2. Anova
  3. 1003-L

Anova 1003-L Installation guide

  • Hello! I've reviewed the Specification, Installation and Operation Sheet for the DOGIPOT Pet Station. This document details the components and instructions for setting up the pet waste station, including the sign, bag dispenser, trash receptacle, and mounting post. It also explains how to properly install the post and assemble all the parts. I'm ready to answer any questions you have about this product.
  • What is included in the DOGIPOT Pet Station?
    How is the mounting post installed?
    What is the capacity of the bag dispenser?
    What is the capacity of the trash receptacle?
DOGIPOT® TELESCOPING POST (ITEM 1301-P)
800.364.7681 www.DOGIPOT.com
SPECIFICATION, INSTALLATION AND OPERATION SHEET
DOGIPOT® PET STATION (ITEM #1003-L)
Y0UR ALUMINUM DOGIPOT® PET STATION INCLUDES:
• AluminumDOGIPOT®PetSign,withmountinghardware(two(2)2¼”X¼”tapbolts,washersandlocknuts)
• AluminumDOGIPOT®JUNIORBagDispenser(ITEM#1002-2),withmountinghardware(two(2)2½”X¼”bolts,
 washersandlocknuts)
• Two(2)keysforDispenserlockingfrontaccesspanel
• Two(2)rollsofDOGIPOT®SmartLitterPickUpBags™(ITEM#1402)(200countperroll),installed
 inDOGIPOT®JUNIORBagDispenser
• 10GallonSteelTrashReceptacle(ITEM#1206-L)withattachablelidandtrashlinerbagretainerbands,with 
 mountinghardware(one(1)2½”x¼”and(1)2¾”x¼”bolts,washersandlocknuts)
• One(1)boxDOGIPOT®SmartLinerTrashBags™(ITEM#1404)(50count)
SEPARATE SHIPPING BOX
• 2”x2” x4’-8’GalvanizedSteelTelescopicMountingPost,withinstallationhardware(two(2)carriagebolts
 (2½”x5/16”),washersandlocknuts)
PLEASE CHECK THE ABOVE INVENTORY AND CALL YOUR DISTRIBUTOR IF ANY PARTS ARE MISSING.
INSTALLATION AND OPERATION INSTRUCTIONS
1. Select a good visible spot in your community or park where you want to install the Aluminum DOGIPOT® Pet
Station.
2.Priortoinstallation,removethe1¾”x1¾”x4’portionofthemountingpostfromthe2”x2”x4’portionofthe
mountingpostbeforecementing. Insert the larger portion of the mounting post (2” x 2” x 4’) approximately 14”
into an 18” deep by 8” diameter hole filled with a 40 lb. bag of “ready to use” concrete mix. Tostabilizethepostwhilecementing,placearod,
boltorotherdevicethroughthetwobottomholes,priortoinsertingintothegroundandcementing.Levelthepostinastraightverticalposition
andletconcretedryforatleast12hours.
3.Aftertheconcreteisdry,insertthesmallerportionofthepost(1¾”x1¾”x4’)intothelargercementedportionofthepost(2’x2’x4’)untilthe
therst4holesarelinedupbetweenthetwoposts.Usetwo(2)carriagebolts,washersandlocknutstoxthetelescopicpostinposition.,theupper
boltinthetopoverlappinghole,pointingfromrighttoleftandthelowerboltinthebottomoverlappinghole,pointingfromfronttoback.Thetotal
heightabovegroundwithbothpostpartsshouldnowbeapproximately6”6”.
4.StartbyinstallingtheDOGIPOT®PetSignontopofthe1¾”post,withtheupperholematchingthemostupperholeinthesquarepostusing
theenclosed2¼”bolts,washersandlocknuts.ContinueinstallingtheAluminumDOGIPOT®JUNIORBagDispenseraccordingtothemounting
instructionenclosedwiththeDispenser,ensuringthatheupperedgeoftheDispenserisapproximately1” belowtheloweredgeoftheDOGIPOT®
PetSign.
5.InstalltheSteelDOGIPOT®TrashReceptaclethroughthepre-drilledtopovalholesinthebackwallofthereceptacleandthroughthesquarepost
withtheremainingbolts,washersandlocknuts,usingthe2¾boltontopandthe2½boltbelow.The upper edge of the trash receptacle must be
approximately 12½” below the lower end of your Aluminum DOGIPOT® JUNIOR Bag Dispenser so that the lid may completely open.The
upperbackwallofthetrashreceptacleissupposedtotouchtheheadofthelowerpostcarriagebolt,whichcreatessomespacebetweenthepost
andthereceptacle,allowingthereceptaclelidtoopenfromlefttoright,withouttouchingthepost.
6.InsertoneoftheenclosedDOGIPOT®SmartLinerTrashBags™intothetrashreceptacle,foldingitovertheinteriorretainerbands.Aswithany
powdercoatedsteelproductconstantlyexposedtotheelements,properinstallationandgeneralmaintenancewillhelppreventandminimize
corrosionandexpandthelifeofthesteeltrashreceptacle(canbeupgradedtoaluminium(ITEM#1206A-L)foranadditionalcharge).DOGIPOT®
offersProductMaintenancePainttohelpcoveranypaintchipswhichmayoccurinthepowdercoatingduringthelifeoftheproduct.
7.ENJOY WATCHING PET OWNERS PICK UP AFTER THEIR DOGS!
DOGIPOT® TELESCOPING POST (ITEM 1301-P)
800.364.7681 www.DOGIPOT.com
(A) DOGIPOT® PET SIGN (ITEM #1203 / 1204)
 •H:18”xW:11.5”
 •14gaugereectivealuminum
 •Weight:1.35lbs.
 •Forestgreenonwhite
(B) ALUMINUM DOGIPOT® JUNIOR BAG DISPENSER (ITEM #1002-2)
 •H:15’5”xW:9.4”xD:3.25”
 •12gaugepowdercoatedforestgreenaluminum
 •Weight:7lbs.
 •400bagcapacity
 •Twodiamondshapedbagdispenserslots
 •Frontlockingaccesspanel
 •Clearlypostedinstructions
(C) STEEL TRASH RECEPTACLE WITH LID (ITEM #1206-L)
 •H:23”x11.5”diameter
 •16gaugepowdercoatedforestgreensteel
 •Weight:14.6lbs.
 •10galloncapacitywithinteriortrashlinerbagretainerbands
 •Attachedstainlesssteelhingedlid
 •One(1)box50countDOGIPOT®SmartLinerTrashBags™
 (ITEM#1404)included(5lbs.)
(D) TELESCOPIC GALVANIZED STEEL MOUNTING POST (ITEM #1301-P)
 •2”x2”x8’
 •11gaugegalvanizedsteel
 •Weight:15lbs.
TOTAL HEIGHT FROM ABOVE GROUND:
 •6’.6”
SPACE BETWEEN DISPENSER AND SIGN:
 •1.0”
SPACE BETWEEN RECEPTACLE AND DISPENSER:
 •12.5”
SPACE BETWEEN GROUND AND RECEPTACLE:
 •8.0”
HOLE:
 •D:18.0”xW:8.0”
 •Fillwith40lbs.“readytouse”cement
TOTAL SHIP WEIGHT: 45 LBS.
(MOUNTING HARDWARE INCLUDED)
(B)
(C)
(D)
(A)
SPECIFICATION, INSTALLATION AND OPERATION SHEET
DOGIPOT® PET STATION (ITEM #1003-L)
/