

This is situated on the lower front frame of the appliance and can be

seen upon opening the top oven cavity door. Alternatively the rating

plate may also be found on the back or top of some models (Where

applicable).

Do not remove the rating plate from the appliance as

this may invalidate the guarantee.

2

S I G 4 5 4

Introduction

For your safety

The appliance is designed for domestic use to cook food. You

must not use it for any other purpose. It is not designed for

commercial use.

Keep children, babies and toddlers away from the appliance at all

times.

The installation instructions tell you how and where it can be

fitted. If the appliance is already installed you must make sure

that all instructions have been followed. If you are in any doubt

ask a registered person. More details on installation on page 35.

Contents

Lighting the appliance 4

The grill 7

The hotplate 10

The ovens 13

Oven cooking chart - main oven 16

- second oven 19

The electronic timer 22

Slow cooking 26

Care and cleaning 28

Installing the appliance 35

General information 37

What is wrong and why? 39

Servicing 41

Installation Instructions 43

Technical Data 44

Safety requirements/ventilation 45

Location of appliance 46

Installation 47

Testing 49

S I G 4 5 4

3

Contents

Page

Lighting the appliance

The ignition system works by means of an electric spark system. Details

about the plug are given on page 37.

Hotplate

To light

1 Lift up the lid. You cannot use the hotplate when the lid is down.

2 Push in the control knob and turn it to the large flame symbol

(highest setting), and press the ignition button immediately. When

the burner has lit release the button.

Warning: If the ignition button is not pressed immediately a build up of

gas may cause the flame to spread.

Please note: If you have any trouble lighting a hotplate burner turn all

the hotplate control knobs off. Make sure that the burner parts have

been replaced correctly. See page 29 for more information.

S I G 4 5 4

4

For your safety

If you close the lid of the appliance while any of the hotplate

burners are lit the gas will go out. This is because it would be

dangerous if the burners stayed on when the lid was closed.

Always use the control knob to turn off a burner. Do not use

the lid as a cut-off device. This will only cut off the gas when

the lid is closed. The gas will flow again when the lid is

opened.

Lighting the appliance

Grill/second oven

The grill and the second oven are operated by the same control so you

cannot use them both at the same time.

Grill

To light:

1 Open the door.

2 Push in the control knob and turn it to the right to the large flame

symbol (highest setting), and press the ignition button immediately.

When the burner has lit release the button.

3 Leave the grill door open when you are using the grill.

Warning: If the ignition button is not pressed immediately a build up of

gas may cause the flame to spread from the grill cavity.

Second oven

To light:

1 Open the oven door.

2 Push in the control knob and turn it to the left to gas mark 1, and

press the ignition button immediately. When the burner has lit

release the button. There will only be small flames at first.

3 Now turn the control knob to the

gas mark you want.

4 Wait until the burner is showing

large flames.

5 Close the oven door.

Important: Remember to remove the grill pan handle before you use

the second oven.

S I G 4 5 4

5

For your safety

Never cover the grill pan or grid with foil as this can lead to grill

fires.

Lighting the appliance

Main oven

To light:

1 Set the time of day on the clock. See page 22

2 Open the oven door.

3 Push in the control knob and turn it to gas mark 9. After a few

seconds the oven will light automatically and the oven light will

illuminate. There will only be small flames at first.

4 Now turn the control knob to the

gas mark you want.

5 Wait until the burner is showing

large flames.

6 Close the oven door.

If there is an electrical power failure (such as a power cut) you cannot

use the main oven. You can use the second oven.

To turn off any burner

1 Push in the control knob and turn it to the off position. This is shown

by a large dot.

Oven light

The main oven light will come on when the oven burner is alight. If you

need to replace the oven light bulb, follow the instructions given on page

38.

S I G 4 5 4

6

For your safety

When you are lighting any burner check that it has lit before you

leave the appliance.

When you are turning off a burner, do not leave the appliance

until the flame has gone out.

Lighting the appliance

The grill

The grill is a high-speed grill. The instructions below tell you how to vary

the heat setting and how to change the height of the grid to suit the food

you are cooking. You should remember to turn the food regularly.

You should not use the grill to keep food warm as it will continue to

cook the food.

Prior to using the grill

We suggest that you operate the grill for approximately 5 - 10 mins to

burn off any residue from the surface. During this period a slight odour

may be emitted, it is therefore advisable to open a window for

ventilation.

When you first operate the grill you may hear some sounds as the

burner heats up, this is quite normal and is not a fault on the appliance.

Heat control

The grill control has two heat

settings.

The control knob turns to the

right from 'OFF' to 'LOW' and then

to 'HIGH'. Use the high setting for

fast cooking such as toast. Use the

low setting to cook thicker food such

as chicken after you have browned

it on the high setting.

S I G 4 5 4

7

The grill

/

For your safety

The grill pan and handle must be in place before igniting the grill.

You must keep the grill door open when the grill burner is lit.

Accessible parts may be hot when the grill is used. Young

children should be kept away.

Never cover the grill pan or grid with foil as this can lead to grill

fires.

Cooking positions

There is only one position for the grill

shelf (Position 2). Positions are counted

from the top downwards.

Most food should be cooked on the grid

in the grill pan. You can turn the grid over to

suit different thicknesses of food.

You can place some dishes straight on to

the grill shelf. This is useful when you are

browning the top of food such as cauliflower

cheese.

General

The shelf in the grill/second oven is different from the shelves in the

main oven. It is important that you do not swap them over. Only use the

shelf with the solid metal plate underneath it in the grill/second oven.

When you are not using the grill you should remove the handle and

store the pan on the shelf in the grill. Turn the grill burner off before you

store the pan. Remember that the pan will get hot when you are using

the main oven.

You can use the grill compartment to warm plates when you are

using the main oven.

Preheating

You don't usually need to preheat the grill. You may wish to preheat it for

a couple of minutes when you are cooking steak or browning food.

Putting food on the grid

Place food such as toast, tea-cakes and

muffins towards the centre of the grid.

Place food which needs a gentle heat,

such as tomatoes and mushrooms towards

the edge of the grid.

Arrange meat, meat products and fish to

suit their thickness and how you like them

cooked.

S I G 4 5 4

8

The grill

The grill pan and handle

The grill pan is supplied with a removable handle.

To attach the handle, place the wirework under the cut out in the pan so

that the metal plate hooks over the top of the grill pan.

Slide the handle to the left and over the central bump on the grill pan.

Ensure the handle is correctly located. It is not necessary to

remove the grill pan handle during grilling.

Place the grill pan on the shelf so that the pan is positioned centrally

beneath the grill.

To remove the handle, slide the handle to the right and lift the handle

away from the cut out on the grill pan.

Note

If you require an additional handle for your grill pan, this can be ordered

from your local Service Force Centre by quoting part number

311479800\6.

S I G 4 5 4

9

The grill

The hotplate

You can only use the hotplate when the lid is open. If you have any

trouble lighting a hotplate burner, turn all hotplate control knobs off and

make sure that the burner parts have been replaced correctly. Now light

the burner in the usual way. See page 29 for more detailed information.

Heat control

The hotplate control knobs turn

anticlockwise from 'OFF' to 'HIGH'

and then to 'LOW'. You can adjust

the heat by turning the control

between the highest and lowest

settings. These are shown as a

large and a small flame symbol.

Burner sizes

The hotplate has three burner sizes

to suit different types of cooking:

Largest burner (Rapid) - use a large

pan for food such as chips.

Medium burners (Normal) - use for

everyday cooking.

Small burner (Simmer) - use for

simmering food such as soups and

stews.

The largest pan which you should use on any burner is 230mm (9").

The base of the smallest pan should not measure less than 100mm (4").

S I G 4 5 4

10

The hotplate

S I G 4 5 4

11

The hotplate

For your safety

1 Take care to avoid burns and scalds when you are

reaching across the hotplate.

2 Use pans with flat bases. They are more stable than

pans which are warped.

3 Do not use pans with very heavy handles which cause

the pan to tip.

4 Put pans on the centre of the burners.

5 Position pan handles so they cannot be accidentally

knocked.

6 Take extra care when you are deep fat frying. Do not

cover the pan with a lid.

Do not leave a pan unattended. If the pan catches fire,

leave it where it is and turn off all controls.

Place a damp cloth or a fitting lid over the pan to

smother the flames.

Never put water on the fire.

Leave the pan to cool for 30 minutes.

7 If you are using a Wok we recommend it has a flat base

as it will stand stable on the pan supports. If you use a

round based Wok with a collar support, the collar must

be of the open wire work type. A closed collar will affect

the performance of the burner. Before you use the Wok

make sure that the collar is stable on the pan supports.

Always follow the instructions that come with the Wok.

8 Do not use the lid as a work surface or chopping board.

this could damage the glass and reduce its strength.

Helpful hints

1 Keep flames under the base of the pans. If the

flames lick round the sides of the pans you are

wasting gas.

2 Only heat the amount of liquid you need. Do

not overfill pans.

3 Cover pans with a lid whenever possible. The

food will heat up more quickly and there will be

less steam in the kitchen.

4 Try cooking more than one vegetable in the

same pan, for example potatoes and carrots.

5 Cut vegetables into smaller pieces. This way

they will cook more quickly.

6 A pressure cooker will save time and energy.

S I G 4 5 4

12

The hotplate

The ovens

Before you use the ovens you should wipe them out with a damp cloth.

This will remove any dust.

Heat zones

Main oven - There are zones of heat within

the oven. The temperature in the middle is

the gas mark you have chosen. The top of

the oven is slightly hotter and the lower shelf

slightly cooler. The base of the oven is quite

a lot cooler. You can make use of these heat

zones when you are cooking foods that need

different temperatures all at the same time.

If you are cooking more than one tray of similar items, for example

cakes or biscuits, swap the trays around during cooking. Or you can

remove the top tray when the food is cooked and move the lower tray to

the higher shelf to finish cooking.

Second oven - You should turn food round during the cooking time.

Preheating

You do not need to preheat the main or second oven for casseroling

and so on.

Preheat the ovens for baking or when you are cooking sensitive food

such as Yorkshire puddings, soufflés and yeast mixtures.

When you are cooking or reheating frozen or chilled food read the

instructions on the packaging. When you are using the second oven to

reheat food you should preheat the oven to gas mark 8.

When you need to preheat the oven, we recommend you do so for

20 minutes.

Oven shelves

You can slot the oven shelves into any of five

positions in the main oven and any of the two

positions in the second oven. Positions are

counted from the top downwards.

The shelf in the grill/second oven is

different from the shelves in the main oven.

Only use the shelf with the solid metal plate

underneath it in the grill/second oven. The

plate may glow red when you are using the

oven. This will not affect the cooking

performance.

S I G 4 5 4

13

The ovens

Most second oven cooking should be carried

out using the shelf provided in shelf position

2. However, when cooking a small joint or a

deep cake you can use the shelf on the base

of the second oven to allow enough air to

circulate around the food.

For safety the shelf will only pull out so far. If you want to remove a

shelf completely, pull it forward as far as it will go, raise the front edge

and lift it out. To put the shelf into a different position, keep the front

edge raised, slot the shelf on to the runner, lower the front edge and

slide the shelf in.

Baking trays and dishes

Leave a gap of 13mm (½") between all dishes

and the sides of the oven so the heat can

circulate properly.

Do not push dishes too far back as food will

burn if it overhangs the burner flames.

For the best results from the main oven we recommend that you use a

baking tray which is 310mm (12") square. If you use a tray or tin which is

larger than this, you may need to turn it around during cooking.

The size of tray which you should use in the second oven should not

measure any bigger than 310mm x 230mm (12" x 9" ). Place the longest

side parallel with the door.

Place single dishes on the centre of the shelf. You may need to turn

large items around during cooking. Turn all food round in the second

oven.

S I G 4 5 4

14

Leave a gap of 13mm (½") between all

dishes and the sides of the oven so

the heat can circulate properly.

Do not push dishes too far back as

food will burn if it overhangs the

burner flames.

The ovens

For your safety

Never place cooking dishes, trays and

so on over the oven burners. This will

damage the appliance as well as the

cookware and possibly the floor

covering underneath the appliance.

Shelf on base

Roasting

For best results we recommend open roasting using minimal fat or oil to

prevent splashing.

It is not necessary to cover meat or poultry or wrap food in foil when

roasting as this restricts the circulation of heat and will lead to extended

cooktimes.

If you use a roasting bag or cover chicken breast with foil, be prepared

to allow an extra 10 - 15 minutes for each 1/2kg (1lb).

When cooking large items such as turkeys, the use of foil may be

required to prevent the breast becoming dry before the rest of the bird is

fully cooked.

Condensation

Condensation may form on the appliance. This is quite normal and

nothing to worry about. The condensation forms when heat and

moisture are present, for example during cooking. Whenever possible

try to make sure that food which contains a lot of moisture, for example

casseroles, are covered. If you do notice any condensation, wipe it up

straight away.

S I G 4 5 4

15

The ovens

Oven cooking chart - Main oven

These instructions are for cooking in the oven after it has been pre-heated for 20 minutes.

If you are cooking more than one tray of similar items, for example cakes or biscuits, swap the trays around during cooking. Or you

can take the top tray out of the oven when the food is cooked and move the lower tray to the higher shelf to finish cooking.

Always leave at least one shelf position between shelves to allow heat to circulate.

The recommended shelf positions give the best results.

Put the dishes in the centre of the shelf.

You can change the gas marks and cooking times to suit your own tastes.

It is important to check that food is piping hot before serving.

If you are using both ovens at the same time you may need to adjust the cooking times.

Food

Gas

mark

Shelf

position

Approximate

cooking time

Roasting meat: Beef 5 4 Rare:

Medium:

Well Done:

20 mins. per ½kg (1lb) and 30 mins.

25 mins. per ½kg (1lb) and 25 mins.

30 mins. per ½kg (1lb) and 30 mins.

Lamb 5 4 Medium:

Well Done:

25 mins. per ½kg (1lb) and 25 mins.

30 mins. per ½kg (1lb) and 30 mins.

Pork and Veal 5 4 Medium:

Well Done:

30 mins. per ½kg (1lb) and 30 mins.

35 mins. per ½kg (1lb) and 35 mins.

Thaw frozen joints thoroughly before cooking them.

S I G 4 5 4

Oven cooking chart

16

Food

Gas

mark

Shelf

position

Approximate

cooking time

Poultry: Chicken

Turkey below 4.5kg (10lbs)

over 4.5kg (10lbs)

Duck and duckling

5

4

5

4

4 or 5

4

20 mins. per ½kg (1lb) and 20 mins.

25 mins. per ½kg (1lb) and 25 mins.

15 mins. per ½kg (1lb) and 15 mins.

25 mins. per ½kg (1lb)

Stuffed poultry Cook as above but calculate weight including stuffing.

Thoroughly thaw frozen joints before cooking them.

The times given above are for open roasting in a preheated oven. If you cover the food with foil or a lid allow an extra 10 - 15

minutes for each ½kg (1lb).

Yorkshire pudding - large

- individual

7

2

25-30 mins.

15-25 mins.

Cakes: Christmas cake (8")

Rich fruit, 180mm (7")

205mm (8")

Madeira, 180mm (7")

Small cakes

Scones

Victoria sandwich

180mm (7")

205mm (8")

2

4

5

7

4

2 & 4

4-5 hours

2¼-2¾hours

2½-2¾ hours

1 hour

15-25 mins.

10-20 mins.

20-30 mins.

20-35 mins.

S I G 4 5 4

Oven cooking chart

17

Food

Gas

mark

Shelf

position

Approximate

cooking time

Pastries: Plate tart (shortcrust)

Fruit pie (shortcrust)

Mince pies (flan pastry)

6

5

2

2 & 4

25 -35 mins.

25-35 mins.

15-25 mins.

To help pastry brown on the underside

cook on a metal plate, or if plates are flat

and have no rim underneath, place on

baking tray.

Puddings: Milk pudding

Baked sponge pudding

Baked custard

2

4

3

4

2 hrs.

45-60 mins.

50-60 mins.

Yeast mixtures: Bread 0.45kg (1lb loaves)

0.90kg (2lb loaves)

Rolls and buns

8*

3

2

30-40 mins.

10-20 mins.

*Note: When baking bread cook for 10 minutes at Gas mark 8 then reduce to mark 6 for the remaining cook time.

Note: You must soak dried beans then boil them in an open pan for 15 minutes before you add them to any dish.

S I G 4 5 4

Oven cooking chart

18

Oven cooking chart - Second oven

These instructions are for cooking in the oven after it has been pre-heated for 20 minutes.

The recommended shelf positions give the best results.

Put the dishes centrally on the shelf and turn food around during the cooking time.

You can change the gas marks and cooking times to suit your own tastes.

It is important to check that food is piping hot before serving.

If you are using both ovens at the same time you may need to adjust the cooking times.

Food

Gas

mark

Shelf

position

Approximate

cooking time

Roasting meat: Beef 5 Shelf on

base

Rare:

Medium:

Well Done:

20 mins. per ½kg (1lb) and 30 mins.

25 mins. per ½kg (1lb) and 25 mins.

30 mins. per ½kg (1lb) and 30 mins.

Lamb 5 Shelf on

base

Medium:

Well Done:

25 mins. per ½kg (1lb) and 25 mins.

30 mins. per ½kg (1lb) and 30 mins.

Pork and Veal 5 Shelf on

base

Medium:

Well Done:

30 mins. per ½kg (1lb) and 30 mins.

35 mins. per ½kg (1lb) and 35 mins.

Thaw frozen joints thoroughly before cooking them.

S I G 4 5 4

Oven cooking chart

19

Food

Gas

mark

Shelf

position

Approximate

cooking time

Poultry: Chicken

Duck and duckling

5

Shelf on

base

20 mins. per ½kg (1lb) and 20 mins.

25 mins. per ½kg (1lb)

Stuffed poultry Cook as above but calculate weight including stuffing.

Thaw frozen joints thoroughly before cooking them.

The times given above are for open roasting in a preheated oven. If you cover the food with foil or a lid allow an extra 10 - 15

minutes for each ½kg (1lb).

Yorkshire pudding - individual 7 2 20-30 mins.

Cakes: Christmas cake (8")

Rich fruit, 180mm (7")

Madeira, 180mm (7")

Small cakes

Scones

Victoria sandwich

180mm (7")

2

4

5

7

4

Shelf

on

base

2

3½-4½ hours

2-2½ hours

1 hour

15-25 mins.

8-12 mins.

20-30 mins.

Pastries: Plate tart (shortcrust)

Fruit pie (shortcrust)

Mince pies (flan pastry)

6

5

2

25-35 mins.

30-40 mins.

15-25 mins.

To help pastry brown on the underside

cook on a metal plate, or if plates are

flat and have no rim underneath, place

on baking tray.

S I G 4 5 4

Oven cooking chart

20

Page is loading ...

Parkinson Cowan SIG454WN User manual

This manual is also suitable for

Parkinson Cowan SIG454WN User manual

Related papers

Other documents